haracterized ontrol Valves (V) eatures and enefi ts QUL PRNTG VLV HRTRISTI TURS Patented Technology NIT O TH LIMO HRTRIZING IS qual percentage flow characteristic. xcellent control stability assured with the characterizing disc. v values equal to v values of globe valves the same size. The need for multiple pipe reduction is usually eliminated. etter control prevents hunting of the control loop, increasing life span of actuator and valve. Thermal isolating adapter between flange and actuator. asy direct coupling of actuator with a single screw. Perpendicular mounting flange and square drive head eliminate lateral forces on the stem. low-out proof stem with thrust-bearing Teflon disc and double O-ring design for long service life.* Non-corroding chrome-plated brass or stainless ball. In order to ensure good stability of control, it is essential for a control valve to have an equal percentage characteristic. This type of characteristic produces a linear variation in thermal output according to the amount of opening of the valve (also known as the system characteristic). Under normal testing conditions a conventional ball valve exhibits an S-shaped characteristic. When it is installed in a real system, however, this characteristic is seriously deformed because, compared with its nominal size, a ball valve possesses an extremely high flow coefficient. Whether used with or without pipe reducers or a reduced bore, they do not normally allow stable regulation of the thermal capacity. elimo s unique haracterized ontrol Valve (V) is very different. special characterizing disc inside the valve gives it an equal percentage characteristic which is comparable with that of a globe valve of the same nominal size. The flow (the v value) is reduced to the required value by a combination of the hole in the ball and the shaped aperture in the disc. The increase in flow as the valve is opened is very slow and controlled. This produces better part-load behavior and improved stability of control while also optimizing energy consumption. Vent holes reduce condensation build-up. orged brass valve body no pin-hole leaks. haracterizing disc made of Tefzel known for excellent strength and chemical resistance. Teflon seats with O-rings provide constant seating force against the ball and reduce torque requirement. ctuator can be mounted in four different positions. * esigned for service life of over 100,000 full cycles. Teflon and Tefzel are both registered trademarks of upont. 800-543-9038 US 866-805-7089 N 03-791-8396 LTIN MRI 1
eature / enefits haracterized ontrol Valves (V) OORINT MOTORIZ OPRTION The optimum functionality of the elimo V is assured by properly coordinating its actuation with MT. Specially developed rotary actuators provide the necessary precision for modulating, floatingpoint, and on/off methods of control. ll Vs are supplied with the appropriate rotary actuator to provide the close-off and operation desired. OPTIMIZ OR ONTROL The elimo V marries known technology with an innovative development the unique characterizing disc. The marriage of V and MT technologies has produced a range of valuable features which surpass the capabilities of globe valves at a very attractive price level: n equal-percentage valve characteristic Unlike a globe valve, no sudden change in inlet flow upon opening xcellent stability of control v values comparable with those of globe valves of the same size or larger Higher close-off ratings than standard globe valves 100% tight shut-off on two-way valves means NO leak-by unlike globe valves that have NSI IV shutoff (leakage rate of 0.01% of the v rating) Three-way valve can be piped in mixing or diverting application low haracteristics of onventional all Valves versus LIMO HRTRIZ ONTROL VLVS Stable control is hard to achieve esirable valve authority is not achieved Series Two-way ½ to 3 3 Series Three-way ½ to Mixing*/iverting 6 Series Two-way langed ½ to 6 Service: v Range 0.3-40 Material: ontrol: hilled/hot water, 60% glycol Stainless trim or rass trim On/Off, loating, -10 V Multi-unction Technology Spring Return or Non-Spring Return Mixing* (Not for use in change over applications) esirable qual Percent low and resulting heat output is achieved with linear results
Sizing/Selection haracterized ontrol Valves (V) -Way Valve low Rate for Water pplications (Gallons Per Minute, GPM) v Maximum Rating Inches N mm -Way V Pressure rop cross the Valve 1 psi psi 3 psi 4 psi 5 psi 6 psi 7 psi 8 psi 9 psi 10 psi 0.3 ½ 15 07() 0.3 0.4 0.5 0.6 0.7 0.7 0.8 0.8 0.9 0.9 0.46 ½ 15 08() 0.5 0.7 0.8 0.9 1.0 1.1 1. 1.3 1.4 1.5 0.8 ½ 15 09() 0.8 1.1 1.4 1.6 1.8.0.1.3.4.5 1. ½ 15 10() 1. 1.7.1.4.8.9 3. 3.4 3.6 3.8 1.9 ½ 15 11() 1.9.7 3.3 3.8 4. 4.7 5.0 5.4 5.7 6.0 3 ½ 15 1() 3.0 4. 5. 6.0 6.8 7.3 7.9 8.5 9.0 9.5 4.7 ½ 15 13() 4.7 6.6 8.1 9.4 11 1 1 13 14 15 7.4 ½ 15 14() 7.4 10 13 15 17 18 0 1 3 10 ½ 15 15()* 10 14 17 0 4 6 8 30 3 16 ½ 15 16()* 14 0 4 8 31 34 37 40 4 44 4.7 ¾ 0 17() 4.7 6.6 8.1 9.4 11 1 1 13 14 15 7.4 ¾ 0 18() 7.4 10 13 15 17 18 0 1 3 10 ¾ 0 19() 10 14 17 0 4 6 8 30 3 14 ¾ 0 0()* 14 0 4 8 31 34 37 40 4 44 4 ¾ 0 1()* 4 34 4 48 54 59 63 68 7 76 7.4 1 5 7.4 10 13 15 17 18 0 1 3 10 1 5 3 10 14 17 0 4 6 8 30 3 19 1 5 4 19 7 33 38 4 47 50 54 57 60 30 1 5 5* 30 4 5 60 67 73 79 85 90 95 10 1¼ 3 9 10 14 17 0 4 6 8 30 3 19 1¼ 3 30* 19 7 33 38 4 47 50 54 57 60 5 1¼ 3 31 5 35 43 50 56 61 66 71 75 79 37 1¼ 3 3* 37 5 64 74 83 91 98 105 111 117 19 1½ 40 38 19 7 33 38 4 47 50 54 57 60 9 1½ 40 39 9 41 50 58 65 71 77 8 87 9 37 1½ 40 40* 37 5 64 74 83 91 98 105 111 117 9 50 48 9 41 50 58 65 71 77 8 87 9 46 50 49 46 65 80 9 103 113 1 130 138 145 57 50 50* 57 81 99 114 17 140 151 161 171 180 65 50 51 65 9 113 130 145 159 170 194 195 06 85 50 5 85 10 147 170 190 08 5 40 55 69 10 50 53 10 170 08 40 68 94 318 339 360 380 40 50 54* 40 339 416 480 537 588 635 679 70 759 60 ½ 65 61 60 85 104 10 134 147 159 170 180 190 75 ½ 65 6 75 106 130 150 168 194 198 1 5 37 110 ½ 65 63 110 156 191 0 46 69 91 311 330 348 150 ½ 65 64 150 1 60 300 335 367 397 44 450 474 10 ½ 65 65* 10 97 364 40 470 514 556 594 630 664 70 3 80 77 70 99 11 140 157 17 185 198 10 1 130 3 80 78 130 194 5 60 90 318 344 368 390 411 170 3 80 80* 170 40 94 340 380 416 450 481 510 538 70 ½ 65 650S-070 70 99 11 140 157 171 185 198 10 1 110 ½ 65 650S-110 110 156 191 0 44 66 8 96 31 30 110 3 80 6300S-110 110 156 191 0 44 66 8 96 31 30 186 4" 100 6400S-186 186 63 3 37 416 456 49 56 558 588 90 5" 15 6500S-90 90 410 50 580 648 710 767 80 870 917 400 6" 150 6600S-400 400 566 693 800 894 980 1058 1131 100 165 GPM = v x Δp *Models with no characterizing disc. The influence of the pipe geometry due to reduced flow is negligible for all valves 57 v and below with characterizing discs. 800-543-9038 US 866-805-7089 N 03-791-8396 LTIN MRI 3
