Normative Document list Gas 6 th June 2008

Transcription

1 Statutory Regulations Normative Document list Gas 6 th June 2008 Health and Safety at Work etc Act 1974 Management of Health and Safety Work etc Act The Gas Safety (Installation & Use) Regulations Gas Safety (Installation & Use) Regulations (Northern Ireland) 1997 (Under review) Gas Safety (Installation & Use) Regulations 1994 (as amended for the Isle of Man) Gas Safety (Installation, Use and Powers of Entry) Ordinance Guernsey The Gas Safety (Management) Regulations 1996 (Under review) Building Regulations (England & Wales) 1991(amended 2002) The Building (Amendment) Regulations 2008 The Building and Approved Inspectors (Amendment) Regulations 2007 Building Standards (Scotland) Regulations 1990 (amended 2002) Building Regulations (Northern Ireland) 2000 Approved Documents to the Building Regulations (England & Wales) B: Fire Safety Volume 1: Dwellinghouses B: Fire Safety Volume 2 - Buildings other than dwellinghouses F: Ventilation J: Combustion Appliances and Fuel Storage Systems L1A: Conservation of fuel and power (New dwellings) L1B: Conservation of fuel and power (Existing dwellings) L2A: Conservation of fuel and power (New buildings other than dwellings) L2B: Conservation of fuel and power (Existing buildings other than dwellings) P: Electrical safety Other documents Building Regulations (England & Wales) Domestic Heating Compliance Guide Non-Domestic Heating, Cooling and Ventilation Compliance Guide Code for Sustainable Homes Note: All of the above Building Regulation documents are available as a free download by visiting Approved Documents to the Building Regulations (Northern Ireland) E-Fire Safety F-Conservation of Fuel and Power K-Ventilation L-Heat Producing Appliances and Liquefied Petroleum Gas Installations P-Sanitary Appliances and Unvented Hot Water Storage Systems Note: All of the above Building Regulation technical booklets are available as a free download by visiting Approved Documents to the Building Standards (Scotland) Regulations Section 2-Fire Section 6-Energy-6.3 heating system Section 3-Enviroment-3.14 ventilation Note: All of the above Technical handbook documents are available as a free download by visiting Page 1 06/06/08

2 Approved Documents to the Building Regulations Isle of Man (IOM) B-Fire Safety F-Ventilation J-Combustion Appliances and Fuel Storage Systems L1-Conservation of Fuel and Power in Dwellings L2-Conservation of Fuel and Power in Buildings other then Dwellings P-Electrical safety Note: The link below takes you to The Department of Local Government and the Environment for the IOM where information on the requirements of Approved documents can be obtained. HSC Publications COP20 - Standards of Training in Safe Gas Installation Approved Code of Practice L21 - Management of Health and Safety at Work L25 - Personal Protective Equipment at Work L27 - The Control of Asbestos at Work L56 - Safety in the Installation and use of Gas Systems and Appliances L73 - A guide to the Reporting of Injuries, Diseases and Dangerous Occurrences Regulations L80 - A guide to the Gas Safety (Management) Regulations HSG65 - Successful Health and Safety Management HSG85 - Electricity at Work HSG137 - Health Risk Management HSG193 - COSHH Essentials HSG210 - Asbestos Essentials (task manual) HSG213 - Asbestos Essentials CS4 - The Keeping of LPG Cylinders and Similar Containers CS11 - The Storage and Use of LPG at Metered Estates EH40 - Occupational Exposure Limits European and British Standards BS 669: Part 1:1989 Specification for strip-wound metallic flexible hoses, covers, end fittings and sockets for domestic appliances burning 1st, 2nd and 3rd family gases BS 669: Part 2:1997 Specification for corrugated metallic flexible hoses, covers, end fittings and sockets for catering appliances burning 1st, 2nd and 3rd family gases. BS 715: 2005 Specification for metal flue boxes for gas-fired appliances not exceeding 20 kw. BS : 1980 Glossary of terms used in the gas industry. Combustion and utilization including installation at consumers' premises BS 1552: 1995 Specification for open bottomed taper plug valves for 1st, 2nd and 3rd family gases up to 200 mbar. BS 3212: 1991 Flexible rubber tubing, rubber hoses and rubber hose assemblies for use in LPG vapour phase and LPG/air installations BS : 2008 Flueing and ventilation for gas appliances of rated input not exceeding 70kW net (1st, 2nd and 3rd family gases) Specification for installation of gas appliances to chimneys and for maintenance of chimneys Page 2 06/06/08

