THE CENTRAL OHIO TRANSIT AUTHORITY BID FORM 1 BID FOR: Miscellaneous Parts for Transit Coaches RFB # 2016-13 1 80 EA 1792 FITTING AEROQUIP 63-190990-4 2 48 EA 8409 FITTING, SWIVEL AEROQUIP 63-190600-16 3 3 EA 26831 BUTTON, HANDLE - KNOB FOR PARKING BRAKE NEW FLYER 5922627 4 24 EA 35725 BOLT, WINDSHIELD SADDLE FLXIBLE 97-4782-159 MCI 3G-34-74 5 18 EA 36020 VALVE KIT, R-12 & R-14 BENDIX 102802N 6 300 EA 36798 PIN, FEMALE, 16-14 GA *** OEM DELPHI ONLY *** DELPHI 12124580 7 12 EA 37226 FITTING, W/W SPACER NEW FLYER 6336661 8 8 EA 42259 ELBOW, MALE, 1/4" MPT, 1/4" TUBE SAE WEATHERHEAD 49X4X4 9 24 EA 42317 CONNECTOR, MALE, 1/8MPT-1/4TU SAE WEATHERHEAD 48 X 4 10 24 EA 57737 PIPE, MALE TO FEMALE, 1/4MPT-1/4FPT BENDIX 276068N 11 160 EA 59501 LOCK,NUT,WHEEL BEARING,FRONT MERITOR R002659 12 16 EA 72918 CLAMP, TILLER; STOP REQUEST CABLE NEW FLYER 6342763 13 2 EA 73841 LAMP, FRONT STEPWELL TRUCKLITE 40203 NEW FLYER 047003 14 540 EA 75028 SEAL, CAMSHAFT METAL OD *** OEM NEW FLYER ONLY *** NEW FLYER 5942748NFA 15 48 EA 75077 BUSHING NEW FLYER 6329692NFA NEW FLYER 6329692 16 4 EA 75432 HORN BUTTON NEW FLYER 150892 17 108 EA 75556 BEARING, CONE OUTER FRONT *** OEM TIMKEN ONLY *** TIMKEN 555-S 18 150 FT 76117 HOSE, MARINE 1IN ID X 1.48IN OD NAPA H151 19 400 EA 76133 FASTENER BUMPER NEW FLYER 097688 20 100 EA 78410 WASHER, CAMSHAFT.12" MERITOR 1229W3117 21 180 EA 85050 ARMREST, ADJUSTABLE, DRIVER, RIGHT NEW FLYER 6341654 GILLIG 82-30990-000 22 50 EA 88732 FITTING, GREASE, 1/4"-28 TAP/THREAD 35/64" NAPA 715-2003 23 8 EA 89102 BELT TENSION GAUGE GATES 91132 24 32 EA 95042 CHAMBER, BRAKE 3636 GILLIG 09-40978-000 25 8 EA 95091 SWITCH, DIMMER W/HARNESS ASSEMBLY GILLIG 13-44189-000 26 16 EA 95190 ADAPTER, PUMP, WASHER GILLIG 18-47826N000 27 4 EA 95273 SEAL, WINDSHIELD GLAZING GILLIG 26-45512-001 28 32 EA 95281 SWITCH, TURN SIGNAL GILLIG 13-55950-000 29 8 EA 95463 SWITCH, RHEOSTAT 12V GILLIG 51-10534-002 30 36 EA 95604 BIKE RACK ASM, W/DEPLOYMENT SPORTWORKS 100634-DPLY GILLIG 53-63966-000 31 24 EA 95653 LATCH PIN ASSY, DL2 SPORTWORKS 100179 32 24 EA 95885 FUSE, 100 AMP GILLIG 51-19332-100 33 12 EA 95893 FUSE, 125 AMP GILLIG 51-19332-125 ( +
( + 34 4 EA 95927 SOLENOID, 24 VOLT 85 AMP GILLIG 51-21794-005 35 4 EA 96016 GAUGE, VDO OIL PRESSURE - 150 PSI GILLIG 51-22968-032 36 8 EA 96214 SWITCH, JOY STICK W/HARNESS *** OEM GILLIG ONLY *** GILLIG 51-42261-000 37 8 EA 96370 BELL, ALARM 12-18VD GILLIG 53-00411-000 38 144 EA 96743 SPRING ASSY, GAS GILLIG 53-20347-008 39 84 EA 96867 GASKET, SURGE TANK CAP GILLIG 53-25343-000 40 6 EA 96917 ELBOW, RUBBER GILLIG 53-27653-006 41 8 EA 96958 VALVE, MODULATOR GILLIG 82-66801-000 42 96 EA 97212 HOSE, SILICONE, 2-1/4IN