INSURANCE MANUAL FOR: The New Jersey Turnpike Authority (OCIP) OCIP Insurance Manual This OCIP Manual is a Contract Document as defined in the Authority s 2004 Standard Specifications, and is fully incorporated into the Contract Documents as if fully set forth therein. In the event of a discrepancy between the terms of the other documents which comprise the Contract Documents, the terms of the other documents shall take precedence.
Table of Contents SECTION 1 - INTRODUCTION...2 Overview...2 About This Manual...3 SECTION 2 PROJECT DIRECTORY...4 SECTION 3 PROJECT DEFINITIONS...5 SECTION 4 OCIP INSURANCE COVERAGE...11 Covered Parties...11 Excluded Parties...11 Evidence of Coverage...11 Description of OCIP Coverage...12 OCIP Termination or Modification...14 SECTION 5 REQUIRED COVERAGE FOR ENROLLEES...15 Coverage and Limits...15 Off-Site Certificate of Insurance (OSC) Requirements...19 SECTION 6 REQUIRED COVERAGE FOR EXCLUDED PARTIES...21 Coverage and Limits...21 Certificate of Insurance (COI) Requirements...22 SECTION 7 ENROLLEE RESPONSIBILITIES...23 General Information...23 OCIP Enrollment...24 Payroll Reports...25 Audit...25 Change Orders...26 Completion of Work...26 SECTION 8 - CLAIM PROCEDURES...27 SECTION 9 - SAFETY PROCEDURES...36 SECTION 10 - OCIP ADMINISTRATION CONTACTS...37
Section 1 - Introduction Overview Welcome to The New Jersey Turnpike Authority s Rolling O w ner Controlled Insurance Program. The New Jersey Turnpike Authority (the Authority ) has arranged insurance for the The New Jersey Turnpike Authority Rolling OCIP (hereafter referred to as OCIP ). An OCIP is a single insurance program that insures Contractors, Subcontractors, Consultants and Subconsultants and other designated parties, hereinafter Enrollee(s), for Work, as defined in the Contract Documents and herein, or Services, as defined in a Consultant s OPS, performed at the Project Site and designated off site exposures (if any). Certain parties may be ineligible for this program and will be excluded from the OCIP. These parties are identified in Section 3 of this OCIP Manual, and in the contract between the Authority and its Contractor or Consultant. Coverage under the OCIP includes Workers Compensation & Employer s Liability, General Liability, Excess Liability, Contractor s Pollution Liability and other insurance as applicable. Refer to Section 4 of this OCIP Manual for complete details of the OCIP Coverage for the project you are working on. While the OCIP is intended to provide broad coverage and high limits, the OCIP is not intended to meet all the insurance needs of Enrollees. In addition to any insurance provided by the Authority, all Enrollees and Excluded Parties will be responsible for providing certain insurance as specified in Sections 5 and 6 of this OCIP Manual. We recommend that Enrollees discuss this OCIP with their insurance agent or insurance consultant to assure that all essential and/or specialized coverage are maintained. Disclaimer: The information in this OCIP Manual is intended to outline the OCIP. If any conflict exists between this Manual and the OCIP insurance policies or contracts between the Authority and Enrollees, the insurance policies will govern first, then the Contract Documents, then this Manual. -Edition No. 5 dated 01-22-2013 Page 2 of 37
Section 1 - Introduction (cont.) About This Manual This Manual is designed to identify, define and assign responsibilities for the administration of the Authority s OCIP. What This Manual Does This Manual: Generally describes the OCIP Identifies responsibilities of the various parties involved in the various projects covered by the OCIP Provides a basic description of the OCIP coverage Describes audit and administrative procedures Provides answers to basic questions about the OCIP May be updated during the course of construction to reflect any changes in State rules and/or regulations or procedures that may be necessary, and said revised and said revisions will replace all previous versions. Copies of any revised Manual will be distributed electronically by the OCIP Administrator What This Manual Does Not Do This Manual does not: Provide coverage interpretation Provide complete information about coverage Provide answers to specific claims questions Specific questions about the OCIP, its administration or the coverage provided should be referred to the appropriate party identified in the Project Directory section immediately following this introduction. NO ENROLLEE HAS THE AUTHORITY TO CHANGE, AMEND OR WAIVE OCIP PROCEDURES OR REQUIREMENTS. ALL CHANGES MUST BE APPROVED BY THE AUTHORITY AND OCIP ADMINISTRATOR. -Edition No. 5 dated 01-22-2013 Page 3 of 37
Section 2 Project Directory The following outlines the OCIP team involved in this project. OCIP SPONSOR The New Jersey Turnpike Authority, (the Authority ) OCIP ADMINISTRATORS OCIP Administrator: Aon Risk Services Northeast, Inc. (formerly known as Project Technologies International/Allied North America) See Section 10 for full listing of contacts OCIP INSURANCE CARRIER - PRIMARY Refer to Section 4 OCIP INSURANCE CARRIER - EXCESS Refer to Section 4 ADDITIONAL INSURANCE COVERAGE Refer to Section 4 -Edition No. 5 dated 01-22-2013 Page 4 of 37
Section 3 Project Definitions The following definitions apply to this project and to the descriptions of the OCIP used in this OCIP Manual. Audit Reconciliation of estimated payrolls to reported payrolls. Audited Payroll The total amount of payroll expended and reported by the Enrollees for the contract and verified by an Insurance Company auditor at the sole discretion of the Authority or Insurance Company. Change Order (CO) As defined in the Contract Documents, a written order to the Contractor, signed by the Chief Engineer, ordering a change in the work from that shown by the original Plans and Specifications. Composite Rating Composite rate is the calculation of the basic rates, increased factors, credits and surcharges into a combined rate. Consultant Consultant shall mean any entity that has entered into an Order for Professional Services with the Authority to provide engineering, architectural, construction management, space planning, technical consultant, scientist or land surveying professional services to the Authority in connection with the OCIP. Contract As to this OCIP Manual, a Contract is a written agreement between: 1) The Authority and a Consultant to provide Services related to an OCIP project; or 2) The Authority and a Contractor to provide construction Work for a project covered by an OCIP. Contract Documents With respect to Contractors, Contract Documents includes, without limitation: Advertisement for Proposal, Proposal Guaranty, Contract Agreement, Contract Bond, Power of Execution, Standard Specifications, Supplemental Specifications, Special Provisions, Plans, Addenda, or other information mailed or otherwise transmitted to the prospective bidders prior to the receipt of bids, Change Orders, Field Orders, and Supplementary Agreements, all of which are to be treated as one instrument whether or not set forth at length in the written Contract Agreement. -Edition No. 5 dated 01-22-2013 Page 5 of 37
