Mercury Speciation in Flue Gas from Coal-fired Power Stations
|
|
- Madeleine Barber
- 7 years ago
- Views:
Transcription
1 Mercury Speciation in Flue Gas from Coal-fired Power Stations Matthew A Dexter, Warren T Corns and Peter B Stockwell P S Analytical Arthur House Crayfields Industrial Estate Main Road Orpington BR5 3HP
2 Overview Hg in stack gas measurements Why? Offline analysis Continuous Emission Monitors Sample collection Sample transport Sample pre-treatment Analysis Calibration Typical Data Summary
3 Why Measure Power Station Hg Emissions? Public concern about Hg emissions Environmental accumulation of toxic metals Major sources of emissions: coal fired power plants waste incinerators Transport strongly dependent on speciation Regulatory compliance US EPA Clean Air Mercury Rule (March 2005)
4 Offline Analysis Reference methods EPA Methods 29 and 101a (Total Mercury) Impinger based HNO 3 /H 2 O 2 or H 2 SO 4 /KMnO 4 Ontario Hydro Method (Speciation) ASTM Method D Impingers with KCl & H 2 SO 4 /KMnO 4 Monitoring methods QuickSEM TM (Total Mercury) 40 CFR Part 75 Appendix K
5 Offline Analysis Reference methods Average data over 1+ hours Labour intensive Delay for results from lab. Monitoring methods Average data over hours or days Delay for results from lab.
6 Online Analysis Continuous Emissions Monitor (CEM) Stack PROBE Heated Sample Line Sample collection Sample transport Sample pre-treatment Analysis Calibration Computer Speciation Module Hg 0 HgT Sir Galahad Stream Selector Calibration Device
7 Sample Collection - The Probe PROBE Heated Sample Line Stack Computer Speciation Module Hg 0 Hg T Sir Galahad Stream Selector Calibration Device
8 Inertial Probe Schematic Venturi Eductor Gas Outlet Flange Gas Inlet Pump Cal Gas Port Gas Sample to Analyser
9 Sample Transport Heated Lines PROBE Heated Sample Line Stack Computer Speciation Module Hg 0 HgT Sir Galahad Stream Selector Calibration Device
10 Sample transport Inert materials Durinert (glass) coatings PFA/PTFE components Temperature Raw sample Ash-free sample
11 Sample Pre-treatment The Speciation Module PROBE Heated Sample Line Stack Computer Speciation Module Hg 0 HgT Sir Galahad Stream Selector Calibration Device
12 The Speciation Module Primary Vent Thermolytic convertor Optional Reagent Feed Hg Tota Peltier Cooler Hot Flue Gas HgCl2 adsorbent Optional Reagent Feed Drain Pump Hg Peltier Cooler 0 Drain Pump Heated Oven
13 Typical Data Using Bench Scale Apparatus Dry Base Speciation Unit, Hg T channel Effect of different flue gas components conc/ng m :00 01:12 02:24 03:36 04:48 06:00 07:12 08:24 time/hh:mm air water, HCl water, HCl, SO2, NO2 water, HCl, SO2, NO2, NO
14 Analysis The Sir Galahad PROBE Heated Sample Line Stack Computer Speciation Module Hg 0 HgT Sir Galahad Stream Selector Calibration Device
15 Sir Galahad Amalgamation Atomic Fluorescence Spectroscopy Why AFS? Sensitivity Selectivity Simplicity Why amalgamation? Sample pre-treatment selectivity Sample preconcentration
16 Schematic Flow Diagram of the Sir Galahad Sample Argon Sample Argon Waste MFC AFS MFC AFS PUMP Waste PUMP Waste
17 Calibration PROBE Heated Sample Line Stack Computer Speciation Module Hg 0 Hg T Sir Galahad Stream Selector Calibration Device
18 On-Line Calibration System Air MFC 1 MFC 2 Hg Reservoir Oven Blank Span
19 A Power Station in Kentucky 120MW unit Fuel: bituminous coal Kentuckian Environmental controls Electrostatic Precipitator (ESP) No Flue Gas Desulfurisation (FGD) No DeNO x (low NO x burners)
20 A Power station in Kentucky Stack monitoring Inertial probe & wet/dry speciation Hg/ug m /10/ :00 24/10/ :00 25/10/ :00 26/10/ :00 27/10/ :00 28/10/ :00 29/10/ :00 30/10/ :00 date/time Wet and Dry Hg T show good agreement HgT dry HgT wet Hg0 dry
