RIGHT TRAILER WEIGHT LENGTH TYPE FINISH AXLES D.O.T LAWS

Transcription

1

2

3 WEIGHT TYPE SELECTING THE RIGHT The weight of your boat needs to include engine(s), fuel, gear and any factory added options that the builder did not include in its boat weight. This weight along with your expected trailer usage will determine the capacity of the trailer. Trailers are manufactured to carry a predetermined weight and should not be overloaded. The Length of the is boat from the pulpit (if included) to the engine mount. Remember, if you are towing with a van or camper you don t want the pulpit over the coupler on the trailer. Many trailers are designed to allow the owner to drive the boat on and off. However, some ramps are too shallow to allow adequate submersion for the boat to load properly. Other ramps may have a dropoff at the water s edge and will not allow proper launching. Be sure to determine if your trailer will perform adequately at your local marina. Choose the type (drive-on or roller) which best fits your needs. FINISH Aluminum or Galvanized. Galvanized trailers offer a protective coating that normally prevents rust for several years. Aluminum trailers will experience virtually no corrosion and are somewhat lighter in weight. Both perform well in salt water. AXLES Single or Tandem Axle trailers are available on all models 8 long and larger. Both models have advantages and disadvantages. Single axle trailers are lighter in weight and easier to maneuver however, their weight capacities are less. Tandem models can carry more weight but are somewhat more difficult to back-up. If you plan to do a lot of long distance driving, consider choosing a tandem trailer for the safety it provides in case of a tire failure. D.O.T LAWS Wide boats and trailers may be subject to certain state towing laws. Please check with your state D.O.T. for regulations. The State of Florida requires brakes on all axles of any trailer with a G.V.W.R. of 000 lbs. or more. This means the combined weight of the boat, trailer and all equipment being towed. Most other states have similar laws. When selecting a trailer for your needs, be sure you comply with these legal statutes. Additionally, today s lighter weight vehicles may not provide adequate braking by themselves. Drive safely; make sure your trailer has brakes installed. ALL MODEL NUMBERS ENDING WITH B ARE ASSEMBLED WITH BRAKES ON ALL AXLES. THESE MODELS ARE AVAILABLE WITHOUT BRAKES; HOWEVER, THE LOAD IS GREATLY REDUCED TO COMPLY WITH FLORIDA LAW.

4 A MODEL ALUMINUM A80 * SHOWN WITH OPTIONAL FRONT FLAT BUNK EXCHANGE A685B NOTE: FLORIDA STATUTE 6.6 SEC. () SUB. SEC. (A) REQUIRES BRAKES ON ALL AXLES OF ANY WITH A G.V.W.R. OF 000 LBS OR MORE. ANY S ORDERED THAT DO NOT COMPLY WITH FLORIDA LAW SHOULD NOT BE TOWED ON PUBLIC ROADS. THE OWNER ACCEPTS ALL RESPONSIBILITY AND LIABILITY FOR USE OF THE.