Section 3 Project Definitions (cont.) For a fuller definition of Contract Documents please refer to the Authority s 2004 Standard Specifications. With respect to Consultants, Contract Documents shall include the Order for Professional Services entered into between the Authority and the Consultant, and any documents incorporated therein. Contractor Shall mean any entity undertaking the execution of the Work, as defined in the Contract Documents, including General Contractors, Construction Managers, Consultant, Design Builder or Subcontractor of Any Tier. Enrollee Includes Contractor, Subcontractor, Consultants and Subconsultants of any tier providing direct services or labor or subcontracting services for the Project, as defined in the contract between the parties, who have submitted all necessary enrollment forms and have been accepted into the OCIP as evidenced by a Certificate of Insurance. Temporary labor services and leasing companies are to be treated as Eligible Enrollees. Enrollment Form Form to be completed by each Enrollee containing mandatory information required to enroll in the OCIP. Estimated Payroll The total amount of payroll, for each applicable trade classification estimated to perform work at the Project Site that was used to calculate the Initial Estimated OCIP Insurance Deduct Excluded Parties Applies to contractors, subcontractors, and other individuals who are hazardous materials removal and/or transport companies, vendors, suppliers, fabricators, material dealers, drivers, or others whose function is solely to supply materials, personnel parts or equipment to and from the Site, and who do not provide or subcontract labor. This includes but is not limited to vendors, suppliers, off-site fabricators, material dealers, drivers, truckers and crane owner/operators whose onsite employees are engaged solely in the delivery, loading, hauling, and/or unloading of material to or from the Site. Contractors and Subcontractors not working at the Project Site (such as deliverymen, truckers, -Edition No. 5 dated 01-22-2013 Page 6 of 37
Section 3 Project Definitions (cont.) haulers, etc.) and others who occasionally work/visit the Site are also excluded. Determination of who is an Excluded Contractor shall be made by the Authority in consultation with the Contractor and the Insurance Broker. Notwithstanding any apparent limits to the definition of "Excluded Parties" described above, the Authority reserves the right, in its sole discretion to remove or exclude (after first being included) any Contractor or Subcontractor from the OCIP, notwithstanding such party s apparent eligibility for same. "Excluded Parties" shall not be included under the OCIP. All Excluded Parties as defined in this Paragraph are required to provide evidence of their own insurance to the Authority before access to the Site is allowed. The specific requirements are detailed in below. Excluded Parties may also be referred to as Excluded Contractors elsewhere in the Contract Documents. Although enrollment in the OCIP is required, it is not automatic and the Authority may elect to exclude an entity from the OCIP. Experience Modification Rating Factor Also known as EMR or Exp Mod factor that is applied to each Contractor s Workers Compensation Policy which is based on that Contractor s own payroll and loss experience. Incident Any incident that takes place at the Project Site whether medical attention is sought or not. Ineligible Parties Refer to Excluded Parties and/or Excluded Contractors. Insurer/Insurance Company/Insurance Carrier The insurance companies named on a policy or certificate of insurance that provide coverage for the OCIP. Notice of Work Completion Form Form that Enrollees must complete and submit to the OCIP Administrator upon completion of Enrollee s Work on the Project Site. OCIP A coordinated insurance program providing certain insurance coverage as generally described in this Manual for Enrollees performing Work at the Project Site. -Edition No. 5 dated 01-22-2013 Page 7 of 37
Section 3 Project Definitions (cont.) OCIP Administrator Firm appointed by the Authority to administer the OCIP Aon Risk Services Northeast, Inc. OCIP Coverage Insurance coverage provided by the OCIP. Off-Site Generally refers to operations outside the defined Project Site, such as at a fabrication facility. Off-Site Certificate of Insurance (OSC) Insurance Certificate setting forth the required coverage maintained by Enrollees beyond the OCIP coverage. Payroll/Net Rate The amount calculated by dividing the Estimated OCIP Insurance Credit by the Total Estimated Payroll for each Enrollee. Project Name New Jersey Turnpike Authority Rolling OCIP Project Site The Project Site designated by the Authority and on file with the insurance company. The Project Site includes those activities at or emanating from contiguous areas, storage areas, work sites, temporary construction yards, staging areas, and/or any dedicated location or area in which Work, services or storage related to the Project is conducted. The OCIP does not provide insurance coverage for permanent yards or other locations of any Enrollee, except as specifically requested by an Enrollee, approved by the Authority and OCIP Administrator and added to the policies by the Insurance Carrier(s). Reported Payroll Payroll reported by Enrollees to the OCIP Administrator for Work expended on the Project Site. -Edition No. 5 dated 01-22-2013 Page 8 of 37
