Item No. X090 SAETY IRST! All of NE kid s Bunkbeds were designed and manufactured with your child s safety as our top priority. Their unparalleled strength is a bi-product of the safety design. Our bunks meet all compliance with ASTM 1427-07 Standard onsumer Safety Specification for Bunk Beds and ode of ederal Regulations (R) 1213 Safety Standards for Entrapment Hazards in Bunk Beds and (R) 1513 Requirements for Bunk Beds. Safety is a cooperative effort between us as the manufacturer, and you as a guardian. Please read and consider the warnings listed on this page when choosing a mattress and discussing rules of use with your child. REPLAEMENT PARTS Replacement parts, including additional guardrails, may be obtained from any of NE kids dealers. Assembly Instructions Page 1 of 21 STAIRASE LOT BE!! SAETY WARNINS 1. ollow the information on the warnings appearing on the upper bunk end structure and on the carton. o not remove warning label from bed. 2. Always use the recommended size mattress or mattress support, or both, to help prevent entrapment or falls. 3. Surface of mattress must be at least 5 inches (127 mm) below the upper edge of guardrails. 4. o not allow children under 6 years of age to use the upper bunk. 5. Prohibit more than one person on the upper bunk. 6. Periodically, check and ensure that the guardrail, stairs, and other components are in their proper position, free from damage, and that all connectors are tight. 7. o not allow horseplay on or under the bed and prohibit jumping on the bed. 8. Always use the stairs for entering and leaving the upper bunk. 9. o not use substitute parts. ontact the manufacturer or dealer for replacement parts. 10. Use of a nightlight may provide added safety precaution for a child using the upper bunk. 11. Always use guardrails on both long sides of the upper bunk. If bunk bed will be placed next to the wall, the guardrail that runs the full length of the bed should be placed against the wall to prevent entrapment between the bed and wall. 12. The use of water or sleep flotation mattresses is prohibited. 13. Keep these instructions for future reference. STRANULATION HAZAR Never attach or hang items to any part of the bunk bed that are not designed for use with the bed; including, but not limited to, hooks, belts and jump ropes SIZE O MATTRESS AN OUNATION Use only mattress, foundation and deck combined which is 74-75 inches long and 37 ½-38 ½ inches wide on upper bunk. Ensure thickness of mattress and foundation combined does not exceed 8 inches and the mattress is at least 5 inches below upper edge of guardrails. NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
Assembly Instructions STAIRASE LOT BE Item No. X090 Page 2 of 21 INTROUTION Enclosed please find simple step-by-step instructions to help you quickly assemble your product. Before you begin we recommend that you follow the steps below: 1. Please read the instructions thoroughly 2. Identify all parts and hardware 3. ather the tool(s) necessary 4. 2 adults required for assembly To protect your parts during assembly please place them on a soft surface.to clean surface use only water on a damp cloth. o not use window cleaners or cleaning abrasives as it will scratch the surface and could damage the protective coating. USTOMER SUPPORT If you are missing parts or need assistance with your product, please contact the retailer from whom you purchased the product. When you call or email, please include the Product s Item Number and PO Number which is located on the Production Tracking Sticker. This sticker can be found on the bottom, inside or back of your product. ully Assembled Staircase Loft NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
A STAIRASE LOT BE - Assembly Instructions PARTS LIST 110mm Bolts X 2 1 3 6 Page 3 of 21 B 90mm Bolts X 8 60mm Bolts X 20 Toy Box Top Support 40mm Bolts X 34 7 E 40mm Screws X 4 Barrel Nuts X 26 Toy Box Side Supports X 2 H I J 8mm Wood owels 2 30mm Screws X 26 20mm Screws 0 10mm Wood owels X 4 2 Outer Staircase Support Panel 4 Inner Staircase Support Panel 8 9 Toy Box Back K 25mm Bolts X 2 Toy Box Sides X 2 L M T-Nuts X 2 Allen Wrench 5 Staircase/rawers 10 Back Staircase Support Panel Toy Box ront Toy Box Bottom NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions PARTS LIST (ONTINUE) Other Tools Required (Not Included) Phillips Screwdriver Page 4 of 21 lathead Screwdriver 11 15 20 Bed Side Rails X 2 16 esk top Top Bottom 21 esk abinet 17 esk Hutch Back Supports (of each type) 12 13 18 uard Rails X 2 esk Hutch Top Panel 22 19 Left & Right esk Hutch Side Panels Headboard Set of Slats NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 5 of 21! NOTE: Before beginning assembly, decide exactly where the bed is to be placed and on which ends you would like the the esk and Staircase. Both the Staircase and esk can be placed at either end and reversed. See below. or right-hand side Staircase assembly, please start at Step 1 on Page 6. or left-hand side Staircase assembly, please skip to Step 1A on Page 9. NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 6 of 21 Steps 1-5: Right-hand Staircase assembly STEP 1 STEP 2 Assemble Toy Box and Support. 5 9 10 9 8 Lay Staircase/rawers flat on its side with drawer fronts facing you and the top facing right. Put Toy Box Support in place with the lip catching the notch at the bottom of Staircase as shown. ently lower and attach Inner Staircase Support Panel making sure to align the open side with the top stair. Be careful not to scratch the finish while positioning the panel, this damage would not be covered under the warranty. We recommend two adults for this step. B 3 7 6 7 6 7 4 NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 7 of 21 STEP 3 STEP 4 Turn partially assembled Staircase over then gently lower and attach the Outer Staircase Support Panel. Again, be careful not to scratch the finish while positioning the panel, this damage would not be covered under the warranty. We recommend two adults for this step. Stand Staircase upright and attach Back Staircase Support Panel. 