Process Safety Management of Highly Hazardous & Explosive Chemicals. Application, Exclusions & Definitions
|
|
- Austin Wiggins
- 7 years ago
- Views:
Transcription
1 Process Safety Management of Highly Hazardous & Explosive Chemicals Application, Exclusions & Definitions
2 Application (a)(i) A process which involves a chemical at or above the specified threshold quantities listed in Appendix A to this section
3 Application (a)(ii) A process which involves a flammable liquid or gas (as defined in (c) of this part) on site in one location, in a quantity of 10,000 pounds ( kg)
4 What Facilities are Covered What Facilities are Covered Those Who Use Chemicals in Appendix A: A List of highly hazardous chemicals, toxics and reactive (Mandatory). Contains a listing of 137 toxic and reactive highly hazardous chemicals which present a potential for a catastrophic event at or above the threshold quantity Examples Chemical Threshold Quantity (TQ) Anhydrous Ammonia 10,000 lbs Chlorine 1,500 lbs Hydrogen Sulfide 1,500 lbs Phosgene 100 lbs Sarin 100 lbs
5 What Facilities are Covered Important Interpretation: /11/ OSHA defines "on-site in one location" for Process Safety Management of Highly Hazardous Chemicals standard OSHA interprets "on-site in one location" to mean that the standard applies when a threshold quantity of a highly hazardous chemical (HHC) exists within an area under the control of an employer or group of affiliated employers. It also applies to any group of vessels that are interconnected, or in separate vessels that are close enough in proximity that the HHC could be involved in a potential catastrophic release.
6 What Facilities are Covered Important Interpretation: 02/01/ PSM applicability to warehousing flammable liquids and other HHCs A company has a warehouse for the storage and distribution of laboratory grade chemicals such as flammable liquids and formaldehyde. The company storage and distribution operation does not include any processing, dispensing, mixing, stirring, agitation, blending, filtering, evaporating, or drying. PSM-covered highly hazardous chemical(s) (HHC) exists in your warehouse/process. You listed two HHCs that are covered by PSM: formaldehyde and flammable liquids. If other HHCs exist in the warehouse/process, they too would be a basis for establishing a PSMcovered process However, when an HHC is stored in one or more cans, packages, containers, tanks, vessels, etc., the amount is aggregated if a single event such as a fire, explosion, incompatible chemical reaction, etc. could result in a release of HHC. For example, if a fire could consume an entire warehouse all the HHCs would be aggregated as either flammable liquids, flammable gasses, or by specific Appendix A chemical listing, where applicable.
7 What Types of Industries? What Types of Industries? Industries that Process Chemicals Such As: Industrial Organics & Inorganics Paints Pharmaceuticals Adhesives Sealants and Fibers Petrochemical facilities Paper Mills (typically four covered processes) Food Processing with Anhydrous Ammonia over the TQ (10,000 lbs)
8 Exclusions (a)(1)(ii)(A) Hydrocarbon fuels used solely for workplace consumption as a fuel (e.g., propane used for comfort heating, gasoline for vehicle refueling), if such fuels are not a part of a process containing another highly hazardous chemical covered by this standard
9 Exclusions (a)(2)(ii) Retail facilities; Oil or gas well drilling or servicing operations; or, Normally unoccupied remote facilities
10 What Facilities are Covered Affect of the Meer Meer Decision: MEER ruling and the MEER Memorandum addressed in the Secretary's letter, OSHA's enforcement policy that the Agency would not cite employers for violations of where stored flammable liquids in atmospheric tanks were connected to a process, unless the process outside of the amount in storage contained more than 10,000 pounds of the substance
11 Definitions (b)
12 Definitions Atmospheric tank means a storage tank which has been designed to operate at pressures from atmospheric through 0.5 p.s.i.g. (pounds per square inch gauge, 3.45 Kpa). Boiling point means the boiling point of a liquid at a pressure of 14.7 pounds per square inch absolute (p.s.i.a.) (760 mm.). Catastrophic release means a major uncontrolled emission, fire, or explosion, involving one or more highly hazardous chemicals, that presents serious danger to employees in the workplace.
13 Definitions Facility means the buildings, containers or equipment which contain a process. Highly hazardous chemical means a substance possessing toxic, reactive, flammable, or explosive properties and specified by paragraph (a)(1) of this section. Hot work means work involving electric or gas welding, cutting, brazing, or similar flame or sparkproducing operations. Normally unoccupied remote facility means a facility which is operated, maintained or serviced by employees who visit the facility only periodically to check its operation and to perform necessary operating or maintenance tasks. No employees are permanently stationed at the facility.
