Vehicle Technical Information Guide For Cruise Control

Transcription

1 Vehicle Technical Information Guide For Cruise Control Model Years: FOR PRE 1996 VEHICLE INFORMATION, REQUEST FORM #4429 TECHNICAL SERVICE PHONE: (910) TECHNICAL SERVICE FAX: (910) WEB: FORM #4428, REV. L,

2 WARNING: The information presented in this manual has been carefully compiled through actual vehicle testing and manufacturers service manual research and to the best of our ability is accurate. However, we do not warrant the accuracy of this information against changes in vehicle design, the use or misuse of this information or typographical errors. It is the responsibility of installer to verify the signal and color on the wire attachments prior to and after the installation of the cruise control to assure proper operation of the cruise control and the vehicle through a road test. We do not accept any responsibility for damage to the vehicle or injury to its occupants caused by the use of this information. Connection to the incorrect wires could cause cruise control or vehicle malfunctions and component damage. These conditions can cause a major risk while driving for you, your passengers and other motorists, exposing all of you to the risk of accident and injury. WARNING: Any installation of a cruise control on a vehicle that does not have clearance at the throttle for lost motion or may have interference by other parts must have the cruise control cable attached to the accelerator pedal for obvious safety reasons. CAUTION: Any installation of a cruise control on a vehicle with an accelerator pedal activated switch for emissions or transmission shifting must have the cruise control cable attached to the accelerator pedal for proper vehicle operation. NOTE: Vehicle manufacturers will occasionally change wire color but rarely change position of the VSS wire. Page 2

3 INDEX HOW TO USE THIS GUIDE... Page 4 WIRE ATTACHMENT LOCATION CHART... Page 5 VEHICLE TECHNICAL INFORMATION BY MANUFACTURER DAEWOO... Page 6 DAIMLER CHRYSLER Chrysler, Dodge, Jeep, Eagle & Plymouth... Page 8 FORD MOTOR COMPANY Ford & Mercury... Page 12 GENERAL MOTORS Buick, Chevrolet, GEO, GMC, Oldsmobile, Pontiac & Saturn... Page 16 HONDA... Page 28 HYUNDAI... Page 28 ISUZU... Page 30 KIA... Page 32 MAZDA Page 34 MITSUBISHI... Page 36 NISSAN... Page 38 SUBARU... Page 40 SUZUKI... Page 42 TOYOTA Page 44 VOLKSWAGEN... Page 46 Page 3

4 HOW TO USE THIS GUIDE I II III IV V VI VII VIII IX X Locate the manufacturer of the vehicle in which this Cruise control kit is being installed in the index on page 3. Locate the manufacturer, model, & engine size that is appropriate to this application in columns A & B. Column C gives the appropriate Custom Control Switch (Leftmost C Column)and Required Throttle Adapter Kit (Rightmost C Column). Column D gives the wire attachment location code for VSS that corresponds to the wire attachment chart on page 5. This column also gives the wire position within that location. Column E gives the vehicle VSS wire color. Column F gives the vehicle VSS pulses per mile. Column G Gives the wire attachment location code for tachometer signal that corresponds to the wire attachment chart on page 5. This column also gives the wire position within that location. Column H gives the vehicle tachometer wire signal color. Column I gives the vehicle brake switch positive side wire color. Column J gives the vehicle brake switch negative side wire color. ADDITIONAL ACCESSORIES: Vacuum Regulator Vacuum Reservoir Canister, 35 cu. in Vacuum Reservoir Canister, 20 cu. in Universal Disengagement Switch, 10mm Page 4

5 ENGINE BULKHEAD Location 1: Location 2: Location 3: Location 4: Location 5: Location 6: Location 7: Location 8: Location 9: Location 10: Location 11: Location 12: Location 13: Location 14: Location 15: Location 16: Location 17: Above or Behind Passenger s Side Kick Panel. Behind Passenger s Side Dash and/or Glove Box. Bottom of Dash Panel Between Center Console & Glove Box. Center Console (Passenger s Side Access). Center Console (Driver s SIde Access). Right Hand Side of Steering Column. Behind Instrument Panel and/or Left Hand Side of Steering Column. Above or Behind Driver s Side Kick panel. Under Passenger s Side Seat. Under Driver s Side Seat. Passenger s Side Fender Well (Between Engine Bulkhead & Shock Tower). Passenger s Side Engine Bulkhead Driver s Side Engine Bulkhead Driver s Side Fender Well (Between Engine Bulkhead & Shock Tower). Driver s Side Fender Well (Between Shock Tower & Front Grill). On Engine Passenger s Side Fender Well (Between Shock Tower & Front Grill). Page 5

6 DAEWOO Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Daewoo Leganza Location1- Three connector ECM middle connector position D7,D10,C Daewoo Lanos Location1- Three connector ECM middle connector position D7,D10,C Daewoo Nubira Location1- Three connector ECM middle connector position D7,D10,C11 Page 6

7 DAEWOO E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Green/White 8000 Middle connector of ECM Orange or Blue or White Red Yellow Position C10 or D11 Green/White 8000 Middle connector of ECM Orange or Blue or White Red Yellow Position C10 or D11 Green/White 8000 Middle connector of ECM Orange or Blue or White Red Yellow Position C10 or D11 Page 7

8 CHRYSLER, DODGE, JEEP, EAGLE & PLYMOUTH Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal 96 Chrysler Cirrus Location 15 Black 40 pin connector (41-80) of PCM position 66 of location 15 black 60 pin con of TCM pos 58 Chrysler Cirrus Location 15 Gray 40 Pin Connector Plymouth Sebring position 66 Avenger, Stratus Dodge Breeze Chrysler Cirrus Location 12 or 15 4 conn. computer Plymouth Sebring * 4th conn. Pos. 32 Dodge Breeze Chrysler Town & Country Pos 66 of Black 40 pin conn (41-80) of 2.4, 3, 3.3, 3.8L PCM Loc 15 or Pos 58 of Blk 60 pin conn of TCM Loc Dodge Avenger Location 15 Black 40 Pin Connector (41-80) of PCM, Pos.66 or Location 15 Black 60 pin conn. of TCM Pos Dodge Colt Location 1 Yellow 22 pin conn. of ECM, Pos Dodge Colt Wagon Location 1 Yellow 22 pin conn. of ECM, Pos Dodge Intrepid Location 17 Black 40 pin conn. (41-80) of PCM Pos. 66 or Location 15 Black 60 pin conn. of TCM Pos Dodge Intrepid * Loc 12 or 15 4 conn computer 4th conn Pos Dodge/ Neon Location 15 Black 40 Pin connector Plymouth (41-80) of PCM Pos. 66 or Dodge Neon Location 12 or 15-4 conn. computer * 4th conn. Pos.32 3 connector ECM Black conn 1st conn pos Dodge Caravan/ Position 66 or 67 of Black 40 pin conn Voyager 2.4L, (41-80) of PCM in Location 15 or Pos L,3.3L &3.8L of Black 60 pin conn TCM Location 17 2 connector ECM Dodge Caravan * Location 12 or 15-4 conn. computer 4th conn. Pos Dodge Trucks Dakota 2.5L, Location 11 White 32 pin connector of L, & 5.2L * PCM Position B Location 12 or 15 4 conn. computer 4th conn. Pos Dodge Trucks Pick-up 3.9L Location 11 White 32 Pin connector of PCM Position B27 Location 12 or 15-4 conn. computer 4th conn. Pos Dodge Trucks Pick-up, Location 11 White 32 Pin connector of Diesel PCM Position B27 Page 8 *03-08 ONLY Not for Manual Transmissions