21 A Power Station in SE England 500MW unit Fuel: bituminous coal Russian Colombian South African <10% biomass (cereal pellets) Environmental controls Electrostatic Precipitator (ESP) No Flue Gas Desulfurisation (FGD) No DeNO x
22 A Power station in SE England Stack monitoring Heated filter blowback probe & dry speciation Unattended operation conc/ug m load/mw /11 09/11 10/11 11/11 12/11 13/11 14/11 date & time Hg levels trend with unit load 15/11 16/11 17/11 18/11 19/ Stack Hg0 Stack HgT Load/MW
23 A Power station in SE England Stack monitoring Heated filter blowback probe & dry speciation Unattended operation SO 2 trending shows variation in fuel Hg conc/ug m B SO2 conc/ppm /11 09/11 10/11 A 11/11 12/11 13/11 14/11 date & time 15/11 16/11 17/11 18/11 19/ Stack Hg0 Stack HgT SO2/ppm Hg in coal A 30 ppb B 100 ppb
24 Conclusion CEM developed to measure mercury in power station stack gases Difficult sampling, transport and pretreatment issues have been addressed Successfully operated unattended on numerous power station stacks
Determining the Variability of Continuous Mercury Monitors (CMMs) at Low Mercury Concentrations
Determining the Variability of Continuous Mercury Monitors (CMMs) at Low Mercury Concentrations EUEC 2011 Phoenix, Arizona January 31 February 2, 2011 Dennis Laudal Tekran Comments This presentation is
More informationPhoenix Process Engineering, Inc. Project Experience Helping Clients Achieve MACT Compliance
Phoenix Process Engineering, Inc. Project Experience Helping Clients Achieve MACT Compliance The Boiler MACT, 40 CFR 63, Subpart DDDDD, was vacated in 2007 by the U.S Court of Appeals and the 2004 rule
More informationFlue Gas Desulfurization CEMS Design Lessons Learned and Monitoring Technologies to Meet the New Mercury and Air Toxics (MATS) Rule
Flue Gas Desulfurization CEMS Design Lessons Learned and Monitoring Technologies to Meet the New Mercury and Air Toxics (MATS) Rule Cemtek Environmental, Interactive CEMS Workshop a technical solution
More informationAssessing the Changes Required by the Industrial Boiler MACT Regulations
Technical Paper MS-17 Assessing the Changes Required by the Industrial Boiler MACT Regulations Authors: A.L. LeClair L.M. McDermitt Babcock & Wilcox Power Generation Group, Inc. Barberton, Ohio, U.S.A
More informationAdvanced Solutions for Gas Monitoring
Continuous Emissions Monitoring Stack Testing Process Monitoring Quality Control Engine Exhaust Gas Monitoring Workplace Air Quality Monitoring Combustion Research Emergency Rescue Services Advanced Solutions
More informationETV Joint Verification Statement
THE ENVIRONMENTAL TECHNOLOGY VERIFICATION PROGRAM U.S. Environmental Protection Agency ETV Joint Verification Statement TECHNOLOGY TYPE: Continuous Emission Monitor APPLICATION: TECHNOLOGY NAME: COMPANY:
More informationContinuous Emissions Monitoring - Program 77
Program Description Program Overview Coal-fired power plants are in increased need of robust, accurate, and certifiable continuous emissions monitors (CEMs) for mercury, particulate matter (PM), acid gases,
More informationRemoving Thallium from Industrial FGD Scrubber Water with Sorbster Adsorbent Media
Case History MAR Systems Inc. Removing Thallium from Industrial FGD Scrubber Water with Sorbster Adsorbent Media Trace thallium levels in process and wastewater streams pose a human toxicity threat. Tidwell
More informationThe Fate of Ammonia and Mercury in the Carbon Burn-Out (CBO ) Process
The Fate of Ammonia and Mercury in the Carbon Burn-Out (CBO ) Process Vincent M Giampa Progress Materials, Inc., One Progress Plaza, St. Petersburg, Florida 33701 KEYWORDS: mercury, ammonia, carbon burn-out,
More informationMercury emissions control in two hazardous waste incineration plants with dry and semi-dry gas cleaning
Mercury emissions control in two hazardous waste incineration plants with dry and semi-dry gas cleaning X. Chaucherie Prof. Dr. B. W. Vosteen P. Berg April 15th, 2015 VDI Wissensforum 15 th Conference
