SPEEDFAX TM 2011 Load Centers & Circuit Breakers Contents

Transcription

1 SPEEDFAX TM 20 Load Centers & Circuit Breakers Contents Load Centers ing System -2 Siemens PL and ES Series Load Centers Introduction -3 PL Series Load Centers Features and Product Offering -4-5 PL Series Single Phase Main Lug & Main Breaker Load Centers -6 PL Series Single Phase Special Load Centers -7 PL Series Three Phase Main Lug & Main Breaker Load Centers -8 PL Series Three Phase Unassembled Load Centers -9 ES Series Load Centers Features and Product Offering -0 - ES Series Single Phase Main Lug & Main Breaker Load Centers -2 ES Series Single Phase Special Load Centers -3 ES Series Three Phase Main Lug & Main Breaker Load Centers -4 EQ Load Centers, Generator Ready Load Centers -6 Riser Panel Load Centers -7 EQ Load Centers, Small Circuit and Circuit Breaker Enclosures -8-9 Load Centers OEM Interiors and Accessories Standby Power Systems Knockout Diagrams Load Center Cross Reference Circuit Breakers Arc-Fault and Ground-Fault Breakers -32 Intelli-Arc Diagnostic Tool -33 Type QP, " Breakers -34 Duplex, Triplex and Quadplex Plug-In Breakers -35 Special Application Breakers -36 Type QD, 3/4" Breakers -37 Main and Branch Circuit Breakers Circuit Breaker Dimension Drawings and Lug Data Circuit Breaker Accessories Surge Protection Products Temporary Power Outlet Panels Introduction and Features ing System -49 Common Configurations -50 Temporary Power Dimension Drawings Structured Wiring AC Disconnects, -Phase, NEMA 3R Rated -60 Residential L Commercial L Industrial

2 Load Centers ing System ing System Type Enclosure or Component E = Indoor Type 2-0 and circuits G = Indoor Type 2-42 circuits W = Outdoor Type 3R I or PI = Interior R = Riser P = PL Series Indoor Type 2-70 circuits S = ES Series Indoor Type 2-70 circuits PW = PL Series Outdoor Type 3R 2-70 circuits SW = ES Series Outdoor Type 3R 2-70 circuits Maximum number of " breakers Maximum number of circuits Type of Main ML or L = Main Lug MB or B = Main Breaker System = -Phase, 3-Wire 3 = 3-Phase, 3-Wire or 3-Phase, 4-Wire Main ere Ex:00 = 00 s Trim/ Others Blank = Combination S = Surface F = Flush T = Feed-Thru Lugs G or GB = Ground Bar Factory Installed Type of Bus Bar Blank C or CU P = Aluminum = Copper = Aluminum Bus, Value Pack P 2 24 B 00 S CU Products Shown In Sections of this Speedfax Meet or Exceed the Following Standards. UL50 Electric Cabinets and Boxes UL67 Electric Panelboards UL486 Wire Connectors UL489 Molded-Case Circuit Breakers UL869 Service Equipment UL943 Ground Fault interrupters (Class A Personnel Protection) Federal Specification W-P-5b Panel Power Distribution Federal Specification W-C-375B Circuit Breakers NEC NEMA 250 Underwriters Laboratories, Inc. Reference File Numbers: Series Connected Circuit Breaker Information is recognized by UL under file #E0848(N) Load Centers Listed by UL under file #E0703 Load Centers UL recognized components found under file #E0703, Volume 6 and 7. (Also referenced under the recognized components directory section QEUY2) EQ Circuit Breakers are Listed by UL under file #E Siemens Industry, Inc. SPEEDFAX 20 Product Catalog

3 Load Centers Siemens PL and ES Series Load Centers Overview PL Series: Convertible Invertible Insta-wire neutrals & grounds Ground bars included Copper busbars Dual neutrals on all configurations Carton-in-carton packaging Lifetime warranty PL Series -phase PL Series 3-phase ES Series: Invertible Insta-wire neutrals & grounds Aluminum busbars Single sided neutral on 24 circuits and below Single piece carton packaging 0 year warranty ES Series -phase ES Series 3-phase Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -3

4 PL Series Load Centers Features All devices convertible from main lug to main breaker and vice versa. All devices are provided with 2 factory installed ground bars. Invertible for bottom feed application. Mounting tabs on the trim hold it in place on the load center, freeing up both hands to drive the trim screws. Combination head screw on the neutrals, ground, trim, upper pan, and bond screw provide installation flexibility. A rigid, sturdy base pan provides the ruggedness required for the most harsh applications. The prepositioned bond screw eliminates bond strap/ screw assemblies, and reduces the risk of losing components in the field. The patented INSTA-WIRE neutral/ground system allows for faster installation because screws are backed out, ready for wire insertion. The visible neutral and grounds system aids in the insertion of conductors. Copper Bus PL Series Load Centers ship with trims packaged separately. The outdoor enclosure has a slide hinge door for the easiest installation and can be removed by backing out only one screw. -4 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog

5 PL Series Load Centers Product Offering The PL Series Load Center product line provides a wide array of variation to meet any application need. The following offering is available in the PL Series product line: 2-70 / Indoor and Outdoor enclosures 00 to 225 Main Lug and Main Breakers Un-assembled offering in 3-phase PL Series -phase Main Lug PL Series 3-phase Main Breaker Un-assembled 3-phase Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -5

6 PL Series -Phase Main Lug & Main Breaker Load Centers -phase, 3-wire SN, 20/240 Volts AC Revised 06/3/4 Main Breaker/Convertible Load Centers Copper Bus 2-70 / eres 60/75 C Rated 22,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R P224B00CU 8 PW224B00CU P624B00CU 2 PW624B00CU P2020B00CU 24 PW2020B00CU P2024B00CU P2424B00CU P3030B00CU PW3040B00CU P3030B25CU 30 PW3040B25CU P2030B50CU PW2030B50CU P3030B50CU PW3040B50CU P2040B200CU 30 PW2040B200CU P3040B200CU 36 PW3040B200CU P3040B P4040B200CU 36 PW4040B200CU P4040B P5470B200CU P4260B225CU 39 PW4260B225CU P5470B225CU 44 Single phase factory installed 22kA IR main circuit breaker offers 22/0kA IR series combination rating when using 0kA type QP, QT, QPF, QE, QN, and QAF2/QAF2C branch breakers. Main Lug/Convertible Load Centers Copper Bus 2-70 / eres 60/75 Rated 00,000A IR Branch Indoor Enclosure - NEMA Type Outdoor Enclosure - NEMA Type 3R P22L25CU 8 PW22L25CU P224L25CU 8 PW224L25CU P624L25CU 2 PW624L25CU P2020L25CU P2024L25CU P2440L25CU P3040L25CU 30 PW3040L25CU P4040L25CU P2030L50CU 24 PW2030L50CU P224L200CU 24 PW224L200CU P2040L200CU 30 PW2040L200CU P2440L200CU P3030L200CU P3040L200CU 36 PW3040L200CU P3040L P3054L200CU 36 PW3054L200CU P4040L200CU 36 PW4040L200CU P4040L PW224L225CU P4260L225CU 39 PW4260L225CU P5470L225CU 44 Suitable for use as service equipment. May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Suitable for use as service entrance equipment when not more than six main disconnecting means are provided. See article of the NEC. 25A load centers will accept MBK00A and MBK25A. 50A load centers will accept MBK50A. 200A load centers will accept MBK200A and MBK50A. 225A load centers will accept MBK225A, MBK200A, MBK50A. Copper bus load centers are recommended for those applications where the environment may be severe (i.e. far and coastal areas). Includes all PL Series features with aluminum bussing. -6 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog

7 PL Series -Phase Special Application Load Centers -phase, 3-wire SN, 20/240 Volts AC Revised 02/26/2 Split Ground Series Main Lug Convertible Load Centers Copper Bus 2-60 / eres 60/75 Rated, 00,000A IR Branch Indoor Enclosure NEMA Type P224L25CUSG P624L25CUSG P2030L25CUSG P2430L25CUSG P2030L50CUSG P3040L200CUSG P3040L200SG P4040L200CUSG P4040L200SG P4260L225CUSG 39 Split Ground Series Main Breaker Convertible Load Centers Copper Bus 40 / 200 eres 60/75 Rated, 22,000A IR Branch Indoor Enclosure NEMA Type P4040B200CUSG 36 Split Ground Load Centers have factory installed 00% neutral with factory bonded 75% ground. No neutral tie strap. Outdoor Trailer Panels Copper Bus 6 / 200 eres 60/75 Rated, 22,000A IR Main Breaker MBK50A or MBK200A PW086L200TC PW086B200TC MBK200A Field Installed 23 Factory Installed 23 Load Centers with White Trim Copper or Aluminum Bus 40 / 200 eres 60/75 Rated 22,000A IR Branch Indoor Enclosure - NEMA Type Main Lug / Main Breaker 200 Main Breaker P3040B200W Main Breaker P4040B200W Main Breaker P4040B200CUW 36 Includes all PL Series features with aluminum bussing. Indoor enclosures are 4 /4" wide by 3 7/8" deep. May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Main lug panel rated 00,000A IR. Load centers with white trim have increased lead time of 3-4 weeks. Sold in pallet quantites only. Load centers with CUW suffix indicates copper bus with white trim. Load centers with W suffix only indicates aluminum bus with white trim. Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -7

