PRATLEY CABLE GLANDS - FOR NON HAZARDOUS AREAS

Transcription

1 Page HED OFFICE & WORKS JCKSON STREET, FCTORI, KRUGERSDORP, GUTENG. PO, KENMRE,. TEL.: () 9-9 FX: () [email protected] PRTLEY (PTY) LTD. SOUTH FRICN BRNCHES CPE TOWN: -9 Coronation Road, Maitland. Tel.: () -// Fax.:() - [email protected] DURBN: Linze Road, Stamford Hill. Tel.: () 9-9/9- Fax.: () 9- [email protected] Directors: K.G.M. PRTLEY Pr. Eng. M.Sc.Mech.Eng. MS..I. Mech.E. M.S..I.M (Managing), I.D. ELSWORTH.C.M..,.C.I.S., F.C.I.B.M.(Financial) NOTE: SEE TERMS ND CONDITIONS T THE END OF THE LIST. PORT ELIZBETH: Pickering Street, Newton Park P.E. Tel.: () - Fax.:() - [email protected] PRTLEY CBLE GLNDS - FOR NON HZRDOUS RES PRTLEY DJUSTBLE GLNDS For SW CBLE (NICKEL PLTED BRSS) (Refer to Sales Leaflet No. ) GLND DJUSTS to accommodate any size armouring! DIFFERENTIL THREDS grip armouring like no other. LIKE HVING BUILT-IN GER" Supplied complete with nickel plated brass locknuts. Shrouds should be fitted, but must be ordered separately. IP if fitted with nipple gasket, inner seal and shroud. The size gland has a fixed nipple and is not adjustable. Sizes 9 & are stud type glands. ccessories see Page &. P P R O V E D SNS 9 THRED M M M M M M M M M N/ N/ (Without shroud) 9,,, 9,,,, 99,, 9,, WITH SPECIL THREDS (Refer to Sales Leaflet No. ) Special Thread Glands are not supplied with locknuts. For Special Threads for sizes to refer to daptors on page. TYPE/ THRED Pg., Pg. ½ N.P.T. 9, 9, 9, PRTLEY BRSS COMPRESSION GLNDS For all circular unarmoured cables. (NICKEL PLTED BRSS) (Refer to Sales Leaflet No. ) Supplied with nickel plated brass locknuts unless otherwise specified. These are Fixed Nipple glands with Rubber Compression Bushes. No shrouds are required. ccessories see Page. s THRED M M M M M M M M M M M,,,,,9 9,9,, 9, 9, 9, S & WITH SPECIL THREDS (Refer to Sales Leaflet No. ) Pratley Special Thread Glands are not supplied with locknuts. P P R O V E D SNS TYPE/ THRED Pg., Pg., Pg.,,, PRTLEY SPECIL BC BRSS COMPRESSION GLND (Refer to Sales Leaflet No. ) special version of gland for aerial bundled cable incorporates a special clover shaped bush. Supplied with gland. BC mm 9, mm 9, JUN

2 Page PRTLEY TUFFLON COMPRESSION GLNDS Particularly suited to instrumentation and appliances. (Refer to Sales Leaflet No. ) Compression glands made from an exceptionally tough engineering plastic (not to be confused with ordinary PVC glands). ccessories see Page. No. P P R O V E D IP s L WHITE THRED M M M M M GREY BLCK 9, 9, 9,,, CCESSORIES - FOR PRTLEY GLNDS IN NON HZRDOUS RES INNER SEL KIT For djustable Glands (Refer to Sales Leaflet No. ) Inner Seals are used to seal pressure tight against the cable bedding. If also fitted with a nipple gasket and shroud, the djustable cable gland will maintain an IP rating. Please specify "for Glands" and use the Cat. when ordering. Rubber Sealing Bush Cup Washer 9, 9,,,,, 9,,, COMPRESSION CONVERSION KIT For djustable Glands (Refer to Sales Leaflet No. ) Inexpensive Kit replaces the Cone Bush in an djustable Gland to convert the gland for use with unarmoured cable. When ordering specify (for djustable Gland) and use catalogue no. The No. L kit has no retaining washer. Retaining Washer (Nickel Plated) Bush Tapered Washer (Nickel Plated) LRGE 9 9 SMLL 9 9,,,,,9,,,, DPTORS For djustable Glands IMPERIL & PG. (NICKEL PLTED BRSS) (Refer to Sales Leaflet No. ) Pg. and Imperial daptors replace the Standard Nipple in a Pratley djustable Gland. The gland may then be screwed directly into Pg. (DIN Standard) or Imperial threaded entries respectively. EXTENDED LENGTH S FOR DJUSTBLE GLNDS (NICKEL PLTED) (Refer to Sales Leaflet No. ) Replace the standard nipple when required for exceptionally thick gland plates. Special Thread daptor L Fit REMOVE IMPERIL DPTOR No. Gland to ¾ No. Gland to No. Gland to ¼ No. Gland to ½ M M M M M Pg. DPTOR No. to Pg., No. to Pg. No. to Pg. No. to Pg., No. to Pg. No. to Pg. No. to Pg. No. to Pg. 9 No. to Pg. 9 LENGHTH (mm),, 9,,, , 9,, 9, Pg. DPTOR S Pg. DPTOR S Pg. Entry ø Pg. Entry ø Pg. 9,mm Pg.,mm Pg. Pg.,,9mm 9,mm Pg. Pg. 9,mm,mm ,,,,,,,, 9,, 9,,,, JUN

3 Page CCESSORIES - FOR PRTLEY GLNDS IN NON HZRDOUS RES PRTLEY BRSS ERTH TGS For djustable & Other Glands (Refer to Sales Leaflet No. ) More than one Earth Tag may be required, depending on conductor size and length. GLND No. & No. No. No. No. No. No. No. RTED Ø Ø RE. mm,, mm. mm,, mm. mm,, mm. mm, 9, mm. mm,, mm. mm,, mm. mm,, mm. mm,, mm CT 9,,, 9,,9,,9 9, PRTLEY STNDRD WTERPROOFING SHROUDS For use with:- Pratley djustable, Flameproof and Ex e Cable Glands & Pratley luminium lloy and EZEE-FIT Cable Boxes. PRTLEY LONG WTERPROOFING SHROUDS For djustable Glands (Refer to Sales Leaflet No. ) Designed for use in corrosive environments with Pratley djustable Cable Glands only. Not for use on boxes. Standard and Long Shrouds are made from specially formulated ultra violet and chemical resistant rubber (UV-C). On special request a hydrocarbon resistant (H-C) version (not U.V. resistant) can be supplied. Standard Long ,9,,,9,9,, 9, 9,,,9,,,, 9,, PRTLEY LOCKNUTS (NICKEL PLTED BRSS) For use with:- Pratley djustable Glands, Compression Glands, Ex e, Ex e Ultra, Ex e Compression, Enviro and Enviro Compression Glands. Sizes,,, & are Castellated Locknuts. Unplated brass locknuts can be supplied on special request. For nickel plated steel locknuts see page 9. Locknut Castellated Locknut THRED M M M M M M M M M M 9 9,,,,,,,,,9, xs COMPRESSION KIT For Size Brass Compression Gland for use with Instrumentation Cable (Refer to Sales Leaflet No. ) xs kit reduces the capacity of gland to accommodate small diameter (- mm) instrumentation cable. For Brass Compression Gland KIT KIT CBLE Ø xs - mm 9, xs COMPRESSION KIT For Size s Tufflon Compression Gland for use with Instrumentation Cable (Refer to Sales Leaflet No. ) xs kit reduces the capacity of s gland to accommodate small diameter (- mm) instrumentation cable. DPTOR BUSHES FOR FLT TWIN & ERTH CBLES For Pratley Brass Compression Glands & Pratley Tufflon Compression Glands. (Refer to Sales Leaflet No. ) For Tufflon Gland For Brass & Tufflon Gland KIT CBLE Ø KIT xs - mm 9, TUFFLON GLND BRSS BUSH & s, L & &,9,, JUN

