Hydraulic Mining Excavator RH -E C engine, mm '", mm '", mm '", mm '", mm '", mm '", mm '",9 mm, mm 9'9", '", mm '" 9 mm '" B, mm '" QSK 9 engine, mm '", mm '", mm '", mm '", mm '", mm '", mm '",9 mm, mm 9'9", mm '", mm '" 9 mm '" B, mm '" RH -E General Data: Operating weight (with C engine) Face Shovel t sht Backhoe t sht Engine output SE J 99 Caterpillar C kw HP Cummins QSK 9-C kw HP Standard bucket capacity Face Shovel (SE :). m 9. yd Std. rock backhoe (SE :). m. yd M.E. backhoe (SE :). m 9. yd Features: TriPower shovel attachment Independent oil cooling system -circuit-hydraulic system Torque control in closed-loop swing circuit utomatic central lubrication system Triple-race swing roller bearing
Operating Weights with Caterpillar C engine Shovel unit Backhoe unit Pad width Width over pads B Operating weight Ground pressure Operating weight Ground pressure Track pads option (on request) mm 9 ½, mm, kg, lb 9. N/cm². psi, kg 9,9 lb 9. N/cm². psi Standard track pads mm ½, mm, kg,9 lb. N/cm². psi, kg, lb. N/cm². psi Track pads option mm 9 ½, mm, kg, lb. N/cm² 9. psi, kg, lb. N/cm² 9. psi Track pads option (on request) 9 mm ½, mm, kg, lb. N/cm². psi, kg, lb. N/cm². psi with Cummins QSK9 engine Shovel unit Backhoe unit Pad width Width over pads B Operating weight Ground pressure Operating weight Ground pressure Track pads option (on request) mm 9 ½, mm, kg, lb 9. N/cm². psi, kg, lb 9. N/cm². psi Standard track pads mm ½, mm, kg, lb. N/cm². psi, kg, lb. N/cm². psi Track pads option mm 9 ½, mm, kg, lb. N/cm² 9. psi, kg 9, lb. N/cm² 9. psi Track pads option (on request) 9 mm ½, mm, kg, lb. N/cm². psi, kg, lb. N/cm². psi Electrical System System voltage V Version: Caterpillar Cummins Batteries ( V each) x h x h in series / parallel h - V h - V installation lternator Working spot lights Battery isolation relay Hydraulic Oil Cooling Oil flow of cooling pump x Halogen lights l/min ( US gal/min) Diameter of fan 9 mm ( ) Cooling system is fully independent of all main circuits, i.e. controlled cooling capacity is available whenever engine is running Gear type cooling pump supplying high volume low pressure oil to fans and aluminium cooler Variable axial piston pump supplying low volume high pressure oil to fan Fan speed is thermostatically controlled Extremely high cooling efficiency to ensure optimum oil temperature Diesel Engine Engine features Microprocessed engine management utomatic rev. reduction Heavy duty air-filters, STRT with automatic dust evacuation Two-stage fuel filter incl. water separator Version - Caterpillar (Tier ) Make and model Caterpillar C Total rated net power ISO / 9 kw ( HP), min - Total rated net power SE J9 9 kw ( HP), min - Total rated gross power SE J99 kw ( HP), min - No. of cylinders Bore Stroke Displacement spiration Max. altitude without deration Emission certification Fuel tank capacity Version - Cummins (Tier ) mm (. in) mm (. in). l (. in³) Turbocharged and charge air cooled, m (,9 ft) a.s.l. US EP/CRB Tier ; Europe NRMM Stage III, l ( US gal) Make and model Cummins QSK 9-C (Tier ) Total rated net power ISO / kw ( HP), min - Total rated net power SE J9 kw ( HP), min - Total rated gross power SE J99 kw ( HP), min - No. of cylinders (each engine) Bore 9 mm (. in) Stroke 9 mm (. in) Displacement 9 l (,9 in³) spiration Turbocharged and aftercooled Max. altitude without deration, m (, ft) a.s.l. Emission certification US EP Tier ; Eurpoe NRMM Tier Fuel tank capacity, l ( US gal) Copyright Terex Corporation
Hydraulic System with PMS Main pumps Max. oil flow Max. pressure, attachment Swing pump Max. oil flow Max. pressure, swing circuit Total volume of hydraulic oil Hydraulic tank capacity x variable swash plate pumps x l/min ( x US gal /min) MPa = bar (, psi) Reversible swash plate pump l/min ( US gal/min) MPa = bar (, psi) approx., l (9 US gal) approx., l ( US gal) Pump Managing Systems (PMS) contains: Electronic load limit control Flow on demand from main pumps depending on joystick position utomatic regulation of main pumps to zero flow without demand utomatic rpm reduction of engine speed during working breaks Reduced oil flow of main pumps at high hydraulic oil temperature or at high engine temperature Pressure cut-off for main pumps Filters: Full-flow high-pressure filters ( µm) for the main pumps, installed directly behind each pump Full-flow filters ( µm) for the complete return circuit Full-flow filter ( µm) for the cooling return circuit Pressure filter ( µm) for servo circuit Pressure filter ( µm) for the feed pump of the closed swing circuit Undercarriage