Material Safety Data Sheet

Transcription

1 Derivan Pty Ltd Issue date: 201 Material Safety Data Sheet 1. IDENTIFICATION OF THE MATERIAL AND SUPPLIER Product Name: Derivan Face & Body Wipes Supplier Codes: DERFBPW Derivan Pty. Ltd. Use: Cleaning face and body painting. ABN Leeds Street, Rhodes 2138 AUSTRALIA Emergency number Mon-Fri 9am -5pm Tel: Tel: Fax: HAZARD IDENTIFICATIONS Hazard Classifications: Non-hazardous substance and Non-dangerous goods according to the Criteria of NOHSC and the ADG Code Hazard Category: None allocated as non-hazardous Risk Phrases: None allocated as non- hazardous. Safety Phrases: None allocated as non-hazardous. Warning Statement: No particular hazards associated with this product. 3. COMPOSITION / INFORMATION ON INGREDIENTS SUBSTANCE NAME PROPORTION CAS NUMBER Water (aqua) Up to Spunlace Fabric 10 60% --- Propylene Glycol <1% Polysorbate 20 <1% Benzyl Alcohol <1% PEG-75 Lanolin <1% Laureth-9 <1% Lanolin <1% Citric Acid <1% Methylchloroisothiazolinone <1% Methylisothiazolinone <1% Ethylhexyl Stearate / Octyl Stearate <1% Aloe Vera (Aloe Barbadensis Gel) Extract <1% Chammomile (Matricaria Chamomilla/Chamomilla Recutita) Flower <1% Extract Tocopheryl Acetate (Vitamin E Acetate) <1% First Aid is not generally required. If in doubt, contact a poisons information centre (Aust. ph : NZ ) or a doctor. Page 1 of 5

2 Derivan Pty Ltd Issue date: FIRST AID AND MEASURES Swallowed: If a minor amount has been swallowed, then if conscious, dilute stomach contents by giving large amounts of water. Seek medical attention. Do not attempt to induce vomiting or give anything by mouth to an unconscious person. Remove the wipe if it is blocking the airway and resuscitate if the subject has stopped breathing. Eyes: Flush with water for a minimum of 15 minutes, keep moving the eyes for complete flushing. Seek medical attention promptly if irritation persists or loss of vision occurs. Skin: Immediately remove contaminated clothing. Wash contaminated skin with water. Seek medical attention if irritation persists. Launder contaminated clothing before re-use. Inhale: Remove promptly to fresh air. If there are signs of drunkenness (intoxication or inebriation) or if respiratory irritation, dizziness, nausea unconsciousness occurs, seek immediate medical attention. Treat unconsciousness by placing the person in the coma position. Remove the wipe if it is blocking the airway. Apply artificial respiration if breathing stops. ADVICE TO DOCTOR: Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media: Use water fog (or if unavailable, fine water spray), dry chemical, carbon dioxide or foam. Unusual Fire and Explosion Hazards: No particular fire and explosion hazards associated with this product. Hazards from Combustion Products: Burning can produce carbon monoxide and/or carbon dioxide Precautions for Fire Fighters and Special Protective Equipment: Use water to cool exposed containers. If safe to do so, remove containers from path of fire. For major fires or where atmosphere is Oxygen deficient or contains unacceptable levels of combustion products, firefighters must wear self-contained breathing apparatus with full-face mask and protective clothing. Prevent spillage from entering drains or water courses. Hazchem Code: None allocated. Flammability: This material is not combustible under normal conditions. 6. ACCIDENTAL RELEASE MEASURES Emergency Procedures: Wear appropriate personal protective equipment to prevent skin and eye contamination. isolate hazard area. Keep unnecessary and unprotected personnel from entering. Mop up the solution. Wash the cleaned up area with water and mop up to remove all traces of product. Ensure the area is safe before allowing personnel to return to the work area. Prevent spillage from entering drains or water courses. Liquid can be collected with absorptive materials such as sand, soil, wood dust or diatomaceous earth. Dangerous Goods Not-applicable. Methods and Materials for Containment and Clean-up Procedures: Contain and recover product when possible. Collect product in an appropriate container and place in a chemical waste container. Collected empty containers can be disposed of through local council waste removal services. 7. HANDLING AND STORAGE Precautions for Safe Handling: Protect against physical damage. Make certain the containers are well sealed when not in use. Page 2 of 5