9 CHRYSLER, DODGE, JEEP, EAGLE & PLYMOUTH E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative White/Orange 8000 Location pin conn (41-80) White/Black Red/Black White/Tan position 60 Yellow/White 4000 Location 15 Gray 40 pin conn White/Black Red/Black White/Tan White/Orange 8000 Position 60 Lt.Green/White 38,600 If manual use N/A Pink/DkBlue White/Tan White/Orange 8000 Location 16 Ignition Coil Pack or Gray Pink/ White/Tan position 50 of PCM Dark Blue White/Orange 8000 Location pin connector White/Black Red/Black White/Tan position 60 Yellow/White 4000 Negative side of Coil Blue Red/White Green Yellow/White 4000 Negative side of Coil Blue Red/White Green White/Orange 8000 Location 15 pos 60 of PCM White/Black Pink/ White/Tan Dark Blue Green/White 38,600 If manual use clutch switch N/A Pink/ White/Tan Dark Blue White/Orange 8000 Location 15 Black 40 pin conn Gray/ Pink/ White/Tan Blue/Orange (41-80) of PCM, Pos. 73 Light Blue Dark Blue Lt.Green/White 38,600 If manual use clutch switch N/A Pink/DkBlue White/Tan Loc 16 Ignition Coil Pk or pos 50 of PCM Gray Pink/ White/Tan White/Orange 8000 Location15 Pos. 60 of White/Black Dark Blue Blue/Orange Powertrain Control Module Lt.Green/White 38,600 Not Used if manual use N/A Pink/ White/Tan Green/Brown Dark Blue White/Orange 8000 Loc11 Gray 32 pin conn of PCM Pos C31 Gray/Lt.Blue Pink/ White Tan Blue/Orange Loc12 Black 32 pin conn of PCM pos A7 Black/Gray Dark Blue White/Orange 8000 Location 11 Gray 32 pin conn of Gray/Lt.Blue Pink/ White/Tan Lt.Green/White 38,600 PCM, position C31 Dark Blue Green/Brown White/Orange 8000 Location 11 Gray 32 pin con of Gray/Lt.Blue Pink/ White/Tan PCM, position C31 Dark Blue Page 9

10 CHRYSLER, DODGE, JEEP, EAGLE & PLYMOUTH Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Dodge Trucks Van/Pickup Location 11 White 32 pin connector of PCM Position B27-3 connector ECM Dodge Trucks Van/Pickup * Location 12 or 15 4 conn computer 4th conn C4 pos 32 3 conn ECM Black Conn 1st Conn pos Eagle Summit Location 1 Yellow 22 pin conn. of ECM Position Eagle Talon Location 5 16 pin data link conn., Position Eagle Talon Location 5 16 pin data link connector (Turbo) Position Jeep Cherokee Location 13 Wire Harness from Transmission Jeep Cherokee * Loc 12 or 15 4 conn. computer 4th conn. Pos Jeep Grand Location 13 Wire Harness from Cherokee Transmission Jeep Wrangler Loc 12 Wire Harness from Transmission Loc 13 Connector above Valve Cover Wrangler * Loc 12 or 15 4 conn. computer 4th conn Pos Plymouth Concord Loc 17 Black 40 pin conn (41-80) of PCM Pos.66 or Loc 15 Black 60 pin conn. of TCM Pos Chrysler PT Cruiser Location 13 (41-80) pin conn of ECM Pos.66 or 67-3 connector ECM * Location 12 or 15 4 conn ECM 4th conn Pos Chrysler PT Cruiser Black 38 pin conn Pos 13 (Manual) 1st conn on ECM Jeep Liberty Location 12 or 14 Gray 32 pin connector * position 17-3 connector ECM Location 12 or 15 4 conn computer 4th conn Pos Dodge Truck Loc 14 Anti-Lock Brake module (Diesel) Dodge Truck * Loc 13 Pos 44 of 50 pin conn on PCM (Diesel) closest to firewall Page 10 *03-08 ONLY

11 CHRYSLER, DODGE, JEEP, EAGLE & PLYMOUTH E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative White/Orange 8000 Location 11 Black 32 pin con of Gray or Pink/ White/Tan PCM, position A7 Gray/Black Dark Blue Lt.Green/White 38,600 Not Used if manual use N/A Pink/DkBlue White/Tan Dk.Green/Brown Gray/Red Yellow/White 4000 Red/White Green Yellow/White 4000 Location 15 Top 40 pin con on Blue/Red Red/Black Green PCM, position 33 Yellow/White 4000 Loc 16 8pin ignition power White Red/Black Green transistor behind engine White/Orange 8000 Location 16 Ignition Coil Gray or Pink/Black White/Tan Gray/Black Green/White 38,600 Not used if manual use N/A Pink/Black White/Tan White/Orange 8000 Location 16 Ignition Coil Gray or Pink/Black White/Tan Gray/Black White/Orange 8000 Location 16 Ignition Coil Gray or Red/Black White/Tan Gray/Black Pink/Blue White/Pink Green/White 38,600 Not used if manual use N/A Pink/DkBlue White/Tan White/Orange 8000 Location 16 Position 60 of PCM White/Black Pink/ White/Tan Dark Blue White/Orange 8000 Location pin conn of ECM Gray/Black Pink/Blue White/Tan Blue/Orange position 11 Green/White 38,600 Not used if manual use N/A Pink/DkBlue White/Tan White/Orange 8,000 If manual transmission N/A Pink/Blue White/Tan use clutch switch Green/Yellow 8000 If manual transmission use clutch switch N/A Pink/Blue White/Tan Green/Orange 38,600 Not used if manual use N/A Pink/DkBlue White/Orange 8000 If manual transmission use clutch switch Pink/Blue White/Tan Lt.Green/White Use clutch switch N/A Gray/Red White/Tan Dr.Green/Violet Page 11

12 FORD & MERCURY Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Ford Focus Location pin connector of ECM Position 28 - Bottom connector side next Ford Focus to firewall Location 1- Middle connector position 1 Contour & Location 12 Position 58 of 104 pin conn Ford & Mystique of PCM Mercury Location pin conn Position 58 Between locations 12 & 13 on top of 96 Ford & Escort & transaxle or Pos. 3 of Gray 10 pin speed Mercury Tracer control amplifier 97 Ford & Escort & Locations 4 80 wire harness running from Mercury Tracer ECM towards center console Ford & Escort/ Location pin conn - Position 58 Mercury Tracer LX20 or Main Harness to PCM Escort ZX Ford & Crown Victoria & Position 58 of 104 pin connector of PCM Mercury Grand Marquis Ford Mustang 5.0L Location 16 Right rear of Engine in a 16 pin connector Ford Mustang 3.8L Loc14 Blk 10 pin Speed Control Amp Pos3 or Loc1 Pos pin conn of PCM or Loc12 Blk 12 pin conn or Loc1 Pos 68 of 104 pin conn Ford Probe Behind center console Pos 58 of 104 pin connector or Pos 14 of 28 pin connector 96 Ford & Taurus & Location 12 pos 58 of 104 pin conn of Mercury Sable PCM Mercury Cougar Location 12 Pos 58 of 104 pin conn on ECM 96 Mercury Villager Location 2 Pos 26 of 88 pin conn of PCM Ford *Aerostar Location 14 Pos 58 of 104 pin conn of PCM 96 Ford *Bronco Location 14 Pos 58 of 104 pin conn of PCM or Location 14 Pos 3 of Gray 10 pin Speed Control Amplifier 96 Ford *Econoline Pos.3 of 60 pin conn of PCM or Pos 3 of Van 10 pin Speed Control Amplifier Page 12 *MUST USE ADAPTER KIT # TO READ ROAD SPEED WHEN USING CRUISE KIT#

