Illustrated Parts List L.U.V. Bug Lawn Utility Vehicle Model Series 0 IMPORTANT: Read safety rules and instructions carefully before operating equipment. Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forestcovered, brush-covered or grass-covered land unless the engine s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator. In the State of California the above is required by law (Section of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 80 Cleveland, Ohio -97. MTD LLC, P.O. BOX CLEVELAND, OHIO -009 Printed in U.S.A. FORM NO. 79-000B.fm (/00)
SECTION : PARTS LIST FOR MODEL SERIES 0 0 07 0 9 7 For reference only 7 9 0 7 0 8 7 8 9 9 8 8 For reference only 7 0 0 0 0 7 0 0 9 8 0 For reference only 8 For reference only* 8 8 7 90 8 7 97 0 For reference only* 8 9 9 8 7 08 7 9 0 9 8 70 77 8 89 7 79 9 0 78 8 8 98 78 0 0 8 9 9 9 9 99 9 80 00 0 70 7 * For clarity of viewing, these parts have been referred to more than once in this illustration.
Model Series 0. -008 Steering Wheel. 7-000 Steering Wheel Cap. 7-00 Shift Pivot Assembly. 8-0 Drive Pedal Assembly. 8-0 Brake Pedal Assembly. 8-09 Idler Brake Assembly 7. 70-09 Hex Bolt /8- x. 8. 70-099 TT Screw /-0 x 0. 9. 70-00A TT Screw /-8 x 0. 0. 70-089 Hex Bolt /8- x.. 70-07 AB Screw /- x 0.. 70-8 Hex Bolt. 70-0 Hex Bolt /-0 x 0.0. 7-0 Spacer. 7-09 Spacer. 7- Ferrule 7. 7- Shaft 8. 7-09 Jam Nut /8-9. 7-080 Flange Lock Nut /-8 0. 7-0 Flange Lock Nut /8-. 7-09 Nylon Lock Nut. 7-07 Flange Lock Nut /-8. 7-007 Jam Nut /-8. 7-07 Hex Nut /8-. 7-00 Cotter Pin. 7-0 Click Pin 7. 7-09B Hairpin Clip 8. 7-070 Cotter Pin 9. 70-0 Shift Knob 0. 70-09 Clutch Grip. 7-07 Clamp. 7-0 Extension Spring. 7-09A Extension Spring. 7-7 Compression Spring. 7-09 Compression Spring. 7-08 Drive Pad 7. 7-09 Brake Pad 9. 7-0 Flat Washer. x.0 x.0 0. 7-09 Lock Washer /8. 7-087 Flat Washer. 7-07 Flat Washer. 7-070 Bell Washer. 7-0 Thrust Washer. 7-070 Flat Washer. 7-07 Flat Washer 7. 78-08 Shoulder Screw.0 x.: /8-8. 78-07 Shoulder Spacer 9. 78-08 Shoulder Screw /-8 x.7 0. 7-09 Flange Bearing. 7-7 Deck Cable. 7-9 Brake Cable. 77-8A Shift Rod. 77-0 Variable Control Rod * Not shown in illustration. 77-9 Control Rod 7. 77- Shift Rod 8. 77- PTO Lever 9. 77-00 Brake Lock -Out Rod 0. 77- Belt Keeper Rod. 78- Shift Switch Bracket. 78- Shift Index Bracket. 78-87 Brake Mounting Bracket. 78-9 Cont. Bracket: PTO. 78-07 Link Bracket. 0-0007 Steering Tube Assembly 7. 8-00A Steering Support Bracket Assembly 8. 8-078A Front Axle RH 9. 8-079A Front Axle LH 70. 70-09A Hex Bolt /8- x. 7. 70-0 Hex Bolt /-8 x.0 7. 70-089 Hex Bolt /- x 0.7 7. 70-087 AB Screw #0- x 0. 7. 70-098 Hex Bolt /-0 x. 7. 7-0 Jam Lock Nut /8-77. 7-00 Hex Nut /- 78. 7-0 Hex Nut /8-79. 7-0 Hex Lock Nut /-0 80. 7-0 Hex Lock Nut /- 8. 7-09 Hex Lock Nut 8. 7-07 Jam Nut 8. 7-0 Ball Joint /8-8. 7-09B Steering Bellow 8. 7-00 Bell Washer 89. 7-09 Flat Washer.8 x. x.0 90. 7-0 Bell Washer.0 x.87 x.00 9. 7-07 Flat Washer.0 x.0 x.00 9. 7-00 Flat Washer /8 x.7 9. 7-078 Flat Washer. x.0 x.0 9. 78-0 Spacer 9. 78-089A Steering Adapter 9. 7-0 Hex Flange Bearing 97. 7-0 Bearing: Steering Column 98. 77-09 Tie Rod 99. 78-090 Pinion Gear 00. 70-0 Spacer 0. 78-0 Steering Gear 0. 8-09 Cover: Steering Column 0. -09A Complete Wheel Assembly: Front -070A Rim Assembly* 7-0 Valve* 7-087A Fl. Bearing* 7-070 Fl. Bearing* 0. 7-0 Cotter Pin 0. 7-089 Choke Control 0. 7-08 Lock Washer 07. 7-07 Hex Nut, /8-08. 7-00 Flat Washer,. x.9 x.00
