Work Order History Report
|
|
- Alaina McCormick
- 8 years ago
- Views:
Transcription
1 Work Order History Report Asset MG304 Asset: MG304, Including Children, Active: True Grader, motor W/O No Description Finished Done 1570 MG304 - Perform Plant Audit and Mobile Plant Mechanical Check List. Completed defects required work list for pending work to be done. 29/04/2010 Reading 6483 Hours 2804 MG304-Carry out 250Hr service 16/06/ Hours 2803 MG304-Carry out repairs as req'd. repair steering wheel console adjuster. replace blade slide wear strips. Adjust blade lift balls/rebush lift cylinder mounting yolks. reseal RHS tandem duo cone. reseal LH/RH control valves. repair air horn. Build up & line bore grader axle pivot boss - outsourced to Gunther Engineering EPO Service fire suppression system - outsourced to Sandvik Report # /07/ Hours 4080 MG304 - Remove and Recondition radiator 27/07/ Hours 4063 MG304 - Coolant contamination found in engine oil 28/07/ Hours 4883 CAT MG 140H (CCA) 500hr 2/08/ Hours 4840 MG304 - Repair of defects as per task list 11/08/ Hours 4852 CAT MG 140H (CCA) 500hr 11/08/ Hours 6029 MG304 - Replace cutting edges 5/09/ Hours 8157 MG304 - Work lights blown 7/10/ Hours 7805 CAT MG 140H (CCA) 1000hr 30/10/ Hours 9048 MG304 - Defects found at 7000hr service 30/10/2010 Hours 9600 MG304 - GET worn 10/11/ Hours 9915 MG304 - Replace grader blades 17/11/ Hours 8116 CAT MG 140H (CCA) 250hr 19/11/ Hours MG304 - FRC Inspection 30/11/2010 Hours 9780 CAT MG 140H (CCA) 500hr 20/12/ Hours CAT MG 140H (CCA) 250hr 27/01/ Hours MG304 - REPLACE A/C HOSE & bonnet latches 17/02/ Hours CAT MG 140H (CCA) 2000hr, carry out as per service sheet 25/02/ Hours
2 14157 Engine derates when articulating. Check for codes. Found throttle position sensor erratic and throttle lock enable switch erratic. Check harness at centre pivot point. Carry out wiggle test. Remove insulation from harness and check wiring. Found three broken wires. Repair wiring. Test, all OK. 26/02/ Hours MG304 - Replace blade 22/03/ Hours CAT MG 140H (CCA) 250hr 28/03/ Hours MG304 - Crack in tandem 1/04/ Hours MG304 - Air con faulty. (Air Conditioner repairs carried out, no paperwork found). 2/04/ Hours MG304 - Rear lights u/s 6/05/ Hours CAT MG 140H (CCA) 500hr - service completed 7/05/ Hours MG304 - Small wiper motor NW. Replaced motor & adjusted blades MG304 - replace lower circle wear plates and lift cylinder cup bearings etc.removed old wear plates of circle drive and replaced checked over operation all ok 11/05/ Hours 2/06/ Hours CAT MG 140H (CCA) 250hr 6/06/ Hours CAT MG 140H (CCA) 1000hr Service completed as per schedule 17/06/ Hours MG304 - Remove and replace scarafier tips. 21/06/ Hours MG304. Hour meter not working. 21/06/ Hours MG304 - Replace fuel filler cap. 21/06/ Hours MG304 - Headlight switch faulty. Replace switch 10/07/ Hours CAT MG 140H (CCA) 250hr 28/07/ Hours MG304-overhaul tandem drives. Remove tandems & strip, clean & inspect ready for repairs. complete parts list & order replacemnt parts. Carry out reassembly of tandems replacing parts as req'd. 17/09/2011 Hours MG304-pressure test all systems. 17/10/2011 Hours MG304- Respray CAT yellow and paint black stripe 17/10/2011 Hours MG304-final electrical and mechanical inspection 18/10/2011 Hours MG304-Carry out overhaul of air conditioning 18/10/2011 Hours MG304. Cutting edges worn and need to be replaced. 30/10/2011 Hours
3 25630 MG304-split machine-replace hitch,repair both left & right Artic cylinders Ref> Attached Doc. 1/11/ Hours CAT MG 140H (CCA) 2000hr- closed due to error 8/11/2011 Hours CAT MG 140H (CCA) 250hr - cancelled due to error 8/11/2011 Hours CAT MG 140H (CCA) 250hr - cancelled do error 8/11/2011 Hours MG304-re-spray unit - Ref MG304-Repairs to "a" frame,blade,rams,implements. Removed, rebuilt & refitted worm drive motor & pump. Removed & rebuilt LHS valve bank, refitted after repairs. Cleaned front & rear articulation areas that have been split ready for line boring. Removed blade lift yoke bushes & replaced with new seals to yokes. fitted blade to turntable. installed all blade cylinders with correct shims & tensioned caps & seals MG304-Line Bore to suit new bushes MG304-overhaul front axle MG304-Carry out inspection for repairs required & create jobs & parts listings MG304-remove engine and transmission,change parts over,install engine and transmission FRC Inspection replace step rh side and hyd hose for blade tilt ram 25/11/ Hours CAT MG 140H (CCA) 500hr 28/11/ Hours CAT MG 140H (CCA) 250hr 25/12/ Hours Replace Belly plate that was left off at Burton 30/12/ Hours Replace Cutting egdes on grader blade 30/12/ Hours Replace Ripper Boots p/n 6Y-5230 x9 on rear 11/01/2012 Hours Replace ripper boots p/n 6Y /01/ Hours CAT MG 140H (CCA) 2000hr 9/02/ Hours replace wear pads and reshim the blabe 9/03/ Hours CAT MG 140H (CCA) 250hr 20/03/ Hours Replace alternator/air cond. belt P/N /04/ Hours
