Overview Domestic / Asian and 2012 European Release

Transcription

1 Version Overview Domestic / Asian and 2012 European Release The focus of this Domestic, Asian and European release: Add coverage for 2013 Model Year for Domestic and Asian, 2012 Model Year for European vehicles. Targeting systems, actuation and adjustment coverage for for all OEM s (vehicles out of warranty). Maintaining the momentum on actuation and adjustment coverage improvements for all years. Giving priority to special functions required for Maintenance Tests that support critical service repairs. For a detailed view of the coverage per OEM go to and select the individual application guides. Did You Know?: The Genisys / Nemisys registration site address has changed! For future growth and user experience changes the website address to the registration site has changed to toolreg.servicesolutionsportal.com/. You can go to the site even after registration to check for any updates that may be available, download the updates and change registration information if you moved, changed , etc. New Vehicle Coverage: This Asian Domestic and European update is a significant improvement to the product in terms of coverage years and actuation and adjustment capability. Coverage includes the following: Coverage Highlights for newly added Model Years Overview Domestic 2013 Added coverage through 2013 for all supported manufacturers Expanded systems coverage for many older Chrysler/Jeep and GM vehicles Added coverage for 1,065 new systems - DRAFT - Page 1

2 Added coverage for 2,762 new vehicle-ecu combinations Added coverage for 4,096 new Actuation tests Added coverage for 561 new Adjustment tests 178 new Manufacturer specific descriptions for OBDII Mode 6 parameters Updated Repair Information for the following: o 5,000 new Repair-Trac fixes o 28% more Code-Assist Library confirmed fixes o DTC Circuit Description o DTC Possible Causes o Code Info o Data Item Circuit Description o Data Item Operating Ranges o PCM Connector Pin Information (B.O.B) o Updated ABS Brake Bleed Procedures for all manufacturers o Updated Oil Light Reset Procedures for all manufacturers. Overview Asian 2013 Added coverage through 2013 for all supported manufacturers Expanded systems coverage for many older Hyundai, Kia, Mazda, Nissan and Toyota vehicles Added coverage for 534 new systems Added coverage for 2,183 new vehicle-ecu combinations Added coverage for 2,658 new Actuation tests Added coverage for 207 new Adjustment tests 281 new Manufacturer specific descriptions for OBDII Mode 6 parameters Updated Repair Information for the following: o 5,000 new Repair-Trac fixes o 28% more Code-Assist Library confirmed fixes o Data Item Circuit Description - Toyota, Scion, Nissan, Infiniti, Honda, Acura, Mazda, Mitsubishi o Data Item Operating Ranges - Toyota, Nissan, Infiniti, Honda, Acura, Mazda, Mitsubishi - DRAFT - Page 2

3 o Updated ABS Brake Bleed Procedures for all manufacturers o Updated Oil Light Reset Procedures for all manufacturers. Overview European 2012 Added coverage through 2013 for Fiat, 2012 for all other supported manufacturers New coverage for Smart vehicles! Expanded systems coverage for many older BMW, Mercedes and Volvo vehicles Added coverage for 364 new systems Added coverage for 3,517 new vehicle-ecu combinations Added coverage for 2,796 new Actuation tests Added 225 new Adjustment tests 22 new Manufacturer specific descriptions for OBDII Mode 6 parameters Updated Repair Information for the following: o 5,000 new Repair-Trac fixes o 28% more Code-Assist Library confirmed fixes o Updated ABS Brake Bleed Procedures for all manufacturers o Updated Oil Light Reset Procedures for all manufacturers. Overview Maintenance Tests As the complexity of vehicle diagnostics continues to grow, vehicles are requiring routine maintenance tests, such as replacing brake system components, performing wheel alignments, TPMS sensor registrations, etc. For many technicians (especially non-scan tool savvy technicians) finding these tests within specific system controllers can be difficult at best, OEM s put these crucial tests into many controllers. This critical test lookup has been added as a quick access function key from the controller screen of the selected vehicle. The function key is called Maintenance. When selected the screen lists the controller(s) that contain the very important maintenance tests for the selected vehicle. The list is live as per the selected vehicle, allowing the user quick access to these critical tests. Maintenance tests are broken down into categories to aid the technician in speedy location of the correct controller. Maintenance Test Categories are: TPMS Registration Service Light Reset - DRAFT - Page 3

4 Steering Service Brake Service Battery/Charging Suspension Service In this release we continued focusing on developing these important tests for all supported OEM s, specific examples are: BMW - Battery Exchange Register, Calibrate Lateral Accel Sensor, Front Brake Zeroing, Inspection/Service Interval Reset, Oil Service Reset, Parking Brake tests, Rear Brake Zeroing, TPMS Registration Chrysler/Jeep - Alternator Field Control, ABS Brake Bleeds, Height Sensor Check, Set Ride Height Level, Steering Angle Sensor Calibration, TPMS Registration Fiat - Clear Steering Pull Compensation Ford - Automated Bleed, Battery Monitor System Reset, Battery Saver Relay, Calibrate Lateral Accel Sensor, Calibrate Longitudinal Accel Sensor, IVD Sensor Calibration, Yaw Rate Sensor Calibration GM - Brake Bleeds, Fuel Filter Life Reset, Oil Life Reset, Park Brake Cable Service Apply and Release, Power Steering Softstops Reset, Reset Trans Oil Life, Steering Angle Sensor, TPMS Registration Honda - ATF Reset, Oil Life Reset, Steering Angle Sensor Calibration, TPMS Registration Hyundai - Air Bleeding Mode, ASP Calibration, Pressure Sensor Calibration, Steering Angle Sensor, TPMS Registration Kia - Electric Park Brake Actuator Control Apply and Release, Air Bleeding Mode, TPMS Registration Mazda - Automated Bleed, IVD Sensor Calibration, TPMS Registration Mercedes - Clear Maintenance Intervals, Electric Parking Brake tests, Suspension tests, TPMS Registration Mitsubishi - All Sensor Calibration, Brake Bleeds, Steering Angle Sensor Calibration Nissan - ABS Bleeds, Steering Angle Sensor Calibration, TPMS Registration, Zero Point Calibration Smart - Alternator test - DRAFT - Page 4

