SPEEDFAX TM 20 Load Centers & Circuit Breakers Contents Load Centers ing System -2 Siemens PL and ES Series Load Centers Introduction -3 PL Series Load Centers Features and Product Offering -4-5 PL Series Single Phase Main Lug & Main Breaker Load Centers -6 PL Series Single Phase Special Load Centers -7 PL Series Three Phase Main Lug & Main Breaker Load Centers -8 PL Series Three Phase Unassembled Load Centers -9 ES Series Load Centers Features and Product Offering -0 - ES Series Single Phase Main Lug & Main Breaker Load Centers -2 ES Series Single Phase Special Load Centers -3 ES Series Three Phase Main Lug & Main Breaker Load Centers -4 EQ Load Centers, 300-400 -5 Generator Ready Load Centers -6 Riser Panel Load Centers -7 EQ Load Centers, Small Circuit and Circuit Breaker Enclosures -8-9 Load Centers OEM Interiors and Accessories -20-22 Standby Power Systems -23-24 Knockout Diagrams -25-29 Load Center Cross Reference -30-3 Circuit Breakers Arc-Fault and Ground-Fault Breakers -32 Intelli-Arc Diagnostic Tool -33 Type QP, " Breakers -34 Duplex, Triplex and Quadplex Plug-In Breakers -35 Special Application Breakers -36 Type QD, 3/4" Breakers -37 Main and Branch Circuit Breakers -38-39 Circuit Breaker Dimension Drawings and Lug Data -40-4 Circuit Breaker Accessories -42-43 Surge Protection Products -44-46 Temporary Power Outlet Panels Introduction and Features -47-48 ing System -49 Common Configurations -50 Temporary Power Dimension Drawings -5-56 Structured Wiring -56-59 AC Disconnects, -Phase, NEMA 3R Rated -60 Residential L Commercial L Industrial
Load Centers ing System ing System Type Enclosure or Component E = Indoor Type 2-0 and 30-42 circuits 300-400 G = Indoor Type 2-42 circuits W = Outdoor Type 3R I or PI = Interior R = Riser P = PL Series Indoor Type 2-70 circuits S = ES Series Indoor Type 2-70 circuits PW = PL Series Outdoor Type 3R 2-70 circuits SW = ES Series Outdoor Type 3R 2-70 circuits Maximum number of " breakers Maximum number of circuits Type of Main ML or L = Main Lug MB or B = Main Breaker System = -Phase, 3-Wire 3 = 3-Phase, 3-Wire or 3-Phase, 4-Wire Main ere Ex:00 = 00 s Trim/ Others Blank = Combination S = Surface F = Flush T = Feed-Thru Lugs G or GB = Ground Bar Factory Installed Type of Bus Bar Blank C or CU P = Aluminum = Copper = Aluminum Bus, Value Pack P 2 24 B 00 S CU Products Shown In Sections of this Speedfax Meet or Exceed the Following Standards. UL50 Electric Cabinets and Boxes UL67 Electric Panelboards UL486 Wire Connectors UL489 Molded-Case Circuit Breakers UL869 Service Equipment UL943 Ground Fault interrupters (Class A Personnel Protection) Federal Specification W-P-5b Panel Power Distribution Federal Specification W-C-375B Circuit Breakers NEC NEMA 250 Underwriters Laboratories, Inc. Reference File Numbers: Series Connected Circuit Breaker Information is recognized by UL under file #E0848(N) Load Centers Listed by UL under file #E0703 Load Centers UL recognized components found under file #E0703, Volume 6 and 7. (Also referenced under the recognized components directory section QEUY2) EQ Circuit Breakers are Listed by UL under file #E8265-2 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog
Load Centers Siemens PL and ES Series Load Centers Overview PL Series: Convertible Invertible Insta-wire neutrals & grounds Ground bars included Copper busbars Dual neutrals on all configurations Carton-in-carton packaging Lifetime warranty PL Series -phase PL Series 3-phase ES Series: Invertible Insta-wire neutrals & grounds Aluminum busbars Single sided neutral on 24 circuits and below Single piece carton packaging 0 year warranty ES Series -phase ES Series 3-phase Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -3
