Chemical Compatibility Chart

Transcription

1 Chemical Compatibility Chart

2 Chemical Compatibility Chart Introduction The selection of materials that comprise the wetted components of a fluidic system needs to be reviewed for compatibility with the gas or liquid media to be employed. Depending on the type and aggressiveness of the media interacting with these components, swelling, reduced life, decreased performance or catastrophic failure could occur. The following compatibility chart should be referenced to properly select materials for specific fluidic applications. This information is compiled from a variety of resources based on technical data and tests made available by various chemical, elastomer, and plastic resin suppliers. Recommendations made in this publication shall not constitute a guarantee or warranty of performance nor a modification or alteration of our standard product warranty, which shall be applicable to such products. This guide is believed to be accurate, but due to the many variables, which may affect the compatibility of materials, this information should be considered as a guide only. Actual decisions on material selection need to be thoroughly tested and evaluated by the customer for each specific application. It is the full responsibility of the customer to perform and evaluate the compatibility of materials for their requirements. Compatibility Legend 1.Excellent (minimal or no effect) 2.Good (possible swelling and/or loss of physical properties) 3.Doubtful (moderate or severe swelling and loss of physical properties) 4.Not Recommended (severe effect and should not be considered) 127 Speedway Drive Mooresville, North Carolina Telephone Fax

3 Acetaldehyde Acetamide Acetanilide 1 Acetate Solvent (pure) Acetic Acid Acetic Acid, 20% Acetic Acid, 80% Acetic Acid (dilute) Acetic Acid (glacial) Acetic Acid (hot, high pressure) Acetic Anhydride Acetic Oxide (Acetic Anhydride) Acetone Acetone Cyanohydrin Acetonitrile Acetophenone Acetyl Acetone Acetyl Bromide 4 Acetyl Chloride Acetyl Chloride (dry) Acetyl Salicylic (Aspirin) Acetylene Acetylene Tetrabromide Acetylene Tetrachloride 1 Acrolein (Acrylaldehyde) Acrylaldehyde Acrylonitrile Adipic Acid Alcohols: Amyl Alcohols: Benzyl Alcohols: Butyl Alcohols: Diacetone Alcohols: Ethyl Alcohols: Hexyl Alcohols: Isobutyl Alcohols: Isopropyl Alcohols: Methyl Alcohols: Octyl Alcohols: Propyl Alkane (Dodecyl Benzene) Alkane Sulfonic Acid Alkyl Aryl Sulfonate Alky Alcohol Alkyl Benzene Alkyl Chloride Allyl Alcohol Allyl Bromide Allyl Chloride Alum Alum 10% Alum 100% Aluminum Acetate Aluminum Bromide Aluminum Chloride Aluminum Chloride 20% Aluminum Fluoride Aluminum Hydroxide Aluminum Nitrate Aluminum Oxide, abrasive Aluminum Phosphate Aluminum Potassium Sulfate Aluminum Potassium Sulfate, 10%

4 Aluminum Potassium Sulfate, 100% Aluminum Salts Aluminum Sodium Sulfate Aluminum Sulfate Alums Amines Aminobenzene (Aniline) Aminobutane (Butyl Amine) Aminosalicyclic Acid 1 1 Ammonia, 10% Ammonia Nitrate Ammonia, anhydrous Ammonia, liquid Ammonia Gas, cold Ammonia Gas, hot Ammonia Liquours Ammonia Nitrate Ammonium Acetate Ammonium Bicarbonate Ammonium Bifluoride Ammonium Bisulfite 1 1 Ammonium Bromide 1 1 Ammonium Carbonate Ammonium Chloride Ammonium Cupric Sulfate Ammonium Dichromate Ammonium Diphosphate 4 1 Ammonium Fluoride Ammonium Fluosilicate 1 1 Ammonium Hydrogen Fluoride Ammonium Hydroxide Ammonium Hydroxide, 10% Ammonium Hydroxide, 46.5% Ammonium Hydroxide, 3 molar Ammonium Hydroxide, conc Ammonium Iodide 1 1 Ammonium Monophosphate Ammonium Nitrate Ammonium Nitrite Ammonium Oxalate Ammonium Perchlorate 1 1 Ammonium Persulfate Ammonium Phosphate Ammonium Phosphate, Dibasic Ammonium Phosphate, Monobasic Ammonium Phosphate, Tribasic Ammonium Salts Ammonium Sulfate Ammonium Sulfide Ammonium Sulfite Ammonium Thiocyanate Ammonium Thiophosphate 1 1 Ammonium Thiosulfate Ammonium Triphosphate Amyl Acetate Amyl Alcohol Amyl Alcohol (Pentanol) Amyl Amine 1 1 Amyl Borate Amyl Chloride Amyl Chloride (Chloropentane) Amyl Chloronaphthalene

5 Amyl Naphthalene Amyl Nitrate 1 1 Amyl Phenol Anhydrous Hydrogen Fluoride Anhydrous Hydrazine Aniline Aniline (Aminobenzene) Aniline Dyes Aniline Hydrochloride Aniline Oil Aniline Sulfate 1 1 Animal Oils & Fats Anise Oil 1 Anisole (Methyl Phenyl Ether) Anone (Cyclohezanoe) Ansul Ether Anthraquinone 1 1 Antifreeze Antimony Pentachloride 1 1 Antimony Trichloride Aqua Regia Aqua Regia (80% HCl, 20% HNO 3 ) Argon Argon Gas 1 1 Arochlor Aromatic Fuels Aromatic Hydrocarbons Arsenic Acid Arsenic Salts Arsenic Trichloride Ascorbic Acid Askarel Asphalt Asphalt Topping ASTM Fluid ASTM Fuel A (aliphatic) ASTM Fuel B (30% aromatic) ASTM Fuel C (50% aromatic) ASTM Fuel D ASTM Oil 1 (high aniline) ASTM Oil 2 (medium aniline) ASTM Oil 3 (low aniline) ASTM Oil 4 (high aniline) ASTM Oils No. 1, No. 2, No Automatic Transmission Fluid Automotvie Brake Fluids Aviation Gasoline Barbol B Barium Carbonate Barium Chlorate Barium Chloride Barium Cyanide Barium Hydrate Barium Hydroxide Barium Nitrate Barium Salts Barium Sulfate Barium Sulfide Bayol Bayol D Beer

