BW65 / BW66 BORG WARNER. RWD 3 Speed 4.2. JP (Automatic Transmissions) Ltd Tel +44 (0) Pump Body.

Transcription

1 BW65 / BW66 RWD 3 Speed A Pump Body 777 Stator 778 Bell Hsg B Sun Gear Direct Clutch Direct Drum 909 Front Band 905 Front Servo C D Case 917 Gov. 781 Ext. Hsg. E Rev. Servo Rear Band Strut Assy Park Pawl Linkage

2 RWD 3 Speed BW65 / BW A Input Shaft Forward Clutch Hub Forward Drum B Center Support Sprag Rear Planet Reverse Band Ring Gear Output Shaft C Yoke V.B. Parts Valve Body D E 300 Oil Tubes

3 T65 / T66 RWD 3 Speed PART # PAPER & RUBBER KIT QTY. REFERENCE # Paper & Rubber Kit, T-65/T Up PART # OVERHAUL KITS QTY. REFERENCE # Overhaul Kit, T-65/T Up PART # MASTER L/STEEL KIT QTY. REFERENCE # Master L/Steels Kit, T-65/T Up PART # MASTER W/STEEL KIT QTY. REFERENCE # Master W/Steels Kit, T-65/T Up PART # FILTER QTY. REFERENCE # A...Filter, T-65/T Up PART # FILTER KIT QTY. REFERENCE # Filter Kit, T-65/T Up PART # BANDS QTY. REFERENCE # Band, T-65/T-66 Front (Flex) Band, T-65/T-66 Rear PART # BUSHINGS QTY. REFERENCE # Bushing Kit, T-65/T Bushing, T-65/T-66 Pump Body Bushing, T-65/T-66 Inner Pump Gear Bushing, T-65 Stator (Front) 23 Spline Input Shaft A...Bushing, T-65 Stator (Front) 26 Spline Input Shaft Bushing, T-65/T-66 Stator (Rear) Bushing, T-65/T-66 Input Shaft Bushing, T-65/T-66 Sun Gear & Planet (Rear) Bushing, T-65/T-66 Planet (Front, Large) Bushing, T-65/T-66 Output Shaft Bushing, T-65/T-66 Case Bushing, T-65/T-66 Extension Housing (1.510 OD)(1.380 ID)(1.210 Long)(Babbit) PART # METAL CLAD SEALS QTY. REFERENCE # Seal, T-65/T-66 Front (Except BMW) Seal, T-65/T-66 Front (BMW) 1973-Up Seal, T-65/T-66 Linkage Seal, T-65/T-66 Rear (Jaguar, Range Rover) (36 x 49.5 x 11mm) Seal, T-65/T-66 Rear (BMW) Seal, T-65/T-66 Speed-O Shaft PART # FRICTION CLUTCH QTY. REFERENCE # Friction, T-65/T-66 Front & Rear Clutch (.061 ) 1971-Up PART # STEEL CLUTCH QTY. REFERENCE # Steel, T-65/T-66 Forward Clutch (.068 ) Flat Steel, T-65/T-66 Direct Clutch (.068 ) (Dished) X...Steel, T-65/T-66 Direct Clutch (.090 ) (Dished) Oversized... AR Steel Module, T-65/T PART # CLUTCH PRESSURE PLATES QTY. REFERENCE # Pressure Plate, T-65/T-66 Direct Clutch (Top) Pressure Plate, T-65/T-66 Forward Clutch (Bottom) d