Section 3 Project Definitions (cont.) Safety Representative A. Safety Representative (SR) A SR is an employee of the Contractor. The SR is required to have at least 5 years heavy construction experience in the type of work of the contract with at least 2 years in a supervisory capacity. The SR shall have completed a 30 hour OSHA Construction Safety and Health course. Duties of the SR include, but are not limited to: a. Primary role is contract safety. b. Is key contact person for all safety-related issues for the Contractor. c. Person must be reachable 24 hours a day. d. Responsible for designating a Competent Person for each work operation for each shift. e. Ensure an alternate SR is designated for time when primary SR is unavailable vacation, sick, etc. f. Shall be familiar with the work being performed, shall be competent to instruct others, and shall be familiar with HASP. g. Safety Representative shall have the authority to order the work to be stopped in the affected area if an unsafe condition is identified. The SR shall appoint a Competent Person (CP). A CP shall be an employee or designee of the Contractor. The CP is required to have at least 3 years heavy construction experience and at least 1 year in a supervisory capacity in the designated work operation to which they are assigned. CP shall be given the authority to assure corrective action is accomplished. The CP shall have completed a 30 hour OSHA Construction Safety and Health course. Duties of the Competent Person include, but are not limited to: a. A Competent Person shall be familiar with the work being performed. b. A Competent Person shall be competent to instruct others. c. A Competent Person shall be familiar with the HASP. d. A Competent Person shall have the authority to order the work to be stopped in the affected area if an unsafe condition is identified. Subcontractor Includes only those persons, entities or other parties that enter into a contract with an Authority Contractor or Consultant or Subcontractor or Subconsultant of any tier to perform work at the Project Site. Temporary Labor Services and Leasing Companies are included as Subcontractors. -Edition No. 5 dated 01-22-2013 Page 9 of 37
Section 3 Project Definitions (cont.) Subcontractor of Any Tier Subcontractors and lower tier subcontractors engaged to perform Work at the Project Site. This term shall include Subconsultants also. Work With respect to Contractors, as defined in the Contract Documents, the furnishing of all labor, services, materials, equipment, tools, transportation, supplies, and other incidentals necessary or convenient for the successful completion by the Contractor of the construction described in the Contract Documents, and the carrying out of all duties and obligations imposed by the Contract Documents on the Contractor. Work is usually performed at or emanating directly from the Project Site. With respect to Consultants, the Work may primarily consist of services provided pursuant to an Order for Professional Services. -Edition No. 5 dated 01-22-2013 Page 10 of 37
Section 4 OCIP Insurance Coverage This section provides a brief description of OCIP Coverage. You should refer to the actual OCIP policies for details concerning coverage, exclusions and limitations. Covered Parties Parties covered as Named Insureds include the Authority and Enrollees. Parties included as Additional Insureds are those designated by the Authority, and any other party the Authority is required under Contract to add as an Additional Insured. Excluded Parties Excluded Parties are not granted any insurance coverage under the OCIP. Excluded Parties as defined in Section 3 of this Manual must meet the insurance requirements outlined in Section 6 and provide evidence of coverage to the Authority and the OCIP Administrator. Evidence of Coverage Upon compliance with all requirements of the OCIP, the OCIP Administrator will provide a Certificate of Insurance evidencing Workers Compensation, General Liability and Excess Liability to Enrollees, each of whom will be a Named Insured on the policies. Enrollees will be issued an individual workers compensation policy. Other documentation including forms, posting notices, etc., may also be furnished. Contractors Pollution Liability and Builders Risk (where applicable) policies will be furnished to Enrollees upon written request to the Authority. If an Enrollee needs to return to the Project Site after the OCIP has expired, it will be required to procure and maintain insurance coverage as outlined in Section 6 of this OCIP Manual under EXCLUDED PARTIES. -Edition No. 5 dated 01-22-2013 Page 11 of 37
Section 4 - OCIP Insurance Coverage (cont.) Description of OCIP Coverage The following section is for information purposes only and describes the policies the Authority has arranged for the OCIP project(s). The OCIP does not provide coverage for Automobile Liability, Equipment Floaters, or Performance Bonds. The Authority will pay insurance premiums including deductibles or self-insured retention unless otherwise stated in the Contract Documents for the OCIP coverage described in this Manual. Insurance Carrier: Workers Compensation and Employer s Liability, including Longshore and Harbor Workers Act Coverage Insurance Company of the State of Pennsylvania Effective Date: July 15, 2009 Limits: Part 1: Workers Compensation - Statutory Part 2: Employer s Liability $1,000,000 Bodily Injury by Accident, each Accident $1,000,000 Bodily Injury by Disease, each employee $1,000,000 Bodily Injury by Disease, policy limit Statutory coverage required by the Workers Compensation laws of the applicable jurisdiction (excluding monopolistic states) with Employers Liability Enrollees will be issued a separate Workers Compensation policy -Edition No. 5 dated 01-22-2013 Page 12 of 37
