Flat Rate Labor Hours Guide
|
|
|
- Avice Cameron
- 7 years ago
- Views:
Transcription
1 Flat Rate Labor Hours Guide Includes MBx10, MVx70, MGk10 and MVs10 Updated Feb 6, 2012 NOTE: BLUE SHADING INDICATES PRODUCTS THAT ARE WARRANTIED FOR 30 DAYS RATHER THAN 90 DAYS. Motovox Motorsports 8844 Hillcrest Road, Kansas City, MO Toll Free: MOTO (6686) Motovox.com 1
2 MBx10 MINI BIKE FLAT RATE LABOR CHART Function Hours Labor BRAKE Adjust brake.25 $15 Replace brake handle assy.25 $15 Replace brake cable.25 $15 Replace brake pads.50 $30 Replace brake caliper.25 $15 Replace brake rotor.50 $30 FUEL Clean carb sediment bowl.25 $15 Replace fuel filter.25 $15 Clean fuel tank.25 $15 Fix leaky fuel cap.25 $15 Replace fuel cap.25 $15 ENGINE Replace engine.50 $30 Clean air filter.25 $15 Replace spark plug.25 $15 Clean & gap spark plug.25 $15 Adjust carb.25 $15 Change oil.25 $15 Replace recoil starter assy..25 $15 Replace muffler.25 $15 Adjust chain.25 $15 Replace chain.25 $15 Lubricate clutch.50 $30 Replace clutch.50 $30 Replace rear sprocket.50 $30 Replace chain tensioner.25 $15 OPERATING CONTROLS Replace fork complete.75 $45 Replace foot peg assy..25 $15 Replace seat.25 $15 Replace number plate.25 $15 Replace handlebars.50 $30 Adjust throttle cable.25 $15 Replace kill switch.25 $15 Replace twist throttle assy..25 $15 Replace hand grips.25 $15 2
3 CHASSIS Replace kickstand.25 $15 Replace front fender.25 $15 Replace rear fender.25 $15 Replace chain guard.25 $15 Replace frame complete 1.50 $90 WHEELS Replace front wheel.50 $30 Replace rear wheel.75 $45 Replace front tire.50 $30 Replace rear tire.75 $45 Replace front wheel bearing.50 $30 Replace rear wheel bearing.75 $45 3
4 MGk10 YOUTH GO-KART FLAT RATE LABOR CHART Function Hours Labor BRAKE Adjust brake.25 $15 Replace brake assembly.25 $15 Replace brake line & bleed.50 $30 Replace brake pads.50 $30 Replace brake rotor.50 $30 Replace brake pedal linkage.25 $15 FUEL Clean carb sediment bowl.25 $15 Replace fuel filter.25 $15 Clean fuel tank.25 $15 Fix leaky fuel cap.25 $15 Replace fuel cap.25 $15 ENGINE Replace engine.50 $30 Clean air filter.25 $15 Replace spark plug.25 $15 Clean & gap spark plug.25 $15 Adjust carb.25 $15 Change oil.25 $15 Replace recoil starter assy..25 $15 Replace muffler.25 $15 Adjust chains.25 $15 Replace chains.25 $15 Lubricate clutch.50 $30 Replace clutch.50 $30 Replace jack shaft assy..50 $30 Replace drive sprocket.50 $30 Replace secondary sprocket.50 $30 OPERATING CONTROLS Adjust steering.50 $30 Replace tie rod.25 $15 Replace center steering link.50 $30 Replace throttle pedal.25 $15 Replace seat.50 $30 Replace cowl assembly.25 $15 Replace steering wheel.25 $15 4
5 Adjust throttle cable.25 $15 Replace kill switch.25 $15 Replace seat belt.25 $15 WHEELS Replace front wheel.50 $30 Replace rear wheel.50 $30 Replace front tire.50 $30 Replace rear tire.50 $30 Replace wheel bearing.50 $30 CHASSIS Replace rear axle.75 $45 Replace rear axle bearing.75 $45 Replace front spindle.25 $15 Replace roll bar.25 $15 Replace roll bar rear brace.25 $15 Replace chain guard.25 $15 Replace frame complete 2.00 $120 5
6 MVx70 PIT BIKE FLAT RATE LABOR CHART Function Hours Labor BRAKE Adjust brakes.25 $15 Replace rear cam lever 1.0 $60 Replace shoes & spring.50 $30 Replace brake handle assy.25 $15 Replace brake tension bar.50 $30 Replace brake cable.25 $15 FUEL Replace fuel tank.50 $30 Replace fuel shutoff valve.25 $15 Replace fuel line.25 $15 Replace fuel filter.25 $15 Clean fuel tank.25 $15 CARBURETOR Replace carburetor.50 $30 Carburetor clean and adjust.75 $45 Carburetor gasket replace.25 $15 Clean air filter.25 $15 EXHAUST Replace exhaust gasket.25 $15 Replace heat shield(s).25 $15 Replace muffle assy.50 $30 ENGINE Replace engine complete 1.5 $90 Replace coil assembly.50 $30 Replace CDI.25 $15 Replace wiring harness.50 $30 Change oil.50 $30 CLUTCH Replace clutch.75 $45 TRANSMISSION & CHAIN Replace shaft 1.00 $60 Replace pawl spring.50 $30 Kick start axle gear 1.00 $60 Drive axle oil seal.50 $30 6
7 Replace drive axle bearing 4.50 $270 Replace Shift cam forks 4.50 $270 Adjust shifter.25 $15 Replace kick start pedal.25 $15 Replace shift lever.25 $15 Replace shift guide.50 $30 Adjust chain.25 $15 Replace chain.25 $15 Replace drive sprocket.50 $30 Replace rear sprocket.50 $30 Replace chain tensioner.25 $15 OPERATING CONTROLS Replace foot peg assy..25 $15 Replace seat.25 $15 Replace number plate.25 $15 Replace handlebars.50 $30 Adjust throttle cable.25 $15 Replace keyed ignition.25 $15 switch Replace kill switch.25 $15 Replace twist throttle assy..25 $15 Replace hand grips.25 $15 Replace throttle cable.50 $30 Replace front brake lever.25 $15 Replace rear brake pedal.25 $15 Replace rear brake cable.25 $15 Replace ignition switch.25 $15 CHASSIS Replace frame complete 3.00 $180 Rear triangle replace 1.00 $60 Rear suspension bearing 1.50 $90 Replace kickstand.25 $15 Replace monoshock assy $60 Replace front fender.25 $15 Replace rear fender.25 $15 Replace chain guard.25 $15 Replace chain guide.50 $30 Replace fork assembly.50 $30 Replace fork seals.75 $45 Replace fork lower leg.50 $30 Replace fork springs.50 $30 WHEELS 7
