HEALTH SAFETY & ENVIRONMENT MANAGEMENT SYSTEM September 2011
OUR HEALTH, SAFETY AND ENVIRONMENT POLICY OUR PRINCIPLE OF DUE CARE We care about the wellbeing of our people and our impact on the environment. OUR HSE ASPIRATION To conduct our business in a way that causes no harm to the health and safety of people and has no unforeseen impacts to the environment. OUR HSE ACTIONS We all believe that our HSE aspiration is achievable and we embrace our responsibility for supporting it by: Always mindful of risk Recognising that risk is present in every task we do and taking the time to identify and understand these risks and manage them safely and responsibly. Enabled and accountable Taking ownership and using our authority, resources, systems and competencies to manage the risks associated with our work. We stop work when confronted by an unknown hazard and proceed only when satisfied we can continue safely and responsibly. Continuously learning Being open and transparent about how well we are doing and relentless in learning from our experience to manage our risks. We work together effectively, welcome any feedback and recognise that we can always do better. Our Compass and HSE Management System set out how we will implement this policy. Grant King Managing Director ORG-HSE-POL-001 November 2014
CONTENTS 1. Purpose and Application 6 2. Governance 8 2.1 Origin Board 8 2.2 HSE Committee of the Board 8 2.3 Operational Risk Committee (ORC) 9 3. Accountabilities and Responsibilities 10 3.1 Managing Director 10 3.2 Executive Director and Executive General Managers 10 3.3 General Managers 11 3.4 Managers and Supervisors 12 3.5 Chief Risk Officer 12 3.6 Group Manager HSE 13 3.7 HSE Managers 13 3.8 Workplace HSE Representatives 14 3.9 Employees and Contractors 14 Origin HSE Management System 15 4.1 The company HSE Policy and HSE Management Standards 15 4.2 Directives 15 4.3 Business Unit HSE Plans and Procedures 16 5. Origin HSE Management System Elements 17 4 September 2011 HSE Management System
6. HSE Management Standards 18 STANDARD 1 Leadership and Commitment 19 STANDARD 2 Organisation, Accountability, Responsibility and Authority 20 STANDARD 3 Planning, Objectives and Targets 21 STANDARD 4 Legal Requirements, Document Control and Information Management 22 STANDARD 5 Personnel, Competence, Training and Behaviours 23 STANDARD 6 Communication, Consultation and Community Involvement 24 STANDARD 7 Hazard and Risk Management 25 STANDARD 8 Incident Management 26 STANDARD 9 Performance Measurement and Reporting 27 STANDARD 10 Operational Control 28 STANDARD 11 Management of Change 29 STANDARD 12 Facilities Design, Construction, Commissioning and Decommissioning 30 STANDARD 13 Contractors, Suppliers, Partners and Visitors 31 STANDARD 14 Crisis and Emergency Management 32 STANDARD 15 Plant and Equipment 33 STANDARD 16 Monitoring the Working Environment 34 STANDARD 17 Health and Fitness for Work 35 STANDARD 18 Environmental Effects and Management 36 STANDARD 19 Product Stewardship, Conservation and Waste Management 37 STANDARD 20 Audits, Assessment and Review 38 7. Definitions 39 8. Other Relevant Policies and Procedures 42 9. Reference Material 43 HSE Management System September 2011 5
1. PURPOSE AND APPLICATION Origin s Health, Safety and Environment (HSE) Policy commitments are communicated and implemented through the HSE Management System. The HSE Management System and Standards apply to all HSE-related matters arising out of all Activities and operations controlled by Origin and its related companies (together the company) and the impact of those Activities and operations on Employees, Contractors, the Environment and the communities in which the company operates. All of Origin s businesses are required to provide appropriate information and to take appropriate actions as required by the HSE Management System to ensure compliance with the criteria established in this document. The HSE Management System incorporates all HSE requirements in the company. The HSE Management System is designed to provide Origin with a consistent approach to HSE management and to allow for the integration of HSE management processes and responsibilities with other business requirements. Individual businesses and sites establish the necessary HSE management plans that describe how HSE risks are managed. Businesses and Sites have the discretion to establish specific procedures where company-wide HSE directives do not cover issues specific to the Business. Where the company does not have operational responsibility but has an equity stake or where significant Origin assets are involved, the HSE Management System, which includes the HSE Management System Standards, provide the company benchmark for due diligence purposes. We conduct ourselves and our business with due care and in accordance with relevant laws and regulations. We have an overriding duty to ensure the health and safety of our Employees, and to minimise the health, safety and environmental impacts on our customers and the communities in which we operate. 6 September 2011 HSE Management System
The HSE Management System is premised on the beliefs that effective management of health, safety and environment is based on a systematic approach with appropriate governance structures set in place and that each of us has clearly defined and unambiguous accountabilities that must be met to achieve that objective. Origin s HSE Management System is based on the continual improvement methodology of Commit-Plan-Do-Check and Review. The elements of the continual improvement loop are executed through a set of standards which interpret, support and provide further details to the requirements of the HSE Policy. Commit Review The Continual Improvement Cycle Plan Check Do HSE Management System September 2011 7