5 A4 A45 A55 A67 A60 A60B A80 A80B A86B A840B A00B A044B A0B A44B A50B A44B A50B A60B A450B A460B A470B A485B A660B A670B A685B A60B A885B A80B A8B A8B BOAT NO. OF AXLES 550 LBS 900 LBS 900 LBS 00 LBS 500 LBS 600 LBS 400 LBS 4700 LBS 500 LBS 500 LBS 6000 LBS 500 LBS 6000 LBS 600 LBS 8400 LBS 060 LBS 8400 LBS 9800 LBS 000 LBS 060 LBS 000 LBS 500 LBS 500 LBS 00 LBS 500 LBS 500 LBS 700 LBS 000 LBS 000 LBS 000 LBS 900 LBS 600 LBS 4000 LBS 900 LBS 900 LBS 5000 LBS 5000 LBS 5800 LBS 5000 LBS 5800 LBS 8500 LBS 5800 LBS 8500 LBS 0000 LBS 8500 LBS 0000 LBS 000 LBS 000 LBS B C C C C 4C C 4C 5D C 4C C 4C C 4C C 4C 4C 4C 4C 5D 5D 4C 5D 5D R6 5D R6 R6 5D TORSION AXLES AND STAINLESS STEEL HARDWARE ON ALL MODELS AND LARGER ALUMINUM CHANNEL ON MODELS A4, A45 AND A55 ALUMINUM I-BEAM ON MODELS A67 AND LARGER ALUMINUM VEE CROSS MEMBERS ALUMINUM DIAMOND PLATE FENDERS ON MODELS A67 AND LARGER GALVANIZED AXLES, HUBS AND WHEELS ADJUSTABLE CYPRESS HULL SUPPORTS ADJUSTABLE BOW STOP AND WINCH STAND BEARING PROTECTION SYSTEM HEAVY DUTY WINCH TONGUE JACK STAINLESS STEEL AND GALVANIZED HARDWARE REAR VERTICAL LOADING GUIDES ON MODELS A67 AND LARGER FRONT CENTERING GUIDES ON MODEL A00B AND LARGER PREMIUM OPTION PACKAGE ON S LESS THAN. NET RADIAL S TORSION AXLES ON S LESS THAN. NET SPARE AND WHEEL STAINLESS STEEL FASTENERS FRONT FLAT BUNK EXCHANGE ALUMINUM WHEELS LED LIGHTS ALL MODEL NUMBERS ENDING WITH B ARE ASSEMBLED WITH BRAKES ON ALL AXLES. THESE MODELS ARE AVAILABLE WITHOUT BRAKES; HOWEVER, THE LOAD IS GREATLY REDUCED TO COMPLY WITH FLORIDA LAW.

6 CTA MODEL ALUMINUM CTA80B * SHOWN WITH OPTIONAL HEAVY DUTY BOWCATCHER CTA40B SUPER DUTY 4,000 LBS 0,000 LBS NET 4 NOTE: FLORIDA STATUTE 6.6 SEC. () SUB. SEC. (A) REQUIRES BRAKES ON ALL AXLES OF ANY WITH A G.V.W.R. OF 000 LBS OR MORE. ANY S ORDERED THAT DO NOT COMPLY WITH FLORIDA LAW SHOULD NOT BE TOWED ON PUBLIC ROADS. THE OWNER ACCEPTS ALL RESPONSIBILITY AND LIABILITY FOR USE OF THE.

7 CA80B CA840B CA00B CTA044B CTA44B CTA50B CTA50B CTA60B CTA560B CTA585B CTA785B CTA70B CTA885B CTA80B CTA8B CTA0B CTAB CTAB CTA5B CTA5B CTA55B CTA57B CTA50B CTA405B CTA407B CTA400B CTA40B BOAT NO. OF AXLES 5000 LBS 500 LBS 500 LBS 6000 LBS 6000 LBS 7040 LBS 7040 LBS 060 LBS 060 LBS 000 LBS 060 LBS 000 LBS 540 LBS 000 LBS 540 LBS 540 LBS 7700 LBS 540 LBS 7700 LBS 9700 LBS 4000 LBS 7700 LBS 9700 LBS 4000 LBS 4000 LBS 860 LBS 40 LBS 80 LBS 5000 LBS 5000 LBS 5900 LBS 5800 LBS 8500 LBS 8500 LBS 0000 LBS 8500 LBS 0000 LBS 000 LBS 0000 LBS 000 LBS 000 LBS 5000 LBS 000 LBS 5000 LBS 0000 LBS 5000 LBS 0000 LBS 0000 LBS TORSION AXLES AND STAINLESS STEEL HARDWARE ON ALL MODELS AND LARGER ALUMINUM I-BEAM ALUMINUM VEE CROSS MEMBERS ALUMINUM DIAMOND PLATE FENDERS GALVANIZED AXLES, HUBS AND WHEELS ADJUSTABLE CYPRESS HULL SUPPORTS ADJUSTABLE BOW STOP AND WINCH STAND BEARING PROTECTION SYSTEM HEAVY DUTY WINCH TONGUE JACK STAINLESS STEEL AND GALVANIZED HARDWARE REAR VERTICAL LOADING GUIDES FRONT CENTERING GUIDES ON MODEL CA00B AND LARGER 4C C 4C C C 4C 4C 4C 4C 5D 5D R6 5D R6 5D R6 R6 5D R6 5D R6 R6 R6 R6 R6 R6 R PREMIUM OPTION PACKAGE ON S LESS THAN. NET RADIAL S TORSION AXLES ON S LESS THAN 7000 LBS. NET SPARE AND WHEEL SPARE MOUNT WITH REPLACEMENT TORSION SPINDLE HUB AND BEARINGS STAINLESS STEEL FASTENERS FRONT FLAT BUNK EXCHANGE ALUMINUM WHEELS LED LIGHTS HEAVY DUTY BOWCATCHER WITH SPECIAL HULL SAFE RUBBER BLOCKS STAINLESS STEEL BRAKE CALIPERS AND ROTORS ALL MODEL NUMBERS ENDING WITH B ARE ASSEMBLED WITH BRAKES ON ALL AXLES. THESE MODELS ARE AVAILABLE WITHOUT BRAKES; HOWEVER, THE LOAD IS GREATLY REDUCED TO COMPLY WITH FLORIDA LAW. 5