14 Definitions Process means any activity involving a highly hazardous chemical including any use, storage, manufacturing, handling, or the on-site movement of such chemicals, or combination of these activities. For purposes of this definition, any group of vessels which are interconnected and separate vessels which are located such that a highly hazardous chemical could be involved in a potential release shall be considered a single process. Replacement in kind" means a replacement which satisfies the design specification. "Trade secret" means any confidential formula, pattern, process, device, information or compilation of information that is used in an employer's business
15 Determining Application Determining Application Determine: Chemicals in Your Process Process Chemistry Quantity of Chemicals in lbs Compare to Appendix A List with Threshold Quantities (TQ s)
16 Determining Application How to Calculate from Gallons to lbs? Multiply the gallons of Liquid x 8.33 (How much a gallon of water weighs) x Specific Gravity of Liquid = lbs of Liquid Example: Wt of 10,000 gallons of gasoline 10,000 x 8.33 x = 61,559 lbs
17 NASA High Pressure Gas Plant - Hydrogen Plant Application & Exclusions Case Study Team Exercise
18 Hydrogen Facts Hydrogen Facts A colorless, highly flammable gaseous element, the lightest of all gases and the most abundant element in the universe, used in the production of synthetic ammonia and methanol, in petroleum refining, in the hydrogenation of organic materials, as a reducing atmosphere, in oxyhydrogen torches, and in rocket fuels. Atomic number: 1 atomic weight: melting point ーC boiling point 252.8ーC density at 0ーC gram per liter valence 1
19 Hydrogen Facts Hydrogen Facts How much does a gallon of liquid hydrogen weigh? 1 liter of liquid hydrogen weighs only 0.07 kg. That is a density of 70.8 kg/mウ (at 20 K) There are liters per gallon, so 1 gallon of liquid H 2 weighs kg. There are lbs per kilogram, so 1 gallon of liquid H 2 weighs lbs. Compare that with the weight of 1 gallon of water: lbs (more than 14 times heavier!)
20 Nitrogen & Helium Plant
21 NASA High Pressure Gas Plant
22
23
24
25
26 Hydrogen Piping to Engine Test Stands
27 Team Exercise Team Exercise With the Information to Follow in The NASA Case Study Video, Presentation & Notebook With Your Team Members, Answer the Following Questions:
28 Case Study Facts Case Study Facts The High Pressure Gas Plant Uses Helium Nitrogen Hydrogen The Nitrogen & Helium Plant is one Section of the Plant The Hydrogen Plant is remotely located from the Nitrogen & Helium Plant The Hydrogen is Piped from the Hydrogen Plant to the Engine Test Stands through a valved system There are approximately 100 miles of pipe at the NASA Stennis Space Center
29 Case Study Exploration Case Study Exploration 1. Are the Nitrogen & Helium sections of the plant a covered process? Yes or No & Why 2. Is the Hydrogen Plant a covered process? Why? 3. How Much Hydrogen is in the Hydrogen Plant - Find in the PSM Documentation? 4. How is the amount of Hydrogen Calculated? 5. Is that All the Hydrogen in the covered process? We will discuss the Team Findings
30 What s Next What s Next Process Information & Toxicity
OREGON OCCUPATIONAL SAFETY AND HEALTH DIVISION DEPARTMENT OF CONSUMER AND BUSINESS SERVICES PROGRAM DIRECTIVE
OREGON OCCUPATIONAL SAFETY AND HEALTH DIVISION DEPARTMENT OF CONSUMER AND BUSINESS SERVICES PROGRAM DIRECTIVE Program Directive: A-177 Issued: April 5, 1993 Revised: June 15, 2015 SUBJECT: PURPOSE: SCOPE:
More informationProcess Safety Management of Highly Hazardous & Explosive Chemicals. Safe Work Practices
Process Safety Management of Highly Hazardous & Explosive Chemicals Safe Work Practices Safe Work Practices 1910.119(f)(1) The employer shall develop and implement safe work practices to provide for the
More informationProcess Safety Management
Process Safety Management U.S. Department of Labor Occupational Safety and Health Administration OSHA 3132 2000 (Reprinted) This informational booklet is intended to provide a generic, non-exhaustive overview
More informationCHAPTER 1: GENERAL APPLICABILITY
CHAPTER 1: GENERAL APPLICABILITY 1.1 INTRODUCTION The purpose of this chapter is to help you determine if you are subject to Part 68, the risk management program rule. Part 68 covers you if you are: The
More informationEPA RISK MANAGEMENT PROGRAM RULE TO IMPACT DISTRIBUTORS AND MANUFACTURERS
EPA RISK MANAGEMENT PROGRAM RULE TO IMPACT DISTRIBUTORS AND MANUFACTURERS I. Introduction Under an EPA rule designed to prevent chemical accidents, certain distributors, formulators and manufacturers of