6 Beet Sugar Liquids Beet Sugar Liquors Benzal Chloride Benzaldehyde Benzene (Benzol) Benzene Sulfonic Acid Benzene Sulfonic Acid, 10% Benzine (Ligroin) (Nitrobenzine) Benzochloride Benzoic Acid Benzol Benonitrile 4 1 Benzophenone Benzoyl Chloride Benzoyl Peroxide 1 1 Benzyl Acetate Benzyl Alcohol Benzyl Benzoate Benzyl Chloride (Chlorotoluene) Benzyl Dichloride Beryllium Chloride 1 1 Beryllium Sulfate 1 1 Bichloride of Mercury 1 Biphenyl (Phenylbenzene) Bismuth Carbonate Black Liquor Black Point Black Sulfate Liquid Black Sulfate Liquors (cold) Blast Furnance Gas Bleach Liquor Boiled Feed Water Bone Oil 1 1 Borax (Sodium Borate) Borax Solutions Bordeaux Mixture Boric Acid (Boracic Acid) Boron Fluids (HEF) Boron Trichloride 1 1 Brake Fluid Brake Fluid (glycol base) Brake Fluid (mineral oil base) Brake Fluid (silicone oil base) Bray GG Brayco 885 (Mil-6085A) Brayco Brine Brine, abrasive Brine (Salt Water) Brine (Sea Water) Bromide Bromine Bromine Anhydrous Bromine Pentafluoride Bromine Trifluoride Bromine Water Bromobenzene Bromochloromethane Bromochlorotrifluoroethane Bromoethane (Ethyl Bromide) Bromotoluene Bromotrifluoromethane

7 Bunker 'C' Fuel Oil Bunker Oil Butadiene Butadiene Rhitemp Butane (Butyl Hydride) (LPG) Butane, 2, 2-Dimethyl Butane, 2, 3-Dimethyl Butanediol Butanol (Butyl Alcohol) Butene (Butylene) Butoxyethanol (Butyl Cellosolve) Butter Buttermilk Butydigol (Butyl Cellosolve) Butyl Acetate Butyl Acetate (room temperature) Butyl Acetyl Ricinoleate Butyl Acrylate Butyl Alcohol (Butanol) Butyl Amine (Aminobutane) Butyl Benzoate Butyl Bromide Butyl Butyrate Butyl Carbitol Butyl Cellosolve (Butoxyethanol) Butyl Cellosolve Adipate Butyl Chloride (Chlorobutane) Butyl Ether Butyl Hydride (Butane) Butyl Oleate Butyl Phenol Butyl Phthalate (Dibutyl Phthalate) Butyl Stearate Butylacetate Butylene (Butene) Butyraldehyde Butyric Acid Butyric Anhydride 1 1 Butyrone (Dipropyl Ketone) Cadmium Chloride 1 1 Cadmium Cyanide Cadmium Nitrate 1 1 Cadmium Sulfate 1 1 Cadmium Liquors Calcine Liquors Calcium Acetate Calcium Arsenate Calcium Bisulfate Calcium Bisulfide Calcium Bisulfite Calcium Bromide 1 1 Calcium Carbonate Calcium Carbonate Slurry Calcium Chlorate Calcium Chlorate (dilute) Calcium Chloride Calcium Cyanide Calcium Hydosulfide Calcium Hydroxide Calcium Hydroxide, 10% Calcium Hydroxide, 50% Calcium Hypochloride

8 Calcium Hypochlorite Calcium Nitrate Calcium Oxichloride Calcium Oxide Calcium Permanganate Calcium Phosphate Calcium Salts Calcium Salts (abrasive) 1 1 Calcium Silicate Calcium Sulfate (Gypsum) Calcium Sulfhydrate Calcium Sulfide Calcium Sulfite Calcium Thiosulfate Calgon Caliche Liquors Camphor Cane Juice 1 1 Cane Sugar Liquor Capric Acid (Caporic Acid) 1 1 Caproic Aldehyde Caprolactam Capryl Alcohol (Octanol) Carbamate Carbinol (Methanol) Carbitol Carbolic Acid (Phenol) Carbon Bisulfide Carbon Dioxide Carbon Dioxide, dry Carbon Dioxide, wet Carbon Disulfide Carbon Monoxide Carbon Tetrachloride Carbon Tetrachloride (dry) Carbon Tetrachloride (wet) Carbonated Water Carbonic Acid Castor Oil Catsup Caustic Potash Casutic Soda Cellosolve Cellosolve, acetate Cellosolve, butyl Cellosolve, methyl Celluguard Cellulose 1 Cellulose Acetate (CA) Cellulube Cellulube A Cellutherm 2505A Cetane (Hexadecane) Cetyl Alcohol 1 1 China Wood Oil (Tung Oil) Chloral Hydrate Chloramine-T Chlordane Chlorextol Chloric Acid Chlorinated Biphenyl Chlorinated Brine

