Washer-Extractor Cover Cabinet Hardmount -Speed Models with P, S or V Computers* SC8 UC8 HC8 SC5 UC5 HC5 SC7 UC7 HC7 SC5 UC5 HC5 SC50 UC50 HC50 Refer to Page 5 for Model Numbers *This manual applies to models of design -4 only Parts CHM757C www.comlaundry.com Part No. F75 August 00
Table of Contents Title Page Parts Ordering Information... Nameplate Location... Model Identification... 5 Decals... 6 Graphic Panels and Controls... 8 Graphic Panels and Controls... 0 Control Module... Control Module... 4 Contactors... 6 Optional Coin Box... 8 Coin Meter and Guide... 0 Dispenser... Supply Dispenser Assembly... 4 -Way Mixing Valve... 6 Supply Dispenser Assembly... 8 Automatic Supply Dispenser... 0 Filter (Optional) and Supply Hose... Drain Valve Assembly... 4 Drain Valve Assembly... 6 Drain Assembly, Hoses and Air Trap... 8 Drain Valve Assembly, Hoses and Air Trap... 40 Drain Valve Assembly, Hoses and Air Trap... 4 Door... 44 Outer Front Panel... 46 Door Lock... 48 Door Lock... 50 Panels... 5 Panels... 54 Inner Front Panel Kit Replacements... 56 Inner Front Panel Kit Replacements... 58 Shell Front, Basket, Outer Shell and Trunnion... 60 Shell Front, Basket, Outer Shell and Trunnion... 6 Motor, Pulley and Belt Assembly... 64 Motor, Pulley and Belt Assembly... 66 (continued) Copyright 00, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT
Motor, Pulley and Belt Assembly... 68 Motor, Pulley and Belt... 70 Steam Heat Option... 7 Electric Heat Option... 74 Electric Heat Option... 76 Capacitors Used on Single Phase Machines... 78 Parts Index... 79 F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT
LB Alliance Laundry Systems is not responsible for personal injury or property damage resulting from improper service. Review all service information before beginning repairs. If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (90) 748-950 for the name of the nearest authorized parts distributor. Parts Ordering Information For technical assistance, call either of the following numbers: (850) 78-06 Marianna, Florida (90) 748- Ripon, Wisconsin When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on nameplate(s) as shown. Nameplate Location Model No. HC80PCAU000 UNIMAC Serial No. 95074 Voltage 08-40 Amps 4 Required Circuit Breaker Amps. 40 Hz 60 Wire 4 Phase Max. Load 80 LB 6 KG Max. Speed 50 RPM Elec. Heating KW Steam Press PSI BAR Product No. 56050 Date Code 0797 95074 08-40 4 40 60 4 80 6 UNIMAC Model No. HC80PCAU000 Serial No. Voltage Amps Required Circuit Breaker Amps. Hz Wire Phase Max. Load KG Max. Speed RPM Elec. Heating KW Steam Press PSI BAR 56050 50 Product No. Date Code 0797 B55P F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT
Model Identification Information in this manual is applicable to these washer-extractors*: SC8VN SC8SN UC8VN UC8PN UC8PC HC8VC HC8SN HC8PC SC5VN SC5SN UC5VN UC5PN UC5PC HC5VC HC5SN HC5PC SC7VN SC7SN UC7VN UC7PN UC7PC HC7VC HC7SN HC7PC SC5VN SC5SN UC5VN UC5PN UC5PC HC5VC HC5SN HC5PC SC50VN SC50SN UC50VN UC50PN UC50PC HC50VC HC50SN HC50PC *This manual applies to models of design -4 only F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 5
locking during shipment. 0056-00B 8968R Decals 4 5 4 6 7 8 IMPORTANT 9 8968R Remove YELLOW retainer Before Starting Machine Note: A Retainer has been inserted to prevent the door from 0 CHM50P 6 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Decals REF PART # DESCRIPTION COMMENTS F0877 Decal OPL models only F007 Decal F006 Decal 4 F05- Decal 5 F060 Decal 6 F079 Decal 7 F46 Decal 8 F066 Decal 9 F00 Decal 0 F058 Tag OPL models only F06 Decal 8968R Decal F065 Decal 4 F069 Decal F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 7
Graphic Panels and Controls OPL Models 5 6 4 7 8 4 0 9 CHM759P 8 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Graphic Panels and Controls OPL Models REF PART # DESCRIPTION COMMENTS * F70576 Keypad UC F40608 Keypad SC F4064 Keypad HC F404 Momentary Switch * F498 Decal UC8VN, UC5VN, UC8PN and UC5PN; Control panel F497 Decal UC7VN and UC7PN; Control panel F496 Decal UC5VN and UC5PN; Control panel F495 Decal UC50VN and UC50PN; Control Panel F467 Decal SC8VN, SC5VN, SC8SN and SC5SN; Control panel F468 Decal SC7VN and SC7SN; Control panel F469 Decal SC5VN and SC5SN; Control panel F470 Decal SC50VN and SC50SN; Control panel F545 Decal HC8SN and HC5SN; Control panel F546 Decal HC7SN; Control panel F547 Decal HC5SN; Control panel F548 Decal HC50SN; Control panel 4 F4006 Spacer 5 F4 Lockwasher 6 F40 Nut 7 F70-0 Microcomputer V computer F70555- Microcomputer P and S computer; Armstrong F70555-0 Microcomputer P and S computer 8 F407 Screw 9 F40 Locknut 0 F406 Lockwasher F6055 Clip F6098 Switch Plate Subassembly F0840 Switch Plate Decal 4 F404 Rocker Switch Red *Please contact the factory for the part numbers of keypad or control panel decals in languages other than English. F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 9
Graphic Panels and Controls Coin Models 4 5 6 7 CHM760P 0 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Graphic Panels and Controls Coin Models REF PART # DESCRIPTION COMMENTS * F40605 Keypad UC F4065 Keypad HC * F068-00 Decal UC8PC and UC5PC; Control panel F060-00 Decal UC7PC; Control panel F048 Decal UC5PC; Control panel F048 Decal UC50PC; Control panel F550 Decal HC8PC, HC5PC, HC8VC and HC5VC; Control panel F55 Decal HC7PC and HC7VC; Control panel F55 Decal HC5PC and HC5VC; Control panel F55 Decal HC50PC and HC50VC; Control panel F4006 Spacer 4 F4 Lockwasher 5 F40 Nut 6 F7058-0 Computer P computer F7058-00 Computer P computer; For models with electric heat F70 Microcomputer Board V computer; Used until 7/5/99 F70-40 Microcomputer V computer; Used after 7/5/99 7 F06489-00 Coin Meter Mounting Shim For models without an extrusion only *Please contact the factory for the part numbers of keypad or control panel decals in languages other than English. F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT
Control Module PC, PN and SN Models 4 4 5 6 7 8 9 0 4 0 5 6 7 8 9 0 8 7 9 8 7 4 7 5 0 6 0 7 8 CHM76P Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Control Module PC, PN and SN Models REF PART # DESCRIPTION COMMENTS F7059P Battery Adapter Board F05 Delay Timer F400 Lockwasher 4 F40 Nut 5 F404 Cover 6 F07 RC Network Filter 7 F500 Fuse 8 F408 Lockwasher 9 F40904 Screw 0 F40 Nut F7046- Relay CCA 0 Volt; Includes relay; PC models only F7046- Relay CCA 0 Volt; Includes relay; PC models only F705 Capacitor F4097 Screw 4 F406 Clamp 5 F07 Flange Relay 0 Volt F00 Flange Relay 0 Volt 6 F409 Decal Terminal strip -8 7 F4096 Screw 8 F4078 Terminal Strip 9 F409 Decal Terminal strip 9-6 0 F4094 Decal Terminal strip 7-4 F4098 Screw F4095 Decal Terminal strip 5- F0606950-0 Electrical Panel Subassembly 4 F405 Water Level Switch SC8, UC8, HC8, SC5, UC5 and HC5; Without heat F40 Water Level Switch SC8, UC8, HC8, SC5, UC5 and HC5; With heat F40 Water Level Switch SC7, UC7 and HC7; With or without heat F407 Water Level Switch SC50, UC50 and HC50; With heat F40 Water Level Switch SC5, UC5, HC5, with or without heat; SC50, UC50 and HC50, without heat 5 F4096 Decal Terminal strip -40 6 F4 Lockwasher 7 F4 Lockwasher 8 F700 Bridge Rectifier OPL models only 9 F487 Input Harness Assembly 0 F70554 Fuse Board SN and PN models; 0 Volt F70450 Output Board CCA SN and PN models; 0 Volt F7059 Solid State Relay Board PC models; 0 Volt F60808 Solid State Relay Board PC models; 0 Volt F406 Cable SN and PN models; 0 Volt F500 Fuse Amp; Slo blo F5009 Fuse.5 Amp; Fast blo F4049 Wiring Harness Battery back-up 4 F90 Battery F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT
Control Module VC, VX and VN Models 4 5 6 7 8 9 0 4 4 5 0 9 8 6 7 CHM8P 4 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Control Module VC, VX and VN Models REF PART # DESCRIPTION COMMENTS F6475 Control Module Cover F4074 Screw F408 Lockwasher VC and VX models only 4 F40904 Screw VC and VX models only 5 F500 Fuse VC and VX models only 6 F0687-0 Door Lock CCA 0 Volt; VC and VX models only F0687-0 Door Lock CCA 0 Volt; VC and VX models only 7 F70448 Output Board CCA 0 Volt F70448-6 Output Board CCA 0 Volt 8 F705 Capacitor VC and VX models only 9 F4097 Screw VC and VX models only 0 F406 Clamp VC and VX models only F5009 Fuse F4048 Screw F4008 Screw 4 F604 Transformer With pump drain F607 Transformer Without pump drain 5 F0646-0 Control Box Assembly VX and VC models Control Box Assembly VN models; NLA 6 F4048 Screw 7 F07 Flange Relay 0 Volt F00 Flange Relay 0 Volt 8 F05 Timer VC and VX models only 9 F400 Lockwasher VC and VX models only 0 F40 Nut VC and VX models only F690 Water Level Switch Bracket F0404-0 Water Level Switch SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; Standard F04045-0 Water Level Switch SC5, UC5, HC5, SC50, UC50 and HC50; Standard F04050-00 Water Level Switch Heat safety F8050 Standoff 4 required 4 F4047 Cable NLA = Part no longer available F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 5
Contactors CHM76P 6 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Contactors REF PART # DESCRIPTION COMMENTS F075 Contactor 0 Volt F077 Contactor 0 Volt * F086 Contactor Interlock * F009-00 Contactor Overload SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7 F040 Contactor Overload SC5, UC5 and HC5 F009-00 Contactor Overload SC50, UC50 and HC50 *The Contactor Overloads and Contactor Interlock must be replaced as a group. F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 7
Optional Coin Box CHM764P 8 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Optional Coin Box REF PART # DESCRIPTION COMMENTS F6058 Key UG F6058 Key UG F60584 Key UG F60585 Key UG4 F60586 Key UG5 F60587 Key UG6 F60588 Key UG7 F60589 Key UG8 F60590 Key UG9 F6059 Key UG0 F6040 Key UG F604 Key UG F604 Key UG F604 Key UG4 F6044 Key UG5 F6068 Coin Box UG; Short F6069 Coin Box UG; Short F6060 Coin Box UG; Short F606 Coin Box UG4; Short F606 Coin Box UG5; Short F606 Coin Box UG6; Short F6064 Coin Box UG7; Short F6065 Coin Box UG8; Short F6066 Coin Box UG9; Short F6067 Coin Box UG0; Short F6067 Coin Box UG; Long F6067 Coin Box UG; Long F60674 Coin Box UG; Long Coin Box UG4; Long; NLA F60676 Coin Box UG5; Long NLA = Part no longer available F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 9
Coin Meter and Guide W000 4 5 6 7 8 9 0 CHMP 0 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Coin Meter and Guide W000 REF PART # DESCRIPTION COMMENTS F60684 Coin Meter U.S. Quarter; 0 Volt; Single drop F6078 Coin Meter U.S. Quarter; 0 Volt; Single drop F60979-6 Coin Meter Assembly U.S. Quarter; 4 Volt; Single drop F06070-00 Coin Meter U.S. $/.5; 0 Volt; Dual drop F060740-00 Coin Meter Canada $/.5; 0 Volt; Dual drop F6098-6 Coin Meter Assembly U.K. Pound/0 Pence; 0 Volt; Dual drop F06076-00 Coin Meter.50/.00 Euro; 0 Volt; Dual drop F60979-8 Coin Meter Assembly Australian $/.0; 0 Volt; Dual drop F60809- Coin Meter Assembly Taiwan 0 Yuan; 0 Volt; Single drop F06079-00 Coin Meter 500 Wan/Yen; 0 Volt; Single drop F6960-5 Coin Meter Assembly Japan 00/500 Yen; 0 Volt; Dual drop F6076 Coin Meter Japan 00/500 Yen; 0 Volt; Dual drop F60698 Coin Meter Africa /5 Rand; 0 Volt; Dual drop F6960-9 Coin Meter Assembly /5 Shekel; 0 Volt; Dual drop F6079 Coin Meter Jeton; 0 Volt; Single drop F06075-00 Coin Meter.880 Token; 0 Volt; Single drop F664-7 Coin Meter Assembly.880 Token; 0 Volt; Single drop F664-4 Coin Meter Assembly.990 Token; 0 Volt; Single drop F6077 Coin Meter.990 Token; 0 Volt; Single drop F00 Decal $.5 insert F60895 Coin Meter Insert 4 F4 Washer 5 F404 Locknut 6 F4057 Connector 7 F4057 Connector 8 F5 Rivet 9 F6084 Coin Guide Assembly Single drop F668 Coin Guide Weldment Dual drop 0 F607 Coin Meter Solenoid F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT
Dispenser 4 5 6 B05PEA Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Dispenser REF PART # DESCRIPTION COMMENTS F6040 Clamp Assembly F5005- Cover F447 Washer 4 F404 Locknut 5 F7070 Gasket 6 F050505-00 Dispenser Subassembly Coin models F6074- Dispenser OPL models; 4 liquid connectors F6074- Dispenser OPL models; 5 liquid connectors F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT
Supply Dispenser Assembly With Mueller Valve 4 5 4 4 0 9 8 7 6 8 4 9 5 7 6 0 4 4 CHM00P 4 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Supply Dispenser Assembly With Mueller Valve REF PART # DESCRIPTION COMMENTS F050505-00 Dispenser Subassembly Coin models F6074- Dispenser OPL models; 4 liquid connectors F6074- Dispenser OPL models; 5 liquid connectors F5090 Siphon Tube Optional F0007 Clamp #8 4 F0008 Hose Order 8 feet 5 F4096 Screw 6 F40948 Screw 7 F606595 Plate 8 F80740 -Way Valve Kit Includes strainer; 0 Volt F8074 -Way Valve Kit Includes strainer; 0 Volt 9 F0005 Clamp #0 0 F008 Hose Order foot F507 Manifold F40 Lockwasher F4099 Screw 4 F50 Hose SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7, HC7, SC5, UC5 and HC5 F5040 Hose SC50, UC50 and HC50 5 F00 Clamp #40 6 F009 Clamp #48 7 F600 Vacuum Breaker Assembly Includes items 8 and 9 F500 Vacuum Breaker Bottom 8 F0509-00 Vacuum Breaker Top 9 F4077 Screw 0 F40 Locknut F900 Cap Plug F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 5
-Way Mixing Valve Mueller Be Sure Pilot Hole Faces Inlet To The Valve. mm Repair Kit 4 6 mm Repair Kit 0 mm Repair Kit 5 B008PED 6 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
-Way Mixing Valve Mueller REF PART # DESCRIPTION COMMENTS F80900 Coil 0-7 Volt F8097 Coil 00-40 Volt F80954 Repair Kit 0 millimeters F8099 Repair Kit millimeters F80958 Flow Restrictor 4 millimeters 4 F7000 Strainer 5 F80957 Flow Restrictor.8 millimeters 6 F70455 -Way Valve Kit 0 Volt; Includes item 4 F70456 -Way Valve Kit 0 Volt; Includes item 4 F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 7
Supply Dispenser Assembly With Elbi Valves 5 6 7 8 9 0 4 6 4 5 4 4 5 5 4 7 4 9 8 4 4 0 CHM0P 8 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Supply Dispenser Assembly With Elbi Valves REF PART # DESCRIPTION COMMENTS F6477 Supply Dispenser Coin models F6074- Dispenser OPL models; 4 liquid connections F6074- Supply Dispenser OPL models; 5 liquid connections F0007 Clamp #8 F5090 Siphon Tube 4 F0008 Hose Order 5 feet 5 F40948 Screw 6 F4074 Screw 7 F660 Cover 8 F40766 Terminal 9 F4096 Screw 0 F4074 Ground Terminal Lug F4090 Screw F505 Fuse F050-0 Fuseholder 4 F40909 Bushing 5 F40 Locknut 6 F40 Nut 7 F878 -Way Valve Standard thread; 0 Volt F875 -Way Valve Metric thread; 0 Volt F870 -Way Valve Metric thread; 0 Volt 8 F870 -Way Valve Standard thread; 0 Volt F875 -Way Valve Metric thread; 0 Volt F878 -Way Valve Metric thread; 0 Volt 9 F4808 "Y" Connector 0 F00 Clamp #40 F50 Hose SC8, UC8, HC8, SC7, UC7, HC7, SC5, UC5 and HC5 F507 Hose SC5, UC5 and HC5 F5040 Hose SC50, UC50 and HC50 F009 Clamp #48 F600 Vacuum Breaker Assembly 4 F4077 Screw 5 F40 Locknut F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 9
Automatic Supply Dispenser 4 5 6 9 8 7 7 8 9 8 6 6 0 0 4 5 7 8 9 6 5 B06PEA 0 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Automatic Supply Dispenser REF PART # DESCRIPTION COMMENTS F7068 Nozzle Kit Includes items, 7 and 8 F8000 Nozzle F4096 Screw F4078 Terminal Strip 4 F0764 Decal External supply 5 F4 Lockwasher 6 F40 Nut 7 F4078 Terminal Strip 8 F470 Screw 9 F40748 Input Power Block terminal F40747 Input Power Block terminal F40746 Input Power Block 4 terminal 0 F4074 Ground Terminal Lug F49 Spacer F4097 Screw F505 Fuse 4 F050-0 Fuseholder 5 F60656 Supply Hose Bracket 6 F4074 Screw 7 F404 Nut 8 F0006 Clamp #4 9 F0068 Tubing Order foot 0 F7008 O-Ring F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT
Filter (Optional) and Supply Hose 4 5 6 B09PEB Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Filter (Optional) and Supply Hose REF PART # DESCRIPTION COMMENTS F7006 Filter Standard thread F7005 Filter Metric thread 090 Washer F70406 Replacement Filter. millimeter F70405 Replacement Filter.5 millimeter 4 F70407 Gasket 5 F7000 Filter Screen 6 F006 Hose /8 inch; Standard thread F0064 Hose /4 inch; Standard thread F0065 Hose /8 inch; Metric thread F0066 Hose /4 inch; Metric thread F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT
Drain Valve Assembly SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7, HC7, SC5, UC5 and HC5 CHM6P 4 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Drain Valve Assembly SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7, HC7, SC5, UC5 and HC5 REF PART # DESCRIPTION COMMENTS F6090 Drain Assembly 0 Volt; Includes all items on the page F6075 Drain Assembly 0 Volt; Includes all items on the page F8068 Drain Valve 0 Volt; Includes items and F8069 Drain Valve 0 Volt; Includes items and F8090 Valve Body F6076 Cover F809 Motor Round shaft; 0 Volt F809 Motor Round shaft; 0 Volt F8094 Motor Keyed shaft; 0 Volt G59764 Motor Keyed shaft; 0 Volt F8097 Motor Keyed shaft; 40 Volt F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 5
Drain Valve Assembly SC50, UC50 and HC50 4 CHM4P 6 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Drain Valve Assembly SC50, UC50 and HC50 REF PART # DESCRIPTION COMMENTS F005 Clamp #8 F505 Plug F809 Motor Round shaft; 0 Volt F809 Motor Round shaft; 0 Volt F8094 Motor Keyed shaft; 0 Volt G59764 Motor Box Keyed shaft; 0 Volt F8097 Motor Keyed shaft; 40 Volt 4 F8068 Drain Valve 0 Volt; Includes item and the attaching screw F8069 Drain Valve 0 Volt; Includes item and the attaching screw F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 7
Drain Assembly, Hoses and Air Trap SC8, UC8, HC8, SC5, UC5, HC5, SC5, UC5, HC5, SC50, UC50 and HC50 4 5 6 6 5 5 9 8 7 0 4 8 CHM0P 8 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Drain Assembly, Hoses and Air Trap SC8, UC8, HC8, SC5, UC5, HC5, SC5, UC5, HC5, SC50, UC50 and HC50 REF PART # DESCRIPTION COMMENTS F00 Clamp #40 F5009 Soap Dispenser Hose F009 Clamp #48 4 F50 Hose SC8, UC8, HC8, SC5, UC5 and HC5 F507 Hose SC5, UC5 and HC5 F5040 Hose SC50, UC50 and HC50 5 F005 Clamp #8 6 F507 Overflow Hose SC8, UC8, HC8, SC5, UC5 and HC5 F50 Overflow Hose SC5, UC5, HC5, SC50, UC50 and HC50 7 F400 Screw 8 F407 Washer 9 F508 Drain Tee SC8, UC8, HC8, SC5, UC5, HC5, SC5, UC5 and HC5 F5098 Drain Tee SC50, UC50 and HC50 0 F00 Clamp SC8, UC8, HC8, SC5, UC5, HC5, SC5, UC5 and HC5 F009 Clamp SC50, UC50 and HC50 F50 Rear Drain Hose SC8, UC8 and HC8 F50 Rear Drain Hose SC5, UC5, HC5, SC5, UC5 and HC5 F5099 Rear Drain Hose SC50, UC50 and HC50 F400 Screw F50 Front Drain Hose SC8, UC8, HC8, SC5, UC5, HC5, SC5, UC5 and HC5 F50400 Front Drain Hose SC50, UC50 and HC50 4 F405 Locknut 5 F004 Air Trap Hose 6 F0005 Clamp #0 F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 9