Sizing/Selection haracterized ontrol Valves (V) 3-Way Valve low Rate for Water pplications (Gallons Per Minute, GPM) v Maximum Rating Inches N mm 3-Way V Pressure rop cross the Valve 1 psi psi 3 psi 4 psi 5 psi 6 psi 7 psi 8 psi 9 psi 10 psi 0.3 ½ 15 307() 0.3 0.4 0.5 0.6 0.7 0.7 0.8 0.8 0.9 0.9 0.46 ½ 15 308() 0.5 0.7 0.8 0.9 1.0 1.1 1. 1.3 1.4 1.5 0.8 ½ 15 309() 0.8 1.1 1.4 1.6 1.8.0.1.3.4.5 1. ½ 15 310() 1. 1.7.1.4.8.9 3. 3.4 3.6 3.8 1.9 ½ 15 311() 1.9.7 3.3 3.8 4. 4.7 5.0 5.4 5.7 6.0 3 ½ 15 31() 3.0 4. 5. 6.0 6.8 7.3 7.9 8.5 9.0 9.5 4.7 ½ 15 313() 4.7 6.6 8.1 9.4 11 1 1 13 14 15 10 ½ 15 315()* 10 14 17 0 4 6 8 30 3 16 ½ 15 316()* 14 0 4 8 31 34 37 40 4 44 4.7 ¾ 0 317() 4.7 6.6 8.1 9.4 11 1 1 13 14 15 7.4 ¾ 0 318() 7.4 10 13 15 17 18 0 1 3 14 ¾ 0 30()* 14 0 4 8 31 34 37 40 4 44 4 ¾ 0 31()* 4 34 4 48 54 59 63 68 7 76 7.4 1 5 7.4 10 13 15 17 18 0 1 3 10 1 5 3 10 14 17 0 4 6 8 30 3 30 1 5 35* 30 4 5 60 67 73 79 85 90 95 10 1¼ 3 39 10 14 17 0 5 7 8 30 3 19 1¼ 3 330 19 7 33 38 43 47 50 54 57 60 5 1¼ 3 331 5 35 43 50 56 61 66 71 75 79 19 1½ 40 338 19 7 33 38 43 47 50 54 57 60 9 1½ 40 339 9 41 50 58 65 71 77 8 87 9 37 1½ 40 340 37 5 64 74 83 91 98 105 111 117 46 1½ 40 341 46 65 80 9 103 113 1 130 138 146 9 50 347 9 41 50 58 65 71 77 8 87 9 37 50 348 37 5 64 74 83 91 98 105 111 117 46 50 349 46 65 80 9 103 113 1 130 138 146 57 50 350 57 81 99 114 18 140 151 161 171 180 68 50 351 68 96 118 136 15 167 180 19 04 15 83 50 35 83 117 144 166 186 04 0 35 49 63 GPM = v x Δp * = Models with no characterizing disc. The influence of the pipe geometry due to reduced flow is negligible for all valves 83 v and below with characterizing discs. 4 800-543-9038 US 866-805-7089 N 03-791-8396 LTIN MRI
Set-up and Wiring Instructions haracterized ontrol Valves (V) ST-UP TR4-3-T US TR4-3 US On/Off or loating Point ctuators Power to pin will drive valve W. Power to pin 3 will drive valve W. -WY VLV SPIY UPON ORRING Power to pin will drive valve W. Power to pin 3 will drive valve W. 3-WY VLV SPIY UPON ORRING NON-SPRING RTURN Stays in Last Position TR4-SR-T US TR4-SR US Proportional Type ctuators LR4 (-3), MT, SR LRX4 (-3), MT, SR R4 (-3), MT, SR RX4 (-3), MT, SR loating Point or Proportional Type ctuators N: losed to, will open as voltage increases. Power to pin will drive valve W. Power to pin 3 will drive valve W. The above will function when the directional switch is in the 1 position, to reverse select the 0 position. NO: Open to, will close as voltage increases. (an be chosen with switch inside terminal block of actuator.) NO: Open to, will close as voltage increases or power applied. (an be chosen with W/W switch.) N: losed to, will open as voltage increases. Power to pin will drive valve W. Power to pin 3 will drive valve W. The above will function when the directional switch is in the 1 position, to reverse select the 0 position. NO: Open to, will close as voltage increases. (an be chosen with switch inside terminal block of actuator.) NO: Open to, will close as voltage increases or power applied. (an be chosen with W/W switch.) TR4 L4 US R4 NO/O Valve: Open to will drive closed. Spring ction: Will spring open to upon power loss. N/ Valve: losed to will drive open. Spring ction: Will spring closed to upon power loss. NO/O Valve: Open to will drive closed. Spring ction: Will spring open to upon power loss. N/ Valve: losed to will drive open. Spring ction: Will spring closed to upon power loss. SPRING RTURN Note ail Position T (-3), MT, SR L (-3), MT, SR SR R, MT loating Point or Proportional Type ctuators GNRL WIRING INSTRUTIONS N/O Valve: losed to will drive open. Spring ction: Will spring open to upon power loss. WRNING The wiring technician must be trained and experienced with electronic circuits. isconnect power supply before attempting any wiring connections or changes. Make all connections in accordance with wiring diagrams and follow all applicable local and national codes. Provide disconnect and overload protection as required. Use copper, twisted pair, conductors only. If using electrical conduit, the attachment to the actuator must be made with flexible conduit. lways read the controller manufacturer's installation literature carefully before making any connections. ollow all instructions in this literature. If you have any questions, contact the controller manufacturer and/or elimo. Transformer(s) elimo actuators require a 4 V class transformer and draws a maximum of 10 V per actuator. The actuator enclosure cannot be opened N/ or NO/ Valve: losed to or Open to. (an be chosen with W/W switch.) Spring ction: Will spring closed to upon power loss. NO/O Valve: Open to Spring ction: Will spring open to upon power loss. (NO action can be chosen with W/W switch.) N/O Valve: losed to will drive open Spring ction: Will spring open to upon power loss. N/ or NO/ Valve: losed to or Open to. (an be chosen with W/W switch.) Spring ction: Will spring closed to upon power loss. NO/O Valve: Open to Spring ction: Will spring open to upon power loss. (NO action can be chosen with W/W switch.) in the field, there are no parts or components to be replaced or repaired. M directive: 89/336/ Software class : Mode of operation type 1 Low voltage directive: 73/3/ UTION It is good practice to power electronic or digital controllers from a separate power transformer than that used for actuators or other end devices. The power supply design in our actuators and other end devices use half wave rectification. Some controllers use full wave rectification. When these two different types of power supplies are connected to the same power transformer and the commons are connected together, a short circuit is created across one of the diodes in the full wave power supply, damaging the controller. Only use a single power transformer to power the controller and actuator if you know the controller power supply uses half wave rectification. 800-543-9038 US 866-805-7089 N 03-791-8396 LTIN MRI 5
