MATERIAL SAFETY DATA SHEET

Transcription

1 MATERIAL SAFETY DATA SHEET Product Name CAS # Product Use Manufacturer information Emergency overview 1. Product and Company Identification Eco-Reclaim Mixture Carpet care CFR Division of Tacony Corporation 311 Wichita Court Fort Worth, TX US Phone: ext Hazards Identification WARNING MAY CAUSE EYE IRRITATION. MAY CAUSE SKIN IRRITATION. Potential short term health effects Eye, Skin contact,, Ingestion. Routes of exposure Eyes Skin Ingestion Target organs Chronic effects Signs and symptoms Potential environmental effects May cause respiratory tract irritation. May cause stomach distress, nausea or vomiting. Eyes. Skin. Prolonged or repeated exposure can cause drying, defatting and dermatitis. Symptoms may include redness, oedema, drying, defatting and cracking of the skin. Symptoms of overexposure may be headache, dizziness, tiredness, nausea and vomiting. Components of this product have been identified as having potential environmental concerns. 3. Composition/Information on ingredients Components CAS # Percent Carbonic acid, sodium salt (2:3) Sodium carbonate Alcohols, C7-21, ethoxylated Citric acid 4. First Aid Measures First aid procedures Eye contact Skin contact Ingestion Notes to physician General advice Flammable properties Flush with cool water. Remove contact lenses, if applicable, and continue flushing. Obtain medical attention if irritation persists. Flush with cool water. Wash with soap and water. Obtain medical attention if irritation persists. If symptoms develop move victim to fresh air. If symptoms persist, obtain medical attention. Do not induce vomiting. Never give anything by mouth if victim is unconscious, or is convulsing. Obtain medical attention. Treat patient symptomatically. If you feel unwell, seek medical advice (show the label where possible). Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Show this safety data sheet to the doctor in attendance. Avoid contact with eyes and skin. Keep out of reach of children. 5. Fire-fighting Measures Not flammable by WHMIS criteria. #21569 Page: 1 of 6

2 Extinguishing media Suitable extinguishing media Unsuitable extinguishing media Protection of firefighters Specific hazards arising from the chemical Protective equipment for firefighters Hazardous combustion products Explosion data Sensitivity to mechanical impact Sensitivity to static discharge Personal precautions Environmental precautions Methods for containment Methods for cleaning up Handling Storage Exposure limits Engineering controls Personal protective equipment Eye/Face protection Hand protection Skin and body protection Respiratory protection General hygiene considerations Appearance Colour Form Odour Odour threshold Treat for surrounding material. Firefighters should wear a self-contained breathing apparatus. Firefighters should wear full protective clothing including self contained breathing apparatus. May include and are not limited to: Oxides of carbon. 6. Accidental release measures Keep people away from and upwind of spill/leak. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Do not discharge into lakes, streams, ponds or public waters. Stop leak if you can do so without risk. Prevent entry into waterways, sewers, basements or confined areas. Before attempting clean up, refer to hazard data given above. Small spills may be absorbed with non-reactive absorbent and placed in suitable, covered, labelled containers. Prevent large spills from entering sewers or waterways. Contact emergency services and supplier for advice. Never return spills in original containers for re-use. 7. Handling and storage Avoid contact with eyes, skin and clothing. Do not breathe mist or vapour. Use with adequate ventilation. Wear appropriate personal protective equipment when handling this product. Use good industrial hygiene practices in handling this material. When using do not eat or drink. Wash hands before breaks and immediately after handling the product. Keep out of reach of children. Store in a closed container away from incompatible materials. 8. Exposure controls/personal protection There are no established ACGIH exposure limits for the hazardous chemicals listed in section 3 of the MSDS. Ensure adequate ventilation. Wear safety glasses with side shields. Rubber gloves. Confirm with a reputable supplier first. As required by employer code. Where exposure guideline levels may be exceeded, use an approved NIOSH respirator. Handle in accordance with good industrial hygiene and safety practice. When using do not eat or drink. Wash hands before breaks and immediately after handling the product. Clear 9. Physical and chemical properties Light yellow to Colourless Liquid Odourless #21569 Page: 2 of 6