3 Conditions for Safe Storage: Store in a cool, dry well ventilated location. Keep containers closed at all times. Incompatibilities: Not to be stored with explosives, flammable gases in bulk, poisonous gasses, spontaneously combustible substances, oxidizing agents, organic peroxides or radioactive substances. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION National Exposure Standards: No Exposure Standards have been assigned by the National Occupational Health and Safety Commission for any components of this product at the use levels. Biological Limit Values: Not known. Engineering Controls: None allocated. Prevent solution from entering drains or water courses. Personal Protection Equipment: Under typical use wipes can be used without restriction. Eye/Face Protection: No specific protection noted. Hygiene Measures: No specific hygiene procedures noted, but good personal hygiene practices are always advisable, especially when working with face paints. Respiratory Protection: Not required. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance: Moist wipes wrapped in plastic flow wrap film, with clip lid. Odour: Characteristic fragrance smell. ph: Vapour Pressure: Low. Vapour Density: Not Applicable. Specific Gravity: About 1.0 (solution only). Boiling Point/Range: About 100 deg C (solution only). Melting Point: Not Applicable. Solubility: Completely soluble in water (solution only). Flash Point: >100 deg C tag closed cup (solution only). Lower Explosive Limit: Not Applicable. Upper Explosive Limit: Not Applicable. Ignition Temperature: >200 deg C Volatile Organic Content: <1% w/w Percent Volatile: >90% w/w (solution only). 10. STABILITY AND REACTIVITY Chemical Stability: Stable under normal storage and handling conditions. Hazardous Decomposition Products: Soot, Carbon Dioxide, Carbon Monoxide. Hazardous Reactions: Hazardous polymerization will not occur. Incompatible Materials: Do not mix with detergents or other chemicals. Conditions to Avoid: Spills and release into the sewers and water courses. 11. TOXICOLOGICAL INFORMATION No adverse health effects are expected, if the product is handled in accordance with this Material Safety Data Sheet and the product label. Symptoms and effects that may arise if the product is mishandled and overexposure occurs are: Acute Health Effects: Not listed as carcinogen. Ingested: Not considered to be toxic. Page 3 of 5

4 Eye: The solution may cause discomfort due to the presence of salts. Skin: Not considered to be an irritant. 12. ECOLOGICAL INFORMATION Eco toxicity: Not considered to be toxicity to fish and other aquatic organisms (solution only). Wipes must not be discarded into the waterways. Mobility: No data is available on mobility in soil. Persistence / Degradability: Degree of elimination >90% (solution only). Fabric is 70% rayon which is biodegradable and 30% PET which is not. 13. DISPOSAL CONSIDERATIONS Waste Disposal Method: Collect residue for recovery, recycling or as a waste material. Dispose of container and unused contents in accordance with federal, state and local requirements. Empty container and lid can be recycled as per local council waste recycling regulations. Product must not be disposed of to the sewerage system, drains or waterways. Container Handling and Disposal: When containers are empty and it can be disposed of via general/household recycling stream. 14. TRANSPORT INFORMATION UN Number: None allocated UN Proper Shipping Name: None allocated Dangerous Goods Class: None allocated Subsidiary risk: None allocated Packing Group: None allocated Hazchem Code: None allocated Road and Rail Transport (ADG): Not classified as a Dangerous Good according to the Australian Code for the Transport of Dangerous Goods by Road and Rail (ADG Code) for transport by road and rail. Marine Transport (IMO/IMDG): Not classified as a Dangerous Good according to the International Maritime Organization Rules (Maritime Dangerous Goods Code - IMDG Code) for transport by sea. Air Transport (ICAO-IATA): Not classified as a Dangerous Good according to the International Civil Aviation Organization (ICAO) and International Air Transport Association (IATA) Dangerous Goods Regulations for transport by air. Note: May vary from country to country. SUSDP: Not scheduled. Special Precautions: Not to be stored with explosives, flammable gases in bulk, poisonous gases, spontaneously combustible substances, oxidizing agents, organic peroxides or radioactive substances. 15. REGULATORY INFORMATION Classification: Not Hazardous according to criteria of NOHSC. Australia (AICS) All ingredients are on the inventory or exempt from listing. United States (TSCA) all ingredients are on the inventory or exempt from listing. Page 4 of 5

5 16. OTHER INFORMATION Date of Preparation: 16/01/2015 Issue date: 16/01/2015 Reasons for Update: General Update. ALLERGIES To the best of our knowledge there has been no intentional addition of dairy, egg, nuts, grains, cereals and soy or gluten products to this product by either Derivan Pty Ltd or our raw material suppliers. Whilst none of our raw material suppliers MSDS state that they do contain any of the Face & body paint, we are not in a position to 100% guarantee that this product is free of the above listed products, due to the limited knowledge of our supplier s processes. Key Legend Information: NOHSC - National Occupational Health & Safety Commission ADG Code - The Australian Dangerous Goods for the Transport of Dangerous Goods by Road and Rail, (ADG Code) TWA - Time Weighted Average STEL - Short Term Exposure Limit EPA - Environmental Protection Agency Principal References: The National Code of Practice for the Preparation of Material Safety Data Sheets, 2nd Edition NOHSC: 2011(2003) Standard for the Uniform Scheduling of Drugs and Poisons No. 21 Effective date 1 June 2006 National Exposure Standards for Atmospheric Contaminants in the Occupational Environment [NOHSC: 1003 (1995)] The Australian Dangerous Goods for the Transport of Dangerous Goods by Road and Rail, (ADG Code). Disclaimer: The above information is accurate to the best of the knowledge available to us. However, since data, safety standards and Government regulations are subject to change, and the conditions of handling and use (or misuse) are beyond our control, we make no warranty, either express or implied, with respect to the completeness or continuing accuracy of the information contained herein AND disclaims all liability for reliance thereon. Users should satisfy them that they have all data relevant to their particular use. End of MSDS Page 5 of 5