ree XLamp XM-L HVW LEs Product family data sheet L-S rev 0 Product escription The ree XLamp XM-L High Voltage White LE provides the lightingclass performance and reliability of ree XLamp LEs in the standard XM package. The XM-L HVW LE is an order of magnitude smaller than other high-voltage LE arrays, allowing easy implementation of spaceconstrained lighting applications with smaller, more efficient high-voltage drivers. mong these applications are small lamps such as 0, GU0 and E7. FETURES inned at 8 Typical forward voltage of V @ m, with Vf binning available ree-standard XM mechanical footprint, with electrically neutral thermal path Low thermal resistance:. /W Wide viewing angle: Maximum drive current: m Maximum junction temperature: 0 Unlimited floor life at 0 º/8% RH Reflow solderable vailable in standard RI and 80 minimum RI configurations Table of contents Flux haracteristics... haracteristics... Relative Spectral Power istribution... Relative Flux vs. Junction Temperature... Electrical haracteristics... Thermal esign... Relative Flux vs. urrent... Typical Spatial istribution... Reflow Soldering haracteristics... Mechanical imensions... 7 Tape and Reel... 8 Packaging... 9 www. cree.com/xlamp opyright 0 ree, Inc. ll rights reserved. The information in this document is subject to change without notice. ree, the ree logo and XLamp are registered trademarks of ree, Inc. ree, Inc. 00 Silicon rive urham, N 770 US Tel: +.99.07.00
XLamp XM-l HVW LE Flux haracteristics (T J = 8 ) The following table provides several base order codes for XLamp XM-L LEs. It is important to note that the base order codes listed here are a subset of the total available order codes for the product family. For more order codes, as well as a complete description of the order-code nomenclature, please consult the XLamp XM-L inning and Labeling document. olor T Range ase Order odes Min Luminous Flux @ m (lm) Order ode Min. Max. Group Flux (lm) ool White,000 K 8,00 K Neutral White,700 K,000 K Warm White,00 K,700 K T 0 XMLHVW-Q0-0000-0000LT T 0 XMLHVW-Q0-0000-0000LT S 8 XMLHVW-Q0-0000-0000LSE T 00 XMLHVW-Q0-0000-0000LTE S XMLHVW-Q0-0000-0000LSE7 S 7 XMLHVW-Q0-0000-0000LSE7 Notes: ree maintains a tolerance of ± 7% on flux and power measurements and ± on RI measurements. Typical RI for ool White (,000 K 8,00 K T) is 8. Typical RI for Neutral White (,700 K,000 K T) is 7. Typical RI for Warm White (,00 K,700 K T) is 8. haracteristics haracteristics Unit Minimum Typical Maximum Thermal Resistance, junction to solder point /W. Viewing ngle (FWHM) degrees Temperature coefficient of voltage mv/ - ES lassification (HM per Mil-Std-88) lass Forward urrent m Reverse urrent m 0. Forward voltage (@ m, 8 ) V LE Junction Temperature 0 opyright 0 ree, Inc. ll rights reserved. The information in this document is subject to change without notice. ree, the ree logo and XLamp are registered trademarks of ree, Inc.
XLamp XM-l HVW LE Relative Spectral Power Relative Spectral Power istribution 00 Relative Radiant Power (%) 80 0 0 0 000K - 800K T 00K - 700K T 0 00 0 00 0 00 0 700 70 Wavelength (nm) Relative Flux Output vs. Junction Temperature Relative Flux vs. Junction Temperature (I F = m) 0% Relative Luminous Flux 00% 80% 0% 0% 0% 0% 0 7 00 0 Junction Temperature (º) opyright 0 ree, Inc. ll rights reserved. The information in this document is subject to change without notice. ree, the ree logo and XLamp are registered trademarks of ree, Inc.
XLamp XM-l HVW LE Electrical Electrical haracteristics haracteristics (Tj = 8º) (T J = 8 ) 0 0 Forward urrent (m) 00 80 0 0 0 0 0.00.00.00.00 8.00 0.00.00 Forward Voltage (V) Thermal esign Thermal esign 0 0 Maximum urrent (m) 00 80 0 0 0 0 Rj-a = 0 /W Rj-a = /W Rj-a = 0 /W Rj-a = /W 0 0 0 0 80 00 0 0 mbient Temperature (º) opyright 0 ree, Inc. ll rights reserved. The information in this document is subject to change without notice. ree, the ree logo and XLamp are registered trademarks of ree, Inc.