More informationNatural Gas Information Contents
Natural Gas Information Contents What is natural gas Natural Gas Components Physical Properties of Natural Gas Different Forms of Natural Gas The Use of Natural Gas Co-generation System Natural Gas and
More informationSECTION FC 2706 NON-PRODUCTION CHEMICAL LABORATORIES
New York City Administrative Code - Title 29 New York City Fire Code SECTION FC 2706 NON-PRODUCTION CHEMICAL LABORATORIES 2706.1 Scope. This section shall govern the storage, handling and use of laboratory
More informationPSM Covered Chemical Facilities National Emphasis Program ABSTRACT
DIRECTIVE NUMBER: 09-06 (CPL 02) EFFECTIVE DATE: July 27, 2009 SUBJECT: PSM Covered Chemical Facilities National Emphasis Program ABSTRACT Purpose: This notice describes policies and procedures for implementing
More information527 CMR: BOARD OF FIRE PREVENTION REGULATIONS 527 CMR 14.00: FLAMMABLE AND COMBUSTIBLE LIQUIDS, FLAMMABLE SOLIDS OR FLAMMABLE GASES
527 CMR 14.00: FLAMMABLE AND COMBUSTIBLE LIQUIDS, FLAMMABLE SOLIDS OR FLAMMABLE GASES Section 14.01: Scope 14.02: Definitions 14.03: Storage 14.04: Handling of Flammable Fluids 14.05: Handling of Flammable
More informationEthanol Vehicle and Infrastructure Codes and Standards Citations
Ethanol Vehicle and Infrastructure Codes and Standards Citations This document lists codes and standards typically used for U.S. ethanol vehicle and infrastructure projects. To determine which codes and
More informationCompressed Gas Cylinder Program
Department of Environmental Health & Safety Procedures Compressed Gas Cylinder Program March 2010 Compressed Gas Cylinder Program Page 1 of 8 Table of Contents I. Introduction II. III. IV. Policy Scope
More informationCOMPRESSED GASES. 1.2 The contents of each cylinder and container must be clearly identified (by tag or stamp) on the cylinder.
Page 1 of 5 COMPRESSED GASES A compressed gas is defined as any mixture of gases in a container with a pressure exceeding 40 psi. at 70 o F, or 104 psi. at 130 o F; or any flammable liquid with an absolute
More informationRe: INGAA s Comments to OSHA s Request for Information concerning Process Safety Management
March 28, 2014 OSHA Docket Office Occupational Safety and Health Administration U.S. Department of Labor Room N-2625 200 Constitution Avenue NW Washington, DC 20210 Via electronic submission: www.regulations.gov
More informationMolar Mass of Butane
Cautions Butane is toxic and flammable. No OPEN Flames should be used in this experiment. Purpose The purpose of this experiment is to determine the molar mass of butane using Dalton s Law of Partial Pressures
More informationMechanical Systems Competency 1.20
Competency 1.20 Mechanical systems personnel shall demonstrate a working level knowledge of the safety and health fundamentals of mechanical systems and/or components. 1. Supporting Knowledge and Skills
More informationHOT WORK PERMIT PROCEDURES
COLUMBIA UNIVERSITY ENVIRONMENTAL HEALTH & SAFETY HOT WORK PERMIT PROCEDURES COLUMBIA UNIVERSITY MEDICAL CENTER February 2010 1 TABLE OF CONTENTS A. PURPOSE 3 B. SCOPE 3 C. POLICIES AND PROCEDURES 3-4
More informationFlammable Liquids 29 CFR 1910.106
Flammable Liquids 29 CFR 1910.106 OSHA s Directorate of Training and Education These materials were developed by OSHA s Directorate of Training and Education and are intended to assist employers, workers,
More informationPIPELINE FUNDAMENTALS. texaspipelines.com
PIPELINE FUNDAMENTALS texaspipelines.com Texas Oil & Gas: Generating $2.6 Billion for State Revenues texaspipelines.com Texas Oil & Gas Texas produces 20% of US Domestic Oil Production 1.1 Million Barrels
More informationGUIDELINES FOR THE LOCATION OF STATIONARY BULK AMMONIA STORAGE FACILITIES
GUIDELINES FOR THE LOCATION OF STATIONARY BULK AMMONIA STORAGE FACILITIES In accordance with Part 1, Section 4 of the Clean Air (General) Regulations, being Alberta Statute 216/75, the Department of the
More informationBP WIND ENERGY POLICIES AND PROCEDURES
BP WIND ENERGY POLICIES AND PROCEDURES Document Control Details 1.0 Purpose/Scope 1.1 This procedure provides the minimum requirements to be followed for the storage of flammable or combustible materials
More informationMATERIAL SAFETY DATA SHEET
` MATERIAL SAFETY DATA SHEET SECTION 1. PRODUCT IDENTIFICATION PRODUCT NAME: Hydrogen, compressed CHEMICAL NAME: Hydrogen FORMULA: H 2 SYNONYMS: None MANUFACTURER: Air Products and Chemicals, Inc. 7201
More informationAt the temperature of liquid hydrogen, however, 99.8% of the hydrogen molecules will be in the para form.