2. GOVERNANCE Governance is provided by the Board, the HSE Committee of the Board and the Operational Risk Committee. 2.1 Origin Board The Board is responsible for approving the Health, Safety and Environment Policy and: overseeing the company s commitment to its principles and values as they relate to the environment and the health and safety of Employees, Contractors, customers and the Community ensuring appropriate risk management systems are established and reports on performance are regularly reviewed reviewing the effectiveness of the company s governance compliance systems and corporate governance principles ensuring that the reputation of the company is protected and enhanced 2.2 HSE Committee of the Board The role of the HSE Committee of the Board (HSE Committee) is to advise and support the Board in meeting its responsibilities in relation to HSE matters arising out of the activities and operations of Origin and its related companies (together, the company). The HSE Committee is part of the Board, exercises its authority and is accountable to the Board for its performance. The HSE Committee makes recommendations to the Board to enable it to demonstrate its commitment and discharge its responsibilities in relation to HSE matters, having regard to the law and the highest standards of governance by: periodically reviewing and recommending to the Board an HSE Policy that clearly states the company s commitment to manage HSE related matters effectively periodically reviewing the company s annual and long term HSE performance objectives and targets reviewing major HSE risks and seeking assurance that measures to manage these risks and control their impacts are in place and effective seeking assurance of the company s compliance with HSE legal and regulatory requirements monitoring the company s HSE performance against its stated targets, including the implementation of an HSE Management System designed to verify that the commitments made in the Policy are being met and that HSE-related risks are being assessed, eliminated, avoided or controlled reviewing significant HSE incidents and HSE Management System failures, and monitoring the actions and measures to minimise the risk of recurrence seeking assurance regarding the adequacy and effectiveness of the company s HSE Policy and HSE Management System, including its functional leadership and structures 8 September 2011 HSE Management System
2.3 Operational Risk Committee (ORC) Operational Risk arises from the company s physical operations or interaction with customers or communities and has possible outcomes that could have a material adverse impact on people, the Environment or the company s financial performance, assets or reputation. The Operational Risk Committee (ORC) comprises members of the Executive Management Team, Corporate Managers and Managers of the Operating business. Its role is to support management and the Board in fulfilling their responsibilities under the company s Risk Management Policy to identify and control Operational Risks. In carrying out this role, the ORC will: review systems that are in place to identify and manage risk effectively review and prioritise risks that are identified and determine which of those risks should be monitored and reviewed corporately review Operational Risk related performance measures, incident reports and audit reports make recommendations to management on improvements to current operational management systems and the addition of new systems establish performance measures and targets for key Operational Risk management systems review the appropriateness of insurance policies to mitigate the company s financial exposure to Operational Risk review relevant external issues, trends and opinions HSE Management System September 2011 9
3. ACCOUNTABILITIES AND RESPONSIBILITIES All company Personnel have the authority to place HSE considerations above other priorities. This extends to the authority of not doing something, unless it can be done safely, without posing a risk to themselves, others or the Environment. All company Personnel have a duty to carry out their work in accordance with the Origin HSE Management System to effectively manage HSE risks. At every level of the organisation our line managers are responsible for HSE, with the ultimate responsibility resting with the general managers and senior management teams. 3.1 Managing Director The Managing Director is accountable for: the effective implementation of the HSE Policy and HSE Management System to meet commitments to stakeholders setting targets for HSE performance and improvement reviewing HSE performance and HSE Management System implementation to drive continual improvement implementation of leadership requirements specified in the HSE Management Standards 3.2 Executive Director and Executive General Managers The Executive Director and Executive General Managers are responsible for: setting expectations and providing resources for successful implementation of the Policy and HSE Management System within their business units providing clear definition of all Sites and/or Activities within their Business Units where this system applies, including transient sites, where Employees or Contractors undertake work or where the company owns plant, property or equipment reviewing the HSE performance of their businesses to ensure they meet company objectives and expectations implementation of leadership requirements specified in the HSE Management Standards 10 September 2011 HSE Management System
3.3 General Managers General Managers are responsible for: the development and implementation of adequate and compliant HSE management plans covering all Sites and Activities that can affect the HSE risk or performance in their area of control all Sites and Activities within their control submitting information on the status and performance of their Sites and Activities as required under Origin Directives and supporting materials the delegation of accountability to a responsible manager for the HSE performance of Sites or Activities the capability of all supervisors and managers appointed responsible for sites and activities to fulfil their requisite accountabilities involvement of all company employees and HSE Committees in the relevant HSE Plans for Sites and Activities within their Business Units assessing the existence and effectiveness of HSE plans through appropriate audits and reviews effective review and corrective actions in response to lessons learnt, incidents, defects, hazards, inadequacies of procedures and suggested improvements that are escalated from Sites and Activities within their area of responsibility implementation of leadership requirements specified in the HSE Management Standards HSE Management System September 2011 11
