UPF/HORIZONTAL 2-, VARIABLE SPEED GAS-FIRED FURNACE XV80 MODELS TUD2B060A9V3VB, TUD2B080A9V3VB TUD2C080A9V4VB, TUD2C080B9V4VB TUD2B00A9V3VB, TUD2C00A9V5VB TUD2C00B9V5VB, TUD2DA9V5VB TUD2DB9V5VB, TUD2DA9V5VB Two-Stage FanAssisted CombustionSystem PUB. NO. 22-650-3 Trane
General Features NATURAL GAS MODELS Central Heating furnace designs are certified by the American Gas Association for both natural and L.P. gas. Limit setting and rating data were established and approved under standart rating conditions using American National Standards Instirute standards. SAFE OPERATION The Integrated System Control has solid state devices, which continuously monitor for presence of flame, when the system is in the heaating mode of operation. Dual solenoid combination gas valve and regulator provide extra safety. QUICK Durable, cycle tested, heavy gauge aluminized steel heat exchanger quickly transfers heat to provide warm conditioned air to the structure. Low energy power vent blower, to increase efficiency and provide a positive discharge of gas fumes to the outside. BURNERS Multiport In-shot burners will give years of quiet and efficient service. All models can be converted to L.P. gas. INTEGRATED SYSTEM CONTROL Exclusively designed operational program provides total control of furnace limit sensors, blowers, gas valve, flame control and includes self diagnostics for ease of service. Also contains connection points for E.A.C./humidifier. AIR DELIVERY The variable speed, direct drive blower motor, has sufficient airflow for most heating and cooling requirements, will switch from heating to cooling speeds on demand from room thermostat. The blower door safety switch will prevent or terminate furnace operation when the blower door is removed. Some models are available with high efficiency blowers. STYLING Heavy gauge steel and wrap-around cabinet construction is used in the cabinet with baked-on enamel finish for strength and beauty. The heat exchanger section of the cabinet is completely lined with foil faced fiberglass insulation. This results in quiet and efficient operation due to the excellent acoustical and insulating qualities of fiberglass. Built-in bottom pan and alternate bottom, left or right side return air connection provision. FEATURES AND GENERAL OPERA- TION The XV80 High Efficiency Gas Furnaces employ a Hot Surface Ignition system, which eliminates the waste of a constant burning pilot. The integrated system control lights the main burners upon a demand for heat from the room thermostat. Complete front service access. a. Low energy power venter b. Vent proving pressure switch. Trane 2 22-650-3
Contents Feature Summary Features and Benefits Standard Equipment Optional Equipment General Data TUD2B060A9V3VB TUD2B080A9V3VB TUD2C080A9V4VB TUD2C080B9V4VB TUD2B00A9V3VB TUD2C00A9V5VB TUD2C00B9V5VB TUD2DA9V5VB TUD2DB9V5VB TUD2DA9V5VB Performance Data Electric Data Field Wiring Diagrams Dimensions 2 4 4 5 6 9 9 9 24 22-650-3 3
Features and Benefits XV80 STANDARD EQUIPMENT Upflow/Horizontal and Power supply 2-stage gas valve 2-speed venter speed blower motor Silicon Nitride hot surface igniter with adaptive heat up Integrated solid state control Attractive color accents Heavy gauge aluminized steel heat exchanger Multi-port In-shot burners Complete front service access Alternate bottom/left/right return air Slide out blower assembly Hinged blower door Perfect fit door catches Insulated blower door Gasketed blower door Internal filter rack Standard filter sizes Two-tone color Direct drive, variable speed motor Integrated solid state control with self-diagnostics Common vent capability Cleanable framed filters Optional L. P. conversion kit Left/right gas connection Accessory hook-up capability Selectable cooling fan off delay eliminates need for BAY24X0 time delay kit Enhanced cooling control 4 22-650-3
Features and Benefits XV80 OPTIONAL EQUIPMENT Thermostat, Mechanical 2-Stage Heating/-Stage Cooling... TAYSTAT24 [ ] Thermostat, Mechanical Heating Only With Fan Switch... BAYSTAT303 [ ] Thermostat, Mechanical Heating Only... BAYSTAT388 [ ] Thermostat, Heating/Cooling Single Stage (Mounts Horizontally)...AY28X092 [ ] Thermostat, Electronic Non-programmable -Stage Heating/-Stage Cooling... BAYSTAT370 [ ] Thermostat, Electronic Programmable (5-2) -Stage Heating/-Stage Cooling... BAYSTAT3 [ ] Thermostat, Heating/Cooling Single Stage (Mounts Vertically)... BAYSTAT305 [ ] Thermostat, Electronic Programmable 2-Stage Heating/2-Stage Cooling... TAYSTAT302C [ ] Thermostat, Electronic Programmable -Stage Heating/-Stage Cooling... TAYSTAT300C [ ] Propane Conversion Kit... BAYLPKT20A [ ] Electronic Air Filter, Perfect Fit High Efficiency (7-/2" Wide Gas Furnace)... TFM75A9FR0 [ ] Electronic Air Filter, Perfect Fit High Efficiency (2" Wide Gas Furnace)... TFM20A9FR0 [ ] Electronic Air Filter, Perfect Fit High Efficiency (24-/2" Wide Gas Furnace)... TFM2A9FR0 [ ] Electronic Air Filter, Perfect Fit Standard Efficiency (7-/2" Wide Gas Furnace)...TFP75A9FR0 [ ] Electronic Air Filter, Perfect Fit Standard Efficiency (2" Wide Gas Furnace)...TFP20A9FR0 [ ] Electronic Air Filter, Perfect Fit Standard Efficiency (24-/2" Wide Gas Furnace)...TFP2A9FR0 [ ] Coil Enclosure (7-/2" Wide Cabinets)...BAYCLE7A722A [ ] Coil Enclosure (2" Wide Cabinets)...BAYCLE2A230A [ ] Coil Enclosure (24-/2" Wide Cabinets)...BAYCLE24AA [ ] Side Filter Rack... BAYFLTR0 [ ] High Altitude Switch...BAYHALT249 [ ] Masonry Chimney Vent Kit (Upflow models only)...bayvent800b [ ] Filter Rack Kit... BAYRACK960A [ ] Available for models with 800 or greater which require an additional side return. 22-650-3 5
ENERAL DATA MODEL TYPE RATINGS 2 st Stage Input BTUH st Stage Capacity BTUH (ICS) 3 2nd Stage Input BTUH 2nd Stage Capacity BTUH (ICS) 3 Temp. rise (Min.-Max.) F. BER DRIVE Diameter - Width (In.) No. Used Speeds (No.) vs. in. w.g. Motor HP R.P.M. Volts / Ph / Hz COMBUSTION FAN - Type Drive - No. Speeds Motor HP - RPM Volts / Ph / Hz FLA FILTER Furnished? Type Recommended Hi Vel. (No.-Size-Thk.) VENT Size (In.) HEAT EXCHANGER Type -Fired -Unfired Gauge (Fired) ORIFICES Main Nat. Gas. Qty. Drill Size L.P. Gas Qty. Drill Size GAS VALVE PILOT SAFETY DEVICE Type BURNERS Type Number POWER CONN. V / Ph / Hz 4 Ampacity (In Amps) Max. Overcurrent Protection (Amps) PIPE CONN. SIZE (In.) DIMENSIONS Crated (In.) WEIGHT Shipping (Lbs.) / Net (Lbs.) TUD-R9V PRODUCT SPECIFICATIONS TUD2B060A9V3VB Upflow / Horizontal,000 3,0 60,000,000 30-60 Direct 0 x 7 See Airflow Table /2 Centrifugal Direct - 2 /50-3000 0.7 Yes High Velocity - 7x25 - in. 4 Round Alum. Steel - Type 3 3 56 Redundant - Two Stage Hot Surface Ignition Multi-port In-shot 3 0.5 5 /2 H x W x D 4-3/4 x 9-/2 x 30-/2 36 / 26 TUD2B080A9V3VB Upflow / Horizontal,000 4,600 80,000 64,000 30-60 Direct 0 x 7 See Airflow Table /2 Centrifugal Direct - 2 /50-3000 0.7 Yes High Velocity - 7x25 - in. 4 Round Alum. Steel - Type 4 4 56 Redundant - Two Stage Hot Surface Ignition Multi-port In-shot 4 0.5 5 /2 H x W x D 4-3/4 x 9-/2 x 30-/2 42 / 32 TUD2C080A9V4VB Upflow / Horizontal,000 4,600 80,000 64,000 30-60 Direct 0 x 0 See Airflow Table 3/4 Centrifugal Direct - 2 /50-3000 0.7 Yes High Velocity - x25 - in. 4 Round Alum. Steel - Type 4 4 56 Redundant - Two Stage Hot Surface Ignition Multi-port In-shot 4 2.9 /2 H x W x D 4-3/4 x 23 x 30-/2 66 / 55 Central Furnace heating designs are certified to ANSI Z2.47 / CSA 2.3 2 For U.S. applications, above input ratings (BTUH) are up to 2,000 feet, derate 4% per,000 feet for elevations above 2,000 feet above sea level. For Canadian applications, above input ratings (BTUH) are up to 4,500 feet, derate 4% per,000 feet for elevations above 4,500 feet above sea level. 3 Based on U.S. government standard tests. 4 The above wiring specifications are in accordance with National Electrical Code; however, installations must comply with local codes. 6 DATA SUBJECT TO CHANGE WITHOUT NOTICE 22-650-3
TUD-R9V PRODUCT SPECIFICATIONS MODEL TYPE RATINGS 2 st Stage Input BTUH st Stage Capacity BTUH (ICS) 3 2nd Stage Input BTUH 2nd Stage Capacity BTUH (ICS) 3 Temp. rise (Min.-Max.) F. BER DRIVE Diameter - Width (In.) No. Used Speeds (No.) vs. in. w.g. Motor HP R.P.M. Volts / Ph / Hz COMBUSTION FAN - Type Drive - No. Speeds Motor HP - RPM Volts / Ph / Hz FLA FILTER Furnished? Type Recommended Hi Vel. (No.-Size-Thk.) VENT Size (In.) HEAT EXCHANGER Type -Fired -Unfired Gauge (Fired) ORIFICES Main Nat. Gas. Qty. Drill Size L.P. Gas Qty. Drill Size GAS VALVE PILOT SAFETY DEVICE Type BURNERS Type Number POWER CONN. V / Ph / Hz 4 Ampacity (In Amps) Max. Overcurrent Protection (Amps) PIPE CONN. SIZE (In.) DIMENSIONS Crated (In.) WEIGHT Shipping (Lbs.) / Net (Lbs.) TUD2C080B9V4VB 5 Upflow / Horizontal,000 4,600 80,000 64,000 30-60 Direct 0 x 0 See Airflow Table 3/4 Centrifugal Direct - 2 /50-3000 0.7 Yes High Velocity - x25 - in. 4 Round Alum. Steel - Type 4 4 56 Redundant - Two Stage Hot Surface Ignition Multi-port In-shot 4 2.9 /2 H x W x D 4-3/4 x 23 x 30-/2 66 / 55 TUD2B00A9V3VB Upflow / Horizontal 65,000,000 00,000 80,000-70 Direct 0 x 7 See Airflow Table /2 Centrifugal Direct - 2 /50-3000 0.87 Yes High Velocity - 7x25 - in. 4 Round Alum. Steel - Type 5 5 56 Redundant - Two Stage Hot Surface Ignition Multi-port In-shot 5 0.8 5 /2 H x W x D 4-3/4 x 9-/2 x 30-/2 42 / 32 TUD2C00A9V5VB Upflow / Horizontal 65,000,000 00,000 79,000 35-65 Direct 0 x 0 See Airflow Table Centrifugal Direct - 2 /50-3000 0.87 Yes High Velocity - x25 - in. 4 Round Alum. Steel - Type 5 5 56 Redundant - Two Stage Hot Surface Ignition Multi-port In-shot 5 4.9 /2 H x W x D 4-3/4 x 23 x 30-/2 66 / 55 Central Furnace heating designs are certified to ANSI Z2.47 / CSA 2.3 2 For U.S. applications, above input ratings (BTUH) are up to 2,000 feet, derate 4% per,000 feet for elevations above 2,000 feet above sea level. For Canadian applications, above input ratings (BTUH) are up to 4,500 feet, derate 4% per,000 feet for elevations above 4,500 feet above sea level. 3 Based on U.S. government standard tests. 4 The above wiring specifications are in accordance with National Electrical Code; however, installations must comply with local codes. 5 Model uses high efficiency blower. 22-650-3 DATA SUBJECT TO CHANGE WITHOUT NOTICE 7
MODEL TYPE RATINGS 2 st Stage Input BTUH st Stage Capacity BTUH (ICS) 3 2nd Stage Input BTUH 2nd Stage Capacity BTUH (ICS) 3 Temp. rise (Min.-Max.) F. BER DRIVE Diameter - Width (In.) No. Used Speeds (No.) vs. in. w.g. Motor HP R.P.M. Volts / Ph / Hz COMBUSTION FAN - Type Drive - No. Speeds Motor HP - RPM Volts / Ph / Hz FLA FILTER Furnished? Type Recommended Hi Vel. (No.-Size-Thk.) VENT Size (In.) HEAT EXCHANGER Type -Fired -Unfired Gauge (Fired) ORIFICES Main Nat. Gas. Qty. Drill Size L.P. Gas Qty. Drill Size GAS VALVE PILOT SAFETY DEVICE Type BURNERS Type Number POWER CONN. V / Ph / Hz 4 Ampacity (In Amps) Max. Overcurrent Protection (Amps) PIPE CONN. SIZE (In.) DIMENSIONS Crated (In.) WEIGHT Shipping (Lbs.) / Net (Lbs.) TUD-R9V PRODUCT SPECIFICATIONS TUD2C00B9V5VB 5 Upflow / Horizontal 65,000,000 00,000 79,000 35-65 Direct 0 x 0 See Airflow Table Centrifugal Direct - 2 /50-3000 0.87 Yes High Velocity - x25 - in. 4 Round Alum. Steel - Type 5 5 56 Redundant - Two Stage Hot Surface Ignition Multi-port In-shot 5 4.9 /2 H x W x D 4-3/4 x 23 x 30-/2 66 / 55 TUD2DA9V5VB Upflow / Horizontal 78,000 62,0,000 97,000 35-65 Direct 0 x 0 See Airflow Table Centrifugal Direct - 2 /50-3000.4 Yes High Velocity - 24x25 - in. 4 Round Alum. Steel - Type 6 6 56 Redundant - Two Stage Hot Surface Ignition Multi-port In-shot 6 5.3 /2 H x W x D 4-3/4 x 26-/2 x 30-/2 93 / 8 TUD2DB9V5VB 5 Upflow / Horizontal 78,000 62,0,000 97,000 35-65 Direct 0 x 0 See Airflow Table Centrifugal Direct - 2 /50-3000.4 Yes High Velocity - 24x25 - in. 4 Round Alum. Steel - Type 6 6 56 Redundant - Two Stage Hot Surface Ignition Multi-port In-shot 6 5.3 /2 H x W x D 4-3/4 x 26-/2 x 30-/2 93 / 8 TUD2DA9V5VB Upflow / Horizontal 9,000 72,800,000,000-70 Direct 0 x 0 See Airflow Table Centrifugal Direct - 2 /50-3000.6 Yes High Velocity - 24x25 - in. 4 Round Alum. Steel - Type 7 7 56 Redundant - Two Stage Hot Surface Ignition Multi-port In-shot 7 5.3 /2 H x W x D 4-3/4 x 26-/2 x 30-/2 97 / 85 Central Furnace heating designs are certified to ANSI Z2.47 / CSA 2.3 2 For U.S. applications, above input ratings (BTUH) are up to 2,000 feet, derate 4% per,000 feet for elevations above 2,000 feet above sea level. For Canadian applications, above input ratings (BTUH) are up to 4,500 feet, derate 4% per,000 feet for elevations above 4,500 feet above sea level. 3 Based on U.S. government standard tests. 4 The above wiring specifications are in accordance with National Electrical Code; however, installations must comply with local codes. 5 Model uses high efficiency blower. 8 DATA SUBJECT TO CHANGE WITHOUT NOTICE 22-650-3
*UD2B060A9V3VB FURNACE AIRF () AND POWER () VS. WITH FILTER AIRF DIP SWITCH SW7 SW8 0. 0.3 0.5 0.7 0.9 ON ON 9 49 65 604 95 69 47 25 604 60 607 0 ST 663 44 75 694 42 684 42 68 42 85 686 42 2 OFF OFF 775 37 05 78 37 776 37 80 805 36 230 8 36 270 ON ON 83 55 0 88 54 50 88 54 85 837 53 2 842 53 280 2ND 907 49 99 0 942 47 2 9 46 300 959 46 330 OFF OFF 038 90 066 42 260 086 4 325 089 4 365 079 4 *UD2B060A9V3VB FURNACE COOLING AIRF () AND POWER () VS. WITH FILTER OUTDOOR UNIT SIZE (TONS) AIRF (350 / TON) DIP SWITCH SW SW2 SW3 SW4 0. 0.3 0.5 0.7 0.9 ON ON OFF ON 499 50 537 80 5 0 5 500 75.5 (0 / TON) ON ON OFF OFF 605 60 60 80 60 597 55 593 80 (0 / TON) ON ON ON OFF 649 75 68 0 665 665 80 672 2 (350 / TON) OFF ON OFF ON 680 80 722 25 680 50 696 90 696 225 2 (0 / TON) OFF ON OFF OFF 798 05 804 809 70 823 235 88 280 (0 / TON) OFF ON ON OFF 884 896 80 924 2 93 280 93 330 (350 / TON) ON OFF OFF ON 8 25 863 75 882 2 894 275 895 3 2.5 (0 / TON) ON OFF OFF OFF 984 70 07 225 038 295 07 330 07 375 (0 / TON) ON OFF ON OFF 25 2 38 35 50 370 6 5 6 475 (350 / TON) OFF OFF OFF ON 035 5 056 265 076 330 076 370 076 0 3 ** ** (0 / TON) OFF OFF OFF OFF 8 300 247 360 268 4 278 5 0 490 (0 / TON) OFF OFF ON OFF 380 4 500 2 550 350 550 235 5 NOTES:. *FIRST LETTER MAY BE "A" OR "T" 2. **FACTORY. 3. CONTINUOUS FAN : OR COOLING AIRF IS APPROXIMATELY 50% OF SELECTED COOLING VALUE. 4. 350 /TON IS RECOMMENDED FOR VARIABLE SPEED APPLICATION FOR COMFORT & HUMID CLIMATE : IS 0 /TON: 0 /TON IS FOR DRY CLIMATE. 22-650-3 DATA SUBJECT TO CHANGE WITHOUT NOTICE 9
*UD2B080A9V3VB FURNACE AIRF () AND POWER () VS. WITH FILTER AIRF DIP SWITCH SW 7 SW 8 0. 0.3 0.5 0.7 0.9 ON ON 800 00 790 49 35 765 50 55 750 0 730 53 230 ST 90 30 890 44 70 875 44 20 860 2 8 47 280 OFF OFF 060 37 88 0 38 2 00 265 00 30 000 350 ON ON 0 54 20 090 55 260 090 55 30 080 55 350 065 56 0 2ND MEDIUM ** ON OFF 2 300 2 355 2 230 460 25 49 500 OFF OFF 42 0 42 470 0 42 530 375 0 3 590 *UD2B080A9V3VB FURNACE COOLING AIRF () AND POWER () VS. WITH FILTER OUTDOOR UNIT SIZE (TONS) AIRF (350 /TON) DIP SWITCH SW SW 2 SW 3 SW 4 0. 0.3 0.5 0.7 0.9 OFF ON OFF ON 880 875 55 860 90 8 225 8 2 2.5 (0 /TON) OFF ON OFF OFF 0 70 000 5 990 2 980 280 960 3 (0 /TON) OFF ON ON OFF 0 20 0 260 0 3 00 350 00 385 (350 /TON) ON OFF OFF ON 0 90 00 2 000 260 000 30 990 3 3.0 (0 /TON) ON OFF OFF OFF 0 250 0 3 90 370 90 75 0 (0 /TON) ON OFF ON OFF 3 355 3 425 330 475 3 530 300 570 (350 /TON) OFF OFF OFF ON 25 265 20 330 20 375 0 0 85 465 3.5 ** ** (0 /TON) OFF OFF OFF OFF 0 7 5 385 575 330 0 (0 /TON) OFF OFF ON OFF 0 475 5 385 575 330 0 NOTES:. * First Letter may be "A" or "T" 2. ** Factory setting 3. Continuous Fan Setting: Heating or Cooling airflow is approximately 50% of selected Cooling value. 4. 350 cfm/ton is recommended for Speed application for COMFORT & HUMID CLIMATE setting; is 0 cfm/ton; 0 cfm/ton is for DRY CLIMATE setting 0 DATA SUBJECT TO CHANGE WITHOUT NOTICE 22-650-3
*UD2C080A9V4VB FURNACE AIRF () AND POWER () VS. WITH FILTER ST 2ND AIRF DIP SWITCH SW 7 SW 8 0. 0.3 0.5 0.7 0.9 ON ON OFF OFF ON ON OFF OFF 782 49 75 870 44 90 962 0 09 54 2 49 90 37 255 762 5 0 865 25 974 55 092 54 90 2 255 388 325 75 5 86 75 963 0 087 55 2 2 30 2 5 7 5 85 8 25 938 4 2 092 54 305 244 370 385 5 737 225 83 46 255 94 42 290 077 55 355 235 0 377 55 *UD2C080A9V4VB FURNACE COOLING AIRF () AND POWER () VS. WITH FILTER OUTDOOR UNIT SIZE (TONS) AIRF (350 /TON) DIP SWITCH SW SW 2 SW 3 SW 4 0. 0.3 0.5 0.7 0.9 ON ON OFF ON 863 90 865 30 8 75 8 2 83 255 2.5 (0 /TON) ON ON OFF OFF 995 5 005 70 989 20 973 260 956 305 (0 /TON) ON ON ON OFF 0 50 2 0 255 07 305 0 360 (350 /TON) OFF ON OFF ON 03 25 03 75 026 25 03 270 003 3 3.0 (0 /TON) OFF ON OFF OFF 63 70 78 230 88 285 83 3 78 5 (0 /TON) OFF ON ON OFF 39 2 337 305 344 365 3 4 336 5 3.5 (350 /TON) ON OFF OFF ON 82 0 6 2 2 295 2 350 2 4 (0 /TON) ON OFF OFF OFF 380 255 325 2 0 2 460 9 55 (0 /TON) ON OFF ON OFF 553 350 566 425 557 500 5 560 559 6 (350 /TON) OFF OFF OFF ON 386 255 330 8 5 2 460 0 5 4 ** ** (0 /TON) OFF OFF OFF OFF 590 360 593 4 59 55 8 575 576 650 (0 /TON) OFF OFF ON OFF 79 360 808 65 80 65 808 775 726 800 NOTES:. * First Letter may be "A" or "T" 2. ** Factory setting 3. Continuous Fan Setting: Heating or Cooling airflow is approximately 50% of selected Cooling value. 4. 350 cfm/ton is recommended for Speed application for COMFORT & HUMID CLIMATE setting; is 0 cfm/ton; 0 cfm/ton is for DRY CLIMATE setting 22-650-3 DATA SUBJECT TO CHANGE WITHOUT NOTICE
*UD2C080B9V4VB FURNACE AIRF () AND POWER () VS. WITH FILTER ST 2ND AIRF DIP SWITCH SW 7 SW 8 0. 0.3 0.5 0.7 0.9 ON ON OFF OFF ON ON OFF OFF 974 49 33 02 93 94 9 89 42 346 5 4 460 47 86 968 49 285 2 44 27 80 20 57 9 388 49 7 56 263 949 50 2 03 25 2 9 57 276 8 49 274 536 335 925 5 254 083 44 255 0 304 93 34 0 49 3 533 7 906 304 066 305 82 362 75 4 372 50 55 477 *UD2C080B9V4VB FURNACE COOLING AIRF () AND POWER () VS. WITH FILTER OUTDOOR UNIT SIZE (TONS) AIRF (350 /TON) DIP SWITCH SW SW 2 SW 3 SW 4 0. 0.3 0.5 0.7 0.9 ON ON OFF ON 842 7 89 4 789 63 756 7 7 249 2.5 (0 /TON) ON ON OFF OFF 956 90 9 928 96 90 2 884 298 (0 /TON) ON ON ON OFF 07 3 078 7 067 233 0 292 028 3 (350 /TON) OFF ON OFF ON 002 99 000 983 20 9 265 942 38 3.0 (0 /TON) OFF ON OFF OFF 28 55 9 50 256 32 39 4 379 (0 /TON) OFF ON ON OFF 278 65 3 238 36 308 305 377 287 444 3.5 (350 /TON) ON OFF OFF ON 63 34 8 99 77 265 6 328 389 (0 /TON) ON OFF OFF OFF 324 79 363 255 372 326 363 7 3 466 (0 /TON) ON OFF ON OFF 5 234 544 39 566 6 565 472 546 550 (350 /TON) OFF OFF OFF ON 324 79 363 255 372 326 363 7 3 466 4 ** ** (0 /TON) OFF OFF OFF OFF 508 2 570 329 594 7 593 3 575 562 (0 /TON) OFF OFF ON OFF 69 322 777 46 86 499 824 579 805 669 NOTES:. * First Letter may be "A" or "T" 2. ** Factory setting 3. Continuous Fan Setting: Heating or Cooling airflow is approximately 50% of selected Cooling value. 4. 350 cfm/ton is recommended for Speed application for COMFORT & HUMID CLIMATE setting; is 0 cfm/ton; 0 cfm/ton is for DRY CLIMATE setting 2 DATA SUBJECT TO CHANGE WITHOUT NOTICE 22-650-3
*UD2B00A9V3VB FURNACE AIRF () AND POWER () VS. WITH FILTER AIRF DIP SWITCH SW 7 SW 8 0. 0.3 0.5 0.7 0.9 ON ON 75 64 86 796 6 32 87 59 75 832 28 838 57 263 ST 862 56 2 92 85 953 5 233 967 50 285 954 50 322 OFF OFF 959 50 002 20 036 46 280 036 46 325 003 355 ON ON 099 67 227 24 66 287 49 64 355 57 64 055 70 5 2ND 286 365 32 56 0 33 56 5 25 6 475 9 66 0 OFF OFF 9 53 465 49 570 347 55 5 265 59 5 63 64 5 *UD2B00A9V3VB FURNACE COOLING AIRF () AND POWER () VS. WITH FILTER OUTDOOR UNIT SIZE (TONS) AIRF (350 /TON) DIP SWITCH SW SW 2 SW 3 SW 4 0. 0.3 0.5 0.7 0.9 ON ON OFF ON 56 50 536 75 55 05 547 35 530 65.5 (0 /TON) ON ON OFF OFF 3 59 65 92 633 27 62 57 68 8 (0 /TON) ON ON ON OFF 68 70 697 0 70 709 80 72 25 (350 /TON) OFF ON OFF ON 680 75 726 735 50 74 90 7 230 2.0 (0 /TON) OFF ON OFF OFF 769 03 89 8 90 8 235 865 286 (0 /TON) OFF ON ON OFF 882 30 938 90 96 2 975 300 970 3 (350 /TON) ON OFF OFF ON 83 80 903 80 928 230 935 275 935 3 2.5 (0 /TON) ON OFF OFF OFF 979 67 036 2 053 295 053 3 05 368 (0 /TON) ON OFF ON OFF 2 2 47 30 76 383 67 442 055 6 (350 /TON) OFF OFF OFF ON 06 20 08 265 095 3 0 382 032 380 3.0** ** (0 /TON) OFF OFF OFF OFF 85 278 223 364 25 5 5 5 0 426 (0 /TON) OFF OFF ON OFF 35 425 372 503 3 535 2 505 68 0 NOTES:. * First Letter may be "A" or "T" 2. ** Factory setting 3. Continuous Fan Setting: Heating or Cooling airflow is approximately 50% of selected Cooling value. 4. 350 cfm/ton is recommended for Speed application for COMFORT & HUMID CLIMATE setting; is 0 cfm/ton; 0 cfm/ton is for DRY CLIMATE setting 22-650-3 DATA SUBJECT TO CHANGE WITHOUT NOTICE 3
*UD2C00A9V5VB FURNACE AIRF () AND POWER () VS. WITH FILTER AIRF DIP SWITCH SW 7 SW 8 0. 0.3 0.5 0.7 0.9 ON ON 900 53 00 890 54 30 870 55 75 850 57 2 835 270 ST 25 50 090 44 0 060 46 235 070 300 070 3 OFF OFF 300 37 2 300 37 290 3 36 365 350 36 0 3 36 490 ON ON 270 59 0 290 260 290 335 290 0 280 460 2ND 575 47 355 600 46 4 60 46 5 600 46 575 0 47 650 OFF OFF 870 560 890 665 860 70 870 830 730 760 *UD2C00A9V5VB FURNACE COOLING AIRF () AND POWER () VS. WITH FILTER OUTDOOR UNIT SIZE (TONS) AIRF (350 /TON) DIP SWITCH SW SW 2 SW 3 SW 4 0. 0.3 0.5 0.7 0.9 ON ON OFF ON 075 35 055 85 05 2 000 265 990 325 3.0 (0 /TON) ON ON OFF OFF 2 85 0 2 20 295 20 350 20 (0 /TON) ON ON ON OFF 0 2 0 3 470 0 50 (350 /TON) OFF ON OFF ON 24 85 20 2 25 295 20 350 20 3.5 (0 /TON) OFF ON OFF OFF 0 30 460 355 470 0 460 500 4 555 (0 /TON) OFF ON ON OFF 6 370 665 460 650 5 6 65 60 660 (350 /TON) ON OFF OFF ON 5 270 0 30 4 375 4 0 4 550 4.0 (0 /TON) ON OFF OFF OFF 670 5 675 490 670 550 655 630 630 700 (0 /TON) ON OFF ON OFF 870 5 880 635 880 730 8 800 670 6 (350 /TON) OFF OFF OFF ON 775 0 800 0 8 680 800 750 680 7 5.0 ** ** (0 /TON) OFF OFF OFF OFF 65 755 8 9 900 805 880 623 800 (0 /TON) OFF OFF ON OFF 230 000 200 000 200 950 965 890 800 825 NOTES:. * First letter may be "A" or "T" 2. ** Factory setting 3. Continuous Fan Setting: Heating or Cooling airflow is approximately 50% of selected Cooling value. 4. 350 cfm/ton is recommended for Speed application for COMFORT & HUMID CLIMATE setting; is 0 cfm/ton; 0 cfm/ton is for DRY CLIMATE setting 4 DATA SUBJECT TO CHANGE WITHOUT NOTICE 22-650-3
*UD2C00B9V5VB FURNACE AIRF () AND POWER () VS. WITH FILTER AIRF DIP SWITCH SW 7 SW 8 0. 0.3 0.5 0.7 0.9 ON ON 953 50 93 944 50 46 936 5 93 908 2 887 54 292 ST 42 42 35 4 42 0 35 42 255 2 322 098 377 OFF OFF 2 38 69 260 38 2 256 38 302 236 38 378 227 7 ON ON 32 88 37 26 34 326 294 53 6 287 53 468 2ND 577 44 30 592 387 592 468 597 563 2 644 OFF OFF 7 2 76 6 762 575 753 675 762 774 *UD2C00B9V5VB FURNACE COOLING AIRF () AND POWER () VS. WITH FILTER OUTDOOR UNIT SIZE (TONS) AIRF (350 /TON) DIP SWITCH SW SW 2 SW 3 SW 4 0. 0.3 0.5 0.7 0.9 ON ON OFF ON 056 4 050 73 044 225 09 284 002 336 3.0 (0 /TON) ON ON OFF OFF 99 5 99 29 94 277 72 349 6 5 (0 /TON) ON ON ON OFF 342 98 3 273 3 3 326 422 3 6 (350 /TON) OFF ON OFF ON 223 224 227 29 287 98 36 87 48 3.5 (0 /TON) OFF ON OFF OFF 389 27 7 294 5 363 377 449 373 55 (0 /TON) OFF ON ON OFF 556 29 570 376 570 5 556 549 559 629 (350 /TON) ON OFF OFF ON 389 27 7 294 5 363 377 449 373 55 4.0 (0 /TON) ON OFF OFF OFF 0 303 595 389 595 469 2 565 5 647 (0 /TON) ON OFF ON OFF 770 4 793 507 795 598 787 698 797 80 (350 /TON) OFF OFF OFF ON 723 382 744 475 754 564 735 663 744 760 5.0 ** ** (0 /TON) OFF OFF OFF OFF 96 546 99 6 996 75 99 850 0 98 (0 /TON) OFF OFF ON OFF 299 754 227 875 227 983 297 067 987 9 NOTES:. * First letter may be "A" or "T" 2. ** Factory setting 3. Continuous Fan Setting: Heating or Cooling airflow is approximately 50% of selected Cooling value. 4. 350 cfm/ton is recommended for Speed application for COMFORT & HUMID CLIMATE setting; is 0 cfm/ton; 0 cfm/ton is for DRY CLIMATE setting 22-650-3 DATA SUBJECT TO CHANGE WITHOUT NOTICE 5
*UD2DA9V5VB FURNACE AIRF () AND POWER () VS. WITH FILTER AIRF DIP SWITCH SW7 SW8 0. 0.3 0.5 0.7 0.9 ON ON 007 57 4 062 54 77 084 53 285 063 54 303 063 54 350 ST 54 50 67 2 230 2 277 22 47 344 22 47 OFF OFF 288 8 39 44 273 30 44 330 349 3 460 ON ON 387 64 250 42 63 3 5 6 0 8 60 460 495 59 5 2ND 9 56 350 637 54 4 666 53 535 678 53 600 54 575 OFF OFF 77 50 475 788 50 560 804 49 650 75 5 675 554 57 590 *UD2DA9V5VB FURNACE COOLING AIRF () AND POWER () VS. WITH FILTER OUTDOOR UNIT SIZE (TONS) AIRF (See Notes) (350 / TON) DIP SWITCH SW SW2 SW3 SW4 0. 0.3 0.5 0.7 0.9 OFF ON OFF ON 95 50 2 225 235 275 25 325 25 3.5 (0 / TON) OFF ON OFF OFF 353 20 3 290 47 370 7 425 4 5 (0 / TON) OFF ON ON OFF 554 35 572 65 0 634 570 567 575 (350 / TON) ON OFF OFF ON 356 0 280 9 370 3 4 4 50 4 (0 / TON) ON OFF OFF OFF 565 3 4 633 475 6 560 554 575 (0 / TON) ON OFF ON OFF 766 0 799 550 80 650 784 685 590 600 (350 / TON) OFF OFF OFF ON 708 4 7 530 759 5 775 675 575 5 5 ** ** (0 / TON) OFF OFF OFF OFF 994 665 8 775 97 785 84 725 68 625 (0 / TON) OFF OFF ON OFF 2247 975 2 925 9 860 86 765 693 680 NOTES: "CONTINUOUS FAN " IS THERMOSTAT FAN SWITCH "ON" AND DIP SWITCHS 5 AND 6 "ON".. *FIRST LETTER MAY BE "A" OR "T" 2. **FACTORY. 3. CONTINUOUS FAN : OR COOLING AIRF IS APPROXIMATELY 50% OF SELECTED COOLING VALUE. 4. 350 /TON IS RECOMMENDED FOR VARIABLE SPEED APPLICATION FOR COMFORT & HUMID CLIMATE : IS 0 /TON: 0 /TON IS FOR DRY CLIMATE. 6 DATA SUBJECT TO CHANGE WITHOUT NOTICE 22-650-3
*UD2DB9V5VB FURNACE AIRF () AND POWER () VS. WITH FILTER AIRF DIP SWITCH S4-3 S4-4 0. 0.3 0.5 0.7 0.9 ON ON 050 99 044 46 46 035 46 8 005 47 2 980 30 ST 24 29 26 88 27 262 92 2 69 4 30 OFF OFF 288 37 47 293 37 22 298 37 293 275 37 309 254 38 373 ON ON 429 9 4 267 3 47 363 5 3 46 6 2ND 672 4 30 695 2 722 8 7 9 697 0 OFF OFF 782 385 809 38 0 890 36 623 835 37 565 87 37 644 *UD2DB9V5VB FURNACE COOLING AIRF () AND POWER () VS. WITH FILTER OUTDOOR UNIT SIZE (TONS) AIRF (See Notes) (350 / TON) DIP SWITCH S3- S3-2 S3-3 S3-4 0. 0.3 0.5 0.7 0.9 OFF ON OFF ON 8 28 9 86 20 260 85 306 62 370 3.5 (0 / TON) OFF ON OFF OFF 3 62 350 232 3 38 337 365 37 3 (0 / TON) OFF ON ON OFF 477 20 49 290 507 490 6 472 508 (350 / TON) ON OFF OFF ON 3 62 350 232 3 38 337 365 37 3 4.0 (0 / TON) ON OFF OFF OFF 496 28 5 300 8 3 5 447 494 5 (0 / TON) ON OFF ON OFF 650 296 67 387 698 5 686 5 67 626 (350 / TON) OFF OFF OFF ON 62 274 63 363 655 2 642 627 598 5.0 ** ** (0 / TON) OFF OFF OFF OFF 8 3 902 533 907 624 906 74 87 755 (0 / TON) OFF OFF ON OFF 87 5 226 7 20 797 98 888 0 953 NOTES: "CONTINUOUS FAN " IS THERMOSTAT FAN SWITCH "ON" AND DIP SWITCHS 5 AND 6 "ON".. *FIRST LETTER MAY BE "A" OR "T" 2. **FACTORY. 3. CONTINUOUS FAN : OR COOLING AIRF IS APPROXIMATELY 50% OF SELECTED COOLING VALUE. 4. 350 /TON IS RECOMMENDED FOR VARIABLE SPEED APPLICATION FOR COMFORT & HUMID CLIMATE : IS 0 /TON: 0 /TON IS FOR DRY CLIMATE. 22-650-3 DATA SUBJECT TO CHANGE WITHOUT NOTICE 7
*UD2DA9V5VB FURNACE AIRF () AND POWER () VS. WITH FILTER AIRF DIP SWITCH SW 7 SW 8 0. 0.3 0.5 0.7 0.9 ON ON 090 62 30 00 6 75 070 63 25 080 62 255 060 63 290 ST 230 55 80 265 53 235 280 53 35 300 380 300 5 OFF OFF 380 49 235 5 290 425 47 375 0 47 0 47 5 ON ON 5 67 3 550 67 385 560 67 475 560 67 5 575 66 605 2ND 760 59 5 790 5 80 6 800 695 725 60 725 OFF OFF 00 65 0 75 00 790 950 54 8 800 775 *UD2DA9V5VB FURNACE COOLING AIRF () AND POWER () VS. WITH FILTER OUTDOOR UNIT SIZE (TONS) AIRF (350 /TON) DIP SWITCH SW SW 2 SW 3 SW 4 0. 0.3 0.5 0.7 0.9 OFF ON OFF ON 75 65 65 0 80 265 70 3 50 0 3.5 (0 /TON) OFF ON OFF OFF 3 225 370 285 0 360 5 4 380 490 (0 /TON) OFF ON ON OFF 5 295 565 0 5 470 575 55 530 5 (350 /TON) ON OFF OFF ON 3 2 330 275 335 355 300 5 2 490 4.0 (0 /TON) ON OFF OFF OFF 550 30 0 0 590 475 555 5 460 60 (0 /TON) ON OFF ON OFF 735 0 735 50 70 600 670 675 590 70 (350 /TON) OFF OFF OFF ON 700 725 470 730 560 725 6 690 700 5.0 ** ** (0 /TON) OFF OFF OFF OFF 980 66 980 70 950 770 885 780 735 735 (0 /TON) OFF OFF ON OFF 290 835 250 870 75 890 905 800 735 735 NOTES:. * First Letter may be "A" or "T" 2. ** Factory setting 3. Continuous Fan Setting: Heating or Cooling airflow is approximately 50% of selected Cooling value. 4. 350 cfm/ton is recommended for Speed application for COMFORT & HUMID CLIMATE setting; is 0 cfm/ton; 0 cfm/ton is for DRY CLIMATE setting 8 DATA SUBJECT TO CHANGE WITHOUT NOTICE 22-650-3
WIRING DIAGRAM PRODUCT DATA From Dwg. D344249P02 22-650-3 DATA SUBJECT TO CHANGE WITHOUT NOTICE 9
PRODUCT DATA SCHEMATIC DIAGRAMS From Dwg. D344249P02 DATA SUBJECT TO CHANGE WITHOUT NOTICE 22-650-3
FIELD WIRING DIAGRAM FOR SINGLE ONLY PRODUCT DATA TO 5 V PH., 60 HZ., POWER SUPPLY PER LOCAL CODES M SEE HUM SEE NOTE 5 NOEE EA C SEE SETE 5 From Dwg. 2B3427 Rev. 0 FIELD WIRING DIAGRAM FOR TWO TO 5 V PH., 60 HZ., PO M WER SUPPL SEE Y PER E LOCAL CODES TE 5 HUM SEE NOTE 5 CEASC SEE NO TE TE 5 SEE From Dwg. 2B3426 Rev. 0 22-650-3 DATA SUBJECT TO CHANGE WITHOUT NOTICE 2
PRODUCT DATA FIELD WIRING DIAGRAM FOR SINGLE WITH SINGLE COOLING (OUTDOOR SECTION WITHOUT TRANSFORMER) From Dwg. 2B3425 Rev. FIELD WIRING DIAGRAM FOR TWO WITH SINGLE COOLING (OUTDOOR SECTION WITHOUT TRANSFORMER) From Dwg. 2B3424 Rev. 22 DATA SUBJECT TO CHANGE WITHOUT NOTICE 22-650-3
PRODUCT DATA FIELD WIRING DIAGRAM FOR TWO WITH TWO COOLING (OUTDOOR SECTION WITHOUT TRANSFORMER) TO 5 V PH., 60 HZ., PO WER SUPPL EEY PER LOCAL CODES SEE 5 HUM SEE WER NO TE 5 ER6 DE EA C SEE NOTE 5 ES L From Dwg. 2B3428 Rev. 0 22-650-3 DATA SUBJECT TO CHANGE WITHOUT NOTICE 23
PRODUCT DATA TUD-9V OUTLINE DRAWING (ALL DIMENSIONS ARE IN INCHES) MODEL A B C D *UD2B060A9V3V** *UD2B080A9V3V** *UD2B00A9V3V** *UD2C080A9V4V** *UD2C00A9V5V** *UD2C080B9V4V** *UD2C00B9V5V** *UD2DA9V5V** *UD2DA9V5V** *UD2DB9V5V** * - First Letter May Be "A" or "T" ** - Suffix Letters May Be "K" (0 Through 9) 7-/2" 9-5/8" 6-/4" 6" 2" 3-/6" 9-3/4" 9-/2" 24-/2" 5-5/6" 23-/4" 23" From Dwg. C34699 24 DATA SUBJECT TO CHANGE WITHOUT NOTICE 22-650-3
22-650-3 DATA SUBJECT TO CHANGE WITHOUT NOTICE 25
PRODUCT DATA Since the manufacturer has a policy of continuous product and product data improvement, it reserves the right to change the design and specifications without notice. Technical Literature - Printed in U.S.A. Trane 60 Troup Highway Tyler, TX 75707