PL Series Load Centers Features All devices convertible from main lug to main breaker and vice versa. All devices are provided with 2 factory installed ground bars. Invertible for bottom feed application. Mounting tabs on the trim hold it in place on the load center, freeing up both hands to drive the trim screws. Combination head screw on the neutrals, ground, trim, upper pan, and bond screw provide installation flexibility. A rigid, sturdy base pan provides the ruggedness required for the most harsh applications. The prepositioned bond screw eliminates bond strap/ screw assemblies, and reduces the risk of losing components in the field. The patented INSTA-WIRE neutral/ground system allows for faster installation because screws are backed out, ready for wire insertion. The visible neutral and grounds system aids in the insertion of conductors. Copper Bus PL Series Load Centers ship with trims packaged separately. The outdoor enclosure has a slide hinge door for the easiest installation and can be removed by backing out only one screw. -4 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog
PL Series Load Centers Product Offering The PL Series Load Center product line provides a wide array of variation to meet any application need. The following offering is available in the PL Series product line: 2-70 / Indoor and Outdoor enclosures 00 to 225 Main Lug and Main Breakers Un-assembled offering in 3-phase PL Series -phase Main Lug PL Series 3-phase Main Breaker Un-assembled 3-phase Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -5
PL Series -Phase Main Lug & Main Breaker Load Centers -phase, 3-wire SN, 20/240 Volts AC Revised 06/3/4 Main Breaker/Convertible Load Centers Copper Bus 2-70 / 00-225 eres 60/75 C Rated 22,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R 00 2 24 P224B00CU 8 PW224B00CU 2 00 6 24 P624B00CU 2 PW624B00CU 23 00 20 20 P2020B00CU 24 PW2020B00CU 27 00 20 24 P2024B00CU 24 00 24 24 P2424B00CU 24 00 30 30 P3030B00CU 30 00 30 40 PW3040B00CU 35 25 30 30 P3030B25CU 30 PW3040B25CU 35 50 20 30 P2030B50CU 24 50 20 30 PW2030B50CU 27 50 30 30 P3030B50CU 30 50 30 40 PW3040B50CU 35 200 20 40 P2040B200CU 30 PW2040B200CU 27 200 30 40 P3040B200CU 36 PW3040B200CU 35 200 30 40 P3040B200 36 200 40 40 P4040B200CU 36 PW4040B200CU 38 200 40 40 P4040B200 36 200 54 70 P5470B200CU 44 225 42 60 P4260B225CU 39 PW4260B225CU 42 225 54 70 P5470B225CU 44 Single phase factory installed 22kA IR main circuit breaker offers 22/0kA IR series combination rating when using 0kA type QP, QT, QPF, QE, QN, and QAF2/QAF2C branch breakers. Main Lug/Convertible Load Centers Copper Bus 2-70 / 25-225 eres 60/75 Rated 00,000A IR Branch Indoor Enclosure - NEMA Type Outdoor Enclosure - NEMA Type 3R 25 2 2 P22L25CU 8 PW22L25CU 2 25 2 24 P224L25CU 8 PW224L25CU 2 25 6 24 P624L25CU 2 PW624L25CU 23 25 20 20 P2020L25CU 24 25 20 24 P2024L25CU 24 25 24 40 P2440L25CU 24 25 30 40 P3040L25CU 30 PW3040L25CU 35 25 40 40 P4040L25CU 36 50 20 30 P2030L50CU 24 PW2030L50CU 27 200 2 24 P224L200CU 24 PW224L200CU 23 200 20 40 P2040L200CU 30 PW2040L200CU 27 200 24 40 P2440L200CU 30 200 30 30 P3030L200CU 36 200 30 40 P3040L200CU 36 PW3040L200CU 35 200 30 40 P3040L200 36 200 30 54 P3054L200CU 36 PW3054L200CU 35 200 40 40 P4040L200CU 36 PW4040L200CU 38 200 40 40 P4040L200 36 225 2 24 PW224L225CU 23 225 42 60 P4260L225CU 39 PW4260L225CU 42 225 54 70 P5470L225CU 44 Suitable for use as service equipment. May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Suitable for use as service entrance equipment when not more than six main disconnecting means are provided. See article 230.7 of the NEC. 25A load centers will accept MBK00A and MBK25A. 50A load centers will accept MBK50A. 200A load centers will accept MBK200A and MBK50A. 225A load centers will accept MBK225A, MBK200A, MBK50A. Copper bus load centers are recommended for those applications where the environment may be severe (i.e. far and coastal areas). Includes all PL Series features with aluminum bussing. -6 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog
