Clyde Atkins Federal Courthouse in Miami, FL

Transcription

1 Construction Management Clyde Atkins Federal Courthouse in Miami, FL Waterproofing WSOC - Fort Meade, MD WSOC - Fort Meade, MD GSA - PBI Airport TSA Training Room 2100 Corporate Drive Boynton Beach, FL Cell: (561) Fax: (561) Society of SAmerican Military Engineers

2 Table of contents Introduction Recognitions and Awards Current and Recent Projects LEED - Hyperpower Maintenance Facilities SCIF Wall Separation Project Profie Design Build Moisture Intrusion Repair, Improvements, Repairs and Mold Remediation Project Profie Moroso Motorsports Park Project Profie Design/Build Internal Review Service 3rd and 9th Floor Renovation Palm Springs Middle School Project Profie New Fitness Center - Wilkie D. Ferguson Courthouse Primary Care Medical Offie Project Profie Current Emergency Repairs Contractor for SDPBC and Broward County Del Mar Village Project Profie Wachovia Securities Project Profie Intracoastal Mall Project Profie Royal Palm Elementary School Project Profie

3 introduction LEBOLO is a full service General Contracting and Construction Management Firm specializing in Commercial, Educational and Federal markets. Established in October 2000, LEBOLO employs a staff of educated Civil Engineers and Project Managers experienced in the construction industry. Managing projects from conception to completion with the use of a Document Management Program (PDM) and ProCore which enables LEBOLO to provide accuracy in estimating, budgeting, prequalification, scheduling and quality control. The repeat client list demonstrates the reputation of projects successfully completed within budget and to the highest standards of excellence.lebolo S expertise and experience makes the development or redevelopment project a satisfying and lucrative experience. LEBOLO specializes in Construction Management, General Contracting, Estimating and Budgeting, Scheduling, Procurement, Quality Control, Plan Review, OSHA Compliance, Final Inspections and Supervision. As a board member of ABC Florida East Coast Chapter, LEBOLO has valuable insight to the most qualified and dependable tradesmen for every phase of a project, allowing the best resources available therefore, assuring its success and eliminating costly delays. LEBOLO was recently awarded the 2013 S.T.E.P. (Safety, Training and Evaluation Process) Diamond Award and the 2012 and 2013 Pinnacle in Safety Award. LEBOLO is dedicated to job safety and is extremely proud of our safety accomplishments

4 Recognitions and Awards 2011, 2012 & 2013 S.T.E.P. Safety Award - Diamond Level Only 1 in South Florida Only 4 in the state of Florida Only 94 in the Nation 2011 AMEX Contractor of the Year 2010 S.T.E.P. Safety Award - Platinum 2009 S.T.E.P. Safety Award - Platinum 2008 S.T.E.P. Safety Award - Gold ** 2012 ABC National Pinnacle Safety Award ** 2011 ABC National Safety in Excellence Award 2010 National Safety Merit Award 2012 and 2013 Pinnacle Safety Award 2008 ABC National Excellence in Construction Award Moroso Motorsports Park Project 02

5 CURRENT and recent PROJECTs LEBOLO S RELEVANT EXPERIENCE: Wellness Center GSA Fed Courthouse GSA Pure Air Pure Air GSA USACE Dept. of Army HOMESTEAD Task Order Dept. of Army MacDill AFB MacDill AFB Divine Savior Academy SWA CDM Smith FL HOUSE GSA GSA GSA GSA GSA Deerfield Beach Repairs & Mold Remediation Fort Lauderdale Courthouse Mold Remediation GSA Fort Myers Courthouse Remediation GSA Tampa Courthouse Remediation Fed Courthouse Window Repairs & Mold Remediation Ocala WSOC a LEBOLO Watts JV, Fort Meade IDIQ Contract for Misc. O&M, Homestead HOMESTEAD Task Order, Sun Shades HOMESTEAD Task Order, MacDill, SCIF Walls HOMESTEAD Task Order, Ammo Storage Generator Relocation LEBOLO RUSH JV IDIQ Contract for Misc. O&M, MacDill AFB Breezeway CENTCOM LEBOLO-Moss JV, Doral Maintenance Building, WPB Detox Center, Pompano Beach Wilkie Ferguson Federal Building Design/Build IRS 3rd & 9th Floor Renovation Ft Lauderdale Judge Ray Federal Courtroom Renovation, Miami Design/Build Renovation Break Room & Training Area Palm Beach International Airport West Palm Beach Wilkie Federal Courthouse, Fitness Center Miami FL - $ 2.2M FL $ 2.3 M Various $56.0 K FL $ 2.3 M FL $59.0 K MD $19.0 M FL $ 4.0 M $343K $1.3M $328K $338K FL $ 4.0 M $1 M $970K FL $18.0 M FL $ 2.0 M FL $ 1.9 M New Garage $167.0 K FL $ 1.2 M FL $400.0 K FL $190.0 K FL $340.0 K 03

