Utilisation de la réflectométrie pour fiabiliser les câbles d un système Contact : CEA LIST Mr Josy COHEN Responsable de projet ingénieur chercheur Josy.cohen@cea.fr +33 1 69 08 78 07 www.cea.fr
Cliquez CEA pour experience modifier in cable style diagnosis du titre Our Laboratory : LFIC : Laboratoire Fiabilité et Capteurs Intégrés More than 10 years experience and knowledge in network cable diagnosis CEA policy : To create breakthrought to take advantage and to create new jobs by industrial transfer for French companies CEA. All rights reserved DACLE Division 2
Cliquez pour Ubiquitous modifier le wired style network du titre Modern Car Civil plane Naval 40 200 1200 km 4 1 10 100 1000 10000 400 2500 Fighter Railway FPSO (Floating Production, Storage and Offloading unit) CEA. All rights reserved DACLE Division 3
Cliquez pour Some modifier wire le defects style du : titre NPP Humidité Température Exposition des couches intérieures Isolation : Electrical Tree Conducteur et Contacts: Corrosion Changement de couleur et durcissement Radiation Fentes dans l isolation Effet sur l isolation Rupture de Liaisons Radicaux Libres Liaison des radicaux libre Changement des propriétés du matériel CEA. All rights reserved DACLE Division 5
Cliquez Some pour wire modifier defects le : style Underwater du titre Développement d organismes vivants Développement d anèmones Grappin de bateau de pèche Frottement contre des roches Ancres CEA. All rights reserved DACLE Division 6
Main causes of degradation on electrical wire : Cliquez pour modifier le style du Submarine titre Around more than 100 detected failure for the submarine wire Proportion des causes de défaut entre 1959 et 2006 sur 2162 entrées (Tyco Telecommunications Inc) Causes des défauts jusqu à 200m de profondeur par an (Wood and Carter - IEEE 2008) CEA. All rights reserved DACLE Division 7
Cliquez Some pour wire modifier defects le style : aeronautic du titre Frottement Arc Electrique Ecrasement Rayon de courbure CEA. All rights reserved DACLE Division 8
Main causes of degradation on electrical wire : Cliquez pour modifier le style Aeronautics du titre With open circuit or short circuit, the system are out of order Chafing defect more important than open or short circuit in ratio. With time, Chafing transforms the defect in open or short circuit Wires with its connectors are the main cause of accident CEA. All rights reserved DACLE Division 9
Some consequences about wire failures Cliquez pour modifier le style du titre A plane staying on the ground cost $150.000 by hour (Boeing) TGV delay cost around 750 by minute (SNCF) Swissair flight 111 Fire on board made by short-circuit in electrical wires TWA fligth 800 Explosion made by short-circuit near fuel tank CEA. All rights reserved DACLE Division 10
Visual control Long, tedious Human error Continuity test Cliquez pour modifier le style How du titre to? Straightforward tools No localization Thermography Too slow Open circuit not cover Reflectometry Cost Real time Easy to operate and to integrate CEA. All rights reserved DACLE Division 11
Like a radar! Cliquez pour Reflectometry modifier style : Principle du titre Injection of a probe signal in a wire Probe signal propagation Each wire strangeness leads a reflection of a part of the probe signal energy the reflected signal is analyzed An echo occurs for each wire strangeness Possible defect information is given by the echo shape A defect flight time could be obtain Corresponding to the defect localization (distance) The propagation speed estimation is a key parameter CEA. All rights reserved DACLE Division 12
