Table of Contents. Service - Quality - Integrity. Hardwoods. Primed MDF, Hemlock & FJ Primed Pine. Care and handling of Millwork

Transcription

1

2 Primed MDF, Hemlock & FJ Primed Pine Casing Base Crowns Chair Rails Hand Rails Trims Rounds Outside Corners Coves Stops OG & Moulded Batten Bullnose, Lattice & Screen Squares Miscellaneous Finish Lumber Table of Contents Hardwoods Casing Base Crowns Bullnose Squares Quarter Rounds Miscellaneous Components Components FJ Veneer Finish Lumber Patterns Radius Base Corners Rosettes Plinth Blocks Corners Build - Up Suggestions Index Care and handling of Millwork Unfinished woodwork is vulnerable! Apply finish as soon as possible following the manufacturer s finishing instructions. Never expose unpainted millwork to direct sunlight! Always protect unfinished millwork from moist conditions. Never store on the ground, on concrete, or where rain can blow in. All mouldings should be stored horizontally off the floor and in a dry location It s critical to protect millwork from direct sunlight prior to finishing to avoid rapid drying and bleaching. Even a few hours exposure to direct sunlight causes drying away from excess heat. Never store on the ground, nor allow wood to come into direct contact with concrete. The natural tendency of concrete to absorb moisture can create a wicking of moisture out of the air or the ground and into the wood. Mouldings must be acclimated 72 hours prior to installation, mouldings should be unbundled and allowed to acclimate to the environment in the room in which they will be installed, with a controlled humidity level. The humidity at the time of acclimation should be similar to the humidity expected upon occupancy of the project. Finishing Light sanding is required prior to finishing. Follow manufacturer s recommended instructions for your product type. and bleaching. Millwork must be stored in a dry area 1

3 Primed MDF - Hemlock - FJ Primed Pine Casing 5000 Architrave Primed MDF - F /4 x 3-3/4 Hemlock - H /16 x 3-3/ Architrave Hemlock - H /4 x 4-3/4 410 Primed MDF - F /16 x 2-1/4 411 Primed MDF - F /4 x 3 Hemlock - H411 3/4 x 3 49 Primed MDF - F x 3-1/ Architrave Primed MDF - F /8 x 5-1/4 Hemlock - H5020A 1-1/8 x 5-1/4 190 Traditional Hemlock - H190 11/16 x 2-1/4 388 Primed MDF - F /16 x 3-1/4 535 Primed MDF - F /4 x 3-1/2 Hemlock - H535 3/4 x 3-1/2 FJ Primed Pine - P /8 x 2-1/4 195 Traditional Hemlock - H195 5/8 x 3-1/4 2

4 Primed MDF - Hemlock - FJ Primed Pine Casing 120 Colonial Hemlock - H120 9/16 x 2-1/4 002 Primed MDF - F /8 x 2-1/4 003 Primed MDF - F /16 x 3-1/4 FJ Primed Pine - P /8 x 3-1/ Casing Hemlock - H2150 5/8 x 3-1/4 Primed MDF - F /8 x 3-1/4 444 Colonial Primed MDF - F /16 x 3-1/8 Hemlock - H444 5/8 x 3-1/4 FJ Primed Pine - P620444A 5/8 x 3-1/8 Knotty Pine - P /8 x 3-1/4 233 Primed MDF - F /16 x 3-1/4 2000C Colonial Hemlock - H2000C 11/16 x 2-1/ Beaded Hemlock - H3005 1/2 x 1-1/2 FJ Primed Pine - P /2 x 1-9/ Beaded Hemlock - H350 9/16 x 2-1/4 312 Beaded Primed MDF - F /8 x 3 3

5 Primed MDF - Hemlock - FJ Primed Pine Casing 3000 Bevel Hemlock - H3000 1/2 x 1-1/2 158 Bevel Primed MDF - F /16 x 1-9/16 FJ Primed - P /16 x 1-7/16 Golden Oak - DC300014GO 7/16 x 1-1/ Bevel Hemlock - H3002 1/2 x 2-1/4 FJ Primed Pine - P /16 x 2-1/4 Golden Oak - DC300214GO 7/16 x 2-1/4 356 Colonial Primed MDF - F /16 x 2-1/4 Hemlock - H356WM 5/8 x 2-1/4 FJ Primed Pine - P /8 x 2-1/4 Knotty Pine - P /8 x 2-1/4 Hemlock - H356VG 5/8 x 2-1/4 110 Sanitary Hemlock - H110 9/16 x 1-1/2 130 Sanitary Hemlock - H130 9/16 x 2-1/4 214 Bevel Primed MDF - F /16 x 2-1/4 324 Bevel Hemlock - H324WM 11/16 x 2-1/ Streamline Hemlock - H3014 7/16 x 2-1/4 327 Streamline Hemlock - H327 5/8 x 2-1/4 102 Step Hemlock - H102 9/16 x 2-1/4 111 Victorian Hemlock - H111 13/16 x 3-1/4 200 Victorian FJ Primed Pine - P /8 x 3-1/2 19 Moulded Primed MDF - F /16 x 2-1/4 Hemlock - H19 9/16 x 2-1/4 32 Step FJ Primed Pine - P /8 x 2-1/4 34 Step FJ Primed Pine - P /8 x 3-1/4 4