5 Toyota - ABS Bleeds, Battery Current Sensor Initialization, Suspension tests, Torque Sensor Adjustment, TPMS Registration, Zero Point Calibration Volvo - Parking Brake service tests, Steering Angle calibration tests, Oil Light Reset tests, TPMS Registration For a detailed view of the Maintenance Tests coverage per OEM go to and select the individual application guides. IMPORTANT NOTE: These unique test and coverage functions go across thousands of vehicle models and car lines. New Coverage - USA Domestic New Expanded Systems Coverage and Special Tests for US Domestic vehicles added with focus on vehicles. Special Tests include among others, actuator tests (bidirectional) and vehicle adjustments, like Steering Angle, TPMS, Brake Bleed, etc. Domestic OEM Specific Information: GM\Saturn Coverage Complete coverage added for 2013MY vehicles Expanded systems coverage for Suspension Control, Steering Wheel Angle Sensor and Multi-Axis Accel Sensor modules. Improved coverage of HVAC and Instrument Panel tests for new Mode 6 GM specific descriptions 778 new systems covered 1,966 new vehicle-ecu combinations 1,605 new Actuation tests, including: o Trans solenoids o 4WD solenoids o ABS solenoids o Lamp tests o Air Pump tests o Fan tests o Injectors - DRAFT - Page 5

6 o Fuel Injector Balance o Fuel Pump tests o EVAP solenoids o EVAP Purge/Seal o Evap Service Bay o EVAP Service Test o Variable Camshaft tests o Cylinder Power Balance o Desired Rail Pressure o EGR tests o O2 Sensor Heater tests o Gauge tests 244 new Adjustment tests, including: o Actuator Recalibration o Automated Bleed o Brake Pedal Position Sensor Calibration o Brake Pressure Sensor Calibration o CAN Bus Configuration Learn o Clear Column Softstops o Clear Trans Adaptives tests o Clear Window Learned Values o Clutch Pedal Position Learn o Configure New Module o Control Module Reset o Crankshaft Learn o DPF Pressure Sensor Reset o DPF Service Regeneration o Fuel Filter Life Reset o Fuel Trim Reset o HO2S Heater Learn - DRAFT - Page 6

7 o HVAC Afterblow Configuration o Hybrid/EV Battery Pack Capacity Learn o Hybrid/EV Battery Pack Capacity Reset o Hybrid/EV Battery Pack Coolant Control Solenoid Valve Learn o Hybrid/EV Battery Pack Data Reset o Idle Learn Reset o Learn Column Softstops o NOx Sensor Reset o Oil Life Reset o Park Brake Cable Replacement Procedure o Passenger Presence Sensor Learn o Power Steering Softstops Reset o Recalibrate All Motors (HVAC) o Reductant Injector Reset o Reductant System Data Reset o Reductant System Reset o Reset Injection Value tests o Reset Transmission Adapts o Reset Transmission Oil Life o Setup New ROS o Setup New SDM o Steering Angle Sensor Centering o Steering Wheel Angle Sensor Learn o Tire Pressure Sensor Registration o Transmission Adaptive Pressure Reset o Transmission Adaptive Values Learn o VIN Relearn o Yaw Rate Sensor Learn o Yaw Rate Sensor Recalibration - DRAFT - Page 7

8 Ford Coverage Complete coverage added for 2013MY vehicles Coverage added for critical new test "Central Configuration Data Parameter (CDP) Learning". This must be run after a PCM or BCM module is replaced, to learn the Central Vehicle Configuration values. Coverage added for critical new test "Clear Misfire Monitor Profile Correction". This must be run after internal engine repairs are done, or the PCM is replace, or the CKP sensor is replaced. Coverage added for critical new test for L diesel PCM, including SCR Emptying, Reset Selective Catalyst Reductant (SCR) Parameters, Line Pressure Control Measured In Current, Reset EGR (Exhaust Gas Recirculation) Throttle Parameters, Reset Exhaust Gas Recirculation (EGR) Valve Parameters 87 new Mode 6 Ford specific descriptions 205 new systems covered 325 new vehicle-ecu combinations 1,041 new Actuation tests, including: o Trans solenoids o 4WD solenoids o ABS solenoids o Lamp tests o Fan tests o Injectors o Fuel Pump o EVAP solenoids o O2 Sensor Heater tests o Power Balance o Relative Compression o Gauge tests o Turbo tests 127 new Adjustment tests, including: o Allow Central Configuration Data Parameter (CDP) Learning o Brake Bleeds - DRAFT - Page 8

9 o Battery Monitor System Reset o Calibrate Lateral Acceleration Sensor o Calibrate Longitudinal Acceleration Sensor o Clear EGR Adaptive Tables o Clear Fuel Injector & HP Pump Adaptive Tables o Clear Transmission Adaptive KAM Tables o Clear Transmission Data Monitor o Clearing Of OBD Misfire Monitor Profile Correction Data o DPF Reset o Initialize Oil Level Sensor o Injector Quantity Adjustment o Injector Pilot Learning Reset o IVD Sensors Calibration tests o Lateral Accel Sensor Initialization Start o Longitudinal Acceleration Sensor Initialization Start o NOx Catalyst Reset o Oil Change Reset o Particulate Filter Regeneration tests o Read All Injector Quantity Adjustment Coding o Reset ECU o Reset Exhaust Gas Recirculation (EGR) Valve Parameters o Reset MAF (Mass Air Flow) Sensor Parameters o Reset Selective Catalyst Reductant (SCR) Parameters o Reset Water In Fuel Counters o Reset ZFC And NVC Learning Values For All Cylinders o SCR Emptying o Tire Pressure Sensor Registration o Yaw Rate Sensor Calibration Chrysler/Jeep Coverage Complete coverage added for 2013MY vehicles - DRAFT - Page 9

