3 Port Solenoid Valve Rubber Seal, Ported Series 00 For details about certified products conforming to international standards, visit us at www.smcworld.com. ported 2 2 3 4 5 6 9 Type of actuation Normally closed Normally open Regarding 20, R port is a supply port. Type of actuation Rated voltage 00 V, 50/60 Hz 200 V, 50/60 Hz 0 V, 50/60 Hz 220 V, 50/60 Hz 24 V 2 V Other Rated voltage 0 5 L How to Order G: Lead wire length 300 mm F: With foot bracket Light/Surge voltage suppressor Nil None Z With light/surge voltage suppressor S With surge voltage suppressor Not available for GZ, HZ and DOZ Light/Surge voltage suppressor M5 M5 M5 x 0.8 Grommet L plug M plug DIN terminal L: With lead wire (Length 300 mm) ) Bracket is not mounted. M: With lead MN: Without D: With wire (Length lead wire 300 mm) V00 SY SYJ VK VT VG S070 VQ VKF VQZ VS VFN H: Lead wire length 600 mm LN: Without lead wire LO: Without MO: Without DO: Without LN, MN type: With 2 sockets. 4-6-5
Series 00 Low power consumption:.8 W Applicable for vacuum use 00 kpa For manifold use, refer to the pages 4-6-8 to 4-6-. Made to Order Specifications (For details, refer to page 4-6-46.) Description Part no. With foot bracket DXT70-34-A Silencer M5 AN20-M5 (ø8 x 7l ) Mounting screw (M3 x 6) For valve unit (R port), Noise reduction: 2 db or more, Effective area 5 mm 2 Specifications Fluid Air Operating pressure range Refer to the table below. Ambient and fluid temperature ( C) 0 to 50 (No freezing. Refer to page 4-8-4.) Response time (ms) () 5 or less Max. operating frequency (Hz) 5 Flow Characteristics Refer to the table below. Manual override Non-locking push type Lubrication Not required Mounting orientation Unrestricted Shock/Vibration resistance (m/s 2 ) (2) 300/50 Enclosure Dustproof ) Based on dynamic performance test, JIS B 8374-98. (Coil temperature: 20 C, at rated voltage, without surge suppressor) 2) Impact resistance: No malfunction occurred when it is tested with a drop tester in the axial direction and at the right angles to the main valve and armature in both energized and de-energized states every once for each condition. (Values at the initial period) Vibration resistance: No malfunction occurred in a one-sweep test between 45 and 000 Hz. Test was performed at both energized and deenergized states in the axial direction and at the right angles to the main valve and armature. (Values at the initial period) Solenoid Specifications Coil rated voltage (V) Allowable voltage fluctuation (%) Power consumption (W) ) [Current ma] Apparent power (VA) [Current ma] ) Surge voltage suppressor Indicator light ) At rated voltage Operating Pressure Type of Operating pressure range actuation (MPa) ported 0 20 N.C. 0 to 0.7 0 to 0.5 ) Weight stands for grommet type Grommet (G)/(H), L plug (L), M plug (M), DIN terminal (D) 50/60 Hz 00, 200, 24, 48, 0, 220 24, 6, 2, 48 5 to +0% of rated voltage.8 (With indicator light 2.) [24 V: 75 (With indicator light 87.5)] 00 V: 45/50 Hz, 42/60 Hz Inrush 4.5/50 Hz, 4.2/60 Hz 200 V: 22.5/50 Hz, 2/60 Hz 00 V: 35/50 Hz, 30/60 Hz Holding 3.5/50 Hz, 3/60 Hz 200 V: 7.5/50 Hz, 5/60 Hz : Diode, : ZNR : LED (Red), : Neon bulb Vacuum specifications (MPa) (P) port R port 27 kpa to 0.6 00 kpa to 0 M5 x 0.8 00 kpa to 0 00 kpa to 0.4 ) Weight (g) 70 Construction ported 0 20 0 (N.C.) JIS Symbol 20 () JIS Symbol De-energized (P) (SUP port) 3(R) (EXH port) Flow Characteristics De-energized Type of Port Supply side actuation size C [dm 3 /(s bar)] N.C. 0. M5 x 0.8 0.9 (P) (EXH port) 3(R) (SUP port) N.C.: 2 (P A) : 3 2 (R A) No. q w e Flow characteristics Exhaust side N.C.: 2 3 (A R) : 2 (A P) b Cv C [dm 3 /(s bar)] b Cv 0.026 0.023 0.9 0.07 0.042 0.07 0.042 0.3 0.8 0.03 Component Parts r Description Push rod EXH poppet N.C. Back up spring Poppet spring Replacement Parts Material Z Resin NBR Stainless steel No. Description Part no. Material t y Solenoid Epoxy DXT70-A- assembly Stainless steel Solenoid Epoxy DXT70-E- assembly Stainless steel u O-ring 3 x x NBR Platinum silver 0 20 Common with 3 Series 500 4-6-6