GILLIG 56-09019-004.00 43 200 EA 97378 WASHER, CAMSHAFT.11" MERITOR 1229S2697 44 200 EA 97386 WASHER GILLIG 82-03397-000 45 4 EA 98764 MIRROR, HEAD ASSM 9 X 11 - LH/SS GILLIG 82-31143-000 46 4 EA 101154 STOW LATCH ASSEMBLY, W/C LIFTU D29-5909 47 10 EA 101402 SOLENOID ASSEMBLY, WCL, LU11 LIFTU 313-0165 48 12 EA 101410 LATCH, WCL LIFTU D21-8086 49 4 EA 101725 CONTROL PANEL ASSEMBLY, WCL LIFTU 361-0054 50 16 EA 102020 HANDLE, DOOR NEW FLYER 010458 51 6 EA 102095 CALBE, INTERLOCK ADAPTER KIT 24V LIFTU 373-0257 52 50 EA 104174 NUT, FLGHD 1/2-20 GR8 GILLIG 54-12555-009 53 50 EA 104182 BOLT, FLGHD 1/2IN - 20IN X 2IN, GR8 GILLIG 54-11349-007 54 16 EA 104828 HARNESS, FIRE DETECTOR LONG GILLIG 50-54564-008 55 50 EA 108589 FITTING, GREASE LONG NEW FLYER 6333903 56 6 EA 109108 SLEEVE BEARING, SST BACKED WCL LIFTU D45-1776 57 16 EA 109322 KIT, REMOTE RELEASE WCL QSTRAINT Q8-6301-RA 58 40 EA 109413 ADAPTOR PARKER 4-4FTX-S 59 8 EA 110312 NOZZLE, FUEL ;POSI-LOCK (WITH VITON SEALS) *** OEM EMCO WHEATON ONLY *** EMCO WHEATON G2266-109 60 16 EA 110767 BRACKET, STANDOFF SPORTWORKS 100669 61 50 EA 111047 CLAMP, 13/16" - 1-3/4" CONSTANT TORQUE BREEZE CT-9420 62 50 EA 111062 CLAMP, 1-5/16" - 2-1/4" CONSTANT TORQUE BREEZE CT-9428 63 12 EA 111617 BOLT, WIPER SADDLE GILLIG 82-27706-003 64 36 EA 111724 HOSE ASM, PARKER 293, BRAKE CHAMBER REAR GILLIG 46-08i8186-0230 65 16 EA 112243 STOP, ACCESS DOOR 7.0" GILLIG 41-10761-000 66 36 EA 114355 CLAMP, EXHAUST GILLIG 53-28193-004 GILLIG 01-63586-001 CUMMINS 5290118 67 12 EA 114421 CLAMP, BAND GILLIG 01-58454-000 68 4 EA 115295 FUSE, 600 AMP GILLIG 51-19332-600 69 16 EA 116152 NUT, RING ALARM GILLIG 82-34670-000 70 12 EA 116350 CONTROL BOX ASSEMBLY, LU11 LIFTU 371-0329 71 48 EA 116517 SEAL, 50DN SEAL SERVICE PACKAGE *** OEM DELCO ONLY *** DELCO 10514967 72 4 EA 117044 BRUSH, HORN ASSEMBLY GILLIG 82-06170-001 Bid Form 1a
( + 73 8 EA 117267 CABLE ASSEMBLY GILLIG 50-25352-035 74 6 EA 117507 GLAZING, SLIDER RH GILLIG 82-48050-206R 75 24 EA 117531 CHAMBER ASM, SPRING BRAKE GILLIG 04-39465-000 76 48 EA 117648 SPRING, RETAINER GILLIG 82-11994-000 77 48 EA 117663 SEAL, OIL (CR) *** OEM SKF ONLY *** SKF 47697 78 24 EA 118018 FLATWASHER, 1/32" GILLIG 82-10276-007 79 24 EA 118067 SPRING, RETURN BRAKE GILLIG 82-30541-000 80 128 EA 118760 STRIKER LIFTU 750-0466 81 128 EA 118786 LOCKNUT, NYLON INSR THIN LIFTU 423-9052 82 8 EA 118810 EQUALIZER, 100 AMP W/CAN PLUG GILLIG 13-56851-000 83 3 EA 118893 POST GILLIG 14-65437-004 84 36 EA 120220 FENDER, RUBBER GILLIG 20-42976L096.00 85 12 EA 120717 KNOB, POTENTIOMETER GILLIG 82-51141-002 86 4 EA 120808 HEIM JOINT, MALE ROD END 1/2" UPPER ARMS ** OEM GILLIG ONLY ** GILLIG 