More informationImproving the Thermal Efficiency of Coal-Fired Power Plants: A Data Mining Approach
Paper 1805-2014 Improving the Thermal Efficiency of Coal-Fired Power Plants: A Data Mining Approach Thanrawee Phurithititanapong and Jongsawas Chongwatpol NIDA Business School, National Institute of Development
More informationBill Maxwell, U.S. Environmental Protection Agency, OAQPS (C439-01)
TO: Bill Maxwell, U.S. Environmental Protection Agency, OAQPS (C439-01) FROM: Jeffrey Cole, RTI International DATE: December 2003 SUBJECT: Methodology for Estimating Cost and Emissions Impact for Coal-
More informationOnline Infrared Flue Gas Analyzer Gasboard 3000
Online Infrared Flue Gas Analyzer Gasboard 3000 O 2 CO CO2 SO 2 NO NO x Use of measurement methods Proprietary Infrared NDIR Detectors - Micro-flow in ppm range: CO, NO, SO2, CO2 - Dual beam in % volume
More informationFMA-80 Fluorescence Mercury Analyzer
FMA-8 Fluorescence Mercury Analyzer www.milestonesrl.com MILESTONE H E L P I N G C H E M I S T S The new Milestone FMA-8 The mercury problem A wide range of mercury analyzers Milestone offers a wide range
More informationBiomass Boiler House Best Practices. Irene Coyle & Fernando Preto CanmetENERGY
Biomass Boiler House Best Practices Irene Coyle & Fernando Preto CanmetENERGY Growing the Margins London, Ontario March 2010 The Biomass & Renewables Group of Industrial Innovation Group (IIG) of CanmetENERGY
More informationEnvironmental Compliance using CEMS
Environmental Compliance using CEMS ERM s Exton Office March 13, 2012 Joel Millard Environmental Regulatory Specialist.1 Overview CEMS Why install a CEMS Common Analyzer Types MATS Compliance using CEMS
More informationSludge Treatment Facility Stack Gas Monitoring Report February 2016
I. INTRODUCTION This Monthly Report aims to provide a summary of environmental performance of the Sludge Treatment Facility (STF) over the monitoring period, which includes the air emission data collected
More informationSO 3 -Monitoring in Flue Gas of a Power Plant Application & Results
of a Power Plant Application & Results : Introduction - SO 3 / H 2 SO4 - The SO 3 Challenge : Spectral evaluation - Components to be monitored - Calibration : Analyzer Setup : Field Test Results : Benefits
More informationTexas Commission on Environmental Quality Page 1 Chapter 117 - Control of Air Pollution from Nitrogen Compounds
Texas Commission on Environmental Quality Page 1 SUBCHAPTER G: GENERAL MONITORING AND TESTING REQUIREMENTS DIVISION 1: COMPLIANCE STACK TESTING AND REPORT REQUIREMENTS 117.8000, 117.8010 Effective June
More informationFlue Gas Mercury Removal Using Carbon- Polymer Composite Material
Flue Gas Mercury Removal Using Carbon- Polymer Composite Material X. Sean Lu, Zach Xu, Steve Stark, Richard Gebert, W.L. Gore &, Inc. Tom Machalek, Carl Richardson, Jennifer Paradis, URS Corporation Ramsay
More informationTECHNICAL BRIEFING SHEET NRG Texas Power LLC Permit No.: HAP-14
TECHNICAL BRIEFING SHEET NRG Texas Power LLC Permit No.: HAP-14 PROJECT DESCRIPTION: NRG Texas Power LLC (NRG Texas) has requested a Hazardous Air Pollutant (HAP) Major Source [FCAA 112(g)] Permit HAP-14,
More informationDMA-80 Direct Mercury Analyzer
DMA-80 Direct Mercury Analyzer Milestone Srl Milestone Srl 1 Introduction Mercury in the atmosphere can be from manmade sources (coal-fired power plants, municipal incinerators, industrial boilers) or
More informationSULFURIC ACID MIST PERFORMANCE TEST PROTOCOL. Duke Energy Florida, Inc. Crystal River Power Plant Units 4&5 Crystal River, Citrus County, Florida
SULFURIC ACID MIST PERFORMANCE TEST PROTOCOL Duke Energy Florida, Inc. Crystal River Power Plant Units 4&5 Crystal River, Citrus County, Florida August 2013 CONTENTS SECTION 1.0 INTRODUCTION...3 SECTION
More information(a) Method 1 Sample and Velocity Traverses for Stationary Sources.