1 ydrogen What is hydrogen? ydrogen is one of the elements, as are helium, carbon, nitrogen, oxygen, neon, sodium, aluminum, sulfur, chlorine, potassium, iron, nickel, copper zinc, silver, platinum, gold,
More informationCSB Public Meeting February 7, 2010, Natural Gas Explosion Kleen Energy Middletown, Connecticut
CSB Public Meeting February 7, 2010, Natural Gas Explosion Kleen Energy Middletown, Connecticut June 28, 2010 www.csb.gov 1 Tonight s Speakers Lauren Wilson Chemical Incident Investigator Dan Tillema Chemical
More informationGas Laws. The kinetic theory of matter states that particles which make up all types of matter are in constant motion.
Name Period Gas Laws Kinetic energy is the energy of motion of molecules. Gas state of matter made up of tiny particles (atoms or molecules). Each atom or molecule is very far from other atoms or molecules.
More informationPropane Fuel. Material Safety Data Sheet
VICTOR Material Safety Data Sheet SECTION 1 - PRODUCT AND COMPANY IDENTIFICATION Product Name: Liquefied Petroleum Gas or Propane (0916-0004) (0056-1297) Product Use: Heating Fuel Synonyms: Propane, LP-Gas,
More informationMATERIAL SAFETY DATA SHEET. PRODUCT IDENTIFIER Carbon Dioxide, Refrigerated Liquid
SECTION I- Product Information* MANUFACTURER: EPCO Carbon Dioxide Products, Inc. OFFICE PHONE: 1-800-259-3726 24-HOUR EMERGENCY: 1-800-259-8095 SHIPPING NAME: Carbon Dioxide, Refrigerated Liquid UN NUMBER:
More informationThe Comprehensive Environmental Response,
Purpose and Applicability of Regulations Chapter 7 The Comprehensive Environmental Response, Compensation, and Liability Act (CERCLA) was enacted by Congress in 1980 to clean up the nation s hazardous
More informationProcess Safety Management of Highly Hazardous & Explosive Chemicals. Management of Change
Process Safety Management of Highly Hazardous & Explosive Chemicals Management of Change What if Our PHA s Reveal the Need to Change Something In our System to Minimize the Potential for Release We Must
More informationPropane as the Alternate Fuel for Fleets
Propane as the Alternate Fuel for Fleets Company Profile Located in Quincy, Illinois since 1848 Fifth Generation, Family Company Nation s largest manufacturer of service, platform and utility van bodies
More informationIB Chemistry. DP Chemistry Review
DP Chemistry Review Topic 1: Quantitative chemistry 1.1 The mole concept and Avogadro s constant Assessment statement Apply the mole concept to substances. Determine the number of particles and the amount
More informationUnit 3 Notepack Chapter 7 Chemical Quantities Qualifier for Test
Unit 3 Notepack Chapter 7 Chemical Quantities Qualifier for Test NAME Section 7.1 The Mole: A Measurement of Matter A. What is a mole? 1. Chemistry is a quantitative science. What does this term mean?
More information= 800 kg/m 3 (note that old units cancel out) 4.184 J 1000 g = 4184 J/kg o C
Units and Dimensions Basic properties such as length, mass, time and temperature that can be measured are called dimensions. Any quantity that can be measured has a value and a unit associated with it.
More informationPREPIPED LIQUID FUEL MANIFOLDS PLPM
PREPIPED LIQUID FUEL MANIFOLDS PLPM INSTRUCTIONS WARNING These instructions are intended for use only by experienced, qualified combustion start-up personnel. Adjustment of this equipment and its components,
More informationGas Detection for Refining. HA University
Gas Detection for Refining HA University Refinery Process and Detection Needs Refining i Crude Oil Final Products Coke Asphalt Waxes, Lubricating Oils and Greases Kerosene, Jet Fuel, Diesel Fuel, Home
More informationGeneral Confined Space Awareness
Confined Spaces General Confined Space Awareness Confined spaces can be found in many industrial settings, from steel mills to paper mills, from shipyards to farms, and from public utilities to the construction
More informationLIQUEFIED PETROLEUM GASES
CHAPTER 38 LIQUEFIED PETROLEUM GASES SECTION 3801 GENERAL 3801.1 Scope. Storage, handling and transportation of liquefied petroleum gas (LP-gas) and the installation of LP-gas equipment pertinent to systems
More informationFLAMMABLE AND COMBUSTIBLE LIQUIDS. n OSHA Changes
FLAMMABLE AND COMBUSTIBLE LIQUIDS OSHA Changes Introduction This module covers the two primary hazards associated with flammable and combustible liquids: explosion and fire. In order to prevent these hazards,
More informationsara 312 & 313 emergency planning & community right-to-know act