3.4 Managers and Supervisors Managers and Supervisors nominated accountable for Sites and Activities are responsible for: adequate HSE management and action plans (including HSE goals, objectives and targets) existing for every Site or Activity for which they are responsible Employees and HSE committees being appropriately involved in the development of HSE management plans and aware of how these plans affect their work all individuals, for whom they are responsible, being adequately skilled for tasks they are expected to perform and work processes used being fit for purpose the use of company-wide procedures in the Site s HSE management plans. The development of Site specific procedures for tasks which are not covered by company-wide procedures the review of, and development of, corrective actions in response to lessons learnt, incidents, defects, hazards, inadequacies of procedures and suggested improvements reported within their area of responsibility providing appropriate resources for compliance with HSE laws and management of HSE risks in accordance with their delegated authorities the escalation of issues to the next level of management when the issue impacts other areas implementation of leadership requirements specified in the HSE Management Standards 3.5 Chief Risk Officer The Chief Risk Officer is responsible for: providing the governance systems, work processes and tools necessary to support the efficient and effective monitoring, analysis and reporting of HSE performance maintaining systems for tracking implementation of risk-based policies and systems, including the HSE Policy and HSE Management System requirements relative to HSE plans and stated responsibilities managing audit and assurance programs to determine the Businesses compliance with HSE legal requirements and internal HSE requirements, including the HSE Management Standards governance reporting to the Managing Director, the Operational Risk Committee and the Board on matters including HSE performance, HSE Management System performance and the HSE risk position of the company 12 September 2011 HSE Management System
3.6 Group Manager HSE The Group Manager HSE is responsible for: developing HSE strategy consistent with HSE Policy and including Origin s goals, objectives and targets developing and improving the HSE Management System to meet the needs of the company and the expectations of its stakeholders communicating and coordinating the implementation of the HSE Policy and HSE Management System in an effective and efficient manner providing access to and advice regarding HSE laws, regulatory requirements and applicable standards that the company and its operations must meet across the various jurisdictions in which it operates developing and issuing HSE Directives and Toolkits where there are common HSE issues across the company defining general HSE responsibilities, accountabilities and competency requirements for Managers and supervisors responsible for Sites and Activities providing guidance on the development of HSE management plans and action plans coordinating the sharing of tools and methods to maximise efficiency. This includes ensuring appropriate training is available where the competencies addressed by the training are common across the organisation providing leadership and advice on HSE practices, including advice on companywide initiatives such as minimum personal protective equipment (PPE) requirements and new practices which may assist in the reduction of incident recurrence and injury severity 3.7 HSE Managers HSE Managers for the Business Units are responsible for: providing technical advice on the implementation of the HSE Management System reporting incidents and other HSE reporting requirements within their Business Unit quality control of incident data input to company databases coordinating HSE related training needs for their Business Unit coordination and close out of all actions deriving from HSE incident investigations communicating HSE alerts of interest to Group HSE for wider communication contributing to the development of company-wide HSE documents HSE Management System September 2011 13
3.8 Workplace HSE Representatives Workplace HSE Representatives (HSE committees) are responsible for: highlighting Employee concerns about workplace hazards, unsafe practices and HSE performance formally escalating HSE issues to management 3.9 Employees and Contractors Each Employee of and Contractor to Origin is responsible for: the HSE implications of their own actions and each has a duty to follow instructions and training and to carry out their work in a manner which does not present a risk to themselves, others or the Environment reporting all incidents, defects, hazards and inadequacies of procedures so that appropriate review and corrective action can be taken suggesting improvements and being active in the general improvement of all systems and methods of work to ensure Origin s operations are carried out in a personally and environmentally safe, reliable and cost effective way All Employees and Contractors have the authority to place HSE considerations above other priorities. This authority empowers Personnel to not undertake a task, unless it can be done safely and without posing a risk to themselves, others or the Environment. 14 September 2011 HSE Management System
4. ORIGIN HSE MANAGEMENT SYSTEM Origin s HSE Management System is hierarchical. Mandatory requirements are established by the HSE Policy, HSE Management Standards and directives. Requirements at any level must meet and support the requirements at higher levels. The HSE Policy, HSE Management Standards and directives are mandatory and apply to all company controlled sites and activities. 4.1 HSE Policy and HSE Management Standards There is a single HSE Policy, issued by Group HSE, approved by the Board and signed by the Managing Director. It establishes a framework for common HSE practices and expectations across all levels of the company. Approved by the Operational Risk Committee, the HSE Management Standards - interpret, support and detail the requirements of the company s HSE Policy and form the basis for the development and application of HSE plans at all levels in the company. 4.2 Directives and Toolkits HSE Directives mandate the minimum requirements, the responsibilities and the business rules that are needed to implement the HSE Policy and HSE Management Standards. Directives may refer to other supporting materials or Toolkits that include documents such as procedures, guidelines, checklists and forms. Key HSE documents including the HSE Policy, HSEMS, Directives and Toolkits are available on Source. HSE Management System September 2011 15