8 Replace front wheel.50 $30 Replace rear wheel.75 $45 True spokes.75 $45 Replace front tire & tube.50 $30 Replace rear tire & tube.75 $45 Replace front wheel bearings.50 $30 Replace rear wheel bearings.75 $45 Replace wheel bearing seal.75 $45 8
9 MVs10 STAND UP SCOOTER FLAT RATE LABOR CHART Function Hours Labor BRAKE Adjust brakes.25 $15 Replace brake handle assy.25 $15 Replace brake cable.25 $15 Replace brake pads.50 $30 Replace brake caliper.25 $15 Replace brake rotor.50 $30 FUEL Replace fuel primer bulb.25 $15 Clean fuel tank.25 $15 Replace fuel filter.25 $15 Replace fuel tank.25 $15 ENGINE Replace engine.50 $30 Replace carburetor.25 $15 Adjust carb.25 $15 LocTite & tighten carb bolts.25 $15 Clean air filter.25 $15 Replace spark plug.25 $15 Clean & gap spark plug.25 $15 Adjust idle speed.25 $15 Replace recoil starter assy..25 $15 Replace muffler.25 $15 Adjust & lube drive chain.25 $15 Replace chain.25 $15 Replace rear sprocket.50 $30 OPERATING CONTROLS Replace fork complete.75 $45 Replace folding assy..50 $30 Lube & adjust headset.50 $30 bearings Replace headset bearings.50 $30 Replace handlebars.25 $15 Replace handlebar stem.25 $15 Adjust throttle cable.25 $15 Replace kill switch.25 $15 Replace ignition switch.25 $15 Replace thumb throttle assy..25 $15 9
10 Replace hand grips.25 $15 CHASSIS Replace kickstand.25 $15 Replace lower body.25 $15 Replace upper body.25 $15 Replace chain guard.25 $15 Replace frame complete 1.50 $90 Replace wiring harness.75 $45 Replace rear shock (if equip).50 $30 Seat tube clamp.25 $15 Replace seat.25 $15 WHEELS Replace front wheel.50 $30 Replace rear wheel.75 $45 Replace front tire.50 $30 Replace rear tire.75 $45 10
DR90. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS AND PRICES ARE SUBJECT TO CHANGE 1 of 51
DR90 Toll Free: 888-863-2252 PART NUMBERS AND PRICES ARE SUBJECT TO CHANGE 1 of 51 CYLINDER & CYLINDER HEAD 1 DR90-001 842645048166 CYLINDER 1 1 2 DR90-002 842645048173 GASKET, CYLINDER 1 1 3 DR90-003
1/29/2008 DR70. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 43
DR70 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 43 CYLINDER & CYLINDER HEAD 1 DR70-001 883099044472 CYLINDER 1 1 2 DR70-002 883099044489 GASKET, CYLINDER 1 1 3 DR70-003 883099044496
1/29/2008 DR125 / DR150. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 55
DR125 / DR150 Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 55 CYLINDER HEAD ASSY. 1 125-001 883099006937 CYLINDER HEAD COVER 1 1 2 125-002 883099006944 BOLT M6X28 2 3 3 125-003 883099006951
1/29/2008 DR50. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 45
DR50 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 45 CYLINDER & CYLINDER HEAD Part UPC Number Description Baja Description 1 DR50-001 842645074424 CYLINDER 1 1 2 DR50-002 842645074431
DR50 Hensim Dirt Runner 49cc Dirt Bike (VIN PREFIX LLCH or LUAH)
Page 1 of 21 Product Information Baja Web > Product Information > Parts Lists > DIRTBIKE > DR50 Hensim Dirt Runner 49cc Dirt Bike (VIN PREFIX LLCH or LUAH) DR50 Hensim Dirt Runner 49cc Dirt Bike (VIN PREFIX
DR90. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS AND PRICES ARE SUBJECT TO CHANGE 1 of 51
DR90 Toll Free: 888-863-2252 PART NUMBERS AND PRICES ARE SUBJECT TO CHANGE 1 of 51 CYLINDER & CYLINDER HEAD Part UPC Number Description Baja Description 1 DR90-001 842645048166 CYLINDER 1 1 2 DR90-002
DR125 and DR150 Hensim Dirt Runner 125cc and 150cc Dirt Bike (VIN PREFIX LLCH or LUAH)
Parts Lists - DR125 and DR150 Hensim Dirt Runner 125cc and 150cc Dirt Bike (VIN PR... Page 1 of 25 Product Information Baja Web > Product Information > Parts Lists > DIRTBIKE > DR125 and DR150 Hensim Dirt
BR150 Pmi Baja Reaction 150cc Go Kart (VIN PREFIX L4VM)
Page 1 of 21 Product Information Baja Web > Product Information > Parts Lists > GOKART > BR150 Pmi Baja Reaction 150cc Go Kart (VIN PREFIX L4VM) BR150 Pmi Baja Reaction 150cc Go Kart (VIN PREFIX L4VM)
1/29/2008 DB30S. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 14
DB30S Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 14 ENGINE Part UPC Number Description Baja Description 31 DB30S-100 883099115806 CLUTCH 1 1 32 DB30S-101 883099115813 ENGINE 1
ENGINE Dinli 904 D1033-011
ENGINE Dinli 904 D1033-011 ENGINE Model Item Part no Description Specification Quantity 01 E140000-01 E14 ENGINE 450C.C. 1 FENDER SEAT D1033-021 FENDER SEAT Model Item Part no Description Specification
C O N T E N T S 1 ABOUT THIS PARTS LIST... 2 ENGINE GROUP... 3 3 CONTENTS-FRAME GROUP
C O N T E N T S 1 ABOUT THIS PARTS LIST... 2 2 CONTENTS-ENGINE ENGINE GROUP ENGINE GROUP... 3 3 CONTENTS-FRAME GROUP FRAME GROUP... 5 4 ENGINE PARTS LIST... 9 5 FRAME PARTS LIST...37 1 ABOUT THIS PARTS
TABLE OF CONTENTS. Section 1 - Assembling your new pit bike.