4 48212 Replace GET cutting edge 1/05/ Hours CAT MG 140H (CCA) 500hr 15/05/ Hours replace set throttle switch.p/n /05/ Hours replace hyd hose from steel line at front down to rh steer ram hose was installed wrong and has being pinched hose part number Replaced in January MG304-Left Hand Front Work Light Inoperative.-Checked Over- Fitted new globe-ok 26/05/ Hours 21/06/ Hours Replace Wiper arm 30/06/ Hours CAT MG 140H (CCA) 250hr 2/07/ Hours MG304-Replace RH lift cylinder not this machine 3/07/ Hours Inspect fire supression 7/08/ Hours CAT MG 140H (CCA) 1000hr 8/08/ Hours FRC Inspection 27/08/ Hours Replace wiper arm 28/08/ Hours CAT MG 140H (CCA) 250hr 22/09/ Hours Repairs as per to do list 15/10/ Hours Replace worn hydraulic hose for steering. Part number Replace spring for steering column tilt. Part number 8C /10/ Hours CAT MG 140H (CCA) 500hr 7/11/ Hours Fit new ripper boots 22/11/ Hours Replace cutting edges 29/11/ Hours Fire supression service level 2 7/12/ Hours CAT MG 140H (CCA) 250hr 22/12/ Hours Replace blade slides 6/01/ Hours CAT MG 140H (CCA) 2000hr 23/02/ Hours MG304-Change out all drive tyres, change out front tyres with the best of the removed drive tyres. 17/04/ Hours
5 89292 MG304-Change out all drive tyres. Change out front tyres for best drive tyres. Torque all to spec. Carry out retorques as req'd. 17/04/ Hours MG304 Inspect and prep for site. Repair steering and brake system(docs attached - Hitachi) 3/03/ Hours CAT MG 140H (CCA) 250hr 12/03/ Hours MG304 - Prep for Site - Electrical (defects)renew worklights, renew horn, renew isolators and lock out, make up new battery wire and service terminals, renew LH headlight globe. 19/06/ Hours Replace broken governor pedal in cab - fit new pedal 24/10/ Hours MG304 - Replace alternator, replace AC compressor, replace belt. - Removed and replace compressor, new belt fitted, threw belt, replace belt, fix door Repair Air Conditioner - remove and refit drive shaft for belt, new alternator and compressor ordered, fitted new components, new belt fitted, A/C regassed. 28/10/ Hours 29/10/ Hours CAT MG 140H (CCA) 500hr - Completed as per Work Order 7/11/ Hours CAT MG 140H (CCA) 250hr 22/11/ Hours MG304 - CAT MG 140H (CCA) 1000hr - Completed as per Work Order Fire suppresion service - Outsourced to Sandvik(Docs to be attached - ed RD, CMP on ) 4/12/ Hours 5/02/ Hours MG304
Work Order History Report
Work Order History Report Asset WL307 Asset: WL307, Including Children, Active: True Loader, Wheel (IT) W/O No Description Finished Hours 179 WL307 R&R transfilter tested ok 3/12/2009 Hours 103 CAT WL
More informationCustomer Owned Certified
TEREX BENFORD TA30 Customer Owned Certified OFF HIGHWAY TRUCKS Inspection Number: 751979 Serial #: A7991472 Date Created: 07/27/2011 07:46:05 AM CDT Engine Serial #: N/A Last Updated: 08/02/2011 07:10:48
More informationWynn s Extended Care
Wynn s Extended Care Every car deserves to receive the very best care... especially yours. How Do You Keep Your Reliable Transportation Reliable? Count on Wynn s Because Wynn s has been caring for cars
More information6-years/75,000 miles Comprehensive coverage Subsequent Owner Warranty $100 Deductible
LINCOLN PREMIER LIMITED WARRANTY 6-years/75,000 miles Comprehensive coverage Subsequent Owner Warranty $100 Deductible Comprehensive Coverage Because Lincoln has always been a brand you can trust and respect,
More informationAUTOMOBILE MECHANIC STUDENT INTERNSHIP SKILLS LIST Provo School District
AUTOMOBILE MECHANIC STUDENT INTERNSHIP SKILLS LIST Provo School District Repairs and overhauls automobiles, buses, trucks, and other automotive vehicles: Examines vehicle and discusses with customer or
More informationAsking Price: N/A Final Price: N/A OROPS BUCKET AUXILIARY HYDRAULICS GENERAL APPEARANCE. Good. Good
Page 1 of 6 SPECIFICATIONS 2005 CATERPILLAR 247B Customer Owned Certified MULTI TERRAIN LOADERS Inspection Number: 1117842 Serial #: MTL01706 Date Created: 09/23/2013 02:53:31 PM CDT Engine Serial #: N/A
More informationJCB TELESCOPIC WHEELED LOADERS TM180 AND TM220
JCB TELESCOPIC WHEELED LOADERS TM180 AND TM220 Incredible versatility is achieved through compact dimensions and the additional lift height provided by a telescopic boom The manoeuvrability of articulated