4.3 HSE Plans and Procedures All company controlled Sites and Activities must be covered by a relevant HSE Plan that describes the management arrangements (HSE management plan) and actions (HSE action plan) required to implement the HSEMS at each Site and Activity. HSE management plans and HSE action plans detail What, Where, How, When and by Whom HSE matters are planned, allocated to responsible owners, implemented, measured and reviewed. Every work place is required to have a relevant HSE management plan in place for controlling assessed risks and have processes in place for assessing new risks and addressing corporate and external reporting requirements, close out of audit findings, licence conditions, audit and inspection schedules, training requirements etc. Appropriate work methods are then developed. These requirements are formalised in Business Unit or Site based HSE management plans that define the work to be done and the way that work should be managed. These plans need to include, but are not limited to coverage of the following issues: Risk management Operational safety Environmental management Waste management Legal compliance Competence based training All requirements can be included in a single HSE plan or be separated by topic. Business Unit HSE procedures Apply within the Business Unit where they are issued and are intended to complement the mandatory Origin directives for those Activities which are exclusive to the Business Unit. Site operational HSE procedures Apply within Sites and operations where they are issued to cover Activities controlled by the relevant Business Unit and are intended to support the mandatory Origin directives for issues and tasks specific to that Site. 16 September 2011 HSE Management System
5. ORIGIN HSE MANAGEMENT SYSTEM ELEMENTS Purpose, Principles, Values and Commitments HSE Policy HSE Management Standards (What) Company-wide Directives and Toolkits (What and How) Business Unit HSE Plans and Business Specific Procedures (What, Where, When, How & Whom) Site Operational HSE Procedures (Interperting the company-wide requirements at the site level) Company-wide HSE documents Business HSE documents Health Safety & Environment Management System HSE Management System September 2011 17
6. HSE MANAGEMENT STANDARDS The HSE Management standards are aligned with the requirements of company HSE Policy and recognised international and national standards including ISO 14001, OHSAS 18001, ISO 31000 and AS 4801 and support the company in its efforts to comply with legal obligations regarding HSE. The objectives of the standards are to: set and formalise expectations for the progressive development and implementation of more specific requirements within Origin Business Units provide auditable criteria against which the HSE Management System can be measured provide a basis from which to drive continual improvement The HSE Management Standards mandate what must be achieved rather than how to achieve it. Therefore Business Units have the flexibility to meet the requirements of the standards in a way which best suits their own business while maintaining consistency of approach across the company. The system also provides mechanisms for assurance of diligence, so that in the event of a failure, it can be demonstrated that all reasonable and foreseeable steps have been taken to avoid the failure. The HSE Management Standards outline requirements in the areas of HSE and Community with the aim to: Health and Safety - Protect, promote and improve the health and wellbeing of Origin s employees - Minimise and manage occupational exposures to all personnel - Minimise adverse impacts of our operations to host communities - Provide a work environment where people are able to work safely and understand their rights and obligations towards a safe workplace - Promote a rewarding workplace for Employees by encouraging personal development, recognising good performance, valuing teamwork and fostering equality of opportunity Environment and Community - Promote the reduction and prevention of pollution, efficient use of resources and energy and biodiversity protection - Promote a culture of benefiting and respecting the rights and interest of the Communities in which we operate, consideration of the environmental and social impact of the resources, products and services we use or provide to others and caring about our impact on customers, colleagues, the Community, Environment and shareholders 18 September 2011 HSE Management System
Standard 1 LEADERSHIP AND COMMITMENT Intent The Board and Executive Management establish the HSE Policy, set expectations and provide resources for successful implementation of the HSE Policy and HSE Management System. Directors, managers, supervisors and Employees and Contractors at all levels demonstrate leadership and commitment to HSE. Performance Requirements 1.1 Origin maintains a HSE Policy that reflects the nature, scale and potential HSE impacts of the company s Activities, products and services. 1.2 The HSE Policy is reviewed every two years and approved by the Origin Board and signed by the Managing Director. 1.3 The Origin Board of Directors seeks assurance of conformance with the HSE Policy and systems and regularly reviews HSE performance and risks. 1.4 Origin Business Units and Sites define and document the scope of their HSE management plans and procedures in conformance with Origin s HSE Management Standards. 1.5 Origin Business Units and Sites integrate the requirements of the HSEMS (including these HSE Management Standards) into their business and site management systems and operating procedures. 1.6 Systems are in place to recognise, reinforce and reward HSE innovation, initiatives, desired behaviours and outcomes. 1.7 The company and its Contractors have systems in place to ensure Employees and Contractors are aware of expected HSE behaviours and have a clear understanding of the consequences of inappropriate conduct. 1.8 Managers demonstrate visible leadership and proactive behaviours by personal example, and reinforce HSE excellence by communicating HSE issues, setting HSE goals, objectives and targets, promoting HSE improvement initiatives, participating in audits and by conducting frequent site inspections, which include HSE reviews and behavioural observations. 1.9 All Employees demonstrate by their day-to-day actions a visible commitment to HSE. 1.10 Managers promote the sharing of HSE lessons learned inside and outside their Business Unit. HSE Management System September 2011 19
