Amphenol Aerospace. D38999 Series III Groundplane Connector with Quadrax PCB Sockets. D38999 Series III with Quadrax and Power Contacts

Transcription

1 mphenol erospace Size 8 igh Speed Quadrax and ifferential Twinax ontacts or use in IL-TL Special* Subminiature ylindrical and RIN 600 Rectangular onnectors Series III Groundplane onnector with Quadrax P Sockets Quadrax ontacts consist of an outer contact with four strategically spaced inner contacts forming two 00 or 50 Ohm matched impedance differential pairs. ifferential Twinax ontacts consist of an outer contact with two inner contacts spaced to form one 00 or 50 Ohm matched impedance differential pair. ontacts can be used in connectors for applications: thernet 00 ase-t-00 Ohm Gigabit thernet 000 ase-t-00 Ohm ibre-hannel-50 Ohm I 394 irewire-0 Ohm Typical lectrical Performance: andwidth: Up to 3 Gigahertz ata Rate: xceeding 3 Gbits/sec Voltage Rating: 500 Vrms sea level ielectric Withstanding Voltage: 000 V rms between all inner sea level 500 V rms between inner and outer sea level Series III with Quadrax and Power ontacts Quadrax and Twinax Transition Plugs and Receptacle dapters * Requires modified connector to accommodate keyed contacts. ight Wire Gigabit thernet ssembly L-05- Printed 5/008

2 oard Level onnectors with ompliant Quadrax ontacts ompliant hole diameters:.05 ±.00 PT Quadrax contact.040 ±.003 PT Shell grounding ccommodates backplane.5 inch minimum thickness onsult mphenol erospace for availability of additional connector configurations oard Level Quadrax onnector ompliant Quadrax Socket and P Tail Quadrax Pin Quadrax able ssembly ttached to oard Level ompliant Quadrax onnector oard Level Transition dapters lso available are matched impedance Quadrax and Twinax Transition dapters which provide a method of launching from the high speed connectors to the P boards. Non-threaded adapters for launching direct from the cable end to the board are also available. Part numbers vary depending on cable. onsult mphenol for more information. Straight Quadrax Receptacle ontact 90 egree Twinax Receptacle ontact and Transition Plug 90 egree Quadrax Receptacle ontact and Transition Plug

3 The following pages provide a list of contact part numbers available, but not limited to the cables listed. ll contacts are available kitted with or installed into RIN 600 and specially modified IL-TL connectors*. or onnectors escription Part Number able Part Number Impedance Quadrax Socket P Socket Quadrax Pin Installation Instruction Sheet** raka ileca , , ilotex T P36, ilotex TP870, PI Wire Ohm L Tensolite 6473/0006X-4(L)/Gore RN Ohm L Tensolite N4Q00, N4Q00-0, 4443/9P05X- 4(L), S80W50-4, 4443/0330X-4(L), Thermax 956-4TN, Tensolite 4450/00X-4(L), N4-Q00, 4443/0366X-4(L), Thermax T956-4T00, Pic Wire 544, Thermax X00Q-4, N4Q (Space), PI Ohm L Tensolite NQ00, NQ00-0,Thermax 956-5, raka ileca , GOR RN Ohm L Tensolite 4450/03089X-4(L) 0 Ohm L Tensolite N6Q00, N6Q00-0, N6-Q00, PI Ohm L JSY0-0 Ohm L Gore RN8487, JSY8 0 Ohm L raka ileca Ohm L-9-W Gore RN853, JS Ohm L-9-N Tensolite N4Q00, N4Q00-0 for.5 Gbps applications P (.035 Length) 00 Ohm P (.866 Length) 00 Ohm P (.035 Length) 50 Ohm P (.836 Length) 00 Ohm 00 Ohm L-9-S raka ileca , , ilotex T P36, PI Wire Ohm L Tensolite 6473/0006X-4(L)/ Gore RN Ohm L Tensolite N4Q00, N4Q00-0, 4443/9P05X- 4(L), S80W50-4, 4443/0330X-4(L), Thermax 956-4TN, Tensolite 4450/00X-4(L), N4-Q00, 4443/0366X-4(L), Thermax T956-4T00, Pic Wire 544, Thermax X00Q-4, N4Q (Space), PI Ohm L Tensolite NQ00, NQ00-0, Thermax 956-5, raka ileca Ohm L Tensolite 4450/03089X-4(L) 0 Ohm L Tensolite N6Q00, N6Q00-0, N6-Q00, PI Ohm L JSY0-0 Ohm L Gore RN8487, JSY8 0 Ohm L Gore RN853, JSY Ohm L-9-N raka ileca Ohm L-9-W Tensolite N4Q00, N4Q00-0 for.5 Gbps applications 00 Ohm L-9-S * Requires modified connector to accommodate keyed contacts. ** Installation instructions are available on-line at 3