While we have taken steps to ensure the accuracy of this Internet version of the document, it is not the official version. Please refer to the official version in the FR publication, which appears on the
More informationHow To Make A Carbon Capture Plant Workable
IEA MOST Workshop: Advances in deployment of fossil fuel technology Beijing June 25, 2014 US DOE National Carbon Capture Center Power Systems Development Facility (PSDF) started combustion testing June
More informationExperience with co-combustion of biomass and waste in coal-fired power plants
Experience with co-combustion of biomass and waste in coal-fired power plants Topsøe Catalysis Forum August 2009 Bo Sander, DONG Energy Power, Denmark GENERATION - HCASA DONG Energy Power in Europe Power
More informationSLMA Meeting. Boiler MACT and Related Rules. Atlanta, GA March 2, 2011. Martin Rollins, P. E. H. M. Rollins Company, Inc. Gulfport, Mississippi
SLMA Meeting Atlanta, GA March 2, 2011 Boiler MACT and Related Rules Martin Rollins, P. E. H. M. Rollins Company, Inc. Gulfport, Mississippi Boiler MACT and Related Rules EPA Had Requested 15 Month Delay
More informationAPPLICATION FOR EXEMPTION Assessing Authority
TO: Combined Request for Pollution Control and Recycling Property Tax Exemption and Iowa Code Section 427.1 (19) APPLICATION FOR EXEMPTION Assessing Authority IMPORTANT: The application should be filed
More informationINDUSTRIAL BOILER MACT FACTSHEET
INDUSTRIAL BOILER MACT FACTSHEET The National Emission Standards for Hazardous Air Pollutants (NESHAP) for Industrial/Commercial/Institutional Boilers and Process Heaters (40 CFR Part 63, Subpart DDDDD),
More informationMercury emission and speciation of coal-fired power plants in China
Atmos. Chem. Phys., 10, 1183 1192, 2010 Author(s) 2010. This work is distributed under the Creative Commons Attribution 3.0 License. Atmospheric Chemistry and Physics Mercury emission and speciation of
More informationEMISSIONS, MONITORING, AND CONTROL OF MERCURY FROM SUBBITUMINOUS COAL-FIRED POWER PLANTS PHASE II
WRI-08-R012 EMISSIONS, MONITORING, AND CONTROL OF MERCURY FROM SUBBITUMINOUS COAL-FIRED POWER PLANTS PHASE II TOPICAL REPORT Start Date 2005 End Date 2007 By: Alan E. Bland Jesse D. Newcomer Western Research
More informationMERCURY REMOVAL FROM NATURAL GAS AND LIQUID STREAMS ABSTRACT. Giacomo Corvini, Julie Stiltner and Keith Clark UOP LLC Houston, Texas, USA
MERCURY REMOVAL FROM NATURAL GAS AND LIQUID STREAMS Giacomo Corvini, Julie Stiltner and Keith Clark UOP LLC Houston, Texas, USA n ABSTRACT Mercury is often present in natural gas, petrochemical and some
More informationGuidance and Reporting Instructions on Temporary E-reporting for the MATS Rule
Guidance and Reporting Instructions on Temporary E-reporting for the MATS Rule As explained in the interim MATS e-reporting rule, which was signed by the Administrator on March 9, 2015, the EPA plans to
More informationSMALL ENTITY COMPLIANCE GUIDE FOR MAJOR SOURCE BOILERS AND PROCESS HEATERS
SMALL ENTITY COMPLIANCE GUIDE F MAJ SOURCE BOILERS AND PROCESS HEATERS National Emission Standards for Hazardous Air Pollutants for Major Sources: Industrial, Commercial, and Institutional Boilers and
More informationSewage sludge treatment with oxygen enrichement and oxyfuel combustion in CFBC - new pilot plant results
Sewage sludge treatment with oxygen enrichement and oxyfuel combustion in CFBC - new pilot plant results 64 TH IEA FLUIDIZED BED CONVERSION MEETING Naples 3 rd of June, 2012 Authors: David Wöß, Gregor
More informationWaste Incineration Plants
Waste Incineration Plants Modern Technology for a better Environmental Welcome at Hafner! We Manufacture Systems for Energy Recovery from Wastes and Biomass as well as for Treatment of Hazardous Wastes.
More informationStack Sampling Stack sampling or source sampling
Stack Monitoring Stack Sampling Stack sampling or source sampling may be defined as a method of collecting representative samples of pollutant laden air/gases at the place of origin of pollutants to determine
More informationSulfur Tail Gas Thermal Oxidizer Systems By Peter Pickard
Sulfur Tail Gas Thermal Oxidizer Systems By Peter Pickard Introduction SRU s (Sulfur Recovery Units) are critical pieces of equipment in refineries and gas plants. SRUs remove sulfur compounds from certain
More informationImage Area EXCEPTIONAL PERFORMANCE FOR CHALLENGING MERCURY ANALYSES. FIMS 100 and 400. Flow Injection Mercury Systems
Image Area EXCEPTIONAL PERFORMANCE FOR CHALLENGING MERCURY ANALYSES FIMS 100 and 400 Flow Injection Mercury Systems Delivering the Performance You Need The determination and monitoring of sub-ppb concentrations