Standard 2 ORGANISATION, ACCOUNTABILITY, RESPONSIBILITY AND AUTHORITY Intent For directors, managers, supervisors and Employees and Contractors at all levels, their accountabilities, roles, responsibilities and authority relating to HSE are clearly defined, documented, communicated and understood throughout Origin. Performance Requirements 2.1 HSE roles, responsibilities, authorities and accountabilities, including those arising from the HSE Policy and HSE Management Standards and personal HSE goals, objectives and targets, are documented, known, exercised and adhered to. The allocation of responsibilities and accountabilities and the delegation of authorities are documented and communicated. 2.2 The Managing Director of Origin is ultimately responsible for the HSE performance of the business, including the effective implementation of the HSE Policy and supporting HSE Standards. 2.3 Managers provide sufficient resources (i.e. human, financial and infrastructure) to maintain legal compliance and to support effective HSE management including the implementation, maintenance, monitoring and reporting of the HSE Management System and the provision of competent HSE advice. 2.4 At every level of the organisation, line managers are responsible for HSE. 2.5 Personnel with appointed or elected HSE responsibilities provide Employees and Contractors with HSE advice, assistance and expertise relevant to their position as required. 2.6 All Personnel are responsible for the HSE implications of their own actions and have a duty to carry out their work in a manner which does not present a risk to themselves, others and/or the Environment. Individual performance will be monitored and reviewed against agreed responsibilities and accountabilities. 2.7 Systems are in place to clearly communicate to Personnel that they have both the right and the responsibility to stop work or refuse to work in situations that may cause harm to health, safety or Environment, and to immediately bring these situations to the attention of those at immediate risk and to company management. 20 September 2011 HSE Management System
Standard 3 PLANNING, OBJECTIVES AND TARGETS Intent A systematic risk based approach to the management of HSE is in place as an integral part of business planning, with HSE goals, objectives and targets established and measured. A philosophy of continual improvement is applied to HSE. Performance Requirements 3.1 Business planning activities at all levels of Origin include HSE considerations. 3.2 On an annual basis Origin sets company-wide HSE goals, objectives and targets consistent with the HSE Policy and HSE Management System to drive performance improvement. These goals, objectives and targets are linked to leading and lagging indicators that are measurable, documented, communicated and reviewed. 3.3 Business Units set annual targets that support the achievement of Origin companywide targets and take into account significant risks, legal and other compliance requirements and the interests of relevant stakeholders. 3.4 Managers, team and individual KPIs are set that support the achievement of company and Business Unit targets. These KPIs are assessed as part of reward schemes and individual performance evaluation. 3.5 HSE action plans are established which include clearly designated responsibilities, time-frames, resources and actions to achieve goals, objectives and targets. HSE risks are considered in the development of goals, objectives and targets in HSE action plans. 3.6 Systems are established to periodically monitor and report the implementation of these goals, objectives and targets including the tracking of KPIs. 3.7 Where conflicts exist between HSE goals, objectives and targets and other business goals, objectives and targets, resolution is consistent with the requirements of these HSE Standards. HSE Management System September 2011 21
Standard 4 LEGAL REQUIREMENTS, DOCUMENT CONTROL AND INFORMATION MANAGEMENT Intent Relevant legal and regulatory requirements and voluntary commitments are identified, documented, made accessible, understood and complied with wherever Origin operates. Effective HSE document control systems are in place to ensure clarity of company expectations and to facilitate efficient and accurate information management. Performance Requirements 4.1 HSE-related acts and regulations are maintained and available. 4.2 Legislative and regulatory requirements (including licences, permits and approval conditions) and voluntary commitments applicable to specific Origin operations are identified and documented in a Site register. 4.3 Regulatory registers are reviewed and kept up-to-date and all changes are communicated to all relevant personnel. 4.4 Where Origin or its Business Units undertake voluntary public commitments in relation to HSE, these commitments are to be regarded and implemented with the same diligence as regulatory requirements. 4.5 Wherever possible, legislative and other external requirements are incorporated into the relevant operational procedures to ensure consistent, ongoing compliance with these requirements. 4.6 Compliance with legal and other requirements is demonstrated, evaluated and reported. 4.7 Where local legal requirements diverge from these Standards, Activities comply with the more stringent of local legal requirements and these Standards. 4.8 In countries where local legislation does not require an adequate level of HSE performance, Activities are conducted in a manner that is consistent with the requirements of these Standards, and relevant international standards, taking into account social and cultural sensitivities. 4.9 Systems are in place to identify which documents are to be controlled and to ensure that these documents are controlled with current versions readily available. 4.10 Systems are in place to ensure that HSE records are established, maintained, accurate, legible and identifiable and also to manage the archiving and disposal of HSE records. 4.11 HSE records have established retention times, consistent with legal requirements and knowledge preservation, and are assigned to responsible custodians. 4.12 Employee health, medical and occupational exposure records are maintained and retained as necessary, with appropriate confidentiality in place. 22 September 2011 HSE Management System
