American West Windmill & Solar

Transcription

1 THE American West Windmill & Solar CO SOLAR PRODUCTS CATALOG Ranching Farming Landscaping Environmental Wildlife Residential

2 Solar pumping systems provide a low cost source of energy that can be easily adapted to many different applications. Below you will find just a few of the many functions that solar pumps are performing throughout the world. Ranching Solar pumping systems are one of the main sources of energy in remote areas. These power sources drive pumps which supply water for livestock and irrigation. Farming Solar Pumping systems are being used in various farming operations to supply water to perform specific operations. Some of these applications include irrigation of crops, providing water for livestock, aerating ponds and streams, agitating manure reservoirs and many other different tasks. Landscaping The landscaping community has created many different uses for the solar pumping systems. The solar pumping system has been adapted by landscapers to perform many different functions such as creating waterfalls, artificial streams, fish ponds and other aquatic functions. Environmental Solar powered pumping systems are being used in many diverse environmental applications. These applications range from the purification of contaminated water to the management of water levels in ponds. All of these functions are being performed by the solar pumping system without damage to the environment and without the use of fossil fuel. Wildlife Solar pumping systems are being used to provide water for all different types of wildlife. Since solar panels generate the power necessary to operate the pump, electricity is not required, systems can be placed in remote areas to pump water into holding tanks for various forms of wildlife. Residential Solar pumping systems are great for providing water to supply a residence that is not tied to an electrical power grid. Even if a home has electricity solar pump systems are still used to make a home more environmentally friendly. Battery systems can be used to provide a constant supply of water throughout the hours when the sun isn t shining. 2

3 Welcome to the premier windmill and solar company in North America. We have strategic distribution throughout the United States. Our products, parts and services cover the entire spectrum of wind powered and solar powered water pumping systems. Our Company represents Lorentz one of the largest solar pump manufacturing companies in the world. We distribute the time tested PS150, PS200, PS600, PS1200, PS1800 and PS4000 Lorentz pumping systems. We are committed to providing quality solar pumps, motors, controls, photovoltaic panels, and panel array racks that are backed by extended warranties. The continued research and development of components help us insure the overall efficiency of our solar pump, motors, controls, PV panels and panel array racks. We are a full service company that can assist you with all phases of solar applications. These services include sight selection and preparation consulting, equipment sizing, construction and maintenance. Our network of distributors and ground water professionals are highly skilled and maintain a high standard of professionalism. Solar Pumping Systems have many advantages over electric pumping systems. The solar pump system does not consume any fossil fuel and this makes it very environmentally friendly. The pumping system is very durable and virtually maintenance free. In this catalog we have included sizing pages to help you determine the proper size of solar pumping system that will be required by your application. Remember that a ground water professional should be contacted prior to purchase of a solar pumping system. These professionals can assist you with all phases of solar pumping system installation. We can assist you by directing you to a professional in your area. The Lorentz Solar Line includes these features standard: No electronics in the motor. Dry run protection with automatic restart. (20 minute delay) Two control inputs in every controller. Variable Speed Control allows user to reduce the flow max flow rate by 30%. This is a great feature to prevent pump and motor damage when pumping in a low producing or seasonal wells. This comes standard on every controller. Status lights on every controller that tell you if the pump is running, if the pump has kicked out for dry run, or if the tank is full. It also comes with battery low voltage indication. Controller is Nema 3R Weather-proof Pump & Motor are constructed of 316 Stainless Steel Standard Pump, Motor, & Controller at 100% Tested before they leave the factory. The ability to replace what fails rather than replacing the entire unit. Broad pump and motor offering to meet your exact lift and flow requirements. Up to 2,000 feet of lift. Up to 43,000 gallons per day. Standard PV Panel sizes stocked are: 90 Watt -12 Volt Panel, 110 Watt 24 Volt Panel, 175 Watt 24 Volt Panel. The American West Windmill & Solar Co. maintains one of the largest selections of solar pump, motor, controller, fixed and tracked solar arrays in North America. We stock a complete line of parts for all components of the solar pumping system. A complete line of supporting products including check valves, float switches, submersible cable, pipe fittings, drop pipe and other accessories are available. Various methods of shipping are available that are designed to facilitate the delivery requirements of all of our customers. Please feel free to call our customer service and application engineers at (888) for consultation to determine equipment requirements, features and benefits or for a recommendation of a qualified groundwater professional in your area. 3

4 PS150-(HR)Helical Rotor or (C)4" Submersible PS150-4 Submersible 12V - 24V Battery or Solar Direct Charger for 12/24V Batteries and MPPT booster for solar direct applications included. Lift up to 72 Feet Flow Rate up to 1,300 GPH Simple Installation Maintenance free Cost Effective Pumping No Electronics in the Motor PS150 is more powerful, energy efficient, quieter, and much more durable than other pumps in this range. The motor is brushless and maintenance free. Applications Livestock Watering Wildlife Watering Dirt Tank Floating Pump Pond Management Irrigation Residential Wells For 12V to 24V systems (1-2 solar modules or batteries in series). Same motor and controller for solar direct or battery systems. PS-150 is a 4 submersible pump but can also be used as a floating pump Construction & Features 4 Radial Flow pump made of all 316 stainless steel. Freeze protection optional (Water drains back to source) Maintenance Free Brushless DC Motor (Same motor for 12V or 24V applications) Maximum Power Point Tracking Current booster for solar direct applications Variable Speed Pump Control allows user to reduce flow rate by 30% Low Voltage Disconnect for battery protection Controller is standard equipped with terminals for float/ pressure switch and terminals low water probe sensor. 12/24V-20Amp Battery Charger Included Battery High Run Function - This means the unit will only pump when charging current from the solar array is available. Cycling of battery is avoided and the batteries lifetime is greatly increased. Solar Direct Requirements A linear current booster is included in the controller with Maximum Power Point Tracking Solar Tracker Array will increase daily water production by 40-50% in the summer Installation Pump may be mounted vertically or horizontally. Pump & Motor must be submerged Unit will fit inside 4 or larger well casing Equipped with safety rope hole Accessories Float switch for tank shut off Well probe sensor to protect pump from dry run. Warranty 2 years against defects in materials & workmanship from date of installation with warranty paperwork completed. 4