Travel speed Max. tractive force Max.. km / h (. mph) kn ( t =, lb) Gradability of travel drives Max. % Track pads (each side) Bottom rollers (each side) Support rollers (each side) Travel drives (each side) Parking brake planetary transmission with axial piston motor Wet multiple disc brake, spring applied / hydraulically released Rolled double-grouser track pads ll running surfaces of sprockets, idlers, rollers and track links are hardened Fully hydraulic self-adjusting track tensioning system with membrane accumulator utomatic hydraulic retarder valve to prevent overspeed on downhill travel coustic travel alarm Operator s Cab Operator s eye level approx.. m ('") Internal dimensions of cab Length, mm ('") Width, mm ('") Height,9 mm ('") Pneumatically cushioned and multi-adjustable comfort seat with lumbar support, seat heating, safety belt, head and arm rests Switch in seat cushion to neutralize automatically the hydraulic controls when operator leaves the seat Joystick controls integrated in independently adjustable seat consoles Fold-away auxiliary seat with safety belt FOPS (rock guard; approved acc. to DIN ISO 9) integrated into cab structure ll-round safety glass, armoured windshield and sliding side window Windshield with parallel intermittent wiper / washer Roller blind at windshield Robust instrument panel incl. large and easy to read instruments Swing System RH -E Swing drive Compact planetary transmission with axial piston motor Parking brake Wet multiple disc brake, spring loaded / hydraulically released Max. swing speed. rpm Swing ring Triple race roller bearing with sealed internal gearing Closed-loop swing circuit with torque control Hydraulic braking of the swing motion by counteracting control ll race ways of swing ring as well as grease bath for internal gearing supplied by automatic central lubrication system utomatic Lubrication System Capacity of grease drum l (. US gal) Single line progressive automated lubrication system, electric motor driven and electronically controlled Connected to the lubrication system are the swing roller bearing with internal gearing and all pivot points of attachment, bucket and cylinders except backhoe bucket and linkage System failures displayed on control panel ttachments Booms and sticks are torsion resistant, welded box design of high tensile steel with massive steel castings at pivot areas Booms and sticks are stress relieved after welding "Pressure-free lowering" of boom (FS) by means of a float valve Shovel attachment with Terex O&K patented TriPower kinematics ensuring the following main features: Horizontal automatic constant-angle bucket guidance Vertical automatic constant-angle bucket guidance utomatic roll-back limiter to prevent material spillage Kinematic assistance to hydraulic forces Constant boom momentum throughout the whole lift arc Crowd force assistance ll buckets (FS and BH) are equipped with a universal wear package suitable for all standard applications, which consists of: Special liner material covering main wear areas inside and outside of bucket Lip shrouds between teeth Side edge protection Heel shrouds at bottom edges Special wear packages for highly abrasive materials on request Copyright Terex Corporation
TriPower Face Shovel ttachment (FS) Working Diagram - Boom. m ('") - Stick. m ('") ft m 9 9 m ft Working Range Max. digging height. m '" Max. digging reach. m '" Max. digging depth. m '" Max. dumping height. m '" Crowd distance on level.9 m '" Digging Forces Max. crowd force kn, lb Max. crowd force at ground level kn, lb Max. breakout force kn, lb Face Shovels Type Heavy rock shovel Standard rock shovel Tooth system ESCO V 9 ESCO V 9 Capacity SE / PCS :.9 m³ (9. yd³). m³ (. yd³) Capacity SE / CECE :. m³ (. yd³). m³ (9. yd³) Total width, mm ('"), mm (9'") Inner width, mm ('"), mm (9'") Opening width, mm ('9"), mm ('9") No. of teeth Weight incl. universal wear kit 9, kg (,9 lb), kg (, lb) Max. material density (loose). t/m³ (, lb/yd³). t/m³ (, lb/yd³) Copyright Terex Corporation
Standard Backhoe ttachment (BH) Working Diagram - Boom. m ('") - Stick. m ('") ft m RH -E 9 9 m ft Backhoes Type Heavy rock bucket Standard rock bucket Mass excavation bucket Tooth system ESCO V 9 ESCO V ESCO V Capacity SE :. m. m. m. yd³. yd³ 9. yd³ Capacity CECE :. m. m. m. yd³. yd³. yd³ Capacity struck. m. m. m. yd³.9 yd³. yd³ Total width, mm,9 mm, mm '" '" 9' Inner width, mm, mm, mm ' '" '" No. of teeth Weight incl., kg, kg, kg universal wear kit, lb, lb, lb Max. material. t/m. t/m. t/m density (loose), lb/yd³, lb/yd³, lb/yd³ Working Range Max. digging depth. m '" Max. digging reach. m '" Max. digging height. m '" Digging Forces Max. crowd force 9 kn, lb Max. breakout force kn, lb Copyright Terex Corporation