XLamp XM-l HVW LE Relative Intensity vs. urrent (Tj = 8º) Relative Flux vs. urrent (T J = 8 ) 0% Relative Luminous Flux (%) 00% 0% 00% 0% 0% 0 0 7 00 Forward urrent (m) Typical Spatial Radiation Pattern Typical Spatial istribution 0 Relative Luminous Intensity (%) 00 80 0 0 0 0-00 -80-0 -0-0 0 0 0 0 80 00 ngle (º) opyright 0 ree, Inc. ll rights reserved. The information in this document is subject to change without notice. ree, the ree logo and XLamp are registered trademarks of ree, Inc.
XLamp XM-l HVW LE Reflow Soldering haracteristics In testing, ree has found XLamp XM-L LEs to be compatible with JEE J-ST-00, using the parameters listed below. s a general guideline, ree recommends that users follow the recommended soldering profile provided by the manufacturer of the solder paste used. Note that this general guideline may not apply to all P designs and configurations of reflow-soldering equipment. Profile feature Lead-based solder Lead-free solder verage ramp-up rate (Ts MX to Tp) /second max /second max Preheat: Temperature min (Ts MIN ) 00 0 Preheat: Temperature max (Ts MX ) 0 00 Preheat: Time (ts MIN to ts MX ) 0-0 seconds 0-80 seconds Time maintained above: temperature (TL) 8 7 Time maintained above: time (tl) 0-0 seconds 0-0 seconds Peak/classification temperature (Tp) 0 Time within of actual peak temperature (tp) 0-0 seconds 0-0 seconds Ramp-down rate /second max /second max Time to peak temperature minutes max 8 minutes max Note: ll temperatures refer to topside of the package, measured on the package body surface. opyright 0 ree, Inc. ll rights reserved. The information in this document is subject to change without notice. ree, the ree logo and XLamp are registered trademarks of ree, Inc.
XLamp XM-l HVW LE Mechanical imensions NOTIE REE ONFIENTIL. THIS PLOT N THE INFORMTION ONTINE WITHIN RE THE PROPRIETRY N ONFIENTIL INFORMTION OF REE, IN. THIS PLOT MY NOT E OPIE, REPROUE OR ISLOSE TO NY UNUTHORIZE PERSON WITHOUT THE WRITTEN ONSENT NOTIE OF REE REE ONFIENTIL. IN. THIS PLOT N THE INFORMTION ONTINE NOTIE WITHIN RE THE PROPRIETRY N REE ONFIENTIL. THIS INFORMTION PLOT N THE OF REE, INFORMTION IN. THIS PLOT ONTINE MY WITHIN NOT E RE OPIE, THE PROPRIETRY REPROUE N OR ISLOSE TO NY ONFIENTIL UNUTHORIZE INFORMTION PERSON OF REE, WITHOUT IN. THE THIS WRITTEN PLOT ONSENT MY NOT OF E REE OPIE, IN. REPROUE OR ISLOSE TO NY UNUTHORIZE PERSON WITHOUT THE WRITTEN ONSENT OF REE IN..000.000.000.0.0.0 REVISONS REV ESRIPTION Y PP' ll measurements are ±. mm unless otherwise indicated..7.0.7.0.7.0.78 REVISONS REV ESRIPTION REVISONS Y PP' REV ESRIPTION Y PP'.78.78.78.78.78.000.78.000.000.78.78.8.8.00.8.8.8.8.00.00.00.00.00.7.9.7.9.7.9.00.8.00.7.00.00.8.8.00.00.7.7.00.78.00.00.00.78 REOMMENE.00.78 P SOLER P.00.00.00.00 RWN Y UNLESS OTHERWISE SPEIFIE REOMMENE STENIL PTTERN 00 Silicon rive IMENSIONS RE IN. RONIN 08// urham, N. 770.00 HEK.00 SHE RE IS OPEN MILLIMETERS N FTER FINISH. Phone (99) -00 TOLERNE UNLESS SPEIFIE: Fax (99) -8.00.XX ±. PPROVE RWN Y UNLESS OTHERWISE.XXX ±. SPEIFIE REOMMENE STENIL PTTERN 00 Silicon rive IMENSIONS RE IN. RONIN 08// THIR NGLE PROJETION RWN Y urham, N. 770 MTERIL HEK