Cover Washer-Extractor Variable Speed Models HC8 SC8 UC8 HC7 SC7 UC7 HC35 SC35 UC35 HC50 SC50 UC50 Parts B003C Part No. F39R3 January 000
Table of Contents Title Page Parts Ordering Information... Nameplate Location... Model Identification... 3 Decal Familiarization... Graphic Panel and Controls... 6 Control Module... 8 Inverter Drive... 0 Manual Control Switch Assembly... Air Filter Assembly... Supply Dispenser... 6 Supply Dispenser Assembly (Mueller)... 8 Supply Dispenser Assembly (Elbi)... 0 Automatic Supply Dispenser Kit... Water Valve... Valve Assembly (Elbi)... 6 Water Filter... 8 Drain Valve Assembly... 30 Drain Valve Assembly... 3 Drain Valve Assembly, Hoses and Air Trap (8, 35 and 50lb.)... 3 Drain Valve Assembly, Hoses and Air Trap (7lb.)...36 Door and Outer Front Panels... 38 Front Panel... 0 Door Lock Assembly... Panels... Shell Front, Cylinder, Outer Shell and Trunnion Assembly... 6 Motor, Pulley and Belt Assembly... 8 Motor, Pulley and Belt Assembly... 50 Power Panel Assembly... 5 Steam Heat Assembly... 5 Electric Heat Assembly... 56 Parts Index... 59 Copyright 000, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. F39
LB Alliance Laundry Systems is not responsible for personal injury or property damage resulting from improper service. Review all service information before beginning repairs. If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (90) 78-3950 for the name of the nearest authorized parts distributor. Parts Ordering Information For technical assistance, call any of the following numbers: (850) 78-035 (850) 78-06 Marianna, Florida (90) 78-3 Ripon, Wisconsin When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on nameplate(s) as shown. Nameplate Location Model No. HC80PC3AU000 UNIMAC Serial No. 95073 Voltage 08-0 Amps Required Circuit Breaker Amps. 0 Hz 60 Wire Phase 3 Max. Load 80 LB 36 KG Max. Speed 530 RPM Elec. Heating KW Steam Press PSI BAR Product No. 56050 Date Code 0797 95073 08-0 0 60 3 80 36 UNIMAC Model No. HC80PC3AU000 Serial No. Voltage Amps Required Circuit Breaker Amps. Hz Wire Phase Max. Load KG Max. Speed RPM Elec. Heating KW Steam Press PSI BAR 56050 530 Product No. Date Code 0797 B55P F39
Model Identification Information in this manual is applicable to these washer-extractors: HC8VNV HC7VNV HC35VNV HC50VNV SC8VNV SC7VNV SC35VNV SC50VNV UC8VNV UC7VNV UC35VNV UC50VNV F39 3
Notes
Decal Familiarization 3 (O.P.L. Only) (Typical) 5 6 3 (80-pound models only) 7 (Not present on EDC models) 8 (MC Models Only) (O.P.L. Only) 0 9 B098PE3A F39
Decal Familiarization REF PART # DESCRIPTION COMMENTS F30877 Decal F3007 Decal 3 F3006 Decal F305- Decal 5 F30630 Decal 6 F36 Decal 7 F3066 Decal Not present on EDC models 8 F300 Decal 9 F30756 Decal MC models only 0 F3058 Tag OPL only F306 Decal 8968R Decal 3 F3065 Decal F30693 Decal F39 5
Graphic Panel and Controls 8 9 6 7 0 5 3 B053PE3E 6 F39
Graphic Panel and Controls REF PART # DESCRIPTION COMMENTS F370576 Keypad UC8, UC7, UC35 and UC50; Keypad, OPL F30608 Keypad SC8, SC5, SC7, SC35 and SC50; Keypad F30 Overlay Decal V-comp, UC F303 Overlay Decal HC8, HC35 and HC50 F30 Overlay Decal SC8, SC7, SC35 and SC50 3 F30 Door Switch 50 Volts, 6 Amps F367 Control Panel Decal SC8 F396 Control Panel Decal UC35, PC F395 Control Panel Decal UC50 F369 Control Panel Decal SC35 F370 Control Panel Decal SC50 F398 Control Panel Decal UC8 F397 Control Panel Decal UC7 F356 Control Panel Decal HC7 F355 Control Panel Decal HC8 F357 Control Panel Decal HC35 F358 Control Panel Decal HC50 F368 Control Panel Decal SC7 5 F30 Rivet 6 F63808- Control Panel Assembly *C8 F638- Control Panel Assembly *C7 F6387- Control Panel Assembly *C35 F63830- Control Panel Assembly *C50 7 F006 Spacer 8 F3035 Washer 9 F303 Nut 0 F37033-60 Computer Board *C8-50VNV F37033-3 Computer Board *C5VNV F39 7