8 AS MODEL ALUMINUM * SHOWN WITH OPTIONAL SWING TONGUE AS80 ALUMINUM SKIFF S BOAT NO. OF AXLES AS66* LBS 600 LBS C 60 9 AS LBS 000 LBS C 98 9 AS60B LBS 4C 98 9 AS LBS 000 LBS C 0 AS80B LBS 4C 0 AS00B LBS 4C 0 6 AS0B LBS 4C 0 4 AS44B LBS C 0 4 *AS66 MODEL COMES WITH ALUMINUM CHANNEL, TORSION AXLE, AND LED LIGHTS 6 ALUMINUM I-BEAM ALUMINUM VEE CROSS MEMBERS PLASTIC FENDERS WITH BACK AND STEP CARPETED HULL SUPPORTS OR LAUNCH PADS STAINLESS STEEL AND GALVANIZED HARDWARE GALVANIZED HUBS AND WHEELS GALVANIZED AXLES WITH SUPER LUBE TONGUE JACK REAR VERTICAL LOADING GUIDES PREMIUM OPTION PACKAGE SPARE AND WHEEL TORSION AXLE STAINLESS STEEL HARDWARE UPGRADE RADIAL S ALUMINUM WHEELS LED LIGHTS NOTE: FLORIDA STATUTE 6.6 SEC. () SUB. SEC. (A) REQUIRES BRAKES ON ALL AXLES OF ANY WITH A G.V.W.R. OF 000 LBS OR MORE. ANY S ORDERED THAT DO NOT COMPLY WITH FLORIDA LAW SHOULD NOT BE TOWED ON PUBLIC ROADS. THE OWNER ACCEPTS ALL RESPONSIBILITY AND LIABILITY FOR USE OF THE.

9 CAT MODEL ALUMINUM CAT78B * SHOWN WITH OPTIONAL DELUXE STEP LADDER CATAMARAN S CAT80B CAT44B CAT50B CAT60B CAT8B CAT560B CAT58B CAT770B CAT78B CAT9B CAT5B BOAT NO. OF AXLES 500 LBS 6000 LBS 0000 LBS 0000 LBS 8500 LBS 0000 LBS 5000 LBS 700 LBS 5000 LBS 5900 LBS 800 LBS 5900 LBS 800 LBS 800 LBS 000 LBS 5000 LBS 4C C 4C 4C 5D 4C 5D 5D 5D 5D R TORSION AXLES AND STAINLESS STEEL HARDWARE ON ALL MODELS AND LARGER BRAKES ON ALL AXLES ALUMINUM I-BEAM ALUMINUM CROSS MEMBERS ALUMINUM DIAMOND PLATE FENDERS CYPRESS HULL SUPPORTS STAINLESS STEEL AND GALVANIZED HARDWARE GALVANIZED AXLES, HUBS AND WHEELS BEARING PROTECTION SYSTEM TONGUE JACK PREMIUM OPTIONS PACKAGE ON S LESS THAN. NET ALUMINUM WHEELS LED LIGHTS RADIAL S TORSION AXLES ON S LESS THAN. NET SPARE AND WHEEL STAINLESS STEEL FASTENERS DELUXE STEP LADDER ALL MODEL NUMBERS ENDING WITH B ARE ASSEMBLED WITH BRAKES ON ALL AXLES. THESE MODELS ARE AVAILABLE WITHOUT BRAKES; HOWEVER, THE LOAD IS GREATLY REDUCED TO COMPLY WITH FLORIDA LAW. 7