More informationThermo Scientific Arke SO 3 System. increased sensitivity. greater value
Thermo Scientific Arke SO 3 System increased sensitivity greater value Technology That Meets the Challenge The Thermo Scientific Arke SO 3 System, with built-in SO 3 generator, uses an advanced Quantum
More informationAir Quality Performance Test Guidelines. Kansas Department of Health and Environment Bureau of Air and Radiation
Air Quality Performance Test Guidelines Kansas Department of Health and Environment Bureau of Air and Radiation December 22, 2004 TABLE OF CONTENTS 1. INTRODUCTION 2. TEST PLANNING 2.1 EPA Test Methods
More informationTEST REPORT for the ARID TECHNOLOGIES VAPOR RECOVERY UNIT installed in LANTANA, FL
Project No. 148 TEST REPORT for the ARID TECHNOLOGIES VAPOR RECOVERY UNIT installed in LANTANA, FL Prepared for: Mr. Ted Tiberi Arid Technologies, Inc. 130 North LaGrange Rd. LaGrange, IL 60525 Prepared
More informationENVIROENERGY SOLUTIONS. Presentation of APC and Wet Electrostatic Precipitation Technology
ENVIROENERGY SOLUTIONS Presentation of APC and Wet Electrostatic Precipitation Technology Agenda Introduce participants Review WESP technology Review the Applications of WESP Questions & answers People
More informationHow To Run A Power Plant In Celje
VRANSKO, May 2009 Waste Management Strategy Waste management strategy in accordance with European directive 91/156/EEC: 1. Reduction at source 2. Reuse 3. Recycle 4. Energy recovery 5.Disposal Celje Regional
More informationS300 Series Dust Monitors
S301 DustGuard S303 Trend Monitor S304 Emission Monitor S305 Stack Monitor Intrinsically Safe (ATEX) Dust Monitors Split Architecture (Remote)Models Data Logging Software S300 Series Dust Monitors Dust
More informationCarbon Dioxide Membrane Separation for Carbon Capture using Direct FuelCell Systems
Carbon Dioxide Membrane Separation for Carbon Capture using Direct FuelCell Systems DFC Technology Used as Electrochemical Membrane for CO 2 Purification and Capture during Power Generation FCE s Direct
More informationEnhanced power and heat generation from biomass and municipal waste. Torsten Strand. Siemens Power Generation Industrial Applications
Enhanced power and heat generation from biomass and municipal waste Torsten Strand Siemens Power Generation Industrial Applications Enhanced power and heat generation from biomass and municipal waste Torsten
More informationLinkoping is in Sweden, where winters are cold
U1YESCO Nodule 19: Combined heat and power Linkoping is in Sweden, where winters are cold If you lived in the Swedish city of Linkoping, you would probably benefit from a way of heating which is unfamiliar
More informationMONITORING STACK GAS EMISSIONS OF VOLATILE TRACE ELEMENTS, SULPHUR DIOXIDE AND PM 10 PARTICULATES FROM COAL-FIRED STOKER SYSTEMS
MONITORING STACK GAS EMISSIONS OF VOLATILE TRACE ELEMENTS, SULPHUR DIOXIDE AND PM 10 PARTICULATES FROM COAL-FIRED STOKER SYSTEMS A.H. Clemens, D. Gong and R.S. Whitney* Coal Research Limited P.O. Box 31-244
More informationNAWTEC18-3541 CONCEPTS AND EXPERIENCES FOR HIGHER PLANT EFFICIENCY WITH MODERN ADVANCED BOILER AND INCINERATION TECHNOLOGY
Proceedings of the 18th Annual North American Waste-to-Energy Conference NAWTEC18 May 11-13, 2010, Orlando, Florida, USA NAWTEC18-3541 CONCEPTS AND EXPERIENCES FOR HIGHER PLANT EFFICIENCY WITH MODERN ADVANCED
More informationA Review on Power Generation in Thermal Power Plant for Maximum Efficiency
International Journal of Advanced Mechanical Engineering. ISSN 2250-3234 Volume 4, Number 1 (2014), pp. 1-8 Research India Publications http://www.ripublication.com/ijame.htm A Review on Power Generation
More informationEnvironmental Equipment, Inc. IMR 5000 Continuous Flue Gas Monitoring System IMR 5000
IMR 5000 Continuous Flue Gas Monitoring System The IMR 5000 is state-of-the-art continuous flue-gas monitoring system, and is designed for a wide variety of flue-gas monitoring applications. The IMR 5000
More informationExamination syllabuses for Manual Stack emissions monitoring. Environment Agency Version 9 January 2015
Examination syllabuses for Manual Stack emissions monitoring Environment Agency Version 9 January 2015 Record of amendments Version Date Section Amendment number 6 August 09 Level 1 Updated Level 1 syllabus
More informationTRIAL CHEMICAL CLEANING OF FOULED APH BASKETS
TRIAL CHEMICAL CLEANING OF FOULED APH BASKETS Dr. Abhay Kumar Sahay, AGM(CC OS) Bijay Manjul, AGM( Operation) Kahalgaon Boiler has three inputs Steam generator 1. WATER 2. COAL 3. AIR Burner Air preheater
More informationWaste to Energy in Düsseldorf. for a clean city.