4 RWD 3 Speed T65 / T66 PART # OIL SEALING RINGS QTY. REFERENCE # Ring Kit, T-65/T Up PART # WASHERS & BEARINGS QTY. REFERENCE # Washer Kit, T-65/T Washer, T-65/T-66 Stator To Input Shaft Bearing, T-65/T-66 Direct Drum (Inner) Bearing, T-65/T-66 Direct Drum To Sun Gear Washer, T-65/T-66 Forward Drum To Direct Drum (Bronze) Washer, T-65/T-66 Forward Drum To Direct Drum (Steel) Washer, T-65/T-66 Input Shaft To Forward Clutch Hub Bearing, T-65/T-66 Sun Gear To Planet Race, T-65/T-66 Sun Gear To Planet (W/3 Flat Sides) Race, T-65/T-66 Planet To Output Shaft Bearing, T-65/T-66 Planet To Output Shaft Washer, T-65/T-66 Output Shaft To Case PART # GASKETS & RUBBER COMPONENTS QTY. REFERENCE # Gasket, T-65/T-66 Pan (Cork) V Gasket, T-65/T-66 Pump PART # TECHNICAL MANUALS QTY. REFERENCE # Technical Manual, T-65/T-66 Jaguar BW6566 PART # HARD PARTS QTY. REFERENCE # Pump, T-65 (Jaguar )With 23 Spline Input Shaft A...Pump, T-66 (Jaguar )With 26 Spline Input Shaft B...Pump, T-65 (BMW) Pump Body W/Gears, T-65/T Stator, T-65 (Jaguar) With 23 Spline Input Shaft A...Stator, T-66 (Jaguar) With 26 Spline Input Shaft B...Stator, T-65 (BMW) Drum, T-65/T-66 Forward Clutch B...Drum, T-65 (BMW) Forward Clutch Drum, T-65/T-66 Direct Clutch W/Sun Gear Piston Kit, T-65/T-66 Forward Clutch Piston Kit, T-65/T-66 Direct Clutch Clutch Hub, T-65/T-66 Forward C;utch Planet, T-65/T-66 (Jaguar) Race # 242 Has 3 Flat Sides (For Planet W/Round Race...Use A) Ring Gear, T-65/T-66 Planet Sun Gear, T-65/T-66 (Jaguar) Center Support, T-65/T PART # SPRAGS & ONE WAY CLUTCHES QTY. REFERENCE # Sprag, T-65/T Outer Race, T-65/T-66 Inside Planet PART # HARD PARTS (Continued) QTY. REFERENCE # Input Shaft, T-65/T Spline (Jaguar) A...Input Shaft, T-65/T Spline (Jaguar) Output Shaft, T-65/T-66 (25 Spline) (8 15/16 Long) Jaguar B...Output Shaft, T-65/T-66 (25 Spline) (9 15/16 Long) Jaguar Governor, T-65/T Valve Body, T-65/T-66 (Jaguar) PART # VALVE BODY COMPONENTS QTY. REFERENCE # S29741D-6K...End Plug Kit, T-65/T-66 Modulator Valve (Plug & O-Ring) In Valve Body (Sonnax) e

5 BW65 / BW66 RWD 3 Speed PART # HARD PARTS (Continued) QTY. REFERENCE # Bell Housing, T-65/T-66 (Jaguar) Case, T-65/T-66 (Jaguar) Extention Housing, T-65/T-66 (Jaguar) Nut, T-65/T-66 Holds Yoke To Output Shaft (Jaguar) Yoke, T-65/T-66 Output Shaft (Jaguar) Gear, T-65/T-66 Speed-O Drive Snap Ring, T-65/T-66 Holds Input Sahft To Forward Drum Snap Ring, T-65/T-66 Holds Return Spring In Forward Drum Snap Ring, T-65/T-66 Holds Direct Clutch Pressure Plate In Snap Ring, T-65/T-66 Holds Direct Clutch Retainer In Snap Ring, T-65/T-66 Holds Output Shaft To Ring Gear Servo Assembly, T-65/T-66 Front (Jaguar) Spring, T-65/T-66 Front Servo (Jaguar) Piston, T-65/T-66 Front Servo (Jaguar) Cover, T-65/T-66 Front Servo (Jaguar) Servo Assembly, T-65/T-66 Rear (Jaguar) Spring, T-65/T-66 Rear Servo (Jaguar) Cover, T-65/T-66 Rear Servo (Jaguar) Strut, T-65/T-66 Front Band Strut Assembly, T-65/T-66 Rear Band Strut, T-65/T-66 Rear Band Apply Bolt, T-65/T-66 Rear Band Adjusting Piston, T-65/T-66 Forward Clutch (Jaguar) Piston, T-65/T-66 Direct Clutch Spring, T-65/T-66 Forward Clutch Disc Spring (.075 ) Spring, T-65/T-66 Direct Clutch Return Retainer, T-65/T-66 Direct Clutch Spring Linkage Assembly, T-65/T-66 Internal (Jaguar) Park Pawl Assembly, T-65/T-66 (Jaguar) Oil Tube, T-65/T-66 Governor Feed (Jaguar) A...Oil Tube Set, T-65/T-66 (Jaguar) f

