SECTION 1: IDENTIFICATION 1.1. Product Identifier Product Form: Mixture Product Name: ALLFLEET Universal Tractor Hydraulic Fluid J20C Product Grades: J20C, Universal Product #: 95243UTHF00 Synonyms: Hydraulic Fluid 1.2. Intended Use of the Product Hydraulic Fluid 1.3. Name, Address, and Telephone of the Responsible Party Company RelaDyne, LLC 9395 Kenwood Rd, Suite 104 Blue Ash, OH 45242 888-830-3156 www.reladyne.com 1.4. Emergency Telephone Number Emergency Number : INFOTRAC 800-535-5053 SECTION 2: HAZARDS IDENTIFICATION 2.1. Classification of the Substance or Mixture Classification (GHS-US) Not Classified Full text of H-phrases: see section 16 2.2. Label Elements GHS-US Labeling Hazard Pictograms (GHS-US) : None Required Signal Word (GHS-US) Hazard Statements (GHS-US) Precautionary Statements (GHS-US) : Not Hazardous : None Required : P273 - Avoid release to the environment. P501 - Dispose of contents/container in accordance with local, regional, national, and international regulations. 2.3. Other Hazards The mixture consists of substances capable of producing an aspiration hazard. Aspiration may result in chemical pneumonia (fluid in the lungs), severe lung damage, respiratory failure, and even death. 2.4. Unknown Acute Toxicity (GHS-US) 9.73 percent of the mixture consists of ingredient(s) of unknown acute toxicity. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS 3.1. Substances Not applicable 5/28/2015 ALLFLEET Universal Tractor Hydraulic Fluid J20C SDS# 028 Page 1 of 7
Name Product Identifier % (w/w) Classification (GHS-US) Petroleum distillates, solvent dewaxed (CAS No) 64742-65-0 75.75 95, Not Classified 64-85 heavy paraffinic, Distillates, petroleum, hydrotreated heavy paraffinic Phosphorodithioic acid, O,O-di-C1-14-alkyl esters, zinc salts (CAS No) 64742-54-7 0 11, 10-17 (CAS No) 68649-42-3 0.7-2.7 Not Classified Aquatic Chronic 3, H402 *The specific chemical identity and/or exact percentage of composition have been withheld as a trade secret within the meaning of the OSHA Hazard Communication Standard [29 CFR 1910.1200]. *More than one of the ranges of concentration prescribed by Controlled Products Regulations has been used where necessary, du e to varying composition. Full text of H-phrases: see section 16 SECTION 4: FIRST AID MEASURES 4.1. Description of First Aid Measures General: Never give anything by mouth to an unconscious person. If you feel unwell, seek medical advice (show the label if possible). Inhalation: Remove to fresh air and keep at rest in a position comfortable for breathing. Obtain medical attention if breathing difficulty persists. Skin Contact: Remove contaminated clothing. Drench affected area with water or soap and water for at least 15 minutes. Wash contaminated clothing before reuse. Obtain medical attention if irritation develops or persists. Eye Contact: Rinse cautiously with water for at least 15 minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Obtain medical attention. Ingestion: Do NOT induce vomiting. Rinse mouth. Immediately call a POISON CENTER or doctor/physician. 4.2. Most Important Symptoms and Effects Both Acute and Delayed General: No known significant effects or critical hazards. Inhalation: Overexposure may be irritating to the respiratory system. Skin Contact: Repeated or prolonged skin contact may cause irritation. Eye Contact: Direct contact with the eyes is likely irritating. Ingestion: Ingestion is likely to be harmful or have adverse effects. Chronic Symptoms: No known significant effects or critical hazards. 4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed If you feel unwell, seek medical advice (show the label where possible). SECTION 5: FIRE-FIGHTING MEASURES 5.1. Extinguishing Media Suitable Extinguishing Media: Use extinguishing media appropriate for surrounding fire. Unsuitable Extinguishing Media: Do not use a heavy water stream. Use of heavy stream of water may spread fire. 5.2. Special Hazards Arising From the Substance or Mixture Fire Hazard: Not flammable but will support combustion. Explosion Hazard: Product is not explosive. Reactivity: Hazardous reactions will not occur under normal conditions. 