Drain Valve Assembly, Hoses and Air Trap SC50, UC50 and HC50; With Heat Shell 4 5 6 5 8 7 9 0 CHM0P 40 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Drain Valve Assembly, Hoses and Air Trap SC50, UC50 and HC50; With Heat Shell REF PART # DESCRIPTION COMMENTS F00 Clamp #40 F5009 Soap Dispenser Hose F009 Clamp #48 4 F5040 Vacuum Breaker Hose 5 F005 Clamp #8 6 F50 Overflow Hose 7 F400 Screw 8 F407 Washer 9 F405 Locknut 0 F5056 Drain Hose F004 Air Trap Hose F0005 Clamp #0 F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 4
Drain Valve Assembly, Hoses and Air Trap SC7, UC7 and HC7 0 9 4 7 6 5 0 6 0 4 8 6 5 8 7 7 0 9 6 5 CHM04P 4 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Drain Valve Assembly, Hoses and Air Trap SC7, UC7 and HC7 REF PART # DESCRIPTION COMMENTS F009 Clamp #48 F50 Vacuum Breaker Hose F00 Clamp #40 4 F487 Tee 5 F5008 Overflow Hose 6 F6087 Pipe 7 F50 Rear Drain Hose 8 F5044 Bottom Fill Hose 9 F457 Nipple 0 F0004 Clamp #0 F0070 Hose F50 Overflow Hose F005 Clamp #8 4 F508 Drain Tee 5 F400 Screw 6 F407 Washer 7 F50 Front Drain Hose 8 F405 Locknut 9 F004 Air Trap Hose 0 F0005 Clamp #0 F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 4
Door 8 0 9 4 6 7 5 6 4 5 8 9 0 7 4 5 6 8 7 0 9 CHM5P 44 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Door REF PART # DESCRIPTION COMMENTS F7055 Door Handle Kit Includes items,,, 4, 5 and 0 F066 Decal Red dot F000 Pushbutton Rod F4 Pin 4 F505 Handle 5 F05 Spring 6 F4907 Washer 7 F40976 Screw 8 F066 Decal Push red button 9 F404 Nut 0 F0507-00 Door Spacer F405 Screw SC8, UC8, HC8, SC5, UC5 and HC5 F405 Screw SC7, UC7, HC7, SC5, UC5, HC5, SC50, UC50 and HC50 F040 Locknut F0509-00 Latch Arm 4 F069 Decal Counterclockwise spin rotation 5 F9005 Door Glass SC8, UC8, HC8, SC5, UC5 and HC5 F9007 Door Glass SC7, UC7, HC7, SC5, UC5 and HC5 F9008 Door Glass SC50, UC50 and HC50 6 F7006- Gasket SC8, UC8, HC8, SC5, UC5 and HC5 F70- Gasket SC7, UC7, HC7, SC5, UC5 and HC5 F704- Gasket SC50, UC50 and HC50 7 F40906 Screw 8 F604079- Door Assembly SC8, UC8, HC8, SC5, UC5 and HC5; Includes magnet; Includes items -8, 5, 6, 9 and 0 F604079- Door Assembly SC8, UC8, HC8, SC5, UC5 and HC5; Coin models; Includes magnet; Includes items -8, 5, 6, 9 and 0 F604079- Door Assembly SC8, UC8, HC8, SC5, UC5 and HC5; OPL models; Includes items -8, 5, 6, 9 and 0 F609- Door Assembly SC7, UC7, HC7, SC5, UC5 and HC5; Includes magnet; Includes items -8, 5, 6, 9 and 0 F609- Door Assembly SC7, UC7, HC7, SC5, UC5 and HC5; Coin models; Includes magnet; Includes items -8, 5, 6, 9 and 0 F609- Door Assembly SC7, UC7, HC7, SC5, UC5 and HC5; OPL models; Includes items -8, 5, 6, 9 and 0 F6090-6 Door Assembly SC50, UC50 and HC50; Includes magnet; Includes items -8, 5, 6, 9 and 0 F6090-4 Door Assembly SC50, UC50 and HC50; Coin models; Includes magnet; Includes items -8, 5, 6, 9 and 0 F6090-5 Door Assembly SC50, UC50 and HC50; OPL models; Includes items - 8, 5, 6, 9 and 0 9 F40 Nut 0 F4 Lockwasher F4070 Magnet J905 Rivet F49 Screw 4 F4070 Magnetic Position Switch 5 F608- Rod 6 F906 Hinge 7 F60679 Shim As required 8 F4056 Screw 9 F405 Locknut 0 F506 Door Mount F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 45
Outer Front Panel 5 4 CHM6P 46 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Outer Front Panel REF PART # DESCRIPTION COMMENTS F4064 Nut F757440 Front Panel Kit SC8, UC8 and HC8; SS; OPL; Designs - F757406 Front Panel Kit SC8, UC8 and HC8; SS; Coin; Designs - F75746 Front Panel Kit SC8, UC8 and HC8; Almond; OPL; Designs - F757408 Front Panel Kit SC8, UC8 and HC8; Almond; Coin; Designs - F75747 Front Panel Kit SC8, UC8 and HC8; White; OPL; Designs - F757404 Front Panel Kit SC8, UC8 and HC8; White; Coin; Designs - F757445 Front Panel Kit SC5, UC5 and HC5; SS; OPL; Designs - F75744 Front Panel Kit SC5, UC5 and HC5; SS; Coin; Designs - F75744 Front Panel Kit SC5, UC5 and HC5; Almond; OPL; Designs - F7574 Front Panel Kit SC5, UC5 and HC5; Almond; Coin; Designs - F757444 Front Panel Kit SC5, UC5 and HC5; White; OPL; Designs - F75740 Front Panel Kit SC5, UC5 and HC5; White; Coin; Designs - F757485-0 Front Panel Kit SC7, UC7 and HC7; SS; OPL; Designs - Front Panel Kit SC7, UC7 and HC7; Almond; OPL; NLA; Designs - F757485-05 Front Panel Kit SC7, UC7 and HC7; White; OPL; Designs - F757484-0 Front Panel Kit SC7, UC7 and HC7; SS; Coin; Designs - F757484-0 Front Panel Kit SC7, UC7 and HC7; Almond; Coin; Designs - Front Panel Kit SC7, UC7 and HC7; White; Coin; NLA; Designs - F757450 Front Panel Kit SC5, UC5 and HC5; SS; OPL; Designs - F75749 Front Panel Kit SC5, UC5 and HC5; SS; Coin; Designs - F757447 Front Panel Kit SC5, UC5 and HC5; Almond; OPL; Designs - F75748 Front Panel Kit SC5, UC5 and HC5; Almond; Coin; Designs - F757446 Front Panel Kit SC5, UC5 and HC5; White; OPL; Designs - F75745 Front Panel Kit SC5, UC5 and HC5; White; Coin; Designs - F757455 Front Panel Kit SC50, UC50 and HC50; SS; OPL; Designs - F757405 Front Panel Kit SC50, UC50 and HC50; SS; Coin; Designs - F75745 Front Panel Kit SC50, UC50 and HC50; Almond; OPL; Designs - F7574 Front Panel Kit SC50, UC50 and HC50; Almond; Coin; Designs - F75745 Front Panel Kit SC50, UC50 and HC50; White; OPL; Designs - F7574 Front Panel Kit SC50, UC50 and HC50; White; Coin; Designs - F49 Screw 4 F05050-00 Trim 5 F40986 Screw NLA = Part no longer available F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 47
Door Lock Coin Models 6 6 4 5 4 5 8 7 0 6 9 5 4 7 9 8 0 CHM79P 48 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Door Lock Coin Models REF PART # DESCRIPTION COMMENTS F066698-05 Door Lock Assembly Standard V-series models F066698-04 Door Lock Assembly V-series models with heat F000 Splash Shield F490 Spacer Nylon F409 Door Lock Micro Switch 4 F405 Locknut Nylon 5 F40977 Screw 6 F6085 Shim 7 F066676-00 Door Lock Plate Subassembly 8 F6000 Cover 9 F4074 Screw 0 F506 Catch Casting F4098 Screw F400 Lockwasher F490 Washer Nylon 4 F06666-00 Door Lock Switch Lever 5 F00 Door Lock Torsion Spring 6 F40 Locknut Nylon 7 F4000 Door Switch 8 F40 Locknut 9 F407 Washer 0 F07 Door Lock Pin Release Spring F005 E-Ring Retainer F407 Locknut F4 Door Locking Pin 4 F50455 Door Pin Linkage 5 F4 Washer 6 F004 Solenoid F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 49