low, Operation and Installation haracterized ontrol Valves (V) LOW PTTRNS -way haracterized ontrol Valves (elimo Series) (elimo 6 Series) low irection Two-way valves should be installed with the disc upstream. Upstream ownstream 3-way haracterized ontrol Valves MIXING (Not for use in change over applications (elimo 3 Series) IVRTING The -port must be piped to the coil to maintain proper control. INORRT PIPING The -port must be piped to the coil to maintain proper control. Three-Wa y Mixing Valve Piping iagra m ( Inputs, 1 Output) Return oil Supply Three-Way iver ting Valve Piping iagram (1 Input, Outputs) Return oil Supply Note Valve Porting! The -port must be piped to the coil! Not the -port! low is not possible from to. If -port is not piped as the common port, the valve must be re-piped. It is good practice to install a balancing valve in the bypass line. These valves are intended for closed loop systems. o not install in an open loop system or in an application that is open to atmospheric pressure. OPRTION/INSTLLTION ORRT PIPING -way valves should be installed with the disc upstream. If installed with disc downstream, flow curve will be deeper. If installed backwards it is NOT necessary to remove and change. No damage or control problems will occur. 3-WY VLVS MUST PIP ORRTLY. They can be mixing or diverting. Mixing is the preferred piping arrangement. iverting* (Not for use in change over applications) The LIMO haracterized ontrol Valve is a ONTROL valve, not a manual valve adapted for actuation. The control port is the -port. It is similar to the globe valve in that the middle port is the or bypass port. The common port is on the main opposite the -port. These diagrams are for typical applications only. onsult engineering specification and drawings for particular circumstances. RU -PORT LOW Note: The -port flow of the 3-way V is lower than that of the -port. In most applications this is beneficial since the reduced flow compensates for the inexistent pressure drop across the coil in the bypass mode. Therefore, proper sizing is important to avoid flow noise in particular when the system is designed with constant speed pumps. Please refer to our valve sizing and selection guidelines. The flow velocity in the pipe upstream and downstream of the valve should be considered as well. The typical HV design maximum flow is 4 to 8 ft/s to avoid noise issues. lso, the pipe reduction factor must be considered and can be found on pages 3 and 4. Pipe reducers decrease the v value of a valve and consequently increase the pressure drop across the valve, a situation that could lead to noise or a lower than designed flow. iverting* (Not for use in change over applications) 6 800-543-9038 US 866-805-7089 N 03-791-8396 LTIN MRI
Nomenclature haracterized ontrol Valve (V) 09 LRX 4 -MT Valve = -way 3 = 3-way 6 = -way langed Valve Size 07-80 = ½ -3 Trim Material = rass lank = Stainless Steel Trim ctuator Type Non-Spring Return TR LR LRX R RX LRQ... NRQ... Spring Return TR L R... lectronic ail-safe GK... Power Supply 4 = 4 V/ 10 = 10 V* 30 = 30 V ontrol lank = On/Off, loating -3 = loating Point -SR = -10 V -MT = Multi-unction Technology -MT95 = 0-135 Ω -T = Terminal Strip -S = uilt-in uxiliary Switch N4 = NM 4X, UL Type 4X, IP 66/67 nclosure ORRING XMPL 1 hoose the valve actuator combination. 09+LRX4-MT Specify preference or confi guration. Non-Spring Models NO = Normally Open N = Normally losed Spring Return Models NO/O = Normally Open/ail Open NO/ = Normally Open/ail losed N/O = Normally losed/ail Open N/ = Normally losed/ail losed See settings Refers to valve ports to. 3 Set-Up +NO or MT orders only - select programming code +Tagging (if needed) P-10001 (01) P-100xx (xx) ontrol voltage applications P-00xx (Wxx) Pulse width modulation applications P-300xx (xx) loating Point applications P-400xx (Jxx) On/Off applications X-XXXXX reate custom MT confi guration code X-XXXXX reate custom MT confi guration in the fi eld with MT-actuator P software 4 oes order require tagging? Tagging: Valves may be tagged per customer specification. xample: HU-1 U- 5 omplete Ordering xample: 09+LRX4-MT+NO+01 *T, LR and R Series has 100 to 40 V nominal power supply. 800-543-9038 US 866-805-7089 N 03-791-8396 LTIN MRI 7
8 This Page Intentionally Left lank
Series, -Way, haracterized ontrol Valve hrome Plated rass all and rass Stem pplication This valve is typically used in air handling units on heating or cooling coils, and fan coil unit heating or cooling coils. Some other common applications include Unit Ventilators, VV box re-heat coils and bypass loops. This valve is suitable for use in a hydronic system with variable fl ow. Technical ata Service chilled or hot water, 60% glycol low characteristic -port equal percentage ontrollable low Range 75 Sizes ½, ¾ Type of end fi tting NPT female ends Materials: ody forged brass, nickel plated all chrome plated brass Stem nickel plated brass Seats PT haracterizing disc Tefzel Packing PM O-rings, lubricated ody pressure rating 600 psi Media temp. range 0 to 50 [-18 to 10 ] lose off pressure 00 psi Maximum differential 50 psi for typical applications pressure (ΔP) Leakage 0% for to xternal leakage according to N 166-1:003 v rating -port: see product chart for values Tefzel is a registered trademark of upont Valve Nominal Size Type Suitable ctuators v Inches N [mm] -way NPT Non-Spring Spring 0.3 ½ 15 07 0.46 ½ 15 08 0.8 ½ 15 09 1. ½ 15 10 1.9 ½ 15 11 3 ½ 15 1 4.7 ½ 15 13 7.4 ½ 15 14 10 ½ 15 15 16 ½ 15 16 4.7 ¾ 0 17 7.4 ¾ 0 18 10 ¾ 0 19 14 ¾ 0 0 4 ¾ 0 1* *Models without characterizing disc TR Series LR Series T Series L Series imensions Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 07-11 ½ 15.38 [60.8] 1.39 [35.] 1-16 ½ 15.38 [60.8] 1.78 [45.] 17-1 ¾ 0.73 [69.3] 1.87 [47.4] low Patterns WayValve-07-0 9