5.3. Advice for Firefighters Precautionary Measures Fire: Exercise caution when fighting any chemical fire. Under fire conditions, hazardous fumes will be present. Firefighting Instructions: Use water spray or fog for cooling exposed containers. Protection During Firefighting: Do not enter fire area without proper protective equipment, including respiratory protection. 5/28/2015 ALLFLEET Universal Tractor Hydraulic Fluid J20C SDS# 028 Page 2 of 7
Hazardous Combustion Products: Under fire conditions, may produce fumes, smoke, oxides of carbon and hydrocarbons. Other Information: Refer to Section 9 for flammability properties. Reference to Other Sections Refer to section 9 for flammability properties. SECTION 6: ACCIDENTAL RELEASE MEASURES 6.1. Personal Precautions, Protective Equipment and Emergency Procedures General Measures: Avoid all contact with skin, eyes, or clothing. Avoid breathing (vapor, mist, spray). 6.1.1. For Non-Emergency Personnel Protective Equipment: Use appropriate personal protection equipment (PPE). Emergency Procedures: Evacuate unnecessary personnel. 6.1.2. For Emergency Personnel Protective Equipment: Equip cleanup crew with proper protection. Emergency Procedures: Stop leak if safe to do so. Eliminate ignition sources. Ventilate area. 6.2. Environmental Precautions Prevent entry to sewers and public waters. Notify authorities if liquid enters sewers or public waters. 6.3. Methods and Material for Containment and Cleaning Up For Containment: Contain any spills with dikes or absorbents to prevent migration and entry into sewers or streams. Methods for Cleaning Up: Clean up spills immediately and dispose of waste safely. Spills should be contained with mechanical barriers. Transfer spilled material to a suitable container for disposal. Contact competent authorities after a spill. 6.4. Reference to Other Sections See Heading 8. Exposure controls and personal protection. For further information refer to section 13. SECTION 7: HANDLING AND STORAGE 7.1. Precautions for Safe Handling Additional Hazards When Processed: Any proposed use of this product in elevated-temperature processes should be thoroughly evaluated to assure that safe operating conditions are established and maintained. Practice good housekeeping - spillage can be slippery on smooth surface either wet or dry. Hygiene Measures: Handle in accordance with good industrial hygiene and safety procedures. Wash hands and other exposed areas with mild soap and water before eating, drinking or smoking and when leaving work. 7.2. Conditions for Safe Storage, Including Any Incompatibilities Technical Measures: Comply with applicable regulations. Storage Conditions: Store in a dry, cool and well-ventilated place. Keep container closed when not in use. Keep/Store away from direct sunlight, extremely high or low temperatures and incompatible materials. Incompatible Materials: Strong acids, strong bases, strong oxidizers. 7.3. Specific End Use(s) Hydraulic Fluid. SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1. Control Parameters For substances listed in section 3 that are not listed here, there are no established Exposure limits from the manufacturer, supplier, importer, or the appropriate advisory agency including: ACGIH (TLV), NIOSH (REL), OSHA (PEL), Canadian provincial governments, or the Mexican government. 8.2. Exposure Controls Appropriate Engineering Controls: Ensure adequate ventilation, especially in confined areas. Emergency eye wash fountains and safety showers should be available in the immediate vicinity of any potential exposure. Ensure all national/local regulations are observed. 5/28/2015 ALLFLEET Universal Tractor Hydraulic Fluid J20C SDS# 028 Page 3 of 7
