GLAZING RUBBERS. AGS Commercial and Residential Products

GLAZING RUBBERS AGS Commercial and Residential Products

We have pleasure in presenting to you the new Capral Glazing Rubber catalogue. This catalogue is designed to simplify the selection and ordering of Capral glazing rubbers for use in Capral proprietary window, door and glazing systems. Glazing rubbers, wedges, channels and seals form an integral part of the engineered window, door and glazing systems designed and developed by Capral. To ensure Capral products perform as intended and to allow reliance on Capral s technical and test report data, it is imperative that only extrusions, components and glazing rubbers supplied by Capral are used in fabrication of Capral proprietary systems. In particular, glazing rubbers and seals are instrumental to achieving required wind, water and air infiltration performance of Capral systems. Material composition, dimensional tolerances, UV stabilisation, hardness and surface finish can all significantly effect the initial and long term performance of both the glazing rubber and the system. Whilst a number of generic alternatives may be available on the market, such products are not tested or endorsed by Capral and are not subject to Capral s warranties with respect to product performance. Extensive testing has proven that products which may be more pliable or easier to use in fabrication may not achieve the required pressure and sealing characteristics required to meet Australian performance standards. Capral has witnessed a number of product failures where use of non-genuine glazing rubbers have caused substantial damage to buildings and required significant rectification works to remedy. When using genuine Capral glazing rubbers you can be assured that the products being used have been specifically designed to perform in their intended application and are supported by Capral s technical and test report data to meet required specifications.

Contents Introduction ==================================================================================== 2 300 Narrowline =============================================================================== 3 400 Narrowline =============================================================================== 4 425 Narrowline =============================================================================== 5 406 St Lucia ===================================================================================== 6 419 Flushline =================================================================================== 7 600 Narrowline =============================================================================== 8 601 Narrowline =============================================================================== 9 625 Narrowline ============================================================================= 10 200 Hinge Door ============================================================================= 11 275 Hinge Door ============================================================================= 12 Artisan Folding Door ====================================================================13 889 Sliding Door =========================================================================== 14 900 Sliding Door =========================================================================== 15 950 Sliding Window ====================================================================== 16 35 Awning Window ====================================================================== 17 50 Awning Window ====================================================================== 18 Euro Window ================================================================================ 19 580 / 480 Sliding Window ============================================================== 20 581/ 481 Double Hung Window ==================================================== 21 582 Awning Window ==================================================================== 22 585 Sliding Door =========================================================================== 23 Miscellaneous ===============================================================================24 Glazing Rubber Tables ================================================================== 25 1

Capral has a long and valued tradition of supplying aluminium extrusion and associated hardware into the Australian Window and Door industry. With our product expertise and strategic partnerships, Capral can offer a wide range of hardware optimised for our market leading products at competitive prices. We are pleased to be able to present our current range of glazing rubbers to suit our Commercial products. While we have endeavoured to make this catalogue as accurate as possible, we reserve the right to make changes to our product range at any time. If you have any questions about any of our glazing products, please contact your Account Manager to discuss in more detail. Introduction Glazing methods A summary of different glazing methods are described below. The methods of glazing described in this manual are specifically for vertical glazing. Selection of materials for sloped glazing can be more critical and we recommend that advice be sought from the supplier of glazing materials. The exact glazing pocket geometry and recommended system for each individual product is shown in its own Technical Data manual. Pocketed Dry Glazed This method is typically used on shopfronts and flush glazed doors. One bead per opening usually at the sill. It is neat, clean to execute and easily re-glazed. Carefully installed, this system is designed to be weatherproof at high Pascal ratings. Rebate and Snap On Bead This method is more versatile than above and allows more tolerance on glass cutting sizes. It has the highest performance potential. Typically butyl or foam tape is used on the fin and a roll-in wedge with bead. Optional heel bead can be specified to further enhance waterproofing capability. Front Glazed Plant-on Cover This method allows glass to be located close to the front of the facade. Screw-on or snap-on covers secure the glass. The same materials as are used for rebate/bead glazing apply. Wrap-around Channel Gasket This method is traditionally used for residential windows and sliding doors. Frames must be assembled around the glass, therefore re-glazing requires panels to be removed and dis-assembled. 2