3 Series, 3-Way, haracterized ontrol Valve hrome Plated rass all and rass Stem pplication This valve is typically used in air handling units on heating or cooling coils, and fan coil unit heating or cooling coils. Some other common applications include Unit Ventilators, VV box re-heat coils and bypass loops. This valve is suitable for use in a hydronic system with variable or constant flow. * (Not for use in change over applications) Technical ata Service chilled or hot water, 60% glycol low characteristic -port equal percentage -port modifi ed for constant common port fl ow ontrollable low Range 75 Sizes ½, ¾ Type of end fi tting NPT female ends Materials: ody forged brass, nickel plated all chrome plated brass Stem nickel plated brass Seats PT haracterizing disc Tefzel Packing PM O-rings, lubricated ody pressure rating 600 psi Media temp. range 0 to 50 [-18 to 10 ] lose off pressure 00 psi Maximum differential 50 psi for typical applications pressure (ΔP) Leakage 0% for to <.0% for to xternal leakage according to N 166-1:003 v rating -port: see product chart for values -port: 70% of to v Tefzel is a registered trademark of upont imensions Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 307-311 ½ 15.41 [61.1] 1.39 [35.] 1.0 [30.6] 31-316 ½ 15.38 [60.4] 1.78 [45.] 1.9 [3.8] 317-31 ¾ 0.73 [69.3] 1.87 [47.4] 1.47 [37.3] 3WayValve-307-30 Valve Nominal Size Type Suitable ctuators v Inches N [mm] 3-way NPT Non-Spring Spring 0.3 ½ 15 307 0.46 ½ 15 308 0.8 ½ 15 309 1. ½ 15 310 1.9 ½ 15 311 3 ½ 15 31 4.7 ½ 15 313 10 ½ 15 315 16 ½ 15 316 4.7 ¾ 0 317 7.4 ¾ 0 318 14 ¾ 0 30 4 ¾ 0 31 *Models without characterizing disc TR Series LR Series T Series L Series low Patterns Port must be piped to the bypass leg. 10
Series, -Way, haracterized ontrol Valve Stainless Steel all and Stem pplication This valve is typically used in air handling units on heating or cooling coils, and fan coil unit heating or cooling coils. Some other common applications include Unit Ventilators, VV box re-heat coils and bypass loops. This valve is suitable for use in a hydronic system with variable fl ow. Technical ata Service chilled or hot water, 60% glycol low characteristic -port equal percentage ontrollable low Range 75 Sizes ½, ¾, 1, 1¼, 1½,, ½, 3 Type of end fi tting NPT female ends Materials: ody forged brass, nickel plated all stainless steel Stem stainless steel Seats PT haracterizing disc Tefzel Packing PM O-rings, lubricated ody pressure rating 600 psi ½ - 1¼ (30) 400 psi 1¼ (31) - 3 Media temp. range 0 to 50 [-18 to 10 ] lose off pressure 00 psi ½ - (50) 100 psi (51) - 3 Maximum differential 50 psi for typical applications pressure (ΔP) Leakage 0% for to xternal leakage according to N 166-1:003 v rating -port: see product chart for values Tefzel is a registered trademark of upont imensions Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 07-11 ½ 15.41 [61.1] 1.39 [35.] 1-16 ½ 15.38 [60.4] 1.78 [45.] 17-1 ¾ 0.73 [69.3] 1.87 [47.4] -5 1 5 3.09 [78.4] 1.87 [47.4] 9-30 1¼ 3 3.7 [94.6] 1.87 [47.4] 31-3 1¼ 3 3.7 [94.6].04 [51.9] 38-40 1½ 40 3.88 [98.5].04 [51.9] 48-50 50 4.1 [107.0].7 [57.7] 51-54 50 4.93 [15.].73 [69.5] 61-65 ½ 65 5.55 [140.9].73 [69.5] 77-80 3 80 5.8 [147.9].73 [69.5] WayValve-07-0 Valve Nominal Size Type Suitable ctuators v Inches N [mm] -Way NPT Non-Spring Spring 0.3 ½ 15 07 0.46 ½ 15 08 0.8 ½ 15 09 1. ½ 15 10 1.9 ½ 15 11 3 ½ 15 1 4.7 ½ 15 13 7.4 ½ 15 14 10 ½ 15 15 16 ½ 15 16 4.7 ¾ 0 17 7.4 ¾ 0 18 10 ¾ 0 19 14 ¾ 0 0 4 ¾ 0 1* 7.4 1 5 10 1 5 3 19 1 5 4 30 1 5 5* 10 1¼ 3 9 19 1¼ 3 30* 5 1¼ 3 31 37 1¼ 3 3* 19 1½ 40 38 9 1½ 40 39 37 1½ 40 40* 9 50 48 46 50 49 57 50 50* 65 50 51 85 50 5 10 50 53 40 50 54* 60 ½ 65 61 75 ½ 65 6 110 ½ 65 63 150 ½ 65 64 10 ½ 65 65* 70 3 80 77 130 3 80 78 170 3 80 80* *Models without characterizing disc low Patterns TR Series LR Series R Series NR...N4 Series R...N4 Series T Series L Series Series 11
3 Series, Three Way, haracterized ontrol Valve Stainless Steel all and Stem pplication This valve is typically used in air handling units on heating or cooling coils, and fan coil unit heating or cooling coils. Some other common applications include Unit Ventilators, VV box re-heat coils and bypass loops. This valve is suitable for use in a hydronic system with variable or constant flow. * (Not for use in change over applications) Technical ata Service chilled or hot water, 60% glycol low characteristic -port equal percentage -port modifi ed for constant common port fl ow ontrollable low Range 75 Sizes ½, ¾, 1, 1¼, 1½, Type of end fi tting NPT female ends Materials: ody forged brass, nickel plated all stainless steel Stem stainless steel Seats PT haracterizing disc Tefzel Packing PM O-rings, lubricated ody pressure rating 600 psi ½ - 1 400 psi 1¼ - Media temp. range 0 to 50 [-18 to 10 ] lose off pressure 00 psi ½ - Maximum differential 50 psi for typical applications pressure (ΔP) Leakage 0% for to <.0% for to xternal leakage according to N 166-1:003 v rating -port: see product chart for values -port: 70% of to v Tefzel is a registered trademark of upont imensions Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 307-311 ½ 15.41 [61.1] 1.39 [35.] 1.0 [30.6] 31-316 ½ 15.38 [60.4] 1.78 [45.] 1.9 [3.8] 317-31 ¾ 0.73 [69.3] 1.87 [47.4] 1.47 [37.3] 3-35 1 5 3.09 [78.4] 1.87 [47.4] 1.59 [40.3] 39-331 1¼ 3 3.96 [100.6].7 [57.7].14 [54.3] 338-341 1½ 40 4.39 [111.6].51 [63.7].40 [61.1] 347-35 50 4.90 [14.5].73 [69.5].74 [69.7] 3WayValve-307-30 Valve Nominal Size Type Suitable ctuators v Inches N [mm] 3-Way NPT Non-Spring Spring 0.3 ½ 15 307 0.46 ½ 15 308 0.8 ½ 15 309 1. ½ 15 310 1.9 ½ 15 311 3 ½ 15 31 4.7 ½ 15 313 10 ½ 15 315 16 ½ 15 316 4.7 ¾ 0 317 7.4 ¾ 0 318 14 ¾ 0 30 4 ¾ 0 31 7.4 1 5 3 10 1 5 33 30 1 5 35* 10 1¼ 3 39 19 1¼ 3 330 5 1¼ 3 331 19 1½ 40 338 9 1½ 40 339 37 1½ 40 340 46 1½ 40 341 9 50 347 37 50 348 46 50 349 57 50 350 68 50 351 83 50 35 *Models without characterizing disc low Patterns Port must be piped to the bypass leg. TR Series LR Series R Series NR...N4 Series R...N4 Series T Series L Series Series 1