10 PONTOON MODEL ALUMINUM ACP04 * SHOWN WITH OPTIONAL PONTOON GUIDES ALUMINUM PONTOON S ACP60 ACP04 ACTP05B ACTP45B ACTP450B ACTP88B ACTP848B 8 BOAT NO. OF AXLES 500 LBS 999 LBS 400 LBS 6000 LBS 500 LBS 600 LBS 000 LBS 400 LBS 5000 LBS 800 LBS 4800 LBS 0D 0E 0C 0C 0E 0D 0E SPARE AND WHEEL PVC PONTOON GUIDES DELUXE STEP LADDER ALUMINUM I-BEAM GALVANIZED AXLES AND WHEELS ADJUSTABLE WINCH STAND AND BOW STOP BEARING LUBRICATION SYSTEM HEAVY DUTY WINCH WITH STRAP TONGUE JACK COMPOSITE BUNK COVERS NOTE: FLORIDA STATUTE 6.6 SEC. () SUB. SEC. (A) REQUIRES BRAKES ON ALL AXLES OF ANY WITH A G.V.W.R. OF 000 LBS OR MORE. ANY S ORDERED THAT DO NOT COMPLY WITH FLORIDA LAW SHOULD NOT BE TOWED ON PUBLIC ROADS. THE OWNER ACCEPTS ALL RESPONSIBILITY AND LIABILITY FOR USE OF THE.

11 PONTOON MODEL GALVANIZED CP04 * SHOWN WITH OPTIONAL DELUXE STEP LADDER GALVANIZED, AXLES AND WHEELS ADJUSTABLE WINCH STAND AND BOW STOP BEARING LUBRICATION SYSTEM HEAVY DUTY WINCH WITH STRAP TONGUE JACK COMPOSITE BUNK COVERS SPARE AND WHEEL PVC PONTOON GUIDES DELUXE STEP LADDER GALVANIZED PONTOON S CP66 CP06 CP04 CTP00B CTP040B CTP45B CTP444B CTP455B CTP88B CTP848B CTP855B CTP860B CTP70B BOAT NO. OF AXLES 090 LBS 00 LBS 999 LBS 4800 LBS 500 LBS 6500 LBS 500 LBS 600 LBS 6600 LBS 7400 LBS 8600 LBS 600 LBS 650 LBS 400 LBS 900 LBS 4000 LBS 5500 LBS 800 LBS 4800 LBS 5500 LBS 6000 LBS C 0C 0E 0B 0E 0C C 4C 0D 0E 4C 0E 0E ALL MODEL NUMBERS ENDING WITH B ARE ASSEMBLED WITH BRAKES ON ALL AXLES. THESE MODELS ARE AVAILABLE WITHOUT BRAKES; HOWEVER, THE LOAD IS GREATLY REDUCED TO COMPLY WITH FLORIDA LAW. 9

12 DRIVE-ON MODEL GALVANIZED BLAZER70 GALVANIZED BLAZER S BLAZER 70 BLAZER 78B BLAZER 98B BLAZER 96B BLAZER 944B BLAZER 8B BLAZER 6B BLAZER 44B BLAZER 58B BLAZER 558B BLAZER 575B BOAT NO. OF AXLES 600 LBS 400 LBS 400 LBS 400 LBS 500 LBS 400 LBS 400 LBS 500 LBS 9000 LBS 000 LBS 800 LBS 800 LBS 600 LBS 800 LBS 600 LBS 5800 LBS 5800 LBS 7500 LBS C 4C 4C 5D C 4C 5D C 4C 4C 5D SPARE AND WHEEL RADIAL S LED LIGHTS 0 GALVANIZED, AXLES, HUB AND WHEELS ADJUSTABLE HULL SUPPORTS KEEL PROTECTION PADS VERTICAL LOADING GUIDES ADJUSTABLE WINCH STAND AND BOW STOP HEAVY DUTY WINCH WITH STRAP BEARING LUBRICATION SYSTEM TONGUE JACK FRONT CENTERING GUIDES ON & 5 MODELS NOTE: FLORIDA STATUTE 6.6 SEC. () SUB. SEC. (A) REQUIRES BRAKES ON ALL AXLES OF ANY WITH A G.V.W.R. OF 000 LBS OR MORE. ANY S ORDERED THAT DO NOT COMPLY WITH FLORIDA LAW SHOULD NOT BE TOWED ON PUBLIC ROADS. THE OWNER ACCEPTS ALL RESPONSIBILITY AND LIABILITY FOR USE OF THE.