Section 4 - OCIP Insurance Coverage (cont.) Insurance Carrier: Commercial General Liability Insurance Company of the State of Pennsylvania Effective Date: July 15, 2009 Limits: $4,000,000 General Annual Aggregate $4,000,000 Products/Completed Operations Aggregate $2,000,000 Personal/Advertising Injury $2,000,000 Each Occurrence $100,000 Fire Damage Legal Liability (any one fire) $5,000 Medical Expense Limit (any one person) Third Party Bodily Injury and Property Damage Limit of Liability - per project A single General Liability policy will be issued for the Authority Products Liability and Completed Operations has been extended for ten (10) years or the Statute of Repose, whichever is less. Insurance Carrier: Excess Liability See Below Effective Date: July 15, 2009 Limits: $100,000,000 Annual General Annual Aggregate $100,000,000 Each Occurrence $100,000,000 Products/Completed Operations Aggregate $25M Limit National Union Fire Insurance $75M xs $25M Limit Aspen/XL. Limit of Liability per project -Edition No. 5 dated 01-22-2013 Page 13 of 37
Section 4 - OCIP Insurance Coverage (cont.) Insurance Carrier Contractor s Pollution Legal Liability Insurance Liberty Insurance Effective Date: July 15, 2009 Limits: $25,000,000 per incident/aggregate Limits: Builders Risk - when included in contract $20,000,000 Each Occurrence /Aggregate Railroad Protective Liability where required If work is to be performed on, over, beneath or within 50 feet of the properties of a railroad, the Authority will provide Railroad Protective Liability Policy as set forth in the Contract Documents. Owners and Contractors Protective where required The Authority will provide Owners and Contractors Protective Policy as set forth in the Contract Documents. OCIP Termination or Modification The Authority reserves the right to terminate or modify the OCIP or any portion thereof. If the Authority exercises this right, Enrollees will be provided notice as required by the terms of the Contract Documents. At its option, the Authority may procure alternate coverage or may require Enrollees to procure and maintain appropriate replacement insurance coverage acceptable to the Authority upon 45 day advance written notice per the Contract Documents. -Edition No. 5 dated 01-22-2013 Page 14 of 37
Section 5 Required Coverage for Enrollees Coverage and Limits Enrollees are required to maintain insurance coverage for the Authority s OCIP from liabilities arising from the Enrollees operations performed away from the Project Site, for types of coverage not provided by the OCIP, and for operations performed in connection with the OCIP by Excluded Parties. Verification of insurance may be submitted in the form of a Certificate of Insurance on a standard ACORD Form 25-S. A sample of an acceptable Certificate of Insurance is available on the OCIP Administrator s website. Requirements include thirty (30) days notice of cancellation, waiver of subrogation, primary and non-contributory and additional insured status. The Authority reserves the right to disapprove enrollment of Enrollees unable to meet the insurance requirements. Certificates evidencing compliance shall be submitted to the OCIP Administrator. A valid Certificate of Insurance must be on file at all times until your Contract is complete or until your Contract is accepted by the Authority s Commissioners, as the case may be. Prior to mobilization and within ten (10) days of any renewal, change or replacement of coverage, Enrollees shall submit to the OCIP Administrator a Certificate of Insurance evidencing the coverage and limits as specified in this section. The Certificate shall evidence a 30-day notice of cancellation provision. The limits of liability shown for the insurance required of the Enrollee are minimum limits only and are not intended to restrict the liability imposed on the Enrollee for Work performed under their Contract. In addition to insurance coverage provided under the OCIP, Enrollees shall maintain and require each of its enrolled Subcontractors/Subconsultants of any tier to maintain the insurance coverage specified below. Such insurance shall be from insurance companies licensed in the State of New Jersey and carry at least an A-7 rating by A.M. Best. -Edition No. 5 dated 01-22-2013 Page 15 of 37
Section 5 Required Coverage for Enrollees (cont.) Limits: Automobile Liability $2,000,000 Combined Single Limit (BI/PD) THIS OCIP DOES NOT COVER AUTOMOBILE LIABILITY Enrollees must provide evidence of Automobile Liability covering all owned, leased, hired and non-owned automobiles, trucks and trailers with coverage not less than that of the Commercial Business Auto Policy. Coverage shall apply both On-Site and away from the Project Site. Limits can be provided by a combination of an automobile liability policy and an excess or umbrella liability policy and shall not be less than shown above. Limits: Commercial General Liability $2,000,000 General Annual Aggregate $2,000,000 Products/Completed Operations Aggregate $2,000,000 Personal/Advertising Injury $2,000,000 Each Occurrence $100,000 Fire Damage Legal Liability (any one fire) $5,000 Medical Expense Limit (any one person) For operations AWAY FROM THE PROJECT SITE and which are not otherwise specifically covered by the OCIP, in a form providing coverage not otherwise less than the standard ISO Commercial General Liability (Occurrence) Policy form. Limits can be provided by a combination of a primary general liability policy and an excess or umbrella liability policy and shall not be less than shown above. -Edition No. 5 dated 01-22-2013 Page 16 of 37
Section 5 Required Coverage for Enrollees (cont.) Limits: Workers Compensation and Employer s Liability Part 1: Workers Compensation - Statutory Part 2: Employer s Liability $1,000,000 Bodily Injury by Accident, each Accident $1,000,000 Bodily Injury by Disease, each employee $1,000,000 Bodily Injury by Disease, policy limit To the extent where required by law, statutory workers compensation including occupational disease and employers liability insurance for operations AWAY FROM THE PROJECT SITE and which are not otherwise specifically covered by the OCIP, with statutory limits as required in the state(s) where the Enrollee is performing such operations. Limits: Umbrella Liability $3,000,000 Annual General Annual Aggregate $3,000,000 Each Occurrence $3,000,000 Products/Completed Operations Aggregate For operations AWAY FROM THE PROJECT SITE and which are not otherwise specifically covered by the OCIP, in a form providing coverage not otherwise less than the standard ISO Commercial General Liability (Occurrence) Policy form. Limits: Professional Liability Architects and Engineers Errors and Omissions Insurance as applicable $2,000,000 $2,000,000 Each Occurrence Aggregate Effective 01-01-2013, Consultants, Sub Consultants and any firm engaged by the prime consultant, shall maintain the limit of $2,000,000. The limit of liability is to be renewed annually for the duration of the project and for a period of three (3) years following the termination of the OPS. There are no exceptions to this requirement. -Edition No. 5 dated 01-22-2013 Page 17 of 37