Control Module 3 9 0 8 3 5 6 7 B38PE3A 8 F39
Control Module REF PART # DESCRIPTION COMMENTS F90 Battery 9-volt F37059 Battery Back-up Board 3 F3035 Water Level Switch HC8, HC7, SC8, SC7, UC8 and UC7 F3038 Water Level Switch HC35, HC50, SC35, SC50, UC35 and UC50 F3096 Screw 5 F37030 Bridge Rectifier 6 F3035 Washer 7 F303 Nut 8 F607507 Electrical Panel HC8, UC8, HC7, UC7, HC35, UC35, HC50 and UC50 F606950- Electrical Panel SC8, SC7, SC35 and SC50 9 F07 Flat Cable V-Computer, 6 Pin, 8" 0 F37059 Fuse Board SC8, SC7, SC35, SC50, UC8, UC7, UC35 and UC50; Cycle, P-Computer, 0 Volt F3703 Fuse Board SC8, SC7, SC35, SC50, UC8, UC7, UC35 and UC50; WE7-V, VAR speed F3307 Flange Relay 0/0 Volt F6056 Harness Battery Back-up, 3 Pin 3 F35009 Fuse / Amp F8050 Standoff F39 9
Inverter Drive 3 6 5 7 8 9 0 3 5 B39PE3A 0 F39
Inverter Drive REF PART # DESCRIPTION COMMENTS F370839 Inverter Drive 8, 7; 30 Volt F37080 Inverter Drive 8; 60 Volt F3708 Inverter Drive 35; 30 Volt F3708 Inverter Drive 35, 50; 60 Volt F30 Nut 3 F30 Washer F3607 Transformer 00 VA 0 SEC F360 Transformer 50 VA multi for pump models 5 F63386 A.C. Drive Box Wrap 6 F900 Thermostat Manual Reset 7 F30996 Screw 8 F3503 Fuseholder 9 F8050 Standoff 0 F3393 Decal Amp F339 Decal Amp F308 Screw F0768 Terminal Strip 3 F6333 Fuseholder Bracket F006 Muffin Fan 0 Volt F005 Muffin Fan 0 Volt 5 F306 Nut F39
Manual Control Switch Assembly 3 5 6 7 8 B0PE3B F39
Manual Control Switch Assembly REF PART # DESCRIPTION COMMENTS F63350 Start/Stop Switch Assembly F3307 Relay 0 Volt F33030 Relay 0 Volt F303 Nut 3 F303 Nut F6055 Clip 5 F63350 Switchplate Sub-assembly 6 F350 Light 5 Volt F35006 Light 0 Volt 7 F338 Decal 8 F30 Rocker Switch 50 Volt, 6 Amp F39 3
Air Filter Assembly 3 B080PE3B F39
Air Filter Assembly REF PART # DESCRIPTION COMMENTS F633508 Filter Foam Mesh F3377 Decal 3 F6333 Air Filter Slide F0639P Velcro Strip Sold per foot F39 5
Supply Dispenser 3 5 6 B05PE3A 6 F39
Supply Dispenser REF PART # DESCRIPTION COMMENTS F63030 Clamp Assembly F50305 Cover 3 F37 Washer F30 Nut 5 F7070 Gasket 6 F6037-3 Dispenser F39 7
Supply Dispenser Assembly (Mueller) 3 5 6 5 5 3 5 5 5 6 0 9 7 5 7 5 8 5 BP E3A 8 F39
Supply Dispenser Assembly (Mueller) REF PART # DESCRIPTION COMMENTS F509 Supply Dispenser Baffle F6037-3 Supply Dispenser 3 F50390 Siphon Tube F0007 Clamp #8 5 F0008 Hose Sold per foot 6 F3098 Screw F3097 Screw UC8, UC35 and UC50 7 F503 Vacuum Breaker Hose HC8, HC35, SC8, SC35, UC8 and UC35 F5030 Vacuum Breaker Hose HC50, SC50 and UC50 F5037 Vacuum Breaker Hose HC7, SC7 and UC7 8 F009 Clamp #8 9 F003 Clamp #0 0 F50330 Vacuum Breaker Bottom F5039 Vacuum Breaker Top F303 Nut 3 F9030 Plug F3077 Screw 5 F73055 Valve 3-Way Mixing Valve, 0 Volt, 60 Hertz, Hose Thread F73056 Valve 3-Way Mixing Valve, 0 Volt, 50 Hertz, Metric 6 F0005 Clamp #0 7 F5037 Manifold F39 9
Supply Dispenser Assembly (Elbi) 5 6 7 8 9 0 3 5 3 3 3 8 6 5 3 30 3 9 8 6 3 7 3 7 3 B60PE3A 0 F39