Personal Protective Equipment: Protective goggles. Gloves. Materials for Protective Clothing: Chemically resistant materials and fabrics. Hand Protection: Wear chemically resistant protective gloves. Eye Protection: Chemical goggles or safety glasses. Skin and Body Protection: Wear suitable protective clothing. Respiratory Protection: Use a NIOSH-approved respirator or self-contained breathing apparatus whenever exposure may exceed established Occupational Exposure Limits. Environmental Exposure Controls: Do not allow the product to be released into the environment. Consumer Exposure Controls: Do not eat, drink or smoke during use. SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES 9.1. Information on Basic Physical and Chemical Properties Physical State : Liquid Appearance : Amber Odor : Slight Hydrocarbon Odor Threshold : Not available ph : Not available Evaporation Rate : Not available Melting Point : Not available Boiling Point : Not available Flash Point : 204C / 400C Auto-ignition Temperature : Not available Decomposition Temperature : Not available Flammability (solid, gas) : Not available Lower Flammable Limit : Not available Upper Flammable Limit : Not available Vapor Pressure : Not available Relative Vapor Density at 20 C : Not available Relative Density : Not available Specific Gravity : 0.85 Solubility : Negligible Partition Coefficient: N-Octanol/Water : Not available Viscosity : Not available Viscosity, Kinematic : Not available Explosive Properties : Product is not explosive Explosion Data Sensitivity to Mechanical Impact : Not expected to present an explosion hazard due to mechanical impact Explosion Data Sensitivity to Static Discharge : Not expected to present an explosion hazard due to static discharge SECTION 10: STABILITY AND REACTIVITY 10.1. Reactivity: Hazardous reactions will not occur under normal conditions. 10.2. Chemical Stability: Stable under recommended handling and storage conditions (see section 7). 5/28/2015 ALLFLEET Universal Tractor Hydraulic Fluid J20C SDS# 028 Page 4 of 7
10.3. Possibility of Hazardous Reactions: Hazardous polymerization will not occur. 10.4. Conditions to Avoid: Direct sunlight, extremely high or low temperatures, heat, hot surfaces, sparks, open flames, incompatible materials, and other ignition sources. 10.5. Incompatible Materials: Strong acids, strong bases, strong oxidizers. 10.6. Hazardous Decomposition Products: No decomposition expected under normal use and storage conditions. SECTION 11: TOXICOLOGICAL INFORMATION 11.1. Information on Toxicological Effects - Product Acute Toxicity: Not classified LD50 and LC50 Data: Not available Skin Corrosion/Irritation: Not classified Eye Damage/Irritation: Not classified Respiratory or Skin Sensitization: Not classified Germ Cell Mutagenicity: Not classified Teratogenicity: Not classified Carcinogenicity: Not classified Specific Target Organ Toxicity (Repeated Exposure): Not classified Reproductive Toxicity: Not classified Specific Target Organ Toxicity (Single Exposure): Not classified Aspiration Hazard: Not classified Symptoms/Injuries After Inhalation: Overexposure may be irritating to the respiratory system. Symptoms/Injuries After Skin Contact: Repeated or prolonged skin contact may cause irritation. Symptoms/Injuries After Eye Contact: Direct contact with the eyes is likely irritating. Symptoms/Injuries After Ingestion: Ingestion is likely to be harmful or have adverse gastrointestinal effects. Chronic Symptoms: Not Classified 11.2. Information on Toxicological Effects - Ingredient(s) LD50 and LC50 Data: Heavy paraffinic, Distillates, petroleum, hydrotreated heavy paraffinic (64742-54-7) LD50 Oral Rat > 2000 mg/kg LD50 Dermal Rabbit > 2 g/kg Petroleum distillates, solvent dewaxed (64742-65-0) LD50 