POWER RE-GENERATION FROM WASTE HEAT COMBINED CYCLE

Transcription

1 POWER RE-GENERATION FROM WASTE HEAT COMBINED CYCLE STEAM TURBINE ELECTRIC GENERATION USING MULTIPLE ENGINES EXHAUST 1200 US $/EKWH CAPITAL COST USE ALL ENGINES TOTAL EXHAUST HEAT AND RE GENERATE 10% MORE ELECTRIC POWER GENERATE SUPER HEATED STEAM HIGH PRESSURE 30 BAR-450 PSI-350 DEG-C SHALL RUN A SMALL STEAM TRUBO GENSET AND PRODUCE ELECTRICTY FREE OF FUEL COST 10 NO. JENBACH JGS320 - EXHAUST HEAT = 6 TON/HR STEAM = 1000 KWE ELCET. 7 NO. CAT G3516B- EXHAUST HEAT = 6 TON/HR STEAM = 1000 KWE ELECTRICTY STEAM TURBINES OPERATING LIFE IS 25 YEARS STEAM TURBINES ARE EXTERNAL COMBUSTION MACHINE STEAM TURBINE DO NOT NEED OIL CHANGES, SPARK PLUG CHANGES & MAINT. STEAM TURBINE FIRST PREVENTIVE MAINT IS AT HRS (4 YRS). STEAM TURBINE DO NOT SMOKE STEAM TURBINE IS UNI DIRECTIONAL ROTARY MACHINE STEAM US TO ROTATE THE TURBINE STEAM IS PRODUCED IN WASTE HEAT OR FIRED BOILER STEAM BOILER MAY BE WASTE HEAT RECOVERY AUXILAIRY STEAM MAY BE GENERATED USING SOLID FUELS IF THE GAS FUEL CUT OFF FROM SSGC-SNGPL SOLID FUELS ARE COAL, AGRI WASTE, RICE HUSK, BAGASSE, CORN WASTE, WOOD CHIPS,LPG,LNG,ETC STEAM CONDENSOR IS 3 RD. MAJOR EQUIPMENT WHICH CONVERTS WET STEAM FROM TURBINE TO INTO CONDENSATE AND PUMP BACK TO FEED TANK. COOLING TOWERS ARE REQUIRED TO CONDENSE THE WET STEAM AT 70 C TO 40 C USING COOLING WATER CLOSE N OPEN CIRCUITS. CONTACT FOR FREE ENERGY CONSERVATION DISCUSSION ENGR. KHALID SAEED CALL FOR PROJECT SITE SURVEY (CHARGEABLE) MOB COMPLETE TURNKEY PROJECT DESIGNER ( cogenpak@gmail.com) INVEST NOW TO RECOVER EARLY FIGHT BACK WITH ENERGY CRISES-BE BRAVE AND ADOPT NEW TECHNIQUES

2 SIMPLE STEAM FLOW DIAGRAM FOR STEAM BOILER TURBINE CONDENSOR - BOILER - CLOSE LOOP

3 SUPERHEATED STEAM TO STEAM TURBINE, 30 BAR / 350 C FOR 1500 KWE STEAM TURBINE STEAM FLOW & PRESSURE CONTROL VALVES, 40 BAR/400C FOR 1500 KWE STEAM TURBINE V-122 V-124 V-123 V-125 STEAM TURBINE GENSET WE KWE, 30 Bar, 350 C, 60 TPH,7000 RPM / 1500 RPM,50Hz, 11 KV, EXTRACTION CODENSING TYPE V-148 V-150 V-149 COOLING TOWERS SET FOR STEAM CONDENSING OPEN CIRCUIT CROSS FLOW TYPE CONDENSATE RETURN FROM STM BOOST HEATER LOW PRESSURE SYSTEM LP STEAM TO HEATING CONDENSATE 70 TO 90 C 12M3/HR E-305 V-121 E-38 E-34 E-36 E-35 CONDENSATE PRE HEATING FROM 70 C TO 90 C PLATE EXCHANGER 60 M3/HR, 30 PSI V-133 V-142 V-132 V-134 V-137 V-129 I-25 I-26 E-39 I-24 I-23 V-136 V-141 V-139 V-135 V-140 V-138 V-130 E-37 V-107 CW PUMPS CLOSE LOOP V-110 FOR CONDENSOR C V-108 E-29 E-31 V-109 E-28 V-146 V-147 V-111 V-119 V-145 V-143 V-144 E-33 HEAT EXCHNAGER FOR CLOSE N OPEN LOOP CW SYSTEM V-126 V-128 V-127 V-106 V-117 E-32 E-27 V-118 V-112 KESC COMBINED CYCLE POWER 8 MWE FROM 88 MWE COGEN CONSULT , Mob V-131 STEAM TURBINE & AUX APRIL ENGR. KHALID SAEED V-114 E-30 V-116 CONDENSATE TRANSFER PUMPS C TO CONDENSATE COLLECTING TANK 10,000 LITERS CHEMICAL DOSING PUMP N TANK SETS FOR ANTI SCALANT,ANTI CORROSSION,BIOCI DES OPEN CIRCUIT COOLING TOWERS E-40 E-42 E-41 E-45 E-44 SIMPLE STEAM FLOW DIAGRAM FOR STEAM STEAM TURBINE CONDENSOR - COOLING TOWERS