4 Page PRTLEY CBLE GLNDS - FOR HZRDOUS RES PRTLEY Ex e GLNDS For SW Cable (NICKEL PLTED BRSS) (Refer to Sales Leaflet No. ) IP Pratley Ex e Cable Glands have fixed nipples and are supplied complete with Waterproofing Shrouds, Inner Seals, locknut and a gasket on the nipple. Certified to SBS for use with Ex e apparatus in Zone,,, & areas. Groups II, IIB & IIC. EPL Da & Gb. PRTLEY Ex e NO. GLND WITH EXTENDED & SHROUD (NICKEL PLTED BRSS) (Refer to Sales Leaflet No. ) Ex e Ex t IP CERTIFICTION PPROVED SNS 9- SNS 9- SNS 9- SNS SNS 9 SUITBLE FOR USE IN ZONE,,, &. SUITBLE FOR USE WITH Ex e EQUIPMENT. SBS TEST REPORT /-9. I.. CERTIFICTE S/-9U s s THRED M M M M M M M M M M THRED M M M M M M M M M M WITH SHROUDS,,,, 9, 9,,,, 9, WITHOUT SHROUDS 9,,,,,, 9,,,9,9 THRED M 9, PRTLEY Ex e BRSS COMPRESSION GLNDS For Unarmoured Cable (NICKEL PLTED BRSS) IP (Refer to Sales Leaflet No. ) Pratley Ex e Brass Compression Cable Glands are fitted with a locknut and gasket on the nipple. Certified to SBS for use with Ex e apparatus in Zone,,, & areas. Groups II, IIB & IIC. EPL Da & Gb. ccessories see Page &. Ex e Ex t IP CERTIFICTION PPROVED SNS 9- SNS 9- SNS 9- SNS SNS 9 SUITBLE FOR USE IN ZONE,,, &. SUITBLE FOR USE WITH Ex e EQUIPMENT. SBS TEST REPORT /-9. I.. CERTIFICTE S/-9U THRED M, s M M M M M M M M M M ,,, 9,,,,,, 99, PRTLEY Ex e HV TPE RMOUR MUNICIPL GLND For medium voltage cable (NICKEL PLTED BRSS) (Refer to Sales Leaflet No. ) Specially designed for medium voltage tape armoured lead sheathed cable. Supplied complete with Waterproofing Shroud, Nipple Gasket & Brass Lock Nut. PRTLEY Ex e HV TPE RMOUR PETRO GLND For medium voltage cable (NICKEL PLTED BRSS) (Refer to Sales Leaflet No. ) Specially designed for medium voltage tape armoured lead sheathed cable as used in the Petrochemical industry. It has a Back Nut Seal and a special nipple extension for fitting a Hv conductor crutch boot. Supplied with Nipple Gasket, Brass Lock Nut, M bolt and star washer to attach earth wire to gland. (Lug not supplied). CERTIFICTION MUNICIPL & PETRO GLNDS Ex e Ex td IP PPROVED SNS 9- SNS 9- SNS SNS 9 SNS -/ SUITBLE FOR USE IN ZONE,,, &. SUITBLE FOR USE WITH Ex e EQUIPMENT. SBS TEST REPORT /-. I.. CERTIFICTE S/-U. THRED M, M, M, THRED M, M, M9 9, Nipple Thread size is larger than gland size JUN

5 Page PRTLEY CBLE GLNDS - FOR HZRDOUS RES PRTLEY Ex e ULTR GLND For lead sheathed SW cable (NICKEL PLTED BRSS) (Refer to Sales Leaflet No. ) This ultra high quality Ex e fixed nipple gland is for lead sheathed SW cable. Supplied complete with lead bush (Custom made for lead sheath cable), high tensile cone ring, cone bush. lock nut, gasket & shroud. When ordering glands for lead sheath cable, please specify actual measured lead sheath diameter. Ex e Ex t IP CERTIFICTION PPROVED SNS 9- SNS 9- SNS 9- SNS SNS 9 SUITBLE FOR USE IN ZONE,,, &. SUITBLE FOR USE WITH Ex e EQUIPMENT. SBS TEST REPORT /-9. I.. CERTIFICTE S/-9U. THRED M M, 9, M M M M M M M,,,, 9,,, PRTLEY Ex e ENVIROGLNDS For SW cable (Refer to Sales Leaflet No. ) Ultra tough corrosion resistant plastic encaptulated brass cable glands. Supplied complete with brass locknut, gasket Inner and outer seal. Fully certified to SBS EN/TEX & IEC Standards for use with Ex e apparatus in Zone,,,, & areas. EPL Da & Gb. Features: Hazardous Ex locations identification band. Built in Safety Gauge. Completely sealed. Corrosion resistant. IP Tough engineering plastic won t crack when tightened. Brass internal components. Not suitable for strong mineral acid environments. See Green Enviroglands for this application. PRTLEY Ex e ENVIROGLNDS GREEN (Refer to Sales Leaflet No. ) vailable on request. Suitable for strong mineral acid environments. PRTLEY Ex e ENVIROGLNDS WITH NPT S (Refer to Sales Leaflet No. ) Because of the tapered thread nipple design, no gasket or locknut is required. "The Gland with the Band" Enviro Ex e IP CERTIFICTION PPROVED Ex t SUITBLE FOR USE IN ZONE,,, &. SUITBLE FOR USE WITH Ex e EQUIPMENT. SBS TEST REPORT /-9. I.. CERTIFICTE S/-9U. x EN -- EN :99 ( &) EN 9 IEC 9- IEC 9- IEC - IEC - CERTIFICTION II GD E Ex e II Sira TEX Ex e II Ex td IP IECEx SIR X s s THRED M 99 M 999 M M M M M M M M THRED M M M M M M M M,,,,,,,, 9,, GREEN M M,,,,,,,, 9,, NPT NPT ½ inch 9, ¾ inch inch,, PRTLEY Ex e ENVIROGLNDS FOR LED SHETH CBLE (Refer to Sales Leaflet No. ) Sizes - When ordering Enviroglands for lead sheath cable, please specify the actual measured lead cable bedding diameter. PRTLEY Ex e ENVIROGLNDS FOR BRIDED CBLE (Refer to Sales Leaflet No. ) Sizes - These Enviroglands incorporate a cone bush and cone ring specially designed for braided cable. THRED SMLL LRGE M, M, M 9, M, M 9, THRED M, M, M, M, M, M, JUN

6 Page PRTLEY CBLE GLNDS - FOR HZRDOUS RES PRTLEY Ex d/e ENVIRO COMPRESSION GLNDS For unarmoured cable (Refer to Sales Leaflet No. ) Dual certified Ex d & Ex e. Ultra tough corrosion resistant plastic encaptulated brass cable glands for use in highly corrosive environments. Fully certified to SBS EN/TEX & IEC Standards for use with Ex e & Ex d apparatus in Zone,,,, & areas. EPL Da & Gb. Features: Hazardous Ex locations Identification Band. Built in Safety Gauge. Completely sealed - IP. Corrosion resistant. Tough engineering plastic won t crack when tightened. Brass internal components. Supplied complete with brass locknut. Not suitable for strong mineral acid environments. See Green Enviroglands for this application. ccessories see Page. SFETY NOTE Sizes & supplied with two sets of seals. Sizes & are Ex e certified but not Ex d. PRTLEY Ex e/d ENVIRO COMPRESSION GLNDS - GREEN (Refer to Sales Leaflet No. ) vailable on request. Suitable for strong mineral acid environment. PRTLEY Ex d/e ENVIRO COMPRESSION GLNDS WITH NPT S (Refer to Sales Leaflet No. ) Dual certified Ex d & Ex e. Because of the tapered nipple design, no gasket or locknut is required. PRTLEY Ex d/e FLMEPROOF CBLE GLNDS For SW Cables (Refer to Sales Leaflet No. ) Dual certified Ex d & Ex e. They are designed for threaded hole applications. Supplied complete with Waterproofing Shrouds, Rubber Bushes, Sealing Gaskets and patented Built in Safety Gauges. Will maintain IP. Consult size selection chart. Special Ex d/e Flameproof glands for lead sheath cable also available on request. ccessories see Page. Ex d II/IIB Ex e I/II Ex t IP x Ex d I/IIC Ex e I/II EN -- EN :99 ( &) EN 9 IEC 9- IEC 9- IEC - IEC - CERTIFICTION II GD E Ex e II Sira TEX Ex e II Ex td IP IECEx SIR X CERTIFICTION PPROVED SUITBLE FOR USE IN ZONE,,, &. GROUPS II, IIB, & SURFCE & UNDERGROUND. I.. No. SBS MS/-9. I.. CERTIFICTE S/-9U. CERTIFICTION PPROVED SNS SNS 9- SNS 9- SNS 9- IP SNS 9 SUITBLE FOR USE IN ZONE,,, &. GROUPS I, II, IIB & IIC SURFCE & UNDERGROUND. SBS TEST REPORT No. /9/M9. I.. CERTIFICTE MS/-U. s * * Not Ex d s * * Not Ex d THRED M 9 M M M M M M M M M,,,,,9,,, 9,, NPT s ½ inch, THRED M M M M M M M M ½ inch ¾ inch inch GREEN M M 9,,,,,9,,, 9,,,,, THRED SMLL LRGE M 9, M, M, M M M M 9 9,, 9,, PRTLEY Ex d/e FLMEPROOF COMPRESSION CBLE GLNDS For Unarmoured Cables (Refer to Sales Leaflet No. ) Dual certified Ex d & Ex e. They are designed for threaded hole applications. Supplied complete with Sealing Gaskets and patented Built in Safety Gauges. Will maintain IP. Consult size selection chart. Special Ex d/e Flameproof glands for lead sheath cable also available on request. ccessories see Page. Ex d I/IIC Ex e I/II CERTIFICTION PPROVED SNS SNS 9- SNS 9- SNS 9- IP SNS 9 SUITBLE FOR USE IN ZONE,,, &. GROUPS I, II, IIB & IIC SURFCE & UNDERGROUND. SBS TEST REPORT No. /9/M9. I.. CERTIFICTE MS/-U. THRED SMLL LRGE M M M M M M M 9,,,,,,, JUN

