Parts Catalog For Nordco Engine (JD 4024TF270)

Transcription

1 POWERTECH-E 2.4L 4024 OEM Diesel Engines and Accessories Parts Catalog For Nordco Engine (JD 4024TF270) (Rev -, Last Update: 06/07)

2 PARTS ORDERING INSTRUCTIONS John Deere parts may be ordered from Superior Diesel, an authorized John Deere dealer or any John Deere engine distributor. For parts noted with an * please call directly to Superior Diesel parts department: (EXT-529) Please have ENGINE MODEL AND SERIAL NUMBER available when ordering parts to help make sure the parts ordered and sent are correct. The serial number is located on the valve cover or behind the fuel filter. You may have to remove the plastic film that covers the serial number tags. (Rev -, Last Update: 06/07) 2

3 PARTS CATALOG FOR NORDCO 66hp SPEC for Nordco P/N INDEX PARTS ORDERING INFORMATION...Previous Page COOLING ASSEMBLY... 4,5 EXHAUST ASSEMBLY... 6 AIR KIT ASSEMBLY THROTTLE ASSEMBLY... 8 MOUNTING ASSEMBLY... 9 ELECTRICAL ASSEMBLY... 0, STARTER TO BATTERY CABLE ASSEMBLY...2 ENCLOSURE ASSEMBLY... 3, 4 ENGINE BUILD CODES. 5 PARTS AT A GLANCE.6 (Rev -, Last Update: 06/07) 3

4 & Cooling Assembly DR200 Radiator, 4024T/5030T Radiator Hose 3 28-H Clamp, Hose H Clamp, Hose Bracket, RAD Lower Support, LH Bracket, RAD Lower Support, RH Cross Brace 2 8 R9585 Fan Spacer 9 9M7873 Bolt 8MM-.25x0MM GR Washer, SAE Flat, 7/ Mount, Isolation (Rev -, Last Update: 06/07) 4

5 Bracket, Upper RAD. Support Bracket, Upper RAD. Support, Side 4 SD32 Shock Mount 2 5 R28442 Fan Spacer, A636 Stud 2 7 J Washer For SD32 Mount FAN 8 Blower Bracket, Radiator Support Hose (Rev -, Last Update: 06/07) 5

6 Exhaust Assembly ¼ Muffler Clamp Muffler, special from Nelson, CS250T Pipe, EXH. 90DEG, 45DEG End Cut 38 4 MC-2 Clamp, Muffler, RE3024 Clamp, 4024/5030 Turbo Flange 6 SD2550 Bracket, Muffler 2 (Rev -, Last Update: 06/07) 6

7 Air Kit Assembly 5 6 G Air Cleaner 2 H ¾ Air Cap W/ Rain Shield 3 H Mounting Band 4 P05532 Elbow, Rubber, 3 x 90* 3 5 P Rubber Reducer Elbow, DEG 6 30R236 Insert Sleeve Tube, 3 OD Aluminized Exhaust 8 8 PM336656S Clamp, 3 ½ T-Bar 3 9 PM336657S Clamp, 4 T-Bar 0 72-H Clamp RBX Service Indicator 2 24SA02 Steel, /8 Hex Fitting (Rev -, Last Update: 06/07) 7

8 Throttle Assembly 6338K453 Bushing, Bronze Flanged Bracket, Throttle Cable Swivel-Special 4 28H523 Bushing Bracket, Throttle (Rev -, Last Update: 06/07) 8

9 40-0 SD769 (wood skid) Not Pictured Mounting Assembly Mount, Engine 4 2 SD769 Wood Skid, Shipping, 4Cyl STD (Rev -, Last Update: 06/07) 9

10 Electrical Assembly Contact Pin, 6-8 AWG Harness, Engine Wire Harness, Deutsch Conn. Adapter Sender, Oil P, W/. 4PSI Warning Sender, Water Temp. 230F Warning Solenoid, 2V Continuous Duty Label, Superior Diesel. X2 8 RE70320 Starter Relay 9 RE Kit, Heater Plug, 0 SD2763 Relay Mount SD2827 Ground Wire 2 (Rev -, Last Update: 06/07) 0

11 2 SD3059 Wire, Alternator Ground N406 Diode, 600V Wire, Ground 5 R30964 Cover 5 6 SD2783 /8 Street Elbow, Brass (Rev -, Last Update: 06/07)

12 Starter To Battery Cable Assembly 472 Block, Terminal 2 SD272 4x30 W/ 3/8 AND ½ Eyes, Red Boot, Red, 8to 2 GA Wire 2 (Rev -, Last Update: 06/07) 2

13 Enclosure Assembly Bracket, Enclosure Support, Rear Bracket, Enclosure Support, Front Panel, Enclosure Lower Skirt Panel, Roof, 250 Series Panel, Rear, 250 Series Panel, Front Enclosure Panel, Door W/Hole, W / Bump out Door, Solid Bump out Screen, Front Lift Off Waffle BRKT, Encl. Front Support (Rev -, Last Update: 06/07) 3

14 Latch, Door Insulation Kit for SD2478 Latch A22 Handle, Black 5 ½ Rubber Bumper K82 Grommet, ¾ ID x.25 x /6 OD K42 Trim, Dual Edge,.25 x 0 Length (Rev -, Last Update: 06/07) 4

15 JOHN DEERE ENGINE BUILD CODES JOHN DEERE CODES (See Following Manual for Parts): 272F PE 4024TF270 DIESEL ENGINE 0 Rocker Arm Cover, Top Oil Fill 302 Crankshaft Pulley, 5.5" Dia, 6 Groove Poly-Vee 40 Flywheel Housing, SAE #4 508 Flywheel, SAE 0", Over Center Clutch, High Inertia 60 Fuel Injection Assembly 702 Air Inlet Turbo 909 Oil Pan, Center Sump, LH Side Drain, 30 Degree Off-Level capability 230 Fan Drive, 0.2" Above Crankshaft Centerline 2402 Fan Belt 280 Exhaust Manifold, Gray Iron 290 Crankcase Vent System, with Hose 3002 Starting Motor with pigtail, 2V, Bosch 2.2 kw 303 Alternator, 20 Amp Bosch 350 Fuel Filter, Modular w/ Water Separator and Hand Primer 3702 Fuel Transfer Pump 4003 Dipstick, Right Side 499 No Add On Pulley 430 Starting Aid, 2V, Low Parasitic Load 450 Balancer Shafts, Cylinder Block 460 Cylinder Block for use with Balancer Shafts 4802 Connecting Rod & Pistons 5204 Auxiliary Drive, SAE B with Cover, No Gear 550 Shipping Stand 560 Industrial Tan (Paintable) 5903 Oil Cooler for Horizontal Oil Filter Orientation 6203 Alternator Mounting, 20 Amp Bosch 65 Turbocharger, with V-Flange Connection 670 Speed Sensor in Timing Gear Cover 7203 Software and Emission Label, 2V, 66 Hp ( RPM 7699 No Oil Pressure Switch 860 Fan Pulley, 5.5" Dia, (.0: Ratio) 980 Lift Straps for Horizontal Oil Filter (Rev -, Last Update: 06/07) 5

16 PARTS AT A GLANCE FUEL FILTER JOHN DEERE FILTER FINAL RE OIL FILTER JOHN DEERE FILTER.RE59626 BELT JOHN DEERE BELT. R50580 STARTER JOHN DEERE STARTER. RE ALTERNATOR JOHN DEERE ALTERNATOR..... AH65975 AIR CLEANER FILTER AIR CLEANER FILTER.. P (Rev -, Last Update: 06/07) 6