300 Narrowline Frame Pocket Size - 16mm 315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200 315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100 300001 M027101 400/300 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400/300 Glazing Wedge 5mm Gap PVC 200 300003 M027103 400/300 Glazing Wedge 7mm Gap PVC 100 300004 M027104 400 Glazing Wedge 8mm Gap PVC 100 300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100 300021 M027214 Duoseal Door stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm Gap SC 100 300023 M027216 Duoseal Door Stop 7mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 302444 M027456 Door Stop Accoustic Seal SC 305 300043 M027359 Expansion Joint Seal PVC 200 300841 M027403 Bulb Seal Small PVC 250m Roll PVC 250 300017 M027206 Wool Pile 6.9 x 6.25 PILE 350 3

400 Narrowline Frame Pocket Size - 16mm 315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200 315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100 300001 M027101 400 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400 Glazing Wedge 5mm Gap PVC 200 300003 M027103 400 Glazing Wedge 7mm Gap PVC 100 300004 M027104 400 Glazing Wedge 8mm Gap PVC 100 300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100 300021 M027214 Duoseal Door Stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm Gap SC 100 300023 M027216 Duoseal Door Stop 7mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 300841 M027403 Bulb Seal Small PVC 250 302444 M027456 Door Stop Accoustic Seal SC 305 300043 M027359 Expansion Joint Seal PVC 200 300017 M027206 Wool Pile 6.9 x 6.25 PILE 350 4

425 Narrowline Frame Pocket Size - 35mm 315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200 315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100 300001 M027101 400/425 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400/425 Glazing Wedge 5mm Gap PVC 200 300003 M027103 400/425 Glazing Wedge 7mm Gap PVC 100 300004 M027104 400/425 Glazing Wedge 8mm Gap PVC 100 300005 M027105 400/425 Glazing Wedge 9.5mm Gap PVC 100 300021 M027214 Duoseal Door Stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm Gap SC 100 300023 M027216 Duoseal Door Stop 7mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 300841 M027403 Bulb Seal Small PVC 250 302444 M027456 Door Stop Accoustic Seal SC 305 300043 M027359 Expansion Joint Seal PVC 200 300017 M027206 Wool Pile 6.9 x 6.25 PILE 350 5

406 St Lucia Frame Pocket Size - 16-35mm 300008 M027121 Captive Wedge 3mm Gap PVC 100 300009 M027122 Captive Wedge 5mm Gap PVC 100 300021 M027214 Duoseal Door Stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm Gap SC 100 300023 M027216 Duoseal Door Stop 7mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 300841 M027403 Bulb Seal Small PVC 250 302444 M027456 Door Stop Accoustic Seal SC 305 300043 M027359 Expansion Joint Seal PVC 200 300017 M027206 Wool Pile 6.9 x 6.25 PILE 350 6

419 Flushline Frame Pocket Size - 21-38mm 300616 M027116 Captive Wedge 4.5mm Gap SA 100 300007 M027120 419 Captive Wedge 6.5mm Gap SA 100 300010 M027131 Captive Wedge 7.5mm Gap SA 50 315790 MSC6 Co-extruded Captive Wedge 3mm Gap SC 100 315789 MSC33 Co-extruded Captive Wedge 5mm Gap SC 100 301232 M027129 Glazing Wedge 4.5mm Gap SA 100 300006 M027119 Glazing Wedge 6.5mm Gap SA 100 300011 M027132 Glazing Wedge 7.5mm Gap SA 100 300021 M027214 Duoseal Door Stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm Gap SC 100 300023 M027216 Duoseal Door Stop 7mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 300841 M027400 Bulb Seal Small PVC 250 302444 M027456 Door Stop Accoustic Seal SC 305 300043 M027359 Expansion Joint Seal PVC 200 300017 M027206 Wool Pile 6.9 x 6.25 PILE 350 SA = Santoprene 7