SHE RE IS OPEN UNLESS OTHERWISE MILLIMETERS OUTLINE RWING, 00 XML FOR SHEET SPEIFIE METL N FTER PRTS FINISH. ONLY Phone (99) -0 REOMMENE P SOLER P REOMMENE STENIL PTTERN 00 Silicon rive IMENSIONS TOLERNE RE.X IN UNLESS ±. SPEIFIE:. RONIN 08// urham, N. 770 Fax (99) -8 RWING NO. R.XX.XX ±.7.HEK SHE RE IS OPEN MILLIMETERS N FTER FINISH. PPROVE Phone (99) -00 TOLERNE UNLESS.XXX SPEIFIE:.XXX ±.. FINL PROTETIVE FINISH 0-0008 X X ±.. Fax (99) -8.XX ±. PPROVE THIR NGLE PROJETION MTERIL OUTLINE RWING, 00 XML.XXX FOR SLE SHEET OF SURFE SHEET ±. FINISH: METL PRTS. ONLY.000 THIR NGLE PROJETION.X ±. MTERIL RWING NO. R.XX ±.7 OUTLINE RWING, 00 XML HV FOR SHEET METL PRTS ONLY.X ±.XXX. ±. FINL PROTETIVE FINISH 0-0008 RWING NO..XX ±.7 SLE.XXX SHEET OF SURFE ±. FINISH:.FINL PROTETIVE FINISH.000 0-0008 SLE SHEET OF SURFE FINISH:..000 / REOMMENE P SOLER P opyright 0 ree, Inc. ll rights reserved. The information in this document is subject to change without notice. ree, the ree logo and XLamp are registered trademarks of ree, Inc. 7
NOTIE REVISIONS REE ONFIENTIL. THIS PLOT N THE INFORMTION ONTINE WITHIN RE THE PROPRIETRY N ONFIENTIL INFORMTION OF REE, IN. THIS PLOT Y NOT E OPIE, REPROUE OR ISLOSE TO NY NUTHORIZE PERSON WITHOUT THE WRITTEN ONSENT F REE IN..00[.079] P.00[.7] Po o.0 +.0 +.009.09 -.00 -.0000 [ ].7[.09] E REV ESRIPTION POKET o -.0mm [."] o -.0mm [."] Ko -.mm [."] Y PP' XLamp XM-l HVW LE Tape and Reel NOTIE NOMINL ll ree carrier tapes conform to REE ONFIENTIL. EI-8, THIS PLOT NOTIE N THE utomated INFORMTION omponent Handling Systems Standard. 8.00[.] P.0[.7]F ONTINE REE ONFIENTIL. WITHIN RE THE THIS PROPRIETRY PLOT N THE NINFORMTION ONFIENTIL ONTINE INFORMTION WITHIN RE OF THE REE, PROPRIETRY N 0..0 IN. THIS [.8] PLOT MY NOT ONFIENTIL E OPIE, INFORMTION REPROUE OF OR REE, ISLOSE IN. THIS TO PLOT NY UNUTHORIZE MY NOT E PERSON OPIE, [.0] WITHOUT REPROUE THE WRITTEN OR MX ISLOSE ONSENT TO NY OF REE UNUTHORIZE IN. PERSON WITHOUT THE WRITTEN ONSENT OF REE IN. W E.00[.7].00[.079].00[.079] P P.0[.09].00[.7].00[.7] Po Po.0.0[.] o o.0 +.0 o.0 +.0 +.009.09 -.00 +.009.09 -.0000 [ ] -.00 -.0000 [ ].[.0] T.7[.09] E.7[.09] E REV REV REVISIONS REVISIONS ESRIPTION ESRIPTION PP' POKET POKET o o - ll -.0mm dimensions.0mm [."] [."] in mm. o o - -.0mm.0mm [."] [."] Ko Ko - -.mm.mm [."] [."] Y Y PP' NOTIE IL. THIS PLOT N THE INFORMTION IN RE THE PROPRIETRY N FORMTION OF REE, IN. THIS PLOT IE, REPROUE OR ISLOSE TO NY ERSON WITHOUT THE WRITTEN ONSENT.0[.] o 7.0.[.] Ko THIR NGLE PROJETION.0.0[.].0.0[.] o o.00[.7].0[.7]f NOMINL.00[.7].0[.7]F NOMINL REVISONS 0..0 [.8] REV 0. ESRIPTION.0 [.8] Y PP' [.0] MX Loaded [.0] pocket count MX E W was 70 S /8/0 S E W REE REFERENE RWING FOR TEK-PK RWING 087 UNLESS OTHERWISE SPEIFIE IMENSIONS RE IN INHES N FTER FINISH. TOLERNE UNLESS SPEIFIE:.XX ±.0.XXX ±.00 FOR SHEET METL PRTS ONLY RWN Y. RONIN HEK PPROVE MTERIL //0 8.00[.] 8.00[.] P P 00 Silicon rive urham, N. 770.0[.09].0[.09] Phone (99) -00 Fax (99) -8 XM 00 RRIER TPE.X ±.0 RWING NO..XX ±.0 FINL PROTETIVE FINISH.XXX ±.00 0-000 SLE SHEET OF SURFE FINISH: 7.0 RWING SLE 7.0 / User Feed irection.[.0] T.