sara 312 & 313 lorin jaeger, C: 512-417-0186, lorin.jaeger@sageenvironmental.com kari keegan, C: 312-965-8038, kari.keegan@sageenvironmental.com October 2012. ALL RIGHTS RESERVED. Revised Nov. 12, 2012
More informationTEST REPORT for the ARID TECHNOLOGIES VAPOR RECOVERY UNIT installed in LANTANA, FL
Project No. 148 TEST REPORT for the ARID TECHNOLOGIES VAPOR RECOVERY UNIT installed in LANTANA, FL Prepared for: Mr. Ted Tiberi Arid Technologies, Inc. 130 North LaGrange Rd. LaGrange, IL 60525 Prepared
More informationChapter XIV OCCUPATIONAL SAFETY AND HEALTH ACT. The Occupational Safety and Health Act (the Act ), 29 U.S.C. 651, et seq., is
Chapter XIV OCCUPATIONAL SAFETY AND HEALTH ACT The Occupational Safety and Health Act (the Act ), 29 U.S.C. 651, et seq., is administered by the Occupational Safety and Health Administration ( OSHA ) of
More informationMATERIAL SAFETY DATA SHEET - Air-Compressed
1. PRODUCT AND COMPANY IDENTIFICATION PRODUCT NAME: CHEMICAL NAME: CHEMICAL FAMILY: SYNONYMS: CHEMICAL FORMULA: USE: NAME AND ADDRESS: Air, compressed Air Nonflammable gas Medical Air, Breathing Air, Compressed
More information5. Which temperature is equal to +20 K? 1) 253ºC 2) 293ºC 3) 253 C 4) 293 C
1. The average kinetic energy of water molecules increases when 1) H 2 O(s) changes to H 2 O( ) at 0ºC 3) H 2 O( ) at 10ºC changes to H 2 O( ) at 20ºC 2) H 2 O( ) changes to H 2 O(s) at 0ºC 4) H 2 O( )
More informationThe Comprehensive Environmental Response,
Purpose and Applicability of Regulations The Comprehensive Environmental Response, Compensation, and Liability Act (CERCLA) was enacted by Congress in 1980 to clean up the nation s hazardous waste sites
More informationA Guide to the Legal Framework of the PSM Standard for Engineers
A Guide to the Legal Framework of the PSM Standard for Engineers Christopher Cunio, Esq. Cooley Manion Jones LLP 21 Custom House Street Boston, MA 02110 ccunio@cmjlaw.com Georges Melhem, Ph.D. iomosaic
More information83 to 87% carbon 11-15% hydrogen 0.1-7% sulphur 0.06-1.5% oxygen 0.1-0.5% nitrogen
Petroleum chemistry rude is the name for a liquid mixture of different hydrocarbon connections found in the earth. Petroleum, strictly speaking is crude oil, but it is used to describe all kinds of hydrocarbons.
More informationTHE BASICS Q: What is VOC? Q: What are flashing losses/voc emissions from hydrocarbon storage tanks? - 1 -
Calculation of Flashing Losses/VOC Emissions from Hydrocarbon Storage Tanks THE BASICS Q: What is VOC? A: VOC is an acronym that stands for Volatile Organic Compounds. VOC are components of hydrocarbon
More informationDEF Q&A. A. SCR is a technology that uses a urea based diesel exhaust fluid (DEF) and a
Selective Catalytic Reduction (SCR) Q. What is Selective Catalytic Reduction (SCR)? A. SCR is a technology that uses a urea based diesel exhaust fluid (DEF) and a catalytic converter to significantly reduce
More informationFire Protection and Prevention
Fire Protection and Prevention The Occupational Safety and Health Administration (OSHA) requires employers to implement fire protection and prevention programs in the workplace. The regulations that apply
More informationWaste Oil Collection / Storage
ENVIRONMENTAL & REGULATORY SERVICES Storage Tank Regulation Section P. O. Box 7837 Madison, Wisconsin 53707-7837 TDD #: (608) 264-8777 http://www.commerce.state.wi.us http://www.wisconsin.gov Jim Doyle,
More informationALVERNIA UNIVERSITY OSHA REGULATION: 29 CFR 1910.252 WELDING, CUTTING, AND BRAZING ( HOT WORK ) SECTION: 3600
OSHA REGULATION: 9 CFR 90.5 WELDING, CUTTING, AND BRAZING ( HOT WORK ) A. POLICY. This procedure follows requirements set forth in 9 CFR 90.5.. This policy applies to all Hot Work operations being done
More informationDOT 126F Hazardous Material Awareness. Oregon State University Environmental Health and Safety
DOT 126F Hazardous Material Awareness Oregon State University Environmental Health and Safety Why is Training Required Hazardous Materials Employee training requirements of CFR49 Parts 171-177 As stated
More informationENVIRONMENT, SAFETY, HEALTH, AND QUALITY DIVISION
ENVIRONMENT, SAFETY, HEALTH, AND QUALITY DIVISION Chapter 40: Chemical Lifecycle Management Chemical Storage Asset Requirements Product ID: 223 Revision ID: 1487 Date published: 20 May 2013 Date effective:
More informationTemperature. Number of moles. Constant Terms. Pressure. Answers Additional Questions 12.1
Answers Additional Questions 12.1 1. A gas collected over water has a total pressure equal to the pressure of the dry gas plus the pressure of the water vapor. If the partial pressure of water at 25.0