Door Lock OPL Models 6 5 4 5 4 9 0 9 7 8 7 8 6 5 4 9 0 CHM05P 50 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Door Lock OPL Models REF PART # DESCRIPTION COMMENTS F066678-00 Door Lock Subassembly 0 Volt F066678-0 Door Lock Subassembly 0 Volt F000 Splash Shield F490 Spacer Nylon F409 Door Lock Micro Switch 4 F405 Locknut Nylon 5 F40977 Screw 6 F6085 Shim 7 F066676-00 Door Lock Plate Subassembly 8 F6000 Cover 9 F4074 Screw 0 F506 Catch Casting F4098 Screw F400 Lockwasher F490 Washer 4 F06666-00 Door Lock Switch Lever 5 F00 Door Lock Torsion Spring 6 F40 Locknut Nylon 7 F407 Washer 8 F07 Door Lock Pin Release Spring 9 F005 E-Ring Retainer 0 F4 Door Locking Pin F50455 Door Pin Linkage F4 Washer F407 Locknut 4 F0660-00 Door Lock Retainer Latch 5 F008 Solenoid 0 Volt F00 Solenoid 0 Volt F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 5
Panels Page of 4 5 6 6 8 7 8 9 8 7 0 5 9 8 4 5 5 4 BPEB 5 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Panels Page of REF PART # DESCRIPTION COMMENTS F607 Bracket F45 Rivet F9080 Lock GR800 F90805 Lock RL00 F6056 Key GR800 F90805- Key RL00 4 F75800 Top Cover Kit SC8, UC8 and HC8; Includes items 7 and 8 F75800-0 Top Cover Kit SC5, UC5 and HC5; Includes items 7 and 8 F079896-00 Top Cover Assembly SC7, UC7 and HC7; Includes items 7 and 8 F75800-0 Top Cover Kit SC5, UC5 and HC5; Includes items 7 and 8 F758000-0 Top Cover Kit SC50, UC50 and HC50; Includes items 7 and 8 5 F40 Locknut 6 F9000 Stud 7 F900 Hinge 8 F4074 Screw 9 F4095 Screw 0 F75806 Valve Panel Kit SC8, UC8, HC8, SC5, UC5 and HC5; Includes items 9 and 5 Valve Panel KIt SC7, UC7 and HC7; MC and MN; Includes items 9 and 5; NLA F75807 Valve Panel Kit SC5, UC5 and HC5; Includes items 9 and 5 F75808 Valve Panel Kit SC50, UC50 and HC50; Includes items 9 and 5 F757000 Rear Panel Kit SC8, UC8 and HC8; Includes item 8 F75700 Rear Panel Kit SC5, UC5, HC5, SC7, UC7, HC7; MC and MN; Includes item 8 F079897-00 Rear Panel Kit SC7, UC7 and HC7; VC, PN and SN; Includes item 8 F75700 Rear Panel Kit SC5, UC5 and HC5; Includes item 8 F75700 Rear Panel Kit SC50, UC50 and HC50; Includes item 8 F6570- Panel SC8, UC8 and HC8; Left F657- Panel SC5, UC5 and HC5; Left F6574- Panel SC7, UC7 and HC7; Left F0657-0 Panel SC8, UC8 and HC8; Right F657- Panel SC5, UC5 and HC5; Right F6575- Panel SC7, UC7 and HC7; Right F64500- Panel SC5, UC5 and HC5; Right F6496- Panel SC50, UC50 and HC50; Right F75760 Side Panel Kit SC5, UC5 and HC5; Left F75760 Side Panel Kit SC50, UC50 and HC50; Left F4008 Screw 4 F407 Washer 5 F405 Locknut NLA = Part no longer available F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 5
Panels Page of 4 5 6 7 8 9 0 CHM06P 54 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Panels Page of REF PART # DESCRIPTION COMMENTS F6075 Latch F6060 Top Brace SC8, UC8 and HC8 F6069 Top Brace SC5, UC5 and HC5 F647 Top Brace SC7, UC7 and HC7 F6004 Top Brace SC5, UC5 and HC5 F607 Top Brace SC50, UC50 and HC50 F4005 Rivet 4 F70607 Grommet 5 F6096 Cover 6 F60694 Electrical Box Assembly 7 F40 Rivet Designs - only 8 F506 Extrusion Panel SC8, UC8, HC8, SC5, UC5 and HC5; Designs - only F5040 Extrusion Panel SC7, UC7 and HC7; Designs - only F504 Extrusion Panel SC5, UC5 and HC5; Designs - only F505 Extrusion Panel SC50, UC50 and HC50; Designs - only 9 F75706 Inner Front Panel Kit SC8, UC8 and HC8; Includes items 8 and 9; Designs - F75705 Inner Front Panel Kit SC5, UC5 and HC5; Includes items 8 and 9; Designs - F079898-00 Inner Front Panel Kit SC7, UC7 and HC7; Includes items 8 and 9; Designs - F7570 Inner Front Panel Kit SC5, UC5 and HC5; Includes items 8 and 9; Designs - F7570 Inner Front Panel Kit SC50, UC50 and HC50; Includes items 8 and 9; Designs - 0 F7040 Gasket Order feet for 8, 5 and 7-pound capacity models; Order 4 feet for 5 and 50-pound capacity models F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 55
Inner Front Panel Kit Replacements OPL Models; Design 4 Models 6 4 5 CHM7P 56 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Inner Front Panel Kit Replacements OPL Models; Design 4 Models REF PART # DESCRIPTION COMMENTS F64808- Control Panel Assembly SC8, UC8, HC8, SC5, UC5 and HC5 F6484- Control Panel Assembly SC7, UC7 and HC7 F6487- Control Panel Assembly SC5, UC5 and HC5 F6480- Control Panel Assembly SC50, UC50 and HC50 F407 Screw F64668- Bezel SC8, UC8, SC5 and UC5; Black F64668- Bezel HC8 and HC5; Pantone F6447- Bezel SC7, UC7, SC5 and UC5; Black F6447- Bezel HC7 and HC5; Pantone F64778- Bezel SC50 and UC50; Black F64778- Bezel HC50; Pantone 4 F64800 Brace SC8, UC8, HC8, NC8, SC5, UC5 and HC5 F6480 Brace SC7, UC7 and HC7 F6480 Brace SC5, UC5 and HC5 F6480 Brace SC50, UC50 and HC50 5 F6468-* Outer Front Panel SC8, UC8, HC8, SC5, UC5 and HC5 F64666-* Outer Front Panel SC7, UC7 and HC7 F6487-* Outer Front Panel SC5, UC5 and HC5 F64765-* Outer Front Panel SC50, UC50 and HC50 6 F40956 Screw *Denotes color of Outer Front Panel: - Stainless Steel; - Almond F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 57
Inner Front Panel Kit Replacements Coin Models; Design 4 Models 5 4 CHM8P 58 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Inner Front Panel Kit Replacements Coin Models; Design 4 Models REF PART # DESCRIPTION COMMENTS F64808- Control Panel Assembly SC8, UC8, HC8, SC5, UC5 and HC5 F6484- Control Panel Assembly SC7, UC7 and HC7 F6487- Control Panel Assembly SC5, UC5 and HC5 F6480- Control Panel Assembly SC50, UC50 and HC50 F7046- Bezel SC8, UC8, HC8, SC5, UC5 and HC5 F7047- Bezel SC7, UC7, HC7, SC5, UC5 and HC5 F7048- Bezel SC50, UC50 and HC50 F64800 Brace SC8, UC8, HC8, SC5, UC5 and HC5 F6480 Brace SC7, UC7 and HC7 F6480 Brace SC5, UC5 and HC5 F6480 Brace SC50, UC50 and HC50 4 F6468-* Outer Front Panel SC8, UC8 and HC8 F6486-* Outer Front Panel SC5, UC5 and HC5 F64665-* Outer Front Panel SC7, UC7 and HC7 F6486-* Outer Front Panel SC5, UC5 and HC5 F64764-* Outer Front Panel SC50, UC50 and HC50 5 F40956 Screw * Denotes color of Outer Front Panel: - Stainless Steel; - Almond F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 59