7 Page PRTLEY CBLE GLNDS - FOR HZRDOUS RES PRTLEY Ex d/e HOSEBCK FLMEPROOF COMPRESSION CBLE GLNDS For Unarmoured Cables with Protected Hosing (Refer to Sales Leaflet No. ) Dual certified Ex d & Ex e. They are designed for threaded hole applications. Supplied complete with Nipple Gaskets to maintain IP. Consult size selection chart. Ex d I/IIC Ex e I/II CERTIFICTION PPROVED SNS SNS 9- SNS 9- SNS 9- IP SNS 9 SUITBLE FOR USE IN ZONE,,, &. GROUPS I, II, IIB & IIC SURFCE & UNDERGROUND. SBS TEST REPORT No. /9/M9. I.. CERTIFICTE MS/-U. THRED SMLL LRGE M M M M M M M,, 9,,,,, PRTLEY Ex d/e EZEE-SEL BRRIER GLNDS For rmoured Cables (Refer to Sales Leaflet No. ) Dual certified Ex d & Ex e. Pratley Barrier Glands are designed to provide a safe and easy to inspect barrier between the individual cores of the cable. The new technology barrier compound is ultra quick, very easy to use and cures in just two minutes. The barrier compound (supplied with glands) ensures proper adhesion to the cable conductors. Supplied complete with nipple gasket and shroud. Lock nuts are optional and can be ordered separately. PRTLEY Ex d/e EZEE-SEL BRRIER GLNDS NPT VERSION (Refer to Sales Leaflet No. ) PRTLEY Ex d/e EZEE-SEL BRRIER COMPRESSION GLNDS For Unarmoured Cables (Refer to Sales Leaflet No. ) Dual certified Ex d & Ex e. Pratley Barrier Glands are designed to provide a safe and easy to inspect barrier between the individual cores of the cable. The new technology barrier compound is ultra quick, very easy to use and cures in just two minutes. The barrier compound (supplied with glands) ensures proper adhesion to the cable conductors. Supplied complete with nipple gasket. Lock nuts are optional and can be ordered separately. PRTLEY Ex d/e EZEE-SEL BRRIER COMPRESSION GLNDS NPT VERSION (Refer to Sales Leaflet No. ) PTENTED NEW TECHNOLOGY- SUPER FST CURING COMPOUND! CERTIFICTION FOR EZEE-SEL BRRIER & EZEE-SEL BRRIER COMPRESSION GLNDS Ex d I/IIC Ex e I/II PPROVED Ex td IP SNS 9- SNS 9- SNS 9- SNS SNS 9 SUITBLE FOR USE IN ZONE,,, &. GROUPS I, II, IIB & IIC SURFCE & UNDERGROUND - DIRECT. SBS TEST REPORT No. /-. I.. CERTIFICTE MS/-U NEW TECHNOLOGY- SUPER FST CURING COMPOUND! STNDRD THRED M x. M x. M x. M x. M x. M x. M x. THRED STNDRD M x. M x. M x. M x. M x. M x. M x., 9,,,, 99, 99, THRED NPT NPT ½, NPT ½ 9, NPT ¾ 9, NPT ¾, NPT ", NPT " 9, NPT ¼", NPT ¼", NPT ½", NPT ½" 99, NPT " 99, NPT " 99, NPT ½" 9 99,,,, 9, 9,, 99, THRED NPT NPT ½, NPT ½, NPT ¾, NPT ¾, NPT ", NPT " 9 9, NPT ¼" 9, NPT ¼" 9, NPT ½" 9, NPT ½", NPT ", NPT " 99, NPT ½" 9 99, CCESSORIES - FOR PRTLEY GLNDS IN HZRDOUS RES PRTLEY Osxs COMPRESSION KIT For Size & s Ex e Brass Compression Glands for use with Instrumentation Cable (Refer to Sales Leaflet No. ) sxs kit reduces the capacity of s & gland to accomodate small diameter instrumentation cable. GLND CBLE BUSH Ø - mm 9, JUN

8 Page CCESSORIES - FOR PRTLEY GLNDS IN HZRDOUS RES SIBUS COMPRESSION BUSH For No. Ex e Brass Compression & Ex d/e Enviro Compression Glands for use with sibus Cable (Refer to Sales Leaflet No. & ) Osxs COMPRESSION KIT For Size s Enviro Compression Gland for use with Instrumentation Cable (Refer to Sales Leaflet No. ) sxs kit reduces the capacity of s gland to accomodate small diameter instrumentation cable. PRTLEY REPLCEMENT FLME-SEL BUSH KITS For Ex d/e Flameproof Glands for use with SW Cable (Refer to Sales Leaflet No. ) SNS -, -, the OSH ct and the MHS ct require periodic inspections of equipment installed in hazardous locations. These kits are designed as replacements for Ex d glands where inspection has revealed that the integrity of the existing bushes has been compromised. IMPORTNT SFETY NOTE! The correct bush kit must be selected and fitted - Failure to do so will lead to a dangerous installation! The number moulded on the replacement bushes must also be checked against the number moulded on the existing bushes to ensure the gland is not an obsolete design. PRTLEY REPLCEMENT FLME-SEL BUSH KITS For Ex d/e Flameproof Compression Glands for use with Unarmoured Cable (Refer to Sales Leaflet No. ) GLND BUSH 9, GLND CBLE BUSH Ø - mm 9, FLMEPROOF REPLCEMENT GLND BUSH KITS SMLL LRGE SMLL LRGE, 9, 9 9 9,,,, 9, 9, FLMEPROOF COMPR REPLCEMENT GLND BUSH KITS SMLL LRGE SMLL LRGE, 9, 9,,,, 9, PRTLEY CBLE ES - FOR USE IN NON HZRDOUS RES PRTLEY EZEE-FIT CBLE (STNDRD) (Refer to Sales Leaflet No. ) For SW cables and luminium Strip rmoured cables. lso Lead Sheath cable and circular Unarmoured cable when fitted with Conversion Kits. Supplied complete with Built in Cable Glands. (Included in the Price). When ordering specify Black or Transparent Polycarbonate (see through) lid. Shrouds must be ordered separately. See Page. Orange boxes are a special & can be supplied on request. See accessories Page, &. SBS S/- EZEE-FIT IP & IP Built in Gland CERTIFICTION IP / IP SNS 9 PPROVED (M Cont.) I.. Certificate No. S/-X M x. (Built in Glands) M x. (Built in CONFIGURTION BLCK TRNS- PRENT WITH SHROUD Two way through box,,9 Three way T box,, Four way right angle,, Three way P/E Y-Type 9 9,, Two way through box,, Three way T box 9,, Four way right angle,, Three way P/E Y-Type,, Glands) Four way P/E H-Type 9, Two way through box M x. Three way T box (Built Four way right angle in Glands) Three way P/E Y-Type 9 9, 9,,,,,,9,,,,9,,9 99,, Four way P/E H-Type M Two way through box x. Three way T box (Built in Four way right angle,, Glands) Three way P/E Y-Type 99,, M Two way through box 9,, x. (Built Three way T box,, in Glands) Four way right angle,, JUN