600 Narrowline Frame Pocket Size - 20mm 315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200 315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100 300001 M027101 400/600 Glazing Wedge 3mm PVC 100 300013 M027142 400/600 Glazing Wedge 5mm Gap PVC 200 300003 M027103 400/600 Glazing Wedge 7mm PVC 100 300004 M027104 400/600 Glazing Wedge 8mm Gap PVC 100 300005 M027105 400/600 Glazing Wedge 9.5mm Gap PVC 100 300021 M027214 Duoseal Door Stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm Gap SC 100 300023 M027216 Duoseal Door Stop 7mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 300841 M027403 Bulb Seal Small PVC 250 302444 302444 Door Stop Accoustic Seal SC 305 300043 M027359 Expansion Joint Seal PVC 200 300017 M027200 Wool Pile 6.9 x 6.25 PILE 350 8

601 Narrowline Frame Pocket Size - 16mm 315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200 315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100 300001 M027101 400/601 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400/601 Glazing Wedge 5mm Gap PVC 200 300003 M027103 400/601 Glazing Wedge7mm Gap PVC 100 300021 M027214 Duoseal Door Stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm GAP SC 100 300023 M027216 Duoseal Door Stop 7mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 300841 M027403 Bulb Seal Small PVC 250 302444 M027456 Door Stop Accoustic Seal SC 305 300043 M027359 Expansion Joint Seal PVC 200 300017 M027206 Wool Pile 6.9 x 6.25 PILE 350 9

625 Narrowline Frame Pocket Size - 35mm 315787 MSC34 Co-extruded Captive Wedge 3mm Gap SC 200 315788 MSC28 Co-extruded Captive Wedge 5mm Gap SC 100 300001 M027101 400/625 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400/625 Glazing Wedge 5mm Gap PVC 200 300003 M027103 400/625 Glazing Wedge 7mm Gap PVC 100 300004 M027104 625/580 Glazing Wedge 8mm Gap PVC 100 300005 M027105 625/580 Glazing Wedge 9.5mm Gap PVC 100 302444 M027456 Door Stop Accoustic Seal Schlegel PVC 305 300021 M027214 Duoseal Door Stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm Gap SC 100 300023 M027216 Duoseal Door Stop 7mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 300841 M027403 Bulb Seal Small PVC 250 300043 M027359 Expansion Joint Seal PVC 200 300017 M027206 Wool Pile 6.9 x 6.25 PILE 350 10

200 Hinge Door Frame Pocket Size - 16-35mm 300001 M027101 400/200 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400/200 Glazing Wedge 5mm Gap PVC 200 300003 M027103 400/200 Glazing Wedge 7mm Gap PVC 100 300021 M027214 Duoseal Door Stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm Gap SC 100 300023 M027216 Duoseal Door Stop 7mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 302444 M027456 Door Stop Accoustic Seal SC 305 300043 M027359 Expansion Joint Seal PVC 200 300045 M027378 Wool Pile 13mm PILE 500 300017 M027206 Wool Pile 6.9 x 6.25 PILE 350 11

275 Hinge Door Frame Pocket Size - 16mm 300001 M027101 400/275 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400/275 Glazing Wedge 5mm Gap PVC 200 300021 M027214 Duoseal Door Stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm Gap SC 100 300023 M027216 Duoseal Door Stop 7mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 302444 M027456 Door Stop Accoustic Seal SC 305 300043 M027359 Expansion Joint Seal PVC 200 300045 M027378 Wool Pile 13mm PILE 500 300017 M027206 Wool Pile 6.9 x 6.25 PILE 350 12

Artisan Folding Door Frame Pocket Size - 16-35mm 300001 M027101 400 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400 Glazing Wedge 5mm Gap PVC 200 300004 M027104 580 Glazing Wedge 8mm Gap PVC 100 300005 M027105 580 Glazing Wedge 9.5mm Gap PVC 100 306867 SPD00701A Push In Buffer Seal 3mm PVC 250 302271 M027834 Ags Buffer Seal Black SC 250 306907 SPD00565B Push in buffer seal 4mm PVC 250 302273 M027836 Ags Kerf Seal Aq21 PVC 250 302274 M027837 Ags Kerf Seal Aq63 300 301296 M027239 PVC fin pressure seal PVC 400 300743 M027171 136 Inset Sash Wiper Seal PVC 50 300045 M027378 Wool Pile 13mm PILE 500 301409 M027379 Wool Pile 16mm PILE 500 301865 M027377 Wool Pile 11mm PILE 600 302272 M027835 Fin-Seal Ags High 4.8 x 8.5 Black PILE 300 13