5 Dimensions Shipping Dimensions Item L A B D S Packaging Shipping Volume Net Weight Gross Weight Inches Inches Inches Inches Inches Inches Cubic Feet Pounds Pounds C-SJ5-8 (Pump & Motor) X 6.30 X PS150 Controller X 9.45 X Sample Battery Layout: Lift / Water Requirements: Solar Radiation: 50 feet of lift and 3,000 GPD required 6kWH/m2/day = 6 peak sunlight hours Pump: Energy Required: Array Size: Battery Size: PS150 C-SJ5-8 Pump & Motor, 3,000 GPH / (14.5 GPM X 60 Minutes) GPH = 3.5 Hours of pumping time. 3.5 Hours X 24V X 12.5 Amps = 1050 Wh X 1,5* = 1,575 Wh * This is a constant factor for battery systems to account for battery charging and array losses. 1,575 Wh / 6 peak sunlight hours (Summer) = Wp array is required. 1,575 Wh / 24V = 65Ah X 2* = 130Ah is minimum size * Minimum factor for batteries Performance Chart of PS150 C-SJ5-8 4 Submersible Pump 12V Battery or 65 Wp Solar Direct 17V Battery or 150 Wp Solar Direct 24V Battery or 300 Wp Solar Direct Lift Ft. Current Amps Flow Rate GPM 5 Hr. Solar Day GPD Current Amps Flow Rate GPM 5 Hr. Solar Day GPD Current Amps Flow Rate GPM 5 Hr. Solar Day GPD Lift Ft , , , , , , , , , , , , , , , , , , , , , , , , , , , , Note: A Solar Tracker will improve daily output in the summer by 40-50% , Note: All Solar Modules have less output due to high temperature, dirt, manufactures tolerances, etc , for maximum performance under these conditions use 20% more wattage to compensate , S 10 1m L B A D 5

6 PS150 Panel Configurations (Maximum Open Circuit Voltage - 50V ) Panel Model # of Panels Panel Wtg. Nominal Voltage Open Circuit Voltage Total Wtg. Total Series Nominal Total Series Open Circuit Total Parallel Nominal Total Parallel Open Circuit Total Series- Parallel Nominal Total Series- Parallel Open Circuit LA-90-12V LA V LA M LA-90-12V LA V LA-90-12V LA M LA V LA V LA-90-12V LA V LA-90-12V LA M LA-90-12V LA V LA-90-12V LA M LA V LA-90-12V LA V LA M LA-90-12V LA V LA-90-12V LA M

7 PS150 C-SJ5-8 (Item No. 2100) for Solar & Battery Operation (Solar generator: Nominal voltage 12 to 24 V DC, open circuit voltage max. 50V DC) 7

8 PS200 (HR)Helical Rotor or (C)4" Submersible Characteristics Lift up to 164 feet Flows up to 4,755 GPD Peak Flow Rate is 720 gallons per hour Simple Installation Maintenance Free High Reliability & Life Expectancy Cost Efficient pumping No Electronics in the Motor Applications Livestock Watering Wildlife Watering Dirt Tank Floating Pump Pond Management Irrigation Residential Wells PS200 Controller Features PS200 Controller is mounted at the surface just like a standard 4 control box. The controller is sealed and weatherproof (Nema 3R) Its purpose is to control the pump system and displays the operating status of the system. Each control is equipped with two control inputs: One allows for the Dry Well Probes sensor to prevent dry run or pump off conditions the other allows for a float, pressure, or remote control switch to be used. Once the Dry Well Probe sensor trips, the controller will shut down the pump system for 20 minutes to allow the well to recover, then it will automatically restart the system. The controller is equipped with overload, underload, & reverse polarity protection. Each contol come with Variable Speed Control which allows the pump speed to be adjusted to reduce flow rate by approximately 30%. Maximum Power Point Tracking for Solar Operation. Battery Low Voltage disconnect and auto-restart after battery has recovered. Motor & Controller are 88% Efficient. EC Drive 600(HR)/200(C) Motor Features Brushless DC Motor No Electronics inside the Motor Water Filled Design IP68, Pressure balanced, max submergence is unlimited. Dynamic Carbon/Ceramic Thrust Bearings Submerged Materials are 316 Stainless Steel Drinking Water Approved 4" Submersible Pump Features Long Life Expectancy Built in Check Valve Dry Run Protection (Dry Well Probe Sensor) 316 Stainless Steel Construction Helical Rotor Pump Features Positive Displacement design Self Cleaning Two main parts that are field serviceable (Stator & Rotor) Stator is constructed of abrasion resistant rubber Rotor is constructed of stainless steel and then hard chrome plated to resist abrasion. Design is more resistant to sand damage than other pump types 8