6 LEED - Hyperpower Maintenance Facilities P3 Group Bernard Paul-Hus $1,811,135 BUILDING TYPE: Commerical - LEED Project Description: This facility was built in the City of Pompano Beach and is the First LEED certified project for the city. This brand new 11,900 SF Facility was built on a 4.5 acre site and is the new Storage and Truck Maintenance yard for HYPOWER. The site will have 125,509 SF of concrete, in lieu of asphalt, 70,000 SF of Green area with native species to limit the use of well water. Two, 2 story, steel buildings were erected, and building 1 has 5,184 watts and building 2 has 5,390 watts dedicated to solar energy (PV) systems while the remaining portion of the roof is finished with a high SRI painting which will limit heat absorption. When you take into account all of the building integrated PV systems, energy efficient lighting, daylight harvesting technology, & high SEER HVAC units; these buildings have significantly reduced their annual power bill as compared to a similar non-leed building. Building 1 has offset its energy use by 55% and building 2 is at a remarkable 90% offset. Lebolo Construction has registered this project with the USGBC ( Registration # and We achieved LEED Gold certification on Building #1 the office building and have submitted to achieve a Platinum Certification on Building #2, the fleet maintenance facility. LEED Gold Building One LEED Platinum Pending Building Two 04 Project won 2012 Construction in Excellence Award

7 SCIF Wall Separation project Profile Project Description: Segregation of second floor in Building 501-D from the current 501-D Sensitive Compartmented Information Facility (SCIF) envelope in order to provide access for foreign partner nation personnel. Existing and new walls to receive Radio Frequency Shielding for complete security of foreign country information from all entities. The Department of the Army Lydia Jones (813) $1,394,539 BUILDING TYPE: Federal - Renovation 05

8 Design Build Moisture Intrusion repairs, Improvements, Repairs and Mold Remediation Project Description: Design / Build - Broward County Federal Courtroom Mold Remediation and Renovation: Demolition, Remediation, and Renovation of several rooms and roofing. Demolish existing space, remove carpet, underlayment, repair subfloor, removed ceilings (acoustical and wood), removed Gypsum, installed new walls, new electrical wiring, perimeter walls repairs, new acoustical ceilings, new paint, new wood floors, and new cabinetry. General Services Admin (GSA) Bryan Pyle (954) (813) $2,336,548 BUILDING TYPE: Federal - Design Build Renovation, Remediation 06

9 Moroso Motorsports park Project Description: The uniqueness of this project is due to its history. Palm Beach International Raceway as it was known in the 1960 s was purchased by Dick Moroso from David Rupp in the 1980 s and renamed Moroso Motorsports Park. In 1968 Dick Moroso was known as one of the most successful modified production drag racers on record. The purchase of the property enabled him to establish a drag strip for local fans. Located on over 200 acres of wooded property in northwest Palm Beach County, the Motorsports Park is known for catering to the motorsports enthusiasts hosting more than 850 events annually. Auto racing being the number one spectator sport in the country, events at the park draw an estimated one million people per year, with media coverage impacting several million or more. As a result, the park previously created an economic impact on Palm Beach County and surrounding areas in excess of $25 million. Now the new Palm Beach International Raceway is projected to double that figure. The park s Road Course, Drag Strip and Karting track have brought motorsport enthusiasts from all over the country. To have the opportunity as local General Contractors and subcontractors to give back to the track, their spectators and the surrounding community is a privilege. The enhancement and needed refurbishment of the facility only broadens the scope of activities and bring a needed in fluctuation of tourism and employment to the area. Moroso Investment Group Keith Ennis $12,021,000 BUILDING TYPE Racetrack Renovation 07