9 Chlorinated Lime Chlorinated Salt Brine Chlorinated Salt Brine-abrasive Chlorinated Solvents Chlorinated Solvents (dry) Chlorinated Solvents (wet) Chlorine, anhydrous liquid Chlorine (dry) Chlorine (wet) Chlorine Dioxide Chlorine Trifluoride Chlorine Water Chloroacetic Acid Chloroacetone Chloroaniline Chlorobenzene Chlorobromomethane Chlorobutadiene (Chloroprene) Chlorobutane (Butyl Chloride) Chlorodecane 1 1 Chlorodifluoromethane Chlorodiphenyl Chlorododecane Chloroethylene (Vinyl Chloride) Chloroform Chlorohydrin Chloronapthalene Chloronitroethane Chloropentafluoroethane Chloropentane (Amyl Chloride) Chlorophenol, 5% Chloroprene (Chlorobutadiene) Chlorosulfonic Acid Chlorothene (Trichloroethane) Chlorotoluene (Benzyl Chloride) Chlorotrifluoreoethylene (CTFE) Chlorotrifluoromethane Chlorox Chocolate Syrup Chrome Alum Chrome Plating Solution Chromic Acid Chromic Acid, 10% Chromic Acid, 30% Chromic Acid, 5% Chromic Acid, 50% Chromic Oxide (aqueous) Chromium Potassium Sulfate Chromium Salts 2 Chromium Sulfate Cider Cinnamon Oil Circo Light Process Oil Citric Acid Citric Oils Citrus Pectin Liquor City Service 65, 120, City Service Kool Motor Oil No City Service Pacemaker No Clorox (Bleach) Clove Oil Coal Tar

10 Cobalt Chloride Cocoa Butter 1 Coconut Oil Cod Liver Oil Coffee Coke Oven Gas Coliche Liqours Convelex Coolanol Coolanol 25, Copper Acetate Copper Ammonium Acetate 1 1 Copper Carbonate Copper Chloride Copper Cyanide Copper Fluborate 1 1 Copper Nitrate Copper Salts Copper Salts (abrasive) Copper Sulfate Copper Sulfate, >5% Copper Sulfate, 5% Copper Sulfate, 10% Copper Sulfate, 50% Copper Sulfide Corn Oil Cottonseed Oil Cream Creosote (coal tar) Creosote (wood tar) Creosote Oil Cresol (Cresylic Acid) Cresol (Methyl Phenol) Cresols 4 4 Cresylic Acid Crotonaldehyde Crotonic Acid Crude Oil Cumene (Isopropyl Benzene) Cupric Acid Cupric Chloride (Copper Chloride) Cupric Sulfate Cuprous Ammonia Acetate 1 Cutting Oil Cutting Oil (water soluble) Cutting Oil (sulfur base) Cyanic Acid Cyanic Compounds 1 Cyanogen Cyanogen Chloride Cyclehexamone Cyclohexane Cyclohexanol Cyclohexanone Cyclohexylamine Cyclopentane Cymene (Isopropyltoluene) Decahydronaphthalene Decalin Decanal Decane Decanol (Decyl Alcohol)

11 Deionized Water Delco Brake Fluid Denatured Alcohol Denatured Solution Detergent Water Solutions Detergent Solutions Detergents Developing Fluid (photographic) Dextron Dextrose DI Water Diacetone (Diacetone Alcohol) Diamylamine Diaznon Dibenzyl Ether Dibenzyl Sebacate Dibromoethyl Benzene Dibutyl Amine Dibutyl Ether Dibutyl Phthalate (DBP) Dibutyl Sebecate (DBS) Dibutylamine Dichloroacetic Acid Dichlorobenzane Dichlorobenzene Dichlorobutane Dichlorodifluoromethane Dichloroethane Dichloroisopropyl Ether Dichloropentane 1 1 Dichlorotetrafluoroethane Dicyclohexylamine Diesel Fuel Diesel Oil Diester Lubricant (Mil-L-7808) Diester Synthetic Lubricant Diethanol Amine (DEA) Diethanolamine Diethyl Amine Diethyl Aniline Diethyl Benzene Diethyl Carbonate Diethyl Ether Diethyl Formaldehyde Diethyl Hydrazine Diethyl Maleate Diethyl Phthalate (DEP) Diethyl Sebacate Diethyl Sulfate Diethylamine Diethylbenzene Diethylene Ether (Dioxane) Diethylene Glycol (Digol) Diethylene Triamine Difluorodibromomethane Diisobutyl Ketone Diisobutylene Diisodecyl Phthalate (DIDP) Diisooctyl Adipate (DIOA) Diisooctyl Phthalate (DIOP) Diisooctyl Sebecate (DIOS) Diisopropyl Amine

12 Diisopropyl Benzene Diisopropyl Ketone Dimethyl Amine (DMA) Dimethyl Aniline Dimethyl Ether 1 1 Dimethyl Formamide (DMF) Dimethyl Ketone (Acetone) Dimethyl Phthalate Dimethyl Sulfide Dimethyl Sulfoxide (DMSO) Dinitrochloro Benzene Dinitrotoluene (DNT) Dioctyl Phthalate (DOP) Diocyl Sebacate Dioxane Dioxolane Dipentene (Limonene) Diphenyc (chlorinated) 1 1 Diphenyc (oxides-abrasive) Diphenyl (Phenylbenzene) Diphenyl Oxide (Phenyl ether) Dipropyl Ketone (Butyrone) 1 1 Dipropylamine Dipropylene Glycol Divinyl Benzene (DVB) Dodecyl Benzene (Alkane) 1 Dow Chemical 50-4, ET Dow Chemical ET Dow Corning 1208, 4050, 6620, F-60, XF Dow Corning 3, 4, Dow Corning 5, 33, 44, 200, 220, 510, 550, 705, Dow Corning Dow Corning F Dow Guard Dowtherm Dowtherm A Dowtherm E Dowtherm Fluids Drinking Water Dry Cleaning Fluids Dyes 1 1 Dyes, abrasive Dyes, water based DTE Light Oil Elco 28 EP Lubricant Embalming Fluids Epichlorohydrin Epoxy Resin Epsom Salts Esam-6 Fluid Esso Fuel Esso Golden Gasoline Esso Motor Oil Esso Transmission Fluid (Type A) Esso WS2812 (Mil-L-7808A) Esso XP90-EP Lubricant Esstic 42, Ethanal (Acetaldehyde) Ethane Ethane Gas Ethanethiol (Ethyl Mercaptan)