4 DRINKING WATER 350 PPM STPRAGE TANK 30 DAYS STORAGE M3 E-26 I-6 V-89 V-63 V-44 DEAERAT OR VESSEL 1000 LITER SS C FEED WATER TO BOILER LCV & FW TANK E-22 THRU DEAERA TORE V-105 FWR-3' D HEADER V-152 V-153 V-102 I-5 V-98 I-17 V-41 I-15 V-87V-96 I-8 V-18 I-16 V-47 V-55 V-97 V-26 V-23 V-82 STEAM HEADER 12' DIA x 10' LONG E-15 TO STEAM TURBINE GEN 10 MWE 60 TPH 30 BAR 350 C E-13 E-3 V-14 V-91 V-9 V-90 V-54 CONDST RETURN HEADER 4' D THERMAL DESALINA TION WT PLANT USING JACKER WASTE HEAT V-52 FEED WATER E-4 TANK 5000 LITERS V-1 V-27 V-100 V-17 V-94 I-11 V-104 E-307 ECONOMIZER V-16 WHR BOILER GAS ENGINES 3 MWE -500C EXHAUST 23% RECOVERABLE ENERGY 23% JACKET HEAT FOR THERMAL DESALINATION E-2 E-24 E-12 E-306 V-5 V-22 V-151 V-84 V-4 V-81 V-74 E-14 E-23 V-62 BOILER FEED WATER PUMPS ONE STANDBY V-35 E-304 V-86 E-1 V-85 REVERSE OSMOSIS & THERMAL DESALINATION WATER TREATMKENT PLANT ZERO PPM TANK 1000 M3 SS 316 FROM TUBE WELL PRE FILTERED SETTLES 3000 PPM TDS -BRINE WATER FEED WTR SUPP BLOW DOWN TANK KESC COMBINED CYCLE POWER COGEN CONSULT , Mob ENGINE EXHAUST & WASTE HEAT BOILER FOR STEAM TYPICAL ENGR. KHALID SAEED SIMPLE STEAM FLOW DIAGRAM - ENGINES EXHAUST WHR BOILER-FEED TANK-DEAERATOR- STEAM HEADER

5 MULTIPLE ENGINES COMMON EXHAUST FOR SINGLE LARGE WASTE HEAT SUPER HEATED STEAM BOILER TO RUN A TURBO GENSET

6 APROVIS BOILERS (GmbH) GERMANY WASTE HEAT RECOVERY - SUPERHEATED STEAM BOILERS USING ENGINES EXHAUST WASTE HEAT info@aprovis-gmbh.de cogenpak@gmail.com

7 COMMON EXHAUST TO A WASTE HEAT RECOVERY SUPERHEATED STEAM BOILER 30 BAR-350 C TO RUN A STEAM TURBINE GENSET

8 APROVIS WASTE HEAT RECOVERY BOILERS GERMANY - SATURATED STEAM BOILERS USING ENGINES EXHAUST WASTE HEAT

9 STEAM TURBINE 1 TO 5 MWE FROM ETT SPILLING HAMBURG GERMANY TO RUN WITH SUPERHEATED STEAM 25 BAR -300C

10 STEAM TURBINE 1 COMBINED CYCLE 8 MWE OR 8 ENGINES EXHAUST HEAT REPRODUCE 1000 KWE ELECTRICTY FREE OF GAS/DIESEL/ANY FUEL

