PART 4: SITE INFORMATION

Transcription

1 TRANSNET PIPELINES TENDER NUMBER: PYP/W1/6/21/1646 DESCRIPTION OF THE WORKS: CONSTRUCTION OF THE FIRE PROTECTION SYSTEM UPGRADE FOR THE FUEL HANDLING AREAS OF THE TARLTON DEPOT AND IRP REFRACTIONATOR ONLY INCLUSIVE OF DEMOLITION, CIVIL, STRUCTURAL, BUILDING, MECHANICAL, ELECTRICAL, INSTRUMENTATION AND CONTROL SYSTEM SUPPLY, INSTALLATION AND COMMISSIONING PART 4: SITE INFORMATION 1. Description of the Site and its surroundings 1.1. General description Tarlton Site: The site is located at the corner of Rustenburg (R400) and Ventersdorp Road (N14). The GPS coordinates are 26 4'42.89"S, 27 38'24.30"E. The site can be seen in the image below: The existing Site Layout information is presented in Annexure C4.1. The site is split into six operational areas; these are the rail loading area, tank farm, IRP area, offices and workshop, road tanker loading and road tanker staging areas. There are in most cases fences separating these areas. The primary entrance to the site is on the N14. This entrance passes directly to the truck staging area then through the security check point and into the site. The first building within the site is the office area, further northwest is the workshop then northwest of that is the tanker loading station then the additive dosing station then the spill basin. Adjacent to the offices to the south west is the existing fire pump house and reservoir; this is within the tank farm area. Further south west is the manifold which is adjoined to the tank farm then the control room in the south west corner. The whole south west edge of the site is the rail loading area, there is extensive staging with a loading gantry and associated pumping manifold approximately south west of the spill basin. The primary tank farm is roughly central on the site and is all contained in a single bund. There is a pump manifold to the north east of the bund area. NEC3 CONTRACT Page 1 of 10 Part C4 PRO-FAT-0226 Rev02 C4. Site Information

2 TRANSNET PIPELINES TENDER NUMBER: PYP/W1/6/21/1646 DESCRIPTION OF THE WORKS: CONSTRUCTION OF THE FIRE PROTECTION SYSTEM UPGRADE FOR THE FUEL HANDLING AREAS OF THE TARLTON DEPOT AND IRP REFRACTIONATOR ONLY INCLUSIVE OF DEMOLITION, CIVIL, STRUCTURAL, BUILDING, MECHANICAL, ELECTRICAL, INSTRUMENTATION AND CONTROL SYSTEM SUPPLY, INSTALLATION AND COMMISSIONING Finally there is the IRP area which falls between the rail loading, spill basin and primary tank farm towards the north of the site. This area includes a fuel processing facility as well as four storage tanks and a control room to the north west of the area adjacent to the spill basin. Cranage is likely to be required for the construction of the water tanks and the installation of some equipment into the pump house depending on the construction philosophy adopted. The space available in the area of this construction is limited however the buildings here are of limited height (Single story industrial construction). If there is any concern over the restriction of access for cranes, the relevant information should be requested immediately Existing buildings, structures, and plant & machinery on the Site This project is an upgrade on an existing facility and as such there are extensive existing buildings and facilities. There is a security upgrade being implemented on the site resulting in revisions to the site wide fencing, the entrance gates and guard houses as well as the office buildings. The available information for this upgrade is presented in Annexure C4.2. The interfaces for this project are the road and rail loading gantries, the tanks and the existing pumphouse and dam area. With regards to the gantries and tanks this information is presented in Annexure C4.3 and it useful for understanding of the scale of work required to fit equipment to these facilities. The available information for the pump house and reservoir is presented in Annexure C4.4 as there are to be temporary connections into the pumphouse, demolition of the pumphouse and demolition of and building in the area of the reservoir Sub-soil information There is extensive trenching required throughout the site as well as earthworks for foundations for the temporary and permanent tanks as well as the pumphouse and valve banks. There is an existing Geotechnical Report completed on the site and this is presented in Annexure C Hidden services This project entails extensive trenching for installation of buried pipes; as such it is necessary to establish as much information regarding the location of existing buried services as possible. The available drawings are therefore presented in Annexure C4.6. Further to this, the drawings for the security upgrade in Annexure C4.2 should also be consulted. All trenching work should be discussed with the site operations team in project meetings before work commences as they have extensive knowledge of the buried services on the site. As discussed in the Works Information and other documents there shall be a process of exploratory excavations implemented to attempt to detect routing problems before the major trenching reaches an obstruction. In developing the design the available information has been used and trench paths planned to avoid underground services wherever possible. Where information is limited the assumed straight line routed between draw boxes and the like have also been considered and avoided where possible. NEC3 CONTRACT Page 2 of 10 Part C4 PRO-FAT-0226 Rev02 C4. Site Information

