P/N D). T.A. Pelsue Company

Transcription

1 P/N D 13253D) : 5.0 :

2 PELSUE 16903D , Pelsue 16903D,., D PSI, 1,03-3,5. 2.0!,,,,,,.!,,.,,,.,,,,,.! 2.01,,.,. 2.02, ANSI/NFPA CAN/CGA-B ,, ANSI/NFPA CAN/CGA-b149.2,, ,,, UL Pelsue,

3 2.06,, (15 50 PSI, 1,03-3,5 ).,, ,.,. 2.08,., 9,4. 1,8., ,, ,.,. 2.11,., Pelsue ,, , ,

4 2.18,,. 2.19, ,.. 5, ANSI/NFPA CAN/CGA-B ,,,. 3.03,., , : T.A. Pelsue Service Department 2500 South Tejon Street Englewood, Colorado : : (303) sales@pelsue.com 4.0 : Pelsue 16903D..,,..,,,, ( ),,,

5 4.01, , 40, : 34,9 : 46,9 : 38,74 : 13, : : 16903D : 220, 50 : 0,5 : BTUH (17640 ) : 100 F (56 C) :,. BS4343, IEC309 CEE D : 230, : 5.01 : ( ),. :,,,., : 115/230 12, 12., : 5.04 :,.,,. 30. : 3,2 ± 0,8., :., 5.06 :.,

6 5.07 : 0,0261. ; :..,,, «OFF» :, :,., 6,8 ),., : : «2.0».., «OFF» D 16903D..,..., PSI (1,03 3,4 ) A ,3 4,6....,,

7 6.03, , 40, «OFF» :,.. 1). ) ( ). ) ( ). 2). 3). 4),. 5). 6) 3 4,. ) ( ). ). ). ). ). ). ). ). ). ). ). ). ). ). ). ). ). ). ) ). ),. ). ). ). ). ). ). ). ) 0,0261 ). ) ). ). ),.. ). ). )

8 7. # 16903D

9 D, , 40, Base 1690D Heater 1690D) Housing 1690D Heater 1690D) Panel Component Wall, 1690D Heater, D) Ring Inner Intake, ) Ring Inner, Outlet, ) Control Panel 1690D Heater 1690D) Heat Shield, View Port Side ( ) Heat Shield, Component Wall Side ( ) Top 1690D Heater 1690D) Hinge Control Box Cover ) Cover Control Panel ) Tubing Rubber, 7/32 Nom. ) Z Tubing RD, ¼ OD. Copper ) Door Control Box Access ) Chimney D Heater 1690D) Handle Cloth Reinforced Neoprene,, 1 ) Outlet Grille ( ) Sight Glass Retainer ) Sight Glass ) Heater Exchanger w/ Air Collector 1 ) Burner Manifold, As Machined ( ) Orifice No. 56, 1/8 NPT ) E Plug Snap-In-Blank.875 Dia ( ) Fitting Street Elbow, ¼ NPT ( ) E Rubber Grommet ½ ID ) E Valve Solenoid, 12V DC 12 ) G Regulator Propane ) Fitting Street Elbow, 3/8 NPT ) Fitting Brass Bushing 3/8 MNPT x 1/8 FNPT, ) Fitting Brass Nipple, ¼ MNPT x 2 Long, ) Fitting ¼ OD Tube Compression x 1/8 MNPT, ) F Fitting Female Tee 1/8 FNPT, ) Fitting Plug, Hex Head, 1/8 NPT, 1 ) Flat Washer #8, Plated ) Nipple 1/8 x 3-1/2 Long ) Cover Plate ) Strain Relief ) Cord 14/3 Wire, 12 long ) Switch Rocker, 125/250VAC,125/250 ) Fuse Holder ( ) Fuse 1 AMP - 1 A) Circuit Board, 12V DC, 12 ) E Cable Assembly Circuit Board ( ) Transformer, 220VAC Prime, 12VAC Sec., 220 /12 1 ) Switch Air Pressure ) Switch Thermal, Open 250, Close 210, 1 250, 210) Access Plate Thermostat ( ) E Rubber Grommet, ¼ ID ( )

10 51 32F Fitting Adapter, 9/16 LH Thread x ¼ MNPT ( ) Rectifier Bridge ) Dust Cap W/ Retainer, Yellow (, 1 ) Lead High Tension, Spark Ignition, 1 ) Hex Locknut, #8-32 ) I Hose Assembly, LPG ¼ x 10 ) Baffle Burner Manifold ( ) Rubber Foot 1-1/2 OD ) Q Washer Neoprene, 5/16 ID x 1-1/2 OD ( ) Igniter Spark/Flame Sensor ( / ) Gasket Spark Igniter ) N Lock Washer, Star #8 ( ) Rivet Stainless Steel, 3/16 Dia. x.125 Grip 2 ) Rivet Stavex, Black Stavex, ) N Screw, 8-32 UNC x 3/8, Truss Head ) N Screw, 8-32 UNC x ¾, Truss Head ) Screw, ¼ -20 UNC x ¾ ( ) Flat Washer ¼ ) Locknut ¼-20 UNC ) Screw - #4 40 UNC x 3/8 ( ) Washer Lock #4 Star ) Hex Lock Nut - #4-40 ) Washer Fender, #10 Plated ( ) Washer Flat #10, Type A Plated ( ) Screw UNC x ½ Black (, ) Locknut Nylon Insert, Black, 2 ) Fitting Brass Bushing ¼ MNPT x 1/8 MNPT (, ) Screw - #8-32 x 3/8 Lg Black (, ) Screw Sheet Metal, #8 x 3/8 black, 7 ) Decal Wiring Diagram, 16903D Heater ( D) Pilot Tube with Bracket ( ) Decal Warning, Unit Usage 1590/1690D Heaters - 1, 1590/1690D) Decal Serial & Rating 1 ) Decal Warning Hazardous Conditions - 1 ) Decal Warning General Hazards 1 ) Decal Electrical Grounding Instructions 1 ) Screen Air Collector - ) Heat Shield Top ) Screw, #6 x 3/8 Lg, Self Tapping, Hex Head ( 2 ) Sight Glass ) N Lock Washer ¼ Star ( ) Screw ¼-20 x ½ Lg Hex Head ) Decal Prior To Ignition )

11 D

12 :, , 40, Schematic 220 VAC 220 Primary, 220 VAC, 220 Secondary, 12 VAC, VAC 12 Power Valve Sense Ground Hi Volt Point to point Top Panel Power Switch Fuse 1 A 1 Control Box Fuel Solenoid Valve Thermal switch Burner Ignition Module Power Valve Sense Ground Hi Volt Ground Stud Pressure switch NO/Comm Quick Disconnect Jumper Control Transformer Main Housing Ground 220 VAC, 50 Hz 220, 50, ( ) Heater Compartment Ignitor Burner Element Sensor Heat exchanger : BE: ( ) BIM: FI: FV: I: S1: TSH: ( ) PSL: ( ) 1: BR: : 1., CSA: 9, 10, 12, 13 14GA TFE, 150, 7, GA, GA

13

14 Pelsue 1590-F 1557, 1590, S ) : Connect POL Regulator Pressure Gauge Tank Valve Propane hose LP Tank POL Fitting 1012 Filter Connect hose to 1590-F Connect hose to Propane inlet POL ). ( 40 PSI). ( ) POL, 1012 ( ) 1590-F. ( )..,, 40 PSI..,,, Pelsue

15

16 Pelsue 1590-F 1557, 1590, S ) : Filter Regulator Gauge Bushing To Propane Tank POL Fitting POL,,, LH Adapter Hose to appliance Nipple Tee