Oral Rat > 5000 mg/kg LD50 Dermal Rabbit > 5 g/kg SECTION 12: ECOLOGICAL INFORMATION 12.1. Toxicity Ecology - General: Toxic to aquatic life. Phosphorodithioic acid, O,O-di-C1-14-alkyl esters, zinc salts (68649-42-3) LC50 Fish 1 1.0-5.0 mg/l (Exposure time: 96 h - Species: Pimephales promelas [static]) EC50 Daphnia 1 1-1.5 mg/l (Exposure time: 48 h - Species: Daphnia magna) LC 50 Fish 2 10.0-35.0 mg/l (Exposure time: 96 h - Species: Pimephales promelas [semi-static]) Petroleum distillates, solvent dewaxed (64742-65-0) EC50 Daphina 1 > 1000 mg/l (Exposure time: 48 h Species: Daphnia magna) LC50 Fish 1 > 5000 mg/l (Exposure time: 96 h - Species: Oncorhynchus mykiss) Distillates, petroleum, hydrotreated heavy paraffinic (64742-54-7) LC50 Fish 1 > 5000 mg/l (Exposure time: 96 h - Species: Oncorhynchus mykiss) EC50 Daphnia 1 > 1000 mg/l (Exposure time: 48 h - Species: Daphnia magna) 5/28/2015 ALLFLEET Universal Tractor Hydraulic Fluid J20C SDS# 028 Page 5 of 7
12.2. Persistence and Degradability Not available 12.3. Bioaccumulative Potential Not available 12.4. Mobility in Soil Not available 12.5. Other Adverse Effects Other Information: Avoid release to the environment. SECTION 13: DISPOSAL CONSIDERATIONS 13.1. Waste treatment methods Sewage Disposal Recommendations: Do not empty into drains; dispose of this material and its container in a safe way. Do not empty into drains. Do not dispose of waste into sewer. Waste Disposal Recommendations: Dispose of waste material in accordance with all local, regional, national, provincial, territorial and international regulations. SECTION 14: TRANSPORT INFORMATION 14.1. In Accordance with DOT Not regulated for transport 14.2. In Accordance with IMDG Not regulated for transport 14.3. In Accordance with IATA Not regulated for transport 14.4. In Accordance with TDG Not regulated for transport SECTION 15: REGULATORY INFORMATION 15.1. US Federal Regulations SARA Section 311/312 Hazard Classes 15.2. US State Regulations None noted 15.3. Canadian Regulations WHMIS Classification Not Classified Not Classified Phosphorodithioic acid, O,O-di-C1-14-alkyl esters, zinc salts (68649-42-3) Listed on the Canadian DSL (Domestic Substances List) WHMIS Classification Class D Division 2 Subdivision B - Toxic material causing other toxic effects Petroleum distillates, solvent dewaxed (64742-65-0) Listed on the Canadian DSL (Domestic Substances List) WHMIS Classification Uncontrolled product according to WHMIS classification criteria Distillates, petroleum, hydrotreated heavy paraffinic (64742-54-7) Listed on the Canadian DSL (Domestic Substances List) WHMIS Classification Uncontrolled product according to WHMIS classification criteria This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations (CPR) and the SDS contains all of the information required by CPR. 5/28/2015 ALLFLEET Universal Tractor Hydraulic Fluid J20C SDS# 028 Page 6 of 7
SECTION 16: OTHER INFORMATION, INCLUDING DATE OF PREPARATION OR LAST REVISION Revision Date : 05/16/2015 Other Information GHS Full Text Phrases: P273 P501 : This document has been prepared in accordance with the SDS requirements of the OSHA Hazard Communication Standard 29 CFR 1910.1200. Avoid release into the environment Dispose of contents/container in accordance with local, regional, national, and international regulations. Party Responsible for the Preparation of This Document RelaDyne, LLC 9395 Kenwood Rd, Suite 104 Blue Ash, OH 45242 888-830-3156 www.reladyne.com This is prepared according to the Hazard Communication Standard (CFR29 1910.1200) HazCom 2012. The information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental requirements only. It should not therefore be construed as guaranteeing any specific property of the product. North America GHS US 2012 & WHMIS 2 5/28/2015 ALLFLEET Universal Tractor Hydraulic Fluid J20C SDS# 028 Page 7 of 7