9 PS200 HR-04 HR-07 HR-14 C-5-4 Max Lift (Feet) Max Flow Rate (GPH) ,320 Max Efficiency % 60% 61% 62% 45% Solar Operation Nominal Voltage 24-48V DC Max Open Circuit Voltage - 100V DC Solar Panels (Wp) Battery Operation Only Battery Operation Nominal Voltage 24-48V DC PS200 Technical Data (Dimensions & Weights) Dimensions Shipping Dimensions Pump Unit Inches Cubic Feet Pounds L A B D S Packaging Shipping Volume Net Weight Gross Weight PS200-HR / X 6.30 X PS200-HR / X 6.30 X PS200-HR / X 6.30 X PS200-C / X 6.30 X PS200 Controller X 9.45 X Sand & Silt Tolerance The Helical Rotor pump has a higher resistance to wear from sand, clay, etc. than any other pump type. In properly constructed wells the amount of sand, clay, etc. is within the tolerance of the pump. A concentration of solids greater than 2% by volume may cause blockage in the pump or the drop pipe, especially at low flow rates. Do not use the pump to develop newly drilled wells. Pump Cable & Splice Standard double jacketed submersible cable 3 wire + ground is recommended. Standard rubber tape with Scotch Kote or heat shrink splice kits are recommended. Drop Pipe The PS200 pump ends are fitted with an 1.25 inch outlet. If the water is dirty, consider a smaller size drop pipe to increase the flow velocity. This helps exhaust solid particles and prevent accumulation in the pipe. When considering reduced pipe size, consult a friction loss chart. We do recommend a torque arrestor. Temperature Limits Pump end & Motor can withstand up to 104oF Water Temperatures Please specify if water temperature exceeeds 104oF Controller ambient temperature is (-22oF to 131oF) S 147* S * By cutting the rubber spacers, diameter can be adjusted from 147 mm (6") to 100 mm (4"). 101 S A A 10 1m L 1m L 1m A 8 8 L D B D B D B Pump Unit HR-04 Pump Units HR-07, HR-14 Pump Units C

10 PS200-All-HR (24V, Battery Operation) Vertical Lift (Feet) Pump Type Peak Flow Rate-GPM Power Watts Wire Size-AWG HR HR HR HR HR HR HR HR HR HR HR HR # 12 # 12 # 12 # HR HR # HR PS200-All-HR (48V Battery Operation) Vertical Lift (Feet) Pump Type Peak Flow Rate-GPM Power Watts Wire Size-AWG HR HR HR HR HR HR HR HR HR HR HR HR HR HR HR # 12 # 12 # 12 # 12 # 12 # HR #

11 PS200-C-5-4 (24V to 48V Battery Operation) 20 Volts 24 Volts Volts Lift Feet Power Watts Peak Flow Rate-GPM Power Watts Peak Flow Rate-GPM Power Watts Peak Flow Rate-GPM N/A N/A For Battery and Solar Direct Systems Lift Limits These systems are selected for optimum performance. To allow for unexpected drawdown each system can handle an additional 15% of Lift Higher Lift? Higher Flow Rate? Choose the PS600 or the PS1200 for higher lift and/or higher flow rate applications and lower cable cost. Wire Sizes Cable layout is calculated to stay within 4% voltage loss. Variations in Length Longer: For each 50% increase the next larger wire size is required Shorter: For each 33% decrease the next smaller wire size can be used. Array to Controller Up to 20 feet # 10 AWG can be used. Controller to Low Water Probe #18 can be used 11

12 Irradiation: 4.0 kwh/m2/day - Tilted Surface Irradiation: 6 kwh/m2/day - Tilted Surface Vertical Lift Feet Pump Model Peak Flow Rate GPM Flow Rate for Solar Array Power Peak - GPD 80W 120W 150W Wire Size-AWG Vertical Lift Feet Pump Model Peak Flow Rate GPM Flow Rate for Solar Array Power Peak - GPD 80W 120W 150W Wire Size-AWG 16 HR # 12 HR ,242 # HR ,004 1,057 # 12 HR ,057 1,585 1,849 # HR # 12 HR w 1,110 # HR ,057 # 12 HR ,030 1,374 1,427 # HR # 12 HR ,030 # HR ,057 # 12 HR ,321 1,374 # HR # 12 HR # HR ,030 # 12 HR ,004 1,294 # HR # HR # HR # HR # 12 Irradiation: 4.0 kwh/m2/day - Tilted Surface Irradiation: 6 kwh/m2/day - Tilted Surface Vertical Lift Feet Pump Model Peak Flow Rate GPM Flow Rate for Solar Array Power Peak - GPD 150W 200W 250W Wire Size-AWG Vertical Lift Feet Pump Model Peak Flow Rate GPM Flow Rate for Solar Array Power Peak - GPD 150W 200W 250W Wire Size-AWG 16 HR ,268 1,427 1,691 # 12 HR ,242 1,849 2,245 # HR ,664 1,744 1,928 # 12 HR ,245 2,510 2,774 # HR ,189 1,321 1,858 # 12 HR ,110 1,858 1,981 # 12 HR ,906 3,963 4,755 # 12 HR ,585 1,717 1,849 # HR ,057 1,215 1,506 # 12 HR ,030 1,585 1,955 # HR ,113 2,378 2,642 # 12 HR ,378 3,434 4,227 # HR ,110 1,427 # 12 HR ,453 1,849 # HR ,453 1,585 1,796 # 12 HR ,849 2,193 2,245 # 12 HR ,347 # HR N/A 660 1,057 # HR ,268 # HR # HR # HR ,113 2,906 3,698 # 12 HR ,453 1,638 1,744 # 12 HR ,585 1,981 2,378 # 12 HR ,321 1,479 1,638 # 12 HR ,321 1,717 2,113 # HR ,136 1,249 1,532 # HR ,057 1,321 # HR ,110 #

13 For Solar Direct Systems Nominal Voltage is Volts Maximum Open Circuit Voltage is 100 Volts Example: 2) 90 Watt 12Volt Panels wired in series = 180 Watt at 24 Volts How Daily Water Volume is Calculated Daily volume is calculated by integrating real flow versus realistic solar panel output throughout the day. The solar array is fixed at a tilted angle = latitude of the location kwh/m2/day = Peak sunlight hours/day Flow Rates may vary by +/- 10% Solar tracker array will increase daily water production by 40-50% in the summer. PS200 Panel Configurations (Maximum Open Circuit Voltage - 100V ) Panel Model # of Panels Panel Wtg. Nominal Voltage Open Circuit Voltage Total Wtg. Total Series Nominal Total Series Open Circuit Total Parallel Nominal Total Parallel Open Circuit Total Series- Parallel Nominal Total Series- Parallel Open Circuit LA-90-12V LA V LA M LA-90-12V LA V LA-90-12V LA M LA V LA-90-12V LA V LA-90-12V LA M LA-90-12V LA V LA-90-12V LA M LA V LA-90-12V LA V LA M LA-90-12V LA V LA-90-12V LA M