8 PL Series 3-Phase Main Lug & Main Breaker Load Centers 3-phase, 3-wire, 240 Volt AC or 3-phase, 4-wire, 20/240 or 20/208 Volts AC Revised 02/26/2 Main Breaker/Convertible Load Centers Copper Bus / eres 60/75 C Rated 22,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R P224B300CU P3042B300CU P3030B325CU P2442B350CU P4242B350CU P3054B3200CU 39 PW3054B3200CU P4260B3200CU 42 PW4260B3200CU P4260B3225CU P4260B3225TCU P5470B3225CU 49 Main Lug/Convertible Load Centers Copper Bus 2-70 / eres 60/75 Rated 00,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R P224L325CU 2 PW224L325CU P2442L3200CU 36 PW2442L3200CU P3054L3200CU 39 PW3054L3200CU P4260L3225CU 42 PW4260L3225CU P5470L3225CU 49 May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Back fed main breaker. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Suitable for use as service entrance equipment when not more than six main disconnecting means are provided. See article of the NEC. Includes factory installed feed through lugs and is also non-convertible. Non-convertible to main breaker. All load centers are provided with tin plated copper bus bars. Rated 00,000A IR in series with breakers listed on wiring diagram. All load centers are provided with tin-plated copper bus bars. -8 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog

9 PL Series 3-Phase Unassembled Load Centers 3-phase, 3-wire, 240 Volt AC or 3-phase, 4-wire, 20/240 or 20/208 Volts AC Main Breaker Convertible Unassembled Load Centers Copper Bus / eres 60/75 C Rated 22,000A IR Interiors Enclosure Trim Kit Interior Enclosure No. Breaker Trim PI3042B300CU 30 3PE30 30 PT3042B PI2442B350CU 36 3PE36 24 PT2442X PI3054B3200CU 39 3PE39 30 PT3054X PI4260B3200CU 42 3PE42 42 PT4260X PI5470B3225CU 49 3PE49 54 PT5470X3225 Main Lug Convertible Unassembled Load Centers Copper Bus 2-70 / eres 60/75 Rated 00,000A IR Interiors Enclosure Trim Kit Interior Enclosure No. Breaker Trim PI224L325CU 2 3PE2 2 PT224L PI2442L3200CU 36 3PE36 24 PT2442X PI3054L3200CU 39 3PE39 30 PT3054X PI4260L3225CU 42 3PE42 42 PT4260X PI5470L3225CU 49 3PE49 54 PT5470X3225 May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Back fed main breaker. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Trim catalog numbers with a B indicate for use with main breaker and is not convertible. L indicates for use with main lug and is not convertible. X indicates can be used with convertible interior. All load center interiors are provided with tin plated copper bus bars. Rated 00,000A IR in series with breakers listed on wiring diagram. Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -9

10 ES Series Load Centers Features Revised 04/28/5 Combination head screw on the neutrals, ground, trim, upper pan, and bond screw provide installation flexibility. Invertible for bottom feed application. Ground bar field installed (select skus with G suffix will have ground bar factory installed). Mounting tabs on the trim hold it in place on the load center, freeing up both hands to drive the trim screws. The prepositioned bond screw eliminates bond strap/ screw assemblies, and reduces the risk of losing components in the field. Single side inboard neutral on 24 circuits and below; dual on 30 circuits and above. A rigid, sturdy base pan provides the ruggedness required for the most harsh applications. The patented INSTA-WIRE neutral/ground system allows for faster installation because screws are backed out, ready for wire insertion. The visible neutral and grounds system aids in the insertion of conductors. Aluminum bus. ES Series Load Centers ship in single piece carton. The outdoor enclosure has a slide hinge door for the easiest installation and can be removed by backing out only one screw. -0 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog

11 ES Series Load Centers Product Offering The ES Series Load Center product line provides a wide array of variation to meet any application need. The following offering is available in the ES Series product line: 2-70 / Indoor and Outdoor enclosures 00 to 225 Main Lug and Main Breakers Value packs a mix of branch breakers provided with the load center. ES Series -phase Main Lug 25A, 2-24 circuits ES Series - phase Main Breaker A, circuits ES Series 3-phase Main Breaker Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -

12 ES Series -Phase Main Lug & Main Breaker Load Centers -phase, 3-wire SN, 20/240 Volts AC Revised 04/28/5 Main Breaker Aluminum Bus 2-70 / eres 60/75 C Rated 22,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R S020B S224B00 8 SW224B S624B00 2 SW624B S2020B00 24 SW2020B S2024B S3030B SW224B S624B SW2024B S2424B25 24 SW2424B S3030B S3040B25 30 SW3040B S630B S2030B S2430B S3030B S3040B50 30 SW3040B SW4040B S632B S2040B SW2040B S2440B S3040B SW3040B S4040B SW4040B S5470B S4260B SW4260B S5470B Main Lug Aluminum Bus 2-70 / eres 60/75 Rated 00,000A IR Branch Indoor Enclosure - NEMA Type Outdoor Enclosure - NEMA Type 3R S22L25 8 SW22L S224L25 8 SW224L S624L25 2 SW624L S2020L S2020L25G S2024L S2024L25G S2424L25 24 SW2424L S2424L25G S2440L S3040L25 30 SW3040L S3040L25G S4040L S2030L50 24 SW2030L S224L200 2 SW224L S2040L SW2040L S2440L S3030L S3040L SW3040L S3054L SW3054L S4040L SW4040L SW224L S4260L SW4260L S5470L Suitable for use as service equipment. May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Suitable for use as service entrance equipment when not more than six main disconnecting means are provided. See article of the NEC. ES Series single phase skus with a "G" suffix have ground bar included (factory installed). -2 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog

13 ES Series -Phase Special Load Centers -phase, 3-wire SN, 20/240 Volts AC Revised 0/22/3 Load Centers with White Trim Aluminum Bus 6-40 / eres 60/75 Rated 00,000A IR Branch Indoor Enclosure NEMA Type Main Lug / Main Breaker 00 Main Breaker 6 24 S624B00W 2 25 Main Lug S2020L25W 2 25 Main Lug S2424L25W Main Lug S3030L200W Main Lug S4040L200W Main Lug S3040L25W Main Breaker S4040B200W 36 Outdoor Trailer Panels Aluminum Bus 6 / 200 eres 60/75 Rated 00,000A IR Main Breaker SW086L200T N/A N/A SW086B200T MBK200A Factory Installed 23 Value Pack Load Centers Load Center Breakers Included N0. of Aluminum Bus S2020B00P S2020B00 (3) Q20, () Q S3040B200P S3040B200 (3) Q20, () Q S3040L200P S3040L200 (3) Q20, () Q S4040B200P S4040B200 (3) Q20, () Q S3054B200P N/A (3) Q20, () Q Split Ground Series Load Centers / eres 6 / 200 eres Aluminum Bus Branch Indoor Enclosure NEMA Type S2030L25SG S3030B50SG S4040B200SG 36 Selectable Main Load Centers / eres Aluminum Bus Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R Available Kits Enclosure Enclosure Height Height Main Lug Main Breaker S2424C25 24 SW2424C25 27 ECMLK25 MBK00A, MBK25A S2040C SW2040C ECMLK225 MBK200A S3040C SW3040C ECMLK225 MBK50A, MBK200A, MBK225A S4040C SW4040C ECMLK225 MBK50A, MBK200A, MBK225A Load centers with white trim have increased lead time of 3-4 weeks. Sold in pallet quantities only. Additional charge will apply. Contact sales office for details. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Breakers are shipped inside a sleeve located inside the load center. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Main breaker rated 22,000A IR. Split Ground load centers have factory installed 00% neutral with factory bonded 75% ground. Selectable main load centers do not come with main lugs or main breakers. Those kits are sold separately. Siemens Industry, Inc. SPEEDFAX 20 Product Catalog -3

14 ES Series 3-Phase Main Lug & Main Breaker Load Centers 3-phase, 3-wire, 240 Volt AC or 3-phase, 4-wire, 20/240 or 20/208 Volts AC Revised 04/28/5 Main Breaker Aluminum Bus / eres 60/75 C Rated 0,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R S224B S3030B S3042B S3042B S2442B SW2442B S4242B S3054B S3054B SW3054B S4260B SW4260B S4242B SW4242B Main Lug Aluminum Bus 2-70 / eres 60/75 Rated 00,000A IR Branch Indoor Enclosure NEMA Type Outdoor Enclosure NEMA Type 3R S224L325 2 SW224L S836L SW836L S2442L SW2442L S224L SW224L S2442L SW2442L S3054L SW3054L S4260L SW4260L S5470L May be installed on higher rated systems when protected by a circuit breaker with a higher AIR rating. Back fed main breaker. Indoor enclosures are 4 /4" wide by 3 7/8" deep. Outdoor enclosures are 4 /2" wide by 4 /4" deep. Suitable for use as service entrance equipment when not more than six main disconnecting means are provided. See article of the NEC. Rated 00,000A IR in series with breakers listed on wiring diagram. -4 Siemens Industry, Inc. SPEEDFAX 20 Product Catalog