13 FORD & MERCURY E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative White/Violet 8000 Location 16-3 pin connector White/Blue 18,000 on Dist- Ignitor Black/Green Green/ Green/Red White/Purple 8000 Loc 12 Pos 48 of 104 pin conn of PCM White/Black Orange/ Orange/ White/Violet Loc11 48 pin conn Pos 48 White Yellow White/Black 8000 Loc 14 on Bulkhead 25 pin Data Link Yellow/Blue Green/ Green or Green Connector Position 19 White White/Black wire harness running from Firewall Lt.Green/ Green/ Green towards center console Red White White/Black 8000 Loc pin conn - Pos 48 Lt.Green/ Green/ Green Red Red Gray/Black 8000 Location pin connector of PCM position 78 PINK/White Green/Red Green Gray/Black 8000 Loc 16- Coil also goes from Coil to Tan/ Green/Red Green 42 pin conn at Right rear of Engine Yellow Gray/Black 8000 Loc1- Pos 48 of 104 pin conn of ECM Orange/ Green/ Red/ White Red Green Orange/White Loc1- Pos 78 of 104 pin conn Pink/White Blue/White 8000 Location 16 Coil Black/ Yellow/ White/ Red/Green White Red Green Gray/Black 8000 Loc 12- Pos-48 of 104 pin conn of PCM Tan/ Lt.Green/ Red/ Yellow Red Lt.Green White/Purple 8000 Loc 12- Pos 48 of 104 pin conn on ECM White/ Orange/ Orange/ Black White Blue Green/Yellow 2000 Loc 2- Pos 3 of 88 pin conn of PCM Green/ Red/ Yellow/ White White Black Gray/Black 8000 Location 14- Pos 48 of 104 pin conn Tan/ Lt.Green/ Lt. Green of PCM Yellow Red Gray/Black 8000 Location14- Pos 48 of PCM White/Pink Lt.Green/ Lt.Green Tan/Yellow Red Gray/Black 8000 Location16 - coil or *spout White/Pink Lt.Green/ Lt.Green Pink Red Page 13

14 FORD & MERCURY Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Ford *Econoline Location13 - Position 58or 68 of 104 pin Van (96-97) conn of PCM 96 Ford *Econoline Position 58 of 104 pin conn of PCM Van Diesel Ford Expedition/ Location 12 - Position 58 or 68 of 104 Explorer pin conn of PCM 96 Ford Explorer Location12 Pos pin conn of PCM or Location11 Pos3 of Black 10 pin Speed Control Amplifier Ford *F-Series Loc11 or 12 Pos58 or 68 of 104 pin conn of PCM or Pos3 of Black 10 pin Speed Control Ford Ranger Loc12 Pos58 or 68 of 104 pin conn of PCM or Loc 11 Pos3 of Black 10 pin Speed Control Amplifier Ford *Windstar Loc12 Pos58 of 104 pin conn of PCM Ford Windstar Black 2 pin conn. Located on driver s Freestar side transaxle behind shift lever. Use tech tip# Ford Taurus Location 12-Position 68 of 104 Pin Conn of PCM Ford Escape Location Pin conn of PCM - 4cyl-Pos. 58 6cyl - Pos Ford Escape Location 12-3 conn. ECM right Conn. pin 4 o5-o7 Ford F150/250/ see tech tip Location 5 Radio harness 4005 web site FORD RANGER LOCATION 12 3 CONNECTOR ECM MIDDLE CONNECTOR POSITION Ford Escape LOCATION 12 3 CONNECTOR ECM MIDDLE CONNECTOR POSITION 1 08 Ford F150/250/ Under Hood on Firewall 3 Conn. PCM middle Conn. position 63 or Anti Lock brake module in drivers fender well Page 14 *MUST USE ADAPTER KIT # TO READ ROAD SPEED WHEN USING CRUISE KIT#

15 FORD & MERCURY E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Gray/Black 8000 Location13 - Pos48 of White/ Lt.Green/ Lt.Green 104 pin conn of PCM Pink Red Gray/Black 8000 Lt.Green/ Lt.Green Red Gray/Black 8000 Location12 - Pos48 of White/Pink Green/ Green 104 pin conn of PCM or Red White/LtGreen Gray/Black 8000 Location12 - Pos48 of Tan/ Lt.Green/ Lt. Green 104 pin conn of PCM Yellow Red Black/ Gray/Black 8000 Location 11 or 12 Pos48 or 78 White/Pink Lt.Green/ Yellow of 104 pin conn of PCM or Pink Red or Green Gray/Black 8000 Location12 Pos48 of Tan/ Lt.Green/ Lt.Green 104 pin conn of PCM Yellow Red Green/White 8000 Not used if manual trans: Not Used Lt.Green/ Lt.Green Use Red 99=18000 Must use Blue/Yellow or 00=28960 Not used if manual trans: relay: Tech Not Not Green/white 01/04 Use Tip #4001 Used Used =28960 Gray/Black 8000 Location 12 - Position 78 Pink/ Green/ Green of 104 Pin connector of PCM White Red 4cyl-Blue/Yellow Location Pin connector of PCM Gray/Yellow Green/ 4 cyl Pos 22 Red Green 6cyl Gray/Black cyl Pos 78 Red/Yellow Blue/Yellow If manual Transmission use clutch switch Green/Red Green pin 3- Lt. Blue 10, Gray/black 8000 if manual Transmission use clutch switch Green/Red Green PURPLE/RED 8000 IF MANUAL TRANSMISSION USE CLUTCH SWITCH Green/Red Green Purple/Red 8000 IF MANUAL TRANSMISSION USE CLUTCH SWITCH Gray/Black 8000 IF MANUAL TRANSMISSION USE Yellow/blue CLUTCH SWITCH Page 15

16 GENERAL MOTORS Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal 96 Buick Century 2.2L Location2 Blue 32 pin conn, Pos Buick Century 2.2L Location 2 Black 80 pin conn, Pos Buick Century 3.1L Location 2 Blue 80 pin conn, Pos Buick Century 3.1L Location 2 Blue 80 pin conn, Pos13 or Buick Century 3.1L Location 13 Factory Cruise plug Pos K 96 Buick LeSabre Location 14 Blue 80 pin conn, Pos Buick LeSabre Location 15 Blue 80 pin conn, Pos Buick LSS Location 14 Blue 80 pin conn, Pos Buick Park Location 14 Blue 80 pin conn, Pos 13 Avenue Buick Regal Location 17 Blue 80 pin conn, Pos Buick Riviera Location 2 Blue 80 pin conn, Pos L Buick Riviera Location 2 Clear 80 pin conn, Pos L Buick Roadmaster Location 15 under air cleaner Black 32 pin conn Pos B-8 96 Buick Skylark 2.4L Location 2 Blue 32 pin conn, Pos 1 97 Buick Skylark 2.4L Location 2 Black 80 pin conn, Pos Buick Skylark 3.1L Location 2 Blue 80 pin conn, Pos. 13 Page 16