More informationPUMP MAINTENANCE SCHEDULE AND CHECKLISTS
PUMP MAINTENANCE SCHEDULE AND CHECKLISTS Providing a maintenance schedule defined specifically by run hours or yardage pumped serves only as a general guideline given the large amount of variables a unit
More informationHITACHI EXTENDED LIFE PROGRAM
HITACHI EXTENDED LIFE PROGRAM HITACHI EXTENDED LIFE PROGRAM Always with the Customer All new Hitachi equipment has our comprehensive manufacturer s warranty. These days however, equipment owners feel they
More informationExtended Protection Plans for New and Pre-Owned Vehicles
Extended Protection Plans for New and Pre-Owned Vehicles Extended Protection you can count on from Old Republic Insured Automotive Services, Inc. (ORIAS) Your vehicle is a major investment. Next to your
More information356 CHECKLIST ELECTRICAL: CHASSIS:
356 CHECKLIST ELECTRICAL: Headlights hi/lo beam Taillights Running lights Turn signals Brake lights License light(s) Fog lights Reverse light Horn Dome lights Dash lights Temp guage Tank level guage Tachometer
More informationMINI EXTENDED SERVICE CONTRACTS
MINI EXTENDED SERVICE CONTRACTS LESS WORRY, MORE WEEEE! CONTINUING COVERAGE FOR YOUR NEW, USED, OR CERTIFIED PRE-OWNED MINI. Whether your odometer is ticking toward the end of your original 4-year/50,000-mile
More information830-II *330492* Cummins 4 Cylinder Engine Breakdown. 330492 Rev. 00
830-II Cummins 4 Cylinder Engine Breakdown 330492 Rev. 00 *330492* This manual is furnished with each new TENNANT Model 830. This manual consists of the 4 Cylinder Cummins Engine Breakdown. MACHINE DATA
More informationUDOT RPMS VEHICLE RECORDS, PREVENTIVE MAINTENANCE & SURVEILLANCE
UDOT RPMS VEHICLE RECORDS, PREVENTIVE MAINTENANCE & SURVEILLANCE VEHICLE RECORDS AND PREVENTIVE MAINTENANCE Prepared by: UTAH DEPARTMENT OF TRANSPORTATION OFFICE OF PLANNING AND PROGRAMMING IN COOPERATION
More informationKobelco Extended Warranty Program. www.kobelco-europe.com
Kobelco Extended Warranty Program www.kobelco-europe.com Kobelco Extended Warranty is a convenient, value added way to give your Kobelco customers added security and peace of mind. Benefits of the Kobelco
More informationCONTINUED COVERAGE FOR YOUR NEW, USED, OR CERTIFIED PRE-OWNED BMW.
BMW EXTENDED SERVICE CONTRACTS FEEL THE RUSH OF ASSURANCE. CONTINUED COVERAGE FOR YOUR NEW, USED, OR CERTIFIED PRE-OWNED BMW. Whether your original 4-year/50,000-mile BMW Warranty is coming to an end,
More information5 Mechanisms and accessories
5 Mechanisms and accessories 51A SIDE OPENING ELEMENT MECHANISMS 52A NON-SIDE OPENING ELEMENT MECHANISMS 54A WINDOWS 55A EXTERIOR PROTECTION 56A EXTERIOR EQUIPMENT 57A INTERIOR EQUIPMENT X79 NOVEMBER 2009
More informationEngine, Drive Train, and Hydraulic Repair Indicator Quick Reference Guide
Engine, Drive Train, and Hydraulic Repair Indicator Quick Reference Guide Planned Indicators Planned Indicators SM provide the best insight Service Meter Hours CAT Engine Repair Indicators Description
More informationRail 001 112 2 Canvas, folding top 001 101 3 Rear panel 001 102 4 Stip in window, left 001 106 dto. right 001 107
U 411 1 Rear view mirror, round, metall 13cm Ø 002 045 2 Raised airintake 002 060 3 Side panelling, front, left 002 030 Side panelling, front, right 002 031 4 Panelling left 002 051 dto. right 002 052
More informationCOMMON WEAR PARTS & QUICK REFERENCE PARTS BREAKDOWN
COMMON WEAR PARTS & QUICK REFERENCE PARTS BREAKDOWN SERIES MECHANICAL SWEEPERS pn GS328985 REV B MAY 2012 COPYRIGHT 2012 GLOBAL ENVIRONMENTAL PRODUCTS, INC. ALL RIGHTS RESERVED REV B MAY 2012 Page 2 Common
More informationExtended Protection Plans for New and Pre-Owned Vehicles
Extended Protection Plans for New and Pre-Owned Vehicles Protection from the Unexpected. Your vehicle is not only an investment; it s your transportation lifeline. Driver s Choice from Old Republic Insured
More information2003 ACCORD - Automatic Transmission Removal
2003 ACCORD - Automatic Transmission Removal Special Tools Required Engine support hanger, A and Reds AAR-T-12566 Engine hanger balancer bar VSB02C000019 Front subframe adapter VSB02C000016 These special
More informationREMOVAL AND INSTALLATION
303-01C-1 REMOVAL AND INSTALLATION Engine Body On Special Tool(s) Adapter For 303-D043 303-D043-02 or equivalent Special Tool(s) 303-01C-1 Turbocharger Lifting Bracket 303-1266 Wrench, Fan Clutch Nut 303-214
More informationCOVERING MILLIONS Preferred Protection Plan, a Service Group Company www.sgifs.com PO Box 26830, Austin, TX 78755-0800.