Supply Dispenser Assembly (Elbi) REF PART # DESCRIPTION COMMENTS F6037-3 Supply Dispenser F0007 Clamp #8 3 F0008 Hose Sold per foot F3098 Screw 5 F307 Screw 6 F60533 Junction Box Cover 7 F077 Input Power Block 3-wire F076 Input Power Block -wire 8 F30938 Screw 9 F073 Ground Lug 0 F30903 Screw F3500 Fuse Amp F35030 Fuse Holder 3 F0909 Bushing F303 Nut 5 F303 Nut 6 F606595 Mixing Valve Mounting Plate 7 F3870 3-Way Mixing Valve Kit Cold, 0 Volt F3878 3-Way Mixing Valve Kit Cold, 0 Volt 8 F303 Washer 9 F3099 Screw 0 F808 "Y" Connector F003 Clamp #0 F503 Vacuum Breaker Hose SC8 and SC35 F5037 Vacuum Breaker Hose SC5 and SC7 F5030 Vacuum Breaker Hose SC50 3 F009 Clamp #8 F5039 Vacuum Breaker Assembly 5 F3077 Screw 6 F303 Nut 7 F3878 3-Way Valve Hot, 0 Volt, U.S. Threads F38730 3-Way Valve Hot, 0 Volt, Metric Threads 8 F50330 Vacuum Breaker Bottom F39
Automatic Supply Dispenser Kit 3 5 6 5 6 7 8 9 0 7 6 3 6 5 6 5 BPE3A F39
Automatic Supply Dispenser Kit REF PART # DESCRIPTION COMMENTS F73068 Nozzle Kit Includes Items, 6 and 7 F3096 Screw F0766 Terminal Strip 3 F3376- Decal F380300 Nozzle 5 F33 Washer 6 F30 Nut 7 F0768 Terminal Strip 8 F077 Terminal Block 9 F30903 Screw 0 F073 Ground Lug F80506 Standoff F3503 Dual Fuseholder 3 F3505 Fuse 3 Amp, 5 x 0 mm F0068 Tubing Sold per foot 5 F0006 Clamp 6 F30 Nut 7 F7008 O-ring F39 3
Water Valve Be Sure Pilot Hole Faces Inlet To The Valve. 3 mm Repair Kit 3 3 mm Repair Kit 0 mm Repair Kit 5 B008PE3E F39
Water Valve REF PART # DESCRIPTION COMMENTS F380900 Coil 0-7 Volt, 50-60 Hertz F38097 Coil 0 Volt F38095 Repair Kit 0 mm, Top F380939 Repair Kit 3 mm, Ends 3 F380958 Flow Restrictor.8 mm F7000 Strainer Screen 5 F380957 Flow Restrictor mm F39 5
Valve Assembly (Elbi) 3 B7PE3A 6 F39
Valve Assembly (Elbi) REF PART # DESCRIPTION COMMENTS G58PE Repair Kit F63857 Valve F380983 Coil Volt F3879 3-Way Valve Cold F3879 3-Way Valve Hot 3 G3000 Diaphram F39 7
IH WORK? HOW DOES THIS WORK? HOW DOES THIS WORK? HOW DOES THIS WORK?HOW DOES THIS WORK?HOW DOES THIS WORK? Water Filter 3 5 B3PE3B 8 F39
Water Filter REF PART # DESCRIPTION COMMENTS F70306 Filter Assembly Hose Thread, Optional F70305 Filter Assembly Metric Thread, Optional F00500 Washer F7006 Filter Element mm F7005 Filter Element.5 mm 3 F7007 Gasket Sold per foot F006 Inlet Hose 3/8 inch F006 Inlet Hose 3/ inch 5 F70300 Hose Screen F39 9
Drain Valve Assembly (Models HC8, HC7, HC35, SC8, SC7, SC35, UC8, UC7 and UC35) 3 B0PE3D 30 F39
Drain Valve Assembly (Models HC8, HC7, HC35, SC8, SC7, SC35, UC8, UC7 and UC35) REF PART # DESCRIPTION COMMENTS F38068 Drain Valve 0 Volt, 60 Hertz F38069 Drain Valve 0 Volt F38090 Valve Body " F6076 Cover 3 F38093 Motor Keyed Shaft, 0 Volt, 60 Hertz F3809 Motor 0 Volt F38098 Drive Shaft And Seal Kit F39 3
Drain Valve Assembly (Models HC50, SC50 and UC50) 3 BPE3A 3 F39
Drain Valve Assembly (Models HC50, SC50 and UC50) REF PART # DESCRIPTION COMMENTS F38068 Drain Valve Assembly 5 Volt, 50-60 Hertz F38069 Drain Valve Assembly 0 Volt, 50-60 Hertz F5035 Overflow Plug F005 Clamp #8 3 F38093 Motor Keyed Shaft, 0 Volt, 60 Hertz F3809 Motor 0 Volt F38098 Drive Shaft And Seal Kit F39 33
Drain Valve Assembly, Hoses and Air Trap (8, 35 and 50lb.) 3 5 6 5 5 5 5 0 9 8 7 6 7 8 3 0 0 B5PE3A 3 F39