11 DDFC SUPERHEATED STEAM BOILER WITH EXHAUST ECONOMIZER TO GENERATE ENGINES EXHAUSY WHR STEAM AT 29 BAR 300 C

12 COGEN CONSULT - DESIGN 86 % ENERGY EFFICIENT PLANTS YOUR ENGINE IS ONLY 38% EFFICIECNT TODAY MUST RECYCLE CONSERVE REMAINING 65% LSOT FUEL COST APPLY COMBINED GENERATION (COGEN) TECHNIQUES CALL COGEN CONSULTANT ENGR KHALID SAEED 30 YRS IN POWER GEN ENERCON-USAID TRAINED SINCE 1980 CALL : or send sms- s cogenpak@ gamil.com

13 COGEN CONSULT - DESIGN 83 % ENERGY EFFICIENT PLANTS YOUR ENGINE IS ONLY 38% EFFICIECNT TODAY MUST RECYCLE CONSERVE REMAINING 65% LSOT FUEL COST APPLY COMBINED GENERATION (COGEN) TECHNIQUES CALL COGEN CONSULTANT ENGR KHALID SAEED 30 YRS IN POWER GEN ENERCON-USAID TRAINED SINCE 1980 Call : or send sms- s cogenpak@ gamil.com

14 COGEN CONSULT - DESIGN 86 % ENERGY EFFICIENT PLANTS YOUR ENGINE IS ONLY 38% EFFICIECNT TODAY MUST RECYCLE CONSERVE REMAINING 65% LSOT FUEL COST APPLY COMBINED GENERATION (COGEN) TECHNIQUES CALL COGEN CONSULTANT ENGR KHALID SAEED 30 YRS IN POWER GEN

15 IF YOU HAVE 8 MWE ENGINES RUNNING YOU MUST REPRODUCE 1000 KWE FREE OF FUEL COST INVEST NOW 12,00,000 US $ AND RECOVER WITHIN 2 YEARS MAX COGEN CONSULT - DESIGN 86 % ENERGY EFFICIENT PLANTS APPLY COMBINED GENERATION (COGEN) TECHNIQUES CALL COGEN CONSULTANT ENGR KHALID SAEED CALL : or send sms- s cogenpak@ gamil.com

16 COGEN CONSULT - DESIGN 83 % ENERGY EFFICIENT PLANTS YOUR ENGINE IS ONLY 38% EFFICIECNT TODAY MUST RECYCLE CONSERVE REMAINING 65% LSOT FUEL COST APPLY COMBINED GENERATION (COGEN) TECHNIQUES CALL COGEN CONSULTANT ENGR KHALID SAEED 30 YRS IN POWER GEN ENERCON-USAID TRAINED SINCE 9180 CALL : or send sms- s cogenpak@ gamil.com

17 COGEN CONSULT - DESIGN 83 % ENERGY EFFICIENT PLANTS YOUR ENGINE IS ONLY 38% EFFICIECNT TODAY MUST RECYCLE CONSERVE REMAINING 65% LSOT FUEL COST APPLY COMBINED GENERATION (COGEN) TECHNIQUES CALL COGEN CONSULTANT ENGR KHALID SAEED 30 YRS IN POWER GEN ENERCON-USAID TRAINED SINCE 9180 CALL : or send sms- s cogenpak@ gamil.com

18 DO NOT CRY USE ALL NATURAL RESOURCES AND IN HOUSE ENERGY LOSSES CALL FOR ENERGY AUDTI CONSERVATION REPORTS AND SURVEY COGEN CONSULT - DESIGN 83 % ENERGY EFFICIENT PLANTS YOUR ENGINE IS ONLY 38% EFFICIECNT TODAY MUST RECYCLE CONSERVE REMAINING 65% LSOT FUEL COST APPLY COMBINED GENERATION (COGEN) TECHNIQUES CALL COGEN CONSULTANT ENGR KHALID SAEED cogenpak@gmail.com 30 YRS IN POWER GEN ENERCON-USAID TRAINED SINCE 9180 CALL : or send sms- s cogenpak@ gamil.com

19 DO NOT USE COOLING TOWERS USE AIR COOLED JACKET WATER RADIATORS WE HAVE TABLE TYPE RADIATORS USING 8 MWE ELECTRICTY ONLY NO CHEMICAL DOSING, NO MUD CLEANING TO WATER MAKEUP NO WATER TANKERS, NO CORROSION, SAVE 100,000/- RS PER MONTH PER 1000 KWE ENGINECALL ENGR KHJALID SAEED VAN SPALL RADIATORS UK