COVERING MILLIONS Preferred Protection Plan, a Service Group Company www.sgifs.com PO Box 26830, Austin, TX 78755-0800. 1-877-565-0816 PPP-308 0903 rev 0408 BENEFITS New and Pre-Owned Vehicles Preferred
More informationInformation and Instructions
Information and Instructions This shop manual contains several sections each covering a specific group of wheel type tractors. The Tab Index on the preceding page can be used to locate the section pertaining
More information2017 Audi Maintenance Schedule - All Models
2017 Audi Maintenance Schedule - All Models MY 2017 Maintenance Intervals - USA Service Intervals If you are not sure when you should bring your Audi in for service or which services are to be performed
More information46431x92A Garden Tractor (1998) Page 1 of 16 Body Chassis
46431x92A Garden Tractor (1998) Page 1 of 16 Body Chassis 46431x92A Garden Tractor (1998) Page 2 of 16 Body Chassis 1 092546E701 Bracket, Seat 2 091963 Z Plate Assembly, Switch 3 164X26 Spring, Compression
More informationService Packages & Pricing
Service Packages & Pricing Silver Gold Motorcycle Service Packages Change oil & filter Change oil & filter Fuel system treatment $ 109.95 $ 129.95 Platinum Replace spark plugs Change oil & filter Fuel
More informationRe-engineering and function testing at Handtmann Zittau WELCOME
Re-engineering and function testing at Handtmann Zittau WELCOME Handtmann Maschinenfabrik GmbH & Co. KG / VVZ 3/01/2015 page 1 Agenda Generell Information Handtmann Zittau Re-engineering Handtmann Zittau
More informationPorsche Approved Certified Pre-Owned. Limited Warranty
Porsche Approved Certified Pre-Owned Limited Warranty Porsche Approved. A guaranteed mark of quality. At Porsche, we re committed to exceptional performance. The inherent reliability and longevity of
More informationMERCEDES FIRST EDITION - 2013
FIRST EDITION - 2013 CONTENTS Accessories... 1 Hydraulic Jacks Air Intake... 2 Air Filter Charger Charging System Intake Charger Hose Intake Manifold Intake Pipe Air Filter Intercooler Charger Aircondition...
More informationSouthern Columbia Area School District Bus/Automotive Parts for Sale. PartNo Description Vendor Amount 1 583966C91 EXHAUST CLAMP 1 2 905-09 PIPE 1
Southern Columbia Area School District Bus/Automotive Parts for Sale PartNo Description Vendor Amount 1 583966C91 EXHAUST CLAMP 1 2 905-09 PIPE 1 3 00025296 BACK UP LIGHTS 1 4 00109869 HARNESS Bus Parts
More informationMOTOR VEHICLE MECHANIC REPAIR CATEGORIES
Chapter 8: Motor Vehicle Mechanic Repair Categories Page 1 CHAPTER 8 MOTOR VEHICLE MECHANIC REPAIR CATEGORIES Section 8-1 REQUIREMENT Section 10 of the Motor Vehicle Service and Repair Act (MCL 257.1310)
More informationPLAN VEHICLE THE COST OF UNEXPECTED REPAIRS FREQUENTLY ASKED QUESTIONS PACKAGE PROTECTION
Administered by GWC Warranty Corporation Showroom Level, 40 Coal Street Wilkes-Barre, PA 18702 1.800.482.7357 www.gwcwarranty.com This plan is backed by American Bankers Insurance Company of Florida (in
More informationFOR ANY QUESTIONS, PLEASE CALL US @ 727.347.9915 M-F 8:00a.m.-8:00p.m. EST. REAR BRAKES 1 AEROSPACE COMPONENTS 727.347.9915
REAR BRAKES 1 AEROSPACE COMPONENTS 727.347.9915 REAR BRAKES Before getting started, remove all stock braking components. Pre-assembly of parts: Clean the bolts and the threads in the hat with acetone.
More information2007 Hummer H3. 2007 BRAKES Disc Brakes - H3. Fastener Tightening Specifications Specification Application
2007 BRAKES Disc Brakes - H3 SPECIFICATIONS FASTENER TIGHTENING SPECIFICATIONS Fastener Tightening Specifications Specification Application Metric English Backing Plate Bolts 135 N.m 100 lb ft Brake Hose
More informationPreventative Maintenance Policies and Plan
Preventative Maintenance Policies and Plan The objectives of the NECTD Preventative Maintenance Policies and Plan are: Ensure that assets are protected and maintained so that they reach their maximum useful
More informationUnit: mm(in) Item Standard value Service limit Axle shaft run out - 0.2(0.008)
Rear Wheel/Brake/Suspension 13. Rear Wheel/Brake/Suspension Service Information 13-1 Troubleshooting 13-2 Rear Wheel 13-3 Rear Cushion 13-4 Rear Swing Arm 13-7 Service Information General Safety If the
More informationPalm Beach County Fleet Management Asset Maintenance History
Workorder: 737575 Meter Reading: 0 In Date: 04/24/2007 Close Date: 04/24/2007 Asset: 10166693 2007 TOYOTA PRIUS Car, MidSize, Hybrid PREDELIVERY INSPECTION PreDelivery Inspection 2.00 Charge: 0.00 Charge:
More informationMAN - MERCEDES - BENZ
SAYFA: 1 10100 10102 10103 355 353 06 15 355 353 03 15 346 353 08 15 AXLE GEAR AXLE GEAR AXLE (WITH BUSHING TYPE) (WITH BUSHING TYPE) (WITH BUSHING TYPE) 2521 2517-2521-2622 10104 10105 10106 308 350 00
More information301.7D. Mini Hydraulic Excavator
301.7D Mini Hydraulic Excavator Engine Weights Gross Power (ISO 14396) 17.9 kw 24.3 hp Operating Weight with Canopy 1610 kg 3,550 lb Net Power 13.2 kw 17.7 hp Operating Weight with Cab 1720 kg 3,792 lb
More informationELECTRICAL WIRING (R.H. DRIVE VEHICLES)
C-1 ELECTRICAL WIRING (R.H. DRIVE VEHICLES) CONTENTS GENERAL.......................... 3 WIRING HARNESS CONFIGURATION DIAGRAMS......................... 4 ENGINE COMPARTMENT................ 4 DASH PANEL...........................