889 Sliding Door Panel Pocket Size - 12-30mm 300030 M027241 889/950 Glazing Channel 5/6mm PVC 100 300034 M027255 889 Glazing Channel 6.5mm PVC 100 300038 M027266 889 Glazing Channel 8.38mm PVC 100 300039 M027268 889 Glazing Channel 10.38mm PVC 100 300824 M027461 889 Glazing Channel 18mm PVC 50 301263 M027462 889 Glazing Channel 25mm PVC 50 300018 M027207 Fin-Seal 6.9 x 5.25 PILE 400 300033 M027248 Fin-Seal 4.8 x 4.75 PILE 500 14

900 Sliding Door Panel Pocket Size - 14-30mm 306905 SPD00561B Backing Gasket 4.0mm PVC 300 306908 SPD00543A Backing Gasket 1.2mm PVC 300 308212 SPD02781A 6mm Gl. Channel 14mm Pocket PVC 100 308213 SPD02782A 8mm Gl. Channel 14mm Pocket PVC 100 308214 SPD02783A 10mm Gl. Channel 14mm Pocket PVC 100 306910 SPD00550A-3mm Co-Extruded Wedge 3.0mm SC 250 306911 SPD00550A-3.5mm Co-Extruded Wedge 3.5mm SC 200 306912 SPD00550A-4mm Co-Extruded Wedge 4.0mm SC 200 306913 SPD00550A-4.5mm Co-Extruded Wedge 4.5mm SC 200 306914 SPD00550A-5mm Co-Extruded Wedge 5.0mm SC 200 306915 SPD00550A-5.5mm Co-Extruded Wedge 5.5mm SC 150 306916 SPD00550A-6mm Co-Extruded Wedge 6.0mm SC 150 306909 SPD00550A-7mm Co-Extruded Wedge 7mm SC 120 314416 SPD02777A Co-Extruded Fin Seal SC 300 300841 M027403 Bulb Seal Small PVC 250 301866 M027430 Wool Pile 4.8 x 4.75 PILE 500 307393 PBF48600-2B Fin-Seal 4.8 x 6.0 PILE 400 15

950 Sliding Window Frame Pocket Size - 12-28mm 300055 M027455 Glazing Channel 4mm PVC 100 300030 M027241 889/950 Glazing Channel 5mm PVC 100 300034 M027255 889/950 Glazing Channel 6.5mm PVC 100 300038 M027266 889/950 Glazing Channel 8.38mm PVC 100 300039 M027268 889/950 Glazing Channel 10.38mm PVC 100 310276 PV043BLACK0230 Glazing Wedge 3mm PVC 230 310278 PV044BLACK0250 Glazing Wedge 4mm PVC 250 309170 G021BLACK0500 Gasket Fixed Panel PVC 500 301408 M027213 Wool Pile 6.9 x 5.25 PILE 450 314769 PB69750-4B Wool Pile 6.9 x 7.5 PILE 300 310801 WP041 Fin-seal 6.9 x 7.5 PILE 300 16

35 Awning Window Frame Pocket Size - 13-23mm. Sash Pocket Size - Refer to Technical Manual 300001 M027101 400/35 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400 Glazing Wedge 5mm Gap PVC 200 300003 M027103 400/35 Glazing Wedge 7mm Gap PVC 100 300004 M027104 580/35 Glazing Wedge 8mm Gap PVC 100 300005 M027105 580/35 Glazing Wedge 9.5mm Gap PVC 100 300021 M027214 Duoseal Door Stop 3mm Gap SC 100 300022 M027215 Duoseal Door Stop 5mm Gap SC 100 300032 M027247 Narrowline Door Stop PVC 100 300041 M027314 35 Sash Bulb Seal 6mm Dia PVC 300 300841 M027403 Bulb Seal Small PVC 250 300743 M027171 136 Sash Wiper Seal PVC 50 300043 M027359 Expansion Joint Seal PVC 200 17