10 Coverage added for the 2013 Dart, which uses Fiat-based diagnostics and protocols Expanded systems coverage for Door and Seat Modules Many focused improvements for Ram 2500/3500 trucks with Cummins 5.9L 61 new Mode 6 Chrysler specific descriptions 82 new systems covered 471 new vehicle-ecu combinations 1,450 new Actuation tests, including: o Trans solenoids o 4WD solenoids o ABS solenoids o Lamp tests o Fan tests o Injectors o Fuel Pump o O2 Sensor Heater tests o Motor tests o Gauge tests o Door Locks 191 new Adjustment tests, including: o Actuator Calibration o Brake Bleeds o Cam/Crank Relearn o Clear All Learned Seat Parameters o ECU Initialization tests o EGS Initialization o HVAC Actuator Calibration Test o Injector Quantity Adjustment o Learn ETC o Longitudinal G Sensor Calibration - DRAFT - Page 10

11 o Program Tire Size o Quick Learn o Reset ECU o Reset Accelerator Pedal Adaptives o Reset Steering Angle Calibration o Set Pinion Factor o Set Ride Height Level o Stationary Desoot o Stationary Regeneration o Steering Angle Sensor Calibration o Throttle Body Self-Learning o Tire Pressure Sensor Registration o Write VIN. New Coverage - USA Asian Powerful Asian diagnostics coverage also includes expanded system coverage and Special Tests. Special focus on the model years. Asian OEM Specific Information: Honda Coverage Complete coverage added for 2013MY vehicles New coverage for Real Time AWD module 24 new systems covered 289 new vehicle-ecu combinations 206 new Actuation tests covered, including: o Trans solenoids o ABS solenoids o Airbag tests o Lamp tests o Fan tests o Fuel Pump tests - DRAFT - Page 11

12 o VTEC tests o Door Locks o EGR tests o Gauge tests 19 new Adjustment tests, including: o All Sensors Neutral Calibration o Crank Pattern Clear o ECM/PCM Reset o Service Light resets o Sensor Cluster Calibration o Steering Angle Sensor Calibration o Tire Pressure Sensor Registration. Toyota Coverage Complete coverage added for 2013MY vehicles Coverage added for Cruise Control systems. 4 new Mode 6 Toyota specific descriptions 71 new systems covered 1,026 new vehicle-ecu combinations 780 new Actuation tests covered, including: o Trans solenoids o ABS solenoids o 4WD tests o Lamp tests o Fan tests o Fuel Pump tests o Variable Camshaft tests o EVAP tests o EGR tests 49 new Adjustment tests, including: o ABS Bleed tests - DRAFT - Page 12

13 o Battery Current Sensor Initialization o Clear Abnormal Operation History o Fuel Density Learning Value Reset o Learning Value Reset o Reset Memory o Torque Sensor Adjustment o Zero Point Calibration/Test Mode o Tire Pressure Sensor Registration Nissan Coverage Complete coverage added for 2013MY vehicles New coverage for Leaf and Cube models 20 new systems covered 322 new vehicle-ecu combinations 527 new Actuation tests covered, including: o Trans solenoids o ABS solenoids o Lamp tests o Fan tests o Fuel Pump tests o Variable Camshaft tests o EVAP tests o EGR tests o O2 Sensor Heater tests 84 new Adjustment tests, including: o Air Bleed tests o Air Fuel Ratio Correction Value o Clear Air-Fuel Ratio Learning o Clear ETC Learning o Clear Normal TAS Learning o Decel G Sensor Calibration - DRAFT - Page 13

14 o Idle Air Volume Learn o Idling Target Rotation Adjustment o Ignition Timing Adjustment o Longitudinal G Sensor Calibration o Reset Memory o Steering Angle Sensor Calibration o Throttle Valve Closed Position Learning o Tire Pressure Sensor Registration Hyundai Coverage Complete coverage added for 2013MY vehicles New coverage for POWER DISTRIBUTION (PIC) module New coverage for SMART KEY UNIT (PIC) module 4 new Mode 6 Hyundai specific descriptions More than 230 new systems covered 295 new vehicle-ecu combinations 616 new Actuation tests covered, including: o Trans solenoids o ABS solenoids o Lamp tests o Fan tests o Fuel Pump tests o Variable Camshaft tests o EVAP tests o Injector tests o O2 Sensor Heater tests o HVAC tests o Gauge tests 30 new Adjustment tests, including: o Air Bleeding Mode o ASP Calibration - DRAFT - Page 14

15 o Auto Detected Configuration Reset o Battery Inspection o G Sensor Calibration o Lateral G Sensor Initialization o Pressure Sensor Calibration o Reset Adaptive Values o Steering Angle Sensor o VCM Learning o Tire Pressure Sensor Registration Kia Coverage Complete coverage added for 2013MY vehicles New coverage for POWER DISTRIBUTION (PIC) module New coverage for SMART KEY UNIT (PIC) module 123 new systems covered 140 new vehicle-ecu combinations 395 new Actuation tests covered, including: o Trans solenoids o ABS solenoids o Lamp tests o Fan tests o Fuel Pump tests o Variable Camshaft tests o EVAP tests o Injector tests o O2 Sensor Heater tests o HVAC tests 13 new Adjustment tests, including: o Air Bleeding Mode o ASP Calibration o Battery Inspection - DRAFT - Page 15