9 Page 9 PRTLEY CBLE ES - FOR NON HZRDOUS RES PRTLEY EZEE-FIT INSTRUMENTTION CBLE : (STNDRD) For Unarmoured Cables For use in terminating extra small (Xs) diameter instrumentation cables. ccomodates cables ranging from mm to mm diameter. Supplied complete with Xs compression cable glands. When ordering specify Black or Transparent lid. Kwikbloks and mounting rail for Kwikbloks must be ordered separately if required (See Kwikblok Price List). CONFIG. Two way through box Three way T box Four way right angle BLCK TRNS- PRENT CERTIFICTION, 9,, IP / IP SNS 9 PPROVED (M Cont.) I.. Certificate No. S/-X PRTLEY KLIK-LOK CBLE (STNDRD) For Unarmoured or rmouredcables (Refer to Sales Leaflet No. ) Patented Suitable for use with Pratley Glands. way right angle box with entries blanked off with removable Pratley Klik-Lok Blanking Plugs. There is an additional (th) closed entry in the base which can be drilled out. Boxes are supplied complete with gasket, cranked brass terminal rail, brass earthing harness, lid retaining strap, identification tag and cable tie. Pratley End Connectors may also be used instead of Pratley Kwikblok Connectors. When ordering specify Black or Transparent (Polycarbonate) see through lid. For accessories see Page. M M CONFIG. Right angle entries of which come fitted with blanking plugs. th closed entry in the base. BLCK TRNS- PRENT CERTIFICTION 9,, IP / IP SNS 9 PPROVED (M Cont.) I.. Certificate No. S/-(R) PRTLEY ECONO CBLE For rmoured Cables (Refer to Sales Leaflet No. ) The Pratley Econo-Boxes provides earth continuity between the threaded entries and can also accept glands for unarmoured cable. Blanking Plugs must be ordered separately (see Tufflon Blanking Plugs). When ordering specify Black or Transparent (Polycarbonate) see through lids. For accessories see Page. BLCK TRNS- PRENT CONFIG. M Right angle, M M threaded entries 9,, CERTIFICTION IP (M Cont.) PPROVED IP I.. Certificate No. S/- PRTLEY BOTTOM CBLE (STNDRD) For Unarmoured or rmoured Cables (Refer to Sales Leaflet No. 9) Box comes standard with x mm threaded entries. Supplied complete with spacers and cranked terminal rail. Pratley End Connectors may also be used instead of Kwikblok Connectors. When ordering specify Black or Transparent (Polycarbonate) see through lid. M CONFIG. x mm Entries BLCK TRNS- PRENT 9, CERTIFICTION IP (M Cont.) PPROVED IP I.. Certificate No. S/-9X PRTLEY LUMINIUM LLOY TUNNEL For use in tunnels (Refer to Sales Leaflet No. ) BS compliant. These boxes are specially designed and certified for use in tunnels where fire and smoke considerations are paramount. They are supplied with special silicone shrouds manufactured for high temperatures & LSF. See also Pratley End Connectors & Silicone Sleeves. Other box sizes also available on request. For accessories see Page &. For Tunnels CONFIG. WITH SHROUD M Three way, M Three way 9, SPECIL CERTIFICTION FOR FIRE SURVIVL OF ELECTRICL EQUIPMENT IP PPROVED BS TEST REPORT FPE//9 JUN

10 Page PRTLEY CBLE ES - FOR NON HZRDOUS RES PRTLEY LUMINIUM LLOY CBLE Epoxy Coated (Refer to Sales Leaflet No. ) These cable boxes are supplied with earth terminal, nickel plated Built in Cable Glands (for SW cable) and Inner Seals. When properly fitted they are watertight (IP). Entries should be protected by waterproofing shrouds. NB! For surface applications only - not to be buried underground. Reducing glands or conversion kits or both may be fitted to terminate smaller cables or circular unarmoured cable. Epoxy coated electrical orange. Waterproofing shrouds must be ordered separately (See Page ). For accessories see Page. CERTIFICTION LUMINIUM LLOY & INSTRUMENTTION ES DIP IP PPROVED SNS -- SNS 9 SUITBLE FOR USE IN ZONE, & SBS TEST REPORT No. I/G9 I No. S/-X CONFIGURTION CT WITH SHROUD Two way through box,9,99 M Three way right angle 9,, Four way right angle,, Two way through box 9,, Three way right angle, 9,9 M Four way right angle,, Three way P/E Y-Type 9, 9,9 Four way P/E H-Type 9,, Two way through box,, M Three way right angle,, Four way right angle 9,, PRTLEY LUMINIUM LLOY INSTRUMENTTION CBLE Epoxy Coated (Refer to Sales Leaflet No. ) For use in terminating extra small (Xs) diameter unarmoured instrumentation cable. Supplied complete with Built In Cable Glands for mm to mm unarmoured cable. Kwikbloks and mounting rail (Code ) for Kwikbloks must be ordered separately if required (see Kwikblok Price List). PRTLEY LUMINIUM LLOY CONDUIT CBLE Epoxy Coated (Refer to Sales Leaflet No. ) Box accepts mm conduit directly. Shrouds are not required. CONFIGURTION Two way through box M Three way right angle Four way right angle CONFIGURTION Two way through box M Three way right angle Four way right angle CT ORNGE COLOUR CT ORNGE COLOUR 9,,,,9,,9 PRTLEY LUMINIUM LLOY FOUNDTION ES For Service Connections Epoxy Coated (Refer to Sales Leaflet No. ) Supplied complete with Built in Gland & Shroud, which are included in the price. Conduit can be fitted to the back entry of Foundation Boxes by means of a Locknut. Boxes No s and have external earth connections. The Pratley Newcastle Box is a single entry box for SW cable with a mm hole in the back. The Pratley phase Foundation Box is a Newcastle Box fitted with a Ex e gland (not illustrated). No. No. No. Two Way ( Entries blanked off) Newcastle No. No. No. x Way Newcastle Box * Phase CT , 9,,,, PRTLEY LUMINIUM LLOY BOILER ELEMENT Epoxy Coated (Refer to Sales Leaflet No. ) mm Ø hole and mm Ø retained slotted metal washer at the back of this box allows easy fitting of a boiler or geyser element. No. (Element not included No. CT 9, JUN

11 Page PRTLEY CBLE ES - FOR NON HZRDOUS RES PRTLEY LUMINIUM LLOY CBLE TO CONDUIT DPTOR (Epoxy Coated) (Refer to Sales Leaflet No. ) This way box accepts cable into one glanded entry and mm conduit in the other threaded entry. It can also be used as a top entry foundation box. Supplied complete with Built In gland and shroud. PRTLEY LUMINIUM LLOY ROOF CONNECTOR For Overhead Service Connections (Refer to Sales Leaflet No. ) mp. Volt Single Phase. Supplied complete with Terminal Connectors and Insulating Sleeves for installation on corrugated or box section roof of galvanised iron or fibre cement. PRTLEY LUMINIUM LLOY SOLR ROOF CONNECTOR For Solar Panel Connections (Refer to Sales Leaflet No. ) Supplied complete with Terminal Connectors and Insulating Sleeves for installation on corrugated or box section roof of galvanised iron or fibre cement. No. No. No. CT 9 9, CT 9, CT 9 9, PRTLEY LUMINIUM LLOY INDUSTRIL LIGHT FITTINGS For use with mm x core SW cable. (Refer to Sales Leaflet No. ) Fitted with E.S. Lampholders. Will also accomodate: mm x core, mm x core and. mm x core SW cables. Pratley will gladly supply and fit these to cable per our customers specifications. Price subject to quote The. mm cable requires a size R shroud. PRTLEY LUMINIUM LLOY INDUSTRIL MP & MP SOCKET FITTINGS (Refer to Sales Leaflet No. ) Fitted with pin socket to accept plug-in fluorescent lamp units and standard amp & amp plugs. Use same shrouds as above. PRODUCT CT I.L. Fitting, I.L.F. Shroud 9, R Shroud, PRODUCT mp Socket mp Socket CT,, PRTLEY CBLE ES - FOR HZRDOUS RES PRTLEY Ex e/n EZEE-FIT CBLE (Refer to Sales Leaflet No. ) For SW cables and luminium Strip rmoured cables. lso Lead Sheath cable and circular Unarmoured cable when fitted with Conversion Kits. Supplied complete with Built in Cable Glands. (Included in the Price). When ordering specify Black or Transparent Polycarbonate (see through) lid. Shrouds must be ordered separately. See Page. Orange boxes are a special & can be supplied on request. For Ex n - Pratley non sparking end connectors can be used. For accessories see Page,& CERTIFICTION Ex e II T Ex n II T DIP Ta= C IP (m-cont.) IP CERTIFICTION PPROVED SNS 9- SNS 9- SNS 9- SNS 9- SNS 9 SUITBLE FOR USE IN ZONE,,, & I.. No. SBS S/-X x II GD Ex e II T Ex td T IECEx SIR.X Sira TEXX x II GD EExn II IP Sira TEX IEC 9- IEC 9- IEC - IEC - EN & EN 9 EN -- EN 9- EN 9- EN - EN - M x. (Built in Glands M x. (Built in Glands M x. (Built in Glands M x. (Built in Glands M x. (Built in Glands CONFIGURTION Two way through box,,9 Three way T box 9,, Four way right angle, 9, Three way P/E Y-Type 9 9,, Two way through box,, Three way T box,, Four way right angle,, Three way P/E Y-Type,, Four way P/E H-Type Two way through box Three way T box 9 Four way right angle Three way P/E Y-Type Four way P/E H-Type Two way through box Three way T box Four way right angle Three way P/E Y-Type Two way through box Three way T box Four way right angle BLCK TRNS- PRENT 9,, 9, 9, 9, 9,, WITH SHROUD, 9,,,9,,9 9,9,,, 9,,,,,,., 9, JUN

