SAFETY DATA SHEET. Section 1: Identification of the substance/mixture and of the company/undertaking. KaVo Everest ZS-Blanks und Ronden

Transcription

1 SAFETY DATA SHEET Section 1: Identification of the substance/mixture and of the company/undertaking Product identifier Trade name or designation of the mixture REACH Registration Number KaVo Everest ZSBlanks und Ronden Synonyms Blanks ZS (16) * Blanks ZS (20) * Blanks ZS (42/16) * Blanks ZS (42/20) * Blanks ZS (60/20) * Blanks ZS (16) * Blanks ZS (20) * Blanks ZS (42/16) * Ronden ZS 100*16 * Ronden ZS 100*20 * Ronden ZS 100*25 Date of first issue Version number 1.0 Revision date Supersedes date Product use professional use Relevant identified uses of the substance or mixture and uses advised against Identified uses Uses advised against Details of the supplier of the safety data sheet Company name Kaltenbach & Voigt GmbH Address Bismarckring 39 D88400 Biberach Germany Telephone number +49 (0) Fax +49 (0) Contact person Peter Fischer Telephone number +49 (0) peter.fischer@bayer.com Emergency telephone +49 (0) number Section 2: Hazards identification Classification of the substance or mixture The mixture has been assessed and/or tested for its physical, health and environmental hazards and the following classification applies. Classification according to Directive 67/548/EEC or 1999/45/EC as amended This preparation does not meet the criteria for classification according to Directive 1999/45/EC as amended. Hazard summary Physical hazards Health hazards Environmental hazards Specific hazards Main symptoms Label elements Not classified for physical hazards. Not classified for health hazards. Not classified for hazards to the environment. Label according to Directive 67/548/EEC or 1999/45/EC as amended Supplemental label information Other hazards Not assigned. Section 3: Composition/information on ingredients Mixture 7120 Version No.: 1.0 Revision date: Print date: 1 / 6

2 General information Chemical name % CASNo. / EC No. REACH Registration No. INDEX No. Notes Zirconium dioxide <= 94 Classification: Aluminiumoxid <= 0.5 Classification: PBT: persistent, bioaccumulative and toxic substance. vpvb: very persistent and very bioaccumulative substance. #: This substance has been assigned Community workplace exposure limit(s). Composition comments Section 4: First aid measures General information Description of first aid measures Inhalation Skin contact Eye contact Ingestion Most important symptoms and effects, both acute and delayed Indication of any immediate medical attention and special treatment needed Section 5: Firefighting measures Extinguishing media Suitable extinguishing media Unsuitable extinguishing media Special hazards arising from the substance or mixture Advice for firefighters Special protective equipment for firefighters Special firefighting procedures Move to fresh air. Call a physician if symptoms develop or persist. Rinse skin with water/shower. Get medical attention if irritation develops and persists. Rinse with water. Get medical attention if irritation develops and persists. Rinse mouth. Get medical advice/attention if you feel unwell. Water. Section 6: Accidental release measures Wear suitable protective equipment. In the event of fire, cool tanks with water spray. Personal precautions, protective equipment and emergency procedures For nonemergency personnel Environmental precautions Methods and material for containment and cleaning up No special environmental precautions required. Stop the flow of material, if this is without risk. Following product recovery, flush area with water. For waste disposal, see section 13. Reference to other sections For personal protection, see section 8. For waste disposal, see section 13. Section 7: Handling and storage Precautions for safe handling Conditions for safe storage, including any incompatibilities Specific end use(s) Avoid dust formation. Do not breathe dust from this material. Provide appropriate exhaust ventilation at places where dust is formed. Avoid contact with skin and eyes. Avoid prolonged exposure. Practice good housekeeping. Avoid eating, drinking and smoking when using the product. Store in a wellventilated place. Keep container tightly closed. Avoid dust formation. Guard against dust accumulation of this material Version No.: 1.0 Revision date: Print date: 2 / 6