3 Physical state Liquid. ph Freezing point Boiling point Pour point Evaporation e Flash point Auto-ignition temperature Flammability limits in air, upper, % by volume Flammability limits in air, lower, % by volume Vapour pressure Vapour density Specific gravity Partition coefficient (n-octanol/water) Solubility (Water) Relative density Viscosity VOC Percent volatile Reactivity Possibility of hazardous reactions Chemical stability Conditions to avoid Incompatible materials Hazardous decomposition products 1. Stability and reactivity May react with incompatible materials. Hazardous polymerisation does not occur. Stable under recommended storage conditions. Do not mix with other chemicals. Caustics. Acids. Oxidizers. May include and are not limited to: Oxides of carbon. 11. Toxicological information Toxicological data Components Alcohols, C7-21, ethoxylated (CAS ) LD5 Rabbit LC5 LD5 Carbonic acid, sodium salt (2:3) (CAS ) LD5 LC5 LD5 > 2 mg/kg 141 mg/kg 56 mg/kg #21569 Page: 3 of 6

4 Components Citric acid (CAS ) LD5 LC5 LD5 Sodium carbonate (CAS ) LD5 LC5 LD5 Effects of acute exposure Eye contact Skin contact Ingestion Sensitisation Chronic effects Carcinogenicity Mutagenicity Reproductive effects Teratogenicity Name of Toxicologically Synergistic Products Mouse Guinea pig Mouse May cause respiratory tract irritation. May cause stomach distress, nausea or vomiting. 12. Ecological information 54 mg/kg 3 mg/kg > 2 mg/kg 4 mg/m3.8 mg/l, 2 Hours 1.2 mg/l, 2 Hours 2.3 mg/l, 2 Hours 49 mg/kg Ecotoxicity See below Ecotoxicological data Components Citric acid (CAS ) Crustacea EC5 Aquatic Fish LC5 Sodium carbonate (CAS ) Crustacea EC5 Aquatic Crustacea EC5 Daphnia magna Bluegill (Lepomis macrochirus) Daphnia Water flea (Ceriodaphnia dubia) 12 mg/l, 72 hr 1516 mg/l, 96 hr 265 mg/l, 48 Hours mg/l, 48 hours #21569 Page: 4 of 6

5 Components Fish Persistence and degradability Bioaccumulation/accumulation Mobility in environmental media Environmental effects Aquatic toxicity Partition coefficient Chemical fate information Disposal instructions Waste from residues / unused products Contaminated packaging LC5 Bluegill (Lepomis macrochirus) 13. Disposal considerations Dispose in accordance with all applicable regulations. 14. Transport information 3 mg/l, 96 hours General Canada: TDG Proof of Classification: In accordance with Part (SOR/ ) of the Transportation of Dangerous Goods Regulations, we certify that the classification of this product is correct as of the SDS date of issue. If applicable, the technical name and the classification of the product will appear below. Transportation of Dangerous Goods (TDG - Canada) Not regulated as dangerous goods. Canadian federal regulations Canada WHMIS Ingredient Disclosure: Threshold limits WHMIS status 15. Regulatory information This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all the information required by the Controlled Products Regulations. Citric acid (CAS ) 1 % Sodium carbonate (CAS ) 1 % WHMIS classification WHMIS labeling Controlled Class D - Division 2B Inventory Status Country(s) or region Inventory Name On Inventory (Yes/No)* Canada Domestic Substances List (DSL) No Canada Non-Domestic Substances List (NDSL) Yes *A"Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) 16. Other information Severe Serious Moderate Slight Minimal LEGEND HEALTH FLAMMABILITY PHYSICAL HAZARD PERSONAL PROTECTION / 2 X 1 #21569 Page: 5 of 6

6 Disclaimer Issue date Effective date Expiry date Prepared by Other information Information contained herein was obtained from sources considered technically accurate and reliable. While every effort has been made to ensure full disclosure of product hazards, in some cases data is not available and is so stated. Since conditions of actual product use are beyond control of the supplier, it is assumed that users of this material have been fully trained according to the requirements of all applicable legislation and regulatory instruments. No warranty, expressed or implied, is made and supplier will not be liable for any losses, injuries or consequential damages which may result from the use of or reliance on any information contained in this document. 11-February February February-219 Dell Tech Laboratories Ltd. Phone: (519) This MSDS conforms to the ANSI Z4.1/Z Standard. #21569 Page: 6 of 6