Printed: 27/09/16 9:44 Page: 1 Invoice No:8178-1 Date: 31/08/16 Job Description: LIST OF REPAIRS 24/08/2016 hubometre replacement hubometre 0.50 Invoice No:8070-1 Date: 31/07/16 Job Description: COF INSPECTION MAINTENANCE CHECK/ 36.00 We value and thank you for your business. GREASE TOTAL 12V BATTERY Rocker Arm COF CHECK / Remove 5th wheel,inspect for cracks,inspect jaw conditions Test operation and adjustment and adjust if needed. Refit cross member assembly Adjust l/front wheel bearing and fill with new oil Secure r/ h battery box 3 x 12mm bolts and nuts Trip to test station failed tyres seat belt Remove seat belt assembly free up and lubricate Refit seatbelt assembly Trip to test station obtain cof Remove sign writing and prepare for sale NOTE: We will send a reminder card for your next COF inspections 20/07/2016 Carry out Pre Cof inspection on truck Check all electrical light conditions and operation Jack up front axle wheels and check wheel bearings and adjust brakes,also adjust rear brakes Check driveshafts,and suspension components Check chassis mounts, and bolts Grease unit. Replace 2 x batteries Check tail light wiring [no power] Check fuses and replace 1 x 10amp fuse [blown]
Printed: 27/09/16 9:44 Page: 2 Remove all hoses and brackets Remove cross member rear of gear box [cracked] Clean up all cracks and weld Carry out 5th certification Invoice No:8042-1 Date: 31/07/16 Repair Kit 6.00 ECU COOLER 28.50 DIESEL 50.00 fittings Air Freight fuel pump O Rings 09/07/2016 Travel to after hrs breakdown Travel to cavendish drive Fill with 50 ltrs diesel Tried bleeding fuel system Fuel leaking behind ECU Remove driveshaft and wait for tow truck Return to workshop Refit driveshaft Had to fit jumper batteries Remove inlet manifold assembly Remove Ecu Replace fuel heat exchanger plate Reassemble manifold and ecu Bleed up system Trouble bleeding fuel still getting alot of air bubbles at cylinder bleed screw check fuel line from tank run fuel cell at tank side still no start shift fuel cell after 1st primary fuel filter still no start. check fuel lines at secondarly filter to head, Carry out fuel system checks on pump Shift fuel cell straight to fuelpump and block, still no go
Printed: 27/09/16 9:44 Page: 3 Check fuel preesure a little low from spec, 0.2 bar Replace pump, still air bubbles,no start Found power steering hose getting hot while cranking engine over Remove fuel and power steering pump assembly Strip power steering pump ok clean up and reassemble Refit fuel and steering pump Refit with manifold and ecu Fill up power steering oil 2lt Prime fuel system Remove rocker cover assembly and check for fuel leaks Remove rocker assembly Still getting alot of air in system Remove all injectors Found no 5 injector clamp loose and a damaged o ring Replace all injector o rings Reassemble injectors and rockers Carry out top tune Run up engine okay Clean up mess Invoice No:8020-1 Date: 28/07/16 Travel to after hours breakdown at westney road fill up with 40 litres of fuel DIESEL 40.00 Traveling to breakdown 20.00 3.00 04/07/2016 Invoice No:7993-1 Date: 30/06/16 23/06/2016 ATTEND TO METRO BOX fill diesel then bleed system Traveling to breakdown 40.00 2.33 Invoice No:7978-1 Date: 30/06/16 Job Description: accident damage Straighten bottom tank mounting brackets Refit strap and step assembly Deliver back to yard
Printed: 27/09/16 9:44 Page: 4 Travel to yard and jumpstart vehicle 19.75 15/06/2016 Remove top and bottom side skirts Cut steps in half [both sides] Remove r/h door step assembly Remove tank straps and straighten Tank filler necks damaged Close fuel tank tap [cross over] Invoice No:7929-1 Date: 31/05/16 30/05/20126 Attend to breakdown jump start truck Traveling to breakdown 30.00 3.00 Invoice No:7868-1 Date: 30/05/16 Job Description: LIST OF REPAIRS 11/05/2016 Pick up vehicle from yard Jumpstart vehicle flat batteries Strip seat Modify new seat to suit New seat is for passenger side supplied by customer Swap over brackets and weld Strip new seat and swap over seatbelt assembly Make up mounting plates Remove drivers seat assembly Outwork: Check and locate fuse covering left side, bumper & top lights sparky to wire up replaceable fuse in bumper to isolate marker and dash lights froming poping fuse inside cab hex bolts Electrical Inspection 19.50 Invoice No:7811-1 Date: 30/04/16 Job Description: B SERVICE OIL FILTER IVECO
Printed: 27/09/16 9:44 Page: 5 FUEL FILTER HEADLIGHT BULB DIFF OIL 85/140 24V BRAKE LIGHT BULB 14.75 18/04/2016 Carry out B service Remove and replace all Fuel filters Drain and replace oil and filters Grease and adjust all brakes Check all fluid levels Check all electrical circuits for operation Check All wheel bearing play and Kingpin play Inspect suspension system Add 2lt diff oil to 2nd axle Deisel leak around r/h fuel tank Check Air system operations Inspect chassis area for cracks Problem with dash lights and marker lights Check light operation Check all wiring Remove instrument panel Replace blown bulbs wedge 3x 24v/5w Refit dash panel Check all fuses replace blown fuse 15amp Spoiler marker lights operational Replace headlight blown bulbs 2x 24v75/70w and 24v/5w Carry out 5th certification Remove 5th wheel,inspect for cracks,inspect jaw conditions Test operation and adjustment and adjust if needed. NOTE: We will send you a reminder card for your next COF inspection and service dates We value and thank you for your business. GREASE TOTAL 24V/5W BULB FUEL FILTER IVECO 3.00
Printed: 27/09/16 9:44 Page: 6 Invoice No:7678-1 Date: 24/03/16 Reading: 206,128 Job Description: LIST OF REPAIRS Welding BLACK IT - GLOSS 400ML 2.50 04/03/2016 grind down existing broken weld tack weld arm to mount gring groove in to crck for strong weld weld arm to mount make a plate to fit the side of arm (cut pattern, cut pattern out of metal) weld plate to the side of the arm make a plate to weld on top of crack weld plate on top gring down excess welds spray paint in matching black