Standard 5 PERSONNEL, COMPETENCE, TRAINING AND BEHAVIOURS Intent Employees competence and appropriate behaviours are critical for the safe control of operations and general company success. Employees are carefully selected, trained and supported. Competence and behaviours are regularly assessed and monitored. Contractors are to provide competent workers and regularly assess and monitor their competence and behaviours. Performance Requirements 5.1 Recruitment, selection and placement processes ensure that personnel are competent for their assigned tasks. 5.2 The company and its Contractors have systems in place to provide inductions for Employees, Contractors and Visitors new to the Site or Activity and HSE training and awareness sessions for relevant personnel. Inductions will cover relevant HSE hazards, Risk Assessments, controls, behaviours, company objectives, policy, systems and procedures. Compliance with HSE requirements covered by the induction will constitute a condition of entering or remaining on company property. 5.3 Personnel have the required skills and training to competently perform their tasks in a healthy, safe and environmentally sound manner. 5.4 The company and its Contractors have systems in place to ensure: qualifications and competency requirements for positions are documented and periodically reviewed training needs are identified in consultation with employees, training schedules and programs are developed and include ongoing periodic refresher training, training is provided by people with appropriate knowledge, skills and experience competency assessments are undertaken, and training and assessment records are maintained 5.5 Each Safety Critical Role or task and the personnel who perform these tasks are assessed for necessary competencies and skills, utilising formal competency-based assessment. 5.6 The company and its Contractors shall train and assess their respective workers in the control and elimination of at-risk behaviours, including the consequences of departure from specified company procedures. 5.7 Systems that reinforce positive HSE behaviours are in place and draw attention to at-risk behaviours. HSE Management System September 2011 23
Standard 6 COMMUNICATION, CONSULTATION AND COMMUNITY INVOLVEMENT Intent Effective, transparent and open communication and consultation with legitimate stakeholders is valued and undertaken across the company. Performance Requirements 6.1 Open and proactive communications are established and maintained with Employees, Contractors, regulatory agencies and communities regarding the HSE Policy, HSEMS and Standards. 6.2 Internal communication and consultation processes are in place to deal with HSE matters. These processes include HSE Committee meetings, toolbox meetings and other site HSE meetings. Meetings include relevant HSE issues. 6.3 Systems are in place to identify stakeholders and to receive, analyse and respond to community concerns and complaints regarding the company s Activities, products and services. 6.4 Mechanisms are in place to resolve conflicts where they arise, through consultation and participation with stakeholders and their intermediaries. 6.5 Host communities and their traditional heritage and values which could potentially be affected by the company s Activities, are identified. Communities are engaged and strategies are developed to eliminate or minimise negative impacts. 6.6 Where community health hazards are identified, these are assessed, managed and communicated to potentially impacted communities and other relevant stakeholders, for example public health and other authorities. 6.7 Arrangements are established for communication with, and the provision of relevant HSE related information to, governments, authorities and other organisations and local communities. 6.8 Systems are in place to regularly assess the general community s expectations of Origin as a corporate citizen. Processes are established to respond to external feedback and engage with the general community. 6.9 Systems are in place to communicate internally and externally the company s HSE goals and publicly report HSE performance. Identified significant HSE risks and impacts are communicated to relevant stakeholders. 24 September 2011 HSE Management System
Standard 7 HAZARD AND RISK MANAGEMENT Intent HSE hazards and risks associated with the company s activities are identified, assessed and managed to prevent or reduce the likelihood and consequence of incidents. Performance Requirements 7.1 Origin has established a Risk Management Policy. As required under that Policy, HSE risk management is applied to all Activities that Origin controls or significantly influences. 7.2 Risk is managed by identifying hazards, assessing consequences and probabilities, evaluating risk and implementing preventive and mitigation measures. 7.3 Risk Assessments are conducted by competent personnel with the relevant knowledge and experience. 7.4 Potential health, safety and environmental hazards are identified and recorded for existing operations, products, business developments, acquisitions, modifications, new projects, closures and divestments. This process takes into account risks to personnel, facilities, the public, customers and the Environment. 7.5 Business Units establish and maintain a Risk register containing identified hazards and risks. Risk register contents include the risk title and classification, risk causes, consequences, exposure, probability, likelihood, plus existing controls and monitoring or control effectiveness as well as links to HSE action plans and the setting of goals, objectives and targets. 7.6 Business Units must identify all Critical Activities/tasks that have the potential to result in serious injury to people, serious environmental impact or a Major Accident Event. Critical Controls designed to mitigate the risks of serious injury to people, serious environmental impact or a Major Accident Event include Critical Systems, Critical Equipment and Critical Procedures and must be recorded in the Risk Register. 7.7 Origin maintains an enterprise-wide Risk Register containing those risks escalated from the Business Units and Corporate Groups, plus any additional risks identified at the company and/or Board level. 7.8 Risk registers are reviewed at least annually, and following a significant change or Significant Incident to reflect learnings and changes. 7.9 Where risk cannot be eliminated, control measures are selected and prioritised using the hierarchy of controls and implemented to effectively manage identified risks. 7.10 Where risks identified exceed specified threshold and immediate mitigation is not possible, the level of risk being tolerated and managed by the Business Unit must be escalated in accordance with Origin s Risk Management Directive. HSE Management System September 2011 25