13 EC/EW/ETW MODEL GALVANIZED EW80V GALVANIZED KEEL ROLLER S EC9 EC EC9 EC EC9V ECV EWV EW4V EW55V EW60V EW70V EW78VB EW80V EW88VB BOAT NO. OF AXLES 50 LBS 450 LBS 50 LBS 450 LBS 50 LBS 450 LBS 560 LBS 560 LBS 900 LBS 500 LBS 600 LBS 400 LBS 600 LBS 900 LBS 00 LBS 900 LBS 00 LBS 900 LBS 00 LBS 00 LBS 00 LBS 500 LBS 000 LBS 000 LBS 800 LBS 000 LBS 800 LBS 8B B 8B B 8B B B B C C C 4C C 4C GALVANIZED, AXLES AND WHEELS TONGUE JACK ON EW MODELS ADJUSTABLE WINCH STAND AND BOW STOP WINCH WITH STRAP CARPETED BUNKS BEARING PROTECTORS CARPETED SIDE GUIDES POLY ROLLERS TONGUE JACK ON EC MODELS SPARE AND WHEEL LED LIGHTS ALL MODEL NUMBERS ENDING WITH B ARE ASSEMBLED WITH BRAKES ON ALL AXLES. THESE MODELS ARE AVAILABLE WITHOUT BRAKES; HOWEVER, THE LOAD IS GREATLY REDUCED TO COMPLY WITH FLORIDA LAW.

14 C/CV/CTV MODEL GALVANIZED C77 GALVANIZED TILT S C4 C5 C55 C75 C77 CV70 CV80-58 CV88-58B CV98-58B CV98-7B CTV944-58B CTV944-7B BOAT NO. OF AXLES 550 LBS 550 LBS 900 LBS 950 LBS 00 LBS 600 LBS 600 LBS 500 LBS 500 LBS 00 LBS 00 LBS 500 LBS 500 LBS 700 LBS 000 LBS 000 LBS 800 LBS 800 LBS 800 LBS B B C C C C C 4C 4C 4C C C GALVANIZED, AXLES AND WHEELS TONGUE JACK ADJUSTABLE WINCH STAND AND BOW STOP WINCH WITH STRAP FLAT BUNKS ON ALL MODELS SPARE AND WHEEL BEARING PROTECTORS POLY ROLLERS LED LIGHTS ALL MODEL NUMBERS ENDING WITH B ARE ASSEMBLED WITH BRAKES ON ALL AXLES. THESE MODELS ARE AVAILABLE WITHOUT BRAKES; HOWEVER, THE LOAD IS GREATLY REDUCED TO COMPLY WITH FLORIDA LAW.

15 JB/CB MODEL GALVANIZED JB6 BASS BOAT/JON BOAT S JB7 JB57 JB5 JB6 JB8 CB77 CB77V BOAT NO. OF AXLES 900 LBS 000 LBS 500 LBS 550 LBS 550 LBS. 00 LBS 00 LBS 700 LBS 700 LBS 00 LBS 00 LBS 00 LBS 700 LBS 700 LBS 8B 8B B B B C C GALVANIZED STEEL, AXLES AND WHEELS WINCH WITH STRAP GALVANIZED U-BOLTS CARPETED FLAT BUNKS CB77 COMES WITH SIDE LOADING GUIDES, TONGUE JACK AND BEARING PROTECTION CB77V COMES WITH SIDE LOADING GUIDES, TONGUE JACK, BEARING PROTECTION AND VEE D CROSSMEMBERS SPARE AND WHEEL TONGUE JACK BOAT GUIDES BEARING PROTECTORS NOTE: FLORIDA STATUTE 6.6 SEC. () SUB. SEC. (A) REQUIRES BRAKES ON ALL AXLES OF ANY WITH A G.V.W.R. OF 000 LBS OR MORE. ANY S ORDERED THAT DO NOT COMPLY WITH FLORIDA LAW SHOULD NOT BE TOWED ON PUBLIC ROADS. THE OWNER ACCEPTS ALL RESPONSIBILITY AND LIABILITY FOR USE OF THE.