6 Primed MDF - Hemlock - FJ Primed Pine Casing 908 Reed Primed MDF - F /16 x 3-1/ Beaded Hemlock - H /16 x 2-1/2 FJ Primed Pine - P /16 x 2-1/2 140 Moulded Hemlock - H140 5/8 x 2-1/2 FJ Primed Pine - P /8 x 2-1/2 338 Howe Primed MDF - F x 3-1/4 472 E2E Bullnose Hemlock -VG - H472VG 5/8 x 2-1/ Fluted Primed MDF - F /8 x 3-3/ Fluted & Reed Hemlock - H /16 x 3-1/ Fluted & Reed FJ Primed Pine - P /16 x 3-1/ Fluted & Reed FJ Primed Pine - P /16 x 2-1/4 473 E2E Bullnose Primed MDF - F /16 x 2-1/4 494 E2E Bullnose Primed MDF - F /2 x 3-1/4 495 E2E Bullnose Hemlock - VG - H495VG 5/8 x 3-1/4 Primed MDF - F /16 x 3-1/2 100 E2E Bullnose Hemlock - H100D 9/16 x 1-1/2 1 E2E Bullnose Hemlock - H1 7/16 x 2-1/4 175 E2E Bullnose Hemlock - H175 1/2 x 2-1/4 CVG Fir - F /8 x 3-1/2 Hemlock - H175VG 1/2 x 2-1/4 5

7 Base Service - Quality - Integrity Primed MDF - Hemlock - FJ Primed Pine 3000C Colonial Hemlock - H3000C 5/8 x 3-1/4 234 Primed MDF - F /16 x 5-1/2 243 Primed MDF - F /2 x 4-1/4 412 Cambridge Primed MDF - F /16 x 4-1/ Victorian Hemlock - H211 3/4 x 4-1/4 326 Primed MDF - F /16 x 3-3/8 208 FJ Primed Pine - P /16 x 3-1/4 545 Primed MDF - F /8 x 5 Hemlock - H545 11/16 x 5

8 Primed MDF - Hemlock - FJ Primed Pine Base 625 Moulded Hemlock - H625 7/16 x 2-1/4 FJ Primed Pine - P /16 x 2-1/4 623 Moulded Primed MDF - F /2 x 3-1/ Primed MDF - F /16 x 6-1/4 618 Moulded Primed MDF - F /16 x 5-1/4 Hemlock - H618 1/2 x 5-1/4 FJ Primed Pine - P /16 x 5-1/4 285 Hemlock - H285VG 1/2 x 5-1/4 FJ Primed Pine - P310623A 7/16 x 3-1/4 Hemlock - H623 7/16 x 3-1/4 Knotty Pine - P /2 x 3-1/4 622 Moulded Primed MDF - F /2 x 2-1/2 653 Gingerbread Hemlock - H653 7/16 x 3-1/4 260 Colonial Hemlock - H260 3/8 x 3-1/4 714 Gingerbread FJ Primed Pine - P /16 x 4-1/8 716 Gingerbread FJ Primed Pine - P /16 x 4-5/8 FJ Primed Pine - P /8 x 3-1/4 663 Gingerbread Hemlock - H663 7/16 x 4-1/4 673 Gingerbread Hemlock - H673 7/16 x 5-1/4 7

9 Base Service - Quality - Integrity Primed MDF - Hemlock - FJ Primed Pine 41 Streamline Hemlock - H41 7/16 x 2-1/4 230 Combo Hemlock - H230 5/8 x 2-1/4 250 Streamline Hemlock - H250 7/16 x 2-1/ Streamline Hemlock - H3102 7/16 x 3-1/4 210 Sanitary Hemlock - H210 3/8 x 1-1/2 218 Sierra Primed MDF - F /16 x 5-1/4 240 Sanitary Hemlock - H240 3/8 x 2-1/ Sierra Primed MDF - F /16 x 7-1/4 215 Sierra Primed MDF - F /2 x 3-1/8 515 Sanitary Hemlock - H515 1/2 x 1-9/ Single Bullnose Primed MDF - F /2 x 3-1/4 473 Single Bullnose Hemlock-VG - H473VG 1/2 x 3-1/2 496 Single Bullnose Hemlock-VG - H496VG 9/16 x 5-3/8 CVG Fir - F /16 x 5-3/8

10 Primed MDF - Hemlock - FJ Primed Pine Crowns 54 Hemlock - H54 1/2 x 2-1/4 47 FJ Primed Pine - P /8 x 4-3/4 75 Bed Mould Hemlock - H75 1/2 x 1-5/8 311 Bed Mould Hemlock - H311 1/2 x 2-5/8 248 FJ Primed Pine - P /4 x 2-1/ Hemlock - H3242 1/2 x 11/ Hemlock - H3244 9/16 x 1-1/4 FJ Primed Pine - 5/8 x 1-1/4 P FJ Primed Pine - P /4 x 2-1/4 FJ Primed Pine - P /16 x 2-1/4 49 Primed MDF - F /16 x 3-5/8 Hemlock - H49 1/2 x 3-1/4 FJ Primed Pine - P /16 x 3-5/8 50 Hemlock - H50 1/2 x 3-7/16 48 Primed MDF - F /16 x 4-1/4 Hemlock - H48 1/2 x 4-1/4 47A FJ Primed Pine - P330047A 9/16 x 4-5/8 46 Primed MDF - 9/16 x 5-1/4 F FJ Primed Pine - P /16 x 3-1/4 9