More informationHeavy Duty Equipment Mechanic (Class Code 3743) Task List. Inspection and Diagnosis
Heavy Duty Equipment Mechanic (Class Code 3743) Task List Inspection and Diagnosis In order to verify complaints and determine malfunctions a Heavy Duty Mechanic: 1. Reads operators written trouble reports,
More informationBUYERS GUIDE. IMPORTANT: Spoken promises are difficult to enforce. Ask the dealer to put all promises in writing. Keep this form.
BUYERS GUIDE IMPORTANT: Spoken promises are difficult to enforce. Ask the dealer to put all promises in writing. Keep this form. VEHICLE MAKE MODEL YEAR VIN NUMBER DEALER STOCK NUMBER (Optional) WARRANTIES
More informationPARTS SECTION. Section MF4
PARTS SECTION Section MF4 Wheels, Steering, Axle; hubs, rims, steering pumps, ALLIS CHALMERS RADIATOR HOSE ALLIS CHALMERS RADIATOR HOSE 70243014 180, 185, 190, 190XT 70248233 180, 185, 190, 190XT Radiator
More informationClass 5 to 7 Truck and Bus Hydraulic Brake System
Class 5 to 7 Truck and Bus Hydraulic Brake System Diagnostic Guide 1st Edition * 5+0 Important Service tes The information in this publication was current at the time of printing. The information presented
More informationDO NOT attempt to repair hub and wheel bearing assembly.
Page 1 of 6 HUB & WHEEL BEARINGS (WITH PULSE VACUUM HUBLOCK) DO NOT attempt to repair hub and wheel bearing assembly. Removal DO NOT remove hub lock assembly by prying on hub lock legs. This can crack
More informationSUSPENSION DIAGNOSIS
SECTION 2A SUSPENSION DIAGNOSIS TABLE OF CONTENTS Diagnosis... 2A-2 General Diagnosis... 2A-2 Hub and Bearing... 2A-7 2A-2 SUSPENSION DIAGNOSIS DIAGNOSIS GENERAL DIAGNOSIS Problems in the steering, the
More informationExtended Coverage Customer Personal Service
Extended Coverage Customer Personal Service www.johndeere.com At John Deere, feeling secure is not an option Standard warranty promises that on construction machines under 100 horsepower, we ll fix all
More informationDuramax Maintenance Info
The following maintenance schedule was arranged using information from GM, OEM manufacturers and personal experience. It does not represent the standard and should only be used as reference, you may choose
More informationPorsche Service. Cayenne (from MY 2008 for the following countries:
Porsche Service Cayenne (from MY 2008 for the following countries: Abu Dhabi, Bahrain, Dubai, Jordan, Qatar, Kuwait, Lebanon, Oman, Saudi Arabia, Syria) Porsche Cayenne Maintaining driving pleasure No
More informationMAINTENANCE INTERVALS
MAINTENANCE INTERVALS Operation and Maintenance Manual Excerpt 2010 Caterpillar All Rights Reserved SEBU8407-03 November 2009 Operation and Maintenance Manual 279C, 289C and 299C Compact Track Loaders
More informationCUTTER-CRUSHER RAMMER RC 22
11/99 PARTS MANUAL PMRC22EN.A99 CUTTER-CRUSHER RAMMER RC 22 SERIAL NO. RC22BC0015-UP RC22RC0021-UP TABLE OF CONTENTS 1. Cylinder RC 22.......................................................... 4 2. Hydraulics
More information2006 Volkswagen Maintenance Schedule by Miles/Kilometers
2.0 Liter Engine: Engine: Change engine oil and oil filter Engine: Check for leaks Service interval display: Reset (Where applicable) Exhaust system: Check for damage & leaks Battery: Check Door check
More informationILLUSTRATED PARTS LIST
TW400 WITH 390cc HONDA ENGINE 390cc 2 WHEEL DRIVE UTILITY VEHICLE ILLUSTRATED S LIST 390cc 2WD B O D Y D I A G R A M 390cc 2WD F R A M E D I A G R A M 390cc 2WD D R I V E T R A I N D I A G R A M DESCRIPTION
More informationTitan Makina Ltd. Şti. 1160. Sok. No: 9 Ostim 06370 Ankara Tel: + 90 312 354 9977 Fax: + 90 312 385 5611 Web: www.titanltd.com.