16 o G Sensor Calibration o Reset Adaptive Values o Tire Pressure Sensor Registration Mazda Coverage Complete coverage added for 2013MY vehicles Expanded systems coverage for RX-8 and 2010 Mazda3 47 new systems covered 66 new vehicle-ecu combinations 59 new Actuation tests covered, including: o Trans tests o ABS tests o Lamp tests o Gauge tests 1 new Adjustment tests, including: o Lateral Accel Sensor Initialization Start Mitsubishi Coverage Complete coverage added for 2013MY vehicles 19 new systems covered 35 new vehicle-ecu combinations 75 new Actuation tests covered, including: o Trans solenoids o ABS solenoids o 4WD tests o Lamp tests o Fan tests o Fuel Pump tests o EVAP tests o Injector tests 23 new Adjustment tests, including: - DRAFT - Page 16

17 o All Sensor Calibration o G Sensor Calibration o SAS Calibration New Coverage - USA European This European update is a significant improvement to the European product in terms of coverage years and actuation and adjustment capability. The focus of this European release, like Domestic / Asian, was to significantly improve the actuation (bidirectional tests) and service adjustment tests coverage with special focus on the model years. European OEM Specific Information: Audi Coverage Coverage updated through 2012 model year. 22 new Mode 6 Audi specific descriptions 9 new systems covered. 83 new vehicle-ecu combinations. 30 new Adjustment tests, including Adaptations, Basic Settings and Coding BMW Coverage Coverage updated through 2012 model year. Expanded systems coverage for several models new systems covered. 1,477 new vehicle-ecu combinations. 762 new Activation tests, including: o AC Compressor o ABS Actuator tests o CBS Service resets o EVAP Solenoids o Fans o Fuel Injector tests o Fuel Pump - DRAFT - Page 17

18 o Fuel Tank Vent Valve(s) o Instrument Cluster Self Test o Lamp tests o Oxygen Sensor Heater(s) o Parking Brake tests o Supercharger/Turbo tests o Shift Solenoid tests o Speed Sensor Test o VANOS Inlet/Exhaust tests 108 new Adjustment tests, including: o Adjust Fuel Consumption Display Correction Factor o Balance Value Of LL (idle) Program o Battery Exchange Register o Calibrate Lateral Acceleration Sensor o Calibrate Stepper Motors o Frequency Counter Reset For Auto Start-Stop MSA o Front Brake Zeroing o Inspection/Service Interval Reset o Memory Reset o Oil Service Reset o Particle Filter Replacement o Perform control-module reset o Rear Brake Zeroing o Reset All Adaptation Values o Reset Calibration o Teach in components o Tire Pressure Sensor Registration o Zero Speed Learning Fiat Coverage Coverage updated for 2013 Fiat 500 models - DRAFT - Page 18

19 Engine, Transmission, ABS, Body and Electric Power Steering 20 new vehicle-ecu combinations. 85 new Activation tests, including: o BSM Longitudinal G Sensor Test o Check PCM Odometer o Door Locks o EVAP Solenoids o Fan(s) o Fuel Injector(s) o Fuel Pump o Ignition Coil(s) o Oxygen Sensor Heater(s) o ABS Solenoids o Trans Solenoids o VVA Cylinder tests 10 new Adjustment tests, including: o Air-Conditioning Self-Learning o Brake Switch Learn o Clear Misfire Learn Correction o Clear Trans Self Learn Data o Clear Steering Pull Compensation o Reset Accel Pedal Adaptives o Reset Adaptive After Oil Change o Throttle Body Self-Learning Mercedes Coverage Coverage updated through 2012 model year. Added coverage for HVAC Controller for the first time to Model Year 2012 vehicles Expanded systems coverage for several 2011 models 128 new systems covered. 1,336 new vehicle-ecu combinations. - DRAFT - Page 19

20 739 new Activation tests, including: o ABS tests o AdBlue tests o Air Conditioning tests o Air Pump o Central Lock tests o EGR Control o EVAP Purge Control o Fans o Fuel Injector(s) o Fuel Pump o Seat tests o Shift Solenoid(s) o Suspension tests o Variable Cam Intake/Exhaust Solenoid(s) 40 new Adjustment tests, including: o Maintenance Resets o ESP Control Unit Calibration o Learning Of The Throttle Valve Stop o Normalizing Of Positioning Motors o Reset Mixture Adaptation o Reset Steering Angle Calibration o Reset Throttle Valve Adaptation o Resetting Of Adaptation Data o Signal Transmission Test o Tire Pressure Sensor Registration Mini Coverage Coverage updated through 2012 model year. Expanded coverage for AIR CONDITIONING module new systems covered. - DRAFT - Page 20

21 48 new vehicle-ecu combinations. 244 new Activation tests. o Air Conditioning Stepper Motor tests o EVAP Solenoids o Fans o Fuel Injector tests o Fuel Pump o Fuel Tank Vent Valve(s) o Instrument Cluster Self Test o Lamp tests o Oxygen Sensor Heater(s) o Supercharger/Turbo tests 42 new Adjustment tests, including: o Adjust Fuel Consumption Display Correction Factor o Balance Value Of LL (idle) Program o Battery Exchange Register o Calibrate Lateral Acceleration Sensor o Calibrate Stepper Motors o Frequency Counter Reset For Auto Start-Stop MSA o Longitudinal Sensor Calibration o Perform control-module reset o Reset All Adaptation Values o Tire Pressure Sensor Registration o Zero Speed Learning Volkswagen Coverage Coverage updated through 2012 model year. 22 new Mode 6 Volkswagen specific descriptions 25 new systems covered. 68 new vehicle-ecu combinations. 30 new Adjustment tests, including Adaptations, Basic Settings and Coding - DRAFT - Page 21