11 Crowns Service - Quality - Integrity Primed MDF - Hemlock - FJ Primed Pine 413 Primed MDF - F /4 x 6-5/ Primed MDF - F /8 x 4-1/2 417 Primed MDF - F630417A 1-1/4 x 3-7/8 712 Classic Crown FJ Primed Pine - P /16 x 4-1/2 911 Lintel Mould Hemlock - H911D 1-1/4 x 2-1/4 912 Lintel Mould Primed MDF - F /2 x 2-1/4 10

12 Primed MDF - Hemlock - FJ Primed Pine Chair Rails 390 Hemlock - H390 5/8 x 2-7/16 FJ Primed Pine - P /16 x 2-5/8 297 Primed MDF - F /16 x Primed MDF - F x 3-1/2 Hand Rails 3507 Hemlock - H /16 x 2-1/4 231 Hemlock - H /16 X 1-5/8 11

13 Trims Service - Quality - Integrity Primed MDF - Hemlock - FJ Primed Pine 352 Corners FJ Primed Pine - P Degree 45 Corners FJ Primed Pine - P Degree 1030 Drip Cap Hemlock - H1030 3/4 x 1-5/ Drip Cap Water Table Hemlock - H /8 x Brickmould Hemlock - H /16 x Shingle Mould Hemlock - H440 5/8 x 1-1/2 FJ Primed Pine - P /4 x 2 CVG Fir - F /4 x O.S. Back Band Hemlock - H /16 x 1-1/ Shake Mould Hemlock - H /4 x 2-1/4 FJ Primed Pine - P /4 x 2-1/4 953 Opening Trim Hemlock - H953WM 7/16 x 1-5/16 FJ Primed Pine - P /16 x 1-3/8 Primed MDF - F /16 x 1-5/ I.S. Back Band Hemlock - H1020 3/4 x 1-1/16 12

14 Primed MDF - Hemlock - FJ Primed Pine Rounds 3222 Full Round Hemlock - H /16 Dia Quarter Round Hemlock - H3202 1/2 x 1/ Quarter Round Hemlock - H3200 1/4 x 1/ Base Shoe Hemlock - H3288 7/16 x 11/ Full Round Hemlock - H /16 Dia Quarter Round Hemlock - H /16 x 11/ Quarter Round Hemlock - H3201 3/8 x 3/8 126 Base Shoe FJ Primed Pine - P /2 x 3/ Full Round Hemlock - H /2 Dia. 325 Quarter Round Hemlock - H325 1 x Quarter Round FJ Primed Pine - P /2 x 1/2 106 Quarter Round FJ Primed Pine- P /16 x 11/ Half Round Hemlock - H3212 5/16 x 3/4 Outside Corners 3280 OS Corner Hemlock - H /16 x 1-1/ OS Corner Hemlock - H /4 x 1-1/ OS Corner Hemlock - H /16 x 11/ OS Corner FJ Primed Pine - P /8 x 1-1/8 206 OS Corner FJ Primed Pine - P /4 x 3/4 202 OS Corner Hemlock - H /16 x 1-1/16 FJ Primed Pine - P /16 x 1-1/16 13

15 Coves Service - Quality - Integrity Primed MDF - Hemlock - FJ Primed Pine 334 Hemlock - H334 1/2 x 1-1/ Hemlock - H3260 1/2 x 1/ Hemlock - H /16 x 11/ Hemlock - H305 5/8 x 2-5/8 93 FJ Primed Pine - P /4 x 3/4 306 Hemlock - H306 5/8 x 3-1/2 85 FJ Primed Pine - P /16 x 1-3/4 Stop, OG & Moulded Batten 417 OG Stop Hemlock - H417 3/8 x 3/4 418 OG Stop Hemlock - H418 7/16 x 1-1/8 419 OG Stop Hemlock - H419 7/16 x 1-5/ OG Stop Hemlock - H420 7/16 x 1-5/8 936 OG Stop Hemlock - H936 3/8 x 1-3/8 FJ Primed Pine - P /16 x 1-3/ Moulded Batten Hemlock - H1050 3/8 x 1-5/16 14

16 Primed MDF - Hemlock - FJ Primed Pine Bullnose & Squares 869 Bullnose Stop Hemlock - H869 7/16 x 1-1/ Bullnose Stop Hemlock - H866 7/16 x 1-5/ Bullnose Stop Hemlock - H865 7/16 x 1-1/2 413 Bullnose Stop Hemlock - H413 7/16 x 1-5/8 887 Bullnose Stop Hemlock - H887 3/8 x 1-1/4 FJ Primed Pine - P /8 x 1-1/ Bullnose Stop Hemlock - H3422 5/16 x 1-3/ Garage Door Stop Hemlock - H425 9/16 x 2-1/4 254 Parting Strip FJ Primed Pine - P /2 x 3/4 268 Lattice Hemlock - H268 1/4 x 1-1/8 267 Lattice Hemlock - H267 1/4 x 1-3/8 FJ Primed Pine - P /32 x 1-3/ Screen Flat Hemlock - H3274 1/4 x 3/ Square Hemlock - H /16 x 11/ Square Hemlock - H /16 x 1-1/ Screen Flat FJ Primed Pine - P /4 x 3/4 266 Lattice Hemlock - H266 1/4 x 1-5/ Parting Strip Hemlock - H3428 7/16 x 11/ Lattice Hemlock - H264 1/4 x 2-1/4 13 Beaded Screen Hemlock - H13 1/4 x 3/4 15