Waste to Energy in Düsseldorf for a clean city. Waste Management in Düsseldorf. Düsseldorf s public utilities company known as Stadtwerke Düsseldorf operates a waste to energy plant (WtE) that has been
More informationQuality Assurance Program Quality Assurance Plan Periodic Audits Standard Operating Procedures Preventive Maintenance Outline Quality Assurance Plan (QAP) What is a QAP Why is a QAP required? What does
More informationMERCURY REMOVAL FROM NATURAL GAS & LIQUID STREAMS. John Markovs UOP Des Plaines, Illinois. Jack Corvini UOP Houston, Texas
MERCURY REMOVAL FROM NATURAL GAS & LIQUID STREAMS By John Markovs UOP Des Plaines, Illinois Jack Corvini UOP Houston, Texas Introduction As an element in the periodic table, mercury is found at trace levels
More informationControl Device Requirements Charts For Oil and Gas Handling and Production Facilities
Device Charts For Oil and Gas Handling and Production Facilities Purpose/Scope: The purpose of this document is to provide standardized guidance for use by the regulated community and air permit reviewers,
More informationTODAY S THERMAL OXIDIZER SOLUTIONS TO MEET TOMORROW S CHALLENGES
Callidus Oxidizers for Waste Destruction TODAY S THERMAL OXIDIZER SOLUTIONS TO MEET TOMORROW S CHALLENGES Thermal oxidizer systems Catalytic oxidizer systems Callidus, experts in Thermal Oxidizers Wide
More informationEnhanced Capture of Mercury in Baghouse
Enhanced Capture of Mercury in by using Novel Filtration Media and Filter Design Vishal Bansal, Robert W. Taylor, Pete Maly, and Bryan Yetter Abstract Study was conducted at a 5-MW equivalent slipstream
More informationEnergy Saving Fact Sheet Boilers
Energy Saving Fact Sheet Boilers Turn a burning issue into real energy savings You need a boiler to heat your premises and provide hot water or to generate steam for use in industrial processes. Unfortunately,
More informationGUIDELINES FOR PROCESSING AND USING REFUSE DERIVED FUEL (RDF) IN CEMENT INDUSTRY
1 GUIDELINES FOR PROCESSING AND USING REFUSE DERIVED FUEL (RDF) IN CEMENT INDUSTRY August, 2012 Government of Pakistan Pakistan Environmental Protection Agency (Ministry of Climate Change) Islamabad 2
More informationDrying of Woody Biomass. Process Engineering / GEA Barr-Rosin
Drying of Woody Biomass BioPro Expo & Marketplace / Atlanta, GA / March 14-16, 2011 Drying of Woody Biomass Conventional Direct Fired Dryer Technology Proprietary work of the Copyright Owner Issues with
More informationTechnique of Monitoring Dioxins in Flue Gas from MSW Incinerators using Dioxin Precursor Analyzer
Technique of Monitoring Dioxins in Flue Gas from MSW Incinerators using Dioxin Precursor Analyzer Hideki Nagano*, Kunio Miyazawa**, Yoshinori Yomura***, Toshihiko Iwasaki****, Takashi Yokoyama***** and
More informationHeavy Metal Separation from Flue Gas Scrub Water with TMT15
Heavy Metal Separation from Flue Gas Scrub Water with TMT15 McIlvaine Company Hot Topic Hour on FGD Wastewater Treatment Rüdiger Peldszus June 16, 2011 An attractive company One of the global leaders in
More informationThe Regulatory Impact Analysis (RIA) for the Mercury Air Toxics Standard (MATS)
The Regulatory Impact Analysis (RIA) for the Mercury Air Toxics Standard (MATS) Kevin Culligan U.S. Environmental Protection Agency (EPA) Associate Division Director, Sector Policies and Programs Division
More informationEvaluation of mobile storage systems for heat transport. G. Storch, A. Hauer, A. Krönauer ZAE Bayern, Walther-Meißner-Str. 6, 85748 Garching, Germany
Evaluation of mobile storage systems for heat transport G. Storch, A. Hauer, A. Krönauer ZAE Bayern, Walther-Meißner-Str. 6, 85748 Garching, Germany Outline Introduction Mobile Storage Units Case Studies:
More informationI. STEAM GENERATION, BOILER TYPES
I. STEAM GENERATION, BOILER TYPES and BOILER PLANT SYSTEMS 1 Steam Generation Water s Unique Properties: High Thermal Capacity (Specific Heat) High Critical Temperature Ideal Medium for Heat Delivery High
More informationBEST AVAILABLE RETROFIT TECHNOLOGY AT EGU FACILITIES. July 1, 2011
BEST AVAILABLE RETROFIT TECHNOLOGY AT EGU FACILITIES July 1, 2011 WISCONSIN DEPARTMENT OF NATURAL RESOURCES 101 South Webster Street Box 7921 Madison, Wisconsin 53707-7921 1 Statement of Purpose This document
More informationPurpose. Scope. Preparing for a Test
www.idem.in.gov www.idem.in.gov Purpose The purpose of this guidance is to provide information about the activities a source can perform prior to conducting a formal stack test. Sources may elect to verify
More informationReport Title: Quantification of Mercury in Flue Gas Emission Using Boron-Doped. Diamond Electrochemistry
Report Title: Quantification of Mercury in Flue Gas Emission Using Boron-Doped Diamond Electrochemistry Type of Report: Final (submitted on 8/19/2003) Reporting Period Start Date: 9/19/2001 Reporting Period
More informationIt s time for H.E.R.O. Energy Saving Strategy for. Tunnel & Shuttle Kilns
Energy Saving Strategy for Tunnel & Shuttle Kilns SANITARY WARE 1 Introduction The application of the Kyoto protocol and the effects of the recent energy crisis, have highlighted just how important it
More informationBubbling Fluidized Bed or Stoker Which is the Right Choice for Your Renewable Energy Project?