3 BS : 2000 Installation and maintenance of flues and ventilation for gas appliances of rated input not exceeding 70 kw net (1st, 2nd and 3rd family gases). Specification for installation and maintenance of ventilation for gas appliances (Amendment No 1 - November 2001 and Amendment No 2 - July 2004) BS 5546: Specification for installation of hot water supplies for domestic purposes, using gas-fired appliances of rated input not exceeding 70 kw (Amendment No 1 October 2005) BS 5449: 1990 Specification for forced circulation hot water central heating systems for domestic premises. Amd. March 02. (Partially replaced by BS EN 12828: 2003 and BS EN 12831: 2003) BS : 2005 Code of practice for domestic butane and propane-gas-burning- Domestic butane- and propane-gas-burning installations. Installations at permanent dwellings, residential park homes and commercial premises, with installation pipework sizes not exceeding DN 25 for steel and DN 28 for corrugated stainless steel or copper BS 5482 Part 2: 1977 Installation in caravans and non-permanent dwellings (Amd May 2001) (under review) BS 5482 Part 3: 1999 Installations in boats, yachts and other vessels Superseded /obsolescent) see BS EN PD : 2005 Code of practice for domestic butane and propane gas-burning installations. Installations in boats, yachts and other vessels BS 3632: 2005 Residential park homes. Specification BS 5864: 2004 Installation and maintenance of gas-fired ducted air heaters of rated input not exceeding 70 kw net (2nd and 3rd family gases). Specification BS : 2005 Specification for installation and maintenance of gas fires, convector heaters, fire/back boilers and decorative fuel effect gas appliances Gas fires, convector heaters, fire/back boilers and heating stoves (1st, 2nd and 3rd family gases) BS : 2005 Specification for installation and maintenance of gas fires, convector heaters, fire/back boilers and decorative fuel effect gas appliances Inset live fuel effect gas fires of heat input not exceeding 15kW, and fire/back boilers (2nd and 3rd family gases) BS : 2005 Specification for installation and maintenance of gas fires, convector heaters, fire/back boilers and decorative fuel effect gas appliances Decorative fuel effect gas appliances of heat input not exceeding 20kW (net) (2nd and 3rd family gases) BS : 2007 Specification for installation and maintenance of gas fires, convector heaters, fire/back boilers and decorative fuel effect gas appliances Independent gas-fired flueless fires, convector heaters and heating stoves of nominal heat input not exceeding 6kW (net) (2nd and 3rd family gases) BS 6172: 2004 Specification for installation of domestic gas cooking appliances. (2nd and 3rd family gases) BS 6173: 2001 Incorporating Corrigendum No.1 and Amendment no.1 Specification for installation of gas-fired catering appliances for use in all types of catering establishments (2nd and 3rd family gases) (under review) BS 6230: 2005 Specification for installation of gas-fired forced convection air heaters for commercial and industrial space heating (2nd and 3rd family gases) BS : 2006 Specification for installation, exchange, relocation and removal of gas meters with a maximum capacity not exceeding 6m 3- h Part 1 Low pressure (2 nd family gases) Page 3 06/06/08