17 GENERAL MOTORS E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Green 4000 Location 2 Blue 32 pin conn., Pos20 White Orange Yellow Green/White 4000 Location 2 Black 80 pin conn, Pos10 White Orange White Green 4000 Location 2 Blue 80 pin conn.,pos53 White Orange Yellow Green/White 4000 Location 2 Blue 80 pin conn., or Green Position 53 or 54 White Orange White Green/White 4000 Location 2 Blue 80 pin conn White Orange White or Green Position 54 Green/White 4000 Location 12 Blue 80 pin conn Pos53 White Orange White Green 4000 Location 15 Blue 80 pin conn. Pos53 White Orange White Green/White 4000 Location 14 Blue 80 pin conn. Pos53 White Orange White Green/White 4000 Location 14 Blue 80 pin conn. Pos53 White Orange White Green 4000 Location 17 Blue 80 pin conn. Pos53 White Orange White Green/White 4000 Location 2 Blue 80 pin conn. Pos53 White Orange White Green/White 4000 Orange White Dark Green/ 4000 Location 15 under air cleaner Black 32 White Orange White White pin conn, Pos B-5 Green/White 4000 Location 2 Blue 32 pin conn. Pos20 White Orange Light Blue Green/White 4000 Location 2 Black 80 pin conn. Pos10 White Orange Light Blue Green/White 4000 Location 2 Blue 80 pin conn, Pos53 White Orange Light Blue Page 17

18 GENERAL MOTORS Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal 97 Buick Skylark 3.1L Location 2 Black 80 pin conn Pos Chevrolet Camaro 3.8L ** Location 2 Blue 80 pin conn. Pos 13 ** Location 8 Blue 80 pin conn. Pos 55 ** Chevrolet Caprice Location 16 under air cleaner, Pos B of the Black connector 96 Chevrolet Cavalier 2.2L Location 17 Blue 32 pin conn. Pos 1 97 Chevrolet Cavalier 2.2L Location 17 Black 80 pin conn. Pos Chevrolet Cavalier 2.4L Location 17 Black 80 pin conn. Pos Chevrolet Cavalier 3.1L Location 1 Black 24 pin conn. Pos B Chevrolet Cavalier 2.2L Location 17 Black 80 pin conn. Pos (RF) Chevrolet Cavalier 2.2L Location 12 ECM Blue conn Pos (RF) Chevrolet Prizm Location 5 Gray 22 pin conn. Pos 9 or Main Wire Harness or transmission Chevrolet Corsica/ Location 2 Blue 80 pin conn. Pos 13 Beretta 3.1L Chevelle/ Location 8 Black 80 pin conn. Pos Chevrolet Malibu 2.4L (RF) (99) Chevrolet Chevelle/ Location 8 Blue 80 pin conn. Pos 13 Malibu 3.1L Location 8 Blue or Black 80 pin conn Pos Chevrolet Chevelle/ Location 13 Factory Cruise plug Pos K Malibu 3.1L or Loc 7 80 pin conn Pos Chevrolet Impala SS Location 15 under Air Cleaner Black 32 pin conn. Pos. B Chevrolet Lumina 3.1L ** Location 17 Blue 80 pin conn. Pos. 13 ** Chevrolet & Astro & Location 15 Black 24 pin conn. Pos 3 GMC Trucks Safari Chevrolet & Astro & Location 13 Factory Cruise Plug Pos. K GMC Trucks Safari **NOTE: THESE PART NUMBERS ONLY FIT THE 96 MODELS. Page 18

19 GENERAL MOTORS E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Green/White 4000 Location 2 Blue 80 pin White Orange Light Blue connector, Pos. 10 Green/White 4000 Location 2 Blue 80 pin conn. Pos 53 White Orange Light Blue Location 8 Blue 80 pin conn. Pos 54 (vacuum reservoir 3417) Green/White 4000 Location 16 Under air cleaner, White Orange White Pos. B-5 of the Black connector Green/White 4000 Location 17 Blue 32 pin conn. Pos 32 White Orange White Green/White 4000 Location 17 Blue 80 pin conn. Pos. 26 White Orange White Green/White 4000 Location 17 Black 80 pin conn. Pos 10 White Orange White Green/White 4000 Location 1 Black 32 pin conn. Pos C-8 White Orange White Green/White 4000 Location 17 Yellow 80 pin conn. Pos 26 White Orange White or Green Green/White 4000 Location 12 Black conn White Orange White Position 19 Violet/White 4000 Location 5 Diagnostic Conn Gray 22 pin Black Red/White Green/ White/Blue connector Pos. 8 or 13 White Green/White 4000 Location 2 Blue 80 pin conn. Pos53 or 13 White Orange Light Blue Green/White 4000 Location 8 Black 80 pin conn Pos 10 White Orange White or Lt. Blue Green or 4000 Location 8 Blue or Black 80 pin conn White Orange White or Green/White Pos. 54 under blue wire Lt. Blue Green 4000 Location 8 Blue conn Pos 54 White Orange White Dark Green 4000 Location 15 under Air Cleaner White Orange White w/white Green 4000 Location 17 Blue 80 pin conn. White Orange White Position 53 or 54 Green/White 4000 Location 15 Clear or White White Orange White 32 pin conn. Pos. 9 Green/White 4000 Location 15 Red conn Pos. 10 White Orange White Page 19

20 GENERAL MOTORS Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal 96 Chevrolet & S-10 & Location 17 Blue 32 pin conn. Pos.1 GMC Trucks Sonoma 2.2L Chevrolet & S-10 & Location 11 or 17 Black 80 pin conn. GMC Trucks Sonoma 2.2L Position 16 (RF) Chevrolet & S-10 & Location 17 Pos. 3 of Black 24 pin conn. GMC Trucks S L OR Location 14 Factory 10 pin conn Vortec (RF:98-99) Position K 96 Chevrolet & Blazer & Location 17 Black 24 pin conn. Pos. 3 GMC Trucks Jimmy 4.3L 96 Chevrolet & V-Blazer & Location 15 between Anti-Lock Module & GMC Trucks V-Jimmy Front Wheel Speed Sensor; Black 24 pin conn. Pos.3 96 Chevrolet Lumina APV Location 2 Blue 80 pin conn. Pos Chevrolet Venture Location 15 Blue 80 pin conn. Position 13 or Chevrolet & Silverado & Location 14 Factory 10 pin conn. Pos.K GMC Trucks C/K Truck (RF) (98-02) Chevrolet & Silverado & Location 15 Factory 10 pin conn. Pos.K GMC Trucks C/K Truck TBGM 96 Chevrolet & #C/K Pickups Location 2 Brown 24 pin conn. Pos. A6 GMC Trucks 6.5L Diesel 96 Chevrolet & G-Van Location 8 Digital Ratio Adapter GMC Trucks Chevrolet & Express. G-Van Location 15 Black 24 or 32 pin connector GMC Trucks Savana Van Position or 3 or Loc. 13 factory 10 pin G-Van Chevrolet & Express G-Van Loc. 15 ECM Green conn Pos. 50 GMC Trucks Savana Van Throttle Body vehicles ONLY G-Van Geo Metro Location 2 Blue 10 or 12 pin conn left of ECM Location 2 16 pin conn. Pos Geo Prizm pin conn. on transaxle behind engine or under coin tray blk conn 2nd from corner or loc 5 gray (99-02) pin conn pos 9 or main harness to computer 96 Geo Tracker Location 8 White 20 pin conn. Pos Geo Tracker Manual/ Location 7 22 pin conn. Pos. 7 3 speed A/T Page 20