Section 5 Required Coverage for Enrollees (cont.) Limits: Environmental Liability Transportation of Hazardous waste/material $5,000,000 Enrollees whose work involves transportation of hazardous waste/ material from the Project Site will maintain Environmental Liability insurance with an endorsement for transporting hazardous material by auto. This policy shall name the Authority, its commissioners, officers, employees and agents as additional insureds MCS-90 Endorsement must be attached to the policy and supplied on a primary basis. Tools & Equipment at discretion of enrollee At their discretion, Enrollees shall secure, pay for, and maintain Property Insurance necessary for protection against loss of owned, borrowed, or rented capital equipment and tools, including any tools owned by employees, and any tools, equipment, staging, towers, and forms owned, borrowed or rented by the Enrollee. The requirement to secure and maintain such insurance is solely for the benefit of the Enrollee. Failure of the Enrollee to secure such insurance or to maintain adequate levels of coverage shall not obligate the Authority or their agents and employees for any losses, and their agents and employees shall have no such liability. The property insurance shall include a Waiver of Subrogation in favor of all parties required to be named as additional insureds under the Contract Documents. -Edition No. 5 dated 01-22-2013 Page 18 of 37
Section 5 Required Coverage for Enrollees (cont.) Limits: Marine Protection and Indemnity Insurance where applicable $5,000,000 Per Occurrence $10,000,000 Aggregate Where applicable, as respects any watercraft (Boats, Barges, etc.) used during the performance of this contract, Enrollees shall provide Marine Protection and Indemnity Insurance covering all marine hazards arising from this contract; including injuries to crew members, if not provided through other insurance; Bodily Injury to third parties and Property Damage to wharves, piers and other structures and loss or damage to other vessels not caused by collision. If the policy is subject to an aggregate limit, replacement insurance will be required if it is likely such aggregate will be exceeded. Limits: Aircraft Liability Insurance where applicable $10,000,000 Per Occurrence If the Enrollee is engaged in any operations utilizing aircraft, it shall maintain aircraft liability insurance written on an occurrence basis. This policy shall name the Authority, its commissioners, officers, employees and agents as additional insureds. Off-Site Certificate of Insurance (OSC) Requirements The Certificate of Insurance must evidence the following: (1) The Automobile Liability, General Liability (ISO Form CG 20 10 11/85 or its equivalent) and Umbrella/Excess Liability shall name the following entities as Additional Insureds: The New Jersey Turnpike Authority, its commissioners, officers, employees and agents (to the extent applicable) and any other entity as required by agreement. (2) Workers Compensation, General Liability, Automobile Liability and Umbrella/Excess Liability shall provide a Waiver of Subrogation in favor of all entities listed above and any others required by contract. Coverage will be primary and non-contributory. -Edition No. 5 dated 01-22-2013 Page 19 of 37
Section 6 Required Coverage for Excluded Parties Coverage and Limits Excluded Parties shall maintain and require each of its Enrolled Subcontractors/Subconsultants to maintain the insurance coverage specified below. Such insurance shall be in a form and from insurance companies licensed in the State where the project is located and carry at least an A-7 rating by A.M. Best s. Limits: Automobile Liability $2,000,000 Combined Single Limit (BI/PD) Covering all owned, leased, hired and non-owned automobiles, trucks and trailers with coverage not less than that of the Commercial Business Auto Policy. Limits can be provided by a combination of an automobile liability policy and umbrella liability policy. Limits: Commercial General Liability $2,000,000 General Annual Aggregate $2,000,000 Products/Completed Operations Aggregate $2,000,000 Personal/Advertising Injury $2,000,000 Each Occurrence $100,000 Fire Damage Legal Liability (any one fire) $5,000 Medical Expense Limit (any one person) Coverage should include a Combined Single Limit for Bodily Injury, Personal Injury and Property Damage. Limits can be provided by a combination of a primary general liability policy and umbrella liability policy. The terms and conditions of coverage shall be provided through the use of ISO Commercial General Liability (Occurrence) Policy form CG 00 01 10/01 or its equivalent and shall encompass at least the following: o Independent contractors o Blanket written contractual liability covering all indemnity agreements Products Liability and Completed Operations, with the provision that coverage shall extend for a period of at least 3 Years from project completion or for any longer period if required elsewhere in the Contract Documents (such longer period shall take precedence). -Edition No. 5 dated 01-22-2013 Page 20 of 37
Section 6 Required Coverage for Excluded Parties (cont.) Limits: Workers Compensation and Employer s Liability Part 1: Workers Compensation - Statutory Part 2: Employer s Liability $1,000,000 Bodily Injury by Accident, each Accident $1,000,000 Bodily Injury by Disease, each employee $1,000,000 Bodily Injury by Disease, policy limit Workers compensation (including occupational disease) in accordance with the laws of the state in which the work is being performed, including All Other States Longshore and Harbor Workers Act Coverage, where applicable Limits: Umbrella Liability $3,000,000 Annual General Annual Aggregate $3,000,000 Each Occurrence $3,000,000 Products/Completed Operations Aggregate Limits: Environmental Liability where applicable $5,000,000 Enrollees whose work involves transportation of hazardous waste/ materials from the project site will maintain Environmental Liability insurance with an endorsement for transporting hazardous material by auto. This policy shall name the Authority, its commissioners, officers, employees and agents as additional insureds. MCS-90 Endorsement must be attached to the policy and supplied on a primary basis. -Edition No. 5 dated 01-22-2013 Page 21 of 37