4 BS : 2006 Specification for installation, exchange, relocation and removal of gas meters with a maximum capacity not exceeding 6m 3- h (2 nd and 3 rd family gases) Part 2 Medium pressure (2 nd family gases) BS : 2007 Specification for installation, exchange, relocation and removal of gas meters with a maximum capacity not exceeding 6m 3 /h Part 3: Low and medium pressure (3rd family gases) BS 6644: 2005 Specification for Installation of gas-fired hot water boilers of rated inputs between 70 kw (net) and 1.8 MW (net) (2nd and 3rd family gases) (Under review) BS 6798: 2000 Specification for installation of gas-fired boilers of rated input not exceeding 70 kw net (Under review) BS 6891: A2: 2008 Incorporating Corrigendum No. 1 Installation of low pressure gas pipework of up to 35 mm (R1¼) in domestic premises (2nd family gas). Specification BS 6896: 2005 Specification for installation of gas-fired overhead radiant heaters for industrial and commercial heating (2nd and 3rd family gases) BS :1992 Jointing materials and compounds. Specification for jointing compounds for use with water, low pressure saturated steam, 1st family gases (excluding coal gas) and 2nd family gases BS 7624: 2004 Specification for installation and maintenance of domestic direct gas-fired tumble dryers of up to 6kW heat input (2nd and 3rd family gases). BS 7671: 2001 Requirements for electrical installations. IEE Wiring Regulations - Sixteenth edition - AMD February 2002 and This Standard will be withdrawn 1 st July BS 7671: 2008 Requirements for electrical installations. IEE Wiring Regulations - Seventeenth edition Comes into effect 1 st July BS : 2005 Carbon monoxide in dwellings and the combustion performance of gas-fired appliances Guide for identifying and managing sources of fumes, smells, spillage/leakage of combustion products and carbon monoxide detector activation BS : 2005 Carbon monoxide in dwellings and the combustion performance of gas-fired appliances Guide for using electronic portable combustion gas analysers in the measurement of carbon monoxide and the determination of combustion performance (Amendment awaited) BS : 2005 Carbon monoxide in dwellings and the combustion performance of gas-fired appliances Guide for responding to measurements obtained from electronic portable combustion gas analysers BS : 2007 Carbon monoxide in dwellings and the combustion performance of gas-fired appliances Guide for using electronic portable combustion gas analysers as part of the servicing and maintenance of gas-fired appliances BS 8313: 1997 Code of practice for accommodation of building services in ducts BS 8446: 2005 Specification for the installation and maintenance of open-flued, non-domestic gas-fired laundry appliances BS EN 416-1:1999 Single burner gas-fired overhead radiant-tube heaters BS EN 721: 2004 Leisure accommodation vehicles Safety ventilation requirements BS EN 751-1:1997 Sealing materials for metallic threaded joints in contact with 1st, 2nd and 3rd family gases and hot water. Anaerobic jointing compounds Page 4 06/06/08