10 Design/Build Internal Review Service 3rd and 9th Floor Renovation project Profile Project Description: Design / Build - IRS 3rd and 9th Floor Renovation: Demolish existing space, remove carpet, underlayment, repair sub-floor, removed ceilings (acoustical and wood), removed old benches, installed new flooring, benches, specialty desks, new electrical wiring, perimeter walls repairs, new acoustical ceilings, new paint, new wood floors, new cabinetry, conduit and pull-strings for new A/V system. General Services Admin (GSA) Bryan Pyle (954) $1,287,061 BUILDING TYPE: Federal - Renovation 08

11 Palm Springs Middle School CM for project - cr. klewin Project Description As Construction Manager, CR Klewin, and its M/WBE CM partner, Lebolo Construction, worked closely with the owner and design team during the preconstruction planning phases to assure the project met schedule and budgetary requirements. This project consisted of a 203,000 SF, 1 and 2-story, tilt-wall and steel construction. Phase 1 - partial demolition of existing campus buildings and locating 23 new portables on site and beginning construction of the 3 new buildings. In addition, a temporary covered walk was constructed to provide access to the existing campus from the bus loop. Phases 2 & 3 - electrical and chiller work and the renovation of the kitchen portion in building 2. Phase 4 - demolition of the existing buildings with the exception of the gymnasium that remained in service until the new facility was completed. Phase 5 - demolition of the existing gym and the completion of the playgrounds. Lebolo Construction s Specific Roll on Project as CM Minority Partner. Project Executive, Randall Lebolo and Assistant Superintendent, Ricky Lopez. Under the direct supervision of Klewin s general superintendent, Bill Talbot, Ricky Lopez was responsible for all trade contractor coordination and supervision of their work on the entire site. Mr. Lopez was also lead superintendent for construction of the multipurpose / cafeteria. Additional responsibilities included coordination of all mechancial and electrical systems within the cafeteria School District of Palm Beach County Warren Haan 3300 Forest Hill Blvd West Palm Beach, FL (561) SIZE 203,000SF BUILDING TYPE Education, New Construction and Modernization 09

12 New Fitness Center - Wilkie D. Ferguson courthouse Project Description: Design/Build brand new fitness center. Installed a raised flooring to contain sound for floor below, new bathrooms, new plumbing, new HVAC, new electrical, new walls, new ceilings. General Services Admin (GSA) Bryan Pyle (954) $1,287,061 BUILDING TYPE: Federal - Renovation 10

13 Primary Care Medical Office Project Description This project was an Interior Build out Tenant Improvement for a new 5,200 square feet high end Medical Office in a multi-tenant building in the city of Boynton Beach. Two contiguous spaces were turned into one bigger space by demolishing all interior partitions, demising wall and all interior finishes including any related mechanical, electrical or plumbing work, to leave it a shell ready to accommodate the approved floor plan and receive all finishes. All ceiling, wall and floor finishes as well as the cabinetry and counter tops for the business center, examination rooms, laboratory and in general, for all spaces, were chosen by the owners of the finest quality and of first class materials to satisfy also their fine clientele. Because this is medical facility, HVAC and plumbing systems were the most significant and critical aspect of this project and demanded from the construction team, special attention to details and technical aspects as well as the careful planning of all activities so that every piece of equipment required was installed to meet strict standards and comply with the norms and regulations of the health agencies and authorities having jurisdiction. Previous to any of the interior work started the existing slab had to be cut and all of the concrete removed to allow for the new sanitary system to be installed as per required standards. Cambridge Medical Center Rich Lucibella $354,467 BUILDING TYPE Interior Build-out Healthcare 11

14 Current Emergency Repairs Contractor for SDPBC and Broward County SDPBC Emergency Repairs Hurricane Frances In September 2004, CR Klewin contracted Lebolo Construction Management to make emergency repairs on various schools within Palm Beach County. The scope of work consisted of clearing debris, grading, cleaning, tree bracing clearing roof drains, securing fencing, spraying for mold, securing light fixtures, replacing AC ducts and replacing ceiling tiles. School Names Allamanda ES Barton ES Benoist Farms ES Christa McAuliffe Middle Citrus Cove ES Conniston Community Middle Coral Reef ES Grassy Waters ES Highland ES HL Johnson ES Independence Middle Indian Ridge School Jeaga Middle Jupiter ES Lake Worth Middle New Horizons ES North Palm Beach ES Palm Beach Central High Palm Beach Gardens High Palm Beach Lakes Community Palmetto ES Pleasant City ES Waters Edge ES West Gate ES Westward ES SDPBC Emergency Repairs Hurricane Jeanne In November 2004, CR Klewin contracted Lebolo Construction Management to make emergency repairs on various schools within Palm Beach County. The scope of work consisted of clearing debris, grading, cleaning, tree bracing clearing roof drains, securing fencing, spraying for mold, securing light fixtures, replacing AC ducts and replacing ceiling tiles. School Names Boca Raton Community Cypress Trails Elementary School Equestrian Trails Elementary School Independence Middle School Palm Beach Central High School School District of Palm Beach County and Broward County School District 12