Technical Paper Bubbling Fluidized Bed or Stoker Which is the Right Choice for Your Renewable Energy Project? J.P. DeFusco, P.A. McKenzie and M.D. Fick Barberton, Ohio, U.S.A. Presented to: CIBO Fluid
More informationMulti-pollutant control solutions for coal based power plants
Multi-pollutant control solutions for coal based power plants By Luca Mancuso and Hans Janssen Content SOx control Wet Scrubbers Open towers Dual Flow Tray Technology Semi-Dry SDA CFB Scrubbers Dust control
More informationSNOX flue gas treatment for boilers burning high-sulphur fuels
SNOX flue gas treatment for boilers burning high-sulphur fuels SNOX flue gas treatment for boilers burning high-sulphur fuels 1 / 18 Summary The processing of more and more high-sulphur crude oil makes
More informationBEST PRACTICES IN LEAK DETECTION AND REPAIR (LDAR) PROGRAMS. November 06, 2014 By: François Thibodeau, Eng.
BEST PRACTICES IN LEAK DETECTION AND REPAIR (LDAR) PROGRAMS November 06, 2014 By: François Thibodeau, Eng. 2 PRESENTATION OVERVIEW 1. Essential Components of a LDAR Program 2. LDAR Best Practices a. A
More informationPellet Process - Uses and Exposures
Pellet Process - Uses and Exposures 1 PROCESS - MANUFACTURING & USES 1 1.1 Manufacturing of pellets 2 Pellets are formed from the raw materials fine ores and additives of < 0.05 mm - into 9-16 mm spheres
More informationWaste a source of energy. Regional Solid Waste Management Plan Review: Engaging solutions for tomorrow. Incineration. Incineration
Waste a source of energy Regional Solid Waste Management Plan Review: Engaging solutions for tomorrow Garbage School 301: Waste to Energy All organic materials contains energy Plant or animal based Plastics
More informationOverview of Integrated Coal Gasification Combined-cycle Technology Using Low-rank Coal
19 Overview of Integrated Coal Gasification Combined-cycle Technology Using Low-rank Coal TAKAO HASHIMOTO *1 KOICHI SAKAMOTO *2 YOSHIKI YAMAGUCHI *3 KOJI OURA *4 KENICHI ARIMA *5 TAKESHI SUZUKI *6 Mitsubishi
More informationOptimal Power Plant Integration of Post-Combustion CO 2 Capture. Dr. Tobias Jockenhövel Dr. Rüdiger Schneider Michael Sandell Lars Schlüter
Optimal Power Plant Integration of Post-Combustion CO 2 Capture Dr. Tobias Jockenhövel Dr. Rüdiger Schneider Michael Sandell Lars Schlüter Siemens AG, Energy Sector Germany POWER-GEN Europe 2009 Cologne,
More informationState of the Art (SOTA) Manual for Boilers and Process Heaters
State of the Art (SOTA) Manual for Boilers and Process Heaters Original Date: July 1997 Revision Date: February 22, 2004 State of New Jersey Department of Environmental Protection Air Quality Permitting
More informationFluidized Bed Based CO 2 Capture by Carbonate Looping
Fluidized Bed Based CO 2 Capture by Carbonate Looping Prof. Dr.-Ing. Bernd Epple bernd.epple@est.tu-darmstadt.de www.est.tu-darmstadt.de Tel. +49 6151 16 4717 1 Carbonator: T 450 750 C CaO + CO 2 CaCO
More information(205) 670-5088 (205) 670-5863
Ruth Ann Yongue Roxann Laird Senior Engineer Assistant Project Director rayongue@southernco.com rfleonar@southernco.com (205) 670-5088 (205) 670-5863 Southern Company Services Power Systems Development
More informationAPPLICATION OF ICP-MS TECHNOLOGY FOR TRACE METALS ANALYSIS
MR. TELLIARD: Our next speaker is Paula Hogg. Paula is currently a lab manager at Hampton Roads Sanitation District s Central Environmental Laboratory. We would like to also thank Hampton Roads for sending
More informationCommitted to make a better world
Committed to make a better world 1. Higher Availability & Reliability 2. Highest Plant efficiency 3. Lower Heat Rate 4. Minimum Auxiliary Power Consumption 5. Minimum Emission of Pollutants Committed to
More informationAir Quality Management Plan