50 Awning Window Sash Pocket Size - Refer to Technical Manual 300001 M027101 400 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400 Glazing Wedge 5mm Gap PVC 200 300003 M027103 400 Glazing Wedge 7mm Gap PVC 100 300004 M027104 400 Glazing Wedge 8mm Gap PVC 100 300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100 300019 M027211 50 Pivot Sash Seal PVC 100 300048 M027410 50 Iinner Sash Chan 5 & 6mm PVC 75 300041 M027314 35 Sash Bulb Seal 6mm Dia PVC 300 300841 M027403 Bulb Seal Small PVC 250 300043 M027359 Expansion Joint Seal PVC 200 18

Euro Window 306908 SPD00543A Backing Gasket 1.2mm PVC 300 306905 SPD00561B Backing Gasket 4.0mm PVC 300 306906 SPD00485 Closing Gasket 3.5mm PVC 150 308261 SPD01544A Euro Open Out Closing Gasket 3m Pk10 SC 30 307041 SPD00861A Euro Suite Dam Gasket PVC 100 306910 SPD00550A-3mm Co-Extruded Wedge 3.0mm SC 250 306911 SPD00550A-3.5mm Co-Extruded Wedge 3.5mm SC 200 306912 SPD00550A-4mm Co-Extruded Wedge 4.0mm PVC 200 306913 SPD00550A-4.5mm Co-Extruded Wedge 4.5mm PVC 200 306914 SPD00550A-5mm Co-Extruded Wedge 5.0mm PVC 200 306915 SPD00550A-5.5mm Co-Extruded Wedge 5.5mm PVC 150 306916 SPD00550A-6mm Co-Extruded Wedge 6.0mm PVC 150 19

580/480 Sliding Window Pocket Size - Refer to Technical Manual 300050 M027424 580 Glazing Channel 4mm PVC 200 300051 M027425 580 Glazing Channel 5mm PVC 200 300052 M027426 580 Glazing Channel 6mm PVC 200 301261 M027274 580/585 Glazing Channel 16mm PVC 100 300610 M027275 580/585 Glazing Channel 18mm PVC 100 300049 M027423 580 Glazing Wedge 3mm PVC 100 310276 PV043 Glazing Wedge 3mm PVC 230 310278 PV044 Glazing Wedge 4mm PVC 250 300003 M027103 400 Glazing Wedge 7mm Gap PVC 100 300004 M027104 400 Glazing Wedge 8mm Gap PVC 100 300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100 300033 M027248 Fin-seal 4.8 x 4.75 PILE 500 300027 M027231 580 Sill Drainage Seal PVC 250 300047 M027409 580 Sill Flap PVC 200 20

581/481 Double Hung Window Pocket Size - Refer to Technical Manual 300026 M027229 581 Glazing Channel 3mm PVC 100 300029 M027235 581 Glazing Channel 4mm PVC 100 300031 M027246 581 Glazing Channel 5/6mm PVC 100 300003 M027103 400 Glazing Wedge 7mm Gap PVC 100 300001 M027101 400 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400 Glazing Wedge 5mm Gap PVC 200 300004 M027104 400 Glazing Wedge 8mm Gap PVC 100 300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100 300033 M027248 Fin-seal 4.8 x 4.75 PILE 500 300041 M027314 35 Sash Bulb Seal 6mm Dia PVC 300 300047 M027409 580 Sill Flap PVC Roll 200m PVC 200 21

582 Awning Window Pocket Size - Refer to Technical Manual 300026 M027229 581 Glazing Channel 3mm PVC 100 300029 M027235 581 Glazing Channel 4mm PVC 100 300031 M027246 581 Glazing Channel 5/6mm PVC 100 301261 M027274 580/585 Glazing Channel 16mm PVC 100 300610 M027275 580/585 Glazing Channel 18mm PVC 100 300001 M027101 400 Glazing Wedge 3mm Gap PVC 100 300013 M027142 400 Glazing Wedge 5mm Gap PVC 200 300003 M027103 400 Glazing Wedge 7mm Gap PVC 100 300004 M027104 400 Glazing Wedge 8mm Gap PVC 100 300005 M027105 400 Glazing Wedge 9.5mm Gap PVC 100 300041 M027314 35 Sash Bulb Seal 6mm Dia PVC 300 22