21 GENERAL MOTORS E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Green/White 4000 Location 17 Blue 32 pin conn. Pos 20 White Orange White Green/White 4000 Location 11 or 17 Black 80 pin conn. White Orange White Position 10 Green/White 4000 Location 17 Pos. 9 of White or Clear White Orange White 32 pin connector Green/White 4000 Location 17 White or Clear 32 pin conn White Orange White Position 9 Green/White 4000 Location 15 White or Clear 32 pin conn White Orange White Position 9 Green 4000 Location 2 Blue 80 pin conn. Pos 53 White Orange White Green 4000 Location 15 Blue 80 pin conn. White Orange White Position 54 or Red 80 pin. pos. 10 Green/White 4000 Location 15 White or Clear or Red White Orange White 32 pin conn. Pos.9 Green/White 4000 Location 15 White or Clear or Red White Orange White 32 pin conn. Pos.9 Green 4000 Not Used if Manual Not Used Orange White Transmission use Lt.Blue/ 4000 Location 16 Ignition Coil White Orange White Black Green/White 4000 Location 15 - Gray 32 pin conn. White Orange White Position 9 or Red 80 pin pos. 10 Green/White 4000 If manual use clutch switch N/A Orange White Yellow/ 4000 Location 16 Coil Brown Yellow/ Green/ Green Location 2 22 pin conn. Pos 6 White White Red/Yellow Location 16 2 pin at Distributor 4000 Location 5 gray 22 pin conn Pos.8 Black Red/ Green/ Violet/White or location 14 diagnostic conn White White Yellow 4000 Location 8 White 22 pin conn. Pos 2 Brown Green Green/ White Yellow 4000 Location 16 - Coil Brown/ Green Green/ White White Page 21

22 GENERAL MOTORS Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Geo Tracker 4 spd A/T Location 7 22 pin conn. Pos Geo *Tracker Location 2 4 connectors on ECM far right conn. Position 5 96 Oldsmobile Achieva 2.4L Location 2 Blue 32 pin conn. Pos 1 97 Oldsmobile Achieva 2.4L Location 2 Black 80 pin conn. Pos Oldsmobile Achieva 3.1L Location 2 Blue 80 pin conn. Pos Oldsmobile Aurora 3.8L Location 2 Blue 80 pin conn. Pos Oldsmobile Aurora 4.0L Location 2 Clear 80 pin conn. Pos Oldsmobile Ciera 2.2L Location 2 Blue 32 pin conn. Pos Oldsmobile Ciera 3.1L ** Location 2 Blue 80 pin conn. Pos. 13 ** Oldsmobile Cutlass Supreme ** Location 2 or 17 Blue 80 pin conn. Pos13 ** Oldsmobile Alero Location 7 Pos.16 of a Black 80 pin conn 2.4L 96 Oldsmobile Delta Location 14 Blue 80 pin conn. Pos Oldsmobile Regency Location 14 Blue 80 pin conn. Pos Oldsmobile Silhouette ** Location 2 24 pin conn. of EMC, L Pos. A Oldsmobile Silhouette Location 2 Blue 80 pin conn. Pos.13 *RECOMMENDED PEDAL PULL ATTACHMENT FOR SAFETY REASONS Page 22 **NOTE: THESE PART NUMBERS ONLY FIT THE 96 MODELS.

23 GENERAL MOTORS E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Yellow 4000 Location 16 - Coil Brown/ Green Green/ White White Blue/Yellow 4000 Location 2 4 connectors on ECM Brown Green Green/ far right connector Pos.4 White Green 4000 Location 2 Blue 32 pin conn. Pos 20 White Orange Lt.Blue Green/White 4000 Location 2 Black 80 pin conn. Pos 10 White Orange White Dark Green Green 4000 Location 2 Blue 80 pin conn. Pos 53 White Orange Lt. Blue Green/White 4000 Location 2 Blue 80 pin conn. Pos.53 White Orange White Green/White 4000 Orange White Green 4000 Location 2 Blue 32 pin conn. Pos. 20 White Orange Yellow Green 4000 Location 2 Blue 80 pin conn. pos.53 White Orange Yellow Green 4000 Location 2 or 17 Blue 80 pin conn White Orange White Position 53 Green/White 4000 Location 7 Pos.26 of a Blue White Orange White 80 pin connector Green/White 4000 Location 14 Blue 80 pin conn. Pos.53 White Orange White Green/White 4000 Location 14 Blue 80 pin conn. Pos.53 White Orange White Brown 2000 Location 2 32 pin conn. Pos D-4 White Orange White Green 4000 Location 2 Blue 80 pin conn. Pos 53 White Orange White Page 23

24 GENERAL MOTORS Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Pontiac Firebird 3.8L Location 2 Blue 80 pin conn. Pos Pontiac Firebird 3.8L Location pin conn. Closest to Firewall Position Pontiac Grand Am 2.4L Location 2 Blue 32 pin conn. Pos Pontiac Grand Am 2.4L Location 8 Black 80 pin conn. Pos.16 Location 12 ECM Blue conn. position Grand Am 2.2L Location 7 Blue conn Pos Pontiac Grand Am 2.4L Location 7 Pos.16 of a Black 80 pin conn 99 Pontiac Grand Am 3.4L Location 7 Pos.15 of Blue 80 pin conn Pontiac Grand Am 3.1L Location 2 Blue 80 pin conn. Pos Pontiac Grand Prix 3.1L ** Location2 or 17 Blue 80 pin conn. Pos.13 ** in Air Filter Box, Pos Pontiac Sunfire Location 17 Blue 32 pin conn. Pos.1 97 Pontiac Sunfire 2.2L Location 17 Black 80 pin conn. Pos Pontiac Sunfire 2.4L Location 17 Black 80 pin conn. Pos Pontiac Transport Location 2 Blue 80 pin conn. Pos Pontiac Transport 3.1L Location 15 Blue 80 pin conn. Pos Pontiac Sunfire Location 17 - Between tire and headlight 2-80 Pin conn, conn near engine Position Pontiac Sunfire Location 12 - Blue connector of ECM Position 34 **NOTE: THESE PART NUMBERS ONLY FIT THE 96 MODELS. Page 24