6 RWD 3 Speed BW65 / BW66 4.2g

7 BW35 RWD 3 Speed PART # PAPER & RUBBER KIT QTY. REFERENCE # Paper & Rubber Kit, T-35 Type 2 American A...Paper & Rubber Kit, T-35 Type 1 Foreign PART # OVERHAUL KITS QTY. REFERENCE # Overhaul Kit, T-35 Type 2 American A...Overhaul Kit, T-35 Type 1 Foreign PART # MASTER L/STEEL KIT QTY. REFERENCE # Master L/Steels Kit, T-35 Type 2 American A...Master L/Steels Kit, T-35 Type 1 Foreign PART # MASTER W/STEEL KIT QTY. REFERENCE # Master W/Steels Kit, T-35 Type 2 American A...Master W/Steels Kit, T-35 Type 1 Foreign PART # FILTER QTY. REFERENCE # Filter, T-35 American (Front) A...Filter, T-35 American (Front) AC...Filter, T-35 Foreign (Front) W/Out Scoop B...Filter, T-35 American (Rear) PART # FILTER KIT QTY. REFERENCE # Filter Kit, T-35 American A...Filter Kit, T-35 American (W/Shroud) AC...Filter Kit, T-35 Foreign (Front) W/Out Scoop PART # BANDS QTY. REFERENCE # Band, T-35 Front (Flex) 1962-Up A...Band, T-35 Front (Solid) (1 17/32 Wide) B...Band, T-35 Front (Solid) (1 27/32 Wide) Band, T-35 Rear PART # BUSHINGS QTY. REFERENCE # Bushing Kit, T Bushing, T-35 Pump Body Bushing, T-35 Inner Pump Bushing, T-35 Stator (Front) 22/23 Spline Input Shaft A...Bushing, T-35 Stator (Front) 26 Spline Input Shaft Bushing, T-35 Stator (Rear) Bushing, T-35 Input Shaft Bushing, T-35 Forward Drum With Sun Gear & Planet (Rear) Bushing, T-35 Planet Sprag Race Bushing, T-35 Output Shaft Bushing, T-35 Case Bushing, T-35 Extension Housing (1.510 OD)(1.380 ID)(1.210 Long)(Babbit) C...Bushing, T-35 Extension Housing (1.800 OD) (Closed Drive Shaft Type) PART # METAL CLAD SEALS QTY. REFERENCE # Seal, T-35 Front (Except BMW) 1962-Up Seal, T-35 Manual Lever Seal, T-35 Rear (2 OD) 1963-Up A...Seal, T-35 Rear (1 3/4 OD) 1963-Up PART # FRICTION CLUTCH QTY. REFERENCE # Friction, T-35 Front & Rear Clutch (.061 ) 1962-Up h