Alcoa World Alumina Australia December 2007 FOREWARD This document has been prepared in accordance with Ministerial and Works Approval conditions granted for the Pinjarra Efficiency Upgrade Project, and
More informationContinuous Monitoring of Flue and Combustible or Hazardous Gases and Vapors
Continuous Monitoring of Flue and Combustible or Hazardous Gases and Vapors www.static-control.in 1 Introduction The detection or monitoring of flue gases and or hazardous gases has been a complex subject
More informationWaste to Energy. Anders Damgaard. Thanks to Jiri Hyks and Thomas H Christensen DTU for some slides
Denmark (Thomas Astrup) Denmark (COWI) Waste to Energy Anders Damgaard Austria (CEWEP) Thanks to Jiri Hyks and Thomas H Christensen DTU for some slides Copyright Anders Damgaard & Morton A. Barlaz, NC
More informationHeating Water by Direct Steam Injection
Heating Water by Direct Steam Injection Producing hot water by direct steam injection provides a solution where large volumes of hot water at precise temperatures are required, and where energy and space
More informationContinuous emission monitoring in power stations and combined heat and power plants
Ref : 02003Ren9771... Continuous emission monitoring in power stations and combined heat and power plants... Thermal Generation Study Committee... The Union of the Electricity Industry - EURELECTRIC, formed
More informationSTATE OF CONNECTICUT DEPARTMENT OF ENVIRONMENTAL PROTECTION BUREAU OF AIR MANAGEMENT
Page 1 of 7 STATE OF CONNECTICUT DEPARTMENT OF ENVIRONMENTAL PROTECTION NEW SOURCE REVIEW PERMIT TO CONSTRUCT AND OPERATE A STATIONARY SOURCE Issued pursuant to Title 22a of the Connecticut General Statutes
More informationATMOSPHERIC EMISSIONS FROM GAS FIRED HOME HEATING APPLIANCES
ATMOSPHERIC EMISSIONS FROM GAS FIRED HOME HEATING APPLIANCES Stefano Cernuschi, Stefano Consonni, Giovanni Lonati, Michele Giugliano, Senem Ozgen DIIAR Environmental Sect., Politecnico di Milano, P.za
More informationImproving Energy Efficiency through Biomass Drying
Improving Energy Efficiency through Biomass Drying Gilbert McCoy, Senior Energy Systems Engineer Northwest CHP Technical Assistance Partnership International District Energy Association Woody Biomass CHP
More informationLong-Term Demonstration of CO2 Recovery from the Flue Gas of a Coal-Fired Power Station
Long-Term Demonstration of CO2 Recovery from the Flue Gas of a Coal-Fired Power Station MASAKI IIJIMA* 1 SHOJIRO IWASAKI* 1 SHINYA KISHIMOTO* 1 TORU TAKASHINA* 2 SUSUMU OKINO* 2 There is now a growing
More informationV. ENERGY SAVINGS IN INDUSTRY
V. ENERGY SAVINGS IN INDUSTRY A. Energy Use in Industry Industry is the major user of energy in modern society, accounting for roughly 40% of final energy use. Coal or oil are heavily used, especially
More informationAdvanced Mercury Removal Technologies. 2009 UOP LLC. All rights reserved. UOP 5241G-01
Advanced Mercury Removal Technologies 2009 UOP LLC. All rights reserved. UOP 5241G-01 Why Remove Mercury? 1. Equipment Protection 2. Improving product quality Mercury found in refinery naphtha >50% of
More informationHEAT RECOVERY OPTIONS FOR DRYERS AND OXIDIZERS
HEAT RECOVERY OPTIONS FOR DRYERS AND OXIDIZERS William K. Scullion, Application Engineering Leader, MEGTEC Systems, De Pere, WI Introduction Competitive pressures continuously motivate us to examine our
More information12 November 2008 *** I:\CIRC\MEPC\01\642.DOC INTERNATIONAL MARITIME ORGANIZATION 4 ALBERT EMBANKMENT LONDON SE1 7SR
INTERNATIONAL MARITIME ORGANIZATION 4 ALBERT EMBANKMENT LONDON SE1 7SR Telephone: 020 7735 7611 Fax: 020 7587 3210 IMO E Ref. T5/1.01 MEPC.1/Circ.642 12 November 2008 2008 REVISED GUIDELINES FOR SYSTEMS
More information