Section 6 Required Coverage for Excluded Parties (cont.) Tools & Equipment at discretion of contractor At its own discretion an Excluded Party shall maintain Property Insurance as necessary for protection against loss of owned, borrowed, or rented capital equipment and tools, including any tools owned by employees, and any tools, equipment, staging, towers, and forms owned, borrowed or rented by the subcontractor. The requirement to secure and maintain such insurance is solely for the benefit of the Enrollee. Failure of the Enrollee to secure such insurance or to maintain adequate levels of coverage shall not obligate the Authority or their agents and employees for any losses, and their agents and employees shall have no such liability. The property insurance shall include a Waiver of Subrogation in favor of all parties required to be named as additional insureds under the Contract Documents Certificate of Insurance (COI) Requirements The Certificate of Insurance must evidence the following: (1) The Automobile Liability, General Liability (ISO Form CG 20 10 11/85 or its equivalent) and Umbrella/Excess Liability shall name the following entities as Additional Insureds: The New Jersey Turnpike Authority, its commissioners, officers, employees and agents (to the extent applicable) and any other entity as required by agreement. All policies to be primary and non-contributory as respects coverage afforded the Additional Insureds. (2) Workers Compensation, General Liability, Automobile Liability and Umbrella/Excess Liability shall provide a Waiver of Subrogation in favor of all entities listed above and any others required by contract. (3) Certificate must provide thirty (30) days written notice prior to cancellation, non-renewal or material modification in any policy and must be submitted and approved prior to commencement of work. -Edition No. 5 dated 01-22-2013 Page 22 of 37
General Information THE NEW JERSEY TURNPIKE AUTHORITY Section 7 Enrollee Responsibilities Throughout the course of these OCIP Project(s), Enrollees will be responsible for reporting and maintenance of certain records as outlined in this section. Failure of Enrollees to comply may result in progress payments being withheld. Participation in the OCIP is mandatory but not automatic. Enrollees of any tier who are found working on the Project Site prior to enrollment in the OCIP will be required to provide a No Known Loss Letter on their letterhead, to the Authority, OCIP Administrator and the OCIP Insurance Carrier along with the enrollment documentation. If a loss occurs prior to enrollment, the loss may not be covered under the OCIP. The Authority retains the sole discretion to determine whether to accept any Enrollee in the OCIP. Enrollees are required to cooperate with the Authority, OCIP Administrator and the OCIP Insurance Carriers with all aspects of the OCIP operation and administration. Responsibilities of the Enrollees include but are not limited to the following: Endeavor to provide a Drug-Free Workplace; Endeavor to provide a Temporary Alternate Work/Return to Work Program for all Employees; Identify the insurance cost removed from initial bids and change orders; Enroll in the OCIP; Upon request, provide a copy of rating pages from insurance policies to verify insurance costs to be removed; Include OCIP provisions in all subcontracts as appropriate; Provide timely evidence of insurance to the OCIP Administrator; Notify the OCIP Administrator of all subcontracts awarded; Maintain and report monthly payroll records; Cooperate with the OCIP Administrator requests for information; Comply with insurance, claim and safety procedures; Notify the OCIP Administrator immediately of any insurance cancellation or non renewal (contractor-required insurance); and Report all incidents immediately as referenced in Section 8 of this OCIP Manual. -Edition No. 5 dated 01-22-2013 Page 23 of 37
OCIP Enrollment THE NEW JERSEY TURNPIKE AUTHORITY Section 7 Enrollee Responsibilities (cont.) If you are a Contractor awarded a Contract, or a Consultant who has entered into and OPS with the Authority: 1. You will be required to complete an OCIP Enrollment Form to request enrollment in the OCIP. A separate OCIP Enrollment Form is required for each Contract under which you are performing Work; however, only one Workers Compensation policy will be issued for your firm. 2. You will exclude the cost of insurance in your bid and identify the cost for all insurance coverage to be provided by the Authority for Work at the Project Site on the Enrollment Form. Upon request, Enrollees must furnish copies of the declaration page, rating sheets, deductible or self insured retention endorsements from their primary Workers Compensation and General Liability policies 3. You will be required to provide a Certificate of Insurance evidencing coverage as outlined in sections 5 and 6 of this OCIP Manual. It is each Enrollee s responsibility to make sure all approved Subcontractors of Any Tier comply with these requirements. 4. When a portion of Work at the Project Site under your Contract is subcontracted to a Subcontractor/Subconsultant, you or your subcontractor/subconsultant must complete and submit a Notice of Subcontract Award to the Authority and the OCIP Administrator prior to mobilization.. 5. You will be provided with a certificate of WC and GL insurance evidencing your participation in the OCIP. This certificate should be provided to your regular insurance carrier so that payroll allocated and reported through this OCIP is not charged to your regular insurance as well. Policies evidencing other insurance provided by the OCIP will be provided upon request. Payroll allocated to this project should be kept separate so that it can be excluded from your regular insurance. 6. Access to the Project Site WILL NOT BE PERMITTED without a completed OCIP Enrollment Form and approved Off-Site Certificate of Insurance. -Edition No. 5 dated 01-22-2013 Page 24 of 37