IS26 Concrete Spraying Machine IS26 Concrete Spraying Machine TECHNICAL SPECIFICATIONS Manipulator Max. vertical spraying reach : Max. horizontal spraying reach : Working lights : Spraying Head Rotation
More informationENTRY-LEVEL AUTOMOTIVE TECHNICIAN
ENTRY-LEVEL AUTOMOTIVE TECHNICIAN Definition: An entry-level automotive technician performs diagnosis and repair to gasoline powered cars and light trucks with limited supervision. The last two bands of
More informationPREVENTION MAINTENANCE CHECKLIST FOR TRACTORS, TRUCKS, AND AUTOMOBILES
PREVENTION MAINTENANCE CHECKLIST FOR TRACTORS, TRUCKS, AND AUTOMOBILES Farm Machinery Fact Sheet FM-21 By Dr. Von H. Jarrett, Extension Agricultural Engineer Systematic sequence for inspection GASOLINE
More information2016 Price Sheet. Custom Built Replacement Chassis
2016 Price Sheet Custom Built Replacement Chassis 5557 Chevy Car Direct Replacment Chassis 15,895 5362 Corvette Direct Replacment Chassis 15,895 5557 Chevy Car Pro Street Chassis 16,895 5362 Corvette Pro
More informationHYDRAULIC LIFT TABLE CART 2200-LB.
HYDRAULIC LIFT TABLE CART 2200-LB. OWNER S MANUAL WARNING: Read carefully and understand all MACHINE ADJUSTMENT AND OPERATION INSTRUCTIONS before operating. Failure to follow the safety rules and other
More informationPC18MR-3 PC20MR-3 PC27MR-3 PC30MR-3 PC35MR-3 PC45MR-3 PC55MR-3
PCMR-3 PC45MR-3 PC55MR-3 MR-3 SERIES COMPACT H YDRAULIC E XCAVATOR WALK-AROUND Photo may include optional equipment Performance and Versatility Komatsu HydrauMind hydraulic system Automatic load sensing
More informationImportance of Pre-Operational Inspections
Importance of Pre-Operational Inspections Sometimes, looking, listening and smelling can prevent an accident or severe damage to equipment. Here are some tips on what to look for, how to listen and what
More information13. REAR WHEEL/BRAKE/SUSPENSION
13. REAR WHEEL/BRAKE/SUSPENSION 13 3.5~4.5kg-m 8.0~10.0kg-m 0.8~1.2kg-m 3.0~4.0kg-m 2.4~3.0kg-m 3.5~4.5kg-m 6.0~8.0kg-m 13-0 13. REAR WHEEL/BRAKE/SUSPENSION 13 REAR WHEEL/BRAKE/SUSPENSION SERVICE INFORMATION...
More informationBR150 Pmi Baja Reaction 150cc Go Kart (VIN PREFIX L4VM)
Page 1 of 21 Product Information Baja Web > Product Information > Parts Lists > GOKART > BR150 Pmi Baja Reaction 150cc Go Kart (VIN PREFIX L4VM) BR150 Pmi Baja Reaction 150cc Go Kart (VIN PREFIX L4VM)
More informationMAINTENANCE INTERVALS
MAINTENANCE INTERVALS Operation and Maintenance Manual Excerpt 2010 Caterpillar All Rights Reserved SEBU7546-03 March 2007 Operation and Maintenance Manual 816F Landfill Compactor, 815F Soil Compactor
More informationillustration ref. no. description SWAG no. RS Kombi, Octavia Scout 4x4, Octavia 4x4 for: Octavia, Octavia Kombi
Skoda protection Kit for strut 20 56 0003 - for: Fabia Skoda protection Kit for strut 30 56 0010 for: Felicia I, Felicia II - Skoda protection Kit for strut 30 56 0029, Octavia Kombi 4x4, Octavia RS, Octavia
More informationCDS TROUBLESHOOTING SECTION I. VACUUM. 1.0. Weak vacuum at wand. Gauge reads normal (10hg to 14hg)
CDS TROUBLESHOOTING SECTION I. VACUUM 1.0. Weak vacuum at wand. Gauge reads normal (10hg to 14hg) 1.1. Clogged hoses or wand tube. Disconnect hoses and carefully check for an obstruction. 1.2. Excessive
More information125 DUKE EU 2011 SPARE PARTS MANUAL: CHASSIS ENGLISH ART.NO.: 3CF8003K4EN
SPARE PARTS MANUAL: CHASSIS ART.NO.: 3CF8003K4EN ENGLISH INDEX FRONT FORK, TRIPLE CLAMP HANDLEBAR, CONTROLS FRAME SIDE / CENTER STAND 3x 4x 5x 6x SHOCK ABSORBER SWING ARM EXHAUST SYSTEM AIR FILTER 7x
More informationCOMMERCIAL GAS DRYER
COMMERCIAL GAS DRYER MODELS CGD8990XW0 4 12 Litho In U.S.A. (CMS) (psw) c 2012 WHIRLPOOL CORPORATION Part No. Rev. B TOP AND CONSOLE PARTS 2 TOP AND CONSOLE PARTS 1 Literature Parts W10184516 Installation
More informationDIESEL Technician. Endorsement: Diesel Technician Prerequisite: None CORE STANDARDS, OBJECTIVES, AND INDICATORS
DIESEL Technician Levels: Grades 10-12 Units of Credit: Minimum 0.5 CIP Code: 47.0605 11 Digit Code: 40-09-00-z00-060 11 Digit CE Code: 40-09-00-13-060 Test #: 907, 908, 909, 910 License: CTE/Secondary
More informationIllustrated Parts List
Spicer Tandem Axles Illustrated Parts List AXIP0085a January 1994 Single Reduction, Dual Range, & Double Reduction Addendum 461, 462, 463, 521, 581 46,000-65,000 lbs Introduction Single Reduction w/wheel
More informationCity of Tampa Employment Services Division FLEET MECHANIC APPLICATION SUPPLEMENT
City of Tampa Employment Services Division FLEET MECHANIC APPLICATION SUPPLEMENT Check the job(s) for which you are applying: Fleet Mechanic I Fleet Mechanic II Fleet Mechanic III NAME Date: Please read