12 Page PRTLEY CBLE ES - FOR HZRDOUS RES PRTLEY EZEE-FIT Ex e/n No. INSTRUMENTTION CBLE For Unarmoured Cables For use in terminating extra small (Xs) diameter instrumentation cables. ccomodates cables ranging from mm to mm diameter. Supplied complete with Xs compression cable glands. When ordering specify Black or Transparent lid. Kwikbloks and mounting rail for Kwikbloks must be ordered separately. M x. CONFIGURTION BLCK Two way through box 9 Three way T box Four way right angle Ex e II T Ex n II T DIP T= C IP (m-cont.) TRNS- PRENT CERTIFICTION PPROVED SUITBLE FOR USE IN ZONE,,, &. I.. No. /-,,, SNS 9- SNS 9- SNS 9- SNS 9- SNS 9 PRTLEY Ex e/n KLIK-LOK CBLE For Unarmoured or rmoured Cables (Refer to Sales Leaflet No. ) We recomend only Pratley Glands be used. way right angle box with entries blanked off with removable Pratley Klik-Lok Blanking Plugs. n additional (th) closed entry in the base can be drilled out if fitted with an Ex e gland. Boxes are supplied complete with a gasket, cranked brass terminal rail, brass earthing harness, lid retaining strap, identification tag and cable tie. Box must be fitted with Pratley Ex e Kwikbloks for Ex e applications. Pratley Non-sparking End Connectors may be used for Ex n applications. When ordering specify Black or Transparent (Polycarbonate) see through lid. For accessories see Page. PRTLEY Ex e/n ENVIRO CBLE For Unarmoured or rmoured Cables (Refer to Sales Leaflet No. ) Ex e and Ex n duel certified. EPL Gb & Da. ccomodate Enviroglands. Tough Engineering plastic - no corrosion. Slotted mounting lugs ( s/s mounting screw kit see pg ) for easy installation. Encapsulated internal earth - continuity between entries. x Threaded Entries & supplied with Blanking Plugs and red Ex Id band on each entry. PRTLEY Ex e/n BOTTOM CBLE For Unarmoured or rmoured Cables (Refer to Sales Leaflet No. 9) Box comes standard with x mm threaded entries. Supplied complete with spacers and cranked terminal rail. Box must be fitted with Pratley Ex e Kwikbloks for Ex e applications. Pratley Non-sparking End Connectors may be used for Ex n applications. When ordering specify Black or Transparent (Polycarbonate) see through lid. Patented M M CERTIFICTION x II GD Ex e II T Ex td IP/ (m)t C Sira TEXX IECEx SIR.9X CONFIGURTION Right angle entries of which come fitted with blanking plugs. th closed entry in the base. Ex e II T Ex n II T DIP Ta= C IP (m-cont.) BLCK TRNS- PRENT CERTIFICTION PPROVED, 9, SNS 9- SNS 9- SNS 9- SNS 9- SNS 9 SUITBLE FOR USE IN ZONE,,, & I.. Certificate No. S/-(R) CONFIGURTION BLCK M Right angle entries M Ex e/n Ex t T IP (m-cont.) CERTIFICTION PPROVED TRNS- PRENT, SNS 9- SNS 9- SNS 9- SNS 9- SNS 9 SUITBLE FOR USE IN ZONE,,, & I.. Certificate No. S/-X & S-9X CONFIGURTION x mm Entries Ex e II T Ex n II T DIP T= C IP (m-cont.) BLCK CERTIFICTION PPROVED TRNS- PRENT 9, SNS 9- SNS 9- SNS 9- SNS SNS 9 SUITBLE FOR USE IN ZONE,,, & I.. Certificate No. S-9X PRTLEY Ex d FLMEPROOF CBLE ES (Refer to Sales Leaflet No. ) These boxes have a lid gasket and are therefore also waterproof (IP).. Cable boxes are stocked in -, - and -way with precision threaded entries to accomodate Pratley Ex d/e Flameproof or Pratley Ex d/e Flameproof Compression Cable Glands. Size not certified for Group IIC. For accessories see Page. Ex d DIP T T IP CERTIFICTION PPROVED SNS 9- SNS 9- SNS 9 SNS GROUPS I, II, IIB. & FOR IIC LSO. SUITBLE FOR USE IN ZONE,,,, &. SURFCE & UNDERGROUND - TEMP CLSS T SBS TEST REPORT /9/M9. I.. No. MS/-. M M M EMPTY VOLUME ml 9 NO. OF WYS CT 9,,, 9, 99,, 99,,, JUN

13 Page PRTLEY CBLE ES - FOR HZRDOUS RES PRTLEY Ex d FLMEPROOF COMBINED CONDUIT/ STOPPER (Refer to Sales Leaflet No. ) Combined Conduit/Stopper Boxes are manufactured in a -way only, Ex d plugs being fitted to unwanted entries. Stopper Box Lid is tapped and fitted with a plugs for filling with compound, which must be done. When the Box is mounted with the lid vertical, a special filler tube is required. This tube can be removed when the compound has set. Filler hole plug requires mm llen Key. Ex d DIP T T IP CERTIFICTION PPROVED SNS 9- SNS 9- SNS 9 SNS GROUPS I, II, IIB. & FOR IIC LSO. SUITBLE FOR USE IN ZONE,,,, &. SURFCE & UNDERGROUND - TEMP CLSS T SBS TEST REPORT /9/M9. I.. CERTIFICTE MS/M9. I.. No. MS/-. M M EMPTY VOLUME ml 9 NO. OF WYS CT 9, 9,,,9 9,9, FILLER TUBE FOR BOVE CT., PRTLEY Ex e/n LUMINIUM LLOY CBLE Epoxy Coated (Refer to Sales Leaflet No. ) Supplied with earth terminal, nickel plated built-in Cable Glands (for SW cable) and Inner Seals. When properly fitted they are watertight (IP). Entries should be protected by waterproofing shrouds. Epoxy coated black. To convert to a way or way box simply remove the gland parts & fit a tufflon blanking plug (See Page ). Shrouds should be ordered separately (See Page ). For accessories see Page. M M M CONFIGURTION Four way right angle Four way right angle Four way right angle CERTIFICTION LUMINIUM LLOY Ex e II T Ex n II T DIP Da Ta=T IP (m-cont) CT 9 PPROVED,, 9, WITH SHROUD 9,,,9 SNS 9- SNS 9- SNS 9- SNS SNS 9 SUITBLE FOR USE IN ZONE,,,& SBS TEST REPORT No. //G9 I No. S-X CCESSORIES - FOR PRTLEY CBLE ES Ex for Hazardous reas Equipment for Non Hazardous reas Equipment PRTLEY N RIL FOR EZEE-FIT & LUMINIUM ES For Fitting Kwikbloks PRTLEY EZEE-FIT Ex e/n S Black or Transparent (Polycarbonate) (Refer to Sales Leaflet No. ) Polycarbonate lids are clear and extremely robust. Lids supplied, ready to fit, complete with captive stainless steel cheese head screws and replaceable gasket and engraved certification. PRTLEY EZEE-FIT STNDRD S Black or Transparent (Refer to Sales Leaflet No. ) Orange standard lids are a special & can be supplied on request. PRTLEY EZEE-FIT REPLCEMENT GSKETS For Box Lids (Refer to Sales Leaflet No. ) The gaskets ensure a waterproof IP seal and are very easy to fit PRTLEY EZEE-FIT REPLCEMENT SCREWS For Box Lids (Refer to Sales Leaflet No. ) Stainless Steel screws complete with washers can be bought separately. Supplied in a pack of screws and washers. N Rail Black Polycarbonate Stainless Steel Ex EZEE-FIT LUMINIUM LLOY /RIL /RIL BLCK TRNSPRENT (POLYCRBONTE) 9, 9,,,9, BLCK TRNSPRENT (POLYCRBONTE),,,, 9 9,9 N/ & x mm x mm & x mm N/ x mm x mm x mm & x mm,,,9 9, GSKET 9, 9, 99, SCREW, & M 9, & M 9, JUN

