YIELD SIMPLE... AFFORDABLE... ENERGY EFFICIENT... LOW MAINTENANCE... Energy Efficient Engineering Water Solutions
The System from Inc. is a revolutionary new mobile advanced treatment system platform. The self-contained system combines the benefits of treatment, distribution, recirculation and disinfection into a single complete pre-engineered wastewater solution. Applications Remote Camps Arctic Environments Disaster Relief Temporary Events Military Operations Proven Treatment Capabilities The heart of the Systems is the proven performance of the AeroCell open cell foam biofilter. The AeroCell media has been extensively tested throughout the world for almost twenty years. Independent third party testing has revealed the open cell foam technology effectively treats wastewater to secondary and tertiary levels. Third party testing has been conducted in the cold climates of Alaska to the heat of Texas with outstanding and consistent results. Simple Operation The System has been designed and constructed with simplicity in mind. The system operation includes very few electrical or moving parts, no sludge accumulation, no complex chemical feeding systems or instrumentation and very little oversight required. Site NSF Standard 40 Testing Alaska Cat. III w/nitrogen Reduction Comm. & Multi-Family Various Systems CBOD5 TSS TN 2 2 9 10 6 22 19 13 Not tested Products show covered by U.S. and/or international patents. Other U.S. and/or international patents may be pending. 2008 Incorporated, all right reserved.
An Affordable Solution The System provides economic benefits in terms of its infrastructure costs, daily operational costs and personnel requirements. The initial capital expenditure of the System is significantly lower than the outdated or complex technologies currently in use. Due to the reduced complexity of the system, daily operational costs are as much as 80% lower than activated sludge and membrane technologies. The ease of operation allows increased economic benefits to the owner through reduced operator oversight. A single operator could actually successfully operate multiple systems simultaneously. Low Maintenance Requirements The System contains only a few pumps, filters and distribution mechanisms that must be maintained on a regular basis. The actual treatment technology is a fixed film media filter, which produces little to no sludge. The treatment requires no chemical addition for proper operation, no backwashing and there are no complicated controls, blowers and etc that must be constantly monitored and adjusted. The simplistic approach to treatment is fast becoming the preferred methodology worldwide. Operational costs are as much as 80% lower! AeroCell foam cube media at one year Energy Conservation The Synergy wastewater treatment trailers are as much as five times more energy efficient than any activated sludge. Benefits Modular Design - Multiple Synergy units may be combined for larger flows. Environmentally Friendly - Unsurpassed treatment levels. Open trench dispersal in most cases. Post-treatment effluent sample from NSF testing facility Powered By: No more disposal fees! Completely self contained system! No more dedicated maintenance personel! Engineering Water Solutions
YIELD Speed Limit The System from Inc. is a revolutionary new mobile advanced treatment system platform. The self-contained system combines the benefits of treatment, distribution, recirculation and disinfection into a single complete pre-engineered wastewater solution. Applications Proven Treatment Capabilities Control Panel 2500 mph gpd Heater/fan Along with the insulated wall and floor, the entire is heated through ceiling mounted thermostatically controlled electric heaters. Air Induction System The duplex pumps are controlled by an easy to operate alternating control panel. The panel includes a water level display and easy to use HOA switches visible through a clear outer door. This simple to operate system provides a constant stream of warm air into the middle of the treatment media. Mobile Energy Efficient Low Maintenance Cost Effective Load Center The Synergy unit is pre-wired and includes a generator ready 200 amp load center. Pressure Filter Standard Septic/Treatment Trailer Layout Site CBOD5 TSS TN Final filtration of the effluent before being delivered to the spray nozzles occurs through the use of wall mounted filters. rated at 2500 gpd Side entry door Simple Operation Inlet 2500 Gallon 1700 Gallon with Aeration 1550 Gallon Outlet Advanced Treatment Module Seasonal Drain Recirculation Tank Pressure Transducer Mounted inside a sight tube, the pressure transducer provides constant water level readings to the panel controlling pump cycles and recirculation rates. Insulated 53 Trailer Energy Efficient The Synergy wastewater treatment trailers are as much as five times more energy efficient than any activated sludge treatment system. Recirculation Device & Solenoid Valve Chlorination Holding Tank & Tablet Feeder Disinfection is achieved through the use of standard chlorine/dechlorination tablet feeders. A 250-gallon fiberglass chlorine contact chamber provides increased retention for maximum disinfection. Pumps Duplex self-priming centrifugal pumps provide dosing to the treatment modules at a maximum flow rate of 100 gpm. Effluent exiting the treatment module is split for maximum treatment. During periods of low flow the control panel automatically positions the solenoid valve to achieve 100% recirculation. E n g i n e e r i n g Wa t e r S o l u t i o n s
10,000 gpd Primary Septic Tank Trailer Layout 5000 gpd Side Entry Treatment Trailer Layout Standard Features 53 insulated/heated trailer Septic/Treatment tanks Recirculation tanks Pressure Filters Control Panel w/transducer Air induction system Generator ready load center Side door entry Lighting and electrical Chlorination/Dechlorination Operation & maintenance manual Optional Features Uninsulated trailer Cooling system UV disinfection Rear door entry Customized layout available Distributed By: Engineering Water Solutions P.O. Box 1520 Crestwood, KY 40014 www.quanics.net 877-QUANICS