More informationDESTROKED. Circuits that will be run through the Ford PCM and Ford Engine Harness
DESTROKED Thank you for your interest in Destroked. Please read through this overview to get a good idea of what is involved in your Cummins conversion project. Circuits that will be run through the Ford
More information4 Star 4 Star Plus. Vehicle
4 Star 4 Star Plus Vehicle Service Contracts WARRANTY SOLUTIONS Experience you can rely on Throughout our history, Warranty Solutions has demonstrated strength and versatility while evolving through ever-changing
More informationMODEL 565E - 22 TON AIR/HYDRAULIC AXLE JACK
1 565AKHU HYDRAULIC 1.22 O-RING - 2 REQUIRED UNIT 1.23 O-RING COMPLETE 1.24 TEFLON O-RING 2 REQUIRED 1.3 EXTENSION SCREW 1.3A SPRING PIN 1.4 SPRING SUPPORT 1.5 SCREW BUSHING 1.6 Y SHAPE SEAL RING 1.7 HEAD
More informationOVEN PARTS For Models:GSC308PJB05, GSC308PJQ05, GSC308PJT05, GSC308PJS05 (Black) (White) (Biscuit) (Black Stainless)
OVEN PARTS 30" BUILT IN ELECTRIC COMBO SENSOR/SC (GOLD LINE) 3 05 Litho In U.S.A. (cre) 1 Part No. Rev.A OVEN PARTS 1 Literature Parts 4455994 Installation Instructions Use & Care Guide 8300346 Microwave
More informationRAC Warranty Platinum - Maintenance & Breakdown Care
RAC Warranty Platinum - Maintenance & Breakdown Care Contents What the Agreement provides... 4 Section A. Our responsibilities under the Agreement... 5 Section B. Your responsibilities under the Agreement...
More informationChapter 7 Hydraulic System Troubleshooting
Chapter 7 Hydraulic System Troubleshooting General The following troubleshooting information is provided as a general guide to identify, locate and correct problems that may be experienced with the hydraulic
More informationCLASS B PRE-TRIP INSPECTION STUDY GUIDE
Miami School 3790 NW 11 th St. Miami, Fl 33126 305-649-5344 La Belle School 250 E. Cowboy Way La Belle, Fl 33935 863-675-0755 STRAIGHT TRUCK FRONT OF VEHICLE CLASS B PRE-TRIP INSPECTION STUDY GUIDE Chock
More informationG PART NUMBER OF CONNECTORS
A 1 A/C Ambient Temp. Sensor 90980 11070 Buckle SW RH (w/ Power Seat) A/C Condenser Fan Motor (1G FE) 90980 10928 B 9 Buckle SW RH (w/o Power Seat) 90980 11212 A 2 A/C Condenser Fan Motor (2JZ GE) 90980
More informationDrum Brake Owners Manual
Drum Brake Owners Manual TIE DOWN ENGINEERING, Inc. 5901 Wheaton Drive, Atlanta, GA 30336 www.tiedown.com (404) 344-0000 Fax (404) 349-0401 2007 TIE DOWN ENGINEERING, INC. ALL RIGHTS RESERVED Instruction
More informationMONTANA STATE PRISON POLICIES AND PROCEDURES. Signature: /s/ Mike Mahoney Effective Date: 6/5/00 Signature: /s/ Ross Swanson Effective Date: 6/5/00
MONTANA STATE PRISON POLICIES AND PROCEDURES Policy No.: MSP 1.2.18 Chapter #1: ADMINISTRATION AND MANAGEMENT Section #2: Fiscal Management Page 1 of 4 (plus attachment) Revision Date: Signature: /s/ Mike
More informationTable of Contents. Overview 1. Pump Disassembly 2. Control Disassembly / Reassembly 7. Pump Reassembly 13. Adjustment Procedures DR Control 19
Table of Contents Overview 1 Pump Disassembly 2 Control Disassembly / Reassembly 7 Pump Reassembly 13 Adjustment Procedures DR Control 19 Adjustment Procedures DRG Control 20 Adjustment Procedures DFR
More informationSTEERING HANDLEBAR/FRONT WHEEL/ FRONT SHOCK ABSORBER
14 14 STEERING HANDLEBAR/FRONT WHEEL/ SCHEMATIC DRAWING ------------------------------------------------- 14-1 SERVICE INFORMATION------------------------------------------------ 14-2 TROUBLESHOOTING-----------------------------------------------------
More informationREPAIR INSTRUCTIONS UNDER BODY CYLINDER (UM, UL)
Table of contents 1. Introduction... 3 1.1. Scope of use... 3 1.2. General remarks... 3 1.3. Contact Hyva... 3 1.4. Precautions... 4 1.5. Spare parts... 4 1.5.1. Prior to use... 4 1.6. Recycling and Reuse
More informationS KID S TEER L OADER SK818-5 SK818-5 SK 818-5. NET POWER SAE J1349 34,7 kw. OPERATING WEIGHT 2.910 kg. OPERATING CAPACITY 870 kg
SK 818-5 SK818-5 SK818-5 S KID S TEER L OADER NET POWER SAE J1349 34,7 kw OPERATING WEIGHT 2.910 kg OPERATING CAPACITY 870 kg S KID STEER L OADER PRESTAZIONI IN SICUREZZA Power, ease-of-use, and simplicity-of-operation
More informationPallet Jack. OWNER S MANUAL Model MH1230. Important Safety Instructions Assembly Instructions Parts and Hardware Identification
OWNER S MANUAL Model MH1230 Important Safety Instructions Assembly Instructions Parts and Hardware Identification Pallet Jack CAUTION: Read, understand and follow ALL instructions before using this product
More informationIntroduction... 2. Body Specifications... 3. Technical Data... 4. Body... 5. Interior Rear Seats... 6. Center Arm Rest... 7. Child Seat Restraint...
