Feet Management Feet Management Murphy Systems ISSPRO Gauges Air-Weigh On-Board Scaes 34-35 Davis DriveRight 36 Davis CarChip 37 Kienze Tachographs 38-40 Eectrica Speciaty Instruments e-mai: e.power@saskte.net 1-800-667-8001 e-power Instruments 33
Feet Management Air-Weigh On-Board Scaes Sef-Weighing Trucks and Traiers Every truck and traier brings its own scae to the oading site. Check-weighing at a truck stop scae made sense before trucks became sef-weighing. Avoid overweight issues that cause: Wasted hours of service Wasted out-of-route mies and fue Overweight fines Waiting in ine to re-work the oad Missed deivery schedues The Air-Weigh scae system converts air pressure in the truck and traier air springs into a very accurate, onthe-ground weight. The more weight on the vehice, the more air pressure required to maintain ride height. Once caibrated, Air-Weigh dispays the weight of the axe group to within 300 bs. (140 kg) of a DOT scae when operated propery. It is much more accurate than an air gauge. The Air-Weigh Tractor and Traier Scae come with an Aarm Output function which is a buit-in feature. The Aarm Output can be connected to any aarm/buzzer or LED device to aert drivers and oaders when a truck is nearing or has reached its weight capacity. The Aarm function is controed via menu-driven software in the Tractor and Traier Scaes, which is controed via a keypad in its cover. The aarm is easiy turned off by pressing the ESC key once. Truck Scae Kit Incudes scae dispay, sensor(s), Truck ComLink sensor processor, cabing and fasteners. Incudes abiity to predict weight transfer to the steer axe from fifth whee. ComLink 1 & 2 kits incude separate channes 1 and 2 for use on trucks with an air suspension steer axe. Specify if for dua eveing vaves on the drive axe suspension. E94720 (AW5800) Truck Scae Kit $1,295.00 Traier Scae Kit Incudes sensor, Traier Scae, cabing, and fasteners. One Traier Scae Kit for each traier suspension to be weighed. Specify if for dua eveing vaves for vehices with eft and right eveing vaves on the same suspension. May aso be specified for traier suspensions with ABS to incude ABS T-Breakout cabe connector for simpe pug-and-pay eectrica instaation. Specify without ABS T-Breakout for junction box connection. New for 2008 E94750 (AW5802) Traier Scae Kit, ABS T-Breakout $799.00 Air-Weigh LoadMaxx Scae LoadMaxx incorporates state-of-the-art hardware and software technoogy. The LoadMaxx Scae offers severa innovative features incuding an interface to J1939 / CAN bus, two programmabe weight aarm outputs, an interface to an incinometer, and enhanced sef-test diagnostics. The J1939 / CAN bus interface aows dash dispays and on-board computers to easiy obtain weight information for wireess transmission to feet headquarters, or for viewing by the driver in the cab. Two aarm outputs can be used to warn the driver when an axe group weight or GVW exceeds ega imits. Parking on an incine can resut in uneven pressure on a vehice s suspension, which affects the accuracy of a scae reading. With the incinometer option for LoadMaxx, the weight dispay, J1939 outputs, and aarm outputs, are turned off when detecting an incine that wi affect weight reading accuracy. The LoadMaxx scae is avaiabe with or without an optiona Air-Weigh dispay device. Drivers see steer axe weight, drive axe weight, gross vehice weight, and payoad weight. The weight information may aso be transferred to an on-board computer for dispay and use by other vehice appications. 34 e-power Instruments 1-800-667-8001 www.e-powerinstruments.com
Feet Management Air-Weigh On-Board Scaes Dedicated Tractor-Traier Scae 5800 Series This innovative on-board scae is designed to hep owner-operators and sma feets with dedicated rigs save money, whie capitaizing on the benefits of on-board weighing. Now a feets, regardess of size, can weigh as they oad, eiminating the costs associated with eaving the oading site overweight. With the Dedicated Tractor-Traier Scae, you get a the features and functions of a compete Air-Weigh Tractor-Traier System except for automatic traier swapping. Easy to Insta Run an air ine from the tractor and traier airbags to the dash. Connect cabes from the sensors to the tractor ComLink. Mount the dispay in-dash and the ComLink behind the dash. Connect to power, and you are ready to caibrate your Air-Weigh Scae. Easy to Caibrate Air-Weigh s simpe on-screen menu makes it easy to setup and caibrate your scae. Caibration is as simpe as