14 PS600 (HR)Helical Rotor or (C)4" Submersible Characteristics Lifts up to 600 Feet Flow rates up to 35,135 GPD or 2,930 GPH Simple Installation Maintenance Free High Reliablility and Long Life Expectancy Cost Efficient Pumping Applications Livestock Watering Wildlife Watering Dirt Tank Floating Pump Pond Management Irrigation Residential Wells PS600 Controller Features PS600 Controller is mounted at the surface just like a standard 4" control box. The controller is sealed and weatherproof (Nema 3R) Its purpose is to control the pump system and displays the operating status of the system. Each control is equipped with two control inputs: One allows for the Dry Well Probes sensor to prevent dry run or pump off conditions the other allows for a float, pressure, or remote control switch to be used. Once the Dry Well Probe sensor trips, the controller will shut down the pump system for 20 minutes to allow the well to recover, then it will automatically restart the system. The controller is equipped with overload, underload, & reverse polarity protection. Each contol comes with Variable Speed Control which allows the pump speed to be adjusted to reduce flow rate by approximately 30%. Maximum Power Point Tracking for Solar Operation. Battery Low Voltage disconnect and auto-restart after battery has recovered. Motor & Controller are 92% Efficient EC Drive 600(HR)&(C) Motor Features Brushless DC Motor No Electronics inside the Motor Water Filled Design IP68, Pressure balanced, max submergence is unlimited. Dynamic Carbon/Ceramic Thrust Bearings Submerged Materials are 316 Stainless Steel Drinking Water Approved 4" Submersible Pump Features Long Life Expectancy Built in Check Valve Dry Run Protection (Dry Well Probe Sensor) 316 Stainless Steel Construction Helical Rotor Pump Features Positive Displacement design Self Cleaning Two main parts that are field serviceable (Stator & Rotor) Stator is constructed of abrasion resistant rubber Rotor is constructed of stainless steel and then hard chrome plated to resist abrasion. Design is more resistant to sand damage than other pump types 14

15 Performance Overview PS600 HR-03 HR-03H HR-04 HR-04H HR-07 HR-10 HR-14 HR-20 C-SJ5-8 C-SJ8-5 Max Lift (Feet) Max Flow Rate (GPH) ,981 2,906 Max Efficiency % 60% 64% 60% 65% 64% 64% 65% 64% 47% 47% Solar Operation Nominal Voltage is Volts DC - Maximum Open Circuit Voltage is 150 Volts DC Solar Panels (Wp) PS600 TECHNICAL DATA (DIMENSIONS & WEIGHTS) Dimensions Shipping Dimensions Pump Inches Cubic Feet Pounds Unit L A B D S Packaging Shipping Volume Net Weight Gross Weight PS600-HR / X 6.3 X PS600-HR-03H / X 6.3 X PS600-HR / X 6.3 X PS600-HR-04H / X 6.3 X PS600-HR / X 6.3 X PS600-HR / X 6.3 X PS600-HR / X 6.3 X PS600-HR / X 6.3 X C-SJ / X 6.3 X C-SJ X 6.3 X PS600 Controller X 9.84 X Sand & Silt Tolerance The Helical Rotor pump has a higher resistance to wear from sand, clay, etc. than any other pump type. In properly constructed wells the amount of sand, clay, etc. is within the tolerance of the pump. A concentration of solids greater than 2% by volume may cause blockage in the pump or the drop pipe, especially at low flow rates. Do not use the pump to develop newly drilled wells. Pump Cable & Splice Standard double jacketed submersible cable 3 wire + ground is recommended. Standard rubber tape with Scotch Kote or heat shrink splice kits are recommended. Drop Pipe The PS200 pump ends are fitted with an 1.25 inch outlet. If the water is dirty, consider a smaller size drop pipe to increase the flow velocity. This helps exhaust solid particles and prevent accumulation in the pipe. When considering reduced pipe size, consult a friction loss chart. We do recommend a torque arrestor. Temperature Limits Pump end & Motor can withstand up to 104oF Water Temperatures Please specify if water temperature exceeeds 104oF Controller ambient temperature is (-22oF to 131oF) 15