17 Primed MDF - Hemlock - FJ Primed Pine Miscellaneous 292 Wainscot Cap Hemlock - H292 9/16 x 1-1/8 163 Base Cap Hemlock - H163 11/16 x 1-3/8 701 Panel Cap Hemlock - H701 5/8 x 1-1/4 300C Wainscot Cap Primed MDF - F490300C 3/4 x Floor Cap Hemlock - H703 1/2 x 3/4 Primed MDF - F /16 x 1-3/8 954 Window Stop Primed MDF - F /8 x 1-5/ Picture Mould Hemlock - H /16 x 1-5/8 Hemlock - H954 1/2 x 1-1/8 705 Base Cap Hemlock - H705 3/4 x 1-1/ Panel Mould Hemlock - H1130 1/2 x Panel Mould Hemlock - H182 9/16 x 1-1/2 995 Cant Strip Solid Pine - P /4 x 3/4 696 Window Stool Primed MDF - F /16 x 6-9/16 T & G Paneling Hemlock - HBP5804 5/8 x 3-3/8 16

18 PRIMED MDF: Service - Quality - Integrity Primed MDF - Hemlock - FJ Primed Pine Finish Lumber Size Lengths Code Size Lengths Code 1/2 X 4 16 F X 6 8, 10, 12, 16 F /2 X 6 16 F X 7 8, 16 F /2 X 8 16 F X 8 8, 10, 12, 16 F X 2 8, 10, 12, 16 F X 10 8, 10, 12, 16 F X 3 8, 10, 12, 16 F X 12 8, 10, 12, 16 F X 4 8, 10, 12, 16 F /4 x 4 16 F X 5 8, 10, 12, 16 F /4 x 6 16 F /4 x 8 16 F HEMLOCK FINISH: VG S4S - C BTR MGS4S - C BTR MIX GRAIN SIZE CODE SIZE CODE SIZE CODE SIZE CODE 1 x 2 1 x 3 1 x 4 1 x 5 1 x 6 1 x 7 HBCVG102 HBCVG103 HBCVG104 HBCVG105 HBCVG106 HBCVG107 1 x 8 1 x 10 1 x 12 5/4 x 6 5/4 x 8 HBCVG108 HBCVG110 HBCVG112 HBCVG546 HBCVG548 1/4 X 4 1/4 X 6 1/2 x 4 1/2 x 6 1 x 2 1 x 3 1 x 4 H104MC H106MC HBCB.504 HBCB.506 HBCB102 HBCB103 HBCB104 1 x 5 1 x 6 1 x 8 1 x 10 1 x 12 2 x 2 HBCB105 HBCB106 HBCB108 HBCB110 HBCB112 HBCD202 S4S BOARDS: VG FIR FINISH: C BTR VERTICAL GRAIN 1 x 2 FVGC102 2 x 3 FVGC203 1 x 3 FVGC103 2 x 4 FVGC204 1 x 4 FVGC104 2 x 6 FVGC206 1 x 5 FVGC105 2 x 8 FVGC208 1 x 6 FVGC106 2 x 10 FVGC210 1 x 8 FVGC108 2 x 12 FVGC212 1 x 10 FVGC110 1 x 12 FVGC112 C Btr Vertical Grain 1/2 x 4 FVGC.504 5/4 x 4 FVGC5404 1/2 x 6 FVGC.506 5/4 x 6 FVGC5406 1/2 x 8 FVGC.508 5/4 x 8 FVGC5408 C Btr Mix Grain T & G Flooring 2 x 2 FMGC202 1 x 4 FVGTG104 4 x 4 FMGC404 MDF REGULAR: SIZE CODE LENGTHS 1 x 3 1 x 4 1 x 5 1 x 6 1 x 8 1 x 10 1 x 12 F F F F F F F FJ PRIMED PINE: SIZE CODE LENGTHS 1 x 2 1 x 3 1 x 4 1 x 5 1 x 6 1 x 8 1 x 10 1 x 12 P P P P P P P P PREFINISHED S4S: SIZE CODE SPECIE 1 x 4 1 x 4 1 x 5 1 x 5 1 x 6 1 x 6 1 x 7 1 x 8 1 x 8 DCBD104GO DCBD104SO DCBD105GO DCBD105SO DCBD106GO DCBD106SO DCBD107GO DCBD108GO DCBD108SO GOLDEN OAK STRAND OAK GOLDEN OAK STRAND OAK GOLDEN OAK STRAND OAK GOLDEN OAK GOLDEN OAK STRAND OAK 17

19 Casing Hardwoods 16 Cherry - C /4 x 3-1/2 Knotty Alder - A120016K 3/4 x 3-1/2 Maple - M /4 x 3-1/2 39 Cherry - C /16 x 3-1/4 Knotty Alder - A120039K 11/16 x 3-1/4 Maple - M /16 x 3-1/4 60 Cherry - C /4 x 3 Knotty Alder - A120060K 3/4 x 3 Maple - M /4 x 3 65 Knotty Alder - A120065K 13/16 x 3-1/4 Maple - M /16 x 3-1/4 62 Cherry - C /4 x 2-3/4 Knotty Alder - A120062K 3/4 x 2-3/4 Maple - M /4 x 2-3/4 57 Cherry - C /8 x 3-1/2 Knotty Alder - A120057K 7/8 x 3-1/2 Maple - M /8 x 3-1/ Knotty Alder - A121403K 5/8 x 3-1/4 18