Shell Front, Basket, Outer Shell and Trunnion Page of 5 6 7 8 4 CHM06P 60 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Shell Front, Basket, Outer Shell and Trunnion Page of REF PART # DESCRIPTION COMMENTS F7400 Shell Front Kit SC8, UC8, HC8, SC5, UC5 and HC5 F6006 Shell Front Assembly SC7, UC7 and HC7 F740-0 Shell Front Kit SC5, UC5 and HC5 F740-0 Shell Front Kit SC50, UC50 and HC50 F79000 Shell Front Gasket Kit F4058 Screw 4 F407 Washer 5 F405 Locknut 6 F74700 Shell Band Kit SC8, UC8, HC8, SC5, UC5 and HC5; Includes items 4 and 5 F6977 Shell Band Assembly SC7, UC7 and HC7; Includes items 4 and 5 F7470 Shell Band Kit SC5, UC5 and HC5; Includes items 4 and 5 F7470 Shell Band Assembly Kit SC50, UC50 and HC50; Includes items 4 and 5 7 F604- Basket Assembly SC8, UC8 and HC8 F6064 Basket Assembly SC5, UC5 and HC5 F697 Basket Assembly SC7, UC7 and HC7 F605- Basket Assembly SC5, UC5 and HC5 F60900- Basket Assembly SC50, UC50 and HC50 8 F0055-00 Sleeve SC8, UC8 and HC8 F0049-00 Sleeve SC5, UC5 and HC5 F0056-00 Sleeve SC7, UC7 and HC7 F0057-00 Sleeve SC5, UC5 and HC5 F05058-00 Sleeve SC50, UC50 and HC50 F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 6
Shell Front, Basket, Outer Shell and Trunnion Page of 0 6 9 8 4 7 6 5 CHM064P 6 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Shell Front, Basket, Outer Shell and Trunnion Page of REF PART # DESCRIPTION COMMENTS F747000 Trunnion Kit SC8, UC8 and HC8; Includes items,,, 7 and F74700 Trunnion Kit SC5, UC5 and HC5; Includes items,,, 7 and F74700 Trunnion Kit SC7, UC7, HC7, SC5, UC5 and HC5; Includes items,,, 7 and F747004 Trunnion Kit SC50, UC50 and HC50; Includes items,,, 7 and F409 Locknut SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7 F4040 Locknut SC5, UC5, HC5, SC50, UC50 and HC50 F48 Washer SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7 F4 Washer SC5, UC5, HC5, SC50, UC50 and HC50 F60770 Trunnion Assembly SC8, UC8 and HC8; Includes item F60599 Trunnion Assembly SC5, UC5 and HC5; Includes item F6058 Trunnion Assembly SC50, UC50 and HC50; Includes item 4 F60700 Frame Assembly SC8, UC8 and HC8 F60678 Frame Assembly SC5, UC5 and HC5 F60 Frame Assembly SC7, UC7 and HC7 F607004 Frame Assembly SC5, UC5 and HC5 F607005 Frame Assembly SC50, UC50 and HC50 5 F408 Locknut 6 F400 Washer 7 F40949 Screw SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7 F40987 Screw SC5, UC5, HC5, SC50, UC50 and HC50 8 F64600 Shell Weldment SC8, UC8 and HC8 F64608 Shell Weldment SC5, UC5, HC5, SC7, UC7 and HC7 F6467 Shell Weldment SC5, UC5 and HC5 F64644 Shell Weldment SC50, UC50 and HC50 9 F400 Washer SC50, UC50 and HC50 only 0 F4094 Screw F0008 Shaft Seal SC8, UC8 and HC8 F004 Shaft Seal SC5, UC5 and HC5 F008 Shaft Seal SC7, UC7, HC7, SC5, UC5 and HC5 F009 Shaft Seal SC50, UC50 and HC50 F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 6
Motor, Pulley and Belt Assembly SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; Page of 8 6 7 4 5 9 CHM74P 64 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Motor, Pulley and Belt Assembly SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; Page of REF PART # DESCRIPTION COMMENTS F607 Bracket SC8, UC8 and HC8 F60505 Bracket SC5, UC5, HC5, SC7, UC7 and HC7 F4008 Screw Capacitor Refer to page 78 4 F4080 Key 5 F8068 Pulley SC8, UC8, HC8, NC8, SC5, UC5 and HC5 F807 Pulley SC7, UC7 and HC7 6 F0459-00 Washer 7 F4097 Screw 8 F804 Belt SC8, UC8 and HC8; J, D, C and G-voltage models; V-70 F08080-00 Belt SC8, UC8 and HC8; E-voltage model; V-70; Replaces belt F804 F807 Belt SC8, UC8 and HC8; Y, O, F, H and B-voltage models; V-70 F804 Belt SC8, UC8 and HC8; F and H-voltage models with heat; V-70; Replaces belt F807 F807 Belt SC5, UC5 and HC5; C, G, J, D, O, K, F, H and Y- voltage models; V-70 F08080-00 Belt SC5, UC5 and HC5; E-voltage models; V-70; Replaces belt F807 F80 Belt SC7, UC7 and HC7; V-800 9 F8040 Bushing SC8, UC8 and HC8; J, D, C and G-voltage models F8040 Bushing SC8, UC8 and HC8; E-voltage models; Used before 5/4/0 F8098 Bushing SC8, UC8 and HC8; E-voltage models; Used after 5/4/0 F8098 Bushing SC8, UC8 and HC8; O, B, F and H-voltage models; F and H-voltaage models with heat F8040 Bushing SC5, UC5 and HC5; C, G, J and D-voltage models F8098 Bushing SC5, UC5 and HC5; E-voltage models; Replaces bushing F804 F8098 Bushing SC5, UC5 and HC5; Y and L-voltage models; Replaces F009 bushing F8040 Bushing SC7, UC7 and HC7; C, G and D-voltage models F8040 Bushing SC7, UC7 and HC7; J-voltage models; Replaces bushing F0 F805 Bushing SC7, UC7 and HC7; E-voltage models; Replaces bushing F04 F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 65
Motor, Pulley and Belt Assembly SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; Page of 5 4 4 6 7 8 9 CHM75P 66 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Motor, Pulley and Belt Assembly SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; Page of REF PART # DESCRIPTION COMMENTS F8047 Pulley SC8, UC8 and HC8; J, D, C, G and E-voltage models; Replaces pulley F8084; Replacement of pulley F8084 requires bushing F8040 F8047 Pulley SC8, UC8 and HC8; E-voltage models; Replaces pulley F8084 or pulley F00 and bushing F8040; Replacement of pulley F8084 or pulley F00 and bushing F8040 requires bushing F8098 F8070 Pulley SC8, UC8 and HC8; O, F, H Y and B-voltage models F8070 Pulley SC8, UC8 and HC8; F and H-voltage models with heat F8047 Pulley SC5, UC5 and HC5; C, G, J and D-voltage models; Replaces pulley F8084; Replacement of pulley F8084 requires bushing F8040; Bushing F8040 is used with pulley F8047 F8047 Pulley SC5, UC5 and HC5; E-voltage models; Replaces pulley F8080; Replacement of pulley F8080 requires bushing F8098; Bushing F8098 is used with pulley F8047 F8070 Pulley SC5, UC5 and HC5; A, O, K, F and H-voltage models F8046 Pulley SC5, UC5 and HC5; Y and L-voltage models; Replaces pulley F809 and bushing F8098; Bushing F8098 is used with pulley F8046 F8048 Pulley SC7, UC7 and HC7; C, G and D-voltage models; Replaces pulley F808; Replaces pulley F809 and bushing F0; Replacement of pulley F808 or pulley F809 and bushing F0 requires bushing 8040; Bushing F8040 is used with pulley F8048 F804 Pulley SC7, UC7 and HC7; E-voltage models; Replaces pulley F8079 and bushing F804; Replacement of pulley F8079 and bushing F04 requires bushing F805; Bushing F805 is used with pulley F804 F8084 Pulley SC7, UC7 and HC7; A, O, K, F and H-voltage models F808 Pulley SC7, UC7 and HC7; Y and L-voltage models; Replaces pulley F8098 F4080 Key F0 Bushing 4 F405 Washer 5 F60844 Support Rod 6 F4040 Cotter Pin 7 F6055 Clip Elmo only 8 F04 Spring 9 M40059P Bearing F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 67