Section 7 Enrollee Responsibilities (cont.) Assignment of Return Premiums The Authority will pay the insurance premiums for the OCIP and will be the sole recipient of any return OCIP premiums or dividends. All Enrollees shall assign to the Authority all adjustments, refunds, premium discounts, dividends, credits or any other monies due from the OCIP insurers. Payroll Reports Enrollees must submit monthly payroll reports via the OCIP Administrator website. Identifying worker hours and payroll for all Work performed at the Project Site. Payroll reports shall include all personnel performing work at the Project Site. Payroll shall be raw wages without burden or fringes, but should include overtime (at the straight-time rate), sick, vacation, and holiday pay. For those months where no onsite labor was expended, a payroll report must be submitted indicating zero ($0) payroll. Payroll Reports are due on the 10 th of the month for the previous month worked and shall be submitted to the OCIP Administrator until completion of the Work under the Contract. A separate payroll report should be submitted for each Contract awarded. Failure to submit Payroll Reports may result in the withholding of payments until required documentation is received. The OCIP payroll and loss experience information sent by the OCIP insurance carrier to the applicable Workers Compensation Bureau will be reflected in each subcontractor s Experience Rating Modifier (ERM). Therefore, it is important that you properly classify payrolls and report your payroll promptly and accurately. Inaccurate or missing payroll may have an adverse impact on your ERM. Audit Enrollees are required to maintain payroll records for the Project Site in accordance with the Basic Manual of Rules, Classifications, and Experience Rating Plan for Workers Compensation and Employer s Liability Insurance. Such records shall allocate the payroll (including overtime) by Workers Compensation classification(s) and shall include total hours worked. -Edition No. 5 dated 01-22-2013 Page 25 of 37
Section 7 Enrollee Responsibilities (cont.) Enrollees shall make available their books, vouchers, contracts, documents, and records, of any and all kinds, to the auditors of the OCIP insurance carriers and/or Authority representatives at any reasonable time during the policy period, any extension, or during a final audit period as required by the insurance policies. Change Orders Any Change Orders shall exclude insurance costs. Completion of Work Upon completion of work, Enrollees should sign on to Aon s website and complete the Notice of Work Completion form in the OCIP Administrator website. Final Payment will not be released by the Authority until all necessary forms have been submitted to the OCIP Administrator. Claim Reporting Enrollees shall follow the claims procedures as established by the Authority, the OCIP Insurance Carrier(s) and the OCIP Administrator as outlined in Section 8 of this OCIP Manual. Enrollees agree to assist and cooperate in every manner possible in connection with the adjustment of all claims and demands in which the Authority s OCIP Insurance Carriers(s) are called on to adjust or defend. Safety Procedures All parties performing work on the Project Site must follow the Contractor s Health and Safety Plan. -Edition No. 5 dated 01-22-2013 Page 26 of 37
Workers Compensation Claims Section 8 - Claim Procedures These procedures are to apply to ALL employees covered by the OCIP for the Project(s): Immediately report any incident, to the Chartis 24 Hour Accident Report Line at 1-800-910-2667, whether or not medical treatment was sought and/or received. The GC s Safety Representative shall complete the NJTA - OCIP Injured Worker s Notification form (Form A, attached) and an Accident Investigation Report (Form B, attached) and submit to the OCIP Administrator within 24 hours. (fax 847-953-7635 / email Elizabeth.okeefe@aon.com ). If the injured employee requires medical attention from a clinic or hospital, then the Safety Representative and/or Competent Person shall issue the Injured Worker Services Form (Form C, attached) and the tmesys first fill Prescription Card which can be presented to the applicable clinic or hospital personnel upon admittance, or faxed to the clinic or hospital ahead of time. In the event of an emergency, site specific emergency procedures should be followed. General Liability Claims Promptly report any injuries or property damage to the public or damage to property within the Project Site that are related to the construction work to the Safety Representative. The Safety Representative will complete an Accident Investigation Report (Form B, attached) and submit it to the OCIP Administrator within 24 hours. (fax 847-953-7635 / email Elizabeth.okeefe@aon.com ). Automobile Liability Claims No coverage is provided for automobile accidents under the OCIP. It is the sole responsibility of Enrollees to report accidents involving their automobiles to their own insurers. HOWEVER, all accidents occurring in or around the Project Site must be reported to the Safety Representative. The Safety representative will report this information to the OCIP Administrator, within 24 hours. (fax 847-953-7635 / email Elizabeth.okeefe@aon.com) and will investigate these accidents with regard to any liability arising out of the Construction Operations at the Project Site that could result in future claims (i.e. due to the conditions of the roads, etc.) Enrollees shall cooperate in the investigation of all automobile accidents. -Edition No. 5 dated 01-22-2013 Page 27 of 37
Pollution Claims THE NEW JERSEY TURNPIKE AUTHORITY Enrollees must immediately notify the Safety Representative of any known or suspected pollution incidents, who will report the incident to the OCIP Administrator. The Safety representative shall submit an Accident Investigation Report (Form B, attached) to the OCIP Administrator, within 24 hours. (fax 847-953-7635 / email Elizaeth.okeefe@aon.com) -Edition No. 5 dated 01-22-2013 Page 28 of 37