20 Hardwoods Casing 5475 Architrave Knotty Alder - A125475K 1-1/16 x 4-3/4 312 Beaded Knotty Alder - A120312K 11/16 x Knotty Alder - A120535K 11/16 x 3-1/ Knotty Alder - A121002K 5/8 x 2-1/ Knotty Alder - A121003K 5/8 x 3-1/4 495 Knotty Alder - A120495K 1 x Architrave Modified Knotty Alder - A125575K 1-1/16 x 5-3/4 444 Colonial Oak Veneer - O /8 x 3-1/4 F115 Colonial Oak - O /2 x 2-1/4 356 Colonial Oak Veneer - O /2 x 2-3/16 Golden Oak - DC35614GO 7/16 x 2-1/4 Strand Oak - DC35614SO 7/16 x 2-1/4 Knotty Alder - A120356K 11/16 x 2-1/4 Oak - O /2 x 2-1/4 324 Bevel Oak Veneer - O /2 x 2-1/4 Oak - O120324B 1/2 x 1-9/16 Oak - O /2 x 2-1/4 307 Bevel Oak Veneer - O /2 x 1-1/2 F113 Bevel Oak - O /16 x 2-1/4 19

21 Base Hardwoods d 623 Knotty Alder - A110623K 1/2 x 3-1/4 618 Knotty Alder - A110618K 1/2 x 5-1/4 620 Knotty Alder - A110620K 9/16 x 4-1/4 Maple - M /16 x 4-1/4 90 Cherry - C /16 x 4-1/2 Knotty Alder - A110090K 9/16 x 4-1/2 Maple - M /16 x 4-1/2 85 Cherry - C /4 x 4-1/4 Knotty Alder - A110085K 3/4 x 4-1/4 Maple - M /4 x 4-1/4 633 O.G. Colonial Oak Veneer - O /2 x 3-1/4 634 O.G. Colonial Oak - O /8 x 2-3/4 724 Streamline Oak - O /8 x 2-3/4 20

22 Hardwoods d Base 31 Cherry - C110B31 9/16 x 4-1/4 Knotty Alder - A110B31K 9/16 x 4-1/ Knotty Alder - A111414K 1/2 x 4-1/4 545 Knotty Alder - A110545K 5/8 x Victorian Knotty Alder - A110412K 9/16 x 4-1/2 Maple - M810B31 9/16 x 4-1/ Knotty Alder - A111013K 1/2 x 3-1/ Knotty Alder - A111015K 1/2 x 5-1/4 400 Knotty Alder - A112400K 5/8 x 4 49 Cherry - C110B49 9/16 x 4-1/4 Knotty Alder - A110B49K 9/16 x 4-1/4 Maple - M810B49 9/16 x 4-1/4 21

23 Crowns Hardwoods d 637- Crown Oak - O /4 x 5-1/4 514 Knotty Alder - A130514K 1-1/4 x 5-1/ Dentil Oak - O /8 x Lintel Mould Knotty Alder - A140911K 1-1/4 x 2-1/ Knotty Alder - A131045K 11/16 x 5-1/ Knotty Alder - A131048K 11/16 x 4-1/4 51 Oak Veneer - O /16 x 3-1/4 Knotty Alder - A131051K 11/16 x 3-1/4 22

24 Hardwoods d Miscellaneous 520 Flat Screen Oak - O /4 x 3/4 200 Base Shoe Oak /16 x 3/4 430 Flat Screen Knotty Alder - A140430K 1/4 x 3/4 661 Quarter Round Oak - O /4 x 3/4 239 Square Oak - O /4 x 3/4 662 Quarter Round Oak - O /2 x 1/2 105 Quarter Round Superior Alder - A140105S 3/4 x 3/4 111 Quarter Round Superior Alder - A140111S 5/16 x 5/16 23

25 Miscellaneous Hardwoods 953 Opening Trim Superior Alder - A150953S 1/2 x 1-3/8 329 Counter Edge Oak - O /8 x 1-1/4 440 Counter Edge Oak - O /8 x 1-1/ Counter Edge Oak - O /8 x 1-3/4 382 OS Corner Knotty Alder - A /4 x 1-1/4 651 OS Corner Oak - O /4 x 3/4 431 Backsplash Oak -O /16 x 3-1/2 652 OS Corner Oak - O /6 x 1-1/6 180 Brickmould Knotty Alder - A120180K 1-1/4 x 2 Cherry - C /4 x Backband Cherry - C /2 x 1-1/8 Knotty Alder - A121518K 1-1/2 x 1-1/8 Maple - M /2 x 1-1/8 24

26 Hardwoods Miscellaneous 20 Wainscot Cap Oak - O /8 x 1-3/4 705 Panel Cap Knotty Alder - A140705K 3/4 x 1-1/8 101 Wainscot Cap Oak - O /16 x 1-5/8 703 Floor Cap Knotty Alder - A140703K 601 Cove 1/2 x 3/4 Oak - O Lip Moulding 3/4 x 3/4 93 Cove Superior Alder - A140093S 3/4 x 3/4 Oak - O /4 x 1-1/4 25