82-27576-004 87 8 EA 120824 BRACKET ASM, W/ROLLER GILLIG 82-27576-001 88 8 EA 128256 HORN, BUTTON ASSEMBLY GILLIG 05-62023-000 89 144 EA 128512 FLAP, MUD REAR GILLIG 06-49500-000 90 16 EA 128884 PLATE, NUT REAR BUMPER MTG GILLIG 06-54159-000 91 24 EA 130674 ENCLOSURE ASM. BATTERY FUSING GILLIG 13-66188-006 92 6 EA 137810 GUARD, LAMP GILLIG 20-51676-000 93 6 EA 141572 HOSE ASM, RETARDER ACCUMULATOR GILLIG 46-20B1014-0210 94 16 EA 142299 HARNESS, FIRE DETECTION WIRE GILLIG 50-54564-002 95 6 EA 142331 HARNESS, ADJUSTABLE FOOT PEDAL GILLIG 50-56460-001 96 4 EA 143172 CONNECTOR, CAP DIAGNOSTIC - ENG/ABS GILLIG 51-26164-025 97 16 EA 143305 SWITCH, ROTARY WINDSHIELD WIPER GILLIG 51-34477-004 98 24 EA 143529 SPEAKER, EXTERIOR GILLIG 51-52445-000 99 4 EA 143677 GAUGE, FUEL GILLIG 51-55148-011 100 24 EA 144576 MOUNT, ENGINE REAR CUSHYFLOAT GILLIG 53-21338-004 101 100 EA 148841 LOCKNUT, NYLOCK SHOCK MOUNTING 3/4-16 GILLIG 54-12551-012 102 56 EA 155309 BOLT, 5/8"-18 X 3.0" GR8 RADIUS ROD FRONT GILLIG 54-11353-011 103 4 EA 157487 HOSE ASM, #4 FC300 GILLIG 46-04B1115-0420 104 100 EA 159590 HOSE, SILICONE 5/16" ID - OVERFLOW ** 1 ROLL EQUALS 50 FEET ** ** OEM NAPA ONLY ** NAPA WHEH22505 105 16 EA 160515 END ASM, RH TIE ROD MERITOR R230069 106 12 EA 160531 END ASM, LH TIE ROD MERITOR R230068 107 32 EA 164640 BUSHING, REAR TRANSVERSE BEAM GILLIG 82-48172-012 108 24 EA 172619 CHAIN STRAND; 3/8"P, 69 LINKS LIFTU 151-3038 109 20 EA 173187 HEX SOC HD CAP SCREW, SST LIFTU 412-9405 110 96 EA 173211 HEX SOC FLAT HD CAP SCREW LIFTU 413-9007 Bid Form 1b
( + 111 48 EA 173245 HEX SOC FLAT HD CAP SCREW LIFTU 413-9102 112 60 EA 173674 RETAINING RING LIFTU 432-0810 113 100 EA 173997 RIVET, SST BLIND LIFTU 440-0016 114 24 EA 174292 GEAR/MOTOR ASSEMBLY LIFTU 748-0034 115 64 EA 174326 BEARING ASSEMBLY LIFTU 748-0037 116 6 EA 174698 HINGED CLOSEOUT ASSEMBLY LIFTU 748-0114 117 8 EA 174870 COUNTER BALANCE ASSEMBLY, FWD LIFTU 748-0128 118 8 EA 174904 COUNTER BALANCE ASSEMBLY, REAR LIFTU 748-0129 119 8 EA 176131 CHAIN COVER, REAR LIFTU 750-0647 120 3 EA 176370 COUPLING INSERT, HYTREL LIFTU D45-9082 121 48 EA 183566 RING, RETAINING HEADLIGHT GILLIG 82-10988-002 122 6 EA 193516 SEATBELT ASM, 2 POINT GILLIG 82-17103 123 36 EA 209023 SAFETY CLIP, BRAKE PEDAL GILLIG 82-44773-002 124 12 EA 209106 PIVOT PIN, BRAKE PEDAL GILLIG 82-44773-005 125 12 EA 209171 PLUNGER, BRAKE TREADLE GILLIG 82-44773-007 126 4 EA 214270 MODULE, INLET-DPF GILLIG 82-51277-000 127 36 EA 225953 ROLLER, UPPER PIVOT GILLIG 20-43337-000 128 36 EA 253104 EXTRUSION, CHASSIS POST GILLIG 14-65437-000 129 672 EA 312520 PB BLASTER, PENETRATING CATALYST NAPA 16PB 130 36 EA 313486 GENERATOR, 50DN *** OEM DELCO