Cliquez pour Reflectometry modifier style : Principle du titre The reflectometry principle is related to the signal propagation mechanism into a transmission line (TL) S dx ZL Parallel Torsade Coaxial i (x) R dx L dx i ( x dx ) Modeling and characterization of a TL R, L, C, G Model v(x) G dx C dx v ( x dx) based on Telegrapher's equations to figure out how a signal is propagated into a TL we have to look signal distortion phenomenon Attenuation and dispersion x Telegrapher's equations 2 v( x, t) LC 2 x Z c 2 x dx v( x, t) v( x, t) ( LG RC) RG v( x, t) 2 t t R jl G jc 1 V g LC CEA. All rights reserved DACLE Division 13
Amplitude en V Cliquez pour Reflectometry modifier style : Principle du titre Injection Plan Cable end Zc: characteristic impedance S Probe signal Reflected signal ZL 0.5 0.4 0.3 0.2 0.1 0 Onde Incident incidente wave TDR Reflectograms Reflected Onde réfléchie wave Circuit ouvert 150 Ohms 75 Ohms 50 Ohms 25 Ohms Court-circuit Probe signal travelling along a line and returning with a delay equivalent to two times the defect distance d 2 L vg 2-0.1-0.2-0.3-0.4-0.5-0.5 0 0.5 1 1.5 2 2.5 Temps en s x 10-7 2 L Defect (ZL) localization and characterization are obtained directly from the reflectograms analysis in the time domain CEA. All rights reserved DACLE Division 14
Cliquez pour Reflectometry modifier style : Principle du titre Particular cases: ZL = : ΓL =+1, open circuit The amplitude of the reflected signal is similar to the probe signal one ZL = 0 : ΓL = -1, short circuit The amplitude of the reflected signal is the opposite of the probe signal ZL = Zc : ΓL = 0, no reflexion The line is suitable L Z Z L L Z Z c c CEA. All rights reserved DACLE Division 15
Cliquez pour modifier CEA le Breakthrought style du titre Some new technologies developed CEA. All rights reserved DACLE Division 16
Cliquez pour modifier le Long style distance du titre Adaptive correlation for performance enhancement : Sensitivity Railway signalization cable, reel length : 2km Measure Standard correlation Adaptive correlation Amplitude (V) 0.1 0.18 0.59 Localization (m) 2260 2257 2073 Relative error 13% 13 % 3.7 % CEA. All rights reserved DACLE Division 17
Cliquez pour modifier On le line style Diagnosis du titre MCTDR (Multicarrier Time Domain Reflectometry) Probe signal corresponds to a sum of sine curves The probe signal spectrum is controllable by cancelling the desired carried signal Safe diagnosis : Harmless ness EMC Compliance Low sensitivity to SNR MCTDR in TRL > 5 CEA. All rights reserved DACLE Division 18
Cliquez pour modifier Complex style network du titre Distributed-MCTDR V1 S1 S2 V2 S3 V3 The reflectometry distribution is obtained with a weighted mean process allowing a cross-correlation between reflectometers. Multi-sensing strategy allowing to avoid the ambiguity. A specific tool is proposed to facilitate the reflectometer deployment and to simulate the diagnosis strategy CEA. All rights reserved DACLE Division 19
Cliquez pour modifier Technology le style integration du titre Avionic DIAGNOCHIP, a 3 mm2 130nm integrated reflectometer A mixed Analog/Digital IP for real time processing 5cm resolution (4GHz guided wavelength) Railway Solar power CEA. All rights reserved DACLE Division 20
Cliquez pour modifier CEA le Breakthrought style du titre Some new technologies in progress CEA. All rights reserved DACLE Division 22
External source of failure Mechanical stress Assembly errors Cliquez pour Reflectometry modifier le for style soft du defect titre Corrosion, oxidation Effect of environment s Internal source of failure Manufacturing errors Wear-out defect Local hot-spot Wear type Primary signs Detection method Overheating of the wire Bad contact Intermittent short circuit faults Wear zone Change in impedance Local hot spot Electromagnetic Magnetic Interference Electric arc Visual inspection Reflectometry Thermal, Point by point test Reflectometry Visual inspection Reflectometry Short circuit faults Circuit-breaker system Reflectometry Broken insulation Exposed conductor Corrosion Crack, damaged area Loss of the function Fire Loss of signal or data Visual inspection Reflectometry Visual inspection Reflectometry Visual inspection Reflectrometry Humidity Loss of signal or data Reflectometry Wear out and/or Loss of the function Local alteration of R, L, C, G parameters Local alteration of the characteristic impedance Zc Local alteration of the propagation speed ΓL 0 Open defect Soft defect CEA. All rights reserved DACLE Division 23