8 RWD 3 Speed BW35 PART # STEEL CLUTCH QTY. REFERENCE # Steel, T-35 Forward Clutch (.068 ) (Flat) 1962-Up Steel, T-35 Direct Clutch (.068 ) (Dished) 1962-Up X...Steel, T-35 Direct Clutch (.090 ) Oversize... AR Steel Module, T PART # MODULATORS QTY. REFERENCE # Modulator, T-35 Screw In PART # OIL SEALING RINGS QTY. REFERENCE # Ring Kit, T Up PART # GASKETS & RUBBER COMPONENTS QTY. REFERENCE # Gasket, T-35 Bottom Pan (Foreign) E7A A...Gasket, T-35 Bottom Pan (American) Gasket, T-35 Front Pump O-Ring, T-35 Front Pump O-Ring, T-35 Forward Clutch Drum (Inner) Foreign 1962-Up A...O-Ring, T-35 Forward Clutch Drum (Inner) American O-Ring, T-35 Direct Clutch (Inner) Foreign 1962-Up Lip Seal, T-35 Direct Clutch (Inner) Foreign 1962-Up B...Lip Seal, T-35 Direct Clutch (Inner) American Lip Seal, T-35 Direct Clutch (Outer) 1962-Up A...O-Ring, T-35 Filler Tube PART # HARD PARTS QTY. REFERENCE # A...Pump, T Pump Body, T-35 With Gears 1962-Up Drum, T-35 Forward Clutch (.800 ID Bore W/Out Oil Groove) A...Drum, T-35 Forward Clutch (.800 ID Bore With Oil Groove) B...Drum, T-35 Forward Clutch (.930 ID) 1970-Up Drum, T-35 Direct Clutch With Sun Gear (.850 ID Bushing) (1 3/4 Wide...Band Surface) A...Drum, T-35 Direct Clutch With Sun Gear (.850 ID Bushing) (2 Wide Band Surface) B...Drum, T-35 Direct Clutch With Sun Gear (1.00 ID Bushing) 1970-Up Planet, T-35 (1.850 OD Sun Gear On Shaft) (No ID Groove Next To Band Surface) A...Planet, T-35 (1.950 OD Sun Gear On Shaft) 1966-Up (With 1 Groove Next To Band Surface)... Race # 242 Is Round Sprag, T-35 Planet A...Input Shaft, T35 (23 Splines) A...Case, T-35 (Air Cooled) Uses A Rear Pump S29741D-6K...End Plug Kit, T-35 Modulator Valve (Plug & O-Ring) In Valve Body (Sonnax) Piston, T-35 Rear Servo A...Piston, T-35 Front Clutch 1962-E B...Piston, T-35 Front Clutch 1962-E69, L i

9 BW35TB / BW37TB FWD 3 Speed PART # PAPER & RUBBER KIT QTY. REFERENCE # Paper & Rubber Kit, BW35TB Saab A...Paper & Rubber Kit, BW37TB Saab & Saab PART # OVERHAUL KITS QTY. REFERENCE # Overhaul Kit, BW35TB Saab A...Overhaul Kit, BW37TB Saab & Saab PART # MASTER L/STEEL KIT QTY. REFERENCE # Master L/Steels Kit, BW35TB Saab A...Master L/Steels Kit, BW37TB Saab & Saab PART # MASTER W/STEEL KIT QTY. REFERENCE # Master W/Steels Kit, BW35TB Saab A...Master W/Steels Kit, BW37TB Saab & Saab PART # FILTER QTY. REFERENCE # Filter, BW35TB A...Filter, BW37TB B...Filter, BW37TB PART # FILTER KIT QTY. REFERENCE # Filter Kit, BW35TB A...Filter Kit, BW37TB B...Filter Kit, BW37TB PART # BANDS QTY. REFERENCE # Band, BW35TB / BW37TB Front (Flex) Band, BW35TB / BW37TB Rear PART # BUSHINGS QTY. REFERENCE # Bushing Kit, BW35TB / BE37TB Bushing, BW35TB / BW37TB Pump Body Bushing, BW35TB / BW37TB Input Shaft Bushing, BW35TB / BW37TB Direct Drum & Planet To Sun Gear (Rear) Bushing, BW35TB / BW37TB Planet To Center Support (Front) (2.855 ID) Bushing, BW35TB / BW37TB Output Shaft To Planet (1.260 ID) PART # METAL CLAD SEALS QTY. REFERENCE # Seal, BW35TB / BW37TB Pump Body Seal, BW37TB Pinion Seal, BW35TB Axle (Both) A...Seal, BW37TB Axle (Left Side) 1981-Up B...Seal, BW37TB Axle (Right Side) 1981-Up PART # FRICTION CLUTCH QTY. REFERENCE # Friction, BW35TB / BW37TB Forward & Direct Clutch (.061 ) Friction Module, BW35TB / BW37TB PART # STEEL CLUTCH QTY. REFERENCE # Steel, BW35TB Saab Forward Clutch (.068 ) Flat Steel, BW35TB Direct Clutch (.068 ) Dished X...Steel, BW35TB Direct Clutch (.090 ) Oversize Steel Module, BW35TB / BW37TB PART # CLUTCH PRESSURE PLATES QTY. REFERENCE # Pressure Plate, BW35TB / BW37TB Direct Clutch (Top) Pressure Plate, BW35TB / BW37TB Forward Clutch (Bottom) j