seecting the CALIBRATION menu, then entering the empty weights when the vehice is empty and entering the heavy weights when the vehice is oaded. Once the system is caibrated, steer, drive, traier(s), GVW and net payoad weights wi be dispayed on the 2 in-dash dispay. Easy to Operate To weigh most accuratey, the vehice shoud be parked on a eve surface with the engine running and the brakes reeased. The height contro vave shoud be in good repair and set at factory-specified ride-height. The suspension shoud be briefy defated, then aowed to return to ride-height with the brakes reeased. When the numbers stabiize, weight to within 300 pounds of a DOT scae wi be dispayed (many Air-Weigh customers caim accuracy within 100 pounds, with a itte practice). Dedicated Tractor Scae 5800 Series Designed to operate on most tractors with air-ride drive axes using dua or singe eveing vaves, tandems, or tridems, and spring or air-ride steers. Air-Weigh aso works with air-ride traiers using singe or dua eveing vaves, tandems, tridems, or spread axes. E94931 Dedicated Tractor Scae Kit $1,195.00 E94932 Air Line Disconnect Kit $ 119.00 E94933 Tractor Air Line Kit $ 66.00 Dedicated Tractor B-Train Scae 5800 Series Aso avaiabe for mutipe-traier combinations incuding B-trains, super-b s, connector doies and pups. E94934 Dedicated Tractor Scae Kit for B-trains $1,398.00 E94935 Air Line Disconnect Kit for B-trains $ 309.00 E94933 Tractor Air Line Kit $ 66.00 The Industry s Most Affordabe and Accurate Tractor-Traier Scae. The Air-Weigh Dedicated Tractor- Traier Scae is a an affordabe oad management system that is permanenty instaed in the dash and caibrated to each suspension on the vehice. By running the traier suspension air ine to the dash, there s no need for a separate traier scae. With no operator interaction required, the in-dash gauge automaticay shows the steer, drive, and traier weights on one screen. A singe button press dispays GVW and Net Payoad weights. A 12V aarm output is standard and aows connection of an in-dash or exterior ight or buzzer to warn of near-ega weight imit or over-ega weight on any axe or GVW. Feet Management Murphy Systems ISSPRO Gauges Speciaty Instruments Eectrica e-mai: e.power@saskte.net 1-800-667-8001 e-power Instruments 35
Feet Management DriveRight 600E Interactive on-board consoe gives instant feedback to drivers. Like an on-board coach, DriveRight 600E gives instant feedback to drivers, improving their performance with every mie. Set the audibe aarms, and the driver wi know instanty whenever he has exceeded company safety imits for speed, acceeration, and hard braking. After the trip, query the consoe for detais on time, speed, distance, and more. Downoad to the Feet Management Software to compare driver performance and track improvement over time. Easiy mounts on dashboard or sun visor. DriveRight 600E is avaiabe in four different modes. Each incudes an interactive on-board consoe and vehice instaation hardware. Hardware varies to meet the needs of specific vehice types and mode-years. E96241 (8126OBD) DriveRight 600E with OBDII Instaation Kit $395.00 Incudes OBDII connector with 6 (1.8 m) cabe. For cars, vans, and pickup trucks, mode-years 1996 and ater. E96242 (8126VSS) DriveRight 600E with VSS Instaation Kit $375.00 Incudes wires and spice connectors to tap into the vehice s speed sensor. For cars, vans, and pickup trucks, 1992 and ater, and some earier mode-years with cruise contro. E96243 (8126GD) DriveRight 600E with Genera Duty Instaation Kit $375.00 Incudes reed switch sensor, magnet, and nyon mounting strap. For oder-mode cars, vans, and pickup trucks, and for other vehices in which OBDII or VSS instaation is not possibe. E96244 (8126HD) DriveRight 600E with Heavy Duty Instaation Kit Incudes reed switch sensor, magnet, heavy-duty stainess stee mounting strap, and extra-ong cabes. For tractors, big rigs or other arge trucks, or buses. $395.00 Current speed Starting time for trip Maximum speed for trip Distance traveed Ending time for trip Number of times deceeration safety imit was exeeded Current time & date Time & date for trip Current acceeration or deceeration rate Amount of time over speed safety imit Number of times acceeration safety imit was exceeded. Current time & date Time & date for trip Use PLUS and MINUS buttons to: Enter driver ID at beginning of trip Specify trip type: business, persona, commute, or other Press SET to change format for: Speed (mph or km/h) Time (12- or 24-hour) Date (month/day or day/ month) Press MODE to cyce through: Current readings Detais for each trip Driver safety imits Feet Management Software Incudes software on CD, seria-port cabe for downoading from the DriveRight 600E on-board consoe, and USB cabe for downoading from CarChip Feet Pro. For easy, automatic downoading, add the wireess downoad system. Data from DriveRight 600E may aso be downoaded using the optiona USB-to-Seria Cabe shown beow, the Pam or Remote Downoad Kits, or the SmartCard System. Reports for diagnostic troube codes, engine monitoring, and emissions readiness require the use of CarChip Feet Pro. A other reports are avaiabe whether you use CarChip Feet Pro or any of the DriveRight 600E modes. E96350 (8186) Feet Management Software $395.00 E86420 (08434) USB to Seria Cabe $20.00 36 e-power Instruments 1-800-667-8001 www.e-powerinstruments.com
Feet Management CarChip Engine Performance Monitoring Monitor any 4 out of 23 possibe parameters incuding: Battery votage RPM Throtte position Engine oad Cooant temperature Fue pressure Fue system status Timing advance Air fow rate Intake air temperature Intake manifod pressure Short-term fue trim (2 ea) Long-term fue trim (2 ea) O2 sensor output votage GPS Modue CarChip Pro No toos or automotive expertise required! Just pug CarChip into the On-board diagnostics (OBD) port (easiy found under the dashboard or steering whee), and it reads and stores data from your car s on-board computers, continuousy ogging driving and engine performance for up to 300 hours. See how and where your vehices are being driven. Add a GPS system to the DriveRight 600E or CarChip Feet Pro in each vehice, and you can see not just how your vehices are being driven but where. Downoad the data to the Feet Management Software, then use Microsoft MapPoint or other third-party mapping programs to create detaied maps showing each driver s routes, the speeds driven, and the ocations of any accidents or near-accidents. GPS/Wireess Interface Modue Connects the GPS Modue to either your DriveRight 600E on-board consoe or the CarChip Feet Pro data ogger. You need one per vehice. Easiy mounts under dashboard using the incuded Vecro strips or doube-sided foam tape. Avaiabe in two modes. A singe Interface Modue can be used to insta both a GPS system and a wireess downoad system. Both versions of CarChip come with the CarChip data ogger, a software CD to anayzing data, and a USB cabe for downoading the data. CarChip Feet Pro To monitor engine performance, use a CarChip Feet Pro in each vehice. To monitor driver performance, issue each driver his own CarChip with a unique ID number. Drivers can quicky and easiy take their CarChip with them from one vehice to the next. Stores up to 1200 hours of driving data depending on the ogging interva and number of parameters seected. Downoad at any time and cear the memory, or simpy et the newest data overwrite the odest. Requires Feet Management Software, sod separatey. CarChip Feet Pro aows you to use GPS tracking and Wireess data ogging. E96122 (8226) CarChip Pro $119.00 E96123 (8426) CarChip Feet Pro $169.00 Feet Management Murphy Systems ISSPRO Gauges Speciaty Instruments GPS Modue Pugs quicky and easiy into the DriveRight 600E on-board consoe or CarChip data ogger using the appropriate GPS/Wireess Interface Modue. For maximum visibiity to GPS sateites, position the modue on the dashboard or windshied. Incudes 6.5 (2 m) cabe. E96301 (8127) Interface Modue for DriveRight 600E $ 65.00 E96302 (8251) Interface Modue for CarChip Feet Pro $ 65.00 E96303 (8128) GPS Modue $100.00 Eectrica e-mai: e.power@saskte.net 1-800-667-8001 e-power Instruments 37
Feet Management KIENZLE - ARGO - VDO Authorized Saes and Service Tachographs State-of-the art recording technoogy Eectronic 1318 Tachograph Speed Ony... Recorder... Speedometer... Cock... Odometer... Tachometer The 1318 eectronic tachograph is the eading industry standard. During a trip, it continuousy records vehice operating information onto a circuar chart inside the unit. Records information about speed, iding, distance traveed, rpm, pto, or engine brake activation, doors open or cosed, emergency sirens and ights, etc. This information can then be used to protect against iabiity in an accident, save fue costs and deays, etc. Avaiabe in many modes: Speed ony (125 kph, 160 kph), Speed and rpm (2500 rpm, 3300 rpm), or combine with a specia event styus to indicate other activity such as emergency sirens and ights. A kits