14 Page CCESSORIES - FOR PRTLEY CBLE ES Ex for Hazardous reas Equipment for Non Hazardous reas Equipment PRTLEY EZEE-FIT LOCK-OUT DEVICE (Refer to Sales Leaflet No. ) To prevent unauthorised removal of the Ezee- Fit box lids (Lock not supplied). No. - Box-M, No. & Box-M 9 9, PRTLEY EZEE-FIT BLNKING PLUGS (Refer to Sales Leaflet No. ) Plugs maintain the IP/ and Ex e rating. Supplied complete with sealing gasket. NOTE: Due to the mm thread pitch, size brass and tufflon blanking plugs cannot be used with a size locknut (Flameproof blanking plugs can be used with a size ( mm) locknut). BRSS THRED TUFFLON mm 9,, mm,, mm,, mm,, mm 9,, PRTLEY EZEE-FIT GLND PRTS KITS For SW Cable (Refer to Sales Leaflet No. ) Ezee-Fit Box Built in glands are supplied with the box. However, the parts can also be supplied separately if required. Inner Seal Bush Cone Bush Cone Ring Cone Nut,,,,, PRTLEY EZEE-FIT CONDUIT REDUCERS (Refer to Sales Leaflet No. ) Ezee-Fit Cable Box entries accept conduit directly as follows: - mm, - mm & - mm. Reducers allow the fitting of different sizes of conduit. lso, to enable the fitting of conduit to the box. When conduit is fitted to Ezee-Fit boxes in hazardous areas, it is necessary to seal the entry. This can be done by using Pratley Putty (See dhesives Catalogue). to mm to mm to mm to mm to mm to mm to mm to mm to mm to mm,9, 9,,,,,, 9,, PRTLEY Ex e/d NPT TIL DPTORS FOR EZEE-FIT (Refer to Sales Leaflet No. ) These nickel plated adaptors enable ½ & ¾ NPT Female threaded accessories to be directly connected to any Pratley Ex e Ezee-Fit junction box. They will maintain the Ex e/n and IP ratings respectively. Fits into Ezee-Fit Box Ex THRED ½ NPT, ¾ NPT 9, ½ NPT 9, ¾ NPT, ½ NPT, ¾ NPT, PRTLEY Ex e/n EZEE-FIT REDUCING GLNDS & SHROUDS (Refer to Sales Leaflet No. ) Nickel plated Reducing Glands replace the Ezee-Fit box Gland Parts to enable a smaller SW cable to be fitted. Reducing Shrouds cover the Reducing Gland completely. compresssion conversion kit may also be fitted into a Reducing Gland if small unarmoured cable is to be terminated. PRTLEY Ex e/n EZEE-FIT COMPRESSION CONVERSION KITS (Refer to Sales Leaflet No. ) Compression Conv. Kits enable unarmoured cable to be fitted to Ezee-Fit Cable Boxes. The Kits replace the Inner Seal, Cone Bush and Compression Ring of the Standard Box Built-in Gland or Reducing Gland. Kit Os = washers & bush Kit OL = washer & bush Kit,, & = washer & bushes Kit = washer & bushes Kit R = washers & bushes Reducing Shroud TO FIT INTO ,, 9, 9,, 9,,,,, KIT R* SHROUD R R RS R RS R CT,,,,,, SMLL LRGE,,,,,, R* (Reducing kit) is for size Ezee-Fit Box but reduces the entry to take smaller (size ) Cables. JUN

15 Page CCESSORIES - FOR PRTLEY CBLE ES Ex for Hazardous reas Equipment for Non Hazardous reas Equipment PRTLEY Ex e/n EZEE-FIT COMPRESSION CONVERSION KIT xs For Instrumentation Cable for the box (Refer to Sales Leaflet No. ) O KIT Oxs CBLE Ø - mm, PRTLEY Ex e/n EZEE-FIT COMPRESSION CONVERSION KIT Rxs For Instrumentation Cable for the box (Refer to Sales Leaflet No. ) Compression Conv. Kits enable small diameter unarmoured cable to be fitted to Ezee-Fit Cable Boxes. The Kits replace the Inner Seal, Cone Bush and Compression Ring of the Standard Box Built-in Gland or Reducing Gland. For Box For Box KIT Rxs CBLE Ø - mm, PRTLEY KLIK-LOK Ex e/n S Black or Transparent (Refer to Sales Leaflet No. ) Polycarbonate lids are clear and extremely robust. ll lids are supplied complete with replaceable gasket and engraved certification. Transparent Ex BLCK TRNSPRENT (POLYCRBONTE),, PRTLEY KLIK-LOK STNDRD S Black or Transparent (Refer to Sales Leaflet No. ) When ordering specify Black or Transparent (Polycarbonate) see through lids PRTLEY KLIK-LOK REPLCEMENT GSKET (Refer to Sales Leaflet No. ) Black BLCK TRNSPRENT (POLYCRBONTE) 9 9, , 9,, PRTLEY KLIK-LOK IDENTIFICTION TG (Refer to Sales Leaflet No. ) PRTLEY KLIK-LOK CRNKED TERMINL RIL (Brass) (Refer to Sales Leaflet No. ) Specially designed raised cranked terminal rail allows easy fitting of wires into connectors (rail can also be inverted). Rail for Box Rail for Box,, 9,, PRTLEY KLIK-LOK BLNKING PLUG (Refer to Sales Leaflet No. ) Specially designed Blanking Plug with removable retaining clip which locks the plug into a secured position (only to be used in the Klik-Lok Box). Retaining Clip O-ring No. Box with mm entry 9, No. Box with mm entry 9,9 PRTLEY KLIK-LOK REDUCING LOCKNUTS FOR NO. (Refer to Sales Leaflet No. ) Can be used to adapt a mm entry to a M or M threaded entry. The Ex e/n and IP raiting will be maintained. THRED mm - mm 9 9, mm - mm 9 9, PRTLEY ECONO S (Refer to Sales Leaflet No. ) When ordering specify Black or Transparent (Polycarbonate) see through lids BLCK TRNSPRENT (POLYCRBONTE), 9,, JUN

16 Page CCESSORIES - FOR PRTLEY CBLE ES Ex for Hazardous reas Equipment for Non Hazardous reas Equipment PRTLEY TUFFLON BLNKING PLUGS Can be used in Econo & luminium lloy Boxes (Refer to Sales Leaflet No. ) Blanking Plugs must be ordered separately for Econo Boxes. THRED - mm mm,, PRTLEY TUNNEL SILICONE SHROUDS (RED) & SLEEVES (RED) (Refer to Sales Leaflet No. ) For use primarly with the Pratley Tunnel Box (see pg. 9) in extremely high temperatures and are fire resistant. They are LSZH (Low Smoke Zero Halogen). They have the same dimensions as standard shrouds. LSZH & Fire Resistant SHROUD CT,,9 9,9,, SLEEVE /D /S CT,,9 PRTLEY LUMINIUM LLOY REPLCEMENT GSKETS (Refer to Sales Leaflet No. ),, 9, PRTLEY LUMINIUM LLOY MOUNTING S (Refer to Sales Leaflet No. ) These lids for boxes have a square cut out to permit easy mounting of meters, controls, gauges, lights, switches and the like. flat plate can also be mounted and drilled to suit various other sizes of apparatus. mm Square, For Box PRTLEY LUMINIUM LLOY CONDUIT REDUCERS (Refer to Sales Leaflet No. ) For use with Pratley luminium lloy Cable Boxes to reduce the entry size to receive Conduit. Conduit daptors are supplied complete with Waterproofing Gaskets and are fitted into the box entry after the original gland parts have been removed. Waterproofing shrouds are not required. mm, mm & mm conduit will fit directly into the s, & box entries respectively. TO CONDUIT mm mm mm 9,, 9, PRTLEY LUMINIUM LLOY BLNKING PLUGS (Refer to Sales Leaflet No. ) For use with Pratley luminium lloy Cable Boxes. Blanking Plugs are supplied complete with Waterproofing Gaskets - IP. To bring an entry into operation again, remove the Plug and fit the gland parts or Reducing Gland or Conversion Kit as appropriate. NICKEL THRED PLTED BRSS TUFFLON mm 9,, mm,, mm,, PRTLEY LUMINIUM LLOY GLND PRTS KIT (Refer to Sales Leaflet No. ) Nickel Plated Brass Built in Glands are supplied with the Box. These Gland Parts can however also be supplied separately if required,,, PRTLEY LUMINIUM LLOY REDUCING GLNDS & SHROUDS (Refer to Sales Leaflet No. ) Reducing Glands are supplied complete with Waterproofing Gaskets (IP) and are fitted into the Box entry after the original gland parts have been removed. Shrouds must be ordered separately. GLND to to to 9,,, SHROUD R, R, JUN