13 Ethanol Ethanol Amine Ethanolamine Ether Ether Compounds Ethyl Acetate Ethyl Acetoacetate Ethyl Acrylate Ethyl Acrylic Acid Ethyl Alcohol Ethyl Aluminium Dichloride Ethyl Amine (Monethylamine) Ethyl Benzene Ethyl Benzoate Ethyl Bromide (Bromoethane) Ethyl Butyl Acetate Ethyl Butyraldehyde Ethyl Butyrate Ethyl Cellosolve Ethyl Cellulose Ethyl Chloride Ethyl Chlorocarbonate Ethyl Chloroformate Ethyl Cyanide (Propionitrile) Ethyl Cyclopentane Ethyl Dichloride Ethyl Ether (Ether) Ethyl Formate Ethyl Hexanol Ethyl Hexyl Acetate Ethyl Hexyl Alcohol 2 Ethyl Iodide Ethyl Mercaptan (Ethanethiol) Ethyl Oxalate Ethyl Pentachlorobenzene Ethyl Pyridrine 1 1 Ethyl Silicate Ethyl Sulfate Ethyl Tertiary Butyl Ether Ethylene (Ethene) Ethylene Alcohol Ethylene Bromide Ethylene Chloride Ethylene Chlorohydrin Ethylene Diamine Ethylene Dibromide Ethylene Dichloride Ethylene Gas Ethylene Glycol (Antifreeze) Ethylene Oxide (ETO) Ethylene Trichloride Ethylenediamine Ethyne (Acetylene) F60 Fluid (Dow Corning) F61 Fluid (Dow Corning) Fatty Acids FC FC-43 Heptacosofluorotributylamine Ferric Chloride Ferric Hydroxide Ferric Nitrate Ferric Oxide (abrasive) 1 1

14 Ferric Persulfate Ferric Sulfate Ferrous Chloride Ferrous Sulfate Fiberglass Resin- unknown variables 3 Fish Oil Fluoboric Acid (Fluoroboric Acid) Fluorinated Cyclic Ether Fluorine Fluoro Benzene 1 1 Fluorobenzene Fluoroboric Acids Fluorocarbon Oils 1 1 Fluorochloroethylene Fluorol (Sodium Flouride) Fluorolube (Fluorocarbon Oils) Fluorosilicic Acid Formaldehyde Formaldhyde, 100% Formaldehyde, 40% Formamide Formic Acid Freon 11 (Feron MF) Freon 112 (Freon BF) Freon 113 (Freon TF) Freon 113, high & low aniline oil Freon Freon 114b Freon Freon Freon 12, ASTM No. Oil (50/50) Freon 12 (wet) Freon Freon 13b Freon 134a 2 2 Freon 142b Freon 152a 1 1 Freon Freon Freon Freon Freon Freon Freon Freon C Freon C Freon K-142b Freon K-152a Freon PCA Freon T-P Freon T-WD Freon TA Freon TC Freon TF Freon TMC Fruit Juice Fuel Oil Fumaric Acid Fuming Sulfuric Acid Furan (Furfuran) Furan Resin 4 Furfural (Furfuraldehyde)

15 Furfuryl Alcohol Furylcabinol Fyrquel 90, 100, 150, 220, 300, 500, Fyrquel A Gallic Acid Gasohol Gasoline Gasoline Heat (low lubricity) Gasoline (high, aromatic) Gasoline, leaded, ref Gasoline, unleaded Gelatin Ginger Oil Glacial Acetic Acid Glauber's Salt Gluconic Acid Glucose Glue, P.V.A Glue Sizing Glycerin Glycerine (Glycerol) Glycine Glycolic Acid Glycols Glycolmonoethylether Gold Monocyanide Grape Juice Grapefruit Oil Grease (petroleum base) Green Sulfate Liquor Gulf Endurance Oils Gulf FR Fluids (emulsion) Gulf Harmony Oils Gulf High Temp Grease Gulf Legion Oils Gulf Paramont Oils Gulf Security Oils Gulfcrown Grease Halothane Halowax Oil Hannifin Lube A Heavy Water HEF-2 (high energy fuel) Helium Heptanal Heptane Hexachloroacetone Hexachlorobutadiene Hexadecane (Cetane) 1 1 Hexalin (Cyclohexanol) Hexamine Hexane (n-hexane) Hexanedioic Acid (Adipic acid) Hexanol Hexone (MIBK) Hexyl Alcohol Hexylene (n-hexene) Hi-Lo MS No High Viscosity Lubricant H High Viscosity Lubricant U Honey Houghto-Safe 271 (Water & Glycol) 1 1 2