25 GENERAL MOTORS E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Green/White 4000 Location2 Blue 80 pin conn. Pos 53 White Orange Lt.Blue Green/White 4000 Location pin conn. Pos. 54 White Orange Lt.Blue Green/White 4000 Location 2 Blue 32 pin conn. Pos. 20 White Orange Lt.Blue Green/White 4000 Location 2Black 80 pin conn. White Orange White Dark Green position 10 or 26 or location 12 black connector of ECM Green/White 4000 Location 7 Black conn (Only White wire) White Orange White Green/White 4000 Location 7 Pos. 26 of a Blue 80 pin conn White Orange White Green/White 4000 Location 7 Pos. 54 of a Blue 80 pin conn White Orange White Green/White 4000 Location 2 Blue 80 pin conn Pos.53 White Orange Lt.Blue Green or 4000 Location 2 or 17 Blue 80 pin conn White Orange White Green/White Pos Pos. 54 Green/White 4000 Location 17 Blue 32 pin conn. Pos. 32 White Orange White Green/White 4000 Location 17 Blue 80 pin conn. Pos. 26 White Orange White Green/White 4000 Location 17 Black 80 pin conn. Pos. 10 White Orange White Green 4000 Location 2 Blue 80 pin conn. Pos. 53 White Orange White Green 4000 Location 15 Blue 80 pin conn. Pos. 53 White Orange White Green/White 4000 Other connector ECM Position 26 White Orange White Green/White 4000 Black connector of ECM only white wire White Orange White Page 25

26 GENERAL MOTORS Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal 03 Pontiac Vibe Location 2-4 connector of ECM 2nd connector left to right Saturn Saturn ECM: Blue 32 pin conn. Pos. D Saturn *LS pin conn. at transmission Saturn *L Right rear of transmission 2 pin conn Saturn *SL Behind Battery ECM Pos Saturn *SL Behind Battery ECM Pos Saturn Ion Location 14 ECM Pos. 50-no wire In Position 50 use magnet packing *PEDAL PULL Page 26

27 GENERAL MOTORS E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Violet/White 4000 Location 2-31 pin connector (E6) Black Red/ Green/ Position 5 White White Green 5000 Not used if manual transmission Not Used Orange White Use Yellow 18,000 If manual transmission use clutch N/A Orange White switch Yellow 10,000 If manual transmission use clutch N/A Orange White switch Violet 10,000 ECM 47 White Orange White Violet 10,000 ECM 47 White Orange White Violet 10,000 Not used if manual use N/A Orange White Page 27

28 HONDA Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Honda Civic DX 1.6L Location 12 3 pin conn. on top of transaxle or Location 7 20 pin conn. (RF) above fuse box 3rd pos. from corner Honda Accord Location 4-31 pin conn. at ECM Honda Civic DX Location 5 Fuse/Relay Box (RF) 2nd Row 13 pin Honda Insight Location 3- Ecm in floor- Blue 31 pin conn position 5 (RF) Honda Element Location 2 - ECM Pin connector Top connector Pos 26 (RF) HYUNDAI Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Hyundai Accent Location 8 Single plug ECM - Pos Hyundai Elantra Location 8 Single plug ECM - Pos Hyundai Sonata Location 8 Data Link connector below fuse panel 97 Hyundai Sonata Diagnostic conn under Drive Side Dash Hyundai Tiburon Location 8 Single plug ECM - Pos Hyundai Accent/ Diagnostic connector below steering Elantra column Accent Hyundai Santa Fe Loc 7 - Data Link connector Hyundai Tiburon Location 7 Data Link Connector Page 28

29 HONDA E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Blue/White 4000 Location 16 Gray 10 pin conn on Yellow/ White/ Green/ distributor Green Green White Blue/White 4000 Location 16 on distributor Yellow/ White/ White/ Green Yellow Black Blue/White 4000 Same 13 pin conn as VSS next wire Blue White/ White/ to VSS Green Black Blue/White 4000 If manual use clutch switch N/A White/Green Green/White Blue/White 4000 If manual use Clutch switch White/ Green/ Green White HYUNDAI E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Yellow/White 4000 Location 8-Pos 47 or Locatio 16 White Red/Black Green/ Or Green/White left side, 4 wire plug White Yellow/White 4000 Location 8-Pos.47 of Ecm White Red/Black Green/ White Yellow/White 4000 Location 16 First connector White Red/ Green/ below fuel rail Blue White Yellow/White Pin connector under White Red/ Green/ fuel rail Black White White 4000 Location 8 - Pos. 47 White Green Green/ White White/Black 4000 If manual transmission use clutch N/A Green Green/ OR Gray/Orange switch White OR Red/Orange Brown N/A Green Green/ Red/Orange If manual transmission, use White clutch switch Brown 4000 if manual transmission use Green Green/White Red/Orange clutch switch n/a Page 29

30 ISUZU Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Isuzu Hombre Location 11-Black 80 pin conn, Pos L RF Isuzu Hombre Loc 2 or 17-Black 24 pin conn, Pos.3 4.3L RF 96 Isuzu Rodeo Location 5 Center 32 pin conn., Gray 2.6L side of connector, Pos.6 97 Isuzu Rodeo Location 4 White 32 pin conn Pos.7 2.6L 96 Isuzu Rodeo Location 5 Gray side of 32 pin conn of 3.2L ECM behind center console, Pos Isuzu Rodeo and Location 5 Pos.7 of middle conn of ECM Amigo 96 Isuzu Trooper Location 8 black connector above Hose Release Page 30

31 ISUZU E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Green/White 4000 Location 2 or 11 - Black 80 pin conn White Orange White Position 10 Yellow/Green 4000 Location 2 or 17 - clear or white White Orange White Green/White 32 pin connector, Pos.9 White/ 4000 Location 16 Coil Blue Green Red Silver Dots White 4000 Location 16 Coil Blue Green/ Green/ White Yellow White 4000 Location 5 Gray side of Yellow Green Red 32 pin conn. Pos. 5 Blue/Black OR 4000 Location 5 Pos. C-10 middle conn Black/Red Black/Yellow of ECM White/Black 4000 Location 16 Largest connector Yellow/ Green Red on coil pack, 2nd position Red Marks Page 31

32 KIA Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal 96 Kia Sephia Location 8 at driver s kick panel, Pos. 8 of 18 pin conn of ECM Kia Sephia Location 3 20 pin conn Behind Carpet or/ Location 5 position 42 of ECM 96 Kia Sportage Location 1 under carpet, 18 pin conn of ECM. Pos 16 or 2 wire conn on transaxle Kia Sportage/ At connector on transmission Rio Kia Spectra Location 5 position 42 of ECM 04 On top transmission 3 pin connector Kia Optima pin connector on transmission- top side Kia Spectra Connector on back of instrument cluster 20 pin connector position Kia Rio Off Transmission Drivers side 3pin connector or Data link connector position 6 OR 3 Page 32

33 KIA E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Green/Red 4000 Location 16 connector on Green Black/ Green/ distributor Orange Black Yellow/Blue Green/Red or 4000 At Distributor or Blue/ Gray/ Orange/Black Yellow/White Orange Blue Blue/Green 4000 Location pin Diagnostic conn Yellow/ Yellow Orange Blue/Black on driver s shock tower Blue Blue/Black or 4000 Location 14 Diagnostic plug Yellow/ White/Green Green/White Green/Orange White or Yellow or Orange Orange/Black 4000 Location 5 Position 47 of ECM Green Yellow Orange Green/Orange Brown 4000 If manual transmission use clutch N/A White/Green Green/White switch Green/Orange 4000 If manual use clutch switch N/A White/Green Green/White Green/Orange 4000 if manual use clutch switch N/A White/Green Green/White Red 4000 if manual use clutch switch N/A White/Green Green/White Page 33