More informationCOMBUSTION. In order to operate a heat engine we need a hot source together with a cold sink
COMBUSTION In order to operate a heat engine we need a hot source together with a cold sink Occasionally these occur together in nature eg:- geothermal sites or solar powered engines, but usually the heat
More information5.2 Transportation And Marketing Of Petroleum Liquids 1-3. 5.2.1 General
5.2 Transportation And Marketing Of Petroleum Liquids 1-3 5.2.1 General The transportation and marketing of petroleum liquids involve many distinct operations, each of which represents a potential source
More informationGuide to good leak testing
Page 0 Guide to good leak testing The Institute of Refrigeration, working with the Carbon Trust, brings you REAL Zero Refrigerant Emission and Loss Zero. The aim of this project is in the title zero refrigerant
More informationThe Deepwater Horizon Oil Spill Part I. Unit Conversion
The Deepwater Horizon Oil Spill Part I. Unit Conversion Why? The Deepwater Horizon oil spill (also known as the BP oil spill) began on 4/20/2010 and ended when the well was capped on 7/15/2010. The spill
More informationThe paper addresses the boil-off in the cryogenic industry and details the specifics of it when applied to vehicle LNG tanks.
What is Boil-off? Scope... 1 Boil-off in the cryogenic industry... 1... 1 Measures for boil-off... 2 LNG vehicle tanks... 2 Boil-off for the vehicle LNG Tank... 2 Heat management and types of fuel delivery
More informationUses of Energy. Residential- homes Commercial - buildings Industry and Manufacturing Transportation- cars, trucks, planes, etc.
Uses of Energy Residential- homes Commercial - buildings Industry and Manufacturing Transportation- cars, trucks, planes, etc. links page recent statistics The United States is a highly developed and industrialized
More informationA Guide to Hazardous Substance Storage Capacity
New Jersey Department of Environmental Protection Bureau of Release Prevention A Guide to Hazardous Substance Storage Capacity August 7, 2014 Introduction The Spill Compensation and Control Act (the Spill
More informationEXPLOSIVE ATMOSPHERES - CLASSIFICATION OF HAZARDOUS AREAS (ZONING) AND SELECTION OF EQUIPMENT
EXPLOSIVE ATMOSPHERES - CLASSIFICATION OF HAZARDOUS AREAS (ZONING) AND SELECTION OF EQUIPMENT OVERVIEW ASSESSING THE RISK RELATIONSHIP BETWEEN FIRES AND EXPLOSIONS CLASSIFYING HAZARDOUS AREAS INTO ZONES
More informationRequirements for Hydrogen Storage and Use
Requirements for Hydrogen Storage and Use I. INTRODUCTION Fire and Life-Safety Group (FLS) The following is a summary of the fire and building code requirements for the storage and use of hydrogen. These
More informationRusty Walker, Corporate Trainer Hill PHOENIX
Refrigeration 101 Rusty Walker, Corporate Trainer Hill PHOENIX Compressor Basic Refrigeration Cycle Evaporator Condenser / Receiver Expansion Device Vapor Compression Cycle Cooling by the removal of heat
More informationControlling fire and explosion risks in the workplace
Controlling fire and explosion risks in the workplace A brief guide to the Dangerous Substances and Explosive Atmospheres Regulations Introduction to DSEAR This leaflet provides a brief introduction to
More informationCompressed Gas Cylinder Storage and Handling Guide
Overview Compressed gas cylinders are used in many workplaces to store gases that vary from extremely flammable (acetylene) to extremely inert (helium). Many compressed gas cylinders are stored at extremely
More informationAlaska. Occupational Safety and Health Standards. quick guide to. hazard communication for general industry. What you should know and not a word more!
Alaska Occupational Safety and Health Standards quick guide to hazard communication for general industry What you should know and not a word more! Table of Contents Overview of AKOSH Services 1 What is
More informationCertain specific properties of compressed gases make them highly useful in various research activities.
GAS CYLINDER SAFETY Introduction Certain specific properties of compressed gases make them highly useful in various research activities. These gases, however, can be dangerous if not handled in an appropriate
More informationFlammable and Combustible Liquids. Slide 1 (of 23)
Flammable and Combustible Liquids Slide 1 (of 23) Introduction The two primary hazards associated with flammable and combustible liquids are explosion and fire Safe handling and storage of flammable liquids
More informationDANGER! EXTREMELY FLAMMABLE GAS UNDER PRESSURE. MAY EXPLODE IF HEATED. MAY BECOME ASPHYXIANT IF RELEASED OR IN CONFINED SPACES.