Standard 8 INCIDENT MANAGEMENT Intent HSE incidents, including near misses, are reported, investigated, and analysed to ensure that preventive actions are taken and learnings are shared throughout the organisation. Performance Requirements 8.1 Systems are in place for timely reporting, investigation and appropriate communication of all HSE incidents to meet Origin s incident management requirements. 8.2 Incidents, near misses and hazards are reported and used as valuable opportunities for learning. 8.3 Systems are in place for full compliance with applicable legislative requirements related to incidents, including reporting to authorities, keeping of records, investigations and other actions as required in each jurisdiction. 8.4 Incident investigations, including identification of root causes and preventative actions, are conducted. The level of the investigation is appropriate to the actual or potential consequence of the incident. 8.5 Significant Incidents are immediately notified to General Counsel who will provide such initial legal advice to the Business Unit General Manager as may be required (including advice on the steps to be followed) and commission (where needed) an investigation by a multifunction team led by a competent independent investigator, who will report to General Counsel to enable appropriate legal advice to be given to the company. 8.6 In the event of a Significant Incident, systems are in place to prevent resumption of work until the risk is assessed, and actions have been taken to reduce the risk of recurrence, to the satisfaction of regulators/relevant authorities (if required). Authorisation to resume work is then given by the appropriate level. 8.7 Where possible, information gathered from reported incidents and incident investigations is analysed to identify trends and is used in the improvement of systems and procedures. 8.8 Systems are in place to follow up and close out all identified corrective actions within acceptable timeframes. 26 September 2011 HSE Management System
Standard 9 PERFORMANCE MEASUREMENT AND REPORTING Intent Health, Safety, and Environmental performance data is collected, analysed and reported to monitor and evaluate ongoing HSE performance and drive continual improvement. Performance Requirements 9.1 Processes are in place to ensure HSE performance is regularly measured, monitored, recorded and analysed with results reported to internal and external stakeholders as appropriate. 9.2 The reported data is collated and analysed, as appropriate, and reported to Personnel who have the responsibility to take action on the basis of this information. Reporting of consolidated data including HSE key performance indicators, shall be carried out at Site level, Business Unit level and for the whole of Origin, as the basis for decision making. 9.3 Group HSE provide HSE reporting requirements and processes and maintain a database containing what is required for both internal performance evaluation and external reports. 9.4 Business Units measure and report HSE performance data on a monthly basis or more frequently if appropriate (e.g. for Significant Incidents) as per Origin s requirements. 9.5 Prevalence and incidence of work-related injury and illness is recorded, assessed and reviewed using data available from all sources including medical surveillance programmes and incident related medical treatment. 9.6 Group HSE periodically aggregate and analyse HSE performance data for all Origin businesses and provide feedback and advice to the businesses on initiatives to drive improvement in HSE performance. 9.7 Systems are established to ensure the appropriate reporting of HSE performance to relevant authorities and/or other stakeholders, as required by legislation or company voluntary commitments. 9.8 Relevant HSE systems and performance information is routinely communicated by Origin management to relevant Personnel. HSE Management System September 2011 27
Standard 10 OPERATIONAL CONTROL Intent All works at Sites and Activities that have the potential to cause harm to the health and safety of people, or the Environment, or to cause damage to equipment, are carried out in accordance with plans and documented procedures, so as to ensure safe work practices. Performance Requirements 10.1 Sites and Activities have operational HSE management plans (including descriptions of operations), systems and procedures established, implemented and maintained where relevant HSE risks have been identified. 10.2 Plans and procedures address the required method for carrying out the company s work Activities and managing other operational aspects and include specific responsibilities. As a minimum, procedures are required which cover induction, locking, tagging and isolation procedures, and also communication at shift handover. 10.3 Plant and equipment drawings, manuals, design data and operating limits are documented, understood and available. 10.4 Key operating risks, including Safety Critical Activities are measured, monitored, analysed and reviewed. 10.5 Risks introduced by high Activity levels, by Activities which are unusual or infrequent, or by the interaction of Activities, are assessed and managed. 10.6 Systems are in place to manage and formally document the activation, maintenance, isolation and deactivation of safety Critical Equipment and other Critical Controls. 10.7 A permit to work process is in place which incorporates checks and authorisations consistent with mechanical and operational risks. As a minimum, the permit to work system covers hot work, confined space and excavation permits. 10.8 Applicable laws, regulations, permits and other regulatory requirements for operational Activities are met, and the resulting operating requirements are documented and communicated to those affected. Compliance with these requirements is periodically verified. 28 September 2011 HSE Management System