34 MAZDA Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal 96 Mazda Location 7 - Green pin conn. 97 Mazda Loc 7 Green 18 pin conn(independent) Location pin conn Pos 58 (or Main Harness) Mazda MVP Position IM or PCM location under passenger m n front of passenger seat Mazda Miata Loc 2 Factory cruise connector (97-98) or RF Loc 8 middle ECM connector or at speedometer conn 96 Mazda Protege & Location 8-18 pin independent conn 323 taped to main harness along floor board Mazda Protege & Location 4 - Main Harness to Computer 323 Position 58 or Mazda B Location pin conn - Pos Mazda B Location pin conn - Pos Mazda Mazda Location pin conn - Pos. 58 or Truck Pos Mazda Protege Location pin conn. Pos 58 or Mazda Tribute Location Pin conn. of PCM 4 cyl-pos cyl-pos Mazda Tribute location 13-3 connector ECM right conn. position 3 or 4 Page 34

35 MAZDA E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Green/Red 4000 Location 16 Coil White/ Green/ Green Black White Green/Red 4000 Location 16 Coil Black/White Green/White Green Gray/Lt.Blue Location pin ECM Orange/ Yellow/ White/ Pos 48 (or Main Wire Harness) Black Red Green Green/Red 4000 Position 2E of PCM Yellow Green/Red 4000 Loc 14 Diagnostic connector Black/White White/Green Green or Green/ Green/ White/Black Loc 15 diagnosis conn on fender Orange Stripe White Stripe Green/Red 4000 Location 16 6 pin conn on Blue/ Green/ Green distributor Purple White Green/Red 4000 Location 16 distributor - Purple/ Green Green/ 6 pin connector Blue Yellow Violet/Red Green Gray/Black 8000 Location pin conn Tan/ Green/ Green Position 48 Yellow Red Gray/Black 8000 Location pin conn Tan/ Green/ Green Position 48 Yellow Red Gray/Black 8000 Location pin conn Pos.48 or 78 Pink/ Green/ Green (Vacuum Reservoir ) White Red Orange 18,000 Location 4 - Position 48 of ECM Purple/White Green/Red Green Green/Red Purple/Red cyl-Blue/Yellow Location pin conn of PCM Gray/Yellow 10,000 4 cyl-pos 22 6 cyl-pos 78 Green/Red Green 6cyl-Gray/Black Red/Yellow Pos. 3- Lt Blue 10,000 If manual trans. use clutch switch N/A Green/Red Green Pos.4-Blue/Yellow 28, Page 35

36 MITSUBISHI Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Mitsubishi Eclipse Location 5 Pos.14 of 16 pin Data Link conn 97 Mitsubishi Galant Location 8-26 pin conn Position 19 Location 4-26 pin conn Position 19 At Transmission 97 Mitsubishi Mirage Location8 -White 18 pin conn Pos Location 1 Yellow 22 pin conn Pos Mitsubishi Montero Location 2-22 or 28 pin conn at ECM Sport Location 1 orange 22 pin conn of ECM pin Mitsubishi Eclipse Loc 5 Blk diagnostic connector Mitsubishi Eclipse Location 7- Diagnostic connector Mitsubishi Mirage at Transmission Mitsubishi Galant At transmission 3-Pin conn or Location 7 Data Link conn. 04 Mitsubishi Galant Loc. 5 harness to Radio or Loc7 Data Link conn Mitsubishi Lancer Location 7 - Data Link connector Mitsubishi Lancer Location 2-22 pin conn. of ECM Page 36 *RECOMMENDED PEDAL PULL ATTACHMENT FOR SAFETY REASONS

37 MITSUBISHI E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Yellow/White 4000 Location 15 top 40 pin conn Blue/ Red/ Green Position 33 Red Black Yellow/White 4000 Location 16 Distributor 6 pin conn White Green/Black Green Location 4 26 pin conn Pos. 10 Yellow/ 4000 Location 12 Tach Diagnostic conn Blue Green/ Green Silver Dots Red Yellow/White Loc 12 blue single pin conn on firewall White Yellow/White 4000 Location 16 Coil White White/ Green Location 1 26 pin conn at ECM Red Position 10 Yellow/White 4000 Location 15 Top 40 pin conn Blue/ Red/ Green White/Blue Position 33 Red Black White/Blue 4000 Same connector as VSS Black/Blue Red/Black Green/Black Yellow 4000 At coil- Ignitor Black White/Red Green Yellow/Black 4000 Location 16 Coil White Green/ Green Red Yellow/White 4000 If manual use clutch switch N/A Green/Red Green White/Black 4000 If manual transmission clutch N/A Green/ Green Blue/Black switch Red Black/Yellow 4000 If manual transmission use N/A Green/Red Green clutch switch Page 37

38 NISSAN Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal 97 Nissan 200 SX Location 5 pos. 26 of ECM Nissan 240SX Location 1 pos. 26 of ECM Nissan Altima Location 5 pos. 26 of ECM Nissan Pathfinder Location 6 pos. 26 of ECM Nissan *Pickup ` 4 cyl. Location 8 Lower left of multi-junction connector 3rd position 4 Cyl Nissan *Frontier Location 5 Pos. ECM Pickup 6 cyl positions right of bolt in ECM Nissan Quest Location 2 Pos. 26 of ECM Nissan Sentra Location 5 pos. 26 of ECM Nissan *XTerra Location 5 Pos. ECM 4 positions right of bolt in ECM 02 Nissan Sentra pin connector on Transmission Nissan *Sentra On top side of transmission Pedal pull Page 38 *RECOMMENDED PEDAL PULL ATTACHMENT FOR SAFETY REASONS

39 NISSAN E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Purple/Red 2000 Location 5 Pos 3 of ECM White Yellow/Green 2000 Position 3 of ECM Yellow/ Red/ Red/ Red Yellow Green Yellow/ Yellow/Green 2000 Position 3 of ECM Loc 5 Red/Blue/ Red/ Red/ Black Yellow Green White/Blue 2000 Location 6 Pos. 3 of ECM White Red/ Green/ Black Yellow White/Blue 2000 Location 16 Coil Blue Green/Black 2000 Location 16 2 pin Black/ Red/ Red/ Distributor Red Black Yellow Green/Yellow 2000 Location 2 - Pos. 3 of ECM Green/ Red/ Yellow/ White White Black Purple/Red 2000 Position 3 of ECM Blue/ Green/ Red/ Orange Yellow Green Green/Black 2000 Location 16 2 pin Black/ Red/ Red/ Distributor Red Black Yellow Red/Yellow 8000 If manual transmission use clutch N/A Red/Black Red/Yellow Red/Yellow 8000 If manual transmission use clutch switch N/A Red/Black Red/Yellow Page 39

40 SUBARU Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Subaru Legacy Passenger Floor-Pos. 83 of ECM Subaru Impreza Passenger Floor-Pos. 83 of ECM Passenger Floor-96 pin ECM Pos. 93 Loc3 35 pin ECM Pos Subaru Outback Passenger Floor Pos 83 of ECM Passenger Floor-96 pin conn Pos Subaru Forester Passenger Floor - 96 pin conn at ECM Position 93 Page 40 *RECOMMENDED PEDAL PULL ATTACHMENT FOR SAFETY REASONS

41 SUBARU E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Green/Black 4000 Passenger Floor Pos 64 of ECM Red Green/ White/ White Black Green/Black 4000 Passenger Floor Pos 64 of ECM Red Green/White White/Black Gray/Black Passenger Floor - 96 pin conn Blue/ White/ Blue/ Green/Yellow at ECM Pos. 64 Green Black Yellow Green/Black 4000 Passenger Floor Pos 64 of ECM Red Green/ White/ 93 pin conn White/ Black Green/Black 4000 Passenger Floor 93 pin conn at ECM Green White/ Blue/ Position 64 Black Yellow Page 41