3 Port Solenoid Valve Rubber Seal, Ported Series 00 Ported Grommet (G), (H) G 0- -M5(-F) H (Mounting hole) L plug (L) 0- L -M5 2-M3 x 0.5 depth 5 (Mounting thread) M plug (M) 0- M -M5 G: 300 mm H: 600 mm (Piping port) Manual override (Non-locking) DIN terminal (D) 0- D -M5 (Mounting hole for manifold) Applicable cable O.D.: ø3.5 to ø7 V00 SY SYJ VK VT VG S070 VQ VKF VQZ VS VFN 300 300 : With light /surge voltage suppressor 4-6-7
2.56 S OLENOID VALVES S ERIES (N)00 3 2 DIRECT A CTING S OLENOID VALVE 0-32NOM P ORTED T ECHNICAL N O or N C 0-32Nom Ported, possible to Manifold Mount Cv 0.05 al Lamp and Surge Voltage Suppressor Suitable for Pressure or Vacuum Fluid Air Ambient and Fluid Temperature Max 50 C / 22ºF Response Time 5ms or less Max Operating Frequency 5c/s Manual Override Non-locking type Lubrication Not required (Use turbine oil ± (ISO VG32) if lubrication is provided) Enclosure Dust Proof S Y M B O L S S OLENOID Electrical Entry Voltages Allowable Voltage Coil Insulation Temperature Rise Grommet (G), Plug (M) 240V, 0V, 24V 2V, 24V -5~+0% of rated voltage Class E or equivalent (20 C) 45 C or less / 3ºF or less Power Consumption.8W/2.W (W/LED) Apparent Inrush 4.5VA/50Hz, 4.2VA/60Hz Power Holding 3.5VA/50Hz, 3VA/60Hz Surge Voltage Suppressor : Diode, : ZNR Indicator Light : LED (Red), : Neon lamp (N)0 CESSORIES (N)00 SOLENOID V ALVE (N)20 DXT70-23-A-30 Plug with 3m lead DXT70-34-A Foot bracket with screws F L O W Type Type Of Actuation Operating Pressure Range kgf/cm 2 Vacuum Application P Port R Port Effective Orifice mm 2 (Cv Factor) Port Size Weight Ported (N)0- -M5 (N)0- -M5 NC NO 0 ~ 7MPa 0 ~ 00PSI 0 ~ 5MPa 0 ~ 70PSI 22in-Hg 0~85PSI 22in-Hg 0~85PSI V ~0PSI V ~55PSI P->A 0.6 (0,034) A->R 0.9 (0.05) R->A 0.6 (0.034) A->P 0.6 (0.034 0-32Nom (M5x0.8) 0.5g S AFETY : In case of (N)20 Supply Air to 'R' Port. "P" Port will be the Exhaust Port. Observe Operating Pressure Ranges - see Technical Specifications for details H O W T O O R D E R (N)00 SOLENOID V ALVE (N) M5 B ODY O PTION 0 3 2 NC 20 3 2 NO V OLTAGE 00V 2 200V 3 0V 4 220V 5 24V 6 2V L AMP & SURGE V OLTAGE S UPPRESSOR Nil Without Z With Indicator Light & Surge Suppressor S With Surge Suppressor E LECTRICAL E NTRY O PTION F Bracket D DIN Connector G Grommet (300mm lead) H Grommet (600mm Lead) L L Type Plug Connector w/lead Wire (300mm Lead) M M Type Plug Connector w/lead Wire (300mm Lead) LO L Type Plug Connector w/o Connector MO M Type Plug Connector w/o Connector S EE N EXT P AGE FOR FURTHER TECHNICAL DETAILS ON THIS PRODUCT REQUEST CATALOG REFERENCE E20
S OLENOID VALVES S ERIES (N)00 2.57 (N)00 BODY P ORTED G ROMMET T YPE (N)00 BODY P ORTED MN PLUG T YPE M ANIFOLD T YPE 20 TOP P ORTED G ROMMET T YPE S ERIES (N)00 M ANIFOLDS 2 9 station manifold with a common supply and exhaust. M ANIFOLD T YPE 20 T OP P ORTED M PLUG T YPE H O W T O O R D E R M ANIFOLD T YPE 20 TOP P ORTED (N)VV4Z 20 S TATIONS 02 2 Stations to 20 20 Stations T HREAD T YPE - PT 00T NPTF O PTION F Bracket Lead Wire Length CESSORIES M ANIFOLD T YPE 20 TOP P ORTED DXT70-25-A Blanking Plate Assembly Stations (n) 2 3 4 5 6 7 8 9 0 L 53 69 85 0 7 33 49 65 8 L2 40 56 72 88 04 20 36 52 68 L3 6 32 48 64 80 96 2 28 44 L4 8 24 40 56 72 88 04 20 36 S EE INSIDE FRONT COVER FOR DETAILS OF YOUR LOCAL SALES OFFICE FOR FURTHER TECHNICAL DETAILS ON THIS PRODUCT REQUEST CATALOG REFERENCE E20