6 Series, Two Way, haracterized ontrol Valve Stainless Steel all and Stem pplication This valve is typically used in air handling units on heating or cooling coils, and fan coil unit heating or cooling coils. Some other common applications include Unit Ventilators, VV box re-heat coils and bypass loops. This valve is suitable for use in a hydronic system with variable or constant fl ow. Technical ata Service chilled or hot water, 60% glycol low characteristic -port equal percentage ontrollable low Range 75 Sizes ½, 3, 4, 5, 6 Type of end fi tting pattern to mate with NSI 15 fl ange Materials: ody cast iron - GG5 all stainless steel Stem stainless steel Seats PT haracterizing disc stainless steel Packing PM O rings, lubricated ody pressure rating according to NSI 15, standard class Media temp. range 0 to 48 [-18 to +10 ] lose off pressure 100 psi Maximum differential 50 psi pressure (ΔP) Leakage 0% for to v rating -port: see product chart for values Valve Nominal Size Type Suitable ctuators v Inches N [mm] -way lange Non-Spring Spring 70 ½" 65 650S-070 110 ½" 65 650S-110 110 3" 80 6300S-110 186 4" 100 6400S-186 90 5" 15 6500S-90 400 6" 150 6600S-400 low Pattern R Series GR Series -way 650 to 6600 haracterized ontrol Valves R Series low irection lectronic ail-safe GKR Series imensions Valve ody Nominal Pipe Size 650S ½" [65] Top lange esign lange iameter ace-to-ace Length Height 7.50" [190.5] 5.50" [139.7] 8.10" [05.4] 6300S 3" [80] 8.00" [03.] 6.60" [167.6] 8.40" [13.1] 6400S 4" [100] 05 9.00" [8.6] 8.30" [10.8] 9.30" [35.9] 6500S 5" [15] 10.00" [54.0] 10.30" [61.6] 10.50" [66.4] 6600S 6" [150] 11.00" [79.4] 1.50" [317.5] 11.70" [96.9] Upstream ownstream olt ircle iameter lange Thickness Minimum olt Hole iameter Number of olt Holes 5.50" [139.7] 0.75" [19.05] 0.75" [19.05] 4 6.00" [15.4] 0.75" [19.05] 0.75" [19.05] 4 7.50" [190.5] 0.94" [3.88] 0.75" [19.05] 8 8.50" [15.9] 0.94" [3.88] 0.88" [.35] 8 9.50" [41.3] 1.00" [5.40] 0.88" [.35] 8 NOTS: 1) lange bolt pattern matches NSI class 15 fl anges (not NSI/SM rated) ) Maximum allowable working pressure: 100 PSIG 3) It is not recommended to connect raised-face fl anges to flat-faced fl anges 13
haracterized ontrol Valve Product Range Overview.., 3.., -way, 3-way, Stainless Steel all and Stem Valve Nominal Size Type Suitable ctuators v Inches N [mm] -way NPT 3-way NPT Non-Spring Return Spring Return NM 4X 0.3 ½ 15 07() 307() 0.46 ½ 15 08() 308() 0.8 ½ 15 09() 309() 1. ½ 15 10() 310() V 1.9 ½ 15 11() 311() 3 ½ 15 1() 31() 4.7 ½ 15 13() 313() 7.4 ½ 15 14() 10 ½ 15 15() 315() 14 ½ 15 16()* 316()* 4.7 ¾ 0 17() 317() 7.4 ¾ 0 18() 318() 10 ¾ 0 19() 14 ¾ 0 0()* 14 ¾ 0 30() 4 ¾ 0 1()* 31()* 7.4 1 5 3 10 1 5 3 33 19 1 5 4 TR Series LR Series TR Series L Series NR Series qual Percentage haracteristic Mode of Operation The haracterized ontrol Valve is operated by a rotary actuator. The actuators are controlled by a standard voltage for on/off control or a proportional signal or 3-point control system which move the ball of the valve to the position dictated by the control system. Product eatures The equal-percentage characteristic of the flow is ensured by the integral characterizing disc. This characteristic provides linear heating or cooling output from the coil improving energy efficiency and comfort. ctuator Specifications ontrol type on/off, floating point, -10 V, multi-function technology (MT) Manual override TR, LR, R, NR, R series lectrical connection 3 ft [1m] cable with ½ conduit fitting or covered screw terminal strip 30 1 5 5* 35* 10 1¼ 3 9 19 1¼ 3 30* 10 1¼ 3 39 19 1¼ 3 330 5 1¼ 3 31 331 37 1¼ 40 3* 19 1½ 40 38 338 9 1½ 40 39 339 37 1½ 40 40* 340 46 1½ 40 341 9 50 48 347 37 50 348 46 50 49 349 57 50 50* 350 65 50 51 68 50 351 83 50 35 85 50 5 10 50 53 40 50 54* R Series R Series R Series Valve Specifications Service chilled or hot water, 60% glycol low characteristic -port equal percentage -port modifi ed for constant common port fl ow ontrollable fl ow range 75 Sizes ½ - Type of end fi tting NPT female ends Materials ody forged brass, nickel plated all stainless steel or chrome Stem stainless steel or chrome Seats Tefl on PT haracterizing disc ½ - 1 ½ (-way) Tefzel ½ -1 (3-way) Tefzel (-way) stainless steel 1¼ - (3-way) stainless steel Packing PM O-rings, lubricated Media temp range 0 to 50 [-18 to 10 ] ody pressure rating ½ - 1¼ (30) 600 psi 1¼ (31) - (51) 400 psi lose-off pressure 00 psi Maximum differential pressure (ΔP) 50 psi Leakage 0% for to <.0% for to v rating/gpm port: see product chart above for values port: 70% of to v Tefzel and Tefl on are registered trademarks of upont * Models without characterizing discs. () Models with chrome plated brass ball and brass stem * 3-Way Valves not for use in change over applications 14
haracterized ontrol Valve Product Range Overview 6.., -way, Stainless Steel all and Stem Valve Nominal Size Type Suitable ctuators N -way v Inches [mm] NPT 70 ½ 65 650S-070 110 ½ 65 650S-110 110 3 80 6300S-110 186 4 100 6400S-186 90 5 15 6500S-90 400 6 150 6600S-400 Non-Spring Return R GR Spring Return R lectronic ail-safe GKR V qual Percentage haracteristic pplications Water-side control of heating and cooling systems for HU supply, cooling towers and chillers. Mode of Operation The haracterized ontrol Valve is operated by a rotary actuator. The actuators are controlled by a standard voltage for on/off control or a proportional signal or 3-point control system which move the ball of the valve to the position dictated by the control system. Product eatures The equal-percentage characteristic of the flow is ensured by the integral characterizing disc. This characteristic provides linear heating or cooling output from the coil improving energy efficiency and comfort. ctuator Specifications ontrol type On/Off, loating Point, -10 V, Multi-unction Technology (MT) Manual override R, GR, R and GKR series lectrical connection 3 ft [1m] cable with ½ conduit fi tting or covered screw terminal strip Valve Specifications Service low characteristic ction chilled or hot water, 60% glycol -port equal percentage max 90 rotation Sizes ½, 3, 4, 5:, 6 Type of end fi tting Materials ody all Stem Seats haracterizing disc Packing ody pressure rating Media temp range lose-off pressure Maximum differential pressure (ΔP) Leakage NSI 15 fl ange pattern cast iron (painted) stainless steel stainless steel PT stainless steel PM O-rings, lubricated ccording to NSI 15, standard class 0 to 50 [-18 to +10 ] 100 psi 50 psi 0% for to 15