42 SUZUKI Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Suzuki *Sidekick/ Location 8 Yellow 22 pin conn of ECM X90 Position 5 97 Suzuki *Swift Location 2 22 pin conn at ECM 98 Position 22 of Suzuki Esteem Location 2 22 pin conn at ECM Pos Location 2 16 pin conn (C-20) at ECM Pos Suzuki Esteem Location 2-35 pin conn Pos 27 Areo Suzuki Swift Location 2-16 pin conn Pos Suzuki Tracker/ Location 2-4connector ECM far right Sidekick* connector bottom row position 5 Grand Vitara Suzuki Areo Location 2-35 pin conn Pos Suzuki Forenza Location 8- ECM Green conn Pos.8 Page 42 *RECOMMENDED PEDAL PULL ATTACHMENT FOR SAFETY REASONS

43 SUZUKI E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Yellow 4000 Location 16 Distributor Brown/ Green Green/ White White Violet/White 4000 Location 16 Distributor Brown/ Green Green/ Yellow/Green White White Violet 4000 Location 16 Distributor Brown/ Green Blue/ Location 2 22 pin conn (E-92) White Yellow at ECM Pos. 6 Brown Violet 4000 Same 35 pin conn Pos. 2 Brown White/ Green/ Yellow White Yellow/Green 4000 use clutch switch N/A White/ Green/ or Violet Yellow White Blue/Yellow 4000 Same connector Pos. 4 Brown Green Green/ White Violet 4000 Same 35 pin conn Pos. 2 Brown White/ Green/ Yellow White Green/White 8000 ECM- white conn. 4th from corner Gray Orange Blue Page 43

44 TOYOTA Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Toyota 4/Runner Location 2 22 pin conn. of ECM Position 8 or Toyota Camry 2.2L Location 2 Right connector in ECM (92-96) Toyota Camry (4 cyl) Loc pin conn. of ECM Pos. 8 or 9 Top conn or 2nd from top 94 Toyota Celica 1.8L Location 4 Pos. 9 of 22 pin conn or (94-97) Position 11 of 12 pin conn 94 Toyota Celica 2.2L Location 4 Pos. 9 of 22 pin conn or (94-97) Position 11 of 12 pin conn Toyota Corolla Location 5 Gray 22 pin conn Pos 9 or Main Wiring Harness(00-01) at transmission Toyota Corolla/Matrix Location 2 - ECM 2nd connector left to right Toyota Corolla Transaxle 3 pin plug OR under coin tray (93-97) Black connector 96 Toyota Paseo Location 2 Pos. 13 of 16 pin conn in (95-96) ECM or Pos. 9 of 22 pin conn 97 Toyota Paseo Location 2 12 pin conn on ECM Pos Toyota Tacoma 4 cyl Location 2 Pos. 8 or 9 of 22 pin conn. or L Pos 12 of 28 pin conn in ECM only Toyota Tacoma V Location 2 Pos 8 or 9 of 22 pin conn. or except man. 4x4 (95-02) Pos. 12 of 28 pin conn in ECM or Location 2 28 pin conn Pos Toyota Tacoma Location 2 Pos 8 or 9 of 22 pin conn or V6 man 4x4 Pos. 12 of 28 pin conn in ECM Toyota Tercel Location 2 Pos 13 of 16 pin conn (95-96) of ECM or Pos. 9 of 22 pin conn (97-98) 95 Toyota T Location 1 Pos. 8 or 9 of 22 pin conn at cyl ECM or Pos. 12 of 28 pin conn or Pos. 11 of 12 pin conn 95 Toyota T Location 1 Pos 8 or 9 of 22 pin conn at cyl ECM or Pos. 12 of 28 pin conn Page 44

45 TOYOTA E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Green/Orange 4000 Location 2 26 pin conn of ECM Black Green/ Green/ Position 15 Red White Violet/Yellow 4000 Location 18 Coil Black Green/ Green/ Red White Yellow 4000 Location 2 26 pin conn of ECM Black Green/ Green/ Purple/White Position 15 Red White Orange 4000 Location 16 Coil Black Green/ Green/ Red White Orange 4000 Location 16 Coil Black Green/ Green/ Red White Violet/White 4000 Location 5 Gray 22 pin conn Black Red/ Green/ White/Blue Pos 8 or Location 13 White White Diagnostic conn Violet/White 4000 Location 2-31 pin connector Black Red/ Green/ of ECM, position 5 (E6) White White Red/Yellow 4000 Location 16 Coil Black Red/ Green/ White White Yellow/ 4000 Location 13 - Ignitor Black/ Silver Band Blue Yellow/ 4000 Location 13 - Ignitor Black/ Green/ Green/ Silver Dots Blue Red White Green/Orange 4000 Location 17 Ignitor on Fenderwell Black Green/ Green/ Location 2 26 pin conn - Pos. 15 Red White Green/Orange 4000 Location 17 Ignitor on Fenderwell Black Green/ Green/ Red White Green/Orange 4000 Location 17 Ignitor on Fenderwell Black Green/ Green/ Red White Yellow/ 4000 Location 13 - Ignitor Black/ Green/ Green/ Silver Dots Blue Red White Green 4000 Location 17 Passenger side Black Green/ Green/ fenderwell, Ignitor Red White Location 14 coil Green 4000 Location 17 Passenger side Black Green/ Green/ fenderwell, Ignitor Red White Page 45

46 TOYOTA Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal Toyota Rav Location 9 22 pin conn on ECM Pos Toyota Tundra Location 2-22 or 28 Pin conn. of ECM Toyota Echo Location 7 - Back of knee panel connector from top 04 Toyota Scion xb Location2-4 plug ECM 2nd conn. left to custom kit Right VOLKSWAGEN Vehicle A B C D Year Vehicle Vehicle Model & Control Switch/ Cruise Control Gray Wire Manufacturer Engine Size Throttle Adapter Attachment For VSS SIgnal 96 Volkswagen Golf Location 13 Wire Connector on Transaxle 96 Volkswagen Jetta Location 13 Wire Connector on Transaxle Page 46

47 TOYOTA E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative Violet/White 4000 Location 13 - Ignitor Black Green/ Green/ Red White Green/Orange 4000 Location 17 - Ignitor on fenderwell Black Green/ Green/ Red White Violet/White 4000 Location 7 - Diagnostic connector Black Green/ Green/ at bottom of Dash Red White Violet/White 4000 Location 2 - ECM Black Green/Red Green/ E4 connector pin 8 White VOLKSWAGEN E F G H I J Vehicle VSS VSS Cruise Control Blue Wire Vehicle Brake Brake Wire Color Pulses Attachment For Tach Signal Tach Switch Switch Wire Color Positive Negative White/Blue 8000 Location 16 Ignitor Black/ Red/ Red/ Red Yellow Black White/Blue 8000 Location 16 Ignitor Black/ Red/ Red/ on Fenderwell Red Yellow Black Page 47

48 Rostra Precision Controls, Inc. Automotive Electronics Group 2519 Dana Drive Laurinburg, NC Tech Service: (800) Fax: (910) Fax Back System: (910) Certified QS 9000/ISO 9001 Made in the U.S.A.