16 Houghto-Safe 620 (Water & Glycol) Hydraulic Oil (petroleum, aircraft) Hydraulic Oil (petroleum base) Hydraulic Oil (synthetic) Hydrazine (Diamine) Hydrazine, alcohol based Hydrazine, anhydrous Hydrazine, water based Hydrobromic Acid Hydrobromic Acid, 100% Hydrobromic Acid, 20% Hydrobromic Acid, 37% cold Hydrobromic Acid, 37% hot Hydrocarbons, light Hydrochloric Acid (Muratic Acid) Hydrochloric Acid, 100% Hydrochloric Acid, 20% Hydrochloric Acid, 3 molar Hydrochloric Acid, 30%-37% Hydrochloric Acid, 37% Hydrochloric Acid, 37% (cold) Hydrochloric Acid, 37% (hot) Hydorchloric Acid (concentrated) Hydrochloric Acid (dry gas) Hydrocyanic Acid Hydrocyanic Acid (gas 10%) 4 Hydrofluoric Acid, <50% Hydrofluoric Acid, >50% Hydrofluoric Acid, 100% Hydrofluoric Acid, 20% Hydrofluoric Acid, 50% Hydrofluoric Acid, 75% Hydrofluoric Acid, concentrated Hydrofluosilicic Acid Hydrofluosilicic Acid, 100% Hydrofluosilicic Acid, 20% Hydrogen Bromide Hydrogen Chloride Hydrogen Chloride, gas Hydrogen Cyanide Hydrogen Fluoride (Anhydrous) Hydrogen Gas Hydrogen Peroxide Hydrogen Peroxide, 10% Hydrogen Peroxide, 100% Hydrogen Peroxide, 30% Hydrogen Peroxide, 50% Hydrogen Peroxide, 90% Hydrogen Sulfide Hydrogen Sulfide (aqua) Hydrogen Sulfide (dry) Hydrogen Sulfide (dry, cold) Hydrogen Sulfide (dry, hot) Hydrogen Sulfide (wet, cold) Hydrogen Sulfide (wet, hot) Hydrolube (Water/ethylene glycol) Hydroguinol Hydroquinone Hydroxyacetic Acid Hyjet Hyjet S Hyjet W 1 1 4

17 Hypochlorous Acid Industron FF Industron FF Industron FF Industron FF Ink 3 3 Ink (may be abrasive) Insecticides (may be abrasive) 1 1 Iodine Iodine (in alcohol) 3 2 Iodine Pentafluoride Iodoform Iron Sulfate 1 Isoamyl Acetate Isoamyl Alcohol Isoamyl Butyrate Isoamyl Chloride Isobutane Isobutyl Alcohol (Isobutanol) Isobutyl Amine Isobutyl Chloride Isobutyl Ether Isobutyl Methyl Ketone Isobutyl N-Butyrate Isobutylene 1 1 Isobutyraldehyde Isobutyric Acid Isododecane Isopentane Isophorone (Ketone) Isopropanol (Isopropyl Alcohol) Isopropyl Acetate Isopropyl Alcohol (IPA) Isopropyl Amine Isopropyl Benzene Isopropyl Chloride Isopropyl Ether Isopropyl Toluene (Cymene) Isooctane Isotane Jet Fuel (JP1-JP6) Jet Fuel (JP3, JP4, JP5) JP3 (Mil-J-5624) JP4 (Mil_J-5624) JP5 (Mil-J-5624) JP6 (Mil-J-25656) JP JPX (Mil-F-25604) Kel F Liquids Kerosene (Kerosine) Ketones Keystone No. 87HX Grease Lacquer Solvents Lacquer Thinners Lacquers Lactams (Amino Acids) Lactic Acid Lactic Acid (cold) Lactic Acid (hot) Lanolin 1 Lard Latex

18 Latex-abrasive Lauryl Alcohol (n-dodecanol) Lavender Oil LB Lead Acetate Lead Chloride Lead Nitrate Lead Oxide Lead Sulfamate Lehigh X Lehigh X Lemon Oil Light Grease Lignin Liquor Ligroin (Nitrobenzine) Lime Lime Bleach Lime Sulfur Limonene (Dipentene) Lindol (Tritolyl Phosphate) Linoleic Acid Linseed Oil Liquefied Petroleum Gas (LPG) Liquefied Petroleum Gas (low seal life) Liquid Oxygen Liquimoly Liquor-Pulp Mill 1 Liquor Sulfate 1 Lithium Bromide Lithium Chloride Lithium Hydroxide Lithophone Lubricants Lubricating Oil Lubricating Oil (crude & refined) Lubricating Oil (di-ester base) Lubricating Oil (pertoleum base) Lye Lye: Ca(OH)2 Calcium Hydroxide Lye: KOH Potassium Hydroxide Lye: NaOH Sodium Hydroxide Lye Solution Magnesium Acetate Magnesium Bisulfate 1 1 Magnesium Carbonate Magnesium Chloride Magnesium Hydroxide Magnesium Nitrate Magnesium Oxide (abrasive) Magnesium Salts Magnesium Sulfate Magnesium Sulfite 1 Malathion Maleic Acid Maleic Anhydride Maleic Hydraxide 1 Mailic Acid (Apple Acid) Malt Liquors 1 1 Manganese Choride 1 1 Manganese (II) Chloride Manganese Carbonate Manganese Nitrate 3 3 1

19 Manganese Sulfate Mash 1 Mayonnaise Melamine Melamine Resins Mercaptobenxothiazole (MBT) Mercuric Chloride Mercuric Chloride (dilute) Mercuric Cyanide Mercurous Nitrate Mercury Mercury Salts (abrasive) 1 Mercury Vapor Mesityl Oxide Methacrylacid Methylester Methacrylic Acid Methane Methanol (Methyl Alcohol) Metholyene Cloride (CH 2 CL 2 ) 1 Methyl Acetate Methyl Acetoacetate Methyl Acetone Methyl Acrylate Methyl Acrylic Acid (Crotonic Acid) Methyl Alcohol (Methanol) Methyl Alcohol, 10% Methyl Amine Methyl Amyl Acetate Methyl Amyl Alcohol Methyl Benzoate Methyl Bromide Methyl Butyl Ketone Methyl Butyrate Methyl Carbonate Methyl Cellosolve Methyl Chloride Methyl Chloroform Mehtyl Chloroformate Methyl Chlorosilances Methyl Cyanide (Acetonitrile) Methyl Cyclopentane Methyl Dichloride Methyl Ether Methyl Ethyl Keone (MEK) Methyl Ethyl Ketone Peroxide Methyl Formate Methyl Glycol Acetate Methyl Iodide Methyl Isobutyl Ketone (MEK) Methyl Isopropyl Ketone Methyl Mercaptan Methyl Methacrylate (MMA) Methyl Oleate Methyl Phenyl Ether (Anisole) Methyl Propyl Ketone Methyl Salicylate Methylamine Methylene Bromide Methylene Chloride Methylene Dichloride MIL-L Lubricants 4 4 1