TR4-3 ctuators, On-Off, loating Point imensions with -Way Valve.50 [63.5] 3.5 [8.6] 1349.8 [71.6] Models TR4-3-T US TR4-3 US TR4-3/300 US TR4-3/500 US TR4-3-T US with 3 ft plenum rated cable TR4-3-T US with 10 ft plenum rated cable TR4-3-T US with 16 ft plenum rated cable Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 07()-11() ½ 15.41 [61.1] 1.39 [35.] 1()-15() ½ 15.38 [60.4] 1.78 [45.] 17()-1() ¾ 0.73 [69.3] 1.87 [47.4] Technical ata ontrol on/off, fl oating point Nominal voltage 4 V 50/60 Hz Nominal voltage range 19. 8.8 V Power consumption 1 W Transformer sizing 1V (class power source) lectrical connection screw terminals accessible after removal of small cover (3 ft, 10 ft, 16 ft cables optional) Input impedance 0.36 kω ngle of rotation 90 Position indication integrated into handle Manual override push down handle Running time 90 seconds @ 60 hz, 108 seconds @ 50 hz Humidity 5 to 95% non-condensing mbient temperature - to 1 (-30 to 50 ) Storage temperature -40 to 176 (-40 to 80 ) Housing NM 1/IP40 Housing rating UL94-5V() gency listing culus according to UL 60730-1/--14, N/ S 60730-1:0, according to 004/108/ and 006/95/ for line voltage and/or S versions Noise level max. 35 db () Quality standard ISO 9001 Rated impulse voltage 330V, ontrol pollution degree, Type of action 1 imensions with 3-Way Valve.50 [63.5].8 [71.6] 3.5 [8.6] Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 307()-311() ½ 15.41 [61.1] 1.39 [35.] 1.0 [30.6] 31()-315() ½ 15.38 [60.4] 1.78 [45.] 1.9 [3.8] 317()-31() ¾ 0.73 [69.3] 1.87 [47.4] 1.47 [37.3] 1350 16
TR4-3 ctuators, On-Off, loating Point Wiring iagrams NOT: TR4-3(-T) US cannot be wired in parallel with themselves or any other actuator. 3 The common connection from the actuator must be connected to the Hot connection of the controller. ctuators with plenum rated cable do not have numbers on wires; use color codes instead. 4 The actuator Hot must be connected to the control board Hot. WRNING Live lectrical omponents! uring installation, testing, servicing and troubleshooting of this product, it may be necessary to work with live electrical components. Have a qualified licensed electrician or other individual who has been properly trained in handling live electrical components perform these tasks. ailure to follow all electrical safety precautions when exposed to live electrical components could result in death or serious injury. loating ontrol W187 W186 On/Off ontrol You may not use one wire control. 17
TR4-SR ctuators, Proportional imensions with -Way Valve.50 [63.5] 3.5 [8.6] 1349.8 [71.6] Models TR4-SR-T US TR4-SR US TR4-SR/300 US TR4-SR/500 US TR4-SR-T US with 3 ft plenum rated cable TR4-SR-T US with 10 ft plenum rated cable TR4-SR-T US with 16 ft plenum rated cable Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 07()-11() ½ 15.41 [61.1] 1.39 [35.] 1()-15() ½ 15.38 [60.4] 1.78 [45.] 17()-1() ¾ 0.73 [69.3] 1.87 [47.4] Technical ata ontrol proportional Nominal voltage 4 V 50/60 Hz, 4 V Nominal voltage range 19. 8.8 V, 1.6 8.8 V Power consumption 0.5 W Transformer sizing 1V (class power source) lectrical connection screw terminals accessible after removal of small cover (3 ft, 10 ft, 16 ft cables optional) Input impedance 100 kω ngle of rotation 90 irection of rotation reversible with switch under cover Position indication integrated into handle Manual override push down handle Running time 90 seconds Humidity 5 to 95% non-condensing mbient temperature - to 1 (-30 to 50 ) Storage temperature -40 to 176 (-40 to 80 ) Housing NM 1/IP40 Housing rating UL94-5V() gency listing culus according to UL 60730-1/--14, N/ S 60730-1:0, according to 004/108/ and 006/95/ for line voltage and/or S versions Noise level max. 35 db () Quality standard ISO 9001 Rated impulse voltage 500V, ontrol pollution degree, Type of action 1 NOT: Response sensitivity is 75mV imensions with 3-Way Valve.50 [63.5].8 [71.6] 3.5 [8.6] Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 307()-311() ½ 15.41 [61.1] 1.39 [35.] 1.0 [30.6] 31()-315() ½ 15.38 [60.4] 1.78 [45.] 1.9 [3.8] 317()-31() ¾ 0.73 [69.3] 1.87 [47.4] 1.47 [37.3] 1350 18
TR4-SR ctuators, Proportional Wiring iagrams W190 ctuators with color coded wires are optional. Wire numbers are provided for reference. UTION quipment damage! ctuators may be connected in parallel. Power consumption and input impedance must be observed. 3 ctuators may also be powered by 4 V. WRNING Live lectrical omponents! uring installation, testing, servicing and troubleshooting of this product, it may be necessary to work with live electrical components. Have a qualified licensed electrician or other individual who has been properly trained in handling live electrical components perform these tasks. ailure to follow all electrical safety precautions when exposed to live electrical components could result in death or serious injury. to 10 V ontrol of TR4-SR(-T) US W191 4 to 0 m ontrol of TR4-SR(-T) US irect/reverse acting switch is under wiring cover. R = W with decrease in signal L = W with decrease in signal No feedback 19
LR...4-3 ctuators, On/Off, loating Point imensions with -Way Valve 1351 H1 H Models LR4-3-T LRX4-3-T w/terminal lock LR4-3 LRX4-3 w/3 ft. cable LR4-3-S LRX4-3-S w/built-in ux. Switch Technical ata ontrol Power supply Power consumption Transformer sizing lectrical connection LR4-3 LRX4-3 Overload protection Input impedance ngle of rotation irection of rotation Position indication Manual override Running time LR4-3 LRX4-3 on/off, fl oating point 4 V ± 0% 50/60 Hz 4 V ± 10% running 1.5 W holding 0. W V (class power source) ½ conduit connector 18 G, plenum rated cable 3 ft [1m] 3 ft [1m], 10 ft [3m], 16 ft [5m] electronic throughout 0 to 95 rotation 600 Ω 90, adjustable with mechanical stop reversible with protected handle external push button 90 seconds, constant independent of load 150, 95, 60, 45, 35 seconds, constant independent of load Humidity 5 to 95% RH, non-condensing (N 60730-1) mbient temperature - to 1 [-30 to 50 ] Storage temperature -40 to 176 [-40 to 80 ] Housing type NM /IP54 Housing material UL94-5V gency listings culus according to UL 60730-1/--14, N/ S 60730-1:0, according to 004/108/ and 006/95/ for line voltage and/or S versions Noise level less than 35 d () Quality standard ISO 9001 LR...4-3-T lectrical connection screw terminal (for 6 to 14 G wire) protected (NM, IP0) Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 07()-11() ½ 15 1.39 [35.] 1.39 [35.] 1()-15() ½ 15 1.78 [45.] 1.78 [45.] 17()-1() ¾ 0 1.87 [47.4] 1.87 [47.4] -5 1 5 1.87 [47.4] 1.87 [47.4] 9-31 1¼ 3 1.87 [47.4] 1.87 [47.4] imensions with 3-Way Valve H1 H Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 307()-311() ½ 15.06 [5.] 1.39 [35.] 1.0 [30.6] 31()-315() ½ 15.38 [60.4] 1.78 [45.] 1.9 [3.8] 317()-31() ¾ 0.73 [69.3] 1.87 [47.4] 1.47 [37.3] 3-35 1 5 3.09 [78.4] 1.87 [47.4] 1.59 [40.3] 135 LR...4-3-S uxiliary switch 1 SPT, 3 (0.5) @ 50 V, UL Listed, adjustable 0 to 100 Rated impulse voltage 800V, ontrol pollution degree 3, Type of action 1 (1. for -S models) 0