Orion Pit Bike Sales Owners Manual (All information and content is the property of Orion Pit Bike Sales. Any attempt to copy or resell is a direct violation of our copyright. All violators will be prosecuted)
46431x92A Garden Tractor (1998) Page 1 of 16 Body Chassis
46431x92A Garden Tractor (1998) Page 1 of 16 Body Chassis 46431x92A Garden Tractor (1998) Page 2 of 16 Body Chassis 1 092546E701 Bracket, Seat 2 091963 Z Plate Assembly, Switch 3 164X26 Spring, Compression
Service Packages & Pricing
Service Packages & Pricing Silver Gold Motorcycle Service Packages Change oil & filter Change oil & filter Fuel system treatment $ 109.95 $ 129.95 Platinum Replace spark plugs Change oil & filter Fuel
6-years/75,000 miles Comprehensive coverage Subsequent Owner Warranty $100 Deductible
LINCOLN PREMIER LIMITED WARRANTY 6-years/75,000 miles Comprehensive coverage Subsequent Owner Warranty $100 Deductible Comprehensive Coverage Because Lincoln has always been a brand you can trust and respect,
11-600036D PRO MAC 60 07/72 to 12/76 IPL 89321 Page 1 of 19 Accessories
11-600036D PRO MAC 60 07/72 to 12/76 IPL 89321 Page 1 of 19 Accessories 11-600036D PRO MAC 60 07/72 to 12/76 IPL 89321 Page 2 of 19 Accessories 84453 Kit - Piston tool 69191 Kit - Pressure test adaptor
DR70-XR Xmoto 70cc Dirt Bike (VIN PREFIX L98B)
Page 1 of 25 Product Information Baja Web > Product Information > Parts Lists > DIRTBIKE > DR70-XR Xmoto 70cc Dirt Bike (VIN PREFIX L98B) DR70-XR Xmoto 70cc Dirt Bike (VIN PREFIX L98B) Engine [Image] ENGINE
PRINCE 50 Parti di ricambio agg. al 30-11-09
. 缸 头 罩 部 件 CYLINDER HEAD COVER(FOR EUROPE) 50000 COVER COMP HEAD 2 5000 GASKET HEAD COVER 3 50002 Aeration Head Cover 4 50372 AERATION CAP 5 50355 TUBE BREATHER 6 50356 TIE-IN 7 50358 AERATION TUBE ASSY
125 DUKE EU 2011 SPARE PARTS MANUAL: CHASSIS ENGLISH ART.NO.: 3CF8003K4EN
SPARE PARTS MANUAL: CHASSIS ART.NO.: 3CF8003K4EN ENGLISH INDEX FRONT FORK, TRIPLE CLAMP HANDLEBAR, CONTROLS FRAME SIDE / CENTER STAND 3x 4x 5x 6x SHOCK ABSORBER SWING ARM EXHAUST SYSTEM AIR FILTER 7x
K&T Saw Shop 606-678-9623 or 606-561-4983
12-600072F PRO MAC 850 SUPER CHAIN SAW 05/92 to Current IPL 215710-R1 Page 1 of 16 Accessories www.ktoutdoor.com 12-600072F PRO MAC 850 SUPER CHAIN SAW 05/92 to Current IPL 215710-R1 Page 2 of 16 Accessories
356 CHECKLIST ELECTRICAL: CHASSIS:
356 CHECKLIST ELECTRICAL: Headlights hi/lo beam Taillights Running lights Turn signals Brake lights License light(s) Fog lights Reverse light Horn Dome lights Dash lights Temp guage Tank level guage Tachometer
AUTOMOBILE MECHANIC STUDENT INTERNSHIP SKILLS LIST Provo School District
AUTOMOBILE MECHANIC STUDENT INTERNSHIP SKILLS LIST Provo School District Repairs and overhauls automobiles, buses, trucks, and other automotive vehicles: Examines vehicle and discusses with customer or