incude everything necessary to insta on most conventiona highway vehices. Large easy-to-read. 5 1/2 mounting diameter. Each kit incudes a seria data ink, power harness, mounting camps, under dash bracket, fuses, and a box of 100 charts. Speed and rpm E07781-Kit Tachograph Kit - Speed Ony 125 kph $995.00 E07782-Kit Tachograph Kit - Speed and 2500 rpm $1,295.00 Mechanized Vibration Recorder The STB Mechanized Vibration Recorder does not require any power or eectric signa. Once the cock is wound and the chart inserted, the recorder reacts and detects the smaest of horizonta or vertica movement. A significant movement is recorded on a time-reevant chart. An exceent instrument for custom operators to show exact time equipment was used. It can be used on any on-off road construction, mining or farming equipment. Stationary machines, pumps or compressors are a further fied of use. The unit s recording system is so sensitive, it wi pick up high votage cabe and pyon vibration to contro the efficiency of anti-vibration devices. Made of rugged aoy meta. E84250 STB Mechanized Vibration Recorder $649.95 E84270 24 Hour Charts 100/box $ 19.95 38 e-power Instruments 1-800-667-8001 www.e-powerinstruments.com
Feet Management Tachograph Accessories Tachograph Charts Order No. Description Speed RPM Hours Price E07840 125-24 125 kph 24 $16.00 E07850 125-24 Mini 125 kph 24 $20.00 E07860 160-24 160 kph 24 $20.00 E07910 125-2500-24 CDN 125 kph 2500 24 $20.00 E07920 125-3300-24 CDN 125 kph 3300 24 $20.00 E07940 125-7 x 24 125 kph 24 x 7 $30.00 E07950 125-7 x 24 Mini 125 kph 24 x 7 $30.00 E07960 125-3300 - 7 x 24E 125 kph 3300 24 x 7 $36.00 Adapters & Converters E18620 E18580 E18590 E18540 E18560 Power Harness Seria Data Link Adapter Transates data from the seria data bus on eectronic engines to the puses required by tachographs, on-board computers, and simiar equipment. Speed Puse Adapter Used to convert speed signas from a magnetic sensor into the speed puses required by 1318 tachographs. RPM Puse Adapter Used to convert rpm signas from a magnetic sensor into the rpm puses required by 1318 tachographs. Frequency Converter Used to convert either speed or rpm puses from a magnetic sensor to the puses required by 1310 tachographs. Frequency Converter A universa frequency converter is used to convert either speed signas or rpm puses from a magnetic sensor to the puses required by eectronic speedometers, on-board computers, and simiar equipment. $169.00 E16150 Power Harness for Mode 1308 tachograph 5 $19.95 E16160 Power Harness for Mode 1310/1315 tachograph 5 $19.95 E16180 Power Harness for Mode 1318 tachograph 5 $19.95 Universa Tachograph Key E34920 Universa Tachograph Key $6.95 Tachograph Lamps E50410 12V Tachograph Lamp Back Pastic Base 5/Pkg. $9.95 E50420 24V Tachograph Lamp Grey Pastic Base 5/Pkg. $9.95 E50430 12V Tachograph Lamp Meta Base 5/Pkg. $9.95 E50440 24V Tachograph Lamp Meta Base 5/Pkg. $9.95 KIENZLE - ARGO - VDO Authorized Saes and Service E18540 / E18560 Frequency Converter E18590 E18620 Seria Data Link Adapter E18580 Speed Puse Adapter Feet Management Murphy Systems ISSPRO Gauges Speciaty Instruments E16150 E16160 Eectrica E50410 E50420 E50430 E50440 E34920 Universa Tachograph Key E16180 e-mai: e.power@saskte.net 1-800-667-8001 e-power Instruments 39
Feet Management KIENZLE - ARGO - VDO Authorized Saes and Service E34850 Tachograph Accessories 5½ Mounting Brackets E34850 Universa Right-Ange Under Dash Bracket $29.95 E34650 1310 Mounting Camp Kit $16.00 E34660 1318 Mounting Camp Kit $16.00 E34650/E34660 Sending Units E08120 E08140 2155 Speed/rpm Sending Unit Mechanica to eectronic transducer for either speed or rpm. Has three terminas. For use with the Mode 1310 tachograph. 2159 Speed/rpm Sending Unit Mechanica to eectronic transducer for either speed or rpm. Has four terminas. For use with the Mode 1318 tachograph E08140 2159 Sending Unit Drive Tangs for 2155/2159 Sending Units E08120 2155 Sending Unit E09010 Tang to.104 sq. $6.95 E09020 Tang to.152 sq. $6.95 E09030 Tang to.187 sq. $6.95 E09040 Tang to.152 pin $6.95 E09050 Tang to.187 pin $6.95 E09060 Tang to.203 pin $14.95 E09070.104 sq. to.203 pin $6.95 Sending Unit Harnesses E16220 2155 Speed Harness 16 $65.00 E16260 2155 rpm Harness 16 $65.00 E16230 2159 Speed Harness 16 $75.00 E16270 2159 rpm Harness 16 $75.00 E16220 2155 Speed Harness E16260 2155 rpm Harness E16230 2159 Speed Harness E16270 2159 rpm Harness 40 e-power Instruments 1-800-667-8001 www.e-powerinstruments.com