3 TRANSNET PIPELINES TENDER NUMBER: PYP/W1/6/21/1646 DESCRIPTION OF THE WORKS: CONSTRUCTION OF THE FIRE PROTECTION SYSTEM UPGRADE FOR THE FUEL HANDLING AREAS OF THE TARLTON DEPOT AND IRP REFRACTIONATOR ONLY INCLUSIVE OF DEMOLITION, CIVIL, STRUCTURAL, BUILDING, MECHANICAL, ELECTRICAL, INSTRUMENTATION AND CONTROL SYSTEM SUPPLY, INSTALLATION AND COMMISSIONING 1.5. Facilities available to Contractor Water Supply Potable Water; litre JoJo tank filled at 500 l/min with 1 outlet located in the existing fire pumphouse Land available 1.6. ANNEXURES Possible land marked on GA seen in Annexure C4.7 REFER TO CD Annexure C4.1 Existing Site Layout Annexure C4.2 Security Upgrade Annexure C4.3 Tank and Gantry Information Annexure C4.4 Pump House and Reservoir Annexure C4.5 Geotechnical Report Annexure C4.6 Buried Services Annexure C4.7 Contractors Area GA NEC3 CONTRACT Page 3 of 10 Part C4 PRO-FAT-0226 Rev02 C4. Site Information

4 TRANSNET PIPELINES TENDER NUMBER: PYP/W1/6/21/1646 DESCRIPTION OF THE WORKS: CONSTRUCTION OF THE FIRE PROTECTION SYSTEM UPGRADE FOR THE FUEL HANDLING AREAS OF THE TARLTON DEPOT AND IRP REFRACTIONATOR ONLY INCLUSIVE OF DEMOLITION, CIVIL, STRUCTURAL, BUILDING, MECHANICAL, ELECTRICAL, INSTRUMENTATION AND CONTROL SYSTEM SUPPLY, INSTALLATION AND COMMISSIONING Annexure C4.1 Existing Site Layout NEC3 CONTRACT Page 4 of 10 Part C4 PRO-FAT-0226 Rev02 C4. Site Information

5

6

7 TRANSNET PIPELINES TENDER NUMBER: PYP/W1/6/21/1646 DESCRIPTION OF THE WORKS: CONSTRUCTION OF THE FIRE PROTECTION SYSTEM UPGRADE FOR THE FUEL HANDLING AREAS OF THE TARLTON DEPOT AND IRP REFRACTIONATOR ONLY INCLUSIVE OF DEMOLITION, CIVIL, STRUCTURAL, BUILDING, MECHANICAL, ELECTRICAL, INSTRUMENTATION AND CONTROL SYSTEM SUPPLY, INSTALLATION AND COMMISSIONING Annexure C4.2 Security Upgrade NEC3 CONTRACT Page 5 of 10 Part C4 PRO-FAT-0226 Rev02 C4. Site Information

8

9

10 TRANSNET PIPELINES TENDER NUMBER: PYP/W1/6/21/1646 DESCRIPTION OF THE WORKS: CONSTRUCTION OF THE FIRE PROTECTION SYSTEM UPGRADE FOR THE FUEL HANDLING AREAS OF THE TARLTON DEPOT AND IRP REFRACTIONATOR ONLY INCLUSIVE OF DEMOLITION, CIVIL, STRUCTURAL, BUILDING, MECHANICAL, ELECTRICAL, INSTRUMENTATION AND CONTROL SYSTEM SUPPLY, INSTALLATION AND COMMISSIONING Annexure C4.3 Tank and Gantry Information NEC3 CONTRACT Page 6 of 10 Part C4 PRO-FAT-0226 Rev02 C4. Site Information

11

12

13 TRANSNET PIPELINES TENDER NUMBER: PYP/W1/6/21/1646 DESCRIPTION OF THE WORKS: CONSTRUCTION OF THE FIRE PROTECTION SYSTEM UPGRADE FOR THE FUEL HANDLING AREAS OF THE TARLTON DEPOT AND IRP REFRACTIONATOR ONLY INCLUSIVE OF DEMOLITION, CIVIL, STRUCTURAL, BUILDING, MECHANICAL, ELECTRICAL, INSTRUMENTATION AND CONTROL SYSTEM SUPPLY, INSTALLATION AND COMMISSIONING Annexure C4.4 Pump house and Reservoir NEC3 CONTRACT Page 7 of 10 Part C4 PRO-FAT-0226 Rev02 C4. Site Information

