POWER RELAY POLE - A SLIM POWER RELAY FTR-MY Series RoHS compliant FEATURES Width mm, height mm,(% smaller than NY series) area mm, super slim, low power, compact and light weight.gr. Nominal power: mw (% less than NY series), power: mw High sensitive High reliability, bifurcated gold overlay silver alloy (cadmium free) Complies with IEC 6, 6 Dielectric strength: VAC Surge strength: V SAFETY STANDARDS UL, CSA, VDE, CQC RoHS Compliant since production Plastic sealed type APPLICATIONS PLC, I/O module Inverter Control ORDERING INFORMATION FTR-MY A A D ** [Example] (a) (b) (c) (d) (e) (f) ( a) Series Name ( b) Contact Arrangement ( c) Coil Type ( d) Coil Nominal Voltage ( e) Contact Material ( f) Custom Designation FTR-MY Serie s A : Form A A : m W. :. : : : 6 : 6 : 9 : 9 D : Gold overlay Silver allo y Special Numbe r Note: The designation name is stamped on the top of the relay case as follows: Example.: Ordering code: FTR-MYAAD Actual marking: MYAAD
COIL DATA CHART FTR-MYAAD, Ω..6 FTR-MYAAD,9Ω.6.9 FTR-MYAAD,Ω 6.. Note: All values in the table are measured at C. *: Specified values are subject to pulse SPECIFICATIONS Item Contact Arrangement form A Material Configuration Resistance (initial) Rating (resistive) Maximum Carrying Current Maximum Switching Rating Maximum Switching Voltage Maximum Switching Current Minimum Switching Load* Gold overlay silver alloy Bifurcated (Crossbar) Maximum mω (at A 6 ) A VAC / A A VA, W 77 VAC, A ma Coil Nominal Power (at C) Power (at C) Operating Temperature mw C to +9 C (no frost) Time Value (at nominal voltage) Maximum ms (at nominal voltage) Maximum ms Life Mechanical x 7 operations minimum Other MODEL FTR-MY Series FTR-MYAA.D FTR-MYAAD FTR-MYAA6D FTR-MYAA9D Electrical Vibration Resistance Shock Resistance Weight Coil Nominal Must Must Nominal Resistance Voltage (± %) Voltage* Voltage* Power. Ω.. Ω.. 6 Ω.. 9 7 Ω 6.. Misoperation Endurance Misoperation Endurance FTR-MY operations minimum (at A VAC, resistive) operations minimum (at A VAC, resistive) (switching frequency times/minute) to Hz (double amplitude of. mm) to Hz (double amplitude of. mm) m/s ( ± ms), m/s (6 ± ms) Approximately. g * Minimum switching loads mentioned above are reference values. Please perform the confirmation test with the actual load before production since reference values may vary according to switching frequencies, environmental conditions and expected reliability levels.
INSULATION Item FTR-MY Note Resistance (initial) Minimum, MΩ at Dielectric Strength open contacts coil and contacts 7 VAC min., VAC min. Surge Voltage, V. x µs standard wave SAFETY STANDARDS Type Compliance Contact rating UL UL, UL 6 E66, E CSA C. No. LR Flammability: UL 9-V (plastics) A, 77 VAC (resistive) A, (resistive) / HP, 77VAC /VAC Pilot duty: D, C, R
REFERENCE DATA Time (ms) Contact Current (A) 9 7 6... Timing Coil Temperature Rise 9 7 6 A A A......... Coil Power (W) Coil Power (W) Maximum Switching Power DC resistive AC resistive. Contact Voltage (V) 6 Temperature Rise (deg.) Operation (x ) Distribution of & Voltage FTR-MYAAD n= Distribution (%) cosφ. Life Curves / VAC (resistive) τ=7 ms.... Distribution (%) Contact Current (A) Nominal Voltage Multiplying Factor.....6.....6 Distribution of & Time FTR-MYAAD n= 6 Operating Range A Must operate Voltage (Hot Coil) A A Must operate Voltage (Cool Coil) 6 Ambient Temperature ( C) Distribution (%) Distribution of Contact Resistance 6 FTR-MYAAD n= Make 6 Nominal Voltage Multiplying Factor (%) 6 Time (ms) Contact Resistance (mω) Contact Resistance (mω) Voltage (V) 6 7.7. Initial Electrical Life Test Electrical Life Test Electrical Life Test 6 6 7 7 FTR-MYAAD FTR-MYAAD n= n= Duty cycle:sec.on / sec.off Hz (Duty %) A (resistive) Operation (x 6 ) Contact Resistance (mω) Voltage (V) Contact Resistance (mω) Voltage (V) FTR-MYAAD n= Duty cycle:sec.on / sec.off.7 VAC A (resistive).7.. Initial Operation (x ) Initial Operation (x )
DIMENSIONS Dimensions Wiring Diagram (BOTTOM VIEW).. +... COIL NO COM..... +. (.77)..9.. +. (BOTTOM VIEW) -O...9. (.). +... +.77 Unit: mm
RoHS Compliance and Lead Free Relay Information. General Information Relays produced after the specific date code that is indicated on each data sheet are lead-free now. All of our signal and power relays are lead-free. Please refer to Lead-Free Status Info. (http://www.fujitsu.com/us/downloads/micro/fcai/relays/lead-free-letter.pdf) Lead free solder paste currently used in relays is Sn-.Ag-.Cu. All signal and power relays also comply with RoHS. Please refer to individual data sheets. Relays that are RoHS compliant do not contain the hazardous materials that are restricted by RoHS directive (lead, mercury, chromium IV, PBB, PBDE). It has been verified that using lead-free relays in leaded assembly process will not cause any problems (compatible). LF is marked on each outer and inner carton. (No marking on individual relays). To avoid leaded relays (for lead-free sample, etc.) please consult with area sales office. We will ship leaded relays as long as the leaded relay inventory exists. Note: Cadmium was exempted from RoHS on October,. (Amendment to Directive /9/EC). Recommended Lead Free Solder Profile Recommended solder paste Sn-.Ag-.Cu. Reflow Solder condtion Flow Solder condtion: Pre-heating: maximum C Soldering: dip within sec. at 6 C soler bath Solder by Soldering Iron: Soldering Iron Temperature: maximum 6 C Duration: maximum sec. We highly recommend that you confirm your actual solder conditions. Moisture Sensitivity Moisture Sensitivity Level standard is not applicable to electromechanical realys.. Tin Whisker Dipped SnAgCu solder is known as low risk tin whisker. No considerable length whisker was found by our in house test. 6
Fujitsu Components International Headquarter Offices Japan Fujitsu Component Limited Gotanda-Chuo Building -, Higashigotanda -chome, Shinagawa-ku Tokyo 6, Japan Tel: (-) 9-7 Fax: (-) 9-66 Email: promothq@fcl.fujitsu.com Web: www.fcl.fujitsu.com North and South America Fujitsu Components America, Inc. E. Caribbean Drive Sunnyvale, CA 99 U.S.A. Tel: (-) 7-9 Fax: (-) 7-97 Email: components@us.fujitsu.com Web: http://us.fujitsu.com/components/ Europe Fujitsu Components Europe B.V. Diamantlaan WV Hoofddorp Netherlands Tel: (-) 69 Fax: (-) 69 Email: info@fceu.fujitsu.com Web: emea.fujitsu.com/components/ Asia Pacific Fujitsu Components Asia Ltd. E Pasir Panjang Road #- Citilink Warehouse Complex Singapore 9 Tel: (6) 67-6 Fax: (6) 67- Email: fcal@fcal.fujitsu.com Web: http://www.fujitsu.com/sg/services/micro/components/ 7 Fujitsu Components America, Inc. All rights reserved. All trademarks or registered trademarks are the property of their respective owners. Fujitsu Components America or its affiliates do not warrant that the content of datasheet is error free. In a continuing effort to improve our products Fujitsu Components America, Inc. or its affiliates reserve the right to change specifications/datasheets without prior notice. Rev. November, 7. 7