SAF-T-LINER MVP-EF PARTS MANUAL. Electrical Section. Page 7-1. Electrical 10/96

Transcription

1 Electrical Page 7-1

2 Switch Cabinet Page 7-2 Electrical

3 Switch Cabinet Item Part Num. Number Qty. Description Notes Cabinet - Switch, Assembly For Thomas Forward Control Insulator - Switch Cabinet AR Blank - Switch Bushing - Snap, 3/4", with Stop Sign Plug - Dome, 7/8" without Stop Sign AR Screw - Tapping, #10 x 5/8", Phillips Plug - Dome, 5/8" Plug - Dome, 1/2" AR Trim - Edging (Order by foot.) Lamp - Wiper Illumination Lamp - Wiper Standoff Illumination Diffuser - Round Plug - Button, For 2 1/2" Diameter Hole Switch - Rocker, Defrost, High/Low Switch - Rocker, Left Heater, High/Low Switch - Rocker, Interior, On/Off Switch - Heater & Fan Double Switch - Electric Windshield Wiper, with Circuit Breaker Not Shown Bushing - Snap, 9/16", Access Door Release Rod Panel - Storage Compartment End 06/06/ Grommet - Rubber, 3/8", Inside Diameter Electrical Page 7-3

4 Panel and Components Page 7-4 Electrical

5 Panel and Components Item Part Num. Number Qty. Description Notes Block - Fuse/CB, 6/4 Circuits Block - Fuse/CB, 20 Circuits AR Jumper - Copper Bar, CB Block to CB Block AR Jumper - Copper Bar, Solenoid to CB Block AR Solenoid, 100-Amp, Coninuous Duty Jumper - Chassis Solenoid to Body Solenoid AR Buzzer - Warning, 12-Volt Metal Panel - Electrical Body, In Switch Cabinet End 04/18/ Panel - Electrical, Pusher and Forward Control Start 04/18/ Decal - CB/Block, 20 Circuit Decal - CB/Block, 10 Circuit Breaker - Circuit, 20 Amp Breaker - Circuit, 30 Amp Breaker - Circuit, 6 Amp Fuse - 20 Amp, Autofuse Fuse - 30 Amp, Autofuse Electrical Page 7-5

6 Wiring Harnesses MVP-EF Main Body Harness - Front End, Main Body, Overhead Harness - Rear End, Main Body, with Metri Pack, 10 Window and 10 Window + 10, Harness - Rear End, Main Body, with Metri Pack, 11 Window, Harness - Rear End, Main Body, with Metri Pack, 12 Window, Harness - Rear End, Main Body, with Metri Pack, 13 Window, Harness - Rear End, Main Body, with Metri Pack, 14 Window, Switch Cabinet Harnesses Harness - Wiring Interior Lights with Metri Pack Harness - Wiring Door Buzzer with Metri Pack Wiper Harness Harness - Wiring Electric Windhield Wiper with Metri Pack Front Heater and Wiper Harness - Wiring Front Heater and Electric Wiper Harness & Jumper Wiring Harness and Jumper Wiring Forward Control Page 7-6 Electrical

7 This page intentionally left blank. Electrical Page 7-7

8 Headlight Page 7-8 Electrical

9 Headlight Item Part Num. Number Qty. Description Notes Headlight - Single, 200 MM Rectangular End 10/13/ Headlight - Single, 200 MM Rectangular Start 10/13/ Bezel - Chrome Headlamp - Sealed Beam, Hi - Low Beam Base - Housing Electrical Page 7-9

10 Marker Lights Page 7-10 Electrical

11 Marker Lights Item Part Num. Number Qty. Description Notes AR Light - Marker, Red, No Shield AR Lens - Red, Marker Light AR Light - Marker, Amber, No Shield AR Lens - Amber, Marker Light AR Shield - Armored, Marker Light AR Gasket - Between Shield and Marker Light * AR Gasket - Lens, Marker Light * AR Bulb - 12-Volt, Marker Light * AR Gasket - Between Body and Light * AR Screw - Lens *Are used on all of the above Marker Light Assemblies Electrical Page 7-11

12 Directional Lights Front Page 7-12 Electrical

13 Light - Turn Signal, 7" x 8", Amber Lens - Amber, Turn Signal Bulb - Miniature, 12-Volt SAF-T-LINER MVP-EF PARTS MANUAL Directional Lights Front Item Part Num. Number Qty. Description Notes Electrical Page 7-13

14 Directional Light Page 7-14 Electrical

15 Directional Light Item Part Num. Number Qty. Description Notes Light - Side Directional Assembly, Amber Lens - Amber, Side Directional Lens - Red, Side Directional Bulb - Side Directional Electrical Page 7-15

16 Dome Light Page 7-16 Electrical

17 Dome Light Item Part Num. Number Qty. Description Notes Light - Dome, Assembly Light - Base Dome Light, Assembly Bulb - Miniature, 12-Volt Lens - Clear, Dome Light Screw - Tapping, #10 x 5/8", Phillips Electrical Page 7-17

18 Stop & Tail Light Page 7-18 Electrical

19 Stop & Tail Light Item Part Num. Number Qty. Description Notes Light - Stop and Tail, with License Lens (KD) Light - Stop and Tail, with License Lens (Grote) Lens - Stop and Tail, Red Bulb - Double Contact, 12-Volt Electrical Page 7-19

20 Stop Light Page 7-20 Electrical

21 Stop Light Item Part Num. Number Qty. Description Notes Light - Stop, Amber, Complete with Bulb Lens - Stop, Amber Bulb - Miniature, 12-Volt Electrical Page 7-21

22 Back-Up Light Page 7-22 Electrical

23 Back-Up Light Item Part Num. Number Qty. Description Notes Light - Back-Up, Clear, 3 7/8" Diameter Lens - Clear Cup - Connector, 6-10, Awg, NC-1610, Insulated Bulb - Miniature, 12-Volt, 11156, SC 32 CP Electrical Page 7-23

24 Step Light Page 7-24 Electrical

25 Light - Stepwell, with 89 Bulb Lens - Clear, Stepwell Bulb - Miniature, 12-Volt Screw - Lens and Mounting SAF-T-LINER MVP-EF PARTS MANUAL Step Light Item Part Num. Number Qty. Description Notes Electrical Page 7-25

26 This page intentionally left blank. Page 7-26 Electrical