20 MIL-L-7808 Lubricants MIL-spec fluids Milk Mine Water (hardness affects wear) Mineral Spirits Mineral Oil MLO MLO MLO MLO Mobil 24DTE Mobil Delvac 1100, 1110, 1120, Mobil HF Mobil Nivac 20, Mobil Therm Mobil Velocite C Mobil Gas WA200 ATF Mobil Oil SAE Mobilux Molasses Monlybdenum Disulfide Grease Monobromo Benzene Monochloro Acetic Acid Monochloro Acetone Monochloro Benzene Monochloroacetic Acid 2 4 Monoethanolamine (MEA) Monoethylamine (Ethyl Amine) Monomethyl Aniline Monomethyl Ether Monomethyl Hydrazine Monotrotoluene 40%- Dinitrotoluene 60% Monovinyl Acetylene Morpholine Motor Oil Muriatic Acid (30%) 1 1 Mustard Mustard Gas n-dodecanol (Lauryl Alcohol) n-heptane n-hexaldehyde n-hexane n-hexanol n-hexene (Hexylene) n-hexene n-octane n-pentane n-propyl Acetate (Propyl Acetate) n-propyl Acetone n-propyl Nitrate (NPN) Naphtha Naphtha Coal Tar (Benzol) Napthalene (Tar Camphor) Napthenic Acid Natural Gas Neatsfoot Oil Neohexane Neon Neville Acid Nickel Acetate (Diacetate) Nickel Chloride Nickel Chloride (abrasive)

21 Nickel Nitrate (Dinitrate) Nickel Salts Nickel Sulfate Niter Cake Nitrating Acid, <15% 3 3 Nitric Acid, 20% Nitirc Acid, 50% Nitric Acid, 5-10% Nitric Acid (3 molar) Nitric Acid (concentrated) Nitric Acid (dilute) Nitric Acid (red fuming) (RFNA) Nitric Acid (red and white fuming) 3 1 Nitrobenzene Nitrobenzine (Ligroin) Nitroethane Nitrogen Nitrogen Gas Nitrogen Tetraoxide Nitromethane Nitropropane Nitrous Acid Nitrous Oxide o-chlornaphthalene o-cresol (Cresylic Acid) o-dichlorobenzene Octachlorotoluene Octadecane Octanol (Octyl Alcohol) Octyl Acetate Octyl Alcohol (Octanol) Oils: Aniline Oils: Castor Oils: Citric 2 1 Oils: Coconut 1 Oils: Cod Liver 2 Oils: Corn 1 1 Oils: Cottonseed Oils: Creosote 4 4 Oils: Diesel Fuel (20,30,40,50) 1 4 Oils: Fuel (1,2,3,5A,5B,6) Oils: Hydraulic Oil (petro) Oils: Hydraulic Oil (synthetic) Oils: Linseed Oils: Mineral Oils: Olive Oils: Orange Oils: Peanut 1 1 Oils: Pine 1 4 Oils: Rapeseed 4 Oils: Rosin 1 Oils: Silicone 1 3 Oils: Soybean 1 1 Oils: Transformer 1 2 Oils: Turbine 1 4 Oleic Acid Olein (Triolene) Oleum Oleum (fuming sulfuric acid) Oleum, 100% Oleum, 25% 4 4 Oronite 8200,

22 Orthochloroethylbenzene Orthodichlorobenzene OS45 Type 11, Silicate Ester Based OS45 Type 1V OS Oxalic Acid Oxalic Acid (cold) 4 Oxygen (100 to 200 deg C.) Oxygen (below 100 deg C.) Oxygen Gas Oxygen Liquid Ozone (50 PPHM) P-Dichlorobenzene P-Tertiary Butyl Caltechol Paint (with Xylene) Paint Thinner (Ducco) Palm Oil Palmitic Acid Par-al-ketone Para-dichlorobenzene Paraffin (molten) Paraffins Paraformaldehyde Paraldehyde Parker O-Lube Peanut Oil Penicillin Pectin Liquor 1 1 Pentachloroethane (Pentalin) Pentachlorophenoc 1 1 Pentachlorophenol (PCP) Pentaerythritol Pentane (Amyl Hydride) Pentanol Pentyl Alcohol (Amyl Alcohol) 1 1 Pentyl Amine (Amyl Amine) Perchloric Acid Perchlorthylene (Perchlor) Petrolatum Petroleum Petroleum Ether Petroleum Oil (above 125 deg C.) Petroleum Oil (below 125 deg C.) Petroleum Oil, crude Petroleum Oil, crude (above 250) Petroleum Oil, crude (below 250) Phathalic Anhydride Phenol (Carbolic Acid) Phenol, 10% Phenol Sulfonic Acid Phenyl Acetate Phenyl Benzene Phenyl Ether (Diphenyl Oxide) Phenyl Ethyl Ether (Phenetole) Phenyl Hydrazine Phenyl Methyl Ketone Phorone Phosgene Phosphate Esters Phosphoric Acid 2 1 Phosphoric Acid, > 40% Phosphoric Acid, < 40%