Motor, Pulley and Belt Assembly SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; Page of CHM76P 68 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Motor, Pulley and Belt Assembly SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; Page of REF PART # DESCRIPTION COMMENTS F096-H Motor SC8, UC8 and HC8; J and D-voltage models; Replaces motors F050 and F05; Order pulley F8047 and bushing F8040 when replacing either motor F050 or F05 F05-H Motor SC8, UC8 and HC8; C, G, F and H-voltage models with or without heat F05 Motor SC8, UC8 and HC8; E-voltage models; Replaces motors F07 and F00; Order pulley F8047 and bushing F8098 when replacing either motor F07 or F00 F096-H Motor SC8, UC8 and HC8; O-voltage models; Replaces motor F00; Order pulley F8070 when replacing motor F00 F00 Motor SC8, UC8 and HC8; B-voltage models F08-H Motor SC8, UC8 and HC8; Y-voltage models F088-H Motor SC5, UC5 and HC5; C, G, F and H-voltage models F089 Motor SC5, UC5 and HC5; J, D and U-voltage models F05 Motor SC5, UC5 and HC5; E-voltage models F087-H Motor SC5, UC5 and HC5; A, O and K-voltage models F04-H Motor SC5, UC5 and HC5; Y and L-voltage models F088-H Motor SC7, UC7 and HC7; C, F and H-voltage models F089 Motor SC7, UC7 and HC7; J, D and U-voltage models F05 Motor SC7, UC7 and HC7; E-voltage models F087-H Motor SC7, UC7 and HC7; A, O and K-voltage models F04-H Motor SC7, UC7 and HC7; Y and L-voltage models F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 69
Motor, Pulley and Belt SC5, UC5, HC5, SC50, UC50 and HC50 9 7 8 5 4 6 6 5 4 8 7 6 7 9 0 CHM08P 70 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Motor, Pulley and Belt SC5, UC5, HC5, SC50, UC50 and HC50 REF PART # DESCRIPTION COMMENTS Capacitor Refer to page 78 F4008 Screw F60505 Capacitor Mounting Bracket 4 F807 Pulley SC5, UC5 and HC5 F807 Pulley SC50, UC50 and HC50 F74800 Pulley Kit SC5, UC5 and HC5; Includes items, 4, 5 and 7 F74800 Pulley Kit SC50, UC50 and HC50; Includes items, 4, 5 and 7 5 F4080 Key 6 F0 Bushing 7 F405 Washer 8 F60059 Rod SC5, UC5 and HC5 F60897 Rod SC50, UC50 and HC50 9 F4040 Cotter Pin 0 F06-H Motor SC5, UC5 and HC5; C, G, F and H -voltage models F00-00 Motor SC5, UC5 and HC5, J, D, O and K-voltage models; Replaces motor F05; Order pulley F8048 and bushing F8098 when replacing motor F05 F00-00 Motor SC5, UC5 and HC5; Y-voltage models F054 Motor SC50, UC50 and HC50; D-voltage models F00-00 Motor SC50, UC50 and HC50; J-voltage models; Replaces motor F054; Order pulley F804 and bushing F8044 when replacing motor F05 F07 Motor SC50, UC50 and HC50; C, G, F and H-voltage models F00-00 Motor SC50, UC50 and HC50; O-voltage models F000-0 Motor SC50, UC50 and HC50; Y-voltage models F004 Bearing F04 Spring F6055 Clip Elmo only 4 F8098 Bushing SC5, UC5 and HC5; C, G, J and D-voltage models F805 Bushing SC50, UC50 and HC50; D, J, C and G-voltage models 5 F8048 Pulley SC5, UC5 and HC5; C, G, J and D-voltage models; Replaces pulley F8085; Bushing F8098 is used with pulley F8048 F808 Pulley SC5, UC5 and HC5; Y, O, K, F and H-voltage models F804 Pulley SC50, UC50 and HC50; D, J, C and G-voltage models; Replaces pulley F8086; Bushing F805 is used with pulley F804 F8077 Pulley SC50, UC50 and HC50; O, K, Y, F and H-voltage models 6 F4080 Key 7 F45 Washer 8 F4000 Screw 9 F804 Belt SC5, UC5 and HC5; C, G, J and D-voltage models; V-850 F804 Belt SC5, UC5 and HC5; Y, O, K, F and H-voltage models; V-80 F807 Belt SC50, UC50 and HC50; D, J, C and G-voltage models; V-90.65; Replaces belt F8004 in 50 Hz models F8004 Belt SC50, UC50 and HC50; O, K, Y, F and H-voltage models; V-900 F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 7
Steam Heat Option 4 5 7 8 6 9 0 7 4 5 8 6 9 7 8 6 5 4 0 CHM04P 7 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Steam Heat Option REF PART # DESCRIPTION COMMENTS F496 Bushing F70606 Temperature Probe F4806 Tee 4 F04050-00 Water Level Switch VN and VC models only; Heat safety 5 F0404-0 Water Level Switch SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; Standard F04045-0 Water Level Switch SC5, UC5, HC5, SC50, UC50 and HC50; Standard 6 F4404 Tubing Order foot 7 F407 Screw 8 F606005 Bracket 9 F4074 Screw 0 F606978 Shell Assembly SC8, UC8 and HC8; Heat option F606980 Shell Assembly SC5, UC5 and HC5; Heat option F60 Shell Assembly SC7, UC7 and HC7; Heat option F60698 Shell Assembly SC5, UC5 and HC5; Heat option F606984 Shell Assembly SC50, UC50 and HC50; Heat option F404 Elbow F40708 Nipple F40707 Nipple 4 F40887 Harness Assembly 5 F80786 Valve 0 Volt F80787 Valve 0 Volt 6 F4070 Nipple 7 F600 Plug 8 F407 Washer 9 F4008 Screw 0 F0054 Hose Includes fitting F60 Steam Injector Tube Assembly F405 Screw F4060 Strap 4 F40409 Plug 5 F7007 Steam Filter 6 F6086 Bracket Assembly All models except SC7, UC7 and HC7 F654 Bracket Weldment SC7, UC7 and HC7 7 F405 Locknut F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 7
Electric Heat Option Page of 4 5 8 7 6 CHM9P 74 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Electric Heat Option Page of REF PART # DESCRIPTION COMMENTS F4404 Tubing Order foot F04050-00 Water Level Switch VN and VC models only; Heat safety F0404-0 Water Level Switch SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; Standard F40 Water Level Switch SC8, UC8, HC8, SC5, UC5 and HC5; V-computer models F40 Water Level Switch SC7, UC7 and HC7; P and S-computer models F405 Water Level Switch SC7, UC7 and HC7; V-computer models F40 Water Level Switch SC5, UC5, HC5; P and S-computer models F04045-0 Water Level Switch SC5, UC5, HC5, SC50, UC50 and HC50; Standard F407 Water Level Switch SC50, UC50 and HC50; P and S-computer models 4 F407 Screw 5 F606005 Bracket 6 F40 Locknut 7 F4074 Screw 8 F4806 Tee F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 75