PL Series -Phase Special Application Load Centers -phase, 3-wire SN, 20/240 Volts AC Revised 02/26/2 Split Ground Series Main Lug Convertible Load Centers Copper Bus 2-60 / 25-200 eres 60/75 Rated, 00,000A IR Branch Indoor Enclosure NEMA Type 25 2 24 P224L25CUSG 8 25 6 24 P624L25CUSG 2 25 20 30 P2030L25CUSG 24 25 24 30 P2430L25CUSG 24 50 20 30 P2030L50CUSG 24 200 30 40 P3040L200CUSG 36 200 30 40 P3040L200SG 36 200 40 40 P4040L200CUSG 36 200 40 40 P4040L200SG 36 225 40 60 P4260L225CUSG 39 Split Ground Series Main Breaker Convertible Load Centers Copper Bus 40 / 200 eres 60/75 Rated, 22,000A IR Branch Indoor Enclosure NEMA Type 200 40 40 P4040B200CUSG 36 Split Ground Load Centers have factory installed 00% neutral with factory bonded 75% ground. No neutral tie strap. Outdoor Trailer Panels Copper Bus 6 / 200 eres 60/75 Rated, 22,000A IR Main Breaker MBK50A or MBK200A 200 8 6 PW086L200TC 200 8 6 PW086B200TC MBK200A Field Installed 23 Factory Installed 23 Load Centers with White Trim Copper or Aluminum Bus 40 / 200 eres 60/75 Rated 22,000A IR Branch Indoor Enclosure - NEMA Type Main Lug / Main Breaker 200 Main Breaker 30 40 P3040B200W 36 200 Main Breaker 40 40 P4040B200W 36 200 Main Breaker 40 40 P4040B200CUW 36 Includes all PL Series features with aluminum bussing. Indoor enclosures are 4 /4" wide by 3 7/8" deep. May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Main lug panel rated 00,000A IR. Load centers with white trim have increased lead time of 3-4 weeks. Sold in pallet quantites only. Load centers with CUW suffix indicates copper bus with white trim. Load centers with W suffix only indicates aluminum bus with white trim. Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -7
PL Series 3-Phase Main Lug & Main Breaker Load Centers 3-phase, 3-wire, 240 Volt AC or 3-phase, 4-wire, 20/240 or 20/208 Volts AC Revised 02/26/2 Main Breaker/Convertible Load Centers Copper Bus 30-70 / 00-225 eres 60/75 C Rated 22,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R 00 2 24 P224B300CU 24 00 30 42 P3042B300CU 30 25 30 30 P3030B325CU 39 50 24 42 P2442B350CU 36 50 42 42 P4242B350CU 42 200 30 54 P3054B3200CU 39 PW3054B3200CU 38 200 42 60 P4260B3200CU 42 PW4260B3200CU 42 225 42 60 P4260B3225CU 42 225 42 60 P4260B3225TCU 49 225 54 70 P5470B3225CU 49 Main Lug/Convertible Load Centers Copper Bus 2-70 / 25-225 eres 60/75 Rated 00,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R 25 2 24 P224L325CU 2 PW224L325CU 2 200 24 42 P2442L3200CU 36 PW2442L3200CU 35 200 30 54 P3054L3200CU 39 PW3054L3200CU 38 225 42 60 P4260L3225CU 42 PW4260L3225CU 42 225 54 70 P5470L3225CU 49 May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Back fed main breaker. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Suitable for use as service entrance equipment when not more than six main disconnecting means are provided. See article 230.7 of the NEC. Includes factory installed feed through lugs and is also non-convertible. Non-convertible to main breaker. All load centers are provided with tin plated copper bus bars. Rated 00,000A IR in series with breakers listed on wiring diagram. All load centers are provided with tin-plated copper bus bars. -8 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog
PL Series 3-Phase Unassembled Load Centers 3-phase, 3-wire, 240 Volt AC or 3-phase, 4-wire, 20/240 or 20/208 Volts AC Main Breaker Convertible Unassembled Load Centers Copper Bus 24-70 / 00-225 eres 60/75 C Rated 22,000A IR Interiors Enclosure Trim Kit Interior Enclosure No. Breaker Trim 00 30 42 PI3042B300CU 30 3PE30 30 PT3042B300 50 24 42 PI2442B350CU 36 3PE36 24 PT2442X350 200 30 54 PI3054B3200CU 39 3PE39 30 PT3054X3200 200 42 60 PI4260B3200CU 42 3PE42 42 PT4260X3200 225 54 70 PI5470B3225CU 49 3PE49 54 PT5470X3225 Main Lug Convertible Unassembled Load Centers Copper Bus 2-70 / 25-225 eres 60/75 Rated 00,000A IR Interiors Enclosure Trim Kit Interior Enclosure No. Breaker Trim 25 2 24 PI224L325CU 2 3PE2 2 PT224L325 200 24 42 PI2442L3200CU 36 3PE36 24 PT2442X3200 200 30 54 PI3054L3200CU 39 3PE39 30 PT3054X3200 225 42 60 PI4260L3225CU 42 3PE42 42 PT4260X3225 225 54 70 PI5470L3225CU 49 3PE49 54 PT5470X3225 May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Back fed main breaker. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Trim catalog numbers with a B indicate for use with main breaker and is not convertible. L indicates for use with main lug and is not convertible. X indicates can be used with convertible interior. All load center interiors are provided with tin plated copper bus bars. Rated 00,000A IR in series with breakers listed on wiring diagram. Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -9
ES Series Load Centers Features Revised 04/28/5 Combination head screw on the neutrals, ground, trim, upper pan, and bond screw provide installation flexibility. Invertible for bottom feed application. Ground bar field installed (select skus with G suffix will have ground bar factory installed). Mounting tabs on the trim hold it in place on the load center, freeing up both hands to drive the trim screws. The prepositioned bond screw eliminates bond strap/ screw assemblies, and reduces the risk of losing components in the field. Single side inboard neutral on 24 circuits and below; dual on 30 circuits and above. A rigid, sturdy base pan provides the ruggedness required for the most harsh applications. The patented INSTA-WIRE neutral/ground system allows for faster installation because screws are backed out, ready for wire insertion. The visible neutral and grounds system aids in the insertion of conductors. Aluminum bus. ES Series Load Centers ship in single piece carton. The outdoor enclosure has a slide hinge door for the easiest installation and can be removed by backing out only one screw. -0 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog
ES Series Load Centers Product Offering The ES Series Load Center product line provides a wide array of variation to meet any application need. The following offering is available in the ES Series product line: 2-70 / Indoor and Outdoor enclosures 00 to 225 Main Lug and Main Breakers Value packs a mix of branch breakers provided with the load center. ES Series -phase Main Lug 25A, 2-24 circuits ES Series - phase Main Breaker 25-225A, 30-70 circuits ES Series 3-phase Main Breaker Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -
ES Series -Phase Main Lug & Main Breaker Load Centers -phase, 3-wire SN, 20/240 Volts AC Revised 04/28/5 Main Breaker Aluminum Bus 2-70 / 00-225 eres 60/75 C Rated 22,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R 00 0 20 S020B00 8 00 2 24 S224B00 8 SW224B00 2 00 6 24 S624B00 2 SW624B00 23 00 20 20 S2020B00 24 SW2020B00 27 00 20 24 S2024B00 24 00 30 30 S3030B00 30 25 2 24 SW224B25 2 25 6 24 S624B25 2-25 6 32 SW2024B25 27 25 24 24 S2424B25 24 SW2424B25 27 25 30 30 S3030B25 30 25 30 40 S3040B25 30 SW3040B25 35 50 6 30 S630B50 24 50 20 30 S2030B50 24 50 24 30 S2430B50 30 50 30 30 S3030B50 30 50 30 40 S3040B50 30 SW3040B50 35 50 40 40 SW4040B50 38 200 6 32 S632B200 24 200 20 40 S2040B200 30 SW2040B200 27 200 24 40 S2440B200 30 200 30 40 S3040B200 36 SW3040B200 35 200 40 40 S4040B200 36 SW4040B200 38 200 54 70 S5470B200 44 225 42 60 S4260B225 39 SW4260B225 42 225 54 70 S5470B225 44 Main Lug Aluminum Bus 2-70 / 25-225 eres 60/75 Rated 00,000A IR Branch Indoor Enclosure - NEMA Type Outdoor Enclosure - NEMA Type 3R 25 2 2 S22L25 8 SW22L25 2 25 2 24 S224L25 8 SW224L25 2 25 6 24 S624L25 2 SW624L25 2 25 20 20 S2020L25 2 25 20 20 S2020L25G 2 25 20 24 S2024L25 2 25 20 24 S2024L25G 2 25 24 24 S2424L25 24 SW2424L25 27 25 24 24 S2424L25G 24 25 24 40 S2440L25 24 25 30 40 S3040L25 30 SW3040L25 29 25 30 40 S3040L25G 30 25 40 40 S4040L25 36 50 20 30 S2030L50 24 SW2030L50 27 200 2 24 S224L200 2 SW224L200 2 200 20 40 S2040L200 24 SW2040L200 27 200 24 40 S2440L200 30 200 30 30 S3030L200 30 200 30 40 S3040L200 30 SW3040L200 35 200 30 54 S3054L200 30 SW3054L200 35 200 40 40 S4040L200 36 SW4040L200 35 225 2 24 SW224L225 23 225 42 60 S4260L225 36 SW4260L225 38 225 54 70 S5470L225 42 Suitable for use as service equipment. May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Suitable for use as service entrance equipment when not more than six main disconnecting means are provided. See article 230.7 of the NEC. ES Series single phase skus with a "G" suffix have ground bar included (factory installed). -2 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog
ES Series -Phase Special Load Centers -phase, 3-wire SN, 20/240 Volts AC Revised 0/22/3 Load Centers with White Trim Aluminum Bus 6-40 / 00 200 eres 60/75 Rated 00,000A IR Branch Indoor Enclosure NEMA Type Main Lug / Main Breaker 00 Main Breaker 6 24 S624B00W 2 25 Main Lug 20 20 S2020L25W 2 25 Main Lug 24 24 S2424L25W 24 200 Main Lug 30 30 S3030L200W 30 200 Main Lug 40 40 S4040L200W 35 25 Main Lug 30 40 S3040L25W 30 200 Main Breaker 40 40 S4040B200W 36 Outdoor Trailer Panels Aluminum Bus 6 / 200 eres 60/75 Rated 00,000A IR Main Breaker 200 8 6 SW086L200T N/A N/A 23 200 8 6 SW086B200T MBK200A Factory Installed 23 Value Pack Load Centers Load Center Breakers Included N0. of Aluminum Bus S2020B00P S2020B00 (3) Q20, () Q230 00 20 20 S3040B200P S3040B200 (3) Q20, () Q230 200 30 40 S3040L200P S3040L200 (3) Q20, () Q230 200 30 40 S4040B200P S4040B200 (3) Q20, () Q230 200 30 40 S3054B200P N/A (3) Q20, () Q230 200 30 54 Split Ground Series Load Centers 30-40 / 25-200 eres 6 / 200 eres Aluminum Bus Branch Indoor Enclosure NEMA Type 25 20 30 S2030L25SG 2 50 30 30 S3030B50SG 30 200 40 40 S4040B200SG 36 Selectable Main Load Centers 24-40 / 25-200 eres Aluminum Bus Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R Available Kits Enclosure Enclosure Height Height Main Lug Main Breaker 25 24 24 S2424C25 24 SW2424C25 27 ECMLK25 MBK00A, MBK25A 200 20 40 S2040C200 35 SW2040C200 35 ECMLK225 MBK200A 200 30 40 S3040C200 36 SW3040C200 35 ECMLK225 MBK50A, MBK200A, MBK225A 200 40 40 S4040C200 36 SW4040C200 38 ECMLK225 MBK50A, MBK200A, MBK225A Load centers with white trim have increased lead time of 3-4 weeks. Sold in pallet quantities only. Additional charge will apply. Contact sales office for details. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Breakers are shipped inside a sleeve located inside the load center. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Main breaker rated 22,000A IR. Split Ground load centers have factory installed 00% neutral with factory bonded 75% ground. Selectable main load centers do not come with main lugs or main breakers. Those kits are sold separately. Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -3
ES Series 3-Phase Main Lug & Main Breaker Load Centers 3-phase, 3-wire, 240 Volt AC or 3-phase, 4-wire, 20/240 or 20/208 Volts AC Revised 04/28/5 Main Breaker Aluminum Bus 30-60 / 00-225 eres 60/75 C Rated 0,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R 00 2 24 S224B300 24 00 30 30 S3030B300 30 00 30 42 S3042B300 30 25 30 42 S3042B325 35 50 24 42 S2442B350 36 SW2442B350 35 50 42 42 S4242B350 42 50 30 54 S3054B350 35 200 30 54 S3054B3200 39 SW3054B3200 38 200 42 60 S4260B3200 42 SW4260B3200 42 225 42 42 S4242B3225 42 SW4242B3225 42 Main Lug Aluminum Bus 2-70 / 25-225 eres 60/75 Rated 00,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R 25 2 24 S224L325 2 SW224L325 2 50 8 36 S836L350 24 SW836L350 23 50 24 42 S2442L350 30 SW2442L350 27 200 2 24 S224L3200 2 SW224L3200 2 200 24 42 S2442L3200 30 SW2442L3200 27 200 30 54 S3054L3200 30 SW3054L3200 35 225 42 60 S4260L3225 36 SW4260L3225 38 225 54 70 S5470L3225 42 May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Back fed main breaker. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Suitable for use as service entrance equipment when not more than six main disconnecting means are provided. See article 230.7 of the NEC. Rated 00,000A IR in series with breakers listed on wiring diagram. -4 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog