Nellis Air Force Base Asbestos and Lead Based Paint Inspection Report

Transcription

1 Nellis Air Force Base Asbestos and Lead Based Paint Inspection Report Building Number: 432 Inspection Date: 2/12/2014 Nellis Work Order: Macrotec Job Number: Introduction: Macrotec Consulting, LLC. performed an inspection for Asbestos Containing Building Materials and Lead Based Paint. The intent of this inspection was to identify materials containing asbestos and lead, within the subject site, that may be impacted during planned renovation activities. Work Order Scope of Work: Conduct an additional survey of the building now that it is unoccupied, to accompany the original demolition survey (Report #11804) conducted at the building in Report Limitations: The information contained in this report pertains only to the specific area defined in the above scope of work. This summarized report is for reference purposes, only. A detailed generic report is on file with Nellis Air Force Base Civil Engineering. Only proper personnel should interpret this report to determine whether the information herein can be utilized for current and future renovation activities within the building. [email protected] Phone: (702) Fax: (702)

2 Macrotec Consulting, LLC. Appendix A - Asbestos Assessment Macrotec Job # Gym/Pool Demo The following table lists each of the materials suspected to contain asbestos at the subject site. For each material the sample number, location and laboratory result are listed. If the material was found to contain asbestos, the friablity and NESHAP classification is identified. 1 Plaster Ceiling This material is located on various ceilings throughout the building. AB1 AB2 AB3 None Detected 1st Floor - Office 1 - Cente None Detected 1st Floor - Office 2 - Cente None 1stDetected Floor - Womens Restroom - Ad 2 Black Mirror Mastic This material is located behind the mirrors throughout the building. Non-Friable, Category II AB4 AB5 10% 1st Chrysotile Floor - Womens Restroom - V 10% Chrysotile 2nd Floor - Weight Room - W 3 HVAC Damper Cloth This material is located on the building's HVAC ducts. AB6 None Detected Exterior - Mid Rubber Roof - E 4 Corrugated Insulation This material is on the middle rubber roof. AB7 None Detected Exterior - Mid Rubber Roof - E 5 TSI Endcap Over Fiberglass This material is located on the water lines running throughout the building. AB8 None Detected 1st Floor - Mech Room - W 6 TSI Beneath Hangers This material is located beneath pipe hangers on the chilled water supply/return, heating water supply/return, and the domestic hot water lines. AB9 AB10 AB11 None Detected 1st Floor - Hall - Adj. raquet None Detected 1st Floor - Trainers Office - S c None Detected 2nd Floor - Mech Room - E c Asbestos Survey Bldg. 432 Macrotec Job #14533 Appendix A

3 Macrotec Consulting, LLC. Appendix B - Lead Assessment Macrotec Job # Gym/Pool Demo Macrotec conducted analysis of the painted surfaces and/or bulk materials that may be impacted during the defined scope of work, using an XRF analyzer. No lead was detected during the inspection of the suspect materials. Appendix D lists the painted surfaces that were analyzed during this inspection along with its location and analysis result. Note: If suspect materials are found during renovation activities outside what was identified in this report, stop work immediately until further testing can be completed. Lead Paint Survey Bldg. 432 Macrotec Job #14533 Page 1

4 Sample Location Diagram N 2nd Floor Mech Room Weight Room AB5 AB11 1st Floor AB3 Womens Locker Bar Lobby AB7 Gym 1 AB6 AB4 Mens Locker VIP Locker Offices AB1 AB9 AB10 Kids Gym Racquet Ball Racquet Ball Racquet Ball Cardio Room Spin Room Fitness Office Mech Room Weight Room AB2 AB8 Laundry Gym 2 * Diagram Not Drawn To Scale Asbestos & Lead Based Paint Survey Nellis AFB, Bldg. 432 Macrotec Project # Appendix C