27 Hardwoods d Components Hardwoods 866 Bullnose Stop Knotty Alder - A150866K 1/2 x 1-3/8 301 Bullnose Stop Oak - O /8 x 1-1/ Bullnose Stop Mahogany - M877 3/8 x 1-1/4 Oak Veneer - O /8 x 1-1/4 Cherry - C /16 x 1-1/4 Maple - M /16 x 1-1/4 774 Solid Stop Maple - M /2 x 1-11/16 Cherry - C /2 x 1-11/16 Maple - M /2 x 1-11/ Colonial Stop Knotty Alder - A150936K 1/2 x 1-3/8 1-3/4 Kerfed Ext. Astragal Cherry - C /16 x 7 Interior Astragal Superior Knotty Alder - DFASTSKA8 1-3/8 x 8 Cherry - C /16 x 8 Cherry - C /8 x 8 Knotty Alder - DFASTSKKA8 1-5/16 x 8 Knotty Alder - DFASTKA 1-3/8 X 8 26

28 Hardwoods d Components FJ Veneer 774 Stop Cherry - CV /2 x 1-11/16 x 86 Maple - MPV /2 x 1-11/16 x 86 Alder Select - ASV /2 x 1-11/16 x 86 Cherry - CV /2 x 1-11/16 x 99 Maple - MPV /2 x 1-11/16 x 99 Fir - FV /2 x 1-11/16 x Stop Cherry - CV /8 x 1-3/8 x 86 Maple - MPV /8 x 1-3/8 x 86 Fir - FV /8 x 1-3/8 x 86 Alder Select - ASV /8 x 1-3/8 x Stop Cherry - CV /16 x 1-1/4 x 86 Maple - MPV /16 x 1-1/4 x 86 Oak Veneer - O /8 x 1-1/4 Strand Oak - DCSTP 3/8 x 1-1/4 Golden Oak - DCSTP 3/8 x 1-1/4 Cherry - CV /16 x 1-1/4 x 99 Maple - MPV /16 x 1-1/4 x Stop Cherry - CV /8 x 1-3/8 x 86 Maple - MPV /8 x 1-3/8 x 86 Fir - FV /8 x 1-3/8 x 86 Alder Select - ASV /8 x 1-3/8 x 86 Fir - FV /16 x 1-1/4 x 86 Alder Select - ASV /16 x 1-1/4 x Brickmould Meranti - MV /4 x 2 27

29 Finish Lumber Hardwoods d KNOTTY ALDER: Description Dimensions Lengths Code Knotty Alder S4S Knotty Alder S4S Knotty Alder S4S Knotty Alder S4S Knotty Alder S4S Knotty Alder S4S Knotty Alder S4S Knotty Alder S4S Knotty Alder S4S Knotty Alder S4S Knotty Alder S4S 1 x 3 1 x 4 1 x 5 1 x 6 1 x 8 1 x 10 1 x 12 5/4 x 4 5/4 x 5 5/4 x 6 5/4 x R/L 6-10 R/L 6-10 R/L 6-10 R/L 6-10 R/L 6-10 R/L 6-10 R/L 6-10 R/L 6-10 R/L 6-10 R/L 6-10 R/L A160103K A160104K A160105K A160106K A160108K A160110K A160112K A160544K A160545K A160546K A160548K RED OAK SQUARE EDGE: Description Dimensions Lengths Code S4S Oak S4S Oak S4S Oak S4S Oak S4S Oak S4S Oak S4S Oak S4S Oak S4S Oak S4S Oak S4S Oak 1 x 2 1 x 3 1 x 4 1 x 5 1 x 6 1 x 8 1 x 10 1 x 12 2 x 2 2 x 4 2 x 6 6, 8, 10, 12 6, 8, 10, 12 6, 8, 10, 12 6, 8, 10, 12 6, 8, 10, 12 6, 8, 10, 12 6, 8, 10, 12 6, 8, 10, 12 8, 10, 12 8, 10, 12 8, 10, 12 O BD102 O BD103 O BD104 O BD105 O BD106 O BD108 O BD110 O BD112 O DI202 O DI204 O DI206 Patterns: Pine, Cedar, Hemlock, Knotty Alder & Fir All Bevel and T&G profiles are Kiln Dried and sold R/L Tally only. FJ are sold with Trim Backs Ceiling Hemlock - HBP5804 5/8 x 3-3/8 Ceiling 28

30 Hardwoods d Radius Base Corners 3/4 RADIUS BASE CORNERS For applications needing 3/4 RADIUS OS BASE CORNER piece (for casing profiles), we offer: Item # Description For Use With PCS/CTN H C356BOR H C356DUL H C1208BOR H C444BOR H C444UL H C444ABOR 5/8 x 2-1/4 Hemlock Colonial 9/16 x 2-1/4 Paint Grade 11/16: X 2-1/2 Hemlock Colonial 5/8 x 3-1/4 Hemlock Colonial 9/16 x 3-1/8 Paint Grade 3-1/8 5/8 x 3-1/8 Paint Grade Hemlock H 356WM, MDF 356, FJ Primed 356 Primed MDF 356 Hemlock H 1208, FJ Primed 1208 Hemlock H 444 Primed MDF 444 FJ Primed 444A /4 RADIUS BASE CORNERS For applications needing 3/4 RADIUS OS BASE CORNER piece (for base profiles), we offer: Item # Description For Use With PCS/CTN H C623BOR H C623UL H C716PBOR 7/16 x 3-1/4 Hemlock O.G. 9/16 x 3-1/4 Paint Grade O.G. 9/16 x 4-5/8 Paint Grade Gingerbread Hemlock H 623 UL 623 FJ Primed