Standard 11 MANAGEMENT OF CHANGE Intent All temporary and permanent changes to the organisation, Personnel, systems, procedures, equipment, products and materials are identified and managed to ensure HSE risks arising from these changes remain at an acceptable level. Performance Requirements 11.1 Formal processes and documented procedures are in place for the effective assessment and management of risks associated with temporary and permanent changes. Procedures include the recording and tracking of any change which has the potential to affect the health and safety of people or the Environment. 11.2 The Risk Assessment of a change is appropriate to the nature of the change and the exposure associated with it. 11.3 The process for managing changes addresses the authority for approval of changes, compliance with all relevant regulations, applicable standards and permits, licence or authority requirements, documentation (including reasons for the changes), deadlines and training requirements. 11.4 The risks and impacts arising from changes are communicated to relevant stakeholders, monitored and managed. 11.5 Systems are in place to ensure change management actions have been completed, their intended outcomes validated, relevant systems and documentation, (including drawings) updated and any unintended risks identified and managed. 11.6 The original scope and duration for temporary changes do not exceed original authorisation without formal review and approval. HSE Management System September 2011 29
Standard 12 FACILITIES DESIGN, CONSTRUCTION, COMMISSIONING AND DECOMMISSIONING Intent Assessment and management of HSE risks is an integral part of project design, construction and commissioning to enable sound HSE performance throughout the construction and operational life of the facility. Decommissioning plans are established for new projects and existing facilities. Performance Requirements 12.1 The planning, design and selection of new Sites, plant, equipment and processes takes into account known and projected HSE aspects and risks, and considers provisions for maintenance, modification, decommissioning, disposal and closure. 12.2 Project HSE plans and procedures establishing technical integrity, HSE specifications and quality assurance requirements are established, documented, understood and their implementation is verified. 12.3 Technical standards for design, construction and commissioning (including any modifications) are compliant with legislation, relevant industry codes and standards. Sound engineering practices and risk management principles (e.g. Quantitative Risk Assessments, HAZOPS and HSE reviews) are utilised. 12.4 Facilities are designed and constructed using technology which balances HSE and commercial risks with financial benefits. A process is established to evaluate and demonstrate that technical risks, biodiversity, social and environmental impacts as well as the minimisation of emissions and discharges are considered. 12.5 Design reviews for constructability, operability and maintainability for maintenance of plant, equipment and systems ensure HSE risks and related considerations are effectively identified, addressed and documented. 12.6 A commissioning plan is documented and approved so that it incorporates HSE risk management and defines responsibilities and competencies. The plan ensures that the facility, plant and equipment conform to required standards for start-up and operability. 12.7 Decommissioning, remediation and restoration plans are established, costed and reviewed regularly using risk-based studies for end of life equipment and/or facilities. 12.8 Operational, maintenance and HSE expertise are integrated early in the project/design stage. Experiences from previous projects and current operations are applied. 12.9 Pre and post-start up reviews are conducted and documented to confirm that: construction is in accordance with specifications operations integrity measures are in place emergency, operational and maintenance procedures are in place and are adequate risk management recommendations have been addressed and required actions taken training of Personnel has been accomplished and documented regulatory and licence and/or other permit requirements are met. 30 September 2011 HSE Management System
Standard 13 CONTRACTORS, SUPPLIERS, PARTNERS AND VISITORS Intent Contractors, Suppliers and Partners are assessed for their capabilities and competencies to perform work on behalf of Origin, and to ensure their HSE performance is aligned with these Standards. Effective arrangements are in place to safeguard the health and safety of Visitors to Origin Sites. Performance Requirements 13.1 Processes are in place for the pre-qualification, selection and retention criteria for work performed by Contractors, Suppliers and others (third parties), along with a system for assuring their compliance with these criteria. These processes include Risk Assessments associated with the services provided. 13.2 Selection criteria include the Contractors and/or Suppliers commitment to HSE, their HSE Management Systems, requirements and specifications related to their equipment, materials, products, services and performance. 13.3 Contracts include specific HSE requirements that Contractors must comply with. It is a line management responsibility to assess competency on an ongoing basis. 13.4 Business Partners, Suppliers of goods and services, and customers are encouraged to establish and maintain systems consistent with these HSE Management Standards. 13.5 Suppliers and Contractors are required to provide information on the Risk Assessment performed and the identified hazards associated with their equipment, products and services, prior to their delivery or commencement of work whenever changes occur. 13.6 Suppliers and Contractors are required to provide information on the measures undertaken, or to be undertaken, to control the risks and hazards identified by them. 13.7 Interfaces between organisations providing and receiving services are effectively managed including the mechanism of dealing with interaction with other plant operators/contractors in the same vicinity, how they will be dealt with, the risks to be controlled and the responsibilities identified. 13.8 Third party HSE performance is monitored and assessed, feedback is provided and deficiencies are highlighted for correction. 13.9 When third parties are performing services on behalf of Origin at a defined Origin controlled Site, their HSE performance is considered within Origin s overall HSE performance. 13.10 Contract Employees will be integrated into Origin s HSE Activities 13.11 Visitors to Origin s Sites receive HSE induction appropriate to the nature of their visit and the Site hazards they may be exposed to. Compliance with the HSE requirements included in the induction constitutes a condition of entering or remaining on Origin s property. HSE Management System September 2011 31