Make/Model: Meter: Serial Number: Eq ID: Fleet No: JOHN DEERE 8235R RW8235RHBP BP041629

Transcription

1 Invoice umber: /25/ Page: 1 of 2 JOH DEERE 8235R RW8235RHBP BP GE-1 Retail 01 STEERIG CODE Autotrac steering will disengage at random times. Customer stated the wheel angle sensor had been replaced previously. Was not able to get steering to disengage. Calibrate steering several times with out any faults. Remove left axle harness and inspect. Found internally damaged wires at the harness flex points. Order and install new harness. Calibrate front axle and check results. Labor: $ Parts: OL&M: Svc Acc/Env: Svc Call: Sub-Total: $ TAXLT /MFWDHUB-8235R Retail 02 HUB SEAL-MFWD & ILS (one side), Replace Raise and support front axle. Remove wheel. Remove retaining screws from hub assembly. Remove and disassemble hub. Clean and replace parts as needed. Reassemble in reverse order. Reinstall and torque wheel to 114 lb-ft. THAK YOU FOR YOUR BUSIESS. P3750 FREIGHT $15.00 COTIUED O EXT PAGE->

2 Invoice umber: /25/ Page: 2 of 2 JOH DEERE 8235R RW8235RHBP BP /MFWDHUB-8235R Retail RE Chassis Wiring Harness $79.15 RE SEAL $69.80 Labor: $4.75 Parts: $ OL&M: Svc Acc/Env: Svc Call: Sub-Total: $ TAXLT Miscellaneous Charges: SERVICE ACCESSORIES/EVIROMET $34.06 Customer PO o: Tax Exempt o: FORM 13 * * * DOCUMET COPY * * * Information Type: Multi-use Acct US Auth. o: Merchant o: Card o: xxxxxxxxxxxx6943 Bill Code: SHOP WORK Credit Plan: PURCHASE Labor: Parts: OL&M: Svc Acc/Enviro: Svc Call/Hauling: Sales Tax: Grand Total: $ $ $34.06 $ TERMS AD CODITIOS This purchase(s) is subject to the terms of the Multi-Use Account, a service of John Deere Financial, f.s.b. I grant the issuer a purchase money security interest, except as limited in that agreement, in the goods described. Received by:... Date:...

3 Invoice umber: /27/ Page: 1 of 2 JOH DEERE 8235R RW8235RHBP BP /Diag-General Retail 01 CHECK OUT HITCH AD SCV CODES Check entire circuit from controller down to hitch position and draft sensors. -wiring ok, supply voltage ok, ground check ok, no shorts. Hitch position sensor reading incorrectly, replace. After hitch position sensor was replaced, hitch would not calibrate. Double check wiring/controller and sensors. Found draft sensor was working but was adjusted incorrectly. Adjust sensor so voltage is 2.3v static with no load. After draft sensor adjustment, was able to calibrate hitch and all codes cleared. HV and codes came back when operating machine. Check DTAC, and found solution Follow DTAC instructions and found that it was hitch valve not operating as it should. Call customer and they did not want to fix the hitch valve at this time. Put tractor back together. THAK YOU FOR YOUR BUSIESS. RE HYD. QUICK $89.67 COTIUED O EXT PAGE->

4 Invoice umber: /27/ Page: 2 of 2 JOH DEERE 8235R RW8235RHBP BP /Diag-General Retail RE SESOR $ Labor: $ Parts: $ OL&M: Svc Acc/Env: Svc Call: Sub-Total: $ TAXLT, TDALJ, TFURJ IVOICE COTAIS $0.90 DISCOUT Miscellaneous Charges: SERVICE ACCESSORIES/EVIROMET $34.20 Customer PO o: Tax Exempt o: FORM 13 * * * DOCUMET COPY * * * Information Type: Multi-use Acct US Auth. o: Merchant o: Card o: xxxxxxxxxxxx6943 Bill Code: SHOP WORK Credit Plan: PURCHASE Labor: Parts: OL&M: Svc Acc/Enviro: Svc Call/Hauling: Sales Tax: Grand Total: $ $ $34.20 $ TERMS AD CODITIOS This purchase(s) is subject to the terms of the Multi-Use Account, a service of John Deere Financial, f.s.b. I grant the issuer a purchase money security interest, except as limited in that agreement, in the goods described. Received by:... Date:...

5 Invoice umber: /9/ Page: 1 of 3 JOH DEERE 8235R RW8235RHBP BP /Diag-General Retail 01 CHECK OUT TIRE WEARIG O OUTSIDE Customer showed me the old tire condition. Raise front end of tractor off the ground. Check tie rod for excessive play. Check upper and lower king pins for play, found play in lower king pin. Had customer bring machine into shop for further repairs. Policy adjust per Alan P. $93.00 S5324 POLICY ADJ-SERV ($93.00) Labor: $93.00 Parts: ($93.00) OL&M: Svc Acc/Env: Svc Call: Sub-Total: TVOSJ /B-SERVICE-CALL Retail 02 SERVICE CALL Policy adjust per Alan P. $ S5324 POLICY ADJ-SERV ($161.20) Labor: $ Parts: ($161.20) OL&M: Svc Acc/Env: Svc Call: Sub-Total: TVOSJ GE-1 Retail COTIUED O EXT PAGE->