Electric Heat Option Page of 6 7 5 4 CHM045P 76 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Electric Heat Option Page of REF PART # DESCRIPTION COMMENTS F087 Contactor SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; 0 Volt; L and Y-voltage models F088 Contactor SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; 0 Volt; E-voltage models F075 Contactor SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; 0 Volt; D, J and O-voltage models F077 Contactor SC8, UC8, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; 0 Volt; D, J and O-voltage models F087 Contactor SC50, UC50 and HC50; 0 Volt; D, J and O-voltage models F088 Contactor SC50, UC50 and HC50; 0 Volt; D, J and O-voltage models F075 Contactor SC8, UC80, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; 0 Volt F077 Contactor SC8, UC80, HC8, SC5, UC5, HC5, SC7, UC7 and HC7; 0 Volt F087 Contactor SC50, UC50 and HC50; 0 Volt; H-voltage models F088 Contactor SC50, UC50 and HC50; 0 Volt; C-voltage models F080 Contactor SC50, UC50 and HC50; 0 Volt; F, N and P-voltage models F08 Contactor SC50, UC50 and HC50; 0 Volt; F, N and P-voltage models F4096 Screw F600 Plug 4 F6006 Heating Element.0 kw F6005 Heating Element.6 kw 5 F496 Bushing 6 F70606 Temperature Probe 7 F606977 Shell Assembly SC8, UC8, HC8 and NC8; Heat option F606980 Shell Assembly SC5, UC5, HC5 and NC5; Heat option F60 Shell Assembly SC7, UC7, HC7 and NC7; Heat option F60698 Shell Assembly SC5, UC5 and HC5; Heat option F606984 Shell Assembly SC50, UC50 and HC50; Heat option F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT 77
Capacitors Used on Single Phase Machines MACHINE 8-Pound Capacity 8-Pound Capacity 8-Pound Capacity 8-Pound Capacity 5 and 7-Pound Capacity 5 and 7-Pound Capacity 5-Pound Capacity 5-Pound Capacity 50-Pound Capacity VOLTAGE PHASE MOTOR BRAND CAPACITORS USED 0-60 Elmo 00 + 0 (Spin Start/Run) 00 (Wash Run) 0/60 Elmo 0 + 50 (Spin Start/Run) 5 (Wash Run) 0/60 Century 00 + 00 (Spin Start/Run) 0 (Wash Run) 0/50 Century 50 +50 (Spin Start/Run) 0 + 5 (Wash Run) 08-40/60 Elmo 0 (Spin Start) + 0 + 0 (Spin Start/Run) 0 + 0 (Wash Run) 0-40/50 Elmo 0 + 0 + 0 (Spin Start) + 00 + 00 (Spin Start/Run) 0 + 0 (LS Run) 08-40/60 Elmo 60 (Spin Start) + 50 (Spin Start/Run) 0 + 5 (Wash Run) 08-40/80 Century 0 + 60 (Spin Start/Run) 0 + 50 (Wash Run) 08-40/60 Elmo 0 + 0 + 0 (Spin Start) + 50 + 0 (Spin Start/Run) 0 + 50 (Wash Run) CAPACITOR PART NUMBER 60 Microfarad F708 0 Microfarad F700 00 Microfarad F70 50 Microfarad F70 5 Microfarad F70 0 Microfarad F704 0 Microfarad F700 0 Microfarad with Resistor F705 60 Microfarad with Resistor F7044 78 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT F75
Parts Index A F8040...65 F496...7, 77 Air Trap Hose F004... 9, 4, 4 C B Basket Assembly F604-... 6 F605-... 6 F60900-... 6 F6064... 6 F697... 6 Battery F90... Battery Adapter Board F7059P... Bearing F004... 7 M40059P... 67 Belt F08080-00... 65 F8004... 7 F80... 65 F807... 65 F804... 7 F804... 7 F804... 65 F807... 7 Bezel F7046-... 59 F7047-... 59 F7048-... 59 F6447-... 57 F6447-... 57 F64668-... 57 F64668-... 57 F64778-... 57 F64778-... 57 Bottom Fill Hose F5044... 4 Brace F64800... 57, 59 F6480... 57, 59 F6480... 57, 59 F6480... 57, 59 Bracket F607... 5 F607... 65 F60505... 65 F606005... 7, 75 Bracket Assembly F6086... 7 Bracket Weldment F654... 7 Bridge Rectifier F700... Bushing F0... 67, 7 F40909... 9 F8009... 65 F805... 65, 7 F8098... 65, 7 Cable F406... F4047...5 Cap Plug F900...5 Capacitor F708...78 F700...78 F70...78 F70...78 F70...78 F704...78 F705..., 5 F700...78 F7044...78 F705...78 Capacitor Mounting Bracket F60505...7 Catch Casting F506...49, 5 Clamp F406..., 5 F0004...4 F0005...5, 9, 4, 4 F0006... F0007...5, 9 F00...5, 9, 9, 4, 4 F005...7, 9, 4, 4 F009...5, 9, 9, 4, 4 Clamp Assembly F6040... Clip F6055...9, 67, 7 Coil F80900...7 F8097...7 Coin Box F6068...9 F6069...9 F6060...9 F606...9 F606...9 F606...9 F6064...9 F6065...9 F6066...9 F6067...9 F6067...9 F6067...9 F60674...9 F60676...9 Coin Guide Assembly F6084... Coin Guide Weldment F668... Coin Meter F06070-00... F06075-00... F06076-00... F75 79 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT
F06079-00... F060740-00... F60684... F60698... F6076... F6077... F6078... F6079... Coin Meter Assembly F60809-... F60979-6... F60979-8... F6098-6... F664-4... F664-7... F6960-5... F6960-9... Coin Meter Insert F60895... Coin Meter Mounting Shim F06489-00... Coin Meter Solenoid F607... Computer F7058-00... F7058-0... Connector F4057... F4057... Contactor F075... 7, 77 F077... 7, 77 F080... 77 F08... 77 F087... 77 F088... 77 Contactor Interlock F086... 7 Contactor Overload F009-00... 7 F009-00... 7 F040... 7 Control Box Assembly F0646-0... 5 Control Module Cover F6475... 5 Control Panel Assembly F64808-... 59 F64808-... 57 F6484-... 59 F6484-... 57 F6487-... 59 F6487-... 57 F6480-... 59 F6480-... 57 Cotter Pin F4040... 67, 7 Cover F404... F5005-... F6076... 5 F6096... 55 F6000... 49, 5 F660... 9 D Decal F060-00... F068-00... F409... F409... F4094... F4095... F4096... F00...7 F006...7 F007...7 F05-...7 F06...7 F048... F048... F066...7 F060...7 F066...45 F066...45 F069...7, 45 F079...7 F0764... F0877...7 F00... F065...7 F46...7 F467...9 F468...9 F469...9 F470...9 F495...9 F496...9 F497...9 F498...9 F545...9 F546...9 F547...9 F548...9 F550... F55... F55... F55... 8968R...7 Delay Timer F05... Dispenser F6074-..., 5, 9 F6074-..., 5 Dispenser Subassembly F050505-00..., 5 Door Assembly F609-...45 F609-...45 F609-...45 F6090-4...45 F6090-5...45 F6090-6...45 F604079-...45 F604079-...45 F604079-...45 Door Glass F9005...45 F9007...45 F9008...45 80 F75 Copyright, Alliance Laundry Systems LLC DO NOT COPY or TRANSMIT