585 Sliding Door Pocket Size - Refer to Technical Manual 300055 M027455 Glazing Channel 4mm PVC 100 300030 M027241 585/889 Glazing Channel 5/6mm PVC 100 300034 M027255 585/889 Glazing Channel 6.5mm PVC 100 300038 M027266 585/889 Glazing Channel 8.38mm PVC 100 300039 M027268 585/889 Glazing Channel 10.38mm PVC 100 301261 M027274 585 Glazing Channel 16mm PVC 100 300610 M027275 585 Glazing Channel 18mm PVC 100 300033 M027248 Fin-seal 4.8 x 4.75 PILE 500 23

Miscellaneous 300035 M027257 Tape Single Sided 9 x 1.6 TAPE 45.7 300040 M027289 Fin-Seal 4.8 x 5 PILE 500 301295 M027209 Wool Pile 9 x 9 Grey PILE 150 24

Glazing Rubber Tables indicates captive wedge 300 Narrowline - Frame Pocket Size 16mm Glass Size (mm) New Material Old Material New Material Old Material 5 300003 M027103 300013 M027142 6 300013 M027142 300013 M027142 6 300013 M027142 315788 MSC28 8 300001 M027101 300001 M027142 8 315788 MSC28 300013 M027101 10 300001 M027101 300001 M027101 10 300001 M027101 315787 MSC34 400 Narrowline - Frame Pocket Size 16mm Glass Size (mm) New Material Old Material New Material Old Material 5 300003 M027103 300013 M027142 6 300013 M027142 300013 M027142 6 300013 M027142 315788 MSC28 8 300001 M027101 300013 M027142 8 315788 MSC28 300001 M027101 10 300001 M027101 300001 M027101 10 300001 M027101 315787 MSC34 425 Narrowline - Frame Pocket Size 35mm Glass Size (mm) New Material Old Material New Material Old Material 18 300004 M027104 300005 M027105 20 300003 M027103 300004 M027104 22 24 25 26 28 300004 M027104 300013 M027142 300013 M027142 315788 MSC28 300003 M027103 300013 M027142 300003 M027103 315788 MSC28 300013 M027142 300013 M027142 300004 M027104 315788 MSC28 300013 M027142 300013 M027142 300013 M027142 315788 MSC28 300001 M027101 300013 M027142 300001 M027101 315788 MSC28 25

Glazing Rubber Tables indicates captive wedge 419 Flushline (Single Glazed) - Frame Pocket Size 21mm Glass Size (mm) New Material Old Material New Material Old Material 6 300011 M027132 300011 M027132 6 300011 M027132 300010 M027131 8 300006 M027119 300006 M027119 8 300006 M027119 315790 MSC6 10 301232 M027129 300006 M027119 10 301232 M027129 315790 MSC6 12 301232 M027129 301232 M027129 12 301232 M027129 315789 MSC33 419 Flushline (Double Glazed) - Frame Pocket Size 38mm Glass Size (mm) New Material Old Material New Material Old Material 24 300011 M027132 300006 M027132 24 300011 M027132 315790 MSC6 26 300011 M027132 301232 M027129 26 300006 M027119 315790 MSC6 28 300006 M027119 301232 M027129 28 300006 M027119 315789 MSC33 600 Narrowline - Frame Pocket Size 20mm Glass Size (mm) New Material Old Material New Material Old Material 6 300003 M027103 300003 M027103 6 300005 M027105 315788 MSC28 8 300013 M027142 300003 M027103 8 300003 M027103 315788 MSC28 10 300013 M027142 300013 M027142 10 300003 M027103 315787 MSC34 12 300001 M027101 300013 M027142 12 300013 M027142 315787 MSC34 601 Narrowline - Frame Pocket Size 18mm Glass Size (mm) New Material Old Material New Material Old Material 5 300003 M027103 300013 M027142 6 300013 M027142 300013 M027142 6 300003 M027103 315788 MSC28 8 300001 M027101 300013 M027142 8 300001 M027101 315788 MSC28 10 300001 M027101 300001 M027101 10 300001 M027101 315787 MSC34 26