K&T Saw Shop 606-678-9623 or 606-561-4983
11-600072-02 PROMAC 800 CHAIN SAW 08/80 to 05/85 IPL 215724-01 Page 1 of 20 Accessories & Tools www.ktoutdoor.com 11-600072-02 PROMAC 800 CHAIN SAW 08/80 to 05/85 IPL 215724-01 Page 2 of 20 Accessories
K&T Saw Shop 606-678-9623 or 606-561-4983
11-600097F MINI-MAC 35AS 07/76 to 04/77 IPL 92754A-R1 Page 1 of 12 Accessories www.ktoutdoor.com 11-600097F MINI-MAC 35AS 07/76 to 04/77 IPL 92754A-R1 Page 2 of 12 Accessories 91753 Case - Carrying 88756
K&T Saw Shop 606-678-9623 or 606-561-4983
11-600016C MAC 110 01/77 to 02/83 IPL 95807-R2 Page 1 of 16 Tools & Accessories www.ktoutdoor.com 11-600016C MAC 110 01/77 to 02/83 IPL 95807-R2 Page 2 of 16 Tools & Accessories 95169 Kit - Spark Arrester
K&T Saw Shop 606-678-9623 or 606-561-4983
13-600072-06 PRO MAC 8200 05/92 to Current IPL 215710-02 Page 1 of 20 Carburetor Assembly www.ktoutdoor.com 13-600072-06 PRO MAC 8200 05/92 to Current IPL 215710-02 Page 2 of 20 Carburetor Assembly 214763-02
2700 DUST CONTROL MACHINE:
700 DUST CONTROL MACHINE: 30016 PAGE 1 700 DUST CONTROL MACHINE: 30016 11 17 9 15 8 16 10 1 13 7 6 1 1 30 OLD STYLE BATERY BOX 8 3 5 3 7 0 18 19 31 3 9 5 1 FACTORY INSTALLED OPTIONS: 30011 ELECTRIC CLUTCH
Extended Protection Plans for New and Pre-Owned Vehicles
Extended Protection Plans for New and Pre-Owned Vehicles Extended Protection you can count on from Old Republic Insured Automotive Services, Inc. (ORIAS) Your vehicle is a major investment. Next to your
LF-1 CYLINDER HEAD COVER
PITBIKE AB, SWEDEN LIFAN 50cc SOHC parts catalogue Copyright PITBIKE AB, SWEDEN LF- CYLINDER HEAD COVER 5 6 7 8 9 0 5 /P5FMI 0/P5FMI /P50FMH /P5FMI-B /P5FMI /P5FMI 5/P50FMH GB/T9 /P5FMI 5/P5FMI 8/P50FMG
Rail 001 112 2 Canvas, folding top 001 101 3 Rear panel 001 102 4 Stip in window, left 001 106 dto. right 001 107
U 411 1 Rear view mirror, round, metall 13cm Ø 002 045 2 Raised airintake 002 060 3 Side panelling, front, left 002 030 Side panelling, front, right 002 031 4 Panelling left 002 051 dto. right 002 052
COVERED. WE VE GOT YOU H-D EXTENDED SERVICE PLAN GET TO KNOW THE HDFS FAMILY: ASK YOUR DEALER FOR MORE INFORMATION. www.hdfsi.com
H-D EXTENDED SERVICE PLAN www.hdfsi.com WE VE GOT YOU COVERED. GET TO KNOW THE HDFS FAMILY: Harley-Davidson Insurance Harley-Davidson Extended Service Plan Harley-Davidson Debt Protection Plan Harley-Davidson
13. REAR WHEEL/BRAKE/SUSPENSION
13. REAR WHEEL/BRAKE/SUSPENSION 13 3.5~4.5kg-m 8.0~10.0kg-m 0.8~1.2kg-m 3.0~4.0kg-m 2.4~3.0kg-m 3.5~4.5kg-m 6.0~8.0kg-m 13-0 13. REAR WHEEL/BRAKE/SUSPENSION 13 REAR WHEEL/BRAKE/SUSPENSION SERVICE INFORMATION...
COVERING MILLIONS Preferred Protection Plan, a Service Group Company www.sgifs.com PO Box 26830, Austin, TX 78755-0800.