6 Invoice umber: /9/ Page: 2 of 3 JOH DEERE 8235R RW8235RHBP BP GE-1 Retail 03 I SHOP REPAIR KIG PI BEARIGS BAD Check for endplay and movement at right front wheel. Remove tire, fender, steering cylinder, tie rod. Remove hub assembly. Replace bearings on kingpins. Remove and replace bearing cups and seals. Reassemble and set bearings to specs with shims on lower kingpin. Replace axle shaft seal and reinstall hub. Add oil to front differential. Test drive and wash up right front axle area. Right front wheel will need to be re torqued. THAK YOU FOR YOUR BUSIESS. JD7424 BEARIG CU $9.30 JD8252 Bearing Cup $17.23 JD8930 Bearing Cone $28.55 JD8968 Bearing Cone $31.24 RE SEAL $18.86 RE SEAL $52.35 RE71181 SEAL $20.26 COTIUED O EXT PAGE->

7 Invoice umber: /9/ Page: 3 of 3 JOH DEERE 8235R RW8235RHBP BP GE-1 Retail TY26625B HYGARD SHOP BULK $13.44 Labor: $ Parts: $ OL&M: Svc Acc/Env: Svc Call: Sub-Total: $ TAXLT Miscellaneous Charges: SERVICE ACCESSORIES/EVIROMET $48.34 Customer PO o: Tax Exempt o: FORM 13 * * * DOCUMET COPY * * * Information Type: Multi-use Acct US Auth. o: Merchant o: Card o: xxxxxxxxxxxx6943 Bill Code: SHOP WORK Credit Plan: DEFAULT CREDIT PLA Labor: Parts: OL&M: Svc Acc/Enviro: Svc Call/Hauling: Sales Tax: Grand Total: $ ($62.97) $48.34 $ TERMS AD CODITIOS This purchase(s) is subject to the terms of the Multi-Use Account, a service of John Deere Financial, f.s.b. I grant the issuer a purchase money security interest, except as limited in that agreement, in the goods described. Received by:... Date:...

8 Workshop Sundry Invoice Bus Phone: Invoice umber: /21/ Account Page: 1 of 1 JOH DEERE 8235R 1RW8235RHBP BP REWORK Misc 01 REWORK CUSTOMER DID THE WORK HIMSELF JUST BILL THE PART CAUSED BY TODD. Rework caused by Todd. Customer did the work themselves. P3750 FREIGHT $34.39 Y R Plate $ Labor: Parts: $ OL&M: Svc Acc/Env: Svc Call: Sub-Total: $ Y Customer PO o: Tax Exempt o: FORM 13 * * * DOCUMET COPY * * * Labor: Parts: OL&M: Svc Acc/Enviro: Svc Call/Hauling: Sales Tax: Grand Total: $ $12.20 $ TERMS AD CODITIOS Approved charges are due the 15th of the month following invoice date. Accounts 30 days past duewill be charged a FIACE CHARGE of 1.5% per month which equals an 18% AUAL RATE of interest per year. $35 returned check fee. Purchaser agrees to pay reasonable attorney fees if collection efforts are required. The invoice must accompany all returned goods. o returns accepted after 30 days. Returned goods subject to restocking charges. Electrical parts are non-refundable. Received by:... Date:...

9 Bus Phone: Invoice umber: /25/ Page: 1 of 2 JOH DEERE 8235R 1RW8235RHBP BP /Diag-Hydraulics Retail HITCH WILL MOVE O IT OW AD HUT Read though dtac case Check connections to hitch valve. Remove the right hand lift cylinder and remove the spool valve. Did not see any marks on valve. Install valve and lift cylinder. Following datc case a swap pilot control solenoid between hitch valve and SCV 3. Problem followed to SCV 3 and hitch valve worked like it should. Replace the pilot control solenoid in SCV 3 and flow rated it. Recalibrate hitch. Test operations. THAK YOU FOR YOUR BUSIESS. COTIUED O EXT PAGE->

10 Bus Phone: Invoice umber: /25/ Page: 2 of 2 JOH DEERE 8235R 1RW8235RHBP BP /Diag-Hydraulics Retail RE Valve Kit $ Labor: $ Parts: $ OL&M: Svc Acc/Env: Svc Call: Sub-Total: $1, TMALJ IVOICE COTAIS $16.69 DISCOUT Miscellaneous Charges: SERVICE ACCESSORIES/EVIROMET $35.22 Customer PO o: Tax Exempt o: FORM 13 * * * DOCUMET COPY * * * Information Type: Multi-use Acct US Merchant o: Auth. o: Card o: xxxxxxxxxxxx6943 Bill Code: JD TRACTOR PARTS/SERVICE Credit Plan: DEERE AG O PAYMETS/O ITEREST WAIVER UTIL JULY Labor: Parts: OL&M: Svc Acc/Enviro: Svc Call/Hauling: Sales Tax: Grand Total: $ $ $35.22 $1, TERMS AD CODITIOS This purchase(s) is subject to the terms of the Multi-Use Account, a service of John Deere Financial, f.s.b. I grant the issuer a purchase money security interest, except as limited in that agreement, in the goods described. Received by:... Date:...

11

12

13