[.0] T EN NOTIE REE ONFIENTIL. THIS PLOT N THE INFORMTION ONTNE WITHIN RE THE PROPRIETRY N ONFIENTIL INFORMTION OF REE, IN. THIS PLOT MY NOT E OPIE, REPROUE OR ISLOSE TO NY UNUTHORIZE PERSON WITHOUT THE WRITTEN ONSENT OF REE IN. Trailer 0mm (min) of empty pockets sealed with tape ( pockets min.) 8.[.].7. THOE SIE.[.] STRT Ko Ko REE REFERENE RWING FOR TEK-PK 00-00009 RWING 087.0[.] REE REFERENE RWING FOR TEK-PK RWING 087 INEX QTY ITEM OMMENTS.0[.] o RWN Y UNLESS OTHERWISE SPEIFIE o. RONIN RWN 00-00009-ORE Y //0 00 Silicon rive IMENSIONS UNLESS RE OTHERWISE IN INHES SPEIFIE. 00-00009-REEL RONIN //0 urham, 00 N. Silicon 770rive N IMENSIONS FTER FINISH. RE IN INHESHEK Phone (99) urham, -00 N. 770 HEK TOLERNE N UNLESS FTER SPEIFIE: FINISH. Fax (99) Phone -8 (99) -00 TOLERNE.XX ± UNLESS.0 SPEIFIE: PPROVE Fax (99) -8.XX ±.0.XXX ±.00 PPROVE NOE SIE X ±.XXX. ±.00 THIR NGLE PROJETION MTERIL THIR NGLE PROJETIONFOR SHEET METL PRTS ONLY XM MTERIL FOR SHEET METL PRTS ONLY XM 00 00 RRIER RRIER TPE TPE Loaded Pockets Leader.X ±.0 RWING NO..XX.X ± ±.0.0 (000 Lamps) 00mm (min.) of RWING NO..XX ±.0 FINL PROTETIVE FINISH.XXX ±.00 FINL PROTETIVE FINISH empty pockets with 0-000 X ±.XXX. ±.00 0-000 SLE SHEET OF at least 00mm SURFE FINISH: RWING SLE SHEET OF/ SURFE FINISH: sealed by tape RWING SLE / (0 empty pockets min.). +..0 MESURE T HU 0 +. -.7 THIR NGLE PROJETION UNLESS OTHERWISE SPEIFIE IMENSIONS RE IN MILLIMETERS N FTER FINISH. TOLERNE UNLESS SPEIFIE:.XX ±..XXX ±. FOR SHEET METL PRTS ONLY. +0..0 MESURE T HU.X ±. FINISH.XX ±.7.XXX ±. SURFE FINISH:..000 RWN Y. RONIN HEK PPROVE MTERIL 0/08/0. ±..9±. 0-000 00 Silicon rive urham, N. 770 Phone (99) -00 Fax (99) -8 XM LOING SPE SHEET OF / ±.. +.0 -. MESURE T EGE 0 0 REVISONS REV ESRIPTION Y PP' RWN Y UNLESS OTHERWISE SPEIFIE IMENSIONS RE IN INHES. RONIN 09/9/09 urham, N. 770 opyright 0 ree, Inc. ll rights reserved. The information in this document is subject to change without notice. N ree, FTER FINISH. HEK the ree logo and XLamp are registered Phone (99) -00 TOLERNE UNLESS SPEIFIE: Fax (99) -8 trademarks of ree, Inc..XX ±.0 PPROVE 8.XXX ±.00 THIR NGLE PROJETION MTERIL FOR SHEET METL PRTS ONLY.X ±.0.XX ±.0.XXX ±.00 FINL PROTETIVE FINISH NTI-STTI HIPS RWING NO. 00-00009 00 Silicon rive REEL, " X MM, PIEE SNP
Packaging Humidity Humidity Indicator Indicator ard (inside (inside bag) bag) XLamp XM-l HVW LE essicant esiccant (inside bag) bag) Vacuum-Sealed Moisture Vacuum-Sealed arrier ag Moisture arrier ag Vacuum-Sealed Moisture Vacuum-Sealed arrier ag Moisture arrier ag REE Label in with ode ree in & ode, arcode Qty, Label Lot # REE Label in with oderee in & ode, arcode Qty, Label Lot # Label with with ustomer ree in ode, P/N, Qty, Qty, Lot #, Lot PO # Label with with ustomer ree in ode, P/N, Qty, Qty, Lot #, Lot PO ## Patent Label Patent Label Label with ustomer Order ode, Qty, Reel I, PO # Label with ustomer Order ode, Qty, Reel I, PO # Label with ustomer Order ode, Qty, Reel I, PO# Label with ree in ode, Qty, Lot # opyright 0 ree, Inc. ll rights reserved. The information in this document is subject to change without notice. ree, the ree logo and XLamp are registered trademarks of ree, Inc. 9