Port inforation & safety regulations
contents Introduction 3 Access - Safety 4 Safe access to ships 5 Sall ships at low tide 6 Mooring at Scheldt River Berths and Deurganck dock 8 Recoended configurations of ships lines 9 Safe and Sound 14 Deurganck dock Fenders and bollards 15 Safety and Inforation Rules & regulations
Introduction Access - Safety Various incidents have arisen in the past due partly to poor knowledge and incorrect application of the safety regulations. Clearly, therefore, there is a need to ake these regulations better known. A for regarding the safety rules fro the Joint Coittee for Prevention and Protection at the Port of Antwerp will be presented to the aster to be signed for acknowledgent. This folder is issued on behalf of Antwerp Port Authority, the local Safety Coittee, the Pilotage and stevedores. It is aied at ship s asters, inforing the about the local safety regulations regarding safe access and ooring. It also gives the general layout of the tidal berths. Below is a detailed gangway/accoodation ladder checklist for vessels. Although it ight see that this inforation concerns the tidal berths only, the regulations are applicable in the whole port area. Ship owners, ship operators, asters and their respective representatives are reinded of their responsibility under international and local regulations to provide safe access to and fro the ship. 7 4 9 5 1 3 8 6 If no safe access no access! 1 Rope guardrails tight Stanchions free of distortion and all in place 3 Safety net positioned between ladder and ship 4 Hoisting arrangeents clear of head height 5 Steps free of oil, grease and ice 6 Botto platfor level (where fitted) 7 Lighting arrangeents positioned effectively 8 Base clear of obstructions 9 Lifebuoy with light / line with float available 3
Safe access to ships Sall ships at low tide Gangway fro accoodation Gangway fro accoodation 4 5
Mooring at Scheldt River Berths and DEURGANCK DOCK Nuber of shiplines: iniu iposed VESSEL LENGTH Headlines FWD Spring Aft Spring STERN LINES 4 4 Prohibition of ooring on autoatic winches solely >50 180-50 3 3 The attention of asters is drawn to the fact that on several occasions in the past, ships oored at river terinals and in the Deurganck dock with all ooring lines on autoatic tension winches, have shifted over a distance of ore then 0 etres along the quay, due to the wake and suction of passing vessels cobined with current. This has resulted in broken lines, daage to gangways and extreely dangerous situations in relation to gantry cranes. 140-180 <140 1 1 For this reason ooring on autoatic tension winches solely is not allowed according art. 48 of the Antwerp Port Police Regulations and inforation Note to Port Custoers N 56. - - - - Ships over 50 in length fore : 4 headlines and springs, aft 4 sternlines and springs Ships between 180 and 50 fore: 3 headlines and springs, aft 3 sternlines and springs Ships between 140 and 180 fore: headlines and springs, aft sternlines and springs Ships saller than 140 fore: headlines and 1 spring, aft sternlines and 1 spring Mooring recoendations Sufficient lines to keep the vessel properly oored should be belayed on bollards at all ties, or, when fitted on drus, with the brake on and the winch disengaged. Additional lines ay be put on autoatic tension control only if there is already the iniu nuber of other lines. Miniu requireents CONSTANT STAND-BY AND SUPERVISION IS REQUIRED, IN ORDER FOR SLACK TO BE GIVEN OUT OR TAKEN IN, SO AS TO KEEP THE LINES PROPERLY TENSIONED Ships ust be safely oored alongside according to the rules of good seaanship. Slack lines ust be avoided. In case of noncopliance the aster ay be suoned and fined. (A coplete version of this regulation ay be obtained fro the dockaster or stevedore.) The following iniu requireents ust be respected regarding the nuber of ooring lines in relation to the ship s length. Additional lines ust be used whenever the conditions require (these additional lines ay be put on autoatic tension control). 6 7
Recoended configurations of ships lines Ship > 50 : iniu 4---4 Safe and Sound Crew ebers ust observe the following safety precautions, both on board and ashore: - Personal protection ust be worn at all ties, including hard hat, safety shoes etc. - Crew ebers ust keep out of the operational area of the gantry cranes at all ties. Ship 180 50 : iniu 3---3 Safety helet Safety shoes Protective clothing Ship 140 180 : iniu --- Ship < 140 : iniu -1-1- 8 9
Safety and Inforation On river Zandvliet control centre VHF channel 1 In port Antwerp Port Authority Dockaster: VHF channel 63 Port Traffic Control: VHF channel 18 1 B Nr. A cable channel gantry rail MLW MHW A Nr. B distance: 0,0 Top view 3 Nr. built-up ladder every 60 ladder sunk in wall every 60 ax. 1.55 MLW-1.5 MLW+4.7 Nr. Cross-section Front view MLLWS+9.4 MLW+8.97 DEURGANCK DOCK Fenders and bollards 13
90 o 87a len 54 3 7,8 50 03 7 (8 3 or ho sc ) (9 6 en a lg ng LL 50 7 al 340 0 60 Ouden Doel beacon al 4 130 1708 30 8 Antwerp Gateway terinal 5 5. 171 176 18 8.5 1140 178 105 4 1710 L1 1730 1714 ooring post 154 17 LL 174 40 Tugs: VHF channel 61 1716 93 70 0 170 1718 ooring post 15 Future Deurganck lock DABL, Septeber 008 PEL To t 851 To t 165 Iso 4s 1706 LL nd n D e ur g a eu r g nck an ck dock do No ck r So th 1 ut h, 13,3 65 173 0 5 5 5 91 60 1734 853 Phenolcheie 0 855 Tugs: VHF channel 06 t7 18 5 8 57 (9 7 ) 95 859 o 1700 or in gp os 170 1704 89a FR 8 61 1736 0 Europa terinal 337, /157, 86 3 1738 475 Deurganck terinal 35 86 5 1740 The World s Port of Call 5 0 45 50 60 0 74 0 Iso 1.5s 89 Turning circle 600 867 88 5 0 490 FG g p 1744 os t 86 174 ) in 0 86 9 or 480 90 3 400 lde o 905 he 640 9 07 34 0 87 909 80 0 5 Noordzee terinal 9 /11 s1 911 0 6 70 Sc FI 3 913 85a Ra LLn LLn Doel 188,5 75 0 490 1 FIW 10 M R 3 s 9 86 9 Doel 80 0/7 M LLn Scheldeolen QFl W 37,8 160 118 DABL, July 007 Iso 1.5s 34 0 84
Antwerp Port Authority Port House Entrepotkaai 1 000 Antwerp Belgiu T +3 (0)3 05 0 11 F +3 (0)3 05 0 8 E info@haven.antwerpen.be www.portofantwerp.co Colophon Responsible editor Annik Dirkx Design and layout Catapult, Antwerp Photography Antwerp Port Authority Paper Arctic The Volue (FSC-certified) January 009