SAW UT10580, UT10582 / 14 / 16 & UT10918

Transcription

1 HOMELITE UT10540, UT1054 / 14 in. 35cc CHAIN SAW UT1050, UT105 / 1 in. 3cc CHAIN SAW UT1050, UT105 & UT1091 / 1 in. 4cc CHAIN SAW (ALL VERSIONS) REPAIR SHEET Small Engine Parts

2 Figure A (See Figure C)

3 The model number will be found on a label attached to the engine housing. Always mention the model number in all correspondence regarding your CHAIN SAW or when ordering repair parts. PARTS LIST (FIGURE A) Chain Cover Assembly... 1 Guide Bar (with SAFE-T-TIP): UT10540, UT in UT1050, UT105 1 in UT1050, UT105, UT in Screw (-19 x 1/ in.) Inner Guide Plate Heat Shield Heat Shield Screw (1/4-0 x 5/ in.) Muffler Assembly Lock Nut (10-4) Screw (10-4 x 5/ in.) Heat Shield Muffler Gasket... 1 Chain (3/ in.): UT10540, UT link, 14 in UT1050, UT105 5 link, 1 in UT1050, UT105, UT1091 link, 1 in E-Clip Clutch Washer Sprocket Drum and Bearing Assembly (.35 chain) Screw (10-1 x 1 mm) Cylinder Cover Spark Plug (Champion RCJ4) Air Filter Oil Cap Assembly Fuel Cap Assembly Starter Cover Assembly Screw (M4 x 1 mm) Screw (10-1 x 4 mm, T5 Torx) Screw (#10-3 x.) Nut (#10-3) Exhaust Cover Nut, Muffler Screen U-Nut Exhaust Cover Gasket... 1 Not Shown: Scabbard: UT10540, UT in UT1050, UT105 1 in UT1050, UT105, UT in... 1 Starter Cover Labels: UT10540, UT cc UT1050, UT105-3 cc UT1050, UT105, UT cc... 1 Warning Labels: UT10540, UT cc UT1050, UT105-3 cc UT1050, UT105, UT cc UT10540, UT cc UT1050, UT105-3 cc UT1050, UT105, UT cc Starting Instruction Label Chain Brake Label Combination Wrench (UT105 only) Operator s Manual ( ) (Rev:0) 3

4 Figure B (See Figure D)

5 The model number will be found on a label attached to the engine housing. Always mention the model number in all correspondence regarding your CHAIN SAW or when ordering repair parts. PARTS LIST (FIGURE B) Oil Tank & Cap Assembly (Inc. Key Nos. -9 and 51) Fuel Tank & Cap Assembly (Inc. Key Nos. 10-1, 1 and 5) Screw (M5 x mm) Choke Lever Primer Bulb Primer Bulb Inlet Tube Switch Cone Spring Oil Pump Inlet Tube Fuel Line Inlet Fuel Line (L=10 mm) Fuel Filter Guide Bar Bolt (M x 4.3 mm) Main Chassis Engine Assembly Front Hand Guard Hand Guard Insert Hose Clamp Oil Pump Gear Spring Oil Pump Outlet Tube Thrust Washer Clutch Assembly Screw (M4 x 9.5 mm) Oil Pump Assembly Chain Brake Pin Spring Chain Break Pivot E-Ring Spring Pin Screw (M4 x 1 mm) Brake Band Chain Brake Linkage Spring Guide Spring Pin Speed Nut ( U -Type) Chain Brake Spring Chain Brake Cover Bar Bushing Rear Handle Screw (10-4 x 5/ in.) Isolator Spring Screw (10-14 x 1 mm) Anti-Vibe Strap Isolator Trigger Lock-Out Lever Trigger Return Spring Rear Handle Cover Throttle Rod Heat Shield Oil Tank Fuel Tank

6 Figure C Clutch Cover Ring Adjustment Knob Cover Knob Lock Spring Plate Tension Nut Bushing Clutch Cover Guide Bar Plate Thrust Washer... 1 PARTS LIST (FIGURE C) Chain Adjustment Gear Adjustment Rod Adjustment Pin Screw (4-1 x 10 mm) Screw (-19 x mm) Screw (-19 x 1/ in.) Gear Cover Spring

7 Figure D 10

8 The model number will be found on a label attached to the engine housing. Always mention the model number in all correspondence regarding your CHAIN SAW or when ordering repair parts. PARTS LIST (FIGURE D) Ignition Switch Harness Bolt (M5 x 5.4 mm) Ignition Module Short Block Assembly (Inc. Key Nos ) Intake Assembly (Inc. Key Nos. 0-31) Crankshaft & Piston Assembly (Inc. Key Nos. 1-1 and page 3, key no. 0) Flywheel Assembly Washer Flywheel Nut Screw (M5 x 4 mm) Crankshaft Case Crankshaft Seal Ball Bearing Crankshaft & Rod Assembly Spring Retainer Piston Pin Piston Piston Ring Cylinder Press Plate, Cylinder Bolt (M5 x 14 mm) Intake Boot Carburetor Air Filter Box Washer Bolt (M5 x 50 mm) Heat Dam Press Plate, Carb Carb Bracket Air Filter Throttle Rod... 1 Homelite Parts