Drain Valve Assembly, Hoses and Air Trap (8, 35 and 50lb.) REF PART # DESCRIPTION COMMENTS F003 Clamp #0 F50309 Soap Dispenser Hose 3 F009 Clamp F503 Hose HC8, HC35, SC8, SC35, UC8 and UC35 F5030 Hose HC50, SC50 and UC50 5 F005 Clamp HC8, HC35, SC8, SC35, UC8 and UC35, #8 F0005 Clamp HC50, SC50 and UC50, #0 6 F5037 Overflow Hose HC8, SC8 and UC8 F5033 Overflow Hose HC35, SC35 and UC35 7 F3097 Screw HC8, HC35, SC8, SC35, UC8 and UC35 F3003 Screw HC50, SC50 and UC50 8 F3037 Washer 9 F5038 Drain Tee HC8, HC35, SC8, SC35, UC8 and UC35 F50398 Drain Tee HC50, SC50 and UC50 0 F003 Clamp HC8, HC35, SC8, SC35, UC8 and UC35 F009 Clamp HC50, SC50 and UC50 F503 Hose HC8, HC35, SC8, SC35, UC8 and UC35 F5000 Hose HC50, SC50 and UC50 F503 Hose HC8, SC8 anduc8 F5033 Hose HC35, SC35 and UC35 F50356 Hose UC50 F50399 Hose SC50 3 F3003 Screw F305 Nut 5 F00 Air Trap Hose 6 F3090 Out-of-Balance Switch HC35, SC35, UC35, HC50, SC50 and UC50 7 F3093 Switch Extension HC35, SC35, UC35, HC50, SC50 and UC50 F39 35
Drain Valve Assembly, Hoses and Air Trap (7lb.) 6 7 5 6 8 3 7 9 0 9 8 9 9 7 6 3 8 5 B6PE3A 36 F39
Drain Valve Assembly, Hoses and Air Trap (7lb.) REF PART # DESCRIPTION COMMENTS F003 Clamp F50309 Soap Dispenser Hose 3 F009 Clamp F5037 Hose 5 F57 Vent Nipple 6 F000 Clamp #0 7 F0070 Hose 8 F60837 Pipe 9 F005 Clamp 0 F5033 Overflow Hose F3097 Screw F3037 Washer 3 F5038 Drain Tee F5033 Hose 5 F3003 Screw 6 F503 Hose 7 F305 Nut 8 F360 Transformer 0 Volt 9 F00 Air Trap Hose F39 37
Door and Outer Front Panels 3 5 7 7 6 8 8 30 3 9 6 0 7 5 9 33 3 6 3 5 3 8 9 0 0 B7PE3B 38 F39
Door and Outer Front Panels REF PART # DESCRIPTION COMMENTS F73055 Door Handle Kit Includes #5, 5, 6, 8 and 9 F3066 Decal Push Red Button F3053 Set Screw HC8, SC8 and UC8 F30533 Set Screw HC7, HC35, HC50, SC7, SC35, SC50, UC7, UC35 and UC50 3 F303 Nut F509 Latch Arm 5 F507 Door Handle Spacer 6 F30 Nut 7 F30693 Decal Counterclockwise Spin Rotation 8 F7009 Gasket O-ring Used on old style UC8 Door Assembly 9 F9005P Door Glass HC8, SC8 and UC8 F9007P Door Glass HC7, SC7, SC35, UC7 and UC35 F9008P Door Glass HC50, SC50 and UC50 0 F7006 Gasket HC8, SC8 and UC8 F703 Gasket HC7, HC35, SC7, SC35, UC7 and UC35 F70 Gasket HC50, SC50 and UC50 F30 Nut F33 Washer 3 F60079- Door Assembly HC8, SC8 and UC8 F60339- Door Assembly HC35, SC7, SC35 and UC35 F60390- Door Assembly HC50, SC50 and UC50; Door Only, OPL F3097 Screw 5 F3096 Screw 6 F30606 Nut 7 F30703 Door Magnet 8 F6083- Hinge Rod HC8, HC5, HC7, HC35, SC8, SC5, SC7, SC35, UC8, UC5, UC7 and UC35 F6083-3 Hinge Rod HC50, SC50 and UC50 9 F60679 Shim As Required 0 F305 Nut F50 Hinge F506 Door Mount 3 F505 Extrusion Trim Sold per foot F30956 Screw 5 F305 Spring 6 F30300 Pushbutton Rod 7 F3066 Decal Red Dot 8 F3 Roll Pin 9 F505 Handle 30 F3907 Washer Nylon 3 F30976 Screw 3 F30703 Magnetic Position Switch 33 F37 Pop Rivet F39 39
Front Panel B8PE3A 0 F39
Front Panel REF PART # DESCRIPTION COMMENTS F63683- Outer Front Panel SC8 and UC8; Stainless Steel F63666- Outer Front Panel SC7 and UC7; Stainless Steel F6387- Outer Front Panel SC35 and UC35; Stainless Steel F63765- Outer Front Panel SC50 and UC50; Stainless Steel F39
Door Lock Assembly 3 0 9 5 8 7 3 6 7 6 5 0 3 3 8 9 B06PE3F F39
Door Lock Assembly REF PART # DESCRIPTION COMMENTS F636-3 Door Lock Assembly 0 Volt, consists of #, 6 and - F603003 Cover F3000 Splash Shield 3 F60385 Shim F30977 Screw 5 F307 Screw 6 F633078 Door Lock Sub-assembly 7 F305 Nut 8 F506 Catch L-Catch 9 F300 Lockwasher 0 F30983 Screw HC8, HC7, SC8, SC7, UC8 and UC7 F3098 Screw HC35, HC50, SC35, SC50, UC35 and UC50 F303 Nut F300 Torsion Spring 3 F390 Washer F60538 Lever 5 F60538 Pushbutton Stop 6 F3903 Washer 7 F300 Nut 8 F33 Washer 9 F3008 Door Release Solenoid 0 F305 Nut F3099 Microswitch F390 Washer F39 3