23 Phosphoric Acid, 50% Phosphoric Acid (3 molar) Phosphoric Acid (concentrated) 1 1 Phosphoric Acid (crude) Phosphoric Acid (molten) 4 Phosphoric Acid (pure) Phosphoric Anhydride Phosphorus 1 Phosphorus Oxychloride Phosphorus Trichloride Photographic Developer Photographic Solutions Phthalic Acid Phthalic Anhydride Picric Acid Picric Acid, H 2 O solution Pine Oil Pinene Pipeline Cleaner Piperidine Plating Solutions, Acid Fluoborate Bath 1 Plating Solutions, Acid Sulfate Bath 1 1 Plating Solutions, Antimony Bath Plating Solutions, Antimony Plating 130F 4 Plating Solutions, Antimony Plating 110F 1 Plating Solutions, Arsenic Bath Plating Solutions, Barrel Chrome Bath Plating Solutions, Barrel Copper Bath Plating Solutions, Black Chrome Bath Plating Solutions, Bath-High Speed Plating Solutions, Bath-Regular Plating Solutions, Plating: High Speed Bath 110F 1 Plating Solutions, Plating: Regular Bath 100F 1 Plating Solutions, Bronze Plating: Cu-Cd Bronze Bath R.T. 1 Plating Solutions, Bronze Plating: Cu-Sn Bronze Bath 160F 1 Plating Solutions, Bronze Plating: Cu-Zn Bronze Bath 100F 1 Plating Solutions, Cadmium Plating: Cyanide Bath 90F 1 Plating Solutions, Cadmium Plating: Fluoborate Bath 100F 4 Plating Solution, Chrome Plating Solutions, Chromic-Sulfuric Bath 1 1 Plating Solutions, Chromium Plating: Barrel Chrome Bath 95F 4 Plating Solutions, Chromium Plating: Black Chrome Bath 115F 4 Plating Solutions, Chromium Plating: Chromic- Sulfuric Bath 130F 4 Plating Solutions, Chromium Plating: Fluoride Bath 130F 4 Plating Solutions, Chromium Plating:Fluosilicate Bath 95F 4 Plating Solutions, Cobalt Plating Solutions Copper Plating Solutions, Copper-Cadium Bronze Bath

24 Chemical or Media Plating Solutions, Copper Fluoborate Bath Plating Solutions, Copper Plating (Acid): Copper Fluoborate Bath 120F 4 Plating Solutions, Copper Plating (Acid): Copper Sulfate Bath R.T. 4 Plating Solutions, Copper Plating (Cyanide): Copper Strike Bath 1 Plating Solutions, Copper Plating (Cyanide): High-Speed Bath 180F 1 Plating Solutions, Copper Plating (Cyanide): Rochelle Salt Bath 150F 1 Plating Solutions, Copper Plating (Misc): Copper (Electroless) 1 Plating Solutions, Copper Plating (Misc): Copper Pyrophosphate 1 Plating Solutions, Copper Strike Bath Plating Solutions, Copper Sulfate Bath Plating Solutions, Copper Tin Bronze Bath Plating Solutions, Copper Zinc Bronze Bath Plating Solutions, Cyanide Bath Plating Solutions, Ferrous Ammonium Sulfate Bath Plating Solutions, Ferrous Sulfate Bath Plating Solutions, Fluoborate Bath Plating Solutions, Fluoride Bath 1 1 Plating Solutions, Fluosilicate Bath 1 1 Plating Solutions Gold Plating Solutions, Gold Plate Bath Plating Solutions, Gold Plating: Acid 75F 1 Plating Solutions, Gold Plating: Cyanide 150F 1 Plating Solutions, Gold Plating: Neutral 75F 1 Plating Solutions, Indium Plating Solutions, Indium Sulfamate Plating room temperature 4 Plating Solutions, Iron Plating Solutions, Iron Plating: Ferrous Am Sulfate Bath 150F 4 Plating Solutions, Iron Plating: Ferrous Chloride Bath 190F 4 Plating Solutions, Iron Plating: Ferrous Sulfate Bath 150F 4 Plating Solutions, Iron Plating: Fluoborate Bath 145F 4 Plating Solutions, Iron Plating: Sulfamate 140F 4 Plating Solutions, Iron Plating: Sulfate-Chloride Bath 160F 4 Plating Solutions, Lead Plating Solutions, Lead Fluoborate Bath 1 Plating Solutions, Lead Fluoborate Plating 4 Plating Solutions, Nickel Plating Solutions, Nickel Fluoborate Bath 1 Plating Solutions, Nickel Plating: Electoless 200F 4 Plating Solutions, Nickel Plating: Fluoborate F 4 Plating Solutions, Nickel Plating: High-Chloride F 4 Plating Solutions, Nickel Plating: Sulfamate F 1

25 Chemical or Media Plating Solutions, Nickel Plating: Watts Type F 1 Plating Solutions, Rhodium Bath 1 Plating Solutions, Rhodium Plating 120F 4 Plating Solutions, Rochelle & Potassium Salt Bath Plating Solutions, Rochelle & Sodium Salt Bath Plating Solutions, Silver Plating Solutions, Silver Plate Bath Plating Solutions, Silver Plating F 1 Plating Solutions, Sulfate-Chloride Bath 1 1 Plating Solutions, Tin Plating Solutions, Tin Fluoborate Bath 1 1 Plating Solutions, Tin-Fluoborate Plating 100F 4 Plating Solutions, Tin-Lead Plating 100F 4 Plating Solutions, Zinc Plating Solutions, Zinc Plating: Acid Chloride 140F 4 Plating Solutions, Zinc Plating Acid Sulfate Bath 150F 4 Plating Solutions, Ainc Plating: Alkaline Cynaide Bath R.T. 1 Pneumatic Service Glycol Polyvinyl Acetate Polyvinyl Acetate Emulsion Potash (Potassium Carbonate) Potassium Acetate Potassium Bicarbonate Potassium Bisulfate Potassium Bisulfite Potassium Borate Potassium Bromate Potassium Bromide Potassium Carbonate (Potash) Potassium Chlorate Potassium Chloride Potassium Chromate Potassium Copper Cyanide Potassium Cupro Cyanide Potassium Cyanide Potassium Cyanide Solutions Potassium Dichromate Potassium Ferricyanide Potassium Ferrocyanide Potassium Fluoride Potassium Hydroxide (Caustic Potash) Potassium Hydroxide Potassium Hydroxide, 50% 1 1 Potassium Hypochlorite Potassium Iodate Potassium Iodide Potassium Nitrate Potassium Nitrite 1 1 Potassium Oxalate Potassium Perchlorate Potassium Perfluoroacetate 1 1 Potassium Permanganate Potassium Persulfate Potassium Phosphate