5 BS EN 751-2:1997 Sealing materials for metallic threaded joints in contact with 1st, 2nd and 3rd family gases and hot water. Non-hardening jointing compounds BS EN 751-3:1997 Sealing materials for metallic threaded joints in contact with 1st, 2nd and 3rd family gases and hot water. Unsintered PTFE tapes BS EN 777-1: 1999 Multi-burner gas-fired overhead radiant tube heater system for nondomestic use System D, Safety (Amd December 02) BS EN 777-2: 1999 Multi-burner gas-fired overhead radiant tube heater system for nondomestic use System E, Safety (Amd September 02) BS EN 777-3: 2000 Multi-burner gas-fired overhead radiant tube heater system for nondomestic use System F, Safety (Amd September 02) BS EN 777-4: 1999 Multi-burner gas-fired overhead radiant tube heater system for nondomestic use System H, Safety (Amd September 02) BS EN 778:1998 Domestic gas-fired forced convection air heaters not exceeding 300kW (Amd May 02) BS EN 1020:1998 Non-domestic gas-fired forced convection heaters not exceeding 300kW (Amd May 02) BS EN 1057: 2006 Copper and copper alloys - Seamless, round copper tubes for water and gas in sanitary and heating applications BS EN 1319:1999 Domestic gas-fired forced convection air heaters for space heating with fanassisted burners not exceeding a net heat input of 70kW (Amd August 02) BS EN :1999 Leisure accommodation vehicles-caravans (Amd May 02) BS EN 1647: 2004 Leisure accommodation vehicles-caravan holiday homes (Amd May 02) BS EN 1762: 2003 Rubber hoses and hose assemblies for liquefied petroleum gas, LPG (liquid or gaseous phase) and natural gas up to 25bar (2.5 Mpa) - Partially replaced by BS EN 12828: 2003 and BS EN 12831: BS EN : 2003 Chimneys. Requirements for metal chimneys - System chimney products BS EN : 2004 Chimneys. Requirements for metal chimneys - Metal liners and connecting flue pipes BS EN 1949: 2002 Specification for the installation of LPG systems for habitation purposes in leisure accommodation vehicles and in other road vehicles BS EN ISO 10239: 2000 Small craft - Liquefied petroleum gas (LPG) systems (Amd February 2002) BS EN 12828: 2003 Heating systems in buildings- Design for water-based heating systems. (Partially replaces BS ) BS EN 12831: 2003 Heating Systems in buildings-method for the calculation of the design heat load. (Partially replaces BS ) BS EN 13410: 2001 Gas-fired overhead radiant heaters - Ventilation requirements for nondomestic premises. (Amd. Jan 03) PD CEN/TR 1749: 2005 European scheme for the classification of gas appliances according to the method of evacuation of the products of combustion Page 5 06/06/08

6 Institution of Gas Engineers and Managers Documents (IGEM) IGE/UP/1- Edition 2: Strength and tightness testing and purging of industrial and commercial gas installations IGE/UP/1A - Edition 2: Strength testing, tightness testing and direct purging of small low pressure industrial and commercial Natural gas installations IGE/UP/1B - Edition 2: Tightness testing and direct purging of small Natural gas installations IGE/UP/2 - Edition 2: Installation pipework on industrial and commercial premises IGE/UP/3 - Edition 2: Gas fuelled spark ignition and dual fuel engines. IGE/UP/4 - Edition 2: Commissioning of gas fired plant on industrial and commercial premises. IGE/UP/6 - Application of positive displacement compressors to Natural gas fuel systems. IGE/UP/7 - Edition 2: Gas installations in timber framed and light steel framed buildings. Note: The Master copy of IGE/UP/7 Edition 2 is held in the Technical Services Library at CORGI headquarters and is free to view online at the following URL: Comm_1722_.pdf IGE/UP/8 - Gas in caravans, holiday homes and boats (Edition 2 awaited) IGE/UP/9 Edition 2 - Gas turbines IGE/UP/10 - Edition 3: Installation of flued gas appliances in industrial and commercial premises. IGE/UP/11 - Gas in educational establishments IGE/UP/12 - Gas fired process plant IGE/GL/3 - Gas supply emergency procedures IGE/GL/8 - Edition 2 - Reporting and investigating incidents IGE/GL/9 - Dealing with natural gas supply emergencies for large customers IGE/TD/4 - Edition 4: Gas Services (under review) IGE/G/1- Defining the end of the network, meter installation etc IGE/G/5 - Gas in flats and other multi-dwelling buildings (Amended January 2008) IGE/GM/1- Part 1 Non-domestic meter installations Flow rate exceeding 6 m 3 h-1 and inlet pressure not exceeding 38 bar Design IGE/GM/1 - Gas meter installations for pressures not exceeding 100bar. (Under revision by IGEM) IGE/GM/4 - Edition 2 - Flow metering practice for pressures between 38 and 100bar IGE/GM/5 - Edition 2 - Selection, installation and use of electronic gas meter volume conversion systems (Edition 3 awaited) IGE/GM/6 - Specification for low pressure diaphragm and rotary displacement meter installations with badged meter capacities exceeding 6m 3 /h (212ft 3 /h) but not exceeding 1076m 3 /h (38000ft 3 /h) (Edition 2 awaited) IGE/GM/7 - Edition 2: Electrical connections and hazardous area classification for gas metering equipment (Edition 3 awaited) Page 6 06/06/08