3 Section 8: Exposure controls/personal protection Control parameters Occupational exposure limits UK. EH40 Workplace Exposure Limits (WELs) Components Type Aluminiumo xid ( ) Zirconium dioxide ( ) EU No exposure limits noted for the ingredient(s). Biological limit values Value Form TWA 4 mg/m3 Respirable dust. 10 mg/m3 Inhalable dust. STEL 10 mg/m3 TWA EU No biological exposure limits noted for the ingredient(s). United Kingdom No biological exposure limits noted for the ingredient(s). Recommended monitoring procedures DNEL PNEC Exposure controls Appropriate engineering controls Follow standard monitoring procedures. 5 mg/m3 Ventilation should be sufficient to effectively remove and prevent buildup of any dusts or fumes that may be generated during handling or thermal processing. Individual protection measures, such as personal protective equipment Eye/face protection Skin protection Do not get in eyes. Safety glasses. Hand protection Use protective gloves. Other Personal protection equipment should be chosen according to the CEN standards and in discussion with the supplier of the personal protective equipment. Respiratory protection Thermal hazards Hygiene measures Environmental exposure controls No personal respiratory protective equipment normally required. Wear respirator if there is dust formation. Handle in accordance with good industrial hygiene and safety practices. Do not breathe dust. Avoid contact with skin. Keep away from food and drink. Section 9: Physical and chemical properties Information on basic physical and chemical properties Physical state Odour Form Colour Odour threshold ph Melting point/freezing point Boiling point, initial boiling point, and boiling range Flash point Autoignition temperature Flammability (solid, gas) Flammability limit lower (%) Flammability limit upper (%) Solid. Solid. White. Odourless Version No.: 1.0 Revision date: Print date: 3 / 6

4 Oxidizing properties Explosive properties Explosive limit Vapour pressure Vapour density Evaporation rate Relative density Density Solubility (water) Partition coefficient (noctanol/water) Decomposition temperature Bulk density Pour point Viscosity Viscosity temperature VOC (Weight %) Percent volatile Other information 3 g/cm³ Section 10: Stability and reactivity Reactivity Chemical stability Conditions to avoid Incompatible materials Hazardous decomposition products No relevant additional information available. Material is stable under normal conditions. None under normal conditions. Section 11: Toxicological information General information No hazardous decomposition products are known. Information on likely routes of exposure Ingestion Inhalation Skin contact Eye contact Symptoms Information on toxicological effects Acute toxicity Skin corrosion/irritation Serious eye damage/eye irritation Respiratory sensitisation Skin sensitisation Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity single exposure Specific target organ toxicity repeated exposure Aspiration hazard Mixture versus substance information Other information Inhalation of dusts may cause respiratory irritation. Dust in the eyes will cause irritation Version No.: 1.0 Revision date: Print date: 4 / 6

5 Section 12: Ecological information Ecotoxicity Persistence and degradability Bioaccumulative potential Mobility Environmental fate Partition coefficient Mobility in soil Results of PBT and vpvb assessment Other adverse effects Not expected to be harmful to aquatic organisms. No data is available on the degradability of this product. Section 13: Disposal considerations Waste treatment methods Residual waste Contaminated packaging EU waste code Disposal methods/information Empty containers should be taken to an approved waste handling site for recycling or disposal. Section 14: Transport information ADR Not regulated as dangerous goods. IATA Not regulated as dangerous goods. IMDG Not regulated as dangerous goods. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Section 15: Regulatory information Collect and reclaim or dispose in sealed containers at licensed waste disposal site. No information available. Safety, health and environmental regulations/legislation specific for the substance or mixture EU regulations Regulation (EC) No. 2037/2000 on substances that deplete the ozone layer, Annex I Regulation (EC) No. 2037/2000 on substances that deplete the ozone layer, Annex II Regulation (EC) No. 850/2004 on persistent organic pollutants, Annex I Regulation (EC) No. 689/2008 concerning the export and import of dangerous chemicals, Annex I, part 1 Regulation (EC) No. 689/2008 concerning the export and import of dangerous chemicals, Annex I, part 2 Regulation (EC) No. 689/2008 concerning the export and import of dangerous chemicals, Annex I, part 3 Regulation (EC) No. 689/2008 concerning the export and import of dangerous chemicals, Annex V Commission Decision 2000/479/EC on the implementation of a European pollutant emission register (EPER) Regulation (EC) No. 1907/2006, Article 59(1). Candidate List Other regulations National regulations Chemical safety assessment The product is classified and labelled in accordance with EC directives or respective national laws. This Safety Data Sheet complies with the requirements of Regulation (EC) No 1907/2006. The product does not need to be labelled in accordance with EC directives or respective national laws. No Chemical Safety Assessment has been carried out Version No.: 1.0 Revision date: Print date: 5 / 6

6 Section 16: Other information References Information on evaluation method leading to the classification of mixture Wording of the Rphrases in sections 2 and 3 Revision information Training information Disclaimer Issue date Revision date Print date None. Product and company identification: Synonyms Composition/Information on Ingredients: Disclosure Overrides Physical & Chemical Properties: Multiple Properties The information in the sheet was written based on the best knowledge and experience currently available Version No.: 1.0 Revision date: Print date: 6 / 6