26 Potassium Salts Potassium Silicate Potassium Sulfate Potassium Sulfide Potassium Sulfite Potassium Sulphate Potassium Tartrate 1 1 Potassium Thiocyanate Prestone Preston Antifreeze PRL-High Temp, Hydraulic Oil Producer Gas Propane Propane (liquefied) Propane (LPG) Propanol (Propyl Alcohol) Propionaldehyde (Propanol) Propionic Acid Propionitrile (Ethyl Cyanide) Propyl Acetate (n-propyl Acetate) Propyl Alcohol (1-Propanol) Propyl Amine Propyl Nitrate (n-propyl Nitrate) Propylene (Propene) Propylene Chlorohydrin Propylene Dichloride Propylene Glycol Propylene Oxide Pydauis 1 1 Pydraul 10E Pydraul 115E Pydraul 230C, 312C & 540C Pydraul 29ELT, 30E, 50E, 65E, & 90E Pyranol 1 Pyranol Transformer Oil Pyridene Pyridine Pyrogallol (Pyrogallic acid) Pyrogard 42, 43, 53 & Pyrogard C&D (Water & Petroleum) Pyroligneous Acid Pyrolube Pyrrole (Azole) Quaternary Ammonium Germicide 1 Quinine (Bisulfate) (Sulfate) 1 1 Quinone 1 Radiation Rapseed Oil Red Line 100 Oil Red Oil (MIL-H-5606) Resorcinal RJ-1 (MIL-F-25558) Rose Oil Rosin Rotenone RP-1 (MIL-F-25576) Rum Rust Inhibitors Sal Ammoniac Salad Dressings Salicylic Acid Salt Brine (NaCl saturated) 1 1 1

27 Salt Solution Salt Water Santosafe Sea Water (Brine) Sesame Seed Oil Sewage Shave Cream Shell 3XF Mine Fluid Shell Alvania Grease Shell Carnea 19& Shell Diala Shell Irus Shell Tellus 27 (petro base) Shell Tellus Shell UMF (5% Aromatic) Shellac Shellac (bleached) Shellac (orange) Silica Gel 1 1 Silicate Esters Silicone Silicone Grease Silicone Oil Silicone Tetrachloride Silver Bromide Silver Chloride 1 1 Silver Cyanide Silver Nitrate Silver Salts Sinclair Opaline CX-EP Lube Sizing Starch 1 Skydrol Skydrol Soap Solutions Socony Mobil Type A Socony PD959B Vacuum Socony Vacuum AMV AC781 Grease Soda Ash (Sodium Carbonate) Soda, Caustic (20%) Soda, Caustic (50%) Sodium Acetate Sodium Aluminate Sodium Arsenite Sodium Azid Sodium Benzoate Sodium Bicarbonate (Baking Soda) Sodium Bichromate Sodium Bisulfate Sodium Bisulfide 3 1 Sodium Bisulfite Sodium Borate (Borax) Sodium Bromide 2 Sodium Carbonate (Soda Ash) Sodium Carbonate (abrasive) Sodium Chlorate Sodium Chloride Sodium Chlorite Sodium Chromate Sodium Citrate Sodium Cyanide Sodium Dichromate 1 1 Sodium Ethylate 1 1

28 Sodium Ferricyanide 1 1 Sodium Ferrocyanide Sodium Fluoride (Fluorol) Sodium Hydrogen Sulfate Sodium Hydrogen Sulfite Sodium Hydrosulfite Sodium Hydroxide (Caustic Soda) Sodium Hydroxide, 20% Sodium Hydroxide, 50% Sodium Hydroxide, 80% Sodium Hypochlorite Sodium Hypochlorite, < 20% Sodium Hyopchlorite, >20% Sodium Hypochlorite, 20% Sodium Hypochlorite, 100% Sodium Hyposulfate Sodium Hyposulfite Sodium Iodide 1 1 Sodium Lactate Sodium Metaphosphate Sodium Metasilicate Sodium Nitrate Sodium Nitrite Sodium Oleate Sodium Orthophenylphenate Sodium Oxalate Sodium Perborate Sodium Perchlorate Sodium Peroxide Sodium Persulfate Sodium Phosphate (Di-basic) Sodium Phosphate (Mono-basic) Sodium Phosphate (Tri-basic) Sodium Polyphosphate Sodium Pyrophosphate Sodium Salts Sodium Silicate Sodium Silicate-abrasive Sodium Sulfate Sodium Sulfide Sodium Sulfite Sodium Tartrate Sodium Tetraborate Sodium Thiosulfate Sodium Thiosulfate (hypo) Sodium Tripolyphosphate 1 1 Soluble Oil Solvasol Solvasol Sorghum Sour Crude Oil Sour Natural Gas Soy Sauce Soybean Oil Sperm Oil Spry SR10 Fuel SR6 Fuel Standard Oil Multilube GX90-EP Stannic Chloride Stannic Chloride, 50% Stannic Fluoborate 1 1 1