31 Rosettes, Plinth Blocks & Corners ROSETTES For applications needing ROSETTES, we offer: Item # Description For Use With PCS/CTN H CSCSGSM 3/4 x 2-3/4 x 2-3/4 W. Maple Hemlock Stain, Paint Grade 200 H CSCSGM 3/4 x 3-1/2 x 3-1/2 W. Maple Hemlock Stain, Paint Grade 100 PLINTH BLOCKS For applications needing PLINTH BLOCKS, we offer: Item # Description For Use With PCS/CTN H CPBM 3/4 x 3-1/2 x 6-1/2 W. Maple Hemlock Stain, Paint Grade 50 UNIVERSAL INSIDE & OUTSIDE CORNERS For applications needing UNIVERSAL INSIDE OR OUTSIDE CORNER piece (for base profiles), we offer: Item # Description For Use With PCS/CTN H CUBI H CUBO H CUBOR 3/4 x 7-1/4 Hemlock ISC 3/4 x 7-1/4 Hemlock Square OSC 3/4 x 7-1/4 Hemlock Radius OSC All Base Profiles All Base Profiles, 90 OSC Walls All Base Profiles, 3/4 Radius OSC

32 Build - Up Suggestions H912 LINTEL H911 LINTEL H912 LINTEL HBCVG104 HBCVG103 HBCVG104 H865 H936 H936 Chair Rail Build-Ups 49 Casing - 1 x 3-1/4 887 Stop - 7/16 x 1-1/4 410 Colonial Casing - 11/16 x 2-1/4 473 Bullnose Casing - 11/16 x 2-1/ Half Round - 3/4 218 Sierra Base - 9/16 x 5-1/4 49 Colonial Crown - 9/16 x 3-5/8 215 Sierra Base - 1/2 x 3-1/8 1 x 3 primed E2E /16 x 2-1/2 Mantel Build-Ups 1 x 10 Primed E2E - 11/16 x 9-1/4 1 x 3 Primed E2E - 11/16 x 2-1/2 413 Beaded Crown - 1-1/4 x 6-5/ Howe Casing 1 x 3-1/4 31

33 Index HEMLOCK Pattern # Profile Page # 1 casing 5 13 beaded screen casing 4 41 base 8 48 crown 9 49 crown 9 50 crown 9 54 crown 9 75 crown casing casing casing casing casing casing flat astragal casing base cap casing vg casing brick mould panel mould casing casing outside corner outside corner base base base hand rail base base base lattice lattice lattice lattice base wainscot cap cove 14 HEMLOCK Pattern # Profile Page # 306 cove crown casing quarter round casing cove casing casing vg casing chair rail casing stop o.g. stop o.g. stop o.g. stop o.g. stop garage dr stop shingle mould shake mould casing casing vg base vg casing vg base base casing base base base base base base base panel cap floor cap base cap stop stop stop stop lintel 10 HEMLOCK Pattern # Profile Page # 936 o.g. stop opening trim window stop casing picture mould back band back band drip cap drip cap batten panel mould casing architrave c casing casing casing c base casing casing casing base quarter round quarter round quarter round quarter round half round full round full round full round crown crown cove cove screen mould outside corner outside corner base shoe stop parting strip hand rail square 15 32

34 Index HEMLOCK Pattern # Profile Page # 3517 square architrave a architrave 2 1/4 x 4 mg s4s board 17 1/4 x 6 mg s4s board 17 1/2 x 4 mg s4s board 17 1/2 x 6 mg s4s board 17 1 x 2 mg s4s board 17 1 x 2 vg s4s board 17 1 x 3 mg s4s board 17 1 x 3 vg s4s board 17 1 x 4 mg s4s board 17 1 x 4 vg s4s board 17 1 x 5 mg s4s board 17 1 x 5 vg s4s board 17 1 x 6 mg s4s board 17 1 x 6 vg s4s board 17 1 x 7 vg s4s board 17 1 x 8 mg s4s board 17 1 x 8 vg s4s board 17 1 x 10 mg s4s board 17 1 x 10 vg s4s board 17 1 x 12 mg s4s board 17 1 x 12 vg s4s board 17 5/4 x 6 vg s4s board 17 5/4 x 8 vg s4s board 17 2 x 2 mg s4s board 17 t & g panel paneling 16 Primed MDF Pattern # Profile Page # 002 casing casing 3 19 casing 4 46 crown 9 48 crown 9 49 casing 2 49 crown casing base cap 16 Primed MDF Pattern # Profile Page # 214 casing base base casing base base base 8 300c wainscot cap casing base casing casing casing chair rail chair rail casing casing casing crown crown crown casing casing casing casing casing casing casing base base window stool base casing lintel opening trim window stop casing casing architrave architrave casing 7 Primed MDF Pattern # Profile Page # 1/2 x 4 s4s board 17 1/2 x 6 s4s board 17 1/2 x 8 s4s board 17 1 x 2 s4s board 17 1 x 3 s4s board 17 1 x 4 s4s board 17 1 x 5 s4s board 17 1 x 6 s4s board 17 1 x 7 s4s board 17 1 x 8 s4s board 17 1 x 10 s4s board 17 1 x 12 s4s board 17 5/4 x 4 s4s board 17 5/4 x 6 s4s board 17 5/4 x 8 s4s board 17 KNOTTY ALDER Pattern # Profile Page # 16 casing base casing base crown casing casing casing casing base base cove quarter round quarter round brick mould casing casing outside corner base base screen mould 23 33