Panels 0 5 7 3 5 7 6 8 7 7 8 9 9 0 8 6 3 7 8 6 5 B9PE3D F39
Panels REF PART # DESCRIPTION COMMENTS F607 Bracket F35 Rivet 3 F90805- Key F90805 Lid Lock 5 F758003 Top Cover Kit HC8, SC8 and UC8 F75800-0 Top Cover Kit HC35, SC35 and UC35 F758000-0 Top Cover Kit HC50, SC50 and UC50 F63963 Top Cover Kit HC7, SC7 and UC7 6 F60753 Latch 7 F390300 Stud 8 F307 Screw 9 F9003 Hinge 0 F303 Nut F3095 Screw F6339- Valve Panel Assembly SC8 and UC8 F6339- Valve Panel Assembly SC7 and UC7 F6339-3 Valve Panel Assembly SC35 and UC35 F6339- Valve Panel Assembly SC50 and UC50 3 F60 Rear Panel SC8 and UC8 F63075 Rear Panel SC7 and UC7 F603 Rear Panel SC35 and UC35 F6039 Rear Panel SC50 and UC50 F6335 Side Panel SC8 and UC8, Right F63355 Side Panel SC35 and UC35, Right F63333 Side Panel SC50 and UC50, Right F6335 Side Panel SC7 and UC7, Right 5 F3037 Washer 6 F305 Nut 7 F63688- Bezel SC8 and UC8 F637- Bezel SC7, SC35, UC7 and UC35 F63778- Bezel SC50 and UC50 F63688- Bezel HC8 F637- Bezel HC7 and HC35 F63778- Bezel HC50 8 F633380- Control Module Box Assembly 9 F6339 Control Module Cover 0 F60307 Side Panel SC35 and UC35, Left F60330 Side Panel SC50 and UC50, Left F6065 Side Panel SC8 and UC8, Left F63069 Side Panel SC7 and UC7. Left F63808- Control Panel Assembly SC8 and UC8 F638- Control Panel Assembly SC7 and UC7 F6387- Control Panel Assembly SC35 and UC35 F63803- Control Panel Assembly SC50 and UC50 F63800 Lower Brace SC8 and UC8 F6380 Lower Brace SC7 and UC7 F6380 Lower Brace SC35 and UC35 F63803 Lower Brace SC50 and UC50 F39 5
Shell Front, Cylinder, Outer Shell and Trunnion Assembly 7 5 6 3 8 7 6 0 9 5 3 B03PE3E 6 F39
Shell Front, Cylinder, Outer Shell and Trunnion Assembly REF PART # DESCRIPTION COMMENTS F77009 Trunnion Kit HC8, SC8 and UC8; Includes reference item 0 F77003 Trunnion Kit HC7, SC7 and UC7; Includes reference item 0 F770 Trunnion Kit HC35, SC35 and UC35; Includes reference item 0 F770 Trunnion Kit HC50, SC50 and UC50; Includes reference item 0 F79000 Shell Front Gasket Kit Includes old and new gaskets, sealer and hardware F60970- Shell Front Assembly HC8, SC8 and UC8 F63006 Shell Front Assembly HC7, SC7 and UC7 F6097- Shell Front Assembly HC35, SC35 and UC35 F6097- Shell Front Assembly HC50, SC50 and UC50 F705 Gasket Sold per foot 3 F3058 Screw F3037 Washer 5 F305 Nut 6 F7700 Shell Band Kit HC8, SC8 and UC8 F63977 Shell Band Kit HC7, SC7 and UC7 F770 Shell Band Kit HC35, SC35 and UC35 F770 Shell Band Kit HC50, SC50 and UC50 7 F60599 Basket Assembly HC8, SC8 and UC8 F63378 Basket Assembly HC7, SC7 and UC7 F60576 Basket Assembly HC35, SC35 and UC35 F60595 Basket Assembly HC50, SC50 and UC50 8 F00 Shaft Seal HC8, SC8 and UC8 F000 Shaft Seal HC7, HC35, SC7, SC35, UC7, and UC35 F00 Shaft Seal HC50, SC50 and UC50 9 F3039 Nut HC8, HC7, SC8, SC7, UC8 and UC7 F300 Nut HC35, HC50, SC35, SC50, UC35 and UC50 0 F38 Washer HC8, HC7, SC8, SC7, UC8 and UC7 F33 Washer HC35, HC50, SC35, SC50, UC35 and UC50 F633950 Frame Assembly HC8, SC8 and UC8 F639 Frame Assembly HC7, SC7 and UC7 F6336 Frame Assembly HC35, SC35 and UC35 F63378 Frame Assembly HC50, SC50 and UC50 F3035 Washer 3 F308 Nut F3099 Screw HC8, HC7, SC8, SC7, UC8 and UC7 F30987 Screw HC35, HC50, SC35, SC50, UC35 and UC50 5 F7006 Shell Kit HC8, SC8 and UC8 F63663 Shell Kit HC7, SC7 and UC7 F7008 Shell Kit HC35, SC35 and UC35 F70 Shell Kit HC50, SC50 and UC50 6 F30303 Washer 7 F309 Screw F39 7
Motor, Pulley and Belt Assembly (Models HC8, HC7, SC8, SC7, UC8 and UC7) 5 3 8 9 0 6 7 6 8 6 5 3 3 8 7 B50P E3B 8 F39
