PARTS MANUAL Tecumseh TC-6 Cycle Engine Parts Breakdown for use with General Hole Digger Form: PM999 Version. Do not discard this manual. Read and comprehend its contents. Keep it readily available for reference when performing any service related function. When ordering replacement parts, please supply the following information: model number, serial number and part number. For customer service assistance, telephone 8.5.5 or +57.5.55. Our Customer Service Department telefax number is 877..75 (DIGGER 5) or +57.5.55. There is no charge for customer service activities. Website: www.generalequip.com Email: general@generalequip.com Copyright 999, General Equipment Company
TECUMSEH TC, FORM PM999, VERSION., AUTHORIZATION: DVR, PAGE:
Reference A 6B 6C 9 9 69 77 78 79 89 9 9 9A 9B 9 9 9 5 77 78 8 87 87A 9 6 Applicable Replacement Parts Diagram Tecumseh TC-6 Series Engine for use with General Hole Digger Part 5 65888 788A 798 9 65986 5777 58 966 85A 75 56 58 5 59 658 65 68 5969 5969 65985 6588 6589 656 68 657 65 59 69 65858 6558 57B 5768A 57698A 577 577 65 65 779 657 577 5769A Description ENGINE HIGH SPEED (NO LOAD) RANGE: 58-6 RPM ENGINE IDLE SPEED RANGE: 9- RPM Cylinder (includes reference 9, 87 and 87A) Screw, Torx T-, /- UNC x /6 Long Crankcase (includes reference, and 69) Crankcase Cover Air Vane Screw, Torx T-8, #-8 UNC x 7/ Long Governor Spring Oil Seal Crankshaft Piston and Rod (includes reference ) Ring Set Cartridge Bearing O Ring Ball Bearing Oil Seal Screw, /- UNC x / Long Flywheel Key Flywheel Pawl Spring Starter Pawl Pawl Screw, #- UNC x /6 Long Belleville Washer Flywheel Nut Solid State Ignition (includes reference ) Spark Plug Cover Screw, Torx T-5, #- UNC x 5/6 Long Ground Wire Cylinder Head Gasket Resistor Spark Plug (CJ8Y) Carburetor Mounting Stud Lock Nut, #- UNC Carburetor Gasket Spacer Air Baffel (includes reference 8 and 87) Speed Control body Compression Spring Screw, Torx T-5, #8- UNF x Long Screw, Torx T-5, #8- UNF x Long Conduit Clip Screw, Torx T-5, #- UNC x / Long RPM Adjusting Lever O Ring Required Quantity N/A N/A TECUMSEH TC, FORM PM999, VERSION., AUTHORIZATION: DVR, PAGE:
Reference Part Description Required Quantity A 5 5A 5 57 58 6 6 7 75 77 9 9 97 98 6 7 7C 7Q 8 9 6 65955 6596 55 555 55 65867 55 6585 6599 57 9 6598 6A 5 76 6595 8 8 57659 665B 55 559 556 69 5969 9A Screw, #- UNF x 9/ Long Thread Insert Air Cleaner Filter Air Cleaner Filter Air Cleaner Filter Screw, #- UNC x / Long Blower Housing Base Screw, #8- UNF x -9/6 Long Stud Exhaust Gasket Muffler (includes reference 7 and 77) Screw, /- UNC x.9 Long Fuel Line Fuel Line Clamp Washer Lock Nut, #8- UNF Fuel tank (includes reference 9, 9, 98 and 7C Fuel Cap Blower Housing Plug Toggle Switch Decal (TC II) Choke Decal Emissions Decal Carburetor (includes reference 8) Rewind Starter and Housing Assembly Spark Arrestor Kit TECUMSEH TC, FORM PM999, VERSION., AUTHORIZATION: DVR, PAGE:
TECUMSEH TC, FORM PM999, VERSION., AUTHORIZATION: DVR, PAGE:
Applicable Replacement Parts Diagram Tecumseh TC-6 Engine Recoil Starter for use with General Hole Digger Reference Part Description Required Quantity 5 6 8 9 5969 65987 65985 657 5969 5969 5969 5956 5969 597 Rewind Starter and Housing Assembly Retainer Screw, #- UNC x -/8 Long Pawl Screw, #- UNC x /6 Long Washer Pawl Spring Pawl Pulley Rewind Spring Starter Rope (# Rope, 7 Long) Starter Handle TECUMSEH TC, FORM PM999, VERSION., AUTHORIZATION: DVR, PAGE: 5
TECUMSEH TC, FORM PM999, VERSION., AUTHORIZATION: DVR, PAGE: 6
Applicable Replacement Parts Diagram Carburetor Manufactured by Tecumseh for use with Tecumseh TC-6 Engine on General Hole Digger Reference A B 5 6 7 7 7 8 5 8 5 5 5 5 6 6 6 6 6 65 68 69 7 Part 69 697 698 696 695 699 699A 699A 69 69 696 698 69 696 695 698 69 697 699 69 69 69 695 696 69 699 698 697 6988 695 696 697 69 Description Carburetor (Includes Reference 8 of Engine Replacement Parts Diagram) Throttle Shaft and Lever Assembly Throttle Return Spring Dust Seal Retainer Dust Seal Retainer Screw Spacer Dust Seal Washer Dust Seal Throttle Shutter Throttle Shutter Screw Idle Speed Screw Idle Mixture Screw Idle Tension Spring Hinge Pin Metering Lever Inlet Needle Metering Lever Stop Metering Lever Pin Screw Fuel Inlet Screen Welch Plug Diaphram (Included in Reference 6 and 7) Cover Gasket (Included in Reference 6 and 7) Cover Cover Screw Repair Kit (Includes Reference 8,, 5, 8, 5, 5, 6 and 6) Module Clamp Screw Pump Diaphram (Included in Reference 6 and 7) Pump Gasket (Included in Reference 6 and 7) Pump Cover Pump Cover Screw Adjustment Limiter module Adjustment Limiter Cap Diaphram/Gasket Set (Includes Reference 5, 5, 6, and 6) NOTE: DETERMINE THE MANUFACTURER OF THE CARBURETOR (TILLOSTSON OR TECUMSEH) BEFORE ORDERING REPLACEMENT PARTS. IF IT IS MANUFACTURED BY TILLOSTSON, IT WILL BE MARKED TILLOTSON. IF IT IS MANUFACTURED BY TECUMSEH, IT WILL NOT BE MARKED. Required Quantity TECUMSEH TC, FORM PM999, VERSION., AUTHORIZATION: DVR, PAGE: 7
TECUMSEH TC, FORM PM999, VERSION., AUTHORIZATION: DVR, PAGE: 8
Applicable Replacement Parts Diagram Carburetor Manufactured by Tecumseh (no markings) for use with Tecumseh TC-6 Engine on General Hole Digger Reference B 5 6 7 7 7 8 A 5 5 5 5 6 6 6 6 65 7 Part 6 6 6 6 66 67 68 69 65 6 6 6 6 6 65 66 67 68 69 65 65 656 65 65 655 65 657 Description Carburetor (Includes Reference 8 of Engine Replacement Parts Diagram) Throttle Shaft and Lever Assembly Throttle Return Spring Dust Seal Retainer Spacer Dust Seal Washer Dust Seal Throttle Shutter Screw, Throttle Shutter and Dust Seal Retainer Idle Speed Screw Hinge Pin Metering Lever Spring Inlet Needle Metering Lever Spring Screw, Metering Lever Pin High Speed Jet High Speed Jet Sealer Cap Diaphram (Included in Reference 7) Cover Gasket (Included in Reference 7) Cover Cover Screw Repair Kit (Includes Reference 8, and 7) Pump Diaphram (Included in Reference 7) Pump Gasket (Included in Reference 7) Pump Cover Pump Cover Screw Gasket Set (Includes Reference 5, 5, 6, and 6) NOTE: DETERMINE THE MANUFACTURER OF THE CARBURETOR (TILLOSTSON OR TECUMSEH) BEFORE ORDERING REPLACEMENT PARTS. IF IT IS MANUFACTURED BY TILLOSTSON, IT WILL BE MARKED TILLOTSON. IF IT IS MANUFACTURED BY TECUMSEH, IT WILL NOT BE MARKED. Required Quantity TECUMSEH TC, FORM PM999, VERSION., AUTHORIZATION: DVR, PAGE: 9