COVERING MILLIONS Preferred Protection Plan, a Service Group Company www.sgifs.com PO Box 26830, Austin, TX 78755-0800. 1-877-565-0816 PPP-308 0903 rev 0408 BENEFITS New and Pre-Owned Vehicles Preferred
360 Automatic Chain Saw UT-10468 Page 1 of 15 Carburetor
360 Automatic Chain Saw UT-10468 Page 1 of 15 Carburetor 360 Automatic Chain Saw UT-10468 Page 2 of 15 Carburetor 1 93205A 1 Repair Kit 2 93205A 1 Repair Kit 3 93205A 1 Repair Kit 4 93205A 1 Repair Kit
Scheduled Maintenance (North America)
Scheduled Maintenance (North America) Follow Schedule 1 if the vehicle is operated mainly where none of the following conditions apply. f any do apply, follow Schedule 2 (Canada and Puerto Rico residents
Southern Columbia Area School District Bus/Automotive Parts for Sale. PartNo Description Vendor Amount 1 583966C91 EXHAUST CLAMP 1 2 905-09 PIPE 1
Southern Columbia Area School District Bus/Automotive Parts for Sale PartNo Description Vendor Amount 1 583966C91 EXHAUST CLAMP 1 2 905-09 PIPE 1 3 00025296 BACK UP LIGHTS 1 4 00109869 HARNESS Bus Parts
PARTS CATALOGUE. JL50QT-5 scooter
PARTS CATALOGUE 2006 Year 00 Edition JL50QT-5 scooter CIXI KINGRING MOTORCYCLE CO.,LTD. INDEX E-01 CRANK CASE 1 E-02 CYLINDER HEAD COVER CYLINDER HEAD 3 E-03 CYLINDER CRANK CASE PISTON 5 E-04 RIGHT CRANKCASE
STEERING HANDLEBAR/FRONT WHEEL/ FRONT SHOCK ABSORBER
14 14 STEERING HANDLEBAR/FRONT WHEEL/ SCHEMATIC DRAWING ------------------------------------------------- 14-1 SERVICE INFORMATION------------------------------------------------ 14-2 TROUBLESHOOTING-----------------------------------------------------
SECTION VII PARTS BREAKDOWN
SECTION VII PARTS BREAKDOWN 21 REAR TINE TILLER MAIN ASSEMBLY ITEM # PART # QTY DESCRIPTION 1 SEE PAGE 25 1 ENGINE-RIGHT ANGLE DRIVE-PULLEY ASSEMBLY 2 SEE PAGE 27 1 FRAME-TRANSMISSION-HOUSING ASSEMBLY
CHAPTER 7 PARTS LISTS, SCHEMATIC DIAGRAMS AND WARRANTY
CHAPTER 7 PARTS LISTS, SCHEMATIC DIAGRAMS AND WARRANTY Parts List - Handlebar Assembly NOTE: Part numbers listed are available through MacKissic, Inc. Please add 916- prefix to the part number when ordering.
Aprilia.no. RS 50 96-98 Eng.6M
01 Carburettor - oil pump 02 Drive shaft 03 Head - piston 04 Primary gear shaft 05 Gearbox driven shaft 06 Selector 07 Clutch 08 Clutch cover 09 Right crankcase 10 Left crankcase 11 Ignition unit RS 50
1. Lay out 2 pieces of 7/8" tubing and mark for bending as shown. Remember that the bend is in the shaded area as shown below in Figure 1.
MINI BIKE PLANS Page 1 INTRODUCTION Before starting to build your Mini-Bike, be sure that you have all the parts shown on the material list. You will note that tubing has been used in the construction.
MUDDY MOTORSPORTS PARK RULE BOOK. Updated 2015
MUDDY MOTORSPORTS PARK RULE BOOK Updated 2015 General Rules 1. All spectators and crew members must be behind the crowd control fence. 2. Only track officials and one crew member will be on the track for
PREVENTION MAINTENANCE CHECKLIST FOR TRACTORS, TRUCKS, AND AUTOMOBILES
PREVENTION MAINTENANCE CHECKLIST FOR TRACTORS, TRUCKS, AND AUTOMOBILES Farm Machinery Fact Sheet FM-21 By Dr. Von H. Jarrett, Extension Agricultural Engineer Systematic sequence for inspection GASOLINE
UDOT RPMS VEHICLE RECORDS, PREVENTIVE MAINTENANCE & SURVEILLANCE
UDOT RPMS VEHICLE RECORDS, PREVENTIVE MAINTENANCE & SURVEILLANCE VEHICLE RECORDS AND PREVENTIVE MAINTENANCE Prepared by: UTAH DEPARTMENT OF TRANSPORTATION OFFICE OF PLANNING AND PROGRAMMING IN COOPERATION
Mini-ZT. Parts Manual. Models 915054-1540 915064-1534 915070-1534. 00462700 4/06 Printed in USA
Mini-ZT Parts Manual Models 0-0 0-00 - 0000 /0 Printed in USA THE MANUAL Before you operate your unit, carefully and completely read manuals supplied with the unit. The contents will provide you with an
Volkswagen Jetta, Golf, GTI 1999, 2000 Brake System 47 Brakes - Hydraulic Components (Page GR-47)
47 Brakes - Hydraulic Components (Page GR-47) FS III front brake calipers, servicing Front brake caliper piston, removing and installing FN 3 front brake calipers, servicing Front caliper piston, removing
Contents. Description Page Description Page
Contents Description Page Description Page Auger Housing Assembly 1 Muffler 18 Handle and Control Assembly 3 Fuel Tank r Assembly 19 Engine and Drive Assembly 5 Clutch Retarder 20 Cylinder Head 7 Retarder
Wynn s Extended Care
Wynn s Extended Care Every car deserves to receive the very best care... especially yours. How Do You Keep Your Reliable Transportation Reliable? Count on Wynn s Because Wynn s has been caring for cars
2016 Price Sheet. Custom Built Replacement Chassis
2016 Price Sheet Custom Built Replacement Chassis 5557 Chevy Car Direct Replacment Chassis 15,895 5362 Corvette Direct Replacment Chassis 15,895 5557 Chevy Car Pro Street Chassis 16,895 5362 Corvette Pro
Curriculum for Motorcycle Mechanic (6 Months)
Curriculum for Motorcycle Mechanic (6 Months) Page 1 Contents Overall objective of the course: 3 Competencies gained after completion of the course:. 3 Job opportunities available immediately and in the
ILLUSTRATED PARTS LIST
TW400 WITH 390cc HONDA ENGINE 390cc 2 WHEEL DRIVE UTILITY VEHICLE ILLUSTRATED S LIST 390cc 2WD B O D Y D I A G R A M 390cc 2WD F R A M E D I A G R A M 390cc 2WD D R I V E T R A I N D I A G R A M DESCRIPTION
MERCEDES FIRST EDITION - 2013
FIRST EDITION - 2013 CONTENTS Accessories... 1 Hydraulic Jacks Air Intake... 2 Air Filter Charger Charging System Intake Charger Hose Intake Manifold Intake Pipe Air Filter Intercooler Charger Aircondition...