10 FWD 3 Speed BW35TB / BW37TB PART # OIL SEALING RINGS QTY. REFERENCE # Ring Kit, BW35TB / BW37TB PART # WASHERS & BEARINGS QTY. REFERENCE # Shim, BW35TB / BW37TB Front Plate Washer, BW35TB / BW37TB Front Plate Bearing, BW35TB / BW37TB Sun Gear Front & Rear Washer, BW35TB Forward Drum To Direct Drum (Front) A...Bearing W/Race, BW37TB Forward Drum To Direct Drum Washer, BW35TB Forward Drum To Direct Drum (Rear) Steel A...Race, BW37TB Forward Drum To Direct Drum (Front) Washer, BW35TB / BW37TB Input Shaft Washer, BW35TB / BW37TB Planet (Front) Washer, BW35TB / BW37TB Planet (Rear) Bearing, BW35TB / BW37TB Planet (Rear) Washer, BW35TB / BW37TB Governor To Seal Cover Cup Race, BW35TB / BW37TB Pinion Retainer (Front & Rear) Bearing, BW35TB / BW37TB Pinion Shim, BW35TB / BW37TB Pinion Shaft Ball Bearing, BW35TB / BW37TB Turbine Shaft Shim, BW35TB / BW37TB Driven Sprocket Bearing Ball Bearing, BW35TB / BW37TB Driven Sprocket To Case PART # GASKETS & RUBBER COMPONENTS QTY. REFERENCE # Gasket, BW35TB Bottom Pan (Rear) A...Gasket, BW37TB Bottom Pan (Rear) AB...Gasket, BW37TB Bottom Pan (Rear) B...Gasket, BW35TB Bottom Pan (Front) BA...Gasket, BW37TB Bottom Pan (Front) BB...Gasket, BW37TB Bottom Pan (Front) Gasket, BW35TB / BW37TB Side Cover Gasket, BW35TB / BW37TB Transmission Case To Engine Gasket, BW35TB / BW37TB Differential Cover Gasket, BW35TB / BW37TB Chain Cover O-Ring, BW35TB / BW37TB Pump Gasket, BW35TB / BW37TB Bell Housing To Case A...O-Ring, BW35TB / BW37TB Filler Tube PART # TECHNICAL MANUALS QTY. REFERENCE # Technical Manual, BW35TB / BW37TB Saab PART # HARD PARTS QTY. REFERENCE # Pump, BW35TB A...Pump, BW37TB Pump Body W/Gears, BW35TB (Thin Gears) A...Pump Body W/Gears, BW37TB (.750 Thick Gears) Stator, BW35TB Support A...Stator, BW37TB Support PART # PUMP COMPONENTS QTY. REFERENCE # Plate, BW35TB Pump A...Plate, BW37TB Pump PART # HARD PARTS (Continued) QTY. REFERENCE # Drum, BW35TB Forward Clutch (Washer Type) A...Drum, BW37TB Forward Clutch (Bearing Type) Drum, BW35TB Fdirect Clutch (Washer Type) A...Drum, BW37TB Direct Clutch (Bearing Type) Piston Kit, BW35TB / BNW37TB Forward Clutch Piston Kit, BW35TB / BW37TB Direct Clutch Clutch Hub, BW35TB / BW37TB Forward Clutch Planet, BW35TB k