LR...4-3 ctuators, On/Off, loating Point Wiring iagrams 3 UTION quipment damage! ctuators may be connected in parallel. Power consumption and input impedance must be observed. ctuators are provided with color coded wires. Wire numbers are provided for reference. 4 ctuators may also be powered by 4 V. Meets culus or UL and S requirements without the need of an electrical ground connection. WRNING Live lectrical omponents! uring installation, testing, servicing and troubleshooting of this product, it may be necessary to work with live electrical components. Have a qualified licensed electrician or other individual who has been properly trained in handling live electrical components perform these tasks. ailure to follow all electrical safety precautions when exposed to live electrical components could result in death or serious injury. On/Off control W193-LR-08 W13-LR-08 loating Point or On/Off control uxiliary switch 1
LR...4-SR ctuators, Proportional imensions with -Way Valve 1351 H1 H Models LR4-SR-T LRX4-SR-T w/terminal lock LR4-SR LRX4-SR w/3ft. cable Technical ata Power supply 4 V ± 0% 50/60 Hz 4 V ± 10% Power consumption running 1.5 W holding 0.4 W Transformer sizing 3 V (class power source) lectrical connection ½ conduit connector 18 G, plenum rated cable LR4-SR LRX4-SR 3 ft [1m] 3 ft [1m], 10 ft [3m], 16 ft [5m] Overload protection electronic throughout 0 to 95 rotation Operating range Y to 10 V, 4 to 0 m eedback output U 1 to 10 V, max 0.5 m Input impedance 100 kω (0.1 m), 500 Ω ngle of rotation 90, adjustable with mechanical stop irection of rotation reversible with protected Position indication handle Manual override external push button Running time LR4-SR LRX4-SR constant independent of load 90 seconds 150, 95, 60, 45, 35 seconds Humidity 5 to 95% RH non-condensing (N 60730-1) mbient temperature - to 1 [-30 to 50 ] Storage temperature -40 to 176 [-40 to 80 ] Housing NM /IP54 Housing material UL94-5V gency listings culus according to UL 60730-1/--14, N/S 60730-1:0, according to 004/108/ and 006/95/ for line voltage and/or S versions Noise level <35 d() Quality standard ISO 9001 LR...4-SR-T lectrical connection screw terminal (for 6 to 14 G wire) protected (NM /IP0) Rated impulse voltage 800V, ontrol pollution degree 3, Type of action 1 (1. for -S models) Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 07()-11() ½ 15.41 [61.1] 1.39 [35.] 1()-15() ½ 15.38 [60.4] 1.78 [45.] 17()-1() ¾ 0.73 [69.3] 1.87 [47.4] -5 1 5 3.09 [78.4] 1.87 [47.4] 9-31 1¼ 3 3.7 [94.6] 1.87 [47.4] imensions with 3-Way Valve H1 H Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 307()-311() ½ 15.06 [5.] 1.39 [35.] 1.0 [30.6] 31()-315() ½ 15.38 [60.4] 1.78 [45.] 1.9 [3.8] 317()-31() ¾ 0.73 [69.3] 1.87 [47.4] 1.47 [37.3] 3-35 1 5 3.09 [78.4] 1.87 [47.4] 1.59 [40.3] 135
LR...4-SR ctuators, Proportional Wiring iagrams UTION quipment damage! ctuators may be connected in parallel. Power consumption and input impedance must be observed. 3 ctuators may also be powered by 4 V. W65-LR-08 5 Only connect common to neg. ( ) leg of control circuits. to 10 V control Meets culus or UL and S requirements without the need of an electrical ground connection. The ZG-R01 500 Ω resistor converts the 4 to 0 m control signal to to 10 V, up to actuators may be connected in parallel. W65-LR-08 WRNING Live lectrical omponents! uring installation, testing, servicing and troubleshooting of this product, it may be necessary to work with live electrical components. Have a qualified licensed electrician or other individual who has been properly trained in handling live electrical components perform these tasks. ailure to follow all electrical safety precautions when exposed to live electrical components could result in death or serious injury. 4 to 0 m control 3
LR...10-3 ctuators, On/Off, loating Point imensions with -Way Valve 1353 H1 H Models LR10-3 LRX10-3 Technical ata ontrol Power supply Power consumption Transformer sizing lectrical connection LR10-3 LRX10-3 Overload protection Input impedance ngle of rotation irection of rotation Position indication Manual override Running time LR10-3 LRX10-3 Humidity mbient temperature Storage temperature Housing Housing material gency listings On/Off, loating Point 100 to 40 V, 50/60 Hz (nominal) 85 to 65 V, 50/60 Hz (tolerance) running W holding 0.5 W 4 V (class power source) ½ conduit connector 18 G, plenum rated cable 3 ft [1m] 3 ft [1m], 10 ft [3m], 16 ft [5m] electronic throughout 0 to 95 rotation 600 Ω 90, adjustable with mechanical stop reversible with protected handle external push button 90 seconds, constant independent of load 150, 95, 60, 45, 35 seconds, constant independent of load 5 to 95% RH non-condensing (N 60730-1) - to 1 [-30 to 50 ] -40 to 176 [-40 to 80 ] NM /IP54 UL94-5V culus according to UL 60730-1/--14, N/S 60730-1:0, according to 004/108/ and 006/95/ for line voltage and/or S versions <35 d() Noise level Quality standard ISO 9001 Rated impulse voltage 4kV, ontrol pollution degree 3, Type of action 1 Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 07()-11() ½ 15.41 [61.1] 1.39 [35.] 1()-15() ½ 15.38 [60.4] 1.78 [45.] 17()-1() ¾ 0.73 [69.3] 1.87 [47.4] -5 1 5 3.09 [78.4] 1.87 [47.4] 9-30 1¼ 3 3.7 [94.6] 1.87 [47.4] imensions with 3-Way Valve H1 H Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 307()-311() ½ 15.06 [5.] 1.39 [35.] 1.0 [30.6] 31()-315() ½ 15.38 [60.4] 1.78 [45.] 1.9 [3.8] 317()-31() ¾ 0.73 [69.3] 1.87 [47.4] 1.47 [37.3] 3-35 1 5 3.09 [78.4] 1.87 [47.4] 1.59 [40.3] 1354 4
LR...10-3 ctuators, On/Off, loating Point Wiring iagrams W405 UTION quipment damage! ctuators may be connected in parallel. Power consumption and input impedance must be observed. Meets culus or UL and S requirements without the need of an electrical ground connection. WRNING Live lectrical omponents! uring installation, testing, servicing and troubleshooting of this product, it may be necessary to work with live electrical components. Have a qualified licensed electrician or other individual who has been properly trained in handling live electrical components perform these tasks. ailure to follow all electrical safety precautions when exposed to live electrical components could result in death or serious injury. On/Off W406 loating Point or On/Off control 5