17 Page CCESSORIES - FOR PRTLEY CBLE ES PRTLEY LUMINIUM LLOY COMPRESSION CONVERSION KITS (Refer to Sales Leaflet No. ) These kits replace the Cone Bush and Inner Seal in Box entries so that they may be used to terminate any unarmoured cable. ll s kit sizes have - bush, retaining washer and tapered washer. ll L kits have no retaining washer. PRTLEY LUMINIUM LLOY xs COMPRESSION CONVERSION KIT - For Instrumentation Cable (Refer to Sales Leaflet No. ) xs kit reduces the capacity of box to accommodate small diameter unarmoured instrumentation cable. PRTLEY ENVIRO STINLESS STEEL MOUNTING SCREW KIT Kit ( x M Cheese head screws mm long with x M washers & x M nuts) for mounting Envirobox with slotted mounting lugs. For Box Ex for Hazardous reas Equipment for Non Hazardous reas Equipment s L s L s L CBLE Ø - mm KIT,,,,,,, x CH Screws mm Long x M Washers, x M Nuts PRTLEY N RIL FOR FLMEPROOF ES For Fitting Kwikbloks (Refer to Sales Leaflet No. ) special N slotted rail and hold-down bracket for fitting Kwikbloks to box. REPLCEMENT SCREWS FOR FLMEPROOF COVERS (Refer to Sales Leaflet No. ) llen Head screws for Flameproof Box covers ( screws per pack). Zinc Plated Ex Ex RIL mm x mm mm x mm LLEN KEY M x, M x,,,,,99 FLMEPROOF MOUNTING BRCKET KIT (Refer to Sales Leaflet No. ) The no. mounting bracket kit consist of a bracket and two M x 9. mm counter-sunk flat head stainless steel screws. PRTLEY Ex d/e FLMEPROOF PLUGS (NICKEL PLTED BRSS) (Refer to Sales Leaflet No. ) Supplied complete with Waterproofing Gasket. Nickel plated brass plugs with hex socket head. For Box Ex Ex HEX THRED SOCKET mm mm mm mm mm mm mm ½ NPT 9, mm mm mm mm mm mm,,,9, 9,,, PRTLEY Ex d/e FLMEPROOF REDUCERS (Refer to Sales Leaflet No. ) To fit a smaller Gland to a larger entry. Supplied complete with Waterproofing Gasket F signifies a Female thread. M signifies a Male thread. ll figures represent mm sizes unless otherwise stated. M F Ex MLE TO FEMLE M - F M - F M - F M - F M - F M - F M - F 9,,,,,,, MLE TO FEMLE M - F M - F M - F M - F M - F M - F M - F M - F M - F M - F 9,, 9,,,,,, 9,, FOR DETILED LIST OF REDUCERS & DPTORS SEE SHEET TTCHED TO THIS LIST JUN

18 Page CCESSORIES - FOR PRTLEY CBLE ES Ex for Hazardous reas Equipment for Non Hazardous reas Equipment PRTLEY Ex d/e FLMEPROOF DPTORS Metric To fit a larger gland or conduit to smaller entries. Supplied complete with Waterproofing Gasket PRTLEY Ex d/e FLMEPROOF THRED DPTORS Imperial, NPT & Pg To fit metric glands or conduit to apparatus with different threads. Maintains IP rating of enclosure. Tapered NPT adaptors and reducers do not require and are not supplied with gaskets. HUGE SELECTION! SEE M M FEMLE TO IMPERIL MLE F - ¾ M F - M F - ½ M F - M F - ½ M M - ¾ F M - F M - ½ F M - F M - ½ F F daptor Type daptor Type B DESIGN STYLE CT 9, 9, 99 9,,, 9 9, 9, 99,,, MLE TO FEMLE METRIC M - F M - F M - F M - F M - F M - F M - F M - F M - F MLE TO FEMLE NPT M - ¼ N.P.T. F M - ½ N.P.T. F ½ N.P.T. - mmf ¾ N.P.T. - mmf ¾ N.P.T. - mmf N.P.T. - mmf N.P.T. - mmf ¼ N.P.T. - mmf ¼ N.P.T. - mmf MLE PG TO FEMLE Pg M - F Pg,M - F Pg,M - F Pg M - F Pg M - F Pg M - F Pg M - F Pg M - F Pg 9M - F DESIGN STYLE CT DESIGN CT STYLE B 999 B B B B B DESIGN STYLE B B B 9 CT ,,,,,9,,, 9,,,,, 9,,,,,,, 9,, 9,,,,, FOR DETILED LIST OF REDUCERS & DPTORS SEE SHEET TTCHED TO THIS LIST F PRTLEY END CONNECTORS & INSULTING SLEEVES (Refer to Sales Leaflet No. ) PRTLEY NON-SPRKING END CONNECTORS & INSULTING SLEEVES (Refer to Sales Leaflet No. ) Comply with SNS --, SNS 9- & SNS 9-. Non-sparking Connectors may be used with Pratley Ex d and Ex n Cable Boxes. PRTLEY STNDRD & Ex e KWIKBLOKS for Standard and Ex e Cable Boxes IK END CONNECTORS,,,,,9 NON-SPRKING END CONNECTORS DINKY SMLL MEDIUM LRGE EXTR L,,,,9, /D /S /M /L /XL /D /S /M /L /XL INSULTING SLEEVES (BLCK) INSULTING SLEEVES (BLCK) FOR DETILED LIST OF KWIKBLOKS & S SEE KWIKBLOK LIST,9,,,,,9,,,, PRTLEY TOUGH PLSTIC GSKETS (BLCK) Tough plastic gaskets incorporate a special face feather for perfect sealing. Special green gaskets available for strongly acidic environments CT mm 9 mm mm mm mm mm mm mm ,,,,,,,, CT Pg, 9, Pg 9, Pg 9, Pg 9 9, Pg 9,9 Pg 9, Pg 9, JUN

19 Page 9 PRTLEY LOCKNUTS (NICKEL PLTED STEEL ) Sizes,,, & Castellated Locknuts. Steel Locknuts should not be used with single core cable due to heating effects. For nickel plated Brass Locknuts see page PRTLEY CBLE RETINERS (Refer to Sales Leaflet No. ) Pratley Cable Retainers anchor cable (or piping) onto angle iron (see picture). Each retainer has possible fitting positions depending upon the cable size. The narrow retainer is for use with a cable tie (not supplied). The broad retainer is for use with a steel strap (not supplied). PRTLEY STIK N CLIP INDUSTRIL (Refer to Sales Leaflet No. ) Simply stick the clips onto a surface and then clip in household cables, cords and wires. lso extremely useful for mounting pens, pencils and tools in handy places ( clips per pack). mm mm mm ELECTRICL TPE,,, PRTLEY PVC ELECTRICL & ERTH MRKING TPE (. mm x 9 mm x m) (Refer to Sales Leaflet No. ) This is a very high quality elastic tape. Packed in useful re-usable containers. Locknut Castellated Locknut "Sizes,,, & " Nickel Plated Steel MISCELLNEOUS CCESSORIES THRED M M M M Small Large CBLE Ø CT - mm ( mm angle iron) - mm ( mm angle iron) CBLE RETINER - BROD Use with Steel Strap,,,, CBLE Ø CT 9,, - mm Small ( mm angle iron), - mm Large ( mm angle iron), PRTLEY SFETY CLENER Cleans switch and relay contacts, commutators, rheostat wipers and precision mechanical parts. Leaves no residue or film. Caution: Product can blemish or destroy some plastics (eg. styrene housings). Test on unimportant surface first. Dispenser of x g erosol Cans Cat 9 Refer to Pratley dhesives Price LIst for Prices and Discounts. PVC ELECTRICL ERTH MRKING TPE Dispenser of Rolls COLOUR Yellow & 9, Green THRED M M M,,9, PVC ELECTRICL TPE Dispenser of Rolls COLOUR Black, Red, Blue, White, Yellow, Green, PRTLEY PVC FIRE RETRDNT TPE (.9 mm x mm x m) (Refer to Sales Leaflet No. ) PRTLEY RUBBER TPE (. mm x mm x. m) (Refer to Sales Leaflet No. ) tough, insulating and self-amalgamating tape. Ideal for insulating busbars, transformer bushing/ cable tail connections, cable sheath cuts and cable ends. Typical electric strength./kv/mm. Packed in strong useful re-usable containers. PRTLEY HIGH-TENSION SPLICING TPE (. mm x 9 mm x m) (Refer to Sales Leaflet No. ) high quality self-fusing tape with excellent electrical properties. For use in the splicing of cable terminations and for corona resistant insulation. Breakdown voltage is kv per. mm. Packed in useful re-usable containers. PVC FLME RETRDENT TPE Dispenser of Rolls PVC FLME RETRDENT TPE Dispenser of Rolls COLOUR COLOUR Black, White, Red, Yellow, Blue, Green, RUBBER TPE Dispenser of Rolls. mm mm x.m 9, HIGH TENSION SPLICING TPE Dispenser of Rolls. mm 9 mm x m, JUN