4 P Pin or onnectors, cont. escription Part Number able Part Number Impedance Transition dapters Sealing Plugs P (.035 Length) 00 Ohm P (.866 Length) 00 Ohm P (.035 Length) 50 Ohm Right ngle Special P 00 Ohm P (.494 Length) 00 Ohm P Special (.430 Length) 00 Ohm P (.94 Length) 00 Ohm P (.859 Length) 00 Ohm Installation Instruction Sheet** Plug contact, Tensolite 6473/0006X-4(L), Gore RN Ohm L-9-S P Receptacle straight 50 Ohm P Receptacle 90 degree 50 Ohm Plug contact, Tensolite N4Q00 00 Ohm L-9-U Plug contact, Tensolite NQ00, NQ00-0, Thermax Ohm Plug contact raka ileca , Ohm L-9-Y Plug contact, N6Q00 cable 00 Ohm P receptacle 90 degree 00 Ohm P receptacle straight 00 Ohm P receptacle straight, special tail length (.00) 00 Ohm able to board 90 degree adapter 50 Ohm GS wired jam nut 00 Ohm Straight in-line receptacle (threaded) N4Q00 cable 00 Ohm L-9-L Straight P cable to board adapter N4Q00 cable 00 Ohm L-9-N Straight P cable to board adapter 6473/0006X-4 (L) cable 50 Ohm L-9-P able to board 90 degree adapter 00 Ohm Pin terminator 00 Ohm T P Standard Plastic T P Standard Plastic to be used with P tails (shorter tail length) etal sealing plug (same as T P) Q etal sealing plug can be used when mating with contacts on mating half Q etal sealing plug used with P s and mating contact on mating half etalized piggyback grommet ** Installation instructions are available on-line at 4

5 or onnectors, cont. escription Part Number able Part Number Impedance ifferential Twinax Socket Twinax Socket P ifferential Twinax Pin Twinax Pin P Transition dapters - Twinax Tensolite 4463/05099X-8(L), Thermax X 00-4, Tensolite 4463/9P05X-(L), Thermax 84, ST (98 Ohm), 6463/70460X- (98 Ohm), PI 04, ileca 709-3, N4T00-00 (Space) Installation Instruction Sheet** 00 Ohm L Tensolite 6483/0307X-(L) 50 Ohm L Tensolite 6453/0384X-(L), Thermax Z, GOR GS , 6453/0384X-()L 00 Ohm L-9-T GOR GS Vacuum egassed 00 Ohm L-9-Y /054X-(L) 00 Ohm L Raychem Ohm JSY-4, Tensolite 4463/030T-(L), Thermax 956-T00 00 Ohm L-9-T S80W Ohm P (.035 Length) 00 Ohm P (.035 Length) 50 Ohm Tensolite 4463/9P05X-(L), Thermax 84, ST (98 Ohm), 6463/70460X- (98 Ohm), 4463/05099X-8(L), Thermax X 00-4, PI 04, ileca 709-3, N4T00-00 (Space) 00 Ohm L Tensolite 6483/0307X-(L) 50 Ohm L Tensolite 6453/0384X-(L), Thermax Z, GOR GS , 6453/0384X-()L 00 Ohm L-9-T GOR GS Vacuum egassed 00 Ohm L-9-Y /054X-(L) 00 Ohm L Raychem Ohm JSY-4, Tensolite 4463/030T-(L), Thermax 956-T P (.035 Length) 00 Ohm P (.035 Length) 50 Ohm 00 Ohm L-9-T Straight receptacle 00 Ohm degree receptacle 00 Ohm degree receptacle (smaller profile) 00 Ohm degree P cable to board, cable 4463/9P05X- 00 Ohm L-9-V degree P (.83 tail) 00 Ohm Straight P (.83 tail) 00 Ohm degree receptacle (small profile.30) 50 Ohm Plug for 4463/9P05X-(L) 00 Ohm L-9-P Plug for 7/ Ohm L-9-J degree P cable to board, cable 6483/0307X- 50 Ohm Plug for 6483/0307X- 50 Ohm L-9-R degree Receptacle 50 Ohm Plug for 6483/0307X- (mates to ) 50 Ohm ** Installation instructions are available on-line at 5

6 or RIN 600 onnectors escription Part Number able Part Number Impedance Installation Instruction Sheet** Tensolite N4Q00, 4443/9P05X-4(L), S80W50-4, 4443/0330X-4(L) 00 Ohm L raka ileca Ohm L-9-I Quadrax Socket Tensolite 6473/0006X-4(L), Gore RN Ohm L-9-L JSY0-0 Ohm raka ileca , NQ00 00 Ohm L-9-S Socket P P (.037 Length) 00 Ohm Quadrax Pin Pin P ifferential Twinax Socket ifferential Twinax Pin Tensolite N4Q00, 4443/9P05X-4(L), S80W50-4, 4443/0330X-4(L) 00 Ohm L raka ileca Ohm L-9-I Tensolite 6473/0006X-4(L), Gore RN Ohm L-9-L JSY raka ileca , NQ00 00 Ohm L-9-S P (.83 Length) 00 Ohm P (.037 Length) 00 Ohm P (.83 Length) 00 Ohm S0386W4 00 Ohm L-9-G SN07T 00 Ohm L-9-G SN07T4 00 Ohm L-9-G Tensolite 4463/9P05X-(L) 00 Ohm S0386W4 00 Ohm L-9-G SN07T 00 Ohm L-9-G SN07T4 00 Ohm L-9-G Tensolite 4463/905X-(L) 00 Ohm ** Installation instructions are available on-line at Quadrax ontact for RIN onnectors 6

7 OW TO ORR mphenol Quadrax onnectors can be ordered by coded part number. The below connectors are kitted with the 00 Ohm Quadrax Socket and Pin contacts only. or contacts other than the previous list, please consult mphenol erospace for part numbers. xample TVP00RQW-75P onnector Type TV designates Tri-Start Series onnector** TVP designates back panel mounted receptacle Shell Style 00 designates wall mount receptacle 0 designates box mount receptacle available only with the P tails and epoxy backfilled (non-removable) 06 designates straight plug 07 designates jam nut receptacle Service lass RQ electroless nickel plated aluminum RGQ electroless nickel plated groundplane aluminum RQW olive drab cadmium plate RGQW olive drab cadmium plated groundplane aluminum RQ Nilronze RGQ Nilronze ground plane RQ corrosion resistance stainless steel RGQ stainless steel ground plane Shell Size / Insert arrangement available IL-TL-38999, Sizes 9-5 (see insert arrangements available on next page) ontact Type P designates pin contacts S designates socket contacts ** onsult mphenol atalog -09 for more information on Tri-Start, IL-TL connectors. This catalog is online at Suggested Strain Relief ue to the piggyback grommet interference with normal strain reliefs on the shell size 9 only, the recommended strain relief for the connector is: mphenol part number TGW-R (O ad) or TGR-R (lectroless Nickel) - Size 9 only or 9-8 insert pattern, recommended backshell - Glenair 367--N. This is recommended due to the proximity of the Size 8 contacts in relation to the shell..367 X..55 X. PIGGY GROT 7

8 Quadrax & ifferential Twinax ontact insert arrangements for IL-TL front face of pin inserts illustrated P N L R J S T U G V f W U h N S R g Insert rrangement Number of ontacts ontact Size Grounded eets oeing Specification S R P N U L T J V G Insert rrangement Number of ontacts ontact Size G U T a V b d S c R q r s e w t Z p f n v u P g k m h N Y L J X W G S R P Z N Y X L T 5 6 W J U V G V U s r T q S p W t R z n m P y k N h L X u Y v Z a b w c d x G e g f J Insert rrangement Number of ontacts ontact Size Insert rrangement 5-6 Number of ontacts 8 4 ontact Size ONTT LGN

9 Suggested Numbering for Quadrax and Twinax ontacts ORINTTION Y PIN ONTT TING SOT ONTT TING IGUR - INNR ONTT NURING, QURX ORINTTION Y PIN ONTT TING SOT ONTT TING IGUR - INNR ONTT NURING, TWINX ifferential Twinax ontact ifferential Twinax ontacts and dapter 9

10 Size 8 Quadrax ated Pair Terminated to Tensolite able N4Q00 ifferential Impedance 00 Ohm ±0 thernet 00 ase-t able I 394 irewire able ttenuation on.5 ft. 00 z :.78 d 400 z : 3.94 d.0 Gz : 7.55 d.5 Gz : 5.8 d 3.0 Gz : 9. d ar nd ross Talk (XT) ye Pattern > -30 d up to 3.5 Gz The minimum output eye opening with a -volt p-p input shall be 408 mv p-p measured at 50% of the period ifferential mode,.5 feet test length, 00 ps rise time (30%-80%),.65 Gb/sec..5 feet test length, tested on P8753S Network nalyzer Size 8 Quadrax ated Pair Terminated to Tensolite able 6473/0006X-4(L) ifferential Impedance 50 Ohm ±30 ibre hannel able ttenuation on.5 ft. 5 z : 4.4 d.06 z : 7.0 d.65 Gz : 0.7 d.00 Gz :.65 d ar nd ross Talk (XT) ye Pattern > -30 d up to 3.5 Gz The minimum output eye opening with a -volt p-p input shall be 438 mv p-p measured at 50% of the period ifferential mode, 35 feet test length, 00 ps rise time (30%-80%),.65 Gb/sec. 35 feet test length, tested on P8753S Network nalyzer Size 8 ifferential Twinax ated Pair Terminated to Tensolite able 4463/9P05X-(L) ifferential Impedance 00 Ohm ±0 thernet 00 ase-t able I 394 irewire able ttenuation on.5 ft. 608 z : 3. d.85 z : 3.98 d.3 Gz : 3.30 d 3.3 Gz : 3.90 d ye Pattern The minimum output eye opening with a -volt p-p input shall be 434 mv p-p measured at 50% of the period ifferential mode,.5 feet test length, 00 ps rise time (0%-80%),.65 Gb/sec. or more information, consult mphenol erospace elaware venue, Sidney, NY Phone: or L-05