15 Del Mar Village Project Description This project was a complete façade renovation project of a strip mall in Boca Raton that included the complete demolition of the existing façade and structural steel modifications required to build a new three level towers with standing seam metal roof. All columns were reframed and sheeted, foam bands, EIFS system, decorative medallions and stucco were installed throughout. Since this mall was totally functional at the time of the project safety was always a priority that required a 100% commitment from all the subcontractors and parties involved. A full time safety director was always monitoring that all safety measures were put in place and fully observed by all personnel and pedestrians. Wool bright Development Jimmy Freyman $ 1,438,140 BUILDING TYPE Exterior Façade Renovation 13

16 Wachovia Securities Project Description Various Renovations for numerous locations. Work includes, demolition, carpeting / tile, interior build out, painting, ceilings, electrical and HVAC work. Wachovia Securities, Reg. Offices,Miami - Office Renovations Wachovia Securities, Melbourne - Office Renovations Wachovia Securities, Aventura - Office Renovations Wachovia Securities, Coral Gable - Office Renovations Wachovia Securities, Coral Springs - Office Renovations Wachovia Securities, Lantana - Office Renovation Wachovia Securities, Las Olas - Office Renovations Wachovia Securities, PGA - Office Renovations Wachovia Securities, Stuart - Office Renovations Wachovia Securities, Sun City - Office Renovations Wachovia Securities, Vero Beach - Office Renovations & Emergency Repairs Wells Far Corp.Properties Brad Divins $ 2,251,000 BUILDING TYPE Renovation 14

17 Intracoastal Mall Project Description This project consisted of the complete demolition of the existing façade and breezeway structure of the eastern section of the Intracoastal Mall in North Miami, to make it wider by extending it into the parking area and completely renovate the façade, stucco and bandings, of a two story out parcel, adding a second means of egress to the second floor by adding an exterior metal stair. The complete face lift of both the eastern wing and out parcel included the framing and sheeting, stucco, foam bands, EIFS systems, stone finishes, exposed structural wood beam and columns and decorative aluminum trellis among other finishes enhanced the appearance and gave it a modern look. The renovation of the parking and concrete curbs, new striping and new landscape throughout completed the total renovation process. Wool bright Development Jimmy Freyman $1,240,391 BUILDING TYPE Exterior Façade Renovation 15

18 ROYAL PALM ELEMENTARY SCHOOL PROJECT PROFILE Project Description Partnering with CR Klewin, the team completed approximately 146,00 GSF replacement facility to accommodate 564 K-12 student stations. The replacement facility will be constructed on the current site followed by demolition of the existing facility, construction of playfields and auxiliary facilities. This contract was completed in 3 phases: Phase I consists of the construction of temporary drives, parking and a temporary bus loop. Also included is the permanent construction of the west staff and visitor parking, the parent dropoff, new drainage and retention, sidewalks and covered walk and drop-off Areas. The building construction consists of Building 1 & 2 entirely and approximately 25% of Building 3; the relocation of (2) hard surfaced play areas and associated equipment; the service court and drive; and the new chiller building. Phase II consists of the construction of the remaining area of Building 3, the balance of the west parking and drives, the pre-k drop-off loop and the associated covered walkways. The demolition of the existing school structure, portions of the existing parking and drives and the north area portables. Phase III consists of the construction of the Shade House, the covered PE Building, the permanent playgrounds, play courts, the completion of the east drives, drop-off and parking areas, the balance of the landscaping, irrigation and drainage, and the removal of the remaining modular classrooms. LEBOLO S portion of the project was 15% of the total project. SDPBC Phyllis Karp $33,239,544 BUILDING TYPE Education, New Construction 16