5 TRIANGLE ENVIRONMENTAL SERVICE CENTER, INC East Boundary Road, Suite B, Midlothian, VA fax: BULK ASBESTOS SAMPLE ANALYSIS SUMMARY CLIENT: CLIENT JOB/ #: JOB SITE: Macrotec Consulting 9724 Mild Weather Ct. Las Vegas, NV Bldg. 432 TESC LOGIN #: DATE OF RECEIPT: DATE OF ANALYSIS: DATE OF REPORT: ANALYST: AE 2/14/2014 2/18/2014 2/18/2014 F. Jiang TESC SAMPLE # CLIENT SAMPLE ID & GROSS DESCRIPTION ESTIMATED % ASBESTOS NON ASBESTOS % FIBERS NON FIBROUS % MATERIALS 1 AB1 / Gray granular, white powder 100% 2 AB2 / Gray granular, white powder 100% 3 AB3 / Gray granular, white powder 100% 4 AB4 / Black adhesive 10% Chrysotile 90% 5 AB5 / Black adhesive 10% Chrysotile 90% 6 AB6 / White fibers 98% Cellulose 2% 7 AB7 / Brown fibers 98% Cellulose 2% 8 AB8 / White powder, brown fibers 98% Cellulose 2% 9 AB9 / Gray powder, fibers 5% Cellulose 85% 10% Fiberglass Samples are analyzed in accordance with Interim Method for the Determination of Asbestos in Bulk Insulation Samples, EPA 600/M , Dec and "Method for the Determination of Asbestos in Bulk Building Materials", EPA 600/R-93/116, July None Detected: not detected at/or below the detected limit of method (Reporting limit: 1% Asbestos). Glass fiber is analyzed for quality control blank. TESC recommends by point count or Transmission Electron Microscopy (TEM), for materials regulated by the EPA NESHAP (National Emission Standards for Hazardous Air Pollutants) and found to contain less than ten percent (<10%) asbestos by Polarized Light Microscopy (PLM). Both services are available for an additional fee. This report shall not be reproduced, except in full written approval of Triangle Environmental Service Center, Inc. This report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. This test report relates only to the item(s) tested. NVLAP Lab Code: [ LEGEND =, Lino.=Linoleum, JC=Joint Compound] Reviewed By Authorized Signatory: Feng Jiang, MS Senior Geologist, Laboratory Director Yuedong Fang, Senior Geologist Tuesday, February 18, 2014 Page 1 of 2

6 TRIANGLE ENVIRONMENTAL SERVICE CENTER, INC East Boundary Road, Suite B, Midlothian, VA fax: BULK ASBESTOS SAMPLE ANALYSIS SUMMARY CLIENT: CLIENT JOB/ #: JOB SITE: Macrotec Consulting 9724 Mild Weather Ct. Las Vegas, NV Bldg. 432 TESC LOGIN #: DATE OF RECEIPT: DATE OF ANALYSIS: DATE OF REPORT: ANALYST: AE 2/14/2014 2/18/2014 2/18/2014 F. Jiang TESC SAMPLE # CLIENT SAMPLE ID & GROSS DESCRIPTION ESTIMATED % ASBESTOS NON ASBESTOS % FIBERS NON FIBROUS % MATERIALS 10 AB10 / Yellow powder, fibers 10% Synthetic 90% 11 AB11 / Yellow powder, fibers 15% Cellulose 85% Total Samples/Layers Analyzed: 11 Samples are analyzed in accordance with Interim Method for the Determination of Asbestos in Bulk Insulation Samples, EPA 600/M , Dec and "Method for the Determination of Asbestos in Bulk Building Materials", EPA 600/R-93/116, July None Detected: not detected at/or below the detected limit of method (Reporting limit: 1% Asbestos). Glass fiber is analyzed for quality control blank. TESC recommends by point count or Transmission Electron Microscopy (TEM), for materials regulated by the EPA NESHAP (National Emission Standards for Hazardous Air Pollutants) and found to contain less than ten percent (<10%) asbestos by Polarized Light Microscopy (PLM). Both services are available for an additional fee. This report shall not be reproduced, except in full written approval of Triangle Environmental Service Center, Inc. This report must not be used by the customer to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. This test report relates only to the item(s) tested. NVLAP Lab Code: [ LEGEND =, Lino.=Linoleum, JC=Joint Compound] Reviewed By Authorized Signatory: Feng Jiang, MS Senior Geologist, Laboratory Director Yuedong Fang, Senior Geologist Tuesday, February 18, 2014 Page 2 of 2