11 BW35TB / BW37TB FWD 3 Speed PART # HARD PARTS (Continued) QTY. REFERENCE # A...Planet, BW37TB Ring Gear, BW35TB A...Ring Gear, BW37TB Sun Gear, BW35TB A...Sun Gear, BW37TB Center Support, BW35TB / BW37TB A...Center Support, BW37TB Center Plate, BW35TB A...Center Plate, BW37TB PART # SPRAGS & ONE WAY CLUTCHES QTY. REFERENCE # Sprag, BW35TB / BW37TB (Use ) Sprag, BW35TB / BW37TB...1 PART # HARD PARTS (Continued) QTY. REFERENCE # Input Shaft, BW35TB (2 Ring) A...Input Shaft, BW37TB (3 Ring) Turbine Shaft, BW35TB / BW37TB Output Shaft, BW35TB (No Rings) A...Output Shaft, BW37TB (With 3 Rings) Governor, BW35TB A...Governor, BW37TB Cover, BW35TB Pinion Seal A...Cover, BW37TB Pinion Seal Chain, BW35TB A...Chain, BW37TB Sprocket, BW35TB / BW37TB Drive (40 Teeth) A...Sprocket, BW35TB / BW37TB Drive (39 Teeth) Sprocket, BW35TB / BW37TB Drive (38 Teeth) A...Sprocket, BW35TB / BW37TB Drive (35 Teeth) B...Sprocket, BW35TB / BW37TB Drive (37 Teeth) Differential Housing, BW35TB / BW37TB (Year Model) (Height) Ring Gear, BW35TB / BW37TB (Year Model) (# Teeth) Pinion, BW35TB / BW37TB (Year Model) (# Teeth) Housing, BW35TB Pinion (Cast Iron) A...Housing, BW37TB Pinion (Aluminum) Valve Body, BW35TB A...Valve Body, BW37TB Bell Housing, BW35TB A...Bell Housing, BW37TB AA...Bell Housing, BW37TB Cover, BW35TB Sprocket A...Cover, BW37TB Sprocket Cover, BW35TB Differential A...Cover, BW37TB Differential Case, BW35TB / BW37TB (Year, Model, Cast #) Cover, BW35TB / BW37TB Side Pan, BW35TB / BW37TB Bottom Nut, BW35TB / BW37TB Holds Drive Sprocket On Nut, BW35TB / BW37TB Holds Driven Sprocket On Nut, BW35TB / BW37TB Pinion Snap Ring, BW35TB / BW37TB Holds Input Shaft To Forward Drum Snap Ring, BW35TB / BW37TB Holds Forward Return Spring Snap Ring, BW35TB / BW37TB Holds Direct Retainer In Snap Ring, BW35TB / BW37TB Holds Output Shaft To Ring Gear Snap Ring, BW35TB / BW37TB Holds Ball Bearing To Pump Snap Ring, BW35TB / BW37TB Holds Bearing To Case Servo Assembly, BW35TB / BW37TB Front Servo Assembly, BW35TB / BW37TB Rear Accumulator Assembly, BW35TB / BW37TB Piston, BW35TB / BW37TB Forward Clutch Piston, BW35TB / BW37TB Direct Clutch Spring, BW35TB / BW37TB Forward Disc Spring (.075 ) Spring, BW35TB / BW37TB Direct Clutch Return Retainer, BW35TB / BW37TB Direct Clutch Oil Tube Set, BW35TB / BW37TB l

12 FWD 3 Speed BW35TB / BW37TB 224 IMPORT LE Self-Diagnostic Information NPR, FUSO There are only 13 components that will cause the Check Trans light to illuminate. 1. Vehicle Speed Sensor #1 2. Engine Speed Sensor 3. Transmission fluid sensor 4. Inhibitor Switch 5. Throttle Position Sensor 6. Vehicle Speed Sensor#2 7. SS#1 8. SS#2 9. Timing Solenoid 10. TCC Solenoid 11. EPC Solenoid 12. Exhaust Brake Solenoid 13. Engine Warming sensor 2004 ATRA. All Rights Reserved 4.2m