Model Series 0 7 8 9 0 9 8 7 7 8 For reference only 7 8 0 9 9 8 9 0 IMPORTANT: For a proper working machine, use Factory Approved Parts. V-BELTS are specially designed to engage and disengage safely. A substitute (non OEM) V-Belt can be dangerous by not disengaging completely. 9 7 8 8 0
Model Series 0. 8-0007A Transmission Assembly*. 9-00 Spindle Housing. 8-0 Idler Bracket Assembly. 8-07 Idler Bracket Assembly. 70-09 Hex Bolt /8- x.. 70-09A Hex Bolt /8- x.0 7. 70-0 Hex Bolt /8- x.0 8. 70-09 Hex Bolt /8- x.7 9. 70-00 TT Screw /-8 x 0.87 0. 70-090 Hex Screw /8- x.7. 70-09 Hex Screw /8- x.0. 70-8 Hex Screw M0 x.:80. 7-0 Hex Nut /8-. 7-09 Jam Lock Nut /8-. 7-09 Hex Flange Nut M0 x.. 7-00A Flange Lock Nut /-8 7. 7-07 Hex Nut /8-8. 7-0 Jam Nut 9/-8 9. 7-0 Key 0. 77-088 Variable Speed Pulley Assembly. 7-008 Extension Spring. 7-08 Extension Spring. 7-08 Extension Spring. 7-00 Flat Washer.0 x.0 x.00. 7-07 Lock Washer /8. 7-09 Bell Washer.9 x. x.0 7. 7-07 Flat Washer /8 x. 8. 7-07 Bell Washer.7 x. x.0 9. 7-0 Flat Washer.0 x.0 x.0 0. 78-0 Shoulder Screw. 78-07 Shoulder Spacer. 78-098 Shoulder Spacer. 7-00 Thrust Bearing. 7-099 Ball Bearing. 70-070 Sleeve Spacer. 70-09 Spacer 7. 7-0 Belt: V Type 8. 7-09 Belt: V Type 9. 7-09 Belt: V Type 0. 7-00 Transmission Pulley. 7-098A Flat Idler Pulley. 7-9 Jack Pulley: Double. 7-00 Engine Pulley: Double. 7-07 Idler Pulley. 78-08 Idler Bracket: Variable Speed. 78-9 Cable Bracket 7. 78- Bracket: Lock: Pedal 8. 7-09 Lock Washer /8 * For full break-down of the transmission assembly, see page.. -0 Rear Wheel Assembly Complete: x x -0 Rim Assembly 7-0 Valve 7-098 Tire. 7-0 Bell Washer.0 x.87 x.00. 70-07 Hex Bolt /- x.70 7
Model Series 0 8 0 8 8 8 7 77 7 9 8 7 7 8 9 79 8 8 0 78 8 0 0 7 8 7 7 9 7 80 Do not over-tighten the seat support pivot bolt and nut on either side. Assembly must move freely to maintain the seat safety mechanism. 7 9 7 9 7 7 0 0 7 0 7 9 8 70 7 9 8 9 8 8
Model Series 0. 77-000 Seat: Black, Low Back. 7-07 Flange Lock Nut *. 8-07 Support Bracket Assembly LH. 7-070 Cotter Pin. 8-07 Support Bracket Assembly RH. 7-09 Tray Hinge. 70-00A TT Screw /-8 x 0. 7. 7-00A Foot Pad. 70-0 Carriage Bolt / x. 8. 78-0000 Rivet. 70-8 Hex Bolt M8-.: 0 9. 7-00 Battery Cover 7. 70-90 Special Screw M-: 0. 7-0 Bag Tray 8. 70-70 Hex Bolt M8-.:. 7-087 Flat Washer. x. x.0 9. 7-0 Flange Lock Nut /8-. 7-0700 Flat Washer 8. x 0. 7-089 Hex Nut M-. 7-07 Lock Washer M. 7-09 Hex Lock Nut M8-.. 70-9 Spacer. 7-00A Flange Lock Nut /-8. 78-000 Bracket: Battery Support. 7-0 Ratchet Clip 7. 78-08A Frame. 7-07 Compression Spring 8. 78-097 Rear Bracket: Pivot Support. 78-08 Engine Heat Deflector 9. 78-0 Support Bracket: Transmission. 7-099 Compression Spring 0. 78-8 Chute Bracket 7. 7-0997 Compression Spring. 78-0 Stop Bracket: Pivot 8. 7-00 Bell Washer.7 x.870 x.0. 78-9 Cable Bracket 9. 7-089 Shoulder Bushing. 70-0A TT Sems Screw /8- x.0 0. 