35 Index KNOTTY ALDER Pattern # Profile Page # 495 casing crown casing base base base base floor cap panel cap stop lentil mould o.g. stop opening trim casing casing base base crown crown casing base backband architrave architrave 19 1 x 3 s4s boards 28 1 x 4 s4s boards 28 1 x 5 s4s boards 28 1 x 6 s4s boards 28 1 x 8 s4s boards 28 1 x 10 s4s boards 28 1 x 12 s4s boards 28 5/4 x 4 s4s boards 28 5/4 x 5 s4s boards 28 5/4 x 6 s4s boards 28 5/4 x 8 s4s boards 28 FINGER JOINT PRIMED PINE Pattern # Profile Page # 003 casing 3 32 casing 4 FINGER JOINT PRIMED PINE Pattern # Profile Page # 34 casing 4 45 outside corner crown 9 47 crown 9 49 crown 9 51 crown 9 54 crown 9 85 cove cove quarter round quarter round base shoe casing screen mould brick mould casing casing outside corner outside corner outside corner base crown parting stop lattice chair rail outside corner casing chair rail shake mould casing base base base base crown base base stop o.g. stop 14 FINGER JOINT PRIMED PINE Pattern # Profile Page # 953 opening trim casing casing casing casing casing casing crown crown 9 1 x 2 s4s boards 17 1 x 3 s4s boards 17 1 x 4 s4s boards 17 1 x 5 s4s boards 17 1 x 6 s4s boards 17 1 x 8 s4s boards 17 1 x 10 s4s boards 17 1 x 12 s4s boards 17 OAK Pattern # Profile Page # 20 wainscot cap wainscot cap casing casing base shoe square stop casing b casing counter edge casing backsplash counter edge lip mould screen mould cove base crown dentil 22 34

36 Index OAK Pattern # Profile Page # 651 outside corner outside corner quarter round quarter round base counter edge 24 1 x 2 s4s boards 28 1 x 3 s4s boards 28 1 x 4 s4s boards 28 1 x 5 s4s boards 28 1 x 6 s4s boards 28 1 x 8 s4s boards 28 1 x 10 s4s boards 28 1 x 12 s4s boards 28 2 x 2 s4s boards 28 2 x 4 s4s boards 28 2 x 6 s4s boards 28 CHERRY Pattern # Profile Page # 16 casing base casing base casing casing casing base base brickmould stop stop back band 24 MAPLE Pattern # Profile Page # 16 casing base casing base casing casing casing casing base base base stop stop back band 24 VG FIR Pattern# Profile Page# 1/2 x 4 s4s boards 17 1/2 x 6 s4s boards 17 1/2 x 8 s4s boards 17 1 x 2 s4s boards 17 1 x 3 s4s boards 17 1 x 4 s4s boards 17 1 x 4 flooring t & g flooring 17 1 x 5 s4s boards 17 1 x 6 s4s boards 17 1 x 8 s4s boards 17 1 x 10 s4s boards 17 1 x 12 s4s boards 17 5/4 x 4 s4s boards 17 5/4 x 6 s4s boards 17 5/4 x 8 s4s boards 17 2 x 2 s4s boards 17 2 x 3 s4s boards 17 2 x 4 s4s boards 17 2 x 6 s4s boards 17 2 x 8 s4s boards 17 2 x 10 s4s boards 17 2 x 12 s4s boards 17 4 x 4 s4s boards 17 35

37 Index MISC. Pattern # Profile Specie Page # 51 crown oak veneer brick mould v.g. fir brick mould mahogany veneer casing oak veneer casing oak veneer casing knotty pine casing oak veneer casing golden oak casing strand oak casing knotty pine casing oak veneer casing v.g. fir base v.g. fir base knotty pine base oak veneer stop cherry veneer stop maple veneer stop select alder veneer stop fir veneer stop oak veneer stop mahogany stop cherry veneer stop maple veneer stop oak veneer stop fir veneer stop select alder veneer stop cherry veneer stop maple veneer stop fir veneer stop select alder veneer stop cherry veneer stop maple veneer stop fir veneer stop select alder veneer cant strip solid pine casing golden oak casing golden oak 4 1 x 3 s4s boards regular mdf 17 1 x 4 s4s boards golden oak 17 1 x 4 s4s boards strand oak 17 MISC. Pattern # Profile Specie Page # 1 x 4 s4s boards regular mdf 17 1 x 5 s4s boards golden oak 17 1 x 5 s4s boards strand oak 17 1 x 5 s4s boards regular mdf 17 1 x 6 s4s boards golden oak 17 1 x 6 s4s boards strand oak 17 1 x 6 s4s boards regular mdf 17 1 x 7 s4s boards golden oak 17 1 x 8 s4s boards golden oak 17 1 x 8 s4s boards strand oak 17 1 x 8 s4s boards regular mdf 17 1 x 10 s4s boards regular mdf 17 1 x 12 s4s boards regular mdf 17 Notes 36

38