OWNER CONTROLLED INSURANCE PROGRAM \ NEW JERSEY TURNPIKE AUTHORITY - OCIP INJURED WORKER S NOTIFICATION FORM (Employers Authorization for Medical Treatment) **Please complete the following and fax it to the Medical Provider (or send with injured worker) prior to the first medical treatment. NOTE: THIS IS AN EMPLOYEE OF AN ENROLLED CONTRACTOR UNDER THE OCIP WORKING ON THE NEW JERSEY TURNPIKE AUTHORITY JOBSITE WHO STATES AN INJURY OCCURRED ON THE JOB. Employee Name (Injured worker): DOB: Job Title: Social Security Number: Gender: Date of Injury: Time of Injury: Time Employee Began Work: Date Employee Reported Accident to Employer: Employer Name & Address (Enrolled Contractor Entity Name): WC Worker s Compensation Claims Reporting Procedures Employer Main Contact Person: Ph #: Accident Location (address): Accident/Injury Description [include specific body part (s)]: Witness(es) Name: Ph #: Ph #: Did Employee Leave Work? Yes or No Time: Did Employee Return to Work? Yes or No Time: FORM A -Edition No. 5 dated 01-22-2013 Page 29 of 37
If Employee Is Disabled, Is There Light Duty Available? Yes or No If Yes, What Type? Does Employee Have Prior Health Condition(s)? Yes or No If Yes, Explain: Do You Question the Accident and Injuries? Yes or No If Yes, Explain: Which of the Following Test(s) Will Be Administered to the Injured Worker? Drug Screen Breath Alcohol Drug Screen & Breath Alcohol Urine Collection Only Completed by (Print): Ph #: Date: Signature: Job Title: FORM A -Edition No. 5 dated 01-22-2013 Page 30 of 37
Accident Investigation Report The unsafe acts of people, and the unsafe conditions that cause accidents, can be corrected only when they are known specifically. It is your responsibility to identify them and correct them. This report and investigation must be completed within 24 hours of the accident. The employee involved and his/her supervisor should cooperate to complete all the information requested. Please use additional paper as necessary. PART I General Information: CONTRACT NUMBER CONTRACTOR Name of Injured Social Sec. # Chartis Reference Number PART II Employee s Description of Accident (What Happened?) Day/Date of Accident Time Exact Location When was supervisor notified? Who did you report the accident to? Job or Activity at Time of Accident: Describe the Accident: Describe the Injury and body part(s) affected: Names of on duty supervisor and any witness(es): Employee Signature: Phone # Date (I certify that the information provided above is true and complete.) PART III Supervisor s Investigation of the Accident: If you do not agree with the employees report, notify your Human Resources Manager and/or the Office of Workers Compensation immediately, and provide details with this report. A. Describe the Acts that led up to or contributed to the Accident: B. Describe the Conditions that led up to or contributed to the Accident: C. Identify some Cause(s) that led up to or contributed to the Accident: FORM B -Edition No. 5 dated 01-22-2013 Page 31 of 37
Accident Investigation Report (cont d) PART IV Corrective Action Taken (What Training, PPE, Procedures and/or Equipment do you recommend to prevent a recurrence of a similar accident?) Has it been done? If not, give reason PART V Accident Analysis Details Severity of Injury / Damage: Fatality Lost Workdays Medical Treatment (off premises) First Aid (On Site) Significant Property Damage Panel of Physicians List Provided to Employee Yes (Attach Copy to this Report) No Employment Category: Regular, Full-time Regular, Part-time Temporary Contractor Other Time in Occupation at time of accident: Less than 6 months 6 mos. To 2 years 2 to 5 years More than 5 years Work Shift at time of accident: Day Shift Evening Shift Night Shift Prepared by: (Name & Title) Work Phone #: Date Report Prepared: Reviewed by: (Name & Title) Work Phone #: Date Report Reviewed: Follow up Action: FORM B -Edition No. 5 dated 01-22-2013 Page 32 of 37
New Jersey Workers Compensation NEW JERSEY TURNPIKE GARDEN STATE PARKWAY OCIP Preferred Provider Organization (PPO) Arrangement Injured Worker Form for Medical Services CHARTIS and COVENTRY CONTRACT NO. CONTRACTOR To Employer: Please complete the following information and fax this form to the physician prior to the first medical treatment/visit for an employee s work related injury/illness. EMPLOYER NAME: EMPLOYER CONTACT: EMPLOYEE NAME: SOCIAL SECURITY NUMBER: DATE OF INJURY: PLACE OF INJURY: TYPE OF INJURY: PHYSICIAN NAME: APPOINTMENT DATE (if available): To Medical Provider: Chartis, the administrator of Workers Compensation claims for the employer indicated above, has contracted with a certified preferred provider organization to provide medical management services and network access. Please call the preferred provider organization prior to any treatment, hospital admission, surgery, second opinion or referral to a specialist. In any emergency situation, do not delay medical care. Provide medical treatment immediately. Call the preferred provider organization within 24 hours of treatment. Send bills to: Chartis P.O. Box 1822 Alpharetta, GA 30023 PREFERRED PROVIDER ORGANIZATION: Coventry - 1-800-895-0698 / www.coventry.com For any billing inquiries, call the ADJUSTER AT: CHARTIS: 1-800-222-4309. QUESTIONS CALL OCIP ADMINISTRATOR: 732-750-5300X8736 FORM C -Edition No. 5 dated 01-22-2013 Page 33 of 37
-Edition No. 5 dated 01-22-2013 Page 34 of 37
-Edition No. 5 dated 01-22-2013 Page 35 of 37
Section 9 - Safety Procedures All parties performing work on the Project Site must follow the Contractor s Health and Safety Plan. -Edition No. 5 dated 01-22-2013 Page 36 of 37
Section 10 - OCIP Administration Contacts Account Executive Account Manager SVP - Claims Worker s Compensation & General Liability OCIP Safety Director OCIP Safety Manager Peter Erwin Tel: 732-750-5300 X8735 Cell: 516-491-3826 Peter.erwin@aon.com Elizabeth O Keefe Tel: 732-750-5300 X8736 Cell: 732-770-5220 Elizabeth.okeefe@aon.com Julian Ehrlich Tel: 516-396-4349 Juliann.Ehrlich@aon.com Rick Comer Tel: 516-396-4347 Rick.Comer@aon.com Orlando Cordero Tel: 516-396-4264 Cell: 516-749-4917 Orlando.Cordero@aon.com Michael Cerick Tel: 732-750-5300 X8734 Cell: 973-908-5701 safetymike22@optonline.net -Edition No. 5 dated 01-22-2013 Page 37 of 37