Motor, Pulley and Belt Assembly (Models HC8, HC7, SC8, SC7, UC8 and UC7) REF PART # DESCRIPTION COMMENTS F3080 Drive Pulley Key F5070 Pulley HC8, SC8 and UC8 F5069 Pulley HC7, SC7 and UC7 3 F35 Washer HC7, SC7 and UC7 F36 Washer HC8, SC8 and UC8 F3000 Screw HC7, SC7 and UC7 F3097 Screw HC8, SC8 and UC8 5 F80368 J-Belt HC7, SC7 and UC7, Poly V F80370 J-Belt HC8, SC8 and UC8, Poly V 6 F3035 Washer 7 F608 Support Rod HC8, HC7, SC8, SC7, UC8 and UC7 8 F303 Bushing 9 F3080 Key Motor 0 F8087 Pulley SC7 and UC7, 60 Hertz F8009 Motor Pulley Bushing F30 Spring 3 F30537 Eye Bolt F63337 Spring Clip Elmo only 5 F0393 Motor HC8, SC8 and UC8 F0395 Motor HC7, SC7 and UC7 6 F300 Cotter Pin 7 F308 Nut 8 F30300 Washer F39 9
Motor, Pulley and Belt Assembly (Models HC35, HC50, SC35, SC50, UC35 and UC50) 5 3 8 9 0 6 7 6 8 6 5 3 3 8 7 B5PE3B 50 F39
Motor, Pulley and Belt Assembly (Models HC35, HC50, SC35, SC50, UC35 and UC50) REF PART # DESCRIPTION COMMENTS F3080 Key F5069 Basket Pulley HC35, SC35 and UC35 F8088 Basket Pulley HC50, SC50 and UC50 3 F35 Washer HC35, HC50, SC35, SC50, UC35 and UC50 F3000 Screw HC35, HC50, SC35, SC50, UC35 and UC50 5 F80369 Poly V-Belt HC35, SC35 and UC35 F80366 Poly V-Belt HC50, SC50 and UC50 6 F3035 Washer 7 F603059 Rod HC35, SC35 and UC35 F603897 Rod HC50, SC50 and UC50 8 F303 Bushing 9 F3080 Key 0 F8087 Pulley F8009 Motor Pulley Bushing F30 Spring 3 F30537 Eye Bolt F63337 Clip Elmo only 5 F039 Motor HC35, SC35 and UC35 F03 Motor HC50, SC50 and UC50 6 F300 Cotter Pin 7 F308 Nut 8 F30300 Washer F39 5
Power Panel Assembly 9 7 8 3 6 5 B5PE3A 5 F39
Power Panel Assembly REF PART # DESCRIPTION COMMENTS F63360 Junction Box Cover F307 Screw 3 F30903 Screw F073 Ground Terminal Lug 5 F303 Nut 6 F303 Nut 7 F0768 Terminal Strip 8 F077 Power Input Block 3 Wire 9 F30938 Screw F39 53
Steam Heat Assembly 3 6 5 3 9 5 0 9 8 7 6 7 B53P E3A 5 F39
Steam Heat Assembly REF PART # DESCRIPTION COMMENTS F936 Bushing Computer Only F370606 Temperature Probe Computer Only 3 F606977 Shell Assembly HC8, SC8 and UC8; Heat Option F630 Shell Assembly HC7, SC7 and UC7; Heat Option F60698 Shell Assembly HC35, SC35 and UC35; Heat Option F60698 Shell Assembly HC50, SC50 and UC50; Heat Option F3600 Plug 5 F005 Hose 6 F305 Screw 7 F060 Strap 8 F6086 Bracket 9 F3037 Washer 0 F305 Nut F3008 Screw F380786 Solenoid Valve Parker Steam, /", 0 Volt F380787 Solenoid Valve Parker Steam, /", 0 Volt 3 F070 Nipple F0 Elbow 5 F0707 Nipple 6 F0708 Nipple 7 F6033 Steam Injector F39 55
Electric Heat Assembly 5 3 6 0 7 9 8 B5PE3A 56 F39
Electric Heat Assembly REF PART # DESCRIPTION COMMENTS F0 Tubing Sold per foot F3035 Tri-Level Water Switch SC8, SC7SN, UC8 and UC7 F303 Tri-Level Water Switch SC35 and UC35 F3038 Tri-Level Water Switch SC50 and UC50 3 F806 Tee F3306 Contactor HC8, HC7, SC8, SC7, UC8 and UC7; 0 Volt F33050 Contactor HC35, SC35 and UC35; 0 Volt F33073 Contactor HC50, SC50 and UC50; 0 Volt 5 F3097 Screw 6 F303 Nut 7 F606978 Shell Assembly HC8, SC8 and UC8; Heat Option F630 Shell Assembly HC7, SC7 and UC7; Heat Option F60698 Shell Assembly HC35, SC35 and UC35; Heat Option F60698 Shell Assembly HC50, SC50 and UC50; Heat Option 8 F3600 Plug 9 F36005 Heating Element.6 kw, 0 Volt 0 F936 Bushing F370606 Temperature Probe F507 Plug F39 57