7 acrotec Phone: (702) Fax: ft client Name NqFB Project Name Gym/Pool Demo Project Location Eldg' a32 Technician Joto, n ntauittu Laboratory re, Stop at 1st Positive?: Y / N H # I Count 2 AB4 z Plqster Ceiling - Plaster Ceiling - Plaster Ceiling - Black //lirror /Ylastic ' nes Elack llliryor /llastic - AB6 ne7 Corrugated lnsulation - Bulk Sampling Ghain of Custody Form Composite Wall Substrate?: Y / N Sample Description n8a T5l Endcap O.ver Fiberglass - nb9 T5l Beneath Hangers - TSI Beneabh Hangers - T5l Eeneath Hangers - Project Number Collection Date WO Number Tum Around Time Method of Analysis Matrix Eulk Itts33 2/72/ Day PLM Sample Location st Floor Of(ice 7 - Center 7st Floor - Office 2 - Center st Floor - Nomens Restroom - Adj' showers st Floor - Nomens Restroom ' Vanity Area 2nd Floor - Neight Room ' Iil side Exterior - mid Rubber Roof - E side Exterior nid Rubber Roof - E side lst Floor - /llech Room - Lil side lst Floor - Hall ' Ad)' raquetball st Floor - Trainers Office - 5 corner.l2nd Floor - /l/lech Room - E corner Relinquished By: eceived By: Relinquished Received By:

8 Time Duration Component Substrate Side Color Building Floor Room Results Depth PbC PbC Error PbL PbL Error PbK PbK Error 2/12/ : Framing Metal D Red Hall, Adj. raquetball NEG 1 < LOD 0.03 < LOD 0.03 < LOD 4.5 2/12/ : Framing Metal D Red Hall, Adj. raquetball NEG 1 < LOD 0.03 < LOD 0.03 < LOD /12/ : Wall Metal D Brown Hall, Adj. raquetball NEG 1.19 < LOD 0.22 < LOD 0.22 < LOD /12/ : Wall Brick D White Hall, Adj. raquetball NEG 1.38 < LOD 0.03 < LOD 0.03 < LOD /12/ : Roof Metal Beige Roof NEG 1 < LOD 0.03 < LOD 0.03 < LOD /12/ : Roof Metal Beige Roof NEG 1 < LOD 0.03 < LOD 0.03 < LOD /12/ : Fascia Metal A Beige Roof NEG 1 < LOD 0.03 < LOD 0.03 < LOD /12/ : Roof Rubber/Foam Black Roof NEG 1 < LOD 0.03 < LOD 0.03 < LOD /12/ : Roof Deck Metal Gray Roof NEG 1 < LOD 0.03 < LOD 0.03 < LOD /12/ : Beam Metal White Weight Room NEG 1 < LOD 0.03 < LOD 0.03 < LOD /12/ : Beam Metal White Weight Room NEG 1 < LOD 0.03 < LOD 0.03 < LOD /12/ : Hanger Metal Yellow Hall, Adj. Mech Rm Null 1 < LOD 0.09 < LOD 0.09 < LOD /12/ : Hanger Metal Yellow Hall, Adj. Mech Rm NEG 1 < LOD 0.07 < LOD 0.07 < LOD 3.9 2/12/ : Hanger Metal Yellow Hall, Adj. Mech Rm NEG 2.92 < LOD 0.26 < LOD 0.26 < LOD /12/ : Truss Metal Red Hall, Adj. Mech Rm NEG 1 < LOD 0.03 < LOD 0.03 < LOD 4.44

9 Active CE Work WO/Request S: WO Indicator: Work Cl-ass: Labor Code-LUC: AF Account Code : RRf Code: whatrs Reimb? A11 : Lab: /:arj /(ah 6ff i aar. special Interest: Customer Account : cust/ce Priority: Work/Org Priority: Project Nun cer: Infrastruct.. Code: JOCAS JON: Deficiency: Fire Shops Assigned: PAL TIER Your modifications (1)Keys (2)First (9)Modify Order/ Reque st Page: l- RKMF A ASB/LBP TEST- FOR W/O Rec Statusr R S SERVICES CONTRACT Tracking Location: ASB/LB MON R Repair Tracking Status: ASB/L,D l-3 Inst/Facifity #: RKMF l-050 Requester's Name: A-LBERT VILLANO Organization: VACANT Mat: Office Symbol: VACANT Contr: Telephone Number: 8427 (G/S) facility Manager: KINGERY, DOUGLAS Fac Mgr Orgn: 99 FSS VACA Fac Mgr Phone: Work ljocacion: / Type of Service: DSW EPS Noun: EPS TTS Ref #: TTS Est Hours: 0,0 OSHA Other Travel/Work Zone: L / ]- RAC: DIN Number: 4 Capitalization: have been saved. (3 ) Desc ( 13 ) ttwcpud (17)Menu (l-8)remrks(19)logs (20)Pvscrn(21-)NxScrn(22) Shops N Vouch #: (8)Find /1() Drirr1- /14\Paf1.'.r (32)Exit