20 FITTED SYSTEMS - FCTORY FITTED TO CUSTOMER SPECIFICTIONS Page TYPICL FCTORY FITTED SYSTEMS You specify, we then factory fit and terminate the correct length of cable and factory test. You install the prefabricated quality certified system. No more poor workmanship taking place in muddy trenches. Reduced labour complement on site. Easier and more accurate tendering. ZED (Refer to Sales Leaflet No. ) P P R O V E D IP low cost general utility box with entries. Fitted with a raised dome lid. Note: Blanking Plugs must be ordered separately (see Tufflon Blanking Plugs). ZED - CCESSORIES (Refer to Sales Leaflet No. ) ZED S (BLCK) (Refer to Sales Leaflet No. ) Complete with M Pan Head Screw with stainless steel washer. TUFFLON BLNKING PLUGS (BLCK) (Refer to Sales Leaflet No. ) Must be ordered separately. EXMPLE Ezee-fit Box fitted FROM STND EXMPLE - reducing gland fitted mm - core cable From TRF. or dist. box Integral gland RNGE Foundation box fitted Integral gland fitted mm -core Cable factory prepared to correct length Foundation box Integral gland fitted mm - core cable factory prepared to correct length o N Ezee-fit box fitted EXMPLE Rail mounted terminals inside mm - core cable From TRF. or dist. box Industrial Light Fitting Box Designed for use with mm x core SW cable THE LOW OPTION! No. No. No. ZED (BLCK) THRED mm mm mm - mm mm BLCK CT. ZED S (BLCK) TUFFLON BLNKING PLUGS (BLCK) No. No. No. EXMPLE THRED BLCK CT. CT. Unarmoured cable to reducing gland and shroud Ezee-fit Y box Fitted with E.S. Lampholder (Light bulb not included) Can be factory fitted to customers specification.,,,,, 9,,, ZED GLNDS P P R O V E D (Refer to Sales Leaflet No. ) SNS low cost range of nickel plated brass glands for SW cable, supplied complete with nickle plated steel locknuts. ZED GLND - CCESSORIES (Refer to Sales Leaflet No. ) ZED SHROUDS (Refer to Sales Leaflet No. ) Must be ordered separately. ZED GLNDS THRED M M M M M M M M M CT.,,, 9,,, 99,, 9 9, ZED SHROUDS CT.,,,99,,,9,,, By placing an order the customer agrees to the following TERMS ND CONDITIONS PYMENT: Payments strictly within the calendar month following the month of purchase. RISK ND OWNERSHIP: Risk passes on delivery but ownership rests with Pratley until the goods have been paid for in full. RETURNS: We cannot accept goods returned without our prior consent and provided that such goods are as new and in current production. handling and inspection charge of % minimum will be raised on the invoice price at our discretion. S: Prices are subject to change without notice. There is a nominal delivery charge of R, (excluding VT) per invoice for all deliveries within the RS. ir freight at customer's request, will be for customer's account. STOCKS: Items listed in this Price List are normally available ex stock. Non stock items must be specially ordered to weeks in advance of required date. CTLOGUE NUMBERS: The catalogue numbers quoted in this Price List are computer code numbers and may be used for ordering without requiring any further details. DESPTCHES: We try to ensure that orders received by noon are despatched the following morning. Road transport collects from us each day and delivers to addressees within the following - days. Our Despatch Department is open from : to : and : to : Mondays to Thursdays and on Fridays from : to :. It is closed on all Public Holidays. JUN

21 Page djustable Glands, Enviroglands, Ex e and Ex e Ultra Glands, Ezee-Fit & lum. lloy Boxes Cable Sizes, mm², mm² mm² mm² mm² mm² mm² mm² mm² mm² 9 mm² mm² mm² mm² GLNDS ND ES FOR SW/PVC CBLES Number of cores, & 9 & & * & 9 *, & 9* * &, & * & & * * & & * & * * * * & & & mm² mm² * Check Bedding Larger Diameter on all cables Gland or Box Size & S or or or or or or or or or or or or or or 9 Max. bedding dia. mm,,,,,,,, /,,,,, /,,, /,,,,, /,,, /,,,, /,,,, /,, /,,,, /,,,, /,,, /,,, /,,,,, /,,,,,,,,, /,,,, 9, *NOTE: The specification for PVC cables (SNS ) does not specify maximum dimensions. This Chart is based on expected maximum dimensions over bedding supplied by cable manufacturers. No guarantee can be given that the selected gland will fit the specified cable. If in doubt, measure the cable bedding diameter and check it against the gland nipple bore in Table "C" below. In Particular, cable sizes marked with an asterisk should always be checked. C B Dimensions of Pratley djustable Glands in mm unless otherwise stated (No. is non adjustable) Nipple Throat Hole Hex Sizes Overall Protruding Size Bore dia. Nipple Diameter /F dia. length No. dia. Thread Gland Diff. Nut Without shroud B will fit C,,9,,,9,,,,,,, 9, 9,,, M M M M M M M M & & & & & & & -,9,,,,, 9, ,, M & B, C 9, 9, 9 N/ N/ x M PCD x M PCD N/ N/ Specifications are subject to alteration without prior notice. SELECTION CHRT GLNDS ND ES FOR UNRMOURED CBLES Brass Compression Glands Flat twin & Round Cable Earth Cable Diameter (mm) Cable Gland Nipple Min. Max. Size Size Thread,, X Small, 9, Ripcord mm & amp, 9, x core S mm Ripcord,,, mm² & amp x core mm 9,,,,,,,9,, 9,9,,,,,,, mm², mm², mm², mm², mm² mm mm mm mm mm mm mm mm Tufflon Compression Glands Flat twin & Round Cable Earth Cable Diameter (mm) Cable Min. Max. Size,,,,,,, 9, 9,,, 9, X Small Ripcord amp x core, mm², mm², mm², mm², mm², mm² When ordering, specify "Round Cable" or "Flat Twin & Earth" Flameproof (Ex d/e) Compression Glands Gland Size Ex d/e Enviro Compression Glands and Ex e Brass Compression Glands CBLE DI. GLND Min. mm Max. mm THRED s & (X Small) Kit,,,,, D Gland Size 9,, 9,,,, Gland Size S S L Nipple Thread mm mm mm mm mm (Enviro) s (Enviro),, M x,p,, M x,p,, M x,p,,9 M x,p,9, M x,p., (Brass) M x,p E Gland Size (Brass) s (Brass) S L S L S L S L S L S L M x,p M x,p M x,p M x,p M x,p M x,p Cable Outside Diameter Min. Max. Compression Conversion Kits Ezee-Fit Boxes Cable Min. Max. Kit Size,, xs, 9, 9,, S L,, Rxs,,,, F Gland Size S L S L S L S L S L S L S L Gland or Box Size,,,, M x,p Ex d/e EZEE-SEL BRRIER GLNDS FOR SW CBLE Cable Bedding pproximate Corresponding Diameter mm. Suitable Cables Min. Max. Min SW Dia Max of Cores,,, 9,, 9,,,9,9,, Ex e HV TPE RMOURED MUNICIPL & PETRO GLNDS Lead Bedding pproximate Corresponding Diameter mm. Suitable Cables Min. Max. Size (mm ) Max. bedding dia. x,, x, x x 9,, x x,,, x x,,,9,,,,,,,,,,,,,,,,, 9,,,,, 9,, FLMEPROOF (Ex d/e) GLNDS FOR SW / PVC CBLE Cable Bedding pproximate Corresponding Diameter mm. Suitable Cables Min. Max. Size (mm²) Cores,,, &,,,,,,,,,, 9,, 9, Compression Conversion Kits S to L for luminium lloy Boxes S to L for djustable Glands Cable Min. Max., 9,,,,,,,,,,,, 9,,9,,, When ordering, specify whether luminium lloy or Cable Gland Conversion Kit,,,,,,,,, 9,, 9,, 9,,,,,,,,,,,, 9,,,, 9,9,,, Kit Size,, xs S L S * L S * L S L S L S L S L S L S L, & & & * &, & & * Gland or Box Size & & These cable sizes are based upon nominal values supplied by cable manufacturers. No guarantee can be given that the selected gland will fit these cables as SNS does not specify cable bedding sizes. When selecting glands, the cable bedding diameter must be measured and compared to the max/min values of the table. * Nominal bedding diameter of these cables is close to the bore size of gland. JUN