Safety Data Sheet 1. Identification Product Name: Natural Gas (Sweet) Chemical Family: Natural Gas Manufacturers Name: Whiting Oil and Gas Corporation Address: 1700 Broadway, Suite 2300 Denver, Colorado
More informationSafety issues of hydrogen in vehicles Frano Barbir Energy Partners 1501 Northpoint Pkwy, #102 West Palm Beach, FL 33407, U.S.A.
Safety issues of hydrogen in vehicles Frano Barbir Energy Partners 1501 Northpoint Pkwy, #102 West Palm Beach, FL 33407, U.S.A. Properties of hydrogen Hydrogen is an odorless, colorless gas. With molecular
More informationMethane in Air 0.0001% to 2.5%
Kele part# GAS-CH4-2.5 Emergency Contact: Chemtrec (800) 424-9300 Or rco (208) 336-1643 1125 West Amity Road Boise, ID 83705 (208) 336-1643 Methane in Air 0.0001% to 2.5% M A T E R I A L S A F E T Y D
More informationSCBA Frequently Asked Questions
SCBA Frequently Asked Questions Q. WHEN SHOULD I USE SCBA? A. An SCBA is the choice when dealing with any oxygen deficient atmosphere that is IDLH (Immediately Dangerous to Life or Health), or any environment
More informationEnergy Measurements and Conversions
Updated September, 2007 File C6-86 http://www.extension.iastate.edu/agdm/wholefarm/html/c6-86.html Energy Measurements and Conversions Don Hofstrand, extension value-added agriculture specialist, co-director
More information10 g 5 g? 10 g 5 g. 10 g 5 g. scale
The International System of Units, or the SI Units Vs. Honors Chem 1 LENGTH In the SI, the base unit of length is the Meter. Prefixes identify additional units of length, based on the meter. Smaller than
More informationGrounding and Bonding Against Static Electricity. Jon Koppari, CSP, MS Occupational Safety and Health Instructor OSHA Training Institute
Grounding and Bonding Against Static Electricity Jon Koppari, CSP, MS Occupational Safety and Health Instructor OSHA Training Institute Objectives Identify Sources of Ignition. Identify Hazards associated
More informationQuebec Quebec Tel : 418-834-7447 Fax : 418-834-3774 MSDS: P10 (10% Methane in Argon) PRODUCT INFORMATION
Tel: 514-956-7503 Fax: 514-956-7504 Internet: www.megs.ca Email : support@megs.ca Montreal Ottawa St-Laurent Nepean Tel : 514-956-7503 Tel : 613-226-4228 Fax : 514-956-7504 Fax : 613-226-4229 Quebec Quebec
More informationDepartment of Transportation Hazardous Material Regulations General Awareness, Safety & Security Training. For: University of Dayton Hazmat Employees
Department of Transportation Hazardous Material Regulations General Awareness, Safety & Security Training For: University of Dayton Hazmat Employees February, 2014 Overview Hazardous materials are substances
More informationAppendix C: Conversions and Calculations
Appendix C: Conversions and Calculations Effective application of pesticides depends on many factors. One of the more important is to correctly calculate the amount of material needed. Unless you have
More informationGaseous hydrogen. Safetygram 4
Safetygram 4 Gaseous hydrogen Hydrogen is a colorless, odorless, tasteless, highly flammable gas. It is also the lightest-weight gas. Since hydrogen is noncorrosive, special materials of construction are
More informationWINDEX ORIGINAL GLASS CLEANER WITH AMMONIA-D
1. PRODUCT AND COMPANY IDENTIFICATION Product information Product name : WINDEX ORIGINAL GLASS CLEANER WITH AMMONIA- D Recommended use : Hard Surface Cleaner Manufacturer, importer, supplier : S.C. Johnson
More informationReporting dangerous goods incidents. Guideline (6th edition)
Reporting dangerous goods incidents Guideline (6th edition) Reference The recommended reference for this publication is: Department of Mines and Petroleum, 2011, Reporting dangerous goods incidents guideline
More informationNotes. Material 1. Appropriate Flammable Liquids
29 CFR 1910.106 Flammable Materials Flammable Liquids Preparation 1. Read Applicable Background information and related Company Policy Chapter. 2. Make Copies of this Lesson Plan for Personnel 3. Make
More informationHealthandSafetyOntario.ca. Introduction. Storage Containers. Storing Flammable Liquids
Flammable Liquids Storage Introduction This guideline is designed to help you store flammable liquids safely. It is based on the requirements of the Ontario Fire Code, Part 4, and of the Regulations for
More informationHYDGROGEN INFRASTRUCTURE DEVELOPMENT
JULY 2014 HYDGROGEN INFRASTRUCTURE DEVELOPMENT ALTERNATIVE FUELS & ADVANCED TRANSPORTATION TECHNOLOGIES introduction The advanced transportation sector plays a vital role in California s economy and in
More informationBUSINESS LICENSE (2014) CHARTER TOWNSHIP OF FLINT 1490 S. DYE ROAD, FLINT Ml 48532 (810) 732-1350 OR FAX (810) 733-6919
BUSINESS LICENSE (2014) CHARTER TOWNSHIP OF FLINT 1490 S. DYE ROAD, FLINT Ml 48532 (810) 732-1350 OR FAX (810) 733-6919 PLEASE CHECK: NEW BUSINESS FEE: $75.00 YEARLY LICENSE RENEWAL FEE: $45.00 NAME OF
More informationOSHA Office of Training and Education 1
Flammable and Combustible Liquids OSHA Office of Training and Education 1 Introduction The two primary hazards associated with flammable and combustible liquids are explosion and fire Safe handling and
More informationList of Frequently Utilized Storage Tank Standards and Practices
List of Frequently Utilized Storage Tank Standards and Practices Below is a list of frequently used storage tank standards and practices from organizations that are referenced in 25 PA Code, Chapter 245.