Parts Index A Air Filter Slide F6333... 5 Air Trap Hose F00... 35, 37 A.C. Drive Box Wrap F63386... B Basket Assembly F60576... 7 F60595... 7 F60599... 7 F63378... 7 Basket Pulley F5069... 5 F8088... 5 Battery F90... 9 Battery Back-up Board F37059... 9 Bezel F637-... 5 F637-... 5 F63688-... 5 F63688-... 5 F63778-... 5 F63778-... 5 Bracket F6086... 55 F607... 5 Bridge Rectifier F37030... 9 Bushing F303... 9, 5 F0909... F936... 55, 57 Coil F380900...5 F38097...5 F380983...7 Computer Board F37033-0...7 F37033-3...7 Contactor F3306...57 F33050...57 F33073...57 Control Module Box Assembly F633380-...5 Control Module Cover F6339...5 Control Panel Assembly F63803-...5 F63808-...7, 5 F638-...7, 5 F6387-...7, 5 F63830-...7 Control Panel Decal F367...7 F368...7 F369...7 F370...7 F395...7 F396...7 F397...7 F398...7 F355...7 F356...7 F357...7 F358...7 Cotter Pin F300...9, 5 Cover F50305...7 F6076...3 F603003...3 C Catch F506... 3 Clamp F000... 37 F0005... 9, 35 F0006... 3 F0007... 9, F003... 9,, 35, 37 F005... 33, 35, 37 F009... 9,, 35, 37 Clamp Assembly F63030... 7 Clip F6055... 3 F63337... 5 F39 59
D Decal F300... 5 F3006... 5 F3007... 5 F305-... 5 F306... 5 F3066... 5 F30630... 5 F3066... 39 F3066... 39 F30693... 5, 39 F30756... 5 F30877... 5 F3065... 5 F36... 5 F3376-... 3 F3377... 5 F338... 3 F3393... F339... 8968R... 5 Diaphram G3000... 7 Dispenser F6037-3... 7 Door Assembly F60339-... 39 F60390-... 39 F60079-... 39 Door Glass F9005P... 39 F9007P... 39 F9008P... 39 Door Handle Kit F73055... 39 Door Handle Spacer F507... 39 Door Lock Assembly F636-3... 3 Door Lock Sub-assembly F633078... 3 Door Magnet F30703... 39 Door Mount F506... 39 Door Release Solenoid F3008... 3 Door Switch F30... 7 Drain Tee F5038... 35, 37 F50398... 35 Drain Valve F38068... 3 F38069... 3 Drain Valve Assembly F38068... 33 F38069... 33 Drive Pulley Key F3080... 9 Drive Shaft And Seal Kit F38098... 3, 33 Dual Fuseholder F3503...3 E Elbow F0...55 Electrical Panel F606950-...9 F607507...9 Extrusion Trim F505...39 Eye Bolt F30537...9, 5 F Filter F633508...5 Filter Assembly F70305...9 F70306...9 Filter Element F7005...9 F7006...9 Flange Relay F3307...9 Flat Cable F07...9 Flow Restrictor F380957...5 F380958...5 Frame Assembly F63378...7 F6336...7 F633950...7 F639...7 Fuse F3500... F35009...9 F3505...3 Fuse Board F3703...9 F37059...9 Fuse Holder F35030... Fuseholder F3503... Fuseholder Bracket F6333... G Gasket F7006...39 F703...39 F70...39 F705...7 F7070...7 F7007...9 Gasket O-ring F7009...39 60 F39
Ground Lug F073..., 3 Ground Terminal Lug F073... 53 H Handle F505... 39 Harness F6056... 9 Heating Element F36005... 57 Hinge F50... 39 F9003... 5 Hinge Rod F6083-... 39 F6083-3... 39 Hose F503... 35 F503... 35, 37 F503... 35 F5033... 35, 37 F5030... 35 F50356... 35 F5037... 37 F50399... 35 F5000... 35 F0008... 9, F005... 55 F0070... 37 Hose Screen F70300... 9 K Key F90805-...5 F3080...5 F3080...5 Key Motor F3080...9 Keypad F30608...7 F370576...7 L Latch F60753...5 Latch Arm F509...39 Lever F60538...3 Lid Lock F90805...5 Light F35006...3 F350...3 Lockwasher F300...3 Lower Brace F63800...5 F6380...5 F6380...5 F63803...5 I Inlet Hose F006... 9 F006... 9 Input Power Block F076... F077... Inverter Drive F370839... F37080... F3708... F3708... J J-Belt F80368... 9 F80370... 9 Junction Box Cover F60533... F63360... 53 M Magnetic Position Switch F30703...39 Manifold F5037...9 Microswitch F3099...3 Mixing Valve Mounting Plate F606595... Motor F03...5 F0393...9 F039...5 F0395...9 F38093...3, 33 F3809...3, 33 Motor Pulley Bushing F8009...9, 5 Muffin Fan F005... F006... F39 6