Glazing Rubber Tables indicates captive wedge 625 Narrowline - Frame Pocket Size 35mm Glass Size (mm) New Material Old Material New Material Old Material 18 300004 M027104 300005 M027105 20 300003 M027103 300004 M027104 22 300004 M027104 300013 M027142 300004 M027104 315788 MSC28 300003 M027103 300003 M027142 25 300003 M027103 315788 MSC28 300013 M027142 300013 M027142 300013 M027142 315788 MSC28 26 300013 M027142 300013 M027142 315788 MSC28 300013 M027142 28 300001 M027101 300013 M027142 300001 M027101 315788 MSC28 200 Hinged Door - Frame Pocket Size 16mm, 25mm & 35mm Glass Size (mm) New Material Old Material New Material Old Material 6 300013 M027142 300013 M027142 8 300001 M027101 300013 M027142 10 300001 M027101 300001 M027101 12 300003 M027103 300003 M027103 15 300013 M027142 300013 M027142 20 300001 M027101 300001 M027101 22 300003 M027103 300003 M027103 24 300003 M027103 300013 M027142 25 300001 M027101 300013 M027142 Bead 6-10mm 25mm 35mm EN2258 EU6659 EU6659 EN2288 EK7556 EU6659 275 Hinged Door Glass Size (mm) New Material Old Material New Material Old Material 6 300013 M027142 300013 M027142 8 300001 M027101 300013 M027142 10 300001 M027101 300001 M027101 27

Glazing Rubber Tables indicates captive wedge Artisan Folding Door Glass Size (mm) New Material Old Material New Material Old Material 6 300013 M027142 300013 M027142 8 300001 M027101 300013 M027142 10 300001 M027101 300001 M027101 12 300003 M027103 300003 M027103 15 300013 M027142 300013 M027142 20 300001 M027101 300001 M027101 22 300003 M027103 300003 M027103 24 300003 M027103 300013 M027142 25 300001 M027101 300013 M027142 Bead 6-10mm 25mm 35mm EN2258 EU6659 EU6659 EN2288 EK7556 EU6659 889 Sliding Door Glass Size (mm) New Material Old Material Pocket (mm) 5 300030 M027241 12 6 / 6.38 300034 M027255 12 8.38 300038 M027266 12 10.38 300039 M027268 12 18 300824 M027461 30 25 301263 M027462 30 900 Sliding Door: Channel Glazed Glass Size (mm) New Material Old Material 6 308212 SPD02781A 8 308213 SPD02782A 10 308214 SPD02783A 900 Sliding Door: Wedge Glazed Glass Size (mm) Bead Backing Gasket Wedge 4 306905 306916 5 EPD0222 306905 306914 6 with single glazed 306905 306912 8 stiles & rails 306908 306914 10 306908 306910 10 EPD0223 306905 306916 12 with DG stiles. 306905 306912 12.76 EPD0228 306908 306916 15 with DG rails 306908 306912 19 306905 306909 20 306905 306916 21 EPD0224 306905 306914 22 306905 306912 with double glazed 23 306908 306916 24 stiles & rails 306908 306914 25 306908 306912 26 306908 306910 28

Glazing Rubber Tables indicates captive wedge 950 Sliding Window: Channel Glazed Glass Size (mm) New Material Old Material 4 300055 M027455 5 300030 M027241 6 300034 M027255 8 300038 M027266 10 300039 M027268 Glass Size (mm) Tape Wedge 22 309639 310276 25 309639 310278 35 Awning Window Glass Size (mm) Bead Tape New Material Old Material 3 8 x 5 300005 M027105 4 EL6337 or EL6474 8 x 5 300003 M027103 5 Beads & Bevel Sash 8 x 5 300013 M027142 6 8 x 5 300001 M027101 8 8 x 5 300003 M027103 10 EL9448 8 x 5 300003 M027103 12 8 x 5 300013 M027142 14 8 x 5 300001 M027101 EU8857 16 8 x 5 300004 M027104 20 10 x 7 300013 M027142 EL9447 25 8 x 3 300001 M027101 29