Mass Excavation Backhoe ttachment Working Diagram - Boom. m ('") - Stick. m (9'") ft m 9 9 m ft Backhoes Type Copyright Terex Corporation Heavy rock bucket Standard rock bucket Mass excavation bucket Tooth system ESCO V 9 ESCO V ESCO V Capacity SE :. m. m. m. yd³. yd³ 9. yd³ Capacity CECE :. m. m. m. yd³. yd³. yd³ Capacity struck. m. m. m. yd³.9 yd³. yd³ Total width, mm,9 mm, mm '" '" 9' Inner width, mm, mm, mm ' '" '" No. of teeth Weight incl., kg, kg, kg universal wear kit, lb, lb, lb Max. material. t/m. t/m. t/m density (loose), lb/yd³, lb/yd³, lb/yd³ Working Range Max. digging depth. m 9'" Max. digging reach. m '" Max. digging height. m '" Digging Forces Max. crowd force kn 9,9 lb Max. breakout force 9 kn, lb
RH -E General Packing List Basic unit with C engine Pad width Width Gross weight* mm (9'½"), mm ('"), kg (9, lb) mm ('½"), mm ('") 9, kg (, lb) mm (9'½"), mm ('"), kg (,9 lb) 9 mm ('½"), mm ('"), kg (, lb) * Weights with QSK9 engine kg / lb less Crate with cabin and FOPS Width, mm ('9") Gross weight, kg (, lb), mm (9 ),9 mm (9 ), mm ( ) Pallet with counterweight Width, mm ('") Gross weight C:, kg (9, lb) QSK9:, kg (, lb) TriPower Shovel ttachment Boom with TriPower linkages, rods and boom cylinders Stick Width, mm ('") Gross weight, kg (9, lb) Width, mm ('") Gross weight, kg (, lb), mm ('") mm ( 9 ), mm ( ) C:, / '" QSK9:, / '", mm ( ), mm ( ), mm ( ), mm ( ) Face shovel incl. pin for stick Capacity (:) Width Gross weight. m³ (. yd³), mm ('") 9, kg (, lb). m³ (9. yd³), mm (9'"), kg (, lb) Crate with stick and bucket cylinders Width, mm ( ) Gross weight, kg (, lb), mm ( ), mm ( ) mm ( )), mm ( ) Crate with accessories Width mm ( ) Gross weight, kg (,9 lb), mm ( ), mm ( ) ll details provided are for general information only. Exact dimensions subject to selected machine configuration and final packing list. Copyright Terex Corporation
Backhoe ttachment Monoboom with main valve block, boom and stick cylinders Boom Length B Width. m³ ( ), mm ( ), mm ( ). m³ ( ), mm (, mm (9 ) C Boom Heigth C Gross weight. m³ ( ),9 mm (9 ), kg (, lb). m³ ( ), mm (9 ), kg (, lb) B Pallet with stick, linkage and bucket cylinders Stick Length B Width. m³ (9 ), mm ( ), mm ( ). m³ ( ), mm ( ), mm ( ) C Stick Heigth C Gross weight. m³ (9 ),9 mm ( ), kg (, lb). m³ ( ),9 mm ( ), kg (,9 lb) B Backhoe bucket incl. pins for stick and linkage Capacity (:) Width Gross weight. m³ (. yd³), mm ('"), kg (, lb). m³ (9. yd³), mm (9'"), kg (,99 lb), mm ( ) Crate with accessories Width mm ( ) Gross weight, kg (,9 lb), mm ( ). m³ =, mm ( ). m³ =, mm (9 ), mm ( ) Optional Equipment General Export crating Finishing as per enduser s corporate colours Customizing of logos as per customer s specification Superstructure Environmentally compatible hydraulic oil Xenon lighting High capacity water separator Fast filling connection for fuel Catwalk with access steps at engine module (standard on C version) Centrifuge for engine oil filtration Various cold weather packages Cab Radio with loudspeaker and antenna On roof mounted airconditioning unit Undercarriage Track pad width mm, mm or 9 mm Track guides HD-LC undercarriage ttachment Xenon lighting on boom Special wear packages Further optional equipment on request The technical specifications mentioned in this data sheet may vary according to the specific equipment/options installed. Effective Date: pril. Product specifications and prices are subject to change without notice or obligation. The photographs and/or drawings in this brochure are for illustrative purposes only. Refer to the appropriate Operator s Manual for instructions on the proper use of this equipment. Failure to follow the appropriate Operator s Manual when using our equipment or to otherwise act irresponsibly may result in serious injury or death. The only warranty applicable to our equipment is the standard written warranty applicable to the particular product and sale and Terex makes no other warranty, express or implied. Products and services listed may be trademarks, service marks or tradenames of Terex Corporation and/or its subsidiaries in the US and other countries and all rights are reserved. Terex is a registered trademark of Terex Corporation in the US and many other countries. Copyright Terex Corporation. M. e / PDF Terex GmbH Karl-Funke-Str., D-9 Dortmund, Germany Tel +9 () 9 Fax +9 () 9 info@terex-ok.com www.terex-ok.com