22 Volvo Coverage Coverage updated through 2012 model year. Expanded coverage for Seat, Door and Climate Control modules new systems covered. 359 new vehicle-ecu combinations. 896 new Activation tests, including: o A/C Fan/Relay o Activate/Deactivate Service Mode o Apply / Release Parking Brake o EVAP Purge Control o Fan(s) o Fuel Injector(s) o Fuel Pump o HVAC tests o Seat tests o Shift Solenoid(s) o Suspension tests o Turbo tests o Variable Intake tests o Window tests 44 new Adjustment tests, including: o ABS Calibration (With DSTC) o Lateral Accel Calibration o Longitudinal Accel Calibration o Oil Change Light Reset o Pressure Sensor 12 Calibration o Rear Brake Installation Check o Reset Adaptive Values o Steering Angle Calibration o Tire Pressure Sensor Registration - DRAFT - Page 22

23 o Yaw Rate Calibration Smart Coverage New coverage added for Smart vehicles! 13 new systems covered. 50 new vehicle-ecu combinations. 170 new Activation tests, including: o AC Compressor o Alternator o ABS/ESP tests o EVAP tests o Fan tests o Fuel Pump o HVAC Motor/Actuator tests o Lamp tests 1 new Adjustment test, Teach In Bleeding Air Flap Actuator Motor Model Year 2010 to Model Year 1996 Focused Improvements Special focus on out of warranty vehicles has been the goal of each past scan tool release. However, the misconception still exists that only the latest model year is added to the software with an update. To help illustrate the focus on out of warranty older vehicles; example coverage by year, make and model is shown below. General Motors Special Test gaps filled for vehicles, for Climate (HVAC) and Instrument Panel Cluster systems o Instrument Panel/Cluster Lamp tests Display Test Oil Life Reset Coolant Gauge Sweep Test Fuel Gauge Sweep Test IPC Gauge Sweep Test - DRAFT - Page 23

24 Oil Gauge Sweep Test Speed Gauge Sweep Test Tach Gauge Sweep Test Volts Gauge Sweep Test PRNDL Display o Climate (HVAC) A/C Clutch/Request Actuator Recalibration Afterblow Option Blower Motor Fan tests Door Position tests Mix Motor Recalibrate All Motors Setup New HVAC Instant OAT Update Expanded systems coverage for Suspension Control, Steering Wheel Angle Sensor and Multi-Axis Accel Sensor modules. Cleanup of special test groupings, more logical now Improved coverage of Cam Phaser solenoid tests for vehicles Cylinder Power Balance test added for many vehicles Fuel Injector Balance test added for many vehicles EVAP Service Bay Test added for many vehicles Oil Life Reset test added for many vehicles Clear Transmission Adapts test added for many trucks Transfer Case Motor tests added for trucks ABS Automated Bleed test added for Century and Regal vehicles ABS Pump Motor test added for 2007 Terraza, Uplander and Relay vehicles ABS Yaw Rate Sensor Recalibration test added for Envoy, Rainier and Trailblazer vehicles - DRAFT - Page 24

25 ABS Motor test added for Cadillac STS Instrument Panel tests added for Cadillac STS - Display Test and many gauge sweep tests Suspension Damper Actuator tests added for 2010 Camaro and LaCrosse vehicles Many more tests added from this major effort! Ford Data refresh rate is now much faster for many systems Many focused improvements for 2008 F-Series 5.4L trucks: o CLIMATE CONTROL - coverage added for this module with DTCs, Data Items and 1 special test o DRIVER SEAT - coverage added for this module with DTCs and Data items o PCM - Added tests Torque Convertor Clutch Control State, Output Test Mode and Line Pressure Control Desired o INSTRUMENT CLUSTER - Added tests for Fuel Gauge Indicator Control and Temperature Gauge o INSTRUMENT CLUSTER - Added tests for Courtesy Lighting Ramp-Down and Ramp-Up o ABS - fix for Automated Brake Bleed test o VEHICLE SECURITY MODULE - 6 new tests added L Diesel - 4 new tests added: o Clear EGR Adaptive Tables o Clear Fuel Injector & HP Pump Adaptive Tables o DPF Reset o Reset Water In Fuel Counters ABS Automated Bleed test added for Five Hundred, Freestyle, Montego vehicles ABS Automated Bleed test added for Taurus, Sable, Flex, MKS, MKT Instrument Cluster tests added for vehicles: o All LCD Segments o Chimer Control o Many warning lamp tests - DRAFT - Page 25

26 o Fuel Gauge Indicator Control On/Off o Fuel Level Low Indicator o Speedometer o Transmission Temperature On/Off o Many more Chrysler Many focused improvements for 2003 Ram 2500/3500 trucks with Cummins 5.9L o ENGINE JTEC - communications issue fixed o ENGINE JTEC - added 3 sensor data parameters o TRANSMISSION - communications issue fixed o ENGINE CUMMINS - added 24 sensor data parameters and 6 input/output parameters o ENGINE CUMMINS - added 6 new special tests: o Read VIN o Write VIN o Fan Clutch PWM Duty Cycle Output o Generator Field Test Mode o Lift Pump Test o A/C Clutch o ABS (4WAL) - added 11 sensor data parameters o TRANSFER CASE - added 11 new input/output parameters o CLIMATE CONTROL - added 10 new special tests and 16 new input/output parameters o SKIM SECURITY - added 2 new input/output parameters ENGINE Injector Quantity Adjustment test added for trucks with 6.7L Cummins engine ABS Set Pinion Factor test added for trucks with 4WAL DOOR MODULE tests added for vehicles MEMORY SEAT tests added for vehicles Nissan - DRAFT - Page 26