16 A/AWC MODEL ALUMINUM AWCE SINGLE PERSONAL WATER CRAFT S AWCE A4 A LBS 560 LBS 860 LBS 00 LBS 00 LBS 500 LBS B B C ALUMINUM C-CHANNEL GALVANIZED AXLE AND WHEELS ADJUSTABLE WINCHSTAND AND BOW STOP ADJUSTABLE HULL SUPPORTS WINCH WITH STRAP TONGUE JACK BEARING PROTECTION SPARE AND WHEEL AWC5E DOUBLE PERSONAL WATER CRAFT S AWC0E AWC5E 499 LBS 999 LBS LBS 500 LBS 0D 0E ALUMINUM I-BEAM GALVANIZED AXLE AND WHEELS ADJUSTABLE WINCHSTAND AND BOW STOP ADJUSTABLE HULL SUPPORTS WINCH WITH STRAP TONGUE JACK BEARING PROTECTION SPARE AND WHEEL

17 WC/EW MODEL GALVANIZED *S SHOWN WITH OPTIONAL TONGUE JACK WCE WCE SINGLE PERSONAL WATER CRAFT S WCE9 WCE WCE9 WCE EWV 50 LBS 450 LBS 70 LBS 500 LBS 560 LBS 900 LBS 00 LBS 900 LBS 00 LBS 00 LBS 8B B 8B B B SPARE AND WHEEL TONGUE JACK ON MODEL WCE AND SMALLER GALVANIZED AXLE AND WHEELS ADJUSTABLE WINCHSTAND AND BOW STOP ADJUSTABLE HULL SUPPORTS WINCH WITH STRAP TONGUE JACK ON EWV BEARING PROTECTION WC6E500 WC7E5 DOUBLE PERSONAL WATER CRAFT S WC6E500 WC7E0 WC7E5 980 LBS 500 LBS 999 LBS 500 LBS 000 LBS 500 LBS C 0D 0E 8 8 GALVANIZED AXLE AND WHEELS ADJUSTABLE WINCHSTAND AND BOW STOP ADJUSTABLE HULL SUPPORTS WINCH WITH STRAP TONGUE JACK BEARING PROTECTION SPARE AND WHEEL 5

18 ATV/UT MODEL GALVANIZED ATV8 ATV S ATV8 BED X LBS 00 LBS 4C 0 GALVANIZED, AXLE AND WHEELS COMPLETE LIGHTS AND WIRING P.T. WOOD DECK FLOOR SPARE AND WHEEL BEARING PROTECTION UT588 UTILITY S UT485 UT580 UT588B UT508B UT68B UT640B BED 50 X 8 6 X 8 6 X 8 6 X 0 75 X 75 X LBS 600 LBS 4800 LBS 500 LBS 000 LBS 800 LBS 800 LBS 800 LBS 4000 LBS C C 4C 4C 4C C GALVANIZED, AXLE AND WHEELS COMPLETE LIGHTS AND WIRING P.T. WOOD DECK FLOOR TONGUE JACK ON MODEL UT580 AND LARGER SPARE AND WHEEL BEARING PROTECTION TONGUE JACK ON MODEL UT48 TAILGATE/RAMP

19 EC/KT/GT MODEL GALVANIZED ECK GALVANIZED CANOE/KAYAK S ECK9 ECK KT4 GT6 NO. OF CANOE/KAYAKS SUPPORTED LBS 550 LBS 550 LBS 550 LBS 900 LBS 00 LBS 00 LBS 00 LBS 8B B B B GALVANIZED, UPRIGHTS, AXLE AND WHEELS TONGUE JACK ON KT4 SPARE AND WHEEL TONGUE JACK ON ECK AKT MODEL ALUMINUM AKT4 ALUMINUM CANOE/KAYAK S AKT AKT4 NO. OF CANOE/KAYAKS SUPPORTED LBS 550 LBS 00 LBS 00 LBS B B ALUMINUM AND UPRIGHTS GALVANIZED AXLE AND WHEELS TONGUE JACK ON AKT4 SPARE AND WHEEL TONGUE JACK ON AKT 7

20