Amplitude [V] Amplitude [V] Cliquez pour Reflectometry modifier le for style soft du defect titre Injection Plan Localized defect Zd Cable end Zc: characteristic impedance S Probe signal Reflected signal Transmitted signal T 0.5 0.4 0.3 0.2 0.1 2 D Parallel defect Reflected wave by the cable end Short Court-circuit 25 Ohms 50 Ohms 75 Ohms 100 Ohms 125 Ohms Circuit Open circuit ouvert 0.45 0.4 0.35 0.3 0.25 Reflected by the defect Serial defect Reflected wave by the cable end Short Court-circuit 25 Ohms 50 Ohms 75 Ohms 100 Ohms 125 Ohms Circuit Open circuit ouvert 0-0.1-0.2 2 L 0.2 0.15 0.1-0.3 Reflected by the defect -0.4 0 0.5 1 Temps [s] 1.5 2 x 10-7 0.05 0 0 0.5 1 1.5 2 Temps [s] x 10-7 CEA. All rights reserved DACLE Division 24
Cliquez pour modifier Soft defect le style methods du titre CEA. All rights reserved DACLE Division 25
Amplitude Amplitude Amplitude Amplitude Cliquez Soft pour defect modifier detection le style (chafing) du titre One of our advance post processing for soft defect signature amplification 1 0.8 Simulation reflectogramme initial reflectogramme traité 1 0.8 Experimentation reflectogramme initial reflectogramme traité 0.6 0.4 Soft defect 0.6 0.4 Soft defect Cab_224b Twisted pair (5 m) - Shielded - AWG24 0.25mm² Soft defect = sheath + shield (pulled out) 2cm 0.2 0.2 0 0-0.2-0.2-0.4 0 1 2 3 4 5 6 Distance(m) -0.4 0 1 2 3 4 5 6 Distance(m) 1.2 1 0.8 0.6 Open wire End of cable reflectogramme initial reflectogramme traité 1 0.8 0.6 0.4 0.2 Adapted wire End of cable reflectogramme initial reflectogramme traité Coaxial cable RG58CU (3.20 mètres) Soft defect = sheath + shield (pull out) 2cm 0 0.4 0.2 Soft defect -0.2-0.4 Soft defect -0.6 0-0.8-0.2 0 0.5 1 1.5 2 2.5 3 3.5 Distance(m) -1 0 0.5 1 1.5 2 2.5 3 3.5 Distance(m) CEA. All rights reserved DACLE Division 26
Cliquez pour modifier Blind le zone style method du titre CEA. All rights reserved DACLE Division 27
Cliquez Interconnection pour modifier characterization le style du titre Signal injection Cable under test Signal injection Cable connection and junction characterization 30cm 50Ω 87Ω Zc = 75 Ω Coaxial V² = 4,65 Likelihood ratio 0,1% real part 1-2% imaginary part ld = 30 cm To characterize interconnection or connector (database) To diagnosis soft defect in the interconnection CEA. All rights reserved DACLE Division 28
Cliquez pour modifier RLCG extract le style method du titre CEA. All rights reserved DACLE Division 29
Cliquez Cable pour and modifier aging characterization le style du titre Cable characterization by RLCG parameters extraction Coaxial (5 m) Zc = 75 Ω V² = 3,7 Likelihood ratio Aging characterization New Coaxial (9,8 m) Zc = 75 Ω Aged CEA. All rights reserved DACLE Division 30
Cliquez pour modifier CEA le Breakthrought style du titre And for the next future CEA. All rights reserved DACLE Division 31
Cliquez pour modifier CEA le Breakthrought style du titre All these new technologies and know how in LFIC What are the new technologies for the future? Which new application domain? Use a cable like environement sensor (temperature, humidity, ) New application domain : SHM CEA is aware about industrials needs CEA. All rights reserved DACLE Division 32
Merci pour votre attention Centre de Grenoble 17 rue des Martyrs 38054 Grenoble Cedex Centre de Saclay Nano-Innov PC 172 91191 Gif sur Yvette Cedex