27 New coverage for IPDM module for , which aids diagnosis of a common electrical failure on many Nissans Added Idle Air Volume Learn for Added Clear Air-Fuel Ratio Learning for Added Idle Throttle Valve Closed Position Learning for Added Ignition Timing for Special Tests availability check has been added for most modules This means the list of tests for the selected vehicle and ecu will be more accurate for what is actually supported by the vehicle. Toyota Special Tests availability check has been added for most modules. This means the list of tests for the selected vehicle and ecu will be more accurate for what is actually supported by the vehicle. Coverage added for Cruise Control systems. Added Signal Check test for many modules ENGINE Control All Cylinders Fuel Cut test added for vehicles ENGINE Injection Volume test added for vehicles HYBRID VEHICLE Battery Current Sensor Initialization test added for vehicles INSTRUMENT PANEL - many new tests added for vehicles METER - many new tests added for vehicles Hyundai / Kia ENGINE Canister Purge Valve and ETC Motor tests added to Azera, Santa Fe and Sonata ABS - many tests added for vehicles New coverage for POWER DISTRIBUTION (PIC) module New coverage for SMART KEY UNIT (PIC) module Mazda Expanded systems coverage for RX-8 and 2010 Mazda3 BMW / Mini Expanded systems coverage for several models Expanded coverage for AIR CONDITIONING module DRAFT - Page 27

28 ENGINE - many new tests added for vehicles ABS - many new tests added for vehicles, including Lateral and Longitudinal Sensor Calibration tests AIR CONDITIONING - many new tests added for vehicles, including Calibrate Stepper Motors DISTRIBUTION GEARBOX - 5 new tests added for vehicles, including Reset Calibration INSTRUMENT CLUSTER - CBS Service tests added for many vehicles ELECTROMECHANICAL PARKING BRAKE - Installation Mode On/Off test added for vehicles Added coverage for ENGINE for 2008 X6 4.4L Mercedes ENGINE - New tests Learning of Throttle Valve Stop and Resetting of Adaptation Data added for vehicles ACTIVE BODY CONTROL - many new tests added for vehicles AIRMATIC SUSPENSION- many new tests added for vehicles BATTERY SENSOR - many new tests added for vehicles Volvo ENGINE - New tests Learning of Throttle Valve Stop and Resetting of Adaptation Data added for vehicles Expanded coverage for Seat, Door and Climate Control modules BRAKE CONTROL - Calibration and Longitudinal Accelerometer Calibration tests added for vehicles CLIMATE CONTROL - many new tests added for vehicles Door modules - many new tests added for vehicles SUSPENSION MODULE - many new tests added for vehicles Test for Pattern Failures To further refine the focus on critical actuations and adjustments there was a drive to develop and release special tests that are required to complete repairs for Pattern Failures. The following provide examples of those pattern failures and vehicles effected. TPM Reset or Tire Pressure Reset tests - DRAFT - Page 28

29 Identifix RepairTrac Pattern Failure Opportunity Ensure we support the TPM Reset or Tire Pressure Reset tests for these vehicles. Result Our tools now have this test SymptomText ProblemText TestAndFix Low tire pressure monitor warning lamp on. Possible the radio displays "LOC". Unable to reset the tire pressure using the headlight procedure and when attempting to reset using the radio, the tire pressure reset option does not appear. Body Control Module (BCM) configuration error. 1. Attempt to clear the code from the Antilock Brake Control Module using the scan tool. 2. If the code does not clear, attempt to reset the tire pressure monitor using the headlight switch method. A. Adjust all tire pressures to the recommended kpa/psi. Refer to Tire Inflation Pressure Specifications in Maintenance and Lubrication, or on the tire placard label in the left door jamb. B. Turn ON the ignition, with the engine OFF. C. Cycle the exterior lamp switch from OFF to parking lamps 3 times within 5 seconds. D. Use the scan tool in order to clear the TPM DTC. 3. If unsuccessful, attempt to reset the tire pressure using the radio method. A. Adjust all tire pressures to the recommended kpa/psi. B. Turn the ignition to ACC or ON, with the engine OFF. C. Turn the radio OFF. D. Press and hold the DISP button until SETTINGS is displayed. E. Press the SEEK up or down arrows until TIRE MON is displayed. F. Press the PREV or NEXT button to enter the submenu. RESET will be displayed. G. Press the DISP button, a chime will sound and DONE will be displayed. H. Scroll until EXIT is displayed. I. Press the DISP button to exit the TPM reset mode. A chime will sound to verify exit. J. Use the scan tool in order to clear the TPM DTC. 4. If the tire pressure option does not appear on the list of options in the radio, install a scan tool and attempt a tire pressure reset using the special functions menu. If the radio did not show any tire reset options, the scan tool reset will most likely be unsuccessful as with the previous mentioned reset procedures. 5. View the vehicle's option configuration and VIN number using the scan tool. Access the special functions, select set up new BCM, view the information stored in the BCM. If the tire pressure monitor is not highlighted with an * next to the option, attempt to highlight the option with an * and enter. Unless the BCM is new, the scan tool will indicate that the BCM is secure and will not allow any option configuration change. If the BCM is secure, replace and configure the BCM. 6. If the VIN number or the option content is not accurate, attempt to enter the correct VIN. If the scan tool states the BCM is secure, replace the BCM and configure the VIN and option configuration into the new BCM. - DRAFT - Page 29