LR...10-SR ctuators, Proportional imensions with -Way Valve 1353 H1 H Models LR10-SR LRX10-SR Technical ata Power supply Power consumption Transformer sizing lectrical connection LR10-SR LRX10-SR Overload protection Operating range Y eedback output U Input impedance ngle of rotation irection of rotation Position indication Manual override Running time LR10-SR LRX10-SR Humidity mbient temperature Storage temperature Housing Housing material gency listings 100 to 40 V, 50/60 Hz (nominal) 85 to 65 V, 50/60 Hz (tolerance) running.5 W holding 1 W 4.5 V (class power source) ½ conduit connector 18 G, plenum rated cable 3 ft [1m] 3 ft [1m], 10 ft [3m], 16 ft [5m] electronic throughout 0 to 95 rotation to 10 V, 4 to 0 m 1 to 10 V, max 0.5 m 100 kω (0.1 m), 500 Ω 90, adjustable with mechanical stop reversible with protected handle external push button constant independent of load 90 seconds 150, 95, 60, 45, 35 seconds 5 to 95% RH non-condensing (N 60730-1) - to 1 [-30 to 50 ] -40 to 176 [-40 to 80 ] NM /IP54 UL94-5V culus according to UL 60730-1/--14, N/S 60730-1:0, according to 004/108/ and 006/95/ for line voltage and/or S versions <35 d() Noise level Quality standard ISO 9001 Rated impulse voltage 4kV, ontrol pollution degree 3, Type of action 1 Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 07()-11() ½ 15.41 [61.1] 1.39 [35.] 1()-15() ½ 15.38 [60.4] 1.78 [45.] 17()-1() ¾ 0.73 [69.3] 1.87 [47.4] -5 1 5 3.09 [78.4] 1.87 [47.4] 9-30 1¼ 3 3.7 [94.6] 1.87 [47.4] imensions with 3-Way Valve H1 H Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 307()-311() ½ 15.41 [61.1] 1.39 [35.] 1.0 [30.6] 31()-315() ½ 15.38 [60.4] 1.78 [45.] 1.9 [3.8] 317()-31() ¾ 0.73 [69.3] 1.87 [47.4] 1.47 [37.3] 3-35 1 5 3.09 [78.4] 1.87 [47.4] 1.59 [40.3] 1354 6
LR...10-SR ctuators, Proportional Wiring iagrams 100 to 40 V 15 19 W365 UTION quipment damage! ctuators may be connected in parallel. Power consumption and input impedance must be observed. 6 Only connect common to neg. ( ) leg of control circuits. 7 500 Ω resistor converts the 4 to 0 m control signal to to 10 V. 15 LR(X) can be supplied with both 10 V and 30 V. 19 ll 10 V and 30 V actuators use appliance rated cables. N L1 H L 1 Neutral Hot + 6 1 ommon Hot + 7 8 ( ) ontrol Signal V/m (+) to 10 V ( ) eedback Signal (+) 3 Y Input, to 10V 5 U Output, to 10V 1 0 able Meets culus or UL and S requirements without the need of an electrical ground connection. WRNING Live lectrical omponents! uring installation, testing, servicing and troubleshooting of this product, it may be necessary to work with live electrical components. Have a qualified licensed electrician or other individual who has been properly trained in handling live electrical components perform these tasks. ailure to follow all electrical safety precautions when exposed to live electrical components could result in death or serious injury. able 1 LR...10-SR Proportional, 100 to 40V 7
LR...4-MT ctuators, Multi-unction Technology imensions with -Way Valve 1353 H1 H Models LRX4-MT Technical ata Power supply Power consumption Transformer sizing lectrical connection LRX4-MT Overload protection Operating range Y eedback output U Input impedance ngle of rotation irection of rotation Position indication Manual override Running time Humidity mbient temperature Storage temperature Housing Housing material gency listings lexible Version 4 V ± 0% 50/60 Hz 4 V ± 10% running W holding 1. W 6 V (class power source) ½ conduit connector 18 G, plenum rated cable 3 ft [1m], 10 ft [3m], 16 ft [5m] electronic throughout 0 to 95 rotation to 10 V (default) 4 to 0 m variable (V, PWM, fl oating point, on/off) to 10 V, 0.5m max V variable 100 kω (0.1 m), 500 Ω 1500 Ω (PWM, fl oating point, on/off) 90 electronically variable adjustable with mechanical stop reversible with protected handle external push button 150 seconds (default) Variable (35 to 150 secs) 5 to 95% RH non-condensing (N 60730-1) - to 1 [-30 to 50 ] -40 to 176 [-40 to 80 ] NM /IP54 UL94-5V culus according to UL 60730-1/--14, N/S 60730-1:0, according to 004/108/ and 006/95/ for line voltage and/or S versions <35 d() Noise level Quality standard ISO 9001 Rated impulse voltage 800V, ontrol pollution degree 3, Type of action 1 (1. for -S models) Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 07-11 ½ 15.41 [61.1] 1.39 [35.] 1-15 ½ 15.38 [60.4] 1.78 [45.] 17-1 ¾ 0.73 [69.3] 1.87 [47.4] -5 1 5 3.09 [78.4] 1.87 [47.4] 9-30 1¼ 3 3.7 [94.6] 1.87 [47.4] imensions with 3-Way Valve H1 H Valve Nominal Size imensions (Inches [mm]) Valve ody Inches N [mm] 307-311 ½ 15.41 [61.1] 1.39 [35.] 1.0 [30.6] 31-315 ½ 15.38 [60.4] 1.78 [45.] 1.9 [3.8] 317-31 ¾ 0.73 [69.3] 1.87 [47.4] 1.47 [37.3] 3-35 1 5 3.09 [78.4] 1.87 [47.4] 1.59 [40.3] 1354 8
LR...4-MT ctuators, Multi-unction Technology Wiring iagrams W538 UTION quipment damage! ctuators may be connected in parallel. Power consumption and input impedance must be observed. 3 ctuators may also be powered by 4 V. 4 6 8 9 Position feedback cannot be used with Triac sink controller. The actuator internal common reference is not compatible. ontrol signal may be pulsed from either the Hot (source) or the ommon (sink) 4 V line. ontact closures & also can be triacs. & should both be closed for triac source and open for triac sink. or triac sink the common connection from the actuator must be connected to the hot connection. On/Off control W538 The ZG-R01 500 Ω resistor converts the 4 to 0 m control signal to to 10 V, up to actuators may be connected in parallel. WRNING Live lectrical omponents! uring installation, testing, servicing and troubleshooting of this product, it may be necessary to work with live electrical components. Have a qualified licensed electrician or other individual who has been properly trained in handling live electrical components perform these tasks. ailure to follow all electrical safety precautions when exposed to live electrical components could result in death or serious injury. loating Point W538 V/4-0 m W538 PWM 9