MOTOR VEHICLE MECHANIC REPAIR CATEGORIES
Chapter 8: Motor Vehicle Mechanic Repair Categories Page 1 CHAPTER 8 MOTOR VEHICLE MECHANIC REPAIR CATEGORIES Section 8-1 REQUIREMENT Section 10 of the Motor Vehicle Service and Repair Act (MCL 257.1310)
Extended Protection Plans for New and Pre-Owned Vehicles
Extended Protection Plans for New and Pre-Owned Vehicles Protection from the Unexpected. Your vehicle is not only an investment; it s your transportation lifeline. Driver s Choice from Old Republic Insured
DR ALL-TERRAIN FIELD and BRUSH MOWER
DR ALL-TERRAIN FIELD and BRUSH MOWER Parts List and Assembly Diagrams Important: Please read the Safety and Operating Instructions and the separate Engine Manufacturer s Owners Manual to become familiar
SR 50 H2O (Pure-jet+Carb.) 03
01 Frame 02 Central stand - Connecting rod 03 Front fork I 04 Front fork II 05 Front fork III 06 Front body I 07 Front body II 08 Front body III 09 Front body IV 10 Central body I 11 Central body II 12
K&T Saw Shop 606-678-9623 or 606-561-4983. 12-400165 MC 91C 11/74 to 04/76 IPL 84456 Page 1 of 11 Accessories
12-400165 MC 91C 11/74 to 04/76 IPL 84456 Page 1 of 11 Accessories 12-400165 MC 91C 11/74 to 04/76 IPL 84456 Page 2 of 11 Accessories 68899 Piston Assy - 0.005 in. oversize 66790 Ring Set - Piston 0.005
VeloCruz PO Box 902021 Sandy, UT 84090 Phone: 801.733.4578 800.393.7101 Fax: 801.383.6070 www.velocruz.com info@velocruz.com
VeloCruz PO Box 902021 Sandy, UT 84090 Phone: 801.733.4578 800.393.7101 Fax: 801.383.6070 www.velocruz.com info@velocruz.com Techical Data............................ 1 Principle of Operation of the 2-Cycle
FZ6-ST FZ6-STC SUPPLEMENTARY SERVICE MANUAL LIT-11616-18-43 5VX-28197-11
FZ6-ST FZ6-STC SUPPLEMENTARY SERVICE MANUAL LIT-66-8-43 5VX-2897- FOREWORD This Supplementary Service Manual has been prepared to introduce new service and data for the FZ6-ST/FZ6-STC. For complete service
Class 5 to 7 Truck and Bus Hydraulic Brake System
Class 5 to 7 Truck and Bus Hydraulic Brake System Diagnostic Guide 1st Edition * 5+0 Important Service tes The information in this publication was current at the time of printing. The information presented
Artnr 530214 Kjedesag bensin CS4600 45cc
1 / 9 2 / 9 Pos Lev art GK art Engelsk Norsk Svensk Stk 00 TSB18-58S 530218 Bar 45cm for CS4600 Sverd 45cm for CS4600 00 SABRE 32S072T 530219 Chain 45cm for CS4600 Sagkjede 45cm for CS4600 Høyre deksel
Kobelco Extended Warranty Program. www.kobelco-europe.com
Kobelco Extended Warranty Program www.kobelco-europe.com Kobelco Extended Warranty is a convenient, value added way to give your Kobelco customers added security and peace of mind. Benefits of the Kobelco
Reproduction. Not for. Coronet RD Series Riding Mowers. Parts Manual. 15.5HP Product. 17.5HP Product
Parts Manual 15.5HP Product Coronet RD Series Riding Mowers Mfg. No. Description 7800674 Coronet RD, 15.5HP Hydro (CE) 7800675 Coronet RD, 15.5HP Hydro (CE, FR) 17.5HP Product Mfg. No. Description 7800678
Third Edition. 1970-72 Corvette Technical Information Manual & Judging Guide Index
Third Edition 1970-72 Corvette Technical Information Manual & Judging Guide Index Index INTERIOR Page 3 1. Upholstery and Seat Belts Page 5 1.1. Vinyl Upholstery Page 5 1.2. Custom (Leather) Upholstery
VEHICLE SERVICE CONTRACT
VEHICLE SERVICE CONTRACT The best way to help protect yourself from unexpected repair costs Protection for the Road Ahead Purchasing a vehicle is a significant investment that is worth protecting. While
DYNA RIDER FOOTBOARD KIT
-J0 REV. 0-0-0 DYNA RIDER FOOTBOARD KIT GENERAL Kit Number 000 Models For model fitment information, see the P&A Retail Catalog or the Parts and Accessories section of www.harley-davidson.com (English
Your New Frog Bike. Congratulations on purchasing a new bike and thank you for choosing Frog!