Glazing Rubber Tables indicates captive wedge 50 Awning Window Glass Size (mm) Bead Tape New Material Old Material 5 10 x 6 300013 M027142 EL6574 or EL2082 6 10 x 6 300013 M027142 8 10 x 6 300003 M027103 10 EL6959 10 x 6 300013 M027142 12 10 x 6 300001 M027101 25 EL2081 10 x 6 300013 M027142 32 10 x 6 300005 M027105 35 EL9447 10 x 6 300003 M027103 38 10 x 6 300013 M027142 EURO Window Glass Size (mm) Bead Backing Gasket Wedge 4 306905 306914 5 306905 306912 6 306908 306916 6.38 306908 306915 EPD0028 6.76 306908 306914 8 306908 306912 8.38 306908 306911 8.76 306908 306910 9 306905 306913 10 306908 306916 10.38 306908 306915 10.76 EPD0029 306908 306914 12 306908 306912 12.38 306908 306911 12.76 306908 306910 23 306905 306913 24 306908 306916 24.38 306908 306915 24.76 EPD0037 306908 306914 26 306908 306912 26.38 306908 306911 26.76 306908 306910 30

Glazing Rubber Tables indicates captive wedge 580/480 Sliding Window: Channel Glazed Glass Size (mm) New Material Old Material 3 300049 M027423 4 300050 M027424 5 300051 MO27425 6 300052 M027426 16 301261 M027274 18 300610 M027275 580/480 Sliding Window: Wedge Glazed Glass Size (mm) Gap New Material Old Material Bead 3 9.5 300005 M027105 4 8.5 300004 M027104 4 8.5 300005 M027105 5 7.5 300003 M027103 300247 5 7.5 300004 M027104 6 6.5 300003 M027103 14 6.5 310278 PV044BLACK0250 ED7772 16 4.5 310276 PV043BLACK0230 ED7762 18 6.5 310278 PV044BLACK0250 ED7762 581/481 Double Hung Window Glass Size (mm) New Material Old Material 3 300026 M027229 4 / 5 300029 M027235 6 300031 MO27246 31

Glazing Rubber Tables indicates captive wedge 582 Awning Window: Channel Glazed Glass Size (mm) New Material Old Material 3 300026 M027229 4 300029 M027235 5 / 6 300031 M027246 16 301261 M027274 18 300610 M027275 582 Awning Window: Wedge Glazed Glass Size (mm) New Material Old Material Bead 3 300005 M027105 4 300005 M027105 5 300004 M027104 6 300003 M027103 10 300045 M027104 12 300003 M027103 14 300013 M027142 16 300003 M027103 18 300012 M027142 22 300005 M027105 EL6474 EL6337 EL9448 EU8857 24 300003 M027103 26 300013 M027142 28 300001 M027101 EL9447 585 Sliding Door Glass Size (mm) New Material Old Material 4 300055 MO27455 5 300030 M027241 6 / 6.5 300034 M027255 8.38 300038 M027266 10.38 300069 M027268 16 301261 M027274 18 300610 M027275 32

DISCLAIMER: Whilst best efforts have been made to ensure the details provided in this brochure are accurate and correct at the time of printing, Capral is not responsible for any loss or damage whatsoever arising as a result of any errors contained in this brochure. Interpretation of standards or codes within this brochure are Capral s interpretation of such codes. Responsibility for code compliance remains with the user of this brochure. In some cases product specifications may be varied without notice. You should not act or rely upon any information contained in this brochure without obtaining appropriate professional advice relating to your particular circumstances. To the maximum extent permitted by law, Capral disclaims all liability for loss of damage suffered by anyone who acts or fails to act in reliance on this brochure.

Distribution Centres New South Wales Building C1 1-107 Erskine Park Road Erskine Park NSW 2759 Northern Territory 8 Mataram Street Winnellie NT 0820 Queensland (North) 303 Woolcock Street Garbutt QLD Queensland (South) 71 Ashburn Road Bundamba QLD 4304 South Australia 38 Cavan Road Dry Creek SA 5094 Tasmania 116 Grove Road Glenorchy TAS 7010 Victoria 151 Barry Road Campbellfield VIC 3061 Western Australia 17 Inspiration Drive Wangara WA 6065 Tel. 1300 366 517 www.capral.com.au