30 Make Model Year Chevrolet Impala Chevrolet Monte Carlo Fuel Gauge Sweep test Identifix RepairTrac Pattern Failure Opportunity Add Fuel Gauge Sweep test to IPC Result Our tools now have this test SymptomText ProblemText TestAndFix The fuel gauge will 1. Use a scan tool that will do the IPC gauge sweep test. spike high intermittently. No 2. If the fuel level reading on the scan tool is correct but the Instrument Panel gauge reading at the IPC is high, repair/replace the IPC. If replaced, the IPC must be programmed. Cluster (IPC) or Powertrain Control Module (PCM) codes. Make Model Year Chevrolet Impala 2004 Chevrolet Monte Carlo 2004 Torque Sensor Calibration and Steering Position Sensor Calibration test Identifix RepairTrac Pattern Failure Opportunity Make sure we support the Torque Sensor Calibration and Steering Position Sensor Calibration tests for these vehicles Result Our tools now have this test Symptom Problem Test And Fix Failure of the torque/position sensor in the steering column. Loss of electric power steering. Make Model Year 1. Observe the subcode identifier after the C0545. This is a 2 digit code. If subcode 4B exists, use the scan tool and perform the Torque Sensor Calibration and the Steering Position Sensor Calibration. 2. If the subcode is 00, observe the scan tool data torque sensor 1 to go down and torque sensor 2 to go up on a left turn. Vice versa on a right hand turn. 3. If the values do not change, confirm the wiring harness between the column and module/motor is not damaged and is plugged in. 4. Replace the torque/position sensor (now serviceable) or replace the steering column. 5. Perform Torque Sensor Calibration and the Steering Position Sensor Calibration using the scan tool. 6. A special policy #10183 is in place for 10 year or 100,000 miles, whichever comes first. Depending on the failure and warranty coverage, the special policy may not fix your problem. - DRAFT - Page 30

31 Chevrolet Malibu Pontiac G Saturn Aura 2008 Reset Alcohol content test Identifix RepairTrac Pattern Failure Opportunity Make sure we support the test to reset Alcohol content Result Our tools now have this test SymptomText ProblemText TestAndFix 1. Scan test the Powertrain Control Module for alcohol content and expect regular pump gas to read less than 10%. 2. If the alcohol content is more than 10%, reset the parameter using the scan tool. To reset the system manually, add more than 3 gallons of gasoline and drive to consume more than 0.3 gallons. This is however often not an effective method. 3. To measure alcohol content, use a clear container with 10 equal fluid segments marked. Add 1 part water and 9 parts The alcohol gasoline. Shake vigorously. Allow the sample to settle. The water and Malfunction content has been alcohol will mix and settle to the bottom. If more than one part clear indicator light on incorrectly liquid on the bottom, that is the amount of alcohol in the sample. 4. with code P0172. calculated by the Attempt to obtain information from the driver if the vehicle is The engine may or Powertrain suspectable to short trip driving. This may cause the computer to not may not run poorly. Control Module. properly update the alcohol content. Make Model Year Chevrolet Impala Chevrolet Monte Carlo Fuel Rail Pressure DI Identifix RepairTrac Pattern Failure Opportunity Make sure we support the Fuel Rail Pressure DI Result Our tools support this data item SymptomText ProblemText TestAndFix The Check Engine Light is on with a code P0193. The Fuel Rail Pressure Temperature Sensor has failed. Using a scan tool to access the Powertrain Control Module data, verify the Fuel Rail Pressure voltage. The voltage is normally V depending on fuel pressure. The voltage has to reach very close to 5 V to set a code P0193. If the voltage shows high on a scan tool, access the fuel rail pressure temperature sensor at the passenger rear corner of the fuel rail near the #1 fuel injector. There is a 4 wire connector on the sensor. The fuel rail pressure signal is the - DRAFT - Page 31

32 Red/Pink wire. This voltage should match what the scan tool shows when backprobing the wire with a voltmeter. If the voltage matches and is at 5 V, verify that the Brown/White wire shows 5 V for the reference voltage. Also check the Gray/Red wire for a good ground. Lastly, connect a mechanical fuel pressure gauge to the fuel rail to be sure the fuel pressure is not over 90 PSI. If the fuel pressure is roughly PSI as it should be or lower, and the voltage on the signal wire is at 5 V, replace the fuel rail pressure sensor. Make Model Year Ford Freestar 2004 Mercury Monterey 2004 Crankshaft Variation Learn test Identifix RepairTrac Pattern Failure Opportunity Make sure we support the Crankshaft Variation Learn test for these vehicles Result Our tools now have this test Symptom Problem Test And Fix 1. Perform a Crankshaft Position System Variation Learn using the scan tool. The scan tool will give instructions that may P0300 trouble include cycling the key, applying the service brake and will code, however eventually advise to raise the engine speed until it hits the rev the engine runs Crankshaft variation limiter. Release the throttle and wait for the scan tool to inform good and it not relearn needs to be the relearn was successful. 2. If the relearn is not successful, actually performed using the scan remove the serpentine belt and disconnect the torque converter misfiring. tool. (automatic transmission) and recheck for the false misfires. Make Model Year Cadillac Escalade 5.3/6.0L Chevrolet Express L Chevrolet Express /5.3/6.0L Chevrolet Silverado /5.3/6.0L Chevrolet Silverado /6.0L Chevrolet Silverado 2500 HD 6.0L Chevrolet Silverado L Chevrolet Suburban /6.0L Chevrolet Tahoe 4.8/5.3L GMC Savana L GMC Savana /5.3/6.0L DRAFT - Page 32