Your New Frog Bike Congratulations on purchasing a new bike and thank you for choosing Frog! We know that you must be raring to go but before you do there s a few little things still to do to get you up
K&T Saw Shop 606-678-9623 or 606-561-4983
16-400048-21 TITAN PB250 06/94 to Current IPL 211569 Page 1 of 13 Accessories www.ktoutdoor.com 16-400048-21 TITAN PB250 06/94 to Current IPL 211569 Page 2 of 13 Accessories 1 219179 1 Nozzle, Round 2
Number Wheeler P/N Description Set Rex P/N Notes 1 603500 Base 1 J001 2 603501 Support, Right 1 J002 3 603502 Support, Left 1 J003 4 600328 Nut (M8)
1 603500 Base 1 J001 2 603501 Support, Right 1 J002 3 603502 Support, Left 1 J003 4 600328 Nut (M8) 4 5 600130 Spring Washer (8mm) 4 6 600344 Roll Pin (M6x30) 4 7 600129 Socket Hd Cap Screw (M8x25) 4 8
Information and Instructions
Information and Instructions This shop manual contains several sections each covering a specific group of wheel type tractors. The Tab Index on the preceding page can be used to locate the section pertaining
SERVICE PARTS LIST PAGE 1 OF 6 BASE ASSEMBLY SPECIFY CATALOG NO. AND SERIAL NO. WHEN ORDERING PARTS 12" DUAL BEVEL COMPOUND MITER SAW B27A
PAGE 1 OF 6 BASE ASSEMBLY 00 0 EXAMPLE: Component Parts (Small #) Are Included When Ordering The Assembly (Large #). SPECIFY CATALOG NO. AND NO. WHEN ORDERING PARTS 1 02-80-0050 Thrust Bearing (1) 2 05-80-0510
Volkswagen Jetta, Golf, GTI 1999, 2000 Brake System 46 Brakes - Mechanical Components (Page GR-46)
46 Brakes - Mechanical Components (Page GR-46) Front brakes Brake pads, removing and installing Brake pads, removing and installing FN 3 brake caliper, servicing FS III brake caliper, servicing Rear wheel
MAN - MERCEDES - BENZ
SAYFA: 1 10100 10102 10103 355 353 06 15 355 353 03 15 346 353 08 15 AXLE GEAR AXLE GEAR AXLE (WITH BUSHING TYPE) (WITH BUSHING TYPE) (WITH BUSHING TYPE) 2521 2517-2521-2622 10104 10105 10106 308 350 00
2011-14 F250 6 RADIUS ARM KIT
92154000 Thank you for choosing Rough Country for your suspension needs. 2011-14 F250 6 RADIUS ARM KIT Rough Country recommends a certified technician installs this system. In addition to these instructions,
TEXT BET & WIN 50 A.C. GENERATOR INSTALLATION 9-4 EXHAUST MUFFLER REMOVAL 2-6 A.C. GENERATOR REMOVAL 9-2 EXHAUST MUFFLER 17-2 AIR CLEANER 3-6
TEXT A.C. GENERATOR INSTALLATION 9-4 EXHAUST MUFFLER REMOVAL 2-6 A.C. GENERATOR REMOVAL 9-2 AIR CLEANER 3-6 AIR SCREW ADJUSTMENT 12-10 AUTO BYSTARTER 12-5 BATTERY 15-4 BRAKE CALIPER 13-11 BRAKE SYSTEM
REMOVAL AND INSTALLATION
303-01C-1 REMOVAL AND INSTALLATION Engine Body On Special Tool(s) Adapter For 303-D043 303-D043-02 or equivalent Special Tool(s) 303-01C-1 Turbocharger Lifting Bracket 303-1266 Wrench, Fan Clutch Nut 303-214
Pallet Jack. OWNER S MANUAL Model MH1230. Important Safety Instructions Assembly Instructions Parts and Hardware Identification
OWNER S MANUAL Model MH1230 Important Safety Instructions Assembly Instructions Parts and Hardware Identification Pallet Jack CAUTION: Read, understand and follow ALL instructions before using this product
2003 ACCORD - Automatic Transmission Removal
2003 ACCORD - Automatic Transmission Removal Special Tools Required Engine support hanger, A and Reds AAR-T-12566 Engine hanger balancer bar VSB02C000019 Front subframe adapter VSB02C000016 These special
YARD CRUISER HYDRO DRIVE SERIES 1 & 2
Parts Manual for YARD CRUISER HYDRO DRIVE SERIES 1 & MODELS YZ11BE YZ181BE YZ15BVE YZ158BVE TM CONTENTS DESCRIPTION PAGE(S) DESCRIPTION PAGE(S) WHEELS- REAR... CASTER, FRONT WHEEL & TIRE ASSM Y.... FRONT
ZAPPY 3 OWNER S MANUAL. Read this manual completely before riding your Electric ZAPPY 3.
ZAPPY 3 OWNER S MANUAL Read this manual completely before riding your Electric ZAPPY 3. TECHNICAL INFORMATION Model No. : ZAPPY 3 Product size Type of motor Motor power Battery type Battery Charger Charging
PARTS MANUAL EH12-2 ENGINE. Model. PUB-EP5713 Rev. 7/99
PARTS MANUAL Model EH12-2 ENGINE PUB-EP5713 Rev. 7/99 940 Lively Blvd. Wood Dale, IL 60191 Phone: 630-350-8200 Fax: 630-350-8212 e-mail: sales@robinamerica.com www.robinamerica.com Copyright 1999 Robin
BUYERS GUIDE. IMPORTANT: Spoken promises are difficult to enforce. Ask the dealer to put all promises in writing. Keep this form.