N Nipple F070...55 F0707...55 F0708...55 Nozzle F380300...3 Nozzle Kit F73068...3 Nut F30... F305...35, 37, 39, 3, 5, 7, 55 F308...7, 9, 5 F300...3 F30...3 F305...3 F303...3, 9,, 5, 53, 57 F303...7, 9, 3,, 39, 3, 53 F3039...7 F300...7 F30606...39 F306... F30...3, 39 F30...7 F30...39 O O-ring F7008...3 Outer Front Panel F63666-... F63683-... F63765-... F6387-... Out-of-Balance Switch F3090...35 Overflow Hose F5037...35 F5033...35, 37 Overflow Plug F5035...33 Overlay Decal F30...7 F303...7 F30...7 P Pipe F60837...37 Plug F9030...9 F3600...55, 57 F507...57 Poly V-Belt F80366...5 F80369...5 Pop Rivet F37...39 Power Input Block F077...53 Pulley F5069...9 F5070...9 F8087...9, 5 Pushbutton Rod F30300...39 Pushbutton Stop F60538...3 R Rear Panel F60...5 F603...5 F6039...5 F63075...5 Relay F3307...3 F33030...3 Repair Kit F380939...5 F38095...5 G58PE...7 Rivet F30...7 F35...5 Rocker Switch F30...3 Rod F603059...5 F603897...5 Roll Pin F3...39 S Screw F3000...9, 5 F3003...35, 37 F3008...55 F305...55 F307..., 3, 5, 53 F3077...9, F308... F3058...7 F30903..., 3, 53 F3096...9, 3, 39 F3097...9, 57 F3095...5 F3097...35, 37, 9 F3099... F30938..., 53 F309...7 F3098...9, F3099...7 F30956...39 F3097...39 F30976...39 F30977...3 F3098...3 F30983...3 F30987...7 F30996... 6 F39
Set Screw F3053... 39 F30533... 39 Shaft Seal F000... 7 F00... 7 F00... 7 Shell Assembly F606977... 55 F606978... 57 F60698... 55, 57 F60698... 55, 57 F630... 55, 57 Shell Band Kit F63977... 7 F7700... 7 F770... 7 F770... 7 Shell Front Assembly F60970-... 7 F6097-... 7 F6097-... 7 F63006... 7 Shell Front Gasket Kit F79000... 7 Shell Kit F63663... 7 F7006... 7 F7008... 7 F70... 7 Shim F60679... 39 F60385... 3 Side Panel F60307... 5 F60330... 5 F6065... 5 F63069... 5 F63333... 5 F6335... 5 F6335... 5 F63355... 5 Siphon Tube F50390... 9 Soap Dispenser Hose F50309... 35, 37 Solenoid Valve F380786... 55 F380787... 55 Spacer F006... 7 Splash Shield F3000... 3 Spring F30... 9, 5 F305... 39 Spring Clip F63337... 9 Standoff F8050... 9, F80506... 3 Start/Stop Switch Assembly F63350... 3 Steam Injector F6033... 55 Strainer Screen F7000...5 Strap F060...55 Stud F390300...5 Supply Dispenser F6037-3...9, Supply Dispenser Baffle F509...9 Support Rod F608...9 Switch Extension F3093...35 Switchplate Sub-assembly F63350...3 T Tag F3058...5 Tee F806...57 Temperature Probe F370606...55, 57 Terminal Block F077...3 Terminal Strip F0766...3 F0768..., 3, 53 Thermostat F900... 3-Way Mixing Valve Kit F3878... F3870... 3-Way Valve F3879...7 F3878... F3879...7 F38730... Top Cover Kit F63963...5 F758000-0...5 F75800-0...5 F758003...5 Torsion Spring F300...3 Transformer F3607... F360..., 37 Tri-Level Water Switch F3035...57 F303...57 F3038...57 Trunnion Kit F77003...7 F77009...7 F770...7 F770...7 Tubing F0068...3 F0...57 F39 63
V Vacuum Breaker Assembly F5039... Vacuum Breaker Bottom F50330... 9, Vacuum Breaker Hose F503... 9, F5030... 9, F5037... 9, Vacuum Breaker Top F5039... 9 Valve F63857... 7 F73055... 9 F73056... 9 Valve Body F38090... 3 Valve Panel Assembly F6339-... 5 F6339-... 5 F6339-3... 5 F6339-... 5 Velcro Strip F0639... 5 Vent Nipple F57... 37 W Washer F00500... 9 F30300... 9, 5 F30303... 7 F3037... 35, 37, 5, 7, 55 F303... F3035... 7, 9, 7, 9, 5 F30... F33... 3, 39 F35... 9, 5 F33... 3 F36... 9 F38... 7 F33... 7 F37... 7 F390... 3 F390... 3 F3903... 3 F3907... 39 Water Level Switch F3035... 9 F3038... 9 Y "Y" Connector F808... 6 F39