14

15

16 TRANSNET PIPELINES TENDER NUMBER: PYP/W1/6/21/1646 DESCRIPTION OF THE WORKS: CONSTRUCTION OF THE FIRE PROTECTION SYSTEM UPGRADE FOR THE FUEL HANDLING AREAS OF THE TARLTON DEPOT AND IRP REFRACTIONATOR ONLY INCLUSIVE OF DEMOLITION, CIVIL, STRUCTURAL, BUILDING, MECHANICAL, ELECTRICAL, INSTRUMENTATION AND CONTROL SYSTEM SUPPLY, INSTALLATION AND COMMISSIONING Annexure C4.5 Geotech Report NEC3 CONTRACT Page 8 of 10 Part C4 PRO-FAT-0226 Rev02 C4. Site Information

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

65

66

67

68 TRANSNET PIPELINES TENDER NUMBER: PYP/W1/6/21/1646 DESCRIPTION OF THE WORKS: CONSTRUCTION OF THE FIRE PROTECTION SYSTEM UPGRADE FOR THE FUEL HANDLING AREAS OF THE TARLTON DEPOT AND IRP REFRACTIONATOR ONLY INCLUSIVE OF DEMOLITION, CIVIL, STRUCTURAL, BUILDING, MECHANICAL, ELECTRICAL, INSTRUMENTATION AND CONTROL SYSTEM SUPPLY, INSTALLATION AND COMMISSIONING Annexure C4.6 - Buried Services NEC3 CONTRACT Page 9 of 10 Part C4 PRO-FAT-0226 Rev02 C4. Site Information

69

70

71

72

73

74 TRANSNET PIPELINES TENDER NUMBER: PYP/W1/6/21/1646 DESCRIPTION OF THE WORKS: CONSTRUCTION OF THE FIRE PROTECTION SYSTEM UPGRADE FOR THE FUEL HANDLING AREAS OF THE TARLTON DEPOT AND IRP REFRACTIONATOR ONLY INCLUSIVE OF DEMOLITION, CIVIL, STRUCTURAL, BUILDING, MECHANICAL, ELECTRICAL, INSTRUMENTATION AND CONTROL SYSTEM SUPPLY, INSTALLATION AND COMMISSIONING Annexure C4.7 Contractors Area GA NEC3 CONTRACT Page 10 of 10 Part C4 PRO-FAT-0226 Rev02 C4. Site Information

75 "COPYRIGHT IS VESTED IN SiVEST IN TERMS OF THE COPYRIGHT ACT (ACT 98 OF 1978) AND NO USE OR REPRODUCTION OR DUPLICATION THEREOF MAY OCCUR WITHOUT THE WRITTEN CONSENT OF THE AUTHOR" THIS DRAWING HAS BEEN PREPARED UNDER THE CONTROLS ESTABLISHED BY THE SiVEST QUALITY MANAGEMENT SYSTEM AND MEETS THE REQUIREMENTS OF THE SETA QUALITY GRADING SYSTEM THAT IS ISO COMPLIANT GENERAL NOTES 1. THIS DRAWING PROVIDES INFORMATION RELATED TO THE FORM OF THE WORK WHEN COMPLETED TOGETHER WITH GUIDANCE, WHERE FUNDAMENTAL TO THE DESIGN, FOR THE SEQUENCE OF CONSTRUCTION. THIS DRAWING DOES NOT PURPORT TO INCLUDE ANY NECESSARY PRECAUTIONS, ITEMS OR COMPONENTS REQUIRED FOR CONSTRUCTION SAFETY. ALL SUCH PRECAUTIONS MUST BE TAKEN AND ITEMS OR COMPONENTS SUPPLIED BY THE CONTRACTOR. 2. ANY DISCREPANCIES ARE TO BE CONFIRMED WITH THE ENGINEER ON SITE PRIOR TO WORK PROCEEDING. 3. ONLY WRITTEN DIMENSIONS SHALL BE USED. 4. ALL DIMENSIONS ARE IN MILLIMETERS. ISSUED FOR REVIEW ES A Revision Details By Date Suffix DURBAN OFFICE 4 Pencarrow Crescent La Lucia Ridge Office Estate Umhlanga Rocks 4320 South Africa Tel Fax [email protected] Project Title Drawing Title DRAWN BY : DESIGNED BY : TARLTON CONTRACTOR DEPOT GENERAL LAYOUT Scale ON ORIGINAL PLAN :500 (A0) DATE: ES Pr No: * * SIGNATURE : DATE : CHECKED ON BEHALF OF SiVEST BY : Pr No: * * SIGNATURE : DATE : SiVEST Drawing Number TLR-M-3011 Revision A