ONLY *** DELCO 8600191 131 2 EA 313726 MODULE, LIGHTING DINEX GILLIG 13-41361-066 132 8 EA 313817 SENSOR, FIRE (350 DEGREES) - HYBRID GILLIG 53-28158-033 133 12 EA 315333 CONTROL BOX ASSEMBLY LIFTU 371-0344 134 4 EA 315549 GLAZING, UPPER SAFETY GLASS GILLIG 20-61107-003 135 8 EA 315648 REGULATOR, VOLTAGE E-FAN NIEHOFF A2-336 NIEHOFF A2-330 136 4 EA 316083 TOOL, EXTRACTION AMP 189727-1 137 24 EA 316331 SPEAKER, EXTERIOR GILLIG 51-11768-002 138 2 EA 316521 HOSE, HYDRAULIC GILLIG 46-20A1010-0320 139 4 EA 316596 COIL, 24V P/S & FAN DRIVE CONTROL GILLIG 13-69957-000 140 16 EA 316802 LATCH HINGE ASSEMBLY LIFTU 748-0272 141 24 EA 316810 STRIKER LIFTU 748-0429 142 12 EA 318550 HANDLE, DOOR SHORT VAPOR 57321791-26 143 6 EA 320622 SWITCH, PROXIMITY ACCESS PANEL GILLIG 13-42070-001 144 8 EA 320929 HARNESS, FIRE DETECTION GILLIG 50-54564-006 145 16 EA 320986 PLUG, DRAIN GILLIG 82-61315-001 146 12 EA 321018 RECEPTACLE, FAST FILL CNG GILLIG 82-76142-001 147 24 EA 322024 SPRING, AIR LF FRONT GILLIG 08-66892-000 148 16 EA 322669 ROLLER LIFTU 745-0381 Bid Form 1c
149 32 EA 322990 PLUGS, LATCH HANDLE FINISHING SPORTWORKS 100829 150 4 EA 323139 HARNESS, SCT AFTERTREATMENT GILLIG 50-64668-001 151 12 EA 323220 ADJUSTER, SLACK RIGHT HAND MERITOR A123275R616 HALDEX 300-10159 GILLIG 82-59787-001 152 12 EA 323238 ADJUSTER, SLACK LEFT HAND MERITOR A203275Q615 HALDEX 300-10158 GILLIG 82-59787-000 153 4 EA 323402 LAMP, ENGINE COMPARTMENT GILLIG 51-64767-001 154 8 EA 323626 HOSE, HUMP 2.5 X 6.0 GILLIG 56-09125-004 155 12 EA 323667 LAMP, STOP 18" STRIP RED HIGH BEAM GILLIG 51-55513-000 156 48 EA 323675 LAMP, HEADLIGHT LED LOW BEAM GILLIG 51-68875-002 DIALIGHT HLC434CB12 157 4 EA 324475 CAMSHAFT, RH GILLIG 82-43907-000 158 4 EA 324582 SUPPORT ARM ASSMEBLY SPORTWORKS 100780 159 6 EA 324855 BELT, SEAT - WHEECHAIR TIE-DOWN GILLIG 82-61400-000 160 4 EA 324863 GAUGE, PRESSURE 5000 PSI - CNG GILLIG 82-76142-000 161 12 EA 325407 SHOCK, FRONT GILLIG 08-67835-000 # OF ITEMS BID GRAND TOTAL $ ( + DELIVERY IN DAYS: TERMS OF PAYMENT: 15 CALENDAR DAYS AFTER ISSUANCE OF ORDER FOB 1600 MCKINLEY AVENUE, COLUMBUS, OH 43222 NET 30 DAYS BIDDER'S EMPLOYER TAX ID NUMBER: COMPANY NAME AND ADDRESS AUTHORIZED SIGNATURE NAME AND TITLE - (TYPED) PHONE NUMBER/FAX NUMBER/ E MAIL ADDRESS *NOTE: PRICE IS EXCLUSIVE OF TAX THIS PAGE MUST BE SIGNED COMPLETED COPY OF MICROSOFT EXCEL FILE, "RFB # 2016-13 BID WORKSHEET", (BID FORMS 1 THORUGH 1d) ON COMPACT DISK OR FLASH DRIVE MUST BE INCLUDED. SEE SECTION 1, PARAGRAPH 9. THE LOWEST PRICE BID PER LINE ITEM WILL BE DETERMINED AS FOLLOWS: PLUS. LINE ITEMS BID WITHOUT MANUFACTURER AND PART NUMBER WILL BE CONSIDERED NONRESPONSIVE. Bid Form 1d