7 IGE/GM/8 Part 1: Non-domestic meter installations. Flow rate exceeding 6 m 3 h-1 and inlet pressure not exceeding 38 bar Design IGE/GM/8 Part 2: Locations, housings and compounds IGE/GM/8 - Part 3: Installation and commissioning IGE/GM/8 - Part 4: Operation and maintenance IGE/GM/8 Part 5: Notices and labels IGE/SR/20 - Dealing with reported gas escapes. IGE/SR/24 - Risk Assessment Techniques British Gas Technical Publications Relating to the use of gas in Industrial and Commercial Premises (available from the IGEM) IM/1 - Guidance notes on the use of oxygen in industrial gas fired plant and working flame burners - 3rd edition (2nd impression) IM/9 - Code of practice for the use of gas in atmosphere gas generators and associated plant - 1st edition Part 1: Exothermic atmosphere gas generators. Part 2: Endothermic atmosphere gas in associated plant. Part 3: Use of generated atmosphere in associated plant. IM/20 - Weep by-pass pressure proving systems - 1st edition IM/28 - Appliances in commercial garages -1st edition IM/30 - Code of practice for gas fired process plant - 1st edition UKLPG (Formally the LP Gas Association (LPGA)) Codes of Practice COP1 - Bulk LPG storage at fixed installations. Part 1: Design and installation. Part 2: Small bulk installations for domestic purposes. Part 4: Buried/mounded LPG storage vessels (Amd Sept 01) COP 7 - Storage of full and empty LPG cylinders and cartridges COP17 - Purging LPG vessels and systems. COP21 - Guidelines for caravan ventilation and flueing checks (Amd Aug 2000). COP22 - LPG Piping system design and installation. COP24 - Use of LPG Cylinders. Part 1: Propane cylinders in residential premises. Part 2: Butane cylinders in residential premises. Part 3: LPG cylinders in mobile catering vehicles, service vehicles and similar commercial units (in preparation). Part 4: Use of LPG for catering and outdoor functions Part 6: Use of Propane in cylinders at Commercial and Industrial premises. Page 7 06/06/08

8 COP25 - LPG Central storage and distribution systems for multiple consumers. GN2 - A guide to servicing cabinet heaters (March 2002) TM 46 - LPG installations for grain dryers TM 70 - Storage and dispensing of LPG at Automotive fuel at petrol stations TM 74 - Final Connections to Caravans or Mobile Homes connected to LPG Central Storage and Distribution Systems for Multiple Consumers TM 78 - Separation distances between LPG cylinders and tanks and domestic oil tanks. TM 83 - Gas soundness testing of LPG service pipework, installation pipework and appliances in holiday homes, caravans and motor homes Heating and Ventilating Contractors' Association DW/172 - Standard for Kitchen Ventilation Systems. CORGI Publications Gas Installer Manual Series Domestic GID1- Essential Gas Safety (4 th Edition) GID2 - Gas Cookers and Ranges (2 nd Edition 2 nd revised) GID3 - Gas Fires and Space Heaters (2 nd Edition - revised) GID4 - Laundry, Leisure and Refrigerators (2 nd Edition - revised) GID5 - Water Heaters (1 st Edition 2 nd revised) GID6 - Gas Meters (1 st Edition - revised) GID7 - Central Heating - Wet and Dry (3 rd Edition) GID8 - Gas Installations in Timber/Light Steel Frame Buildings (2 nd Edition) GID9 - LPG - including Caravans and Boats (3 rd Edition) GID10 The complete Domestic Manual Series listed above GID11 Using Portable Electronic Combustion Gas Analysers for Investigating Reports of Fumes GID12 - Using Portable Electronic Combustion Gas Analysers Servicing and Maintenance ND1 - Essential Gas Safety Non-Domestic (2 nd Edition) ND2 - Commercial Catering and Laundry Non-Domestic (1 st Edition) Pocket Guides USP1 - The Gas Industry Unsafe Situations Procedure (4 th Edition) (Currently under review) SRB1 - Ventilation Slide Rule Booklet (3 rd Edition - revised) Page 8 06/06/08