7-08 Lock Washer. 78-9 Belt Keeper Bracket. 7-07 Flat Washer 8. x. 70-8 Hex Bolt M8-.: 0. 78-0 Shoulder Screw. 7-0 Pin: Belt Guard. 79- Support Tube: Seat 7. 7-09 Lock Nut M8-.. 78-000 Seat Bracket 8. 7-00 Hex Nut /-8. 78-07 Spacer 9. 7-0 Engine Mount: Gromm.. 78-079 Bag Switch Cover 70. 7-09 Lock Washer / 7. 78-078 Seat Support Bracket 7. 7-070 Flat Washer 8. x 8. 79 Switch Plate 7. 77-9 Belt Keeper Rod 9. 8-0 Pivot Bar Assembly 7. 70-09 Spacer 0. 8-08 Support Bracket Assembly RH 7. 78-0 Mounting Plate. 8-09 Bracket Assembly: Steering Column 7. 7-98 Battery. 8-09 Pivot Support Bracket: Front 7. 70- Self-Tapping Screw /8- x.0. 70-0 Ab Screw #0- x 0. 77. 70-0 Self-Tapping Screw /-0 x 0.7. 70-099 TT Screw /-0 x 0. 78. 7-0 Lock Washer. 70-0 Machine Screw 79. 7-07 Hex Sems Nut /-0. 70-8 Hex Screw M8-.: 0 80. 78-0008 Spacer 7. 70-708 Special Screw 8. 7-00 Speed Nut 8. 70-7 Special Screw 8. 78-08 Bag Hinge Bracket 9. 7- Clevis Pin 8. 7-009 Torsion Spring 0. 7-08 Speed Nut /-0 8. 7-0 Hinge Pin. 7-00 Hex Nut 8. 8-008 Bag Chute Door Assembly. 7-09 Hex Lock Nut * Torque: 9.8-. n.-m. or 7- in.-lbs. 9
0 Model Series 0 0 7 0 7 7 8 8 0 7 9 0 9 0 0 9 8 0 8 9 7 7 0 8 For reference only 7 7 7 7
Model Series 0. 8-0 Shift Assembly: Front Lift. 8-0 Pivot Bracket Assembly. 8-08 Bracket Assembly: Lift Handle. 70-0 Hex Bolt /-0 x.. 70-8 Hex Bolt M8-.: 0. 7-08 Ferrule 7. 7-0 Flange Lock Nut /8-8. 7-09 Hex Lock Nut M8-. 9. 7-07 Lock Nut /-0 0. 7-00 Hairpin Clip. 7-00 E-Ring. 7-09 Handle Grip. 7-00 Torsion Spring. 7-0 Thrust Washer.7 x.70 x.00. 7-0 Flat Washer /8 x.0 x.00. 7-0B Flange Washer. x.88 7. 7-00 Flat Washer.07 x.8 x. 8. 78-08 Shoulder Screw. x.7: /8-9. 77-7 Lift Link 0. 70-0A Spacer. 78- Upper Lift Link Bracket. 78-8 Lift Hanger Bracket. 78- Lift Indx. Bracket. 9-000 Spindle Housing. 8-09A Deck. 70-07 Hex Screw /8- x.7 7. 70-0 Hex Bolt /8- x.0 8. 70-00 TT Screw /-8 x 0.87 9. 70-00 Wing Bolt M8-. x 0 mm. 0. 7-07A Flange Nut /8-8. 7-07 Hex Nut /8-. 7-0 Speed Nut M8-.. 7-A Grass Catcher Chute. 7-77 Side-Discharge Chute. 7-0 Mulch Plug. 7-08 Extension Spring 7. 7-09 Lock Washer 8. 7-070 Flat Washer 8. x 9. 78-09 Spindle Shaft 0. 78-098 Shoulder Spacer. 7-099 Ball Bearing. 7-07 Blade: Bagging. 7-070 Blade: -in-. 70-000 Spacer. 7-09 Belt: V Type. 7-099 Deck Pulley 7. 7-098A Flat Idler Pulley 8. 78- Idler Bracket: Deck
Model Series 0 8 7 9. 9-0 Tube Assembly: Front Frame. -007 Grass Catcher Bag. 70-9 Mach. Screw #0- x.0. 7-0 Lock Nut #0-. 7-08 Retainer Strap. 7-000 Flat Washer 7. 79-0 Side Tube: Frame 8. 79- Bag Handle 9. 79-9 Support Tube
Model Series 0 Transmission Assembly 9 8 7 0. -00 Shaft Assembly: Detent. 8-007B Upper Housing Assembly. 8-0 Drive Shaft Assembly: LH Brake. 8-0009A Axle Assembly. -00 Brake Assembly: Yoke LH. 70- TT Screw /-0 x. 7. 77-078 Brake Pad 8. 79-0B Lower Housing 9. 7-08 Spring Detent 0. 77-08 Grease. 7-08 Ball: Detent:.0. 7-00 Brake Disc. 777X07 Label. 8-0007A Transmission Assembly Complete
Model Series 0 7 8. 9-000 Harness Assembly. 7-009 Key Switch. 7- Solenoid: V. 00 amp.. 7-7A Interlock Switch. 7-7 Key. 7-77 Switch: Plgr N.C./N.C. 7. 7-A Switch: Plgr N.O./N.C. 8. 7- Switch: Mt. Snap N.C.