33 GMC Savana /6.0L GMC Sierra /5.3/6.0L GMC Sierra /6.0L GMC Sierra 2500 HD 6.0L GMC Sierra L GMC Sierra Denali 6.0L GMC Yukon 4.8/5.3/6.0L GMC Yukon Denali 6.0L GMC Yukon XL L GMC Yukon XL L Hummer H2 6.0L Battery Registration test Identifix RepairTrac Pattern Failure Opportunity Make sure we support the Battery Registration test for these vehicles Result Our tools now have this test Symptom Problem Test And Fix Charging system is Register battery replacement with a BMW factory compatible scan tool and must be performed when installing a new battery. Be sure to scan not properly all modules on the car for codes that may have been induced due to charging battery low voltage from the old battery. Do not use memory savers on and may have BMW's, it will cause the instrument cluster main fuse to blow and erroneous error Replacement could cause damage to the cluster or other modules, There is no need messages in battery is not for memory power, as there will be no loss of memory for radio or instrument cluster. registered. other modules. Make Model Year BMW 325i 2006 BMW 325xi 2006 BMW 328i BMW 328xi BMW 330ci 2006 BMW 330i 2006 BMW 330xi 2006 BMW 335d BMW 335i BMW 335i BMW 335is 2011 BMW 335xi BMW 528i DRAFT - Page 33

34 BMW 528xi 2008 BMW 530i 2006 BMW 530i 2007 BMW 530xi 2006 BMW 530xi 2007 BMW 535i BMW 535i GT BMW 535xi 2008 BMW 550i 2006 BMW 550i BMW 550i GT BMW 645ci BMW 650i BMW 650i BMW Alpina B BMW Alpina B BMW M BMW M BMW X BMW Z Technician Reported Defect Fixes and Improvements: General Motors Fixed Regal 2.0L - All data items display NO DATA Fixed Impala - ENGINE will not read DTCs Fixed Sierra 1500 Hybrid - BATTERY ENERGY CONTROL MODULE does not have Read/Clear DTC choice Fixed Aveo - Genisys does not read same codes as TechII Fixed G6 - Communication issues when reading codes or doing All System DTC Scan Fixed W4 Series - Will not show data for Fuel Pressure Fixed Vue - No choice for Electronic Brake Control module Fixed Tahoe, Silverado and Acadia - connecting the tool causes IPC to be inoperable, MIL on, and communication issues Fixed Silverado 6.6L - Injector 1 test does not work - DRAFT - Page 34

35 Fixed Montana - ENGINE is missing Crank Relearn test Fixed Impala - EVAP Purge test will not actuate solenoid Fixed Trailblazer/Envoy - Air Pump tests missing Fixed CTS - ABS Brake Pedal Pos Sensor Calibration test will set DTC and not proceed any further Fixed Grand Am - 3 U-codes and 3 B-codes did not show description Fixed Montana/Silhouette - missing coverage for Airbag module Fixed many vehicles - DIs displayed inside EVAP tests are not related to EVAP items Fixed Silverado - Special tests do not work Fixed Express - ABS Brake Bleed not available Fixed C Cam Retard data item reads incorrectly Fixed Chevy Astro - B1S1 O2 Sensor reads incorrect values Fixed K truck - MAP reads incorrect values Ford Fixed SuperDuty - ABS Brake Bleed has incorrect instructions Fixed Mustang - Brake Bleed procedures show incorrectly Fixed SuperDuty - Several ENGINE data items show incorrect values Fixed Crown Vic - Fuel Pressure shows incorrect values Fixed SuperDuty - ENGINE intermittent display of data items Fixed SuperDuty - Intermittent communications Fixed SuperDuty - ENGINE KOER test will not complete Fixed Crown Vic - ABS no communication Fixed F ENGINE no communication Fixed F ENGINE Cylinder Head Temp data item reads incorrect values Chrysler / Jeep Fixed - CAN communications issue resulting in application crashing to Application Manager screen Fixed Charger, Challenger and 300 CAN communications issue fixed Fixed Sprinter van ENGINE communications issue - DRAFT - Page 35

36 Fixed Ram Transmission Quick Learn test did not finish properly Fixed Jeep Liberty no communications with Engine, Trans or ABS Fixed Ram communications issues Fixed Wrangler - communications issues Fixed Ram - ABS Speed sensors show intermittent data Toyota Fixed Camry - ENGINE EVAP tests do not work properly Fixed RX330 - Air/Fuel sensor data items read incorrect values Fixed RX330 - Fuel Injector Volume test will not run Fixed Runner - EVAP Vent test results in no communication Fixed Highlander - EVAP tests result in no communication Fixed Camry - EVAP tests result in no communication Fixed GS300 - ABS tests result in no communication Honda Improvements - ENGINE DTC reading, some P-codes were previously not being read correctly Nissan Fixed - Missing some CRITICAL tests, such as Throttle Valve Closed Pos. Learn, Clear Air-Fuel Ratio Learn and Idle Air Volume Learn Hyundai / Kia Fixed Sonata - ENGINE data items IAT and Fuel Tank Pressure show incorrect values Fixed Sonata - ABS tests are missing Fixed Tiburon - Airbag DTCs not read properly Mercedes Fixed ML320 - No coverage for Airbag Fixed ML430 - No coverage for Airbag VW / Audi Fixed - VW Routan - communication issues Fixed - Data items scrolling issue Improved - KW1281 protocol systems communication - DRAFT - Page 36

37 Fixed - KW1281 protocol systems Controller Information Soft Code displayed incorrectly Improved - Login + Adaptation test BMW / Mini Fixed i - ENGINE Secondary Air Pump test has incorrect instructions and won't show data items Next Release: Focused on expansion of vehicle coverage, repair information, out of warranty years tests and continued software improvements. Most importantly, listening to our customers to add the fixes, functions and features requested. Thank you for your patronage! - DRAFT - Page 37