BUYERS GUIDE IMPORTANT: Spoken promises are difficult to enforce. Ask the dealer to put all promises in writing. Keep this form. VEHICLE MAKE MODEL YEAR VIN NUMBER DEALER STOCK NUMBER (Optional) WARRANTIES
CLASSIC ROAD RACING IN THESE PARTS OF THE RULES WITCH DO NOT GIVE DESCRIPTION, HAVE TO USE THE FIM RULES
CLASSIC ROAD RACING GENERAL RULES AND INSTRUCTIONS CONCERNING THE CLASSIC RACING MOTORCYCLES AND RACING GEAR USING IN THE CLASSIC ROAD RACING COMPETITIONS IN FINLAND IN THESE PARTS OF THE RULES WITCH DO
MEMBERS ASSESSMENT BOOKLET TO GAIN ENTRY LEVEL QUALIFICATION FOR INTRODUCTION TO VEHICLE TECHNOLOGY
l MEMBERS ASSESSMENT BOOKLET TO GAIN ENTRY LEVEL QUALIFICATION FOR INTRODUCTION TO VEHICLE TECHNOLOGY BY IMIAL Entry Level Award for the Introduction to Vehicle Technology (Entry 3) (QCF) QFQUAL I.D: 501/0549/8
INDEX INTRODUCTION. Reference No. 10-21L-01 R E V I S E D : 2 0 0 5 0 2
10-21L-01 SRM-2305, SRM-2305SI 1 1 INTRODUCTION We are constantly working on technical improvement of our products. For this reason, technical data, equipment and design are subject to change without notice.
Range Road RR Series Semi-Automatic Firewood Processor. Crated Unit Assembly Manual
Range Road RR Series Semi-Automatic Firewood Processor Crated Unit Assembly Manual 1 1) Undo 8-18mm x 19mm Nuts and bolts, 2 on each leg of top frame 2) Lift top of Metal crate off and move out of work
ENTRY-LEVEL AUTOMOTIVE TECHNICIAN
ENTRY-LEVEL AUTOMOTIVE TECHNICIAN Definition: An entry-level automotive technician performs diagnosis and repair to gasoline powered cars and light trucks with limited supervision. The last two bands of
1993 SUSPENSION Volkswagen Front. EuroVan
Article Text ARTICLE BEGINNING 1993 SUSPENSION Volkswagen Front EuroVan DESCRIPTION FWD independent suspension is an double-wishbone type with torsion bars mounted on upper control arm. Wheel is supported
BICYCLE OWNER S MANUAL R E A D T H I S B E F O R E U S I N G Y O U R N E W B I C Y C L E
BICYCLE OWNER S MANUAL R E A D T H I S B E F O R E U S I N G Y O U R N E W B I C Y C L E User Guide Table of Contents Introduction Page 3 1. Assembly Page 4-6 User Guide 2. Operating Instructions Page
CHAPTER 2 : STERLING MIDI JUNIOR AND STERLING MIDI JUNIOR FOUR
CHAPTER 2 : STERLING MIDI JUNIOR AND STERLING MIDI JUNIOR FOUR Sterling Midi Junior is a transportable rear wheel drive, three or four wheel electric powered Scoota with pneumatic tyres, upolstered seat
PUMP MAINTENANCE SCHEDULE AND CHECKLISTS
PUMP MAINTENANCE SCHEDULE AND CHECKLISTS Providing a maintenance schedule defined specifically by run hours or yardage pumped serves only as a general guideline given the large amount of variables a unit
PARTS MANUAL EH035V ENGINE. Models. PUB-EP Rev. 09/04
PARTS MANUAL Models EH035V ENGINE PUB-EP Rev. 09/04 940 Lively Blvd. Wood Dale, IL 60191 Phone: 630-350-8200 Fax: 630-350-8212 e-mail: sales@robinamerica.com www.robinamerica.com Copyright 2004 Robin America,
From the Smallest Part... ...to Turn-Key Rods!
From the Smallest Part... Price: $3.00...to Turn-Key Rods! 32 Ford Coupe 34 Ford Cabriolet 34 Ford California Kid Corbin Rods features the very best fiberglass bodies and chassis at the lowest prices!
Sales division Technical network leadership WORKSHOP MANUAL
Sales division Technical network leadership WORKSHOP MANUAL Workshop manual Technical network leadership TABLE OF CONTENTS TABLE OF CONTENTS TABLE OF CONTENTS... CHARACTERISTICS... 3 Engine...3 Capacities....3
Copyright 2009 S&S Truck Parts, Inc. All rights reserved.
ALL PARTS SUPPLIED ARE S&S/NEWSTAR, USE OF OTHER MANUFACTURER S NAMES, PART NUMBERS, OR TRADEMARKS ARE FOR INFORMATIONAL AND IDENTIFICATION PURPOSES ONLY. HUMVEE, HMWV ARE REGISTERED TRADEMARKS OF AM General
Heavy Duty Equipment Mechanic (Class Code 3743) Task List. Inspection and Diagnosis
Heavy Duty Equipment Mechanic (Class Code 3743) Task List Inspection and Diagnosis In order to verify complaints and determine malfunctions a Heavy Duty Mechanic: 1. Reads operators written trouble reports,
3000, 4000, 4100, 7500, 7700
3000, 4000, 4100, 7500, 7700 Drum & Disc Brake Lathes s Identification READ these instructions before placing unit in service. KEEP these and other materials delivered with the unit in a binder near the
Sample G1 ASE-type Certification Test. Sample ASE Maintenance and Light Repair (G1)-Type Certification Test
Sample G1 ASE-type Certification Test Sample ASE Maintenance and Light Repair (G1)-Type Certification Test Content Area Questions In Test Percentage Of Test A. Engine Systems 9 16% B. Automatic 4 7% Transmissions
P a r t s L i s t. P a r t s L i s t. Date:24.11.2008 Page: 1
Group:Duster/Mist Blowers Model:DM-4610(SrNr 004334 and before) Section:Cylinder, Crankcase, Piston 3 101514-06210 1 COVER, CYLINDER 4 145512-06210 1 GASKET, MUFFLER Sus. by 145512-06211 4 145512-06211