Electrical Page 7-1
Switch Cabinet Page 7-2 Electrical
Switch Cabinet Item Part Num. Number Qty. Description Notes 1 52002053 1 Cabinet - Switch, Assembly For Thomas Forward Control 2 68000868 1 Insulator - Switch Cabinet 3 52002232 AR Blank - Switch 4 22012379 1 Bushing - Snap, 3/4", with Stop Sign 67000164 1 Plug - Dome, 7/8" without Stop Sign 5 29920003 AR Screw - Tapping, #10 x 5/8", Phillips 6 65002813 1 Plug - Dome, 5/8" 7 67000178 1 Plug - Dome, 1/2" 8 53001383 AR Trim - Edging (Order by foot.) 9 52002188 1 Lamp - Wiper Illumination 52002216 1 Lamp - Wiper Standoff Illumination 10 53001447 1 Diffuser - Round 67000131 1 Plug - Button, For 2 1/2" Diameter Hole 11 52002077 1 Switch - Rocker, Defrost, High/Low 12 52002078 1 Switch - Rocker, Left Heater, High/Low 13 52002084 1 Switch - Rocker, Interior, On/Off 14 52000794 1 Switch - Heater & Fan Double 15 52000242 1 Switch - Electric Windshield Wiper, with Circuit Breaker Not Shown 69005034 1 Bushing - Snap, 9/16", Access Door Release Rod 52002140 1 Panel - Storage Compartment End 06/06/95 67000141 1 Grommet - Rubber, 3/8", Inside Diameter Electrical Page 7-3
Panel and Components Page 7-4 Electrical
Panel and Components Item Part Num. Number Qty. Description Notes 1 52002183 1 Block - Fuse/CB, 6/4 Circuits 2 52002242 1 Block - Fuse/CB, 20 Circuits 3 52002252 AR Jumper - Copper Bar, CB Block to CB Block 4 52002256 AR Jumper - Copper Bar, Solenoid to CB Block 5 52000103 AR Solenoid, 100-Amp, Coninuous Duty 6 52002192 1 Jumper - Chassis Solenoid to Body Solenoid 7 22016365 AR Buzzer - Warning, 12-Volt Metal 8 52001449 1 Panel - Electrical Body, In Switch Cabinet End 04/18/95 60002101 1 Panel - Electrical, Pusher and Forward Control Start 04/18/95 9 52002264 1 Decal - CB/Block, 20 Circuit 10 52002265 1 Decal - CB/Block, 10 Circuit 11 52000774 1 Breaker - Circuit, 20 Amp 52000776 1 Breaker - Circuit, 30 Amp 52000721 1 Breaker - Circuit, 6 Amp 52000515 1 Fuse - 20 Amp, Autofuse 52000517 1 Fuse - 30 Amp, Autofuse Electrical Page 7-5
Wiring Harnesses MVP-EF Main Body 52002051 Harness - Front End, Main Body, Overhead 52001638 Harness - Rear End, Main Body, with Metri Pack, 10 Window and 10 Window + 10, 52001410 Harness - Rear End, Main Body, with Metri Pack, 11 Window, 52001411 Harness - Rear End, Main Body, with Metri Pack, 12 Window, 52001412 Harness - Rear End, Main Body, with Metri Pack, 13 Window, 52001413 Harness - Rear End, Main Body, with Metri Pack, 14 Window, Switch Cabinet Harnesses 52001393 Harness - Wiring Interior Lights with Metri Pack 52001394 Harness - Wiring Door Buzzer with Metri Pack Wiper Harness 52001637 Harness - Wiring Electric Windhield Wiper with Metri Pack Front Heater and Wiper 52002179 Harness - Wiring Front Heater and Electric Wiper Harness & Jumper Wiring 22054376 Harness and Jumper Wiring Forward Control Page 7-6 Electrical
This page intentionally left blank. Electrical Page 7-7
Headlight Page 7-8 Electrical
Headlight Item Part Num. Number Qty. Description Notes 1 52000146 2 Headlight - Single, 200 MM Rectangular End 10/13/94 52001886 2 Headlight - Single, 200 MM Rectangular Start 10/13/94 52000147 2 Bezel - Chrome 52001891 2 Headlamp - Sealed Beam, Hi - Low Beam 85520127 2 Base - Housing Electrical Page 7-9
Marker Lights Page 7-10 Electrical
Marker Lights Item Part Num. Number Qty. Description Notes 1 22019370 AR Light - Marker, Red, No Shield 22025370 AR Lens - Red, Marker Light 22020370 AR Light - Marker, Amber, No Shield 22026370 AR Lens - Amber, Marker Light 22021370 AR Shield - Armored, Marker Light 22022370 AR Gasket - Between Shield and Marker Light * 52000227 AR Gasket - Lens, Marker Light * 52000811 AR Bulb - 12-Volt, Marker Light * 52000228 AR Gasket - Between Body and Light * 29000015 AR Screw - Lens *Are used on all of the above Marker Light Assemblies Electrical Page 7-11
Directional Lights Front Page 7-12 Electrical
1 52000154 2 Light - Turn Signal, 7" x 8", Amber 52000199 2 Lens - Amber, Turn Signal 22069365 2 Bulb - Miniature, 12-Volt SAF-T-LINER MVP-EF PARTS MANUAL Directional Lights Front Item Part Num. Number Qty. Description Notes Electrical Page 7-13
Directional Light Page 7-14 Electrical
Directional Light Item Part Num. Number Qty. Description Notes 1 22020378 1 Light - Side Directional Assembly, Amber 52000085 1 Lens - Amber, Side Directional 52000198 1 Lens - Red, Side Directional 52000086 1 Bulb - Side Directional Electrical Page 7-15
Dome Light Page 7-16 Electrical
Dome Light Item Part Num. Number Qty. Description Notes 85520092 1 Light - Dome, Assembly 22020374 1 Light - Base Dome Light, Assembly 22068365 1 Bulb - Miniature, 12-Volt 22021374 1 Lens - Clear, Dome Light 27161648 1 Screw - Tapping, #10 x 5/8", Phillips Electrical Page 7-17
Stop & Tail Light Page 7-18 Electrical
Stop & Tail Light Item Part Num. Number Qty. Description Notes 1 22041375 2 Light - Stop and Tail, with License Lens (KD) 22020377 2 Light - Stop and Tail, with License Lens (Grote) 22008377 2 Lens - Stop and Tail, Red 22009367 2 Bulb - Double Contact, 12-Volt Electrical Page 7-19
Stop Light Page 7-20 Electrical
Stop Light Item Part Num. Number Qty. Description Notes 1 22023372 2 Light - Stop, Amber, Complete with Bulb 22059372 2 Lens - Stop, Amber 22069365 2 Bulb - Miniature, 12-Volt Electrical Page 7-21
Back-Up Light Page 7-22 Electrical
Back-Up Light Item Part Num. Number Qty. Description Notes 1 52002037 2 Light - Back-Up, Clear, 3 7/8" Diameter 85520130 2 Lens - Clear 22023365 2 Cup - Connector, 6-10, Awg, NC-1610, Insulated 22069365 2 Bulb - Miniature, 12-Volt, 11156, SC 32 CP Electrical Page 7-23
Step Light Page 7-24 Electrical
1 22002374 1 Light - Stepwell, with 89 Bulb 22003374 Lens - Clear, Stepwell 85520048 Bulb - Miniature, 12-Volt 27161906 Screw - Lens and Mounting SAF-T-LINER MVP-EF PARTS MANUAL Step Light Item Part Num. Number Qty. Description Notes Electrical Page 7-25
This page intentionally left blank. Page 7-26 Electrical