More informationFACTS ABOUT PROPANE America's Exceptional Energy
FACTS ABOUT PROPANE America's Exceptional Energy PROPANE INDUSTRY Propane, the most common liquefied petroleum gas (LP-gas), is one of the nation's most versatile sources of energy and supplies about 4
More informationBalancing chemical reaction equations (stoichiometry)
Balancing chemical reaction equations (stoichiometry) This worksheet and all related files are licensed under the Creative Commons Attribution License, version 1.0. To view a copy of this license, visit
More informationReview - After School Matter Name: Review - After School Matter Tuesday, April 29, 2008
Name: Review - After School Matter Tuesday, April 29, 2008 1. Figure 1 The graph represents the relationship between temperature and time as heat was added uniformly to a substance starting at a solid
More informationNFPA Hazard Class: * Physical Form: Solid. Health: 0 (Least) * Appearance: Yellow Flammability: 1 (Slight)
Safety Data Sheet Microcrystalline Wax 1. Chemical Product Identification Generic Name: Microcrystalline Wax INCI Name: Microcrystalline Wax Chemical Family: Mineral Emergency Telephone Numbers: Page 1
More informationProblem Solving. Stoichiometry of Gases
Skills Worksheet Problem Solving Stoichiometry of Gases Now that you have worked with relationships among moles, mass, and volumes of gases, you can easily put these to work in stoichiometry calculations.
More informationNitrogen Blanketing for Methanol Storage and Transportation
Nitrogen Blanketing for Methanol Storage and Transportation Overview Air is the enemy of many materials. Not only can oxygen cause safety concerns and product degradation, but moisture, dirt, hydrocarbons
More informationFIRE PREVENTION PLAN
FIRE PREVENTION PLAN 1 FIRE PREVENTION PLAN OSHA s Fire Prevention Plan regulation, found at 29 CFR 1910.38(b) and 29 CFR 1926.24, requires Northern Clearing, Inc. to have a written fire prevention plan
More informationSample Written Program. For. Flammable Liquids
Sample Written Program For Flammable Liquids 1 Flammable Liquids. (YOUR COMPANY NAME) Purpose Proper Storage and use of flammable liquids can significantly reduce the possibility of accidental fires and
More informationQUEENSLAND FIRE AND RESCUE SERVICE SCIENTIFIC BRANCH
QUEENSLAND FIRE AND RESCUE SERVICE SCIENTIFIC BRANCH What is the Scientific Branch? The QFRS Scientific Branch was established in 2004, with origins back to 1992. Its objective is to maximise the safety
More informationADMINISTRATIVE SERVICES MANUAL
Purpose Responsibilities Proper Storage and use of flammable liquids can significantly reduce the possibility of accidental fires and injuries. To minimize risk to life and properly, the requirements of
More informationRevised April (May) 2015
Section 19.0 Cross Connection Control Policy 19.1 Responsibility 19.1.1 The Elkhart Water Utility has the responsibility to supply safe, potable water from the source to the point of delivery defined as
More informationEmergency Planning and Community Right-to-Know
Emergency Planning and Community Right-to-Know CT Business and Facility Required Reporting Guidance EPCRA Law and Regulations Updated November 2011 For more detail and specific required reporting instructions
More informationU.S. National Work Group for the Development of Commercial Hydrogen Measurement Standards
U.S. National Work Group for the Development of Commercial Hydrogen Measurement Standards Fuel Specifications Subcommittee (FSS) A Proposed Method of Sale and Quality Specification for Hydrogen Vehicle
More information