3 B 2 1 1 3 4 NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 8 of 21 STEP 5 With two adults, lift the Staircase into desired position. Skip to Step 6 on Page 11 NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 9 of 21 STEP 1A Steps 1A-5A: Right-hand Staircase assembly STEP 2A Assemble Toy Box and Support. 8 9 Lay Staircase/rawers flat on its side with drawer fronts facing you and the top facing left. Put Toy Box Support in place with the lip catching the notch at the bottom of Staircase as shown. ently lower and attach Inner Staircase Support Panel making sure to align the open side with the top stair. Be careful not to scratch the finish while positioning the panel, this damage would not be covered under the warranty. We recommend two adults for this step. 9 10 5 B 3 6 7 7 7 4 6 NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 10 of 21 STEP 3A Turn partially assembled Staircase over then gently lower and attach the Outer Staircase Support Panel. Again, be careful not to scratch the finish while positioning the panel, this damage would not be covered under the warranty. We recommend two adults for this step. STEP 4A Stand Staircase upright and attach Back Staircase Support Panel. B 3 1 2 1 4 3 NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 11 of 21 STEP 5A STEP 6 Steps 6-10: esk Hutch assembly With two adults, lift the Staircase into desired position. Loosely affix esk Top to Right esk Hutch Side Panel (do not completely tighten bolts). Remove drawers from esk abinet, then attach Right esk Hutch Side Panel to esk abinet. 15 13 13 11 11 X 2 X 2 NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 12 of 21! NOTE: Before continuing assembly, decide whether you would like the esk to be outside-facing or inside-facing and follow instructions below. STEP 7 Steps 7-9: Outside-facing esk assembly it esk Hutch Back Supports, esk Top, and Left esk Hutch Side Panel together using wood dowels(12). 13 16 or outside-facing esk assembly, please continue with Step 7 on This Page. 15 11 12 17 or inside-facing esk assembly, please skip to Step 7A on Page 15. NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 13 of 21 STEP 8 Secure esk Hutch Side Panels and Back Supports as shown and tighten any bolts that were left loose. K K L RONT VIEW L 13 13 REAR VIEW L L K K 12 12 E NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 14 of 21 STEP 9 Attach esk Hutch Top Panel. E E E 18 Skip to Step 10 on Page 16 NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Steps 7A-9A: Inside-facing esk assembly Page 15 of 21 STEP 7A STEP 8A STEP 9A it esk Hutch Back Supports, esk Top, and Left esk Hutch Side Panel together using wood dowels(12). 13 16 K Secure esk Hutch Side Panels and Back Supports as shown and tighten any bolts that were left loose. 13 L Attach esk Hutch Top Panel. E 18 E E 11 15 L K 12 12 17 E NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 16 of 21 STEP 10 STEP 11 Steps 11-14: Upper Bed assembly With two adults, move the esk Hutch into position then replace the drawers. Attach Headboard to the top of the esk Hutch. 19 19 or outside-facing esk assembly or inside-facing esk assembly NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 17 of 21 STEP 12 Attach Headboard/esk Hutch, Bed Side Rails and Staircase (do not completely tighten bolts until Step 14). B 19 J B 20 etail for all four corners 20 A B NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 18 of 21 STEP 13 Attach Slats. H H H 22 22 Lay slat roll between side rails and screw in slats to slat support as indicated. Make sure rails are pulled into slats prior to screwing in place.! WARNIN To help prevent serious or fatal injuries SREW BOTH SIES O EAH SLAT TO THE SLAT SUPPORT. ailure to do so could result in the collapse of the entire slat roll, and will void your warranty. NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 19 of 21 STEP 14 Position uard Rails in place, tighten all Bed Side Rail bolts completely, then attach uard Rails as shown. I 21 I etail for both sides 21 etail for all four corners NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions Page 20 of 21 STEP 15 With at least two adults, make sure the loft is in desired final position then slide the Toy Box into place. NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com
STAIRASE LOT BE - Assembly Instructions ARE INSTRUTIONS Page 21 of 21 A lacquer finish is used on this furniture to protect the wood. It is not waterproof, clean spills immediately. ust using a slightly damp cloth, making sure no standing water is left on the furniture. O NOT use any household cleaners, citrus-based polishes, wood soaps, or oils; they can break down the natural lacquer finish. o not place furniture in direct sunlight. Natural solid wood furniture will naturally color as it ages, however, direct sunlight dramatically speeds up the process. In natural wood furniture, the variations in texture and grain will affect the finish, making it impossible to guarantee an exact match between two pieces of wood even though identical finishing processes are used. These differences in character are not defects, but variations that make each piece of furniture unique and beautiful. Solid wood naturally expands and contracts. In high humidity you may find that drawers can stick slightly. This will correct itself, and is not reason for concern. o not place furniture over heating or cooling vents. ramatic changes in temperature can cause the wood to split. If you place objects such as lamps or plants on your case pieces make sure to move them from time to time. There may be a slight discoloration where the object was. However, by exposing it to light the color will catch up to the rest of the case. Plastic or foam footed items such as phones or clocks can damage this finish, use trivets under such items. NE kids 2300 Prospect r. hristiansburg, VA 24073 www.ne-kids.com