9 GRB1- Gas Rating Slide Rule Natural Gas Domestic (2 nd Edition) TTG1 - Terminals & Terminations (3 rd Edition) TTP1 - Tightness Testing and Purging (2 nd Edition - revised) FFG1 - Fault Finding Guide (1 st Edition - revised) FFG2 - Fault Finding Manual - Domestic wet central heating-hot water systems Other CORGI publications ES1 - Essential Electrical Safety 1 st Edition) CRPB - Electrical Component Exchange Pocket Guide EEM1 - Ground Source Heat Pumps ITWS1 - Inspection and Testing of Domestic Central Heating Wiring Systems CDP1 - Commissioning Of Water Pipework - Domestic CORGI Learning Aids TWB1 - Gas Safety Domestic (CCN1) Workbook TWB2 - Domestic gas-fired central heating/hot water boilers and circulators up to 70kW (CEN1) Workbook TWB3 - Domestic gas-fired cooking appliances (CKR1) Workbook TWB4 - Domestic gas fires and wall heaters (HTR1) Workbook TWB5 - Domestic gas water heating appliances (WAT1) Workbook TWB6 - Gas Safety for Non Domestic heating (COCN1) Workbook TWB7 - Domestic combustion performance analysis on gas-fired appliances (CPA1) Workbook Forms CP1- Gas Safety Record CP2 Leisure Industry Landlord s Gas Safety Record CP3Form Chimney/Flue/Fireplace and Hearth Commissioning Record CP4 - Gas Safety Inspection Form CP6 - Services/Maintenance Check List CP7 - Central Heating Survey Form CP12 - Landlord/Home Owner Gas Safety Record CP14 - Warning/Advice Notice CP15 - Plant Commissioning/Servicing Record Page 9 06/06/08

10 CP16 - Gas Testing and Purging Form CP17 - Gas Installation Safety Report CP18 - Estimate of Works Report CP19 - Invoice Pad CP20 - Central Heating Commissioning/Inspection Record CP21 - Condensing Boiler Installation Assessment Form CP22 - Minor Electrical Installation Works Certificate CP23 - Domestic Electrical Installation Certificate CP24 - Electrical Safety warning/advice Notice CP25 - Maintenance Work Record CP26 - Fumes Investigation Report CP27 - Domestic Period Inspection Report CP28 - Faulty Equipment Register CP29 - Portable Appliance Testing Report CP31 - Repaired Equipment Register CP32 - Gas Testing and Purging Domestic Form CP33 - Commissioning of Water Pipework Form CP34 - Central Heating Cleansing Record CP35 - Electrical Control Wiring Certificate CP36 - Customer Complaint Form CP37 - Test Equipment Check Record CP38 - Gas Fired Home Heating Installations Energy Efficiency Checklist CP39 - Commercial Heating Installations Energy Efficiency Checklist CP40 - Bathroom Quality Checklist CP41 - Combined Pressure Test Record Sheet RP1 - RIDDOR (F2508G2) Miscellaneous BGMAG ASPECT CORGI edition annual subscription (replaces GIBS1 - Gas Industry Bulletin Services (GIBS)) BH1- Installing and Servicing Domestic Central Heating Wiring Systems and Controls Page 10 06/06/08

11 DHG - Domestic Heating Design Guide Electrical Publications IEE Publications IEE on-site guide BS 7671: 2001 (2004) IEE Electricians guide to the Building Regulations. Page 11 06/06/08