Table of Contents Subject Page Introduction.......................................... 2 Body Specifications.................................... 3 Technical Data........................................
More informationNATIONAL CERTIFICATE (VOCATIONAL)
NATIONAL CERTIFICATE (VOCATIONAL) SUBJECT GUIDELINES AUTOMOTIVE REPAIR AND MAINTENANCE NQF LEVEL 3 Implementation: January 2014 INTRODUCTION A. What is Automotive Repair and Maintenance Level 3 about?
More informationARTICULATED DUMP TRUCKS
ARTICULATED DUMP TRUCKS Image 1 DISCLAIMER The information provided in this guide merely aims to assist machinery importers meeting the Import Permit Conditions (Clean as New). Importers should note that
More informationMASTER CYLINDER. Section 2. Master Cylinder. Tandem Master Cylinder. Master Cylinder
MASTER CYLINDER Master Cylinder The master cylinder converts the motion of the brake pedal into hydraulic pressure. It consists of the reservoir tank, which contains the brake fluid; and the piston and
More informationFORD CREDIT EXTENDED SERVICE PLAN GENUINE PARTS
FORD CREDIT One of the many benefits of buying a Ford Certified Pre-Owned vehicle is flexible financing options from Ford Credit. Ask your Ford Dealer for the details on current offers. EXTENDED SERVICE
More informationCLASS III TRUCK PARTS Baker
CLASS III TRUCK PARTS Baker Identify replacement parts for Baker PAL, PAL-AR, PAL-WR 7.2 Instant Access to 250,000 Parts and Growing Baker PAL, PAL-AR, PAL-WR 1 000 774-1033 Toggle 26 000 757-1050 Tie
More informationLIFT N RACK PRO OPERATING & INSTALLATION GUIDE 5500 Lb. LIFT CAPACITY
LIFT N RACK PRO OPERATING & INSTALLATION GUIDE 5500 Lb. LIFT CAPACITY IMPORTANT: READ THIS MANUAL BEFORE IN-STALLING, OPERATING OR MAINTAINING YOUR LIFT. Chassis Liner Company Sales Office Toll Free: 800-242-2448
More informationMaintenance Service Operations
Maintenance Requirements miles x 1000 7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 All 2009 Models km x 1000 12 24 36 48 60 72 84 96 108 120 Engine PCV, inspect, clean nipple and hoses (5 cylinder engine VIN
More informationExtended Warranty Programme
Extended Warranty Programme 1 P a g e Extended Warranty Introduction Volkswagen Extended Warranty Programme is an extension of the New Vehicle Warranty offered by Volkswagen Group Sales India Private Limited
More informationFremont County School District No. One, Lander, Wyoming Common Core of Knowledge and Skills For Standards and Measures/Assessment
Level: CV.ATBR.1 Resources CV.ATBR.1.1 Students prepare and analyze CV.ATBR.1.1.1 Students will apply for a personal car personal financial information. loan via a mock-up project. Students effectively
More informationEXCAVATOR SAFETY TRAINING
EXCAVATOR SAFETY TRAINING INSPECTION CHECKLIST INSPECTION AREA INSPECTION RESULTS Sat. Unsat. N/A Comments Carrier & Car Body Rotation system Tracks Rollers Frame, welds, bolts Drive system Upper Structure
More information1/29/2008 DR50. Baja Motorsports Inc. P.O. Box 61150 Phoenix, AZ 85082 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 45
DR50 Toll Free: 888-863-2252 PART NUMBERS PRICES ARE SUBJECT TO CHANGE 1 of 45 CYLINDER & CYLINDER HEAD Part UPC Number Description Baja Description 1 DR50-001 842645074424 CYLINDER 1 1 2 DR50-002 842645074431
More informationUnit LT01 Carry Out Routine Lift Truck Maintenance
Unit LT01 Carry Out Routine Lift Truck Maintenance UNIT OVERVIEW This unit is about conducting routine maintenance, adjustment and replacement activities as part of the periodic servicing of Lift Trucks.
More information