16 Solar Panels Vertical Lift (Feet) 16 ft. 33 ft. 50 ft. 65 ft. 100 ft. 133 ft. 165 ft. 200 ft. Array Mounting Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Flow Rate Gallons Per Day 300 Wp ,888 17,171 5,019 7,133 5,019 6,868 3,963 5,812 1,981 2,510 1,638 2,298 1,585 2,087 1,242 1,796 Irradiation kwh/ 6 10,039 13,737 3,963 5,812 3,963 5,283 2,906 4,227 1,638 2,166 1,427 1,955 1,268 1, ,400 m2/day 4.5 7,661 10,039 3,170 4,227 2,906 3,963 1,849 2,378 1,321 1,796 1,189 1, , ,004 Pump Model C-SJ8-5 HR-14 HR-04 Peak Flow Rate - GPM Wire Size/Max. Length # 10 is good to 330 Ft. 350 Wp ,737 20,605 5,812 7,925 6,076 7,661 4,755 6,868 3,698 5,283 1,796 2,298 1,611 2,193 1,506 2,087 Irradiation kwh/ 6 11,359 16,379 5,019 6,868 4,755 6,340 3,963 5,283 2,642 3,698 1,717 2,193 1,453 1,981 1,268 1,823 m2/day 4.5 8,718 11,624 4,227 5,812 3,698 5,019 2,642 3,698 1,585 2,113 1,585 2,113 1,242 1,638 1,057 1,479 Pump Model C-SJ8-5 HR-14 HR-04 Peak Flow Rate - GPM Wire Size/Max. Length # 10 is good to 330 Ft. 420 Wp ,850 23,775 6,868 8,189 6,340 7,925 5,283 7,661 4,227 6,076 2,298 3,434 1,796 2,298 1,611 2,193 Irradiation kwh/ 6 13,209 19,020 5,812 7,133 5,019 6,604 4,491 6,340 3,170 4,491 1,981 2,906 1,585 2,087 1,427 1,902 m2/day ,303 14,001 4,491 6,340 3,963 5,548 3,698 5,019 2,113 2,906 1,717 2,298 1,321 1,849 1,189 1,585 Pump Model C-SJ8-5 HR-14 HR-07 HR-04 Peak Flow Rate - GPM Wire Size/Max. Length # 10 is good to 330 Ft. 480 Wp ,435 25,096 8,982 12,944 7,925 11,359 5,812 7,925 4,755 6,868 3,698 4,227 2,906 4,227 2,298 3,434 Irradiation kwh/ 6 14,794 21,134 7,397 10,039 6,340 8,454 5,019 7,133 3,963 5,019 2,642 3,698 2,245 3,170 1,849 2,642 m2/day ,624 15,850 5,812 7,397 4,755 6,340 3,963 5,548 3,170 4,227 1,849 2,510 1,453 1,981 1,321 1,717 Pump Model C-SJ8-5 C-SJ5-8 HR-14 HR-07 HR-04 # 10 / 280Ft. Peak Flow Rate - GPM Wire Size/Max. Length # 10 is good to 130 Ft. # 8 is good to 260 Ft. 660 Wp ,662 29,587 15,850 22,719 10,039 15,058 6,868 7,925 5,812 7,661 4,491 6,604 3,698 5,019 2,589 3,804 Irradiation kwh/ 6 18,756 25,889 13,209 18,492 8,454 12,152 6,076 7,661 4,755 6,340 3,698 5,019 2,906 3,963 2,245 3,170 m2/day ,794 19,549 9,246 12,416 6,340 8,718 5,019 6,604 3,698 5,019 2,642 3,698 2,113 2,642 1,849 2,510 Pump Model C-SJ8-5 C-SJ5-8 HR-14 HR-07 Peak Flow Rate - GPM Wire Size/Max. Length # 10 is good to 130 Ft. # 8 is good to 265Ft. 720 Wp ,983 33,022 17,435 24,568 11,095 16,114 8,718 12,416 6,340 7,925 5,283 7,661 4,755 6,868 2,906 3,698 Irradiation kwh/ 6 20,077 28,002 14,265 20,605 9,246 13,209 6,868 9,510 5,283 6,868 4,755 6,604 3,698 5,019 2,642 3,698 m2/day ,586 21,134 10,303 14,001 6,604 8,982 5,812 7,925 4,491 6,076 4,227 5,548 2,378 3,170 2,378 3,170 Pump Model C-SJ8-5 C-SJ5-8 HR-14 HR-07 Peak Flow Rate - GPM Wire Size/Max. Length # 10 is good to 130 Ft. # 8 is good to 300 Ft. Instructions 1. Lift: Find the lift you require and read the column below it. 2. Daily Volume: Find the daily volume you require at an irradiation of 4.5, 6, or 7.5 kwh/m2/day. 7.5 is a moderately dry summer weather. For more water add more watts or consider a tracker. 3. Pipe Sizing: Use peak flow rate for pipe sizing. 4. Wire Sizing - Max Length System Voltage Volts is nominal (Maximum Open Circuit Voltage is 150V DC) Example: 6) 90W-12V panels wired in series would be 540W at 72 Volts. Lift Limits These systems are selected for optimum performance. To allow for unexpected drawdown, each system can handle an additional 15% of lift. Wire Sizes Cable size is calculated to stay within 4% voltage loss. Variations in Wire Length Longer: For each 50% increase the next larger wire size is required. Shorter: For each 33% decrease the next smaller wire size is required. Array to controller: # 10 is good to 20 Ft. Controller to Dry Well Probe: # 18 is recommended. 16

17 230 ft. 265 ft. 300 ft. 330 ft. 400 ft. 460 ft. 530 ft. 600 ft. Vertical Lift (Feet) Solar Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Array Mounting Panels Flow Rate Gallons Per Day 1,004 1, , , , Irradiation kwh/ 793 1, m2/day HR-03 HR-03 Pump Model 300 Wp Peak Flow Rate - GPM # 10 is good to 330 Ft. # 8 is good to 450 Ft. Wire Size/Max. Length 1,294 1,796 1,004 1, , , , , Irradiation kwh/ 1,083 1, , , , m2/day 925 1, , HR-04 HR-03 Pump Model 350 Wp Peak Flow Rate - GPM # 10 is good to 330 Ft. # 8 is good to 450 Ft. Wire Size/Max. Length 1,506 2,008 1,242 1,823 1,189 1,427 1,057 1, , , Irradiation kwh/ 1,268 1,691 1,030 1, , , , m2/day 1,057 1, , , HR-04 HR-04H HR-03 HR-03H Pump Model 420 Wp Peak Flow Rate - GPM # 10 is good to 330 Ft. # 8 is good to 450 Ft. # 6 is good to 600 Ft. Wire Size/Max. Length 1,611 2,298 1,506 2,166 1,453 2,113 1,321 1,849 1,189 1, , , Irradiation kwh/ 1,453 1,955 1,268 1,770 1,162 1,717 1,004 1, , , m2/day 1,189 1,585 1,030 1, , HR-04 HR-04H HR-03 HR-03H Pump Model 480 Wp Peak Flow Rate - GPM # 8 is good to 260 Ft. # 6 is good to 600 Ft. Wire Size/Max. Length 2,298 3,302 2,113 3,038 1,717 2,113 1,453 2,061 1,347 1,955 1,189 1, Irradiation kwh/ 1,928 2,774 1,717 2,430 1,453 1,955 1,294 1,770 1,057 1, ,321 6 m2/day 1,585 2,245 1,321 1,849 1,189 1,585 1,136 1, , HR-07 HR-04H Pump Model 660 Wp Peak Flow Rate - GPM # 8 is good to 265Ft. # 6 is good to 420 Ft. Wire Size/Max. Length 2,642 3,698 2,483 3,698 2,298 3,434 1,585 2,113 1,506 2,113 1,400 1, Irradiation kwh/ 2,378 3,434 2,166 3,170 1,955 2,906 1,532 1,849 1,321 1,717 1,162 1,559 6 m2/day 2,113 2,906 1,849 2,510 1,585 2,140 1,453 1,611 1,057 1, , HR-07 HR-04H Pump Model 720 Wp Peak Flow Rate - GPM # 8 is good to 300 Ft. # 6 is good to 500 Ft. Wire Size/Max. Length Vertical Lifts higher than 330Ft. For lifts that are higher than 330 Ft. please compare the wire sizes of the PS1200 system. Due to higher system voltage the use of smaller wire is possible and might reduce the overall system cost. Calculations of Daily Water Volume Daily volume is calculated by intergrating real flow versus realistic solar output throughout the day. Calculations include a 10% PV output degradation to allow for losses due to heat, dirt, etc. Cable losses are included at maximum allowable length. The solar array is fixed ar a tilted angle equal to the latitude of the location. Irradiation: kwh/m2/day = peak sunlight hours/day Flow Rates may vary +/- 10% 17

18 PS600 Panel Configurations (Maximum Open Circuit Voltage - 150V ) Panel # of Panel Nominal Open Circuit Total Total Series Total Series Total Parallel Total Parallel Total Series- Parallel Total Series- Parallel Model Panels Wtg. Voltage Voltage Wtg. Nominal Open Circuit Nominal Open Circuit Nominal Open Circuit LA-90-12V LA V LA M LA-90-12V LA V LA-90-12V LA M LA V LA-90-12V LA V LA-90-12V LA M LA-90-12V LA V LA-90-12V LA M LA V LA-90-12V LA V LA M LA-90-12V LA V LA-90-12V LA M

19 PS600 Panel Configurations (Maximum Open Circuit Voltage - 150V ) Panel # of Panel Nominal Open Circuit Total Total Series Total Series Total Parallel Total Parallel Total Series- Parallel Total Series- Parallel Model Panels Wtg. Voltage Voltage Wtg. Nominal Open Circuit Nominal Open Circuit Nominal Open Circuit LA-90-12V LA-90-12V LA V LA M LA-90-12V LA V LA-90-12V LA M LA V LA-90-12V LA V LA M LA-90-12V LA V LA M LA V LA M LA V LA M LA M LA M LA M PS600 HR-14 (Item-No X) Solar Operation (Solar generator: Nominal voltage 48 to 72V DC, open circuit voltage max. 150V DC) 19

20 PS1200 (HR)Helical Rotor or (C)4" Submersible Characteristics Lifts up to 787 Feet Flow rates up to 41,607 GPD or 5,600 GPH Simple Installation Maintenance Free High Reliablility and Long Life Expectancy Cost Efficient Pumping Applications Livestock Watering Wildlife Watering Dirt Tank Floating Pump Pond Management Irrigation Residential Wells PS1200 Controller Features PS1200 Controller is mounted at the surface just like a standard 4 control box. The controller is sealed and weatherproof (Nema 3R) Its purpose is to control the pump system and displays the operating status of the system. Each control is equipped with two control inputs: One allows for the Dry Well Probes sensor to prevent dry run or pump off conditions the other allows for a float, pressure, or remote control switch to be used. Once the Dry Well Probe sensor trips, the controller will shut down the pump system for 20 minutes to allow the well to recover, then it will automatically restart the system. The controller is equipped with overload, underload, & reverse polarity protection. Each contol comes with Variable Speed Control which allows the pump speed to be adjusted to reduce flow rate by approximately 30%. Maximum Power Point Tracking for Solar Operation Battery Low Voltage disconnect and auto-restart after battery has recovered. Motor & Controller are 92% Efficient EC Drive 1200(HR)&(C) Motor Features Brushless DC Motor No Electronics inside the Motor Water Filled Design IP68, Pressure balanced, max submergence is unlimited. Dynamic Carbon/Ceramic Thrust Bearings Submerged Materials are 316 Stainless Steel Drinking Water Approved 4 Submersible Pump Features Long Life Expectancy Built in Check Valve Dry Run Protection (Dry Well Probe Sensor) 316 Stainless Steel Construction Helical Rotor Pump Features Positive Displacement design Self Cleaning Two main parts that are field serviceable (Stator & Rotor) Stator is constructed of abrasion resistant rubber Rotor is constructed of stainless steel and then hard chrome plated to resist abrasion. Design is more resistant to sand damage than other pump types 20

21 Performance Overview PS1200 HR-03 HR-03H HR-04 HR-04H HR-07 HR-10 HR-14 HR-20 C-SJ5-8 C-SJ8-5 C-SJ12-3 Max Lift (Feet) Max Flow Rate (GPH) ,981 2,906 5,548 Max Efficiency % 60% 64% 60% 65% 64% 64% 65% 64% 48% 48% 48% Solar Operation Nominal Voltage is Volts (Maximum Open Circuit Voltage is 200 Volts DC) Solar Panels (Wp) , , , , , , , ,200 PS1200 Technical Data (Dimensions & Weights) Dimensions Shipping Dimensions Pump Inches Cubic Feet Pounds Unit L A B D S Packaging Shipping Volume Net Weight Gross Weight PS1200-HR / X 6.3 X PS1200-HR-03H / X 6.3 X PS1200-HR / X 6.3 X PS1200-HR-04H / X 6.3 X PS1200-HR / X 6.3 X PS1200-HR / X 6.3 X PS1200-HR / X 6.3 X PS1200-HR / X 6.3 X C-SJ / X 6.3 X C-SJ X 6.3 X C-SJ X 6.3 X PS1200 Controller Sand & Silt Tolerance The Helical Rotor pump has a higher resistance to wear from sand, clay, etc. than any other pump type. In properly constructed wells the amount of sand, clay, etc. is within the tolerance of the pump. A concentration of solids greater than 2% by volume may cause blockage in the pump or the drop pipe, especially at low flow rates. Do not use the pump to develop newly drilled wells. Pump Cable & Splice Standard double jacketed submerisble cable 3 wire + ground is recommended. Standard rubber tape with Scotch Kote or heat shrink splice kits are recommended. Drop Pipe The PS1200 pump ends are fitted with an 1.25 inch outlet. If the water is dirty, consider a smaller size drop pipe to increase the flow velocity. This helps exhaust solid particles and prevent accumulation in the pipe. When considering reduced pipe size, consult a friction loss chart. We do recommend a torque arrestor. Temperature Limits Pump end & Motor can withstand up to 104oF Water Temperatures Please specify if water temperature exceeeds 104oF Controller ambient temperature is (-22oF to 131oF) 21

22 Solar Panels Vertical Lift (Feet) 16 ft. 33 ft. 50 ft. 65 ft. 100 ft. 133 ft. 165 ft. 200 ft. 230 ft. Array Mounting Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Flow Rate Gallons Per Day 350Wp Irradiation kwh/ m2/day ,737 20,605 5,812 7,925 6,076 7,661 4,755 6,868 3,698 5,283 1,796 2,298 1,611 2,193 1,506 2,087 1,294 1, ,359 16,379 5,019 6,868 4,755 6,340 3,963 5,283 2,642 3,698 1,717 2,193 1,453 1,981 1,268 1,823 1,083 1, ,718 11,624 4,227 5,812 3,698 5,019 2,642 3,698 1,585 2,113 1,585 2,113 1,242 1,638 1,057 1, ,268 Pump Model C-SJ8-5 HR-14 HR-04 Peak Flow Rate - GPM Wire Size/Max. Length # 12 is good to 230 Ft. 420 Wp Irradiation kwh/ m2/day ,850 23,775 6,868 8,189 6,340 7,925 5,283 7,661 4,227 6,076 2,298 3,434 1,796 2,298 1,611 2,193 1,506 2, ,209 19,020 5,812 7,133 5,019 6,604 4,491 6,340 3,170 4,491 1,981 2,906 1,585 2,087 1,427 1,902 1,268 1, ,303 14,001 4,491 6,340 3,963 5,548 3,698 5,019 2,113 2,906 1,717 2,298 1,321 1,849 1,189 1,585 1,057 1,427 Pump Model C-SJ8-5 HR-14 HR-07 HR-04 Peak Flow Rate - GPM Wire Size/Max. Length # 12 is good to 230 Ft. 480 Wp Irradiation kwh/ m2/day ,435 25,096 8,982 12,944 7,925 11,359 5,812 7,925 4,755 6,868 3,698 5,283 2,906 3,698 2,298 3,434 1,611 2, ,794 21,134 7,397 10,039 6,340 8,454 5,019 7,133 3,963 5,019 2,642 3,698 2,245 3,170 1,849 2,642 1,453 1, ,624 15,850 5,812 7,397 4,755 6,340 3,963 5,548 3,170 4,227 1,849 2,510 1,453 1,981 1,321 1,717 1,189 1,585 Pump Model C-SJ8-5 C-SJ5-8 HR-14 HR-07 Peak Flow Rate - GPM Wire Size/Max. Length # 12 is good to 200 Ft. Irradiation kwh/ m2/day ,662 29,587 15,850 22,719 10,039 15,058 6,868 7,925 5,812 7,661 4,491 6,604 3,698 5,019 2,589 3,698 2,298 3, ,756 25,889 13,209 18,492 8,454 12,152 6,076 7,661 4,755 6,340 3,698 5,019 2,906 3,963 2,245 3,170 1,928 2, Wp ,794 19,549 9,510 12,416 6,340 8,718 5,019 6,604 3,698 5,019 2,642 3,698 2,113 2,642 1,849 2,510 1,585 2,245 Pump Model C-SJ8-5 C-SJ5-8 HR-14 HR-07 Peak Flow Rate - GPM Wire Size/Max. Length # 12 is good to 150 Ft. # 10 is good to 450 Ft. 720 Wp Irradiation kwh/ m2/day ,983 33,022 17,435 24,568 11,095 16,114 8,718 12,416 6,340 7,925 5,283 7,661 4,755 6,868 2,906 3,698 2,642 3, ,077 28,002 14,265 20,605 9,246 13,209 6,868 9,510 5,283 6,868 4,755 6,604 3,698 5,019 2,642 3,698 2,378 3, ,586 21,134 10,303 14,001 6,604 8,982 5,812 7,925 4,491 6,340 4,227 5,548 2,378 3,170 2,378 3,170 2,113 2,906 Pump Model C-SJ8-5 C-SJ5-8 HR-14 HR-07 Peak Flow Rate - GPM Wire Size/Max. Length # 10 is good to 500 Ft. 840 Wp Irradiation kwh/ m2/day ,361 35,135 19,549 29,059 15,058 22,455 10,567 15,850 6,340 7,925 5,812 7,925 5,019 7,133 3,698 5,283 2,642 3, ,190 29,059 16,643 24,040 11,888 17,171 8,718 12,416 5,812 7,661 5,548 7,397 4,227 6,076 3,170 4,491 2,642 3, ,964 24,304 12,152 16,379 7,925 10,831 6,604 8,982 5,283 6,868 4,755 6,340 3,434 4,755 2,642 3,698 2,378 3,434 Pump Model C-SJ8-5 C-SJ5-8 HR-14 HR-10 HR-07 Peak Flow Rate - GPM Wire Size/Max. Length # 10 is good to 500Ft. 1,000 Wp Irradiation kwh/ m2/day ,305 54,155 22,190 33,022 17,435 26,417 11,359 15,850 8,982 12,680 6,076 7,925 5,548 7,661 4,491 6,604 3,698 5, ,342 48,872 19,285 27,738 14,529 20,605 8,982 11,888 7,133 9,510 5,812 7,397 4,755 6,604 3,698 5,548 3,170 4, ,210 36,984 12,416 17,171 10,303 13,473 6,868 8,718 6,076 8,189 5,283 6,604 3,963 5,283 3,170 4,227 2,642 3,698 Pump Model C-SJ12-3 C-SJ8-5 *C-SJ5-8 HR-14 HR-10 Peak Flow Rate - GPM Wire Size/Max. Length # 10 is good to 500Ft. Instructions 1. Lift: Find the lift you require and read the column below it. 2. Daily Volume: Find the daily volume you require at an irradiation of 4.5, 6, or 7.5 kwh/m2/day. 7.5 is a moderately dry summer weather. For more water add more watts or consider a tracker. 3. Pipe Sizing: Use peak flow rate for pipe sizing. 4. Wire Sizing - Max Length System Voltage Volts is nominal (Maximum Open Circuit Voltage is 200V DC) Example: 8) 90W-12V panels wired in series would be 720W at 96 Volts. Lift Limits These systems are selected for optimum performance. To allow for unexpected drawdown, each system can handle an additional 15% of lift. Wire Sizes Cable size is calculated to stay within 4% voltage loss. 22

23 265 ft. 300 ft. 330 ft. 400 ft. 460 ft. 530 ft. 600 ft. 660 ft. 760 ft. Vertical Lift (Feet) Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Fixed Tracker Array Mounting Solar Panels Flow Rate Gallons Per Day 1,004 1, , , , , , , , , HR-03 Irradiation kwh/ m2/day Pump Model 350Wp Peak Flow Rate - GPM # 10 is good to 500 Ft. Wire Size/Max. Length 1,242 1,823 1,189 1,427 1,057 1, , , ,030 1, , , , , , Irradiation kwh/ m2/day HR-04H HR-03 HR-03H Pump Model 420 Wp Peak Flow Rate - GPM # 10 is good to 500 Ft. # 8 is good to 750 Ft. Wire Size/Max. Length 1,506 2,166 1,453 2,113 1,321 1,849 1,189 1, , , ,268 1,770 1,162 1,717 1,004 1, , , ,030 1, , Irradiation kwh/ m2/day HR-04H HR-03 HR-03H Pump Model 480 Wp Peak Flow Rate - GPM # 10 is good to 500Ft. # 8 is good to 750 Ft. Wire Size/Max. Length 2,113 3,038 1,717 2,113 1,453 2,061 1,347 1,955 1,189 1, , , , ,717 2,430 1,453 1,955 1,294 1,770 1,057 1, , , Irradiation kwh/ m2/day 1,321 1,849 1,189 1,585 1,136 1, , HR-07 HR-04H HR-03H Pump Model 660 Wp Peak Flow Rate - GPM # 10 is good to 450 Ft. # 8 is good to 750 Ft. Wire Size/Max. Length 2,483 3,698 2,298 3,434 1,585 2,113 1,506 2,113 1,400 1, , , , , ,166 3,170 1,955 2,906 1,532 1,849 1,321 1,717 1,162 1, , , , ,849 2,510 1,585 2,140 1,453 1,611 1,057 1, , , , Irradiation kwh/ m2/day HR-07 HR-04H HR-03H Pump Model 720 Wp Peak Flow Rate - GPM # 10 is good to 500 Ft. # 8 is good to 750 Ft. Wire Size/Max. Length 2,642 4,491 2,483 3,698 2,113 3,170 1,902 2,906 1,585 1,902 1,110 1,374 1,057 1, , , ,351 3,170 2,219 3,170 1,928 2,642 1,717 2,378 1,374 1,691 1,030 1, , , , ,061 2,642 1,928 2,589 1,717 2,325 1,453 1,955 1,162 1, , , , , Irradiation kwh/ m2/day HR-07 HR-04H HR-03H Pump Model 840 Wp Peak Flow Rate - GPM # 10 is good to 500Ft. # 8 is good to 750 Ft. Wire Size/Max. Length 3,434 4,755 2,642 3,698 2,378 3,434 2,245 3,170 1,717 2, ,906 3,963 2,378 3,170 2,113 2,906 2,008 2,906 1,532 1, ,378 3,170 2,113 2,906 1,849 2,510 1,770 2,378 1,321 1, Irradiation kwh/ m2/day HR-10 HR-07 HR-04H Pump Model 1,000 Wp Peak Flow Rate - GPM # 10 is good to 500Ft. Wire Size/Max. Length Variations in Wire Length Longer: For each 50% increase the next larger wire size is required. Shorter: For each 33% decrease the next smaller wire size is required. Array to controller: # 10 is good to 20 Ft. Controller to Dry Well Probe: # 18 is recommended. Calculations include a 10% PV output degradation to allow for losses due to heat, dirt, etc. Cable losses are included at maximum allowable length. The solar array is fixed ar a tilted angle equal to the latitude of the location. Irradiation: kwh/m2/day = peak sunlight hours